n Heavy-duty, high efficiency compressor n Copper tubing with enhanced fin coils n External service gauge ports CABINET

Transcription

1 PHP10 Package Heat Pump 2-5 Ton 10 SEER REFRIGERANT SYSTEM n Heavy-duty, high efficiency compressor n opper tubing with enhanced fin coils n External service gauge ports ABINET n Low profile with compact footprint n Insulation to minimize heat loss n Powder paint for maximum durability n Easy service access n Wire grille to protect condenser coil n One piece no leak top design n Weather protected heavy-duty condenser fan motor n Aluminum fan for long life n Internal 1 filter rack BLOWER n Insulated compartment to reduce sound n Split ring design with quick plug-in wiring n Multispeed motor for wide airflow range n PS prelubricated motor for low maintenance and maximum efficiency n Dynamically balanced blower with resilient motor mounts for smooth and quiet operation ONTROLS n Trade available components n Solid state defrost control board n olor coded wiring for easy service INSTALLATION n Horizontal or down discharge n Factory wired for economizer connection ( Series 3 phase only) n Full perimeter base rail system for easy installation on roofcurb applications n Series 3 phase units set up for down discharge WARRANTY n 5 Years on all parts (2 years on Series 3 phase) n 5 Years limited on compressor AESSORIES n Hinged Roofcurb n oncentric Duct Kit n Economizer - Horizontal Modulating n Economizer - Downflow Modulating w/relief n Electric Strip Heat Kits (5 25 kw) n Single Point Power Entry Kit n Barometric Relief Damper n 0 25% Manual Outside air kit n 0 25% automatic outside air kit n Short cycle protector n Low ambient kit n Outdoor thermostat kits ompak 1 0

2 Number Guide P HP 10 B 48 D A - 1 P - Package Revision ode HP - Heat Pump A V/60HZ/1Ø B V/60HZ/3Ø 10 - Nominal SEER - 460V/60HZ/3Ø D - 575V/60HZ/3Ø B - Series D - Direct Drive Nominal apacity 48-48,000 Btuh Physical Electrical Voltage/ Hz/Phase Diameter (in.) Normal Voltage Range Outside Fan Min. ircuit Ampacity Nominal RPM Fuse/ HAR Brkr. Indoor Blower Wheel dia. x width (in.) Refrigerant harge (oz.) PHP10* , x PHP10* , x PHP10* , x PHP10* , x PHP10* , x PHP10* , x *Refers to B or series ( series 3 phase only). Weight (lbs.) ompressor Fan Motor Indoor Blower Rated Locked Rated Rated Rated Rated Load Rotor Load Load HP HP (amps) (amps) (amps) (amps) PHP10B24DA /60/ / /2 PHP10B30DA /60/ / /2 PHP10B36DA /60/ / /2 PHP10B42DA /60/ / /2 PHP10B48DA /60/ / /10 PHP10B60DA /60/ / /10 PHP1036DB /60/ / /2 PHP1048DB /60/ / /10 PHP1060DB /60/ / /10 PHP1048D 460/60/ / /10 PHP1060D 460/60/ / /10 PHP1048DD 575/60/ / /10 PHP1060DD 575/60/ / /10

3 Performance ooling Heating 47ºF 18ºF FM Btuh SEER EER S/T HSPF Btuh OP Btuh OP PHP10*24 23, , , PHP10*30 29, , , ,000 PHP10*36 34, , , ,200 PHP10*42 40, , , ,400 PHP10*48 48, , , ,600 PHP10*60 59, , , ,950 *Refers to B or series ( series 3 phase only). Blower Performance Blower ext. static pressure - in. w.c. w/o filter(s)¹ Speed High 1,100 1,060 1, PHP10*24 Med Low High 1,400 1,350 1,280 1,200 1,120 1, PHP10*30 Med 1,160 1,120 1,080 1, Low 1,050 1,020 1, High 1,400 1,350 1,280 1,200 1,120 1, PHP10*36 Med 1,160 1,120 1,080 1, Low 1,050 1,020 1, High 1,640 1,560 1,500 1,400 1,300 1,260 1,160 PHP10*42 Med 1,570 1,500 1,440 1,340 1,270 1,200 1,100 Low 1,480 1,430 1,360 1,290 1,230 1,170 1,050 High 2,150 2,100 2,030 1,950 1,875 1,750 1,650 PHP10*48 Med 1,920 1,870 1,790 1,730 1,650 1,580 1,500 Low 1,750 1,720 1,650 1,600 1,550 1,480 1,400 High 2,150 2,100 2,030 1,950 1,875 1,750 1,650 PHP10*60 Med 1,920 1,870 1,790 1,730 1,650 1,580 1,500 Low 1,750 1,720 1,650 1,600 1,550 1,480 1,400 ¹Add.10 to duct static for downflow FM equivalent. *Refers to B or series ( series 3 phase only).

4 ooling Performance Extended Ratings PHP10*24 PHP10*30 PHP10*36 PHP10*42 Indoor Outdoor Temp. - DBºF Temp DB/WB ºF Btuh S/T kw Btuh S/T kw Btuh S/T kw Btuh S/T kw Btuh S/T kw 85/72 28, , , , , /67 26, , , , , /63 23, , , , , /72 36, , , , , /67 33, , , , , /63 31, , , , , /72 39, , , , , /67 37, , , , , /63 35, , , , , /72 48, , , , , /67 46, , , , , /63 45, , , , , /72 60, , , , , PHP10*48 80/67 56, , , , , /63 51, , , , , /72 71, , , , , PHP10*60 80/67 66, , , , , /63 60, , , , , *Refers to B or series ( series 3 phase only). Heating Performance Extended Ratings Outdoor Temp DB/WBºF 0/0 17/15 35/33 47/43 62/56 Btuh kw Btuh kw Btuh kw Btuh kw Btuh kw PHP10*24 9, , , , , PHP10*30 10, , , , , PHP10*36 12, , , , , PHP10*42 14, , , , , PHP10*48 15, , , , , PHP10*60 22, , , , , *Refers to B or series ( series 3 phase only).

5 Heat Strip Electrical (Single Phase) Blower Unit PHP10*24A PHP10*30A PHP10*36A PHP10*42A PHP10*48A PHP10*60A Heater AHSA05A AHSA07A AHSA10A AHSA05A AHSA07A AHSA10A AHSA15A AHSA20A AHSA05SA AHSA07A AHSA10A AHSA15A AHSA20A AHSA10A AHSA15A AHSA20A Unit Blower Motor Minimum Fuse/ Min. Minimum Fuse/ Min. Minimum Supply kw Rated ircuit Wire ircuit HAR Wire ircuit Voltage Load Ampacity Size² Ampacity Brkr. Size² Ampacity Amps¹ A A B B Fuse/ HAR Brkr AHSA25A ¹Blower Motor always on ircuit A. ²Based on 60 type copper conductor 50 feet long in accordance with the National Electric ode. *Refers to B or series ( series 3 phase only). Min. Wire Size²

6 Heat Strip Electrical (Three Phase) Blower Unit PHP10*36B PHP10*48B PHP10*60B PHP10*48D PHP10*60D Heater Unit Supply Voltage kw Blower Motor Rated Load Amps¹ Minimum ircuit Ampacity A Fuse/ HAR Brkr. A Min. Wire Size² Minimum ircuit Ampacity B Fuse/ HAR Brkr. B Min. Wire Size² Minimum ircuit Ampacity Fuse/ HAR Brkr. AHSA10B AHSA15B AHSA10B AHSA15B AHSA20B AHSA25B AHSA AHSA AHSA AHSA AHSA10D PHP10*48DD AHSA15D PHP10*60DD AHSA20D AHSA25D ¹Blower Motor always on ircuit A. ²Based on 60 type copper conductor 50 feet long in accordance with the National Electric ode. *Refers to B or series ( series 3 phase only). Min. Wire Size²

7 Accessories Kit Number Description Used with AURB161-1* 14" Hinged Roofcurb PHP24-42 AURB163-1* 14" Hinged Roofcurb PHP48-60 AEON172-1* Economizer - Downflow Modulating w/relief PHP24-42 AEON173-1* Economizer - Horizontal Modulating PHP24-42 AEON170-1* Economizer - Downflow Modulating w/relief PHP48-60 AEON171-1* Economizer - Horizontal Modulating PHP48-60 ADMPR % Manual Outside Air Damper PHP24-42 ADMPR % Motorized Outside Air Damper PHP24-42 ADMPR166-1* 0-25% Manual Outside Air Damper PHP48-60 ADMPR167-1* 0-25% Motorized Outside Air Damper PHP48-60 ADMPR151-1 Barometric Relief Damper PHP24-60 AON164-1* oncentric Duct Adapter PHP24-42 AON165-1* oncentric Duct Adapter PHP48-60 ADIFF89-1 Air Diffuser - Flush PHP24-60 ADIFF150-1 Air Diffuser - Step Down PHP24-60 AHSA05A-1 5 kw Electric Heat Kit PHP24-42 AHSA07A-1 7 kw Electric Heat Kit PHP24-42 AHSA10A-1 10 kw Electric Heat Kit PHP24-60 AHSA15A-1 15 kw Electric Heat Kit PHP30-60 AHSA20A-1 20 kw Electric Heat Kit PHP30-60 AHSA25A-1 25 kw Electric Heat Kit PHP48-60 AHSA10B-1 10 kw Electric Heat Kit - 3 Phase PHP36-60B AHSA15B-1 15 kw Electric Heat Kit - 3 Phase PHP36-60B AHSA20B-1 20 kw Electric Heat Kit - 3 Phase PHP36-60B AHSA25B-1 25 kw Electric Heat Kit - 3 Phase PHP48-60B AHSA kw Electric Heat Kit - 3 Phase PHP48-60 AHSA kw Electric Heat Kit - 3 Phase PHP48-60 AHSA kw Electric Heat Kit - 3 Phase PHP48-60 AHSA kw Electric Heat Kit - 3 Phase PHP48-60 AHSA10D-1 10 kw Electric Heat Kit - 3 Phase PHP48-60D AHSA15D-1 15 kw Electric Heat Kit - 3 Phase PHP48-60D AHSA20D-1 20 kw Electric Heat Kit - 3 Phase PHP48-60D AHSA25D-1 25 kw Electric Heat Kit - 3 Phase PHP48-60D ALOAM111-1 Low Ambient ontrol PHP24-60 AHPSW436-1 High Pressure ut-out Kit PHP24-60 ATIMR446-1 Short ycle Protector PHP24-60 ASTAT444-1 Outdoor Thermostat PHP24-60 ASPWR160-1 Single Point Power Entry PHP24-42 ASPWR161-1 Single Point Power Entry PHP48-60 ASPWR162-1 Single Point Power Entry 460/575 Volt PHP48-60 *For use with B and series units ( series 3 phase only).

8 Accessories (All dimensions in inches) Hinged Roof urb AURB161-1(24-42) AURB163-1 (48-60) Kit Number A B D E F G AURB /4 43 1/ AURB /2 47 1/ /8 23 1/2 23 1/2 19 1/2 A B Supply Return E 1Ð Ð G F 1Ð D oncentric urb Adaptor AON164-1 (24-42) AON165-1 (48-60) Kit Number A B D E AON /2 18 3/4 18 1/2 16 AON /8 23 5/

9 0-25% Manual Outside Air Damper ADMPR145-1 (24-42) ADMPR166-1(48-60) Perforated Air Intake Panel (Replaces existing duct cover on unit) Air Intake Hood Adjustable Air Slide Damper 0-25% Motorized Outside Air Damper ADMPR146-1 (24-42) ADMPR167-1 (48-60) Air Intake Hood Motorized Damper Assembly Adjustable Air Slide Damper Perforated Air Intake Panel (Replaces existing duct cover on unit)

10 Accessories (All dimensions in inches) Ecnomizer - Downflow Modulating with Relief AAEON172-1 (24-42) Fresh Air Hood with Filter 16 Î 12 Barometric Relief Damper (Underneath) Ecnomizer - Downflow Modulating with Relief AEON170-1 (48) É Fresh Air Hood with Filter 20 Ì 18 Ö Barometric Relief Damper (Underneath) Ecnomizer - Horizontal Modulating AEON173-1 (24-42) AEON171-1 (48) A B AEON /4 11 5/8 AEON /4 12 1/8 9 Ð A B Return Duct Economizer Adapter (Shipped attached to economizer) 10 Barometric Relief

11 Dimensions (in.) A B D E F PHP10*24 PHP10*30 PHP10*36 PHP10* / / /2 46 1/2 46 1/2 46 1/2 45 5/8 45 5/8 45 5/8 45 5/8 17 1/2 17 1/2 PHP10*48 PHP10* / /2 50 1/2 54 5/8 49 5/8 21 1/2 G H J K L PHP10*24 PHP10*30 PHP10*36 PHP10* /2 11 1/ / / PHP10*48 PHP10* /8 1 1/8 6 1/4 5 5/8 M N P Q R PHP10*24 PHP10*30 PHP10*36 PHP10* / / /8 15 5/8 23 1/8 27 1/8 19 7/8 23 7/8 9 1/16 9 1/16 PHP10*48 PHP10*60 2 1/4 17 1/ / / /8 *Refers to B and series ( series 3 phase only). J E Supply F Return F B K REAR D L Return (48&60only) Return F Supply F G 2 A G H M G J TOP 2 É 4 Ò oil Access Panel N ondensate Drain 3 / 4 NPT LEFT SIDE P Q R Power Entry Low Voltage Entry Heat Strip Power Entry Rigging Holes(8) RIGHT SIDE Blower Access Panel

12 All specifications are subject to change without notice. 421 Monroe Street Bellevue, OH (419) Form #APHP10B/-100 (9/99) Armstrong Air onditioning Inc Printed in U.S.A. *APHP10B *