Universal Ports-Jump Emergency Jump Starter Item #409456

Transcription

1 Thanks for shopping with Improvements! Universal Ports-Jump Emergency Jump Starter Item # PORTA-JUMP TM EMERGENCY Car Battery Booster UNIVERSAL MODEL-UPJB USER S MANUAL

2 PORTA-JUMP QUICK START GUIDE TEST, CHARGE AND DRIVE Quick Start Guide to a Safe Charge* Make sure that all electrical accessories are turned off. Wait five minutes for vehicle battery to stabilize. If this step is omitted it will be very difficult to get your vehicle started. Remove the Porta- Jump Tote Bag from storage. Remove all accessories and leave the PJ Battery Box in the tote bag. Caution: the PJ Battery Box may become warm to the touch during operation. Do not touch or handle. Roll down the sides of the tote bag exposing the top of the battery box. If it is necessary to move the battery box during operation use the tote bag to lift the battery box. Next identify the specific ignition system your vehicle operates under. It may be necessary to refer to your Owner s Manual. There are two classifications: (1) The power port/cigarette lighter receptacle is powered directly by the vehicle s battery, remains active at all times, even when the ignition key is in the off position or (2) The power port/cigarette lighter receptacle is only powered when the ignition key is in the Accessory (ACC) position. Some new model vehicles are equipped with Keyless Ignition systems and or Push Button Starters, generally these systems operate in either Class 1 or 2 above. Check your Owner s Manual for the correct classification. TEST The TEST is performed by inserting the PJ Adapter Plug into the cigarette lighter/power port receptacle (the adapter jack is not plugged into the PJ Battery Pack at this time) with the Charge/Recharge switch in the forward position. The test will indicate your charging options as follows: (1) Class 1 Ignition System (with key in off position) Green light ON indicates vehicle battery

3 will accept charge and NO Light indicates that vehicle battery will not accept charge and you should seek professional help. (2) Class 2 Ignition System (key in ACC position) Green light ON indicates vehicle will accept charge and NO Light indicates that vehicle battery will not accept charge and you should seek professional help. Go to Charging Option. Charging Option #1: For Class 1 Ignition Systems (key in off position) insert the PJ Adapter Cord Jack End into PJ Battery Pack Jack Receptacle to begin the charge. The charging cycle takes from minutes. An audible sound will indicate that the charge is complete. The green LED light will progressively glow brighter. Charging Option #2: For Class 2 Ignition Systems (key in ACC position) insert the PJ Adapter Cord Jack End into the PJ Battery Pack Jack Receptacle to begin the charge. The charging cycle takes from minutes. An audible sound will indicate that the charge is complete. The green LED light will progressively glow brighter. Note: If Charging Options #1 or #2 fail to charge your vehicles battery to the starting point refer to the Fail Safe Charging Option described in this User s Manual. DRIVE The audible sound will indicate the end of the charging period, between minutes. Leaving the PJ Adapter plugged into the PJ Battery Box and inserted into the cigarette lighter/power port receptacle start your car. Do not pump gas pedal. RECHARGE To recharge the PJ Battery Pack reverse the charge/recharge switch on the adapter plug to the back or rear position to begin the recharge. After 30 minutes drive time your unit will be fully charged. STORAGE Return the PJ Adapter Plug and other Accessories to the tote bag and place in glove box.

4 *These are quick reference tips; refer to the product s detailed User s Manual for additional instructions, descriptions, warnings, certifications and disposal information. PORTA-JUMP EMERGENCY CAR BATTERY BOOSTER Thank you for purchasing the Porta-Jump Emergency Car Battery Booster by SWE, Inc. The Porta-Jump Multi-Vehicle battery booster is designed to transfer stored energy from the precharged Porta-Jump sealed battery to your vehicle s lead acid battery in twelve to fifteen minutes. The patented technology replaces your battery s lost surface charge. The Porta-Jump comes ready to use right out of the box. It requires no precharging or maintenance charging truly portable power at its best and will hold its charge up to the expiration date stamped on the battery box. Before using this product, read the instructions carefully. If your vehicle s battery is past its stated warranty or life expectancy or is mechanically defective, the Porta-Jump may not be able to provide a basic surface charge. It is important to always properly service and maintain your vehicle s primary lead acid battery, as detailed in your Owner s Manual. It is also recommended that you replace your primary battery when the manufacturer s warranty period expires; the date is stamped on the top of the battery. The Porta-Jump Emergency Car Battery Booster is a rechargeable battery booster designed for use on 4, 6 and 8 cylinder, gas or diesel powered cars, light trucks and SUV s with 12 volt electrical operating systems. The Porta- Jump, with the Accessory Kit, may also be used to provide an emergency battery boost to other vehicles utilizing a 12 volt electrical system including motorcycles, motor scooters, boats, ATV, RV, Snow Mobiles, Snowmobiles and airplanes.

5 The Porta-Jump first tests the condition of your car s battery to determine if the battery can accept a charge and then gives it enough charge so that you can safely start the engine. The Porta-Jump can be stored in your glove compartment, console or trunk of your vehicle and can be used multiple times before proper disposal is necessary. WARNINGS AND PRECAUTIONS Use as directed. Keep out of reach of children. Product is not waterproof; it will be damaged if submerged in water. During operation, the Porta-Jump battery box may become warm to the touch. Follow operating instructions and avoid handling the battery box during operation. STORAGE AND DISPOSAL Optimal operating temperature ranges: -4F (-20C) to 130F (54C). Recommended storage range: 32F (0 C) to 95F (35 C). Protective storage is required in extreme conditions exceeding the above guidelines. The product is safe to dispose of in certified landfills. The product contains no cadmium or mercury. OPERATING INSTRUCTIONS The Porta-Jump Emergency Car Battery Booster was designed specifically to assist motorists, like yourself, overcome an emergency situation caused by your vehicle experiencing a discharged battery. Porta-Jump has taken great care to design a product that will assist motorists to safely drive away from the emergency in minutes. One can imagine that with over 300 new car models being introduced into the marketplace each and every year that a product that can service a majority of different operating systems is a daunting task. To facilitate the vastness of the market Porta-Jump has narrowed the charging

6 methods to two basic OPTIONS. A majority of vehicles will fall into either one of these categories and if not, Porta-Jump has a Fail-Safe option, if the first two options fail. THE EMERGENCY! When you return to your car and discover that the vehicle will not start, usually when you insert the key and hear the clicking sound. Don t panic, take a deep breath and collect your thoughts. Immediately begin to take charge and turn off everything that may be discharging your car s battery. Turn off: The headlights. The interior lights, including the dashboard panel display dimmer, the overhead lights, map lights, side panel lights and rear overhead lights. The radio, CD player, cell phone and any plug in device such as a navigational aide. A/C or heater fan. If you have a car alarm system, like Lo Jack or a navigational system, like Tom-Tom, they must be put into the Valet Mode or they will interrupt power flow to or from the electrical system and the Porta-Jump may not work. Once you have turned off all possible electrical devices that are interrupting current flow, to or from, your vehicle s battery allow 5 minutes for your vehicle s battery to stabilize. Failure to pause for this critical recovery period may result in not being able to start your vehicle. Most fully operational batteries will begin to recover if they have been successfully operating in the immediate past (not stored for more than 2 weeks) and will automatically recover from a total discharged state so that the battery boost provided by the Porta-Jump will be successful. THE TEST The TEST is performed by inserting the PJ Adapter Plug into the cigarette lighter/power port receptacle (the adapter jack is not plugged into the PJ Battery Pack at this time) with the Charge/Recharge switch in the forward position. The test will indicate your charging options as follows: (1) Class 1 Ignition System (with key in off position) Green light ON indicates vehicle battery will accept charge and NO Light indicates

7 that the vehicle battery will not accept charge and you should seek professional help. (2) Class 2 Ignition System (key in ACC position) Green light ON indicates vehicle will accept charge and NO Light indicates that the vehicle battery will not accept charge and you should seek professional help. Go to Charging Option. CHARGING OPTION #1 For Class 1 Ignition Systems (key in off position) insert the PJ Adapter Cord Jack End into PJ Battery Pack Jack Receptacle to begin the charge. The charging cycle takes from minutes. An audible sound will indicate that the charge is complete. The green LED light will progressively glow brighter. CHARGING OPTION #2 For Class 2 Ignition Systems (key in ACC position) insert the PJ Adapter Cord Jack End into the PJ Battery Pack Jack Receptacle to begin the charge. The charging cycle takes from minutes. An audible sound will indicate that the charge is complete. The green LED light will progressively glow brighter. DRIVE The audible sound will indicate the end of the charging period, between minutes. Leaving the PJ Adapter plugged into the PJ Battery Box and inserted into the cigarette lighter/power port receptacle start your car. Do not pump gas pedal. CHARGING OPTION #3 FAIL SAFE OPTION If Charging Options #1 and #2 fail to charge your car s battery to the starting point utilize the Fail Safe Option. Before exiting the vehicle turn the ignition switch to the OFF position and remove the key. You will need to take the Porta-Jump Battery Box (still in the rolled down Tote Bag) by the pull strings to avoid touching the battery box, the PJ Adapter Plug and the Porta-Jump Mini Jumper Cables (Alligator Clips with red and black tips) with you as you exit the vehicle. Lift the hood and locate the vehicle s battery. Attach the RED clip to the battery s RED (+)terminal and the Black clip to the battery s Black (-) Terminal. If a Black Terminal is not evident then attach the Black Clip to a metal surface of the vehicle s frame to ground the circuit.

8 Plug the Porta-Jump Adapter Plug into the Mini Jumper Cable s receptacle and check to make sure the PJ Adapter Plug s Charge/Recharge Switch is set to the forward position. If the Green LED glows (even faintly) then proceed with the charge. If the Green LED fails to glow then your vehicle s battery is defective and you should call for professional help. To proceed with the charge, leave the mini jumper cables attached to the battery, keep the PJ Adapter Cord plugged into the mini jumper cables and now plug the PJ Adapter Cord s Jack End into the PJ Battery Box to start the charge. At the completion of the charge cycle (12 to 15 minutes) an audible beep will indicate that you may start your vehicle. It is now time to start your vehicle. It is necessary to leave everything attached to your vehicle s battery and return to the Driver s Station, insert the key and start your vehicle. Once the vehicle is running you may return to the battery and disconnect the Mini Jumper Cables. To recharge the PJ Battery Box follow the instructions listed below. Be advised - that some automobile manufacturers have placed the battery in other locations within the vehicle to accommodate design requirements. Your battery may be under the rear seat or in a special compartment under the frame toward the rear. If your battery is not accessible, the manufacturer has placed a CHARGING POINT somewhere under the hood. Please refer to your Owner s Manual to locate the charging point (usually a nut ). Instead of attaching the alligator clips to the battery attach them to the charging point, as instructed, and continue the charge as described above. RECHARGING THE PORTA-JUMP BATTERY BOX To recharge the PJ Battery Pack reverse the charge/recharge switch on the adapter plug (leaving the PJ Adapter cord/battery box plugged into the cigarette lighter/ power port receptacle) and after 30 minutes drive time your unit will be fully charged. If the Fail Safe Option was used to recharge the battery simply return the PJ Battery Box and Adapter Cord to your inside console and plug the Adaptor Cord into your vehicle s power port and set the charge/recharge switch to recharge. After 30 minutes drive time your unit will be fully charged. PORTA-JUMP ACCESSORY KIT The Porta-Jump Accessory Kit expands the recharging options to include motorcycles, motor scooters, ATV, RV, boats, snowmobiles

9 and airplanes that operate on a standard 12 volt electrical system. The accessories are designed to accommodate the operating features of these vehicles, which might be different from the standard automobile recharging protocols. Please refer to each vehicles Owner s Manual and follow those specific recharging protocols for a successful battery boost. The Mini Jumper Cables (commonly referred to as alligator clips ) are designed to attach directly to the discharged vehicle s battery. Follow the user instructions in the Fail Safe Mode above. TECHNICAL INFORMATION The Porta-Jump Battery Box is powered by 1500 mah AA Alkaline Batteries producing 30 Volts Output Capacity. The Porta-Jump System is certified and displays the following marks: CE, ETL RoHS. The Porta-Jump System is protected under United States Patent Number: 7,573,230 and other US and International patents pending. RECOMMENDED BATTERY MAINTENANCE The best way to avoid an emergency situation where your vehicles battery becomes discharged is to properly maintain the battery. It is recommended that each time you have your vehicle serviced have the mechanic check your vehicle s battery, including, the fluid levels (if applicable), the terminal connections should be free of corrosive build-up and fastened to the battery terminals, the battery cables should be inspected. The mechanic should check your vehicle s fuse box for defective fuses and replace them as needed. Specific attention should be made that the cigarette lighter receptacle and the power port fuses are operational since they determine if your potential recharge will be effective. The mechanic should verify the battery manufacturer s warranty expiration date. If the battery is out of warranty it should be replaced. The closer your battery gets to the expiration date the weaker it becomes. The Porta-Jump System should not be used as a battery extender or replacement. Your vehicle s battery is the most important component in the vehicles operation. It should be inspected regularly and replaced when indicated.