FLUIDS, LUBRICANTS AND GENUINE PARTS

Transcription

1 LX - CHRYSLER L V8 SRT HEMI MDS FLUIDS, LUBRICANTS AND GENUINE PARTS ENGINE Cooling System (3.0L Diesel 12.7 Quarts 12 Liters (3.6L 10.0 Quarts 9.5 Liters (5.7L without Severe Duty II Cooling System 14.5 Quarts 13.9 Liters (5.7L with Severe Duty II Cooling System 15.0 Quarts 14.3 Liters 1

2 (6.4L 15.2 Quarts 14.4 Liters Engine Oil with Filter Engine Oil - ACEA Categories (Gasoline For countries that use the ACEA European Oil Categories for Service Fill Oils, We recommend you use engine oils ACEA C3, and approved to Fiat SAE 5W-30 engine oil approved to Fiat may be used when SAE 5W-20 engine oil is not available. Engine Oil (3.0L Diesel MOBIL 1 SAE 5W-30 Low Ash Fully Synthetic oil, ACEA C AA 9.1 Quarts 8.6 Liters Engine Oil (3.6L API Certified SAE 5W-20 engine oil, Chrysler Group LLC Material Standard MS PA 5 Quarts PA 6 Quarts 5.6 Liters 2

3 Engine Oil (5.7L API Certified SAE 5W-20 engine oil, Chrysler Group LLC Material Standard MS PA 5 Quarts PA 7 Quarts 6.6 Liters Engine Oil (6.4L API Certified SAE Full Synthetic engine oil 0W-40, meeting the requirements of Chrysler Group LLC Material Standard MS PA 7 Quarts 6.6 Liters Engine Oil Filter (3.0L Diesel Engine Oil Filter Kit AA Engine Oil Filter (3.6L Engine Oil Filter (5.7L and 6.4L Fuel (approximate) Engine Oil Filter Engine Oil Filter AB AB 3

4 Fuel Selection (3.0L Diesel Use good quality diesel fuel from a reputable supplier in your vehicle. The manufacturer requires that you must fuel this vehicle with Ultra Low Sulfur Highway Diesel fuel (15 ppm Sulfur maximum) and prohibits the use of Low Sulfur Highway Diesel fuel (500 ppm Sulfur maximum) to avoid damage to the emissions control system. For most yearround service, No. 2 diesel fuel meeting ASTM specification D-975 Grade S15 will provide good performance. If the vehicle is exposed to extreme cold (below 20F or -7C), or is required to operate at colderthan-normal conditions for prolonged periods, use climatized No. 2 diesel fuel or dilute the No. 2 diesel fuel with 50% No. 1 diesel fuel. This will provide better protection from fuel gelling or waxplugging of the fuel filters. This vehicle is fully compatible with biodiesel blends up to 5% biodiesel meeting ASTM specification D Gallons 72 Liters 4

5 Fuel Selection (3.6L Fuel Selection (5.7L Fuel Selection (6.4L 87 Octane 87 Octane Acceptable - 89 Octane Recommended 91 Octane Only or higher 19 Gallons 72 Liters 19 Gallons 72 Liters 19 Gallons 72 Liters A/C Refrigerant System A/C Refrigerant System R-134a AB 1.50 Pounds 681 Grams # System fill capacity includes heater and coolant recovery bottle filled to MAX level. SPARK PLUGS Gap Spark Plugs (3.6L Champion SP149125AD (RER8ZWYCB4) in 1.10 mm Spark Plugs (5.7L NGK Yttrium AB (LZFR5C-11) in 1.10 mm Spark Plugs (6.4L NGK Single Platinum AC (LZTR6AP11EG) in 1.10 mm TRANSMISSION Automatic NAG 1 - Service Fill ATF AA +4 Automatic Transmission Fluid AA 5.3 Quarts 5.0 Liters 5

6 # NAG 1 - Overhaul Fill ATF AA +4 Automatic Transmission Fluid AA 8.1 Quarts 7.7 Liters # 8HP45 ATF AA 9.5 Quarts 9.0 Liters # Dry fill capacity. Depending on type and size of internal cooler, length and inside diameter of cooler lines, or use of an auxiliary cooler, these figures may vary. Refer to the appropriate service information for the correct procedures. For the 8HP45 see to the fluid checking standard procedure (Refer to 21 - Transmission and Transfer Case/Automatic - 8HP45/FLUID and FILTER - Standard Procedure) prior to checking or adding fluid to this transmission. A unique transmission fluid has been developed for this transmission. This fluid is NOT compatible with ATF+4 or any other current Chrysler transmission fluid. For specifics about this unique fluid see FLUIDS, LUBRICANTS AND GENUINE PARTS. TRANSFER CASE BW Transfer Case Lubricant AA 2.11 Pints 1.0 Liters CHASSIS s (Front) 175mm FIA Front 75W AA 1.26 Pints 0.6 Liters s (Rear) 6

7 200mm RII Rear 215mm RII Rear 75W W Quarts 1.1 Liters Quarts 1.2 Liters # 226mm RII Rear 75W AA 1.4 Quarts 1.3 Liters Chassis Systems ## Brake Master Cylinder Brake Fluid DOT 3, SAE 12 oz. Bottle AB J oz. Bottle AB ### Power Steering Reservoir (Belt Driven Pump) Power Steering Fluid AA #### Electro Hydraulic Power Steering (EHPS) Hydraulic Power Steering Fluid AA or AB # Limited-Slip Rear s require the addition of 118 ml (4 oz.) Limited Slip Additive. ## If Brake Fluid DOT 3 is not available, then Brake and Clutch Fluid DOT 4 (P/N AC), is acceptable. ### If Power Steering Fluid +4 is not available, then ATF +4 Automatic Transmission Fluid (P/ N AA), is acceptable. #### There is an Electro Hydraulic Power Steering (EHPS) pump on Non-SRT vehicles which requires a different power steering fluid. Do not mix power steering fluid types. Damage may result to the power steering pump and system if any other fluid is used. The EHPS system uses fluid which meets material specification MS or equivalent. The mechanical power steering pump systems on SRT vehicles require the use of Power Steering Fluid +4, which meets material specification MS-9602 or equivalent. Do not overfill. 7