CME306 and CME456 Service Parts

Size: px

Start display at page:

Download "CME306 and CME456 Service Parts"

Avice Hutchinson
5 years ago
Views:

1 CME0 and CME Service Parts This parts list contains the parts numbers for the CME0 and CME air and water cooled models. The title at the top of the page identifies which model the parts list applies to. The machines are available in /0 or 0/0 or 0/0 electrical configurations. The A and B series have different water cooled condensers. C series has a different expansion valve and fan motor bracket, as well as the B series water cooled condenser.. Be sure to check the description to confirm that the correct part number is being ordered. Table of Contents Cabinet Page ater Pump and Sensor Page Evaporator and ater Distribution Page CME0 Air Cooled efrigeration Page CME Air Cooled efrigeration Page Air Cooled Section Page Interior Parts Page CME0 ater Cooled efrigeration Page CME ater Cooled efrigeration Page 0 ater Cooled Section Page Control Box and Electrical Page iring Diagram Page May 00 Page

2 CME0 and CME Service Parts Cabinet Top panel, plastic, includes item 0--0 Insulation A-0 ight side panel, includes catches 0--0 Strike 0--0 Insert -0-0 CM emblem Emblem A-0 Front panel, includes trim strip, strikes and emblems 0-- Trim strip 0--0 Screw Catch 0--0 Filter for air cooled 0--0 Screw A-0 Left side panel, AC A-0 Left side panel, C Catch May 00 Page

3 CME0 and CME Service Parts ater Pump and Sensor 0--0 Float stem, was dark blue, changed to black ater level sensor 0--0 Screw Sump cover 0--0 Float 0--0 Pump bracket - front half -- ater pump, CME0 /0 -- ater pump, CME0 all 0 volt -- ater pump, CME /0 -- ater pump, CME all 0 volt Pump bracket, back half --0 Harness December 0 Page

4 CME0 and CME Service Parts Evaporator and ater Distribution a ater distributor 0--0 Manifold ( only) a ubber plug A-0 Left evaporator A-0 ight evaporator ( only) ater hose, CME only -0- Temperature sensor, includes discharge sensor 0--0 ater trough CME only 0--0 ater hose, CME0 only ( plate) -0-0 Purge valve,/0 Hz -0- Coil only, volt -0-0 Purge valve, 0 volt -0- Coil only, 0 volt 0 A0-00 ater manifold, CME0 only November 00 Page

5 CME0 and CME Service Parts CME0 Air Cooled efrigeration 0 A-0 Evaporator --0 Hot gas valve -0-0 Strainer -0- Access valve -0-0 Port cap -0-0 Stem cap -0- Discharge sensor, includes water sensor Compressor, /0, includes PTC, un Cap and drier. SCE-CAA- verload for above Compressor, 0/0, includes drier verload for above Compressor, 0/0. SCE-CA- verload for above Screw asher -00- Grommet -00- Sleeve -00- TX, AN ½ SZ. For A and B series. --0 TX. Danfoss, for C thru H series -0-0 Insulation for TX Filter drier Air cooled condenser A-00 Suction line January 0 Page

6 CME0 and CME Service Parts CME Air Cooled efrigeration 0 see page Evaporator -- Hot gas valve -0-0 Strainer -0- Access valve -0-0 Port cap -0-0 Stem cap -0- Discharge sensor, includes water sensor Compressor, /0, includes PTC, un Cap. and drier. SCE-CAA- verload for above Compressor, 0/0, includes drier verload for above Compressor, 0/0. SCE-CA- verload for above Screw asher -00- Grommet -00- Sleeve -00- TX, AN ½ SZ. For A and B series. --0 TX. Danfoss, for C thru H series -0-0 Insulation for TX 0--0 Filter drier Air cooled condenser -0-0 Check valve A-00 Suction line January 0 Page

7 CME0 and CME Service Parts Air Cooled Section 0 A-00 Shroud for CME --0 Fan blade -- Fan motor, /0 --0 Fan motor, 0 volt A0-00 Fan motor bracket for A or B series (or EM&Sfanmotor) A0-00 Fan motor bracket for C series (or GE fan motor) 0--0 Screw, bracket to shroud A0-00 Shroud for CME0 A-00 Top of shroud A-00 Divider A-00 AC back panel A-00 AC baffle Drain fitting A-00 Shroud bottom November 00 Page

8 CME0 and CME Service Parts Interior Parts Cascading shield, CME only -00- Ice Sensors, set of two Upper splash panel Evaporator support 0--0 Evaporator cover 0--0 Insulation 0--0 Grommet Lower splash panel -0-0 Tubing, C only, order units (ft) Tubing, AC only -0-0 Tube, 0 Hz AS listed units --0 ater valve -0-0 ater valve, 0 Hz AS listed units 0--0 Grommet seal 0--0 Grommet Ice deflector November 00 Page

9 CME0 and CME Service Parts CME0 ater Cooled efrigeration 0 A-0 Evaporator --0 Hot gas valve -0-0 Strainer -0- Access valve -0-0 Port cap -0-0 Stem cap -0- Discharge sensor, includes water sensor -- Compressor, /0, includes PTC and drier SCE-CAA verload for above -0- Compressor, 0/0, includes drier -00- verload for above -- Compressor, 0/0. SCE-CA- --0 verload for above Screw asher -00- Grommet -00- Sleeve January 0 Page -00- TX, AN ½ SZ. For A and B series series --0 TX. Danfoss, for C thru H -0- Insulation for TX 0--0 Filter drier ater regulating valve -00- Hi pressure cut out -0- A Series water cooled condenser -- B or C Series water cooled condenser A-00 Suction line

10 CME0 and CME Service Parts CME ater Cooled efrigeration see page Evaporator -- Hot gas valve -0-0 Strainer -0- Access valve -0-0 Port cap -0-0 Stem cap -0- Discharge sensor, includes water sensor Compressor, /0, includes un cap, PTC and drier. SCE-CAA- verload Compressor, 0/0, includes drier verload Compressor, 0/0.SCE-CA- verload for above Screw asher -00- Grommet -00- Sleeve TX, AN SZ. For A or B series TX for C series. Insulation TX: Filter drier -0-0 Check valve -0-0 ater regulating valve -00- Hi pressure cut out A Series water cooled condenser B or C Series water cooled condenser A-00 Suction line January 0 Page 0

11 CME0 and CME Service Parts ater Cooled Section A0-00 Purge valve bracket, also used on air cooled A-00 Drain casting Screw A00-00 Back panel for water cooled May 00 Page

12 CME0 and CME Service Parts Control Box and Electrical Transformer /0/ only --0 Transformer, 0/0/ only --0 Contactor -0- Purge valve timer --0 Fuse for 0/0 only -0-0 Terminal strip for 0/0 only --0 Fuse holder 0/0 only --0 elay 0/0 only --0 PTC -0- un Cap, CME0 for /0 Hz -0- un cap, for CME0 0/0 hz -0- un Cap CME /0-0-0 un Cap for all CME 0 volt -00- Start Cap, CME0 0/ elay holder --0 Transformer for 0/0/ only -- Controller A0-00 Control box cover A0-00 Brace ctober 0 Page Harnesses: Hi oltage: --0 AC 0/0 --0 C 0/0 --0 AC, C /0 Low oltage --0 C, 0/0 --0 AC, 0/0 --0 AC, C /0

13 CME0 and CME Service Parts 0 Hz iring Diagram -0-0 SLENID MT (AI CLEDNL) MT (0NL) MT / / / USE CPPE CNDUCTS NL DASHED LINES INDICATE FIELD IING HICH MUST BE INSTALLED IN ACCDANCE ITH THE NATINAL ELECTICAL CDE AND ALL STATE AND LCAL CDES. CAUTIN: PTC ILL BE HT. CMPESS MA NT STAT IF PTC IS NT ALLED T CL HTGAS / SLENID / LAD ALE THEM (PTINAL) SUMP SENS DISCHAGE SENS TANSMITTE ECEIE THIS UNIT MUST BE GUNDED. LEEL SENS ELECTNIC CNTL CMMUNICATINS PT / HIGH PESSUE CNTL (CLED NL) SEE NAMEPLATE F PPELTAGE EQUIEMENTS AND MAXIMUM FUSE SIZE CAUTIN: METHAN NE DISCNNECT MEANS MA BE EQUIED T DISCNNECT ALL PE T THIS UNIT. JUNCTIN BX L T CNTACT L T / /(- NL) (- NL) GUND SCE LINE TANSFME / UN CAP / PTC EATHGUND PESUPPL PTECT INTENAL ALE ELA CMPESS TEMINAL BX C S March 00 Page

14 CME0 and CME Service Parts 0 Hz Schematic Diagram L TANSFME L LINE ALE TIME ELA ELA TIGGE HT GAS ALE BI N STAT ( PTINAL) ALE HIGH PESSUE CNTL (C NL) CNTACT CIL ELECTNIC CNTL SUMP DISCHAGE TEMP X- MIT C. LEEL SENS ALE ELA CNTACTS CNTACT T ALE MT (AC NL) MT () (AC NL) PTC UN CAP. CMPESS January 000 Page

15 CME0 and CME Service Parts CME 0 Hz Air Cooled iring Diagram GUND SCE / / ELA (ACNL) G/ ELA EATH GUND ELA THEM TANSMITTE ECEIE ELECTNIC CNTL / LAD LINE ALE / L TANSFME BI N STAT FUSE (A) LI NE DISCHAGE TEMP ALE ELA CIL ELA ELA ALE ELA CNTACTS ALE ALE TIME TIGGE ELA CIL ELA CIL ELECTNIC CNTL SUMP CNTACT T HT GAS ALE ALE X-MIT C. CMPESS CNTACT CIL LEEL SENS L MT MT ( NL) SUMP TEMP SENS DISCHAGE TEMP SENS LEEL SENS CMMUNICATINS PT MT / PTC UN CAP --0 THIS UNIT MUST BE GUNDED. USE CPPE CNDUCTS NL JUNCTIN BX DASHED LINES INDICATE FIELD IING HICH MUST BE INSTALLED IN ACCDANCE ITH THE NATINAL ELECTICAL CDE AND ALL STATE AND LCAL CDES. SLENID HT GAS SLENID CAUTIN: ME THAN NE DISCNNECT MEANS MA BE EQUIED T DISCNNECT ALL PE T THIS UNIT TANSFME CNTACT L T T L / ( NL) MT / / / / / MT 0 PE SUPPL / 0 0 PTECT INTENAL ALE TIME TEMINAL BX CMPESS SEE NAMEPLATE F LTAGE EQUIEMENTS AND MAXIMUM FUSE SIZE C S CAUTIN: PTC ILL BE HT CMPESS MA NT STAT IF PTC IS NT ALLED T CL / PTC UN CAP. January 000 Page

16 CME0 and CME Service Parts CME 0 Hz ater Cooled iring Diagram -0-0 HIGH PESSUE CNTL / SLENID HT GAS SLENID / / SEE NAMEPLATE F PPE LTAGE EQUIEMENTS AND MAXIMUM FUSE SIZE / TANSFME / / 0 / JUNCTIN BX PE SUPPL 0 ALE TIME CAUTIN: CMPESS MA NT STAT IF PTC IS NT ALLED T CL PTC ILL BE HT / HIGH PESSUE CNTL L T CNTACT L T THEM SUMP TEMP SENS THIS UNIT MUST BE GUNDED. USE CPPE CNDUCTS NL CAUTIN: MT ME THAN NE DISCNNECT MEANS MA BE EQUIED T DISCNNECT ALL PE T THIS UNIT PTECT INTENAL TEMINAL BX CS CMPESS DASHED LINES INDICATE FIELD IING HICH MUST BE INSTALLED IN ACCDANCE ITH THE NATINAL ELECTICAL CDE AND ALL STATE AND LCAL CDES. PTC UN CAP DISCHAGE TEMP SENS LEEL SENS CMMUNICATINS PT / TANSMITTE ECEIE ELECTNIC CNTL LAD LINE G/ ELA GUND SCE EATH GUND ALE L L TANSFME FUSE (A) STAT LINE SUMP DISCHAGE TEMP CNTACT T ALE TIME TIGGE HT GAS ALE ALE ELECTNIC CNTL ALE ELA CNTACTS X- MIT ALE C. ELA CNTACT CIL ELA CIL ALE ELA CIL CMPESS LEEL SENS ELA / PTC UN CAP. January 000 Page

17 January 000 Page --0 CAUTIN: ME THAN NE DISCNNECT MEANS MA BE THEM SUMP SENS DISCHAGE SENS TANSMITTE ECEIE LEEL SENS USE CPPE CNDUCTS NL EQUIED T DISCNNECT ALL PE T THIS UNIT. ELECTNIC CNTL CMMUNICATINS PT / SLENID HT GAS SLENID / / MT T L / / TANSFME LAD LINE CNTACT L T / / ELA / MT 0 / PE SUPPL ELA G/ ELA 0 / JUNCTIN BX 0 PTECT INTENAL GUND SCE EATH GUND TEMINAL BX SEE NAMEPLATE F PPE LTAGE EQUIEMENTS AND MAXIMUM FUSE SIZE ALE TIME STAT CAP PTC C S ALE / DASHED LINES INDICATE FIELD IING HICH MUST BE INSTALLED IN ACCDANCE ITH THE NATINAL ELECTICAL CDE AND ALL STATE AND LCAL CDES. CAUTIN: PTC ILL BE HT. CMPESS MA NT STAT IF PTC IS NT ALLED T CL L LINE TANSFME FUSE (A) STAT DISCHAGE ELA ALE ELA CNTACTS CNTACT T ELA CIL ALE ELA CIL ELA ALE ALE TIME TIGGE ELA CIL ELECTNIC CNTL SUMP HT GAS ALE X-MIT ALE CNTACT CIL C. STAT CAP. LEEL SENS MT PTC L CME0 0 Hz Air Cooled iring Diagram CME0 and CME Service Parts THIS UNIT MUST BE GUNDED. CMPESS CMPESS

18 January 000 Page -0-0 CAUTIN: ME TH AN NE DISCNNECT ME AN S MA BE EQUIED T DISCNNECT AL L P E THIS UN IT. THEM SUMP SENS DISCHAGE SENS TANSMITTE ECEIE HIGH PESSUE CNTL LEEL SENS USE CPPE CNDUCTS NL ELECTNIC CNTL T CMMUNICATINS PT / SLENID HT GAS SLENID / / T L / / TANSFME LAD LINE CNTACT L T / / ELA MT SEE NAMEPLATE F PPE LTAGE EQUIEMENTS AND MAXIMUM FUSE SIZE 0 PE SUPPL G/ ELA 0 / JUNCTIN BX PTECT INTENAL EATH GUND ALE TIME TEMINAL BX GUND SCE PTC STAT CAP C S ALE DASHED LINES INDICATE FIELD IING HICH MUST BE INSTALLED IN ACCDANCE ITH THE NATINAL ELECTICAL CDE AND ALL STATE AND LCAL CDES. CAUTIN: PT C ILL BE HT. CMPESS MA NT STAT IF PTC IS NT ALLED T CL / L LINE TANSFME FUSE (A) STAT DISCHAGE ELA ALE ELA CNTACTS CNTACT T ELA CIL ALE ELA CIL ALE ALE TIME TIGGE ELECTNIC CNTL SUMP HT GAS ALE X-MIT ALE HIGH PESSUE CNTL C. STAT CAP. CNTACT CIL LEEL SENS PTC L CME0 0 Hz ater Cooled CME0 and CME Service Parts THIS UNIT MUST BE GUNDED. CMPESS CMPESS

CME1356R and CME1656R Service Parts

CME1356R and CME1656R Service Parts CME and CME Service Parts This parts list contains the part numbers and description of the replacment parts available for these two models. They have been manufactured in both 0 and 0 Hz, plus there have