HERMETIC CENTRIFUGAL LIQUID CHILLER 19EB MACHINE WITH FRAME 4 OR 5 COMPRESSOR SERVICE PARTS GUIDE HOW TO USE THIS CATALOG

Transcription

1 MACHINE WITH FRAME 4 OR 5 COMPRESSOR SERVICE PARTS GUIDE HOW TO USE THIS CATALOG 1. THIS CATALOG PRESENTS THE MOST COMMONLY USED SPECIFIED PARTS FOR THE STANDARD CENTRIFUGAL REFRIGERATION MACHINE AND IS NOT APPLICABLE TO ANY SPECIAL ORDER MACHINES. (CONTACT CARRIER WITH MACHINE SERIAL NUMBER FOR ANY SPECIAL ORDER UNIT PARTS.) 2. OCCASIONALLY, DUE TO LIMITATIONS OF ILLUSTRATIONS USED, A PART MAY NOT BE ILLUSTRATED. THESE PARTS ARE IDENTIFIED BY "N" IN THE COLUMN NEXT TO THE ITEM NUMBER. 3. THE FOLLOWING PARTS ARE NOT LISTED IN THIS CATALOG: A. IMPELLERS, SHROUDS, DIFFUSERS B. COMPRESSOR MOTOR (ROTOR & STATOR) C. EVAPORATOR TUBE PART NUMBERS D. CONDENSER TUBE PART NUMBERS IF ANY OF THESE PARTS ARE REQUIRED, CONTACT YOUR CARRIER REPRESENTATIVE WITH THE MODEL AND SERIAL NUMBER OF YOUR MACHINE. 4. POSITIVE IDENTIFICATION OF YOUR MACHINE TO PROPERLY SELECT PARTS MAY BE DONE BY REFERRING TO THE MACHINE NAME PLATE. REFER TO PAGE #2. 5. ITEM NOTES ARE GENERALLY ASSOCIATED WITH THE PART NUMBER DIRECTLY ABOVE. Graphics Page: 1 Electronic Graphics

2 CODE CODE COMPR. IMPELLER CODE COMPR. IMPELLER MOTOR CODE POSITION UNISHELL POSITION FRAME SHROUD POSITION FRAME SHROUD POSITION SIZE SIZE #5 #6 #7 #8 SIZE #7 #8 SIZE B D C D D D E D F D G D D H D J D K D L D M D N D P D Q D Graphics Page: 2 Electronic Graphics

3 FOR ALTERNATE ARRANGEMENT SEE VIEW A A SEE DETAIL VIEW B VIEW A LOCATED ON SIDE OF VESSEL B / ) , ) 4 / - / ) C 284 VIEW B Graphics Page: 3 Electronic Graphics

4 A A OR LO-SIDE CHAMBER 300 OR 304 OR SECTION A-A HI-SIDE CHAMBER OR 298 OR 302 OR 306 UTILITY VESSEL 295 OR 299 OR 303 OR 307 Graphics Page: 4 Electronic Graphics

5 PUMPDOWN ASSEMBLY PUMPDOWN CONTROL BOX ASSEMBLY Graphics Page: 5 Electronic Graphics

6 B SECTION B-B B 322 DEHYDRATOR OIL COOLER FILTER ASSEMBLY OIL RESERVOIR COVER ASSEMBLY Graphics Page: 6 Electronic Graphics

7 SEE TERMINAL ARRANGEMENT Graphics Page: 7 Electronic Graphics

8 Graphics Page: 8 Electronic Graphics

9 COMPRESSOR TRANSMISSION Graphics Page: 9 Electronic Graphics

10 ROTOR & BEARING ASSEMBLY DETAIL "C" SEE DETAIL "C" Graphics Page: 10 Electronic Graphics

11 LOCATION REAR BEARING ASSEMBLY ITEM #58 Graphics Page: 11 Electronic Graphics

12 SECTION B-B A B B SECTION A-A A 133A GASKET OR B O-RING OR Catalog No: RCD (1/99) Supersedes: & Rev. Rev. GUIDE VANE SHAFT & SEAL ASSEMBLY Graphics Page: 12 Electronic Graphics

13 H H SECTION H-H CHAIN DRIVE GUIDE VANE ASSEMBLY Graphics Page: 13 Electronic Graphics

14 HIGH VOLT. TERM. ARRANGEMENT ITEM # HIGH VOLT. TERM. ARRANGEMENT ITEM # HIGH VOLT. TERM. ARRANGEMENT ITEM #114 Graphics Page: 14 Electronic Graphics

15 LOW VOLT TERM. ARG. ITEM # MUST ORDER COMPLETE NEW ASY LOW VOLT TERM. ARG. OLD STYLE Graphics Page: 15 Electronic Graphics

16 HIDDEN DESIGN I HIDDEN 408 LOCATION SAFETY INDICATOR PANEL 32GA Graphics Page: 16 Electronic Graphics

17 DESIGN II Supersedes & Rev. LEAD-LAG CONTROL ASSEMBLY 32SM Graphics Page: 17 Electronic Graphics

18 , ) ) ), - ), $ & ) 4-4 " + ) 2 ) + 16 ; ) 7 6, ) 5-0, ) ) 5 6 ) ) ) MP CONTROL PANEL Graphics Page: 18 Electronic Graphics

19

20

21

22

23

24

25

26

27

28

29

30