HN B G1/US B G2/US B G3
|
|
|
- Alison Holland
- 5 years ago
- Views:
Transcription
1 HN B G/US B G/US B G Compact direct acting, port solenoid valve air, water,, low vacuum (. x 0 Pa (abs)) CONTENTS Safety precautions port solenoid valve HNB NC (normally closed) type USB NC (normally closed) type 8 USB NC (normally closed) type 0 port solenoid valve HNG Universal type 6 USG Universal type USG Universal type Resin body type USB NC (normally closed) type 6 USB NC (normally closed) type 6 USG Universal type 6 USG Universal type 6 Electronic Catalog file list 0 Always read the precautions in the Introduction and page before starting use. K S/ NP/N PD/F/ Compact direct acting, port solenoid valve
2 Safety precautions Always read this section before starting use. Compact direct acting, port solenoid valve Working fluid () When using this valve for, the life can be shortened considerably due to wear. Use a valve for. () This valve cannot be used for maintaining the vacuum. Consult with CKD when the vacuum needs to be maintained. WARNG CAUTION Design & Selection Continuous energizing Consult with CKD when using the port valve in a continuously energized state. Fluid viscosity The fluid viscosity must be 0 mm /s. Malfunctions could occur if the viscosity is higher than 0 mm /s. Leakage current from other fluid control components When operating the solenoid valve with a programmable controller, etc., check that the output leakage current from the programmable controller is within the following specifications. Failure to observe this could lead to malfunctions. Triode AC switch Programmable controller side CR circuit C R Leakage current Solenoid valve Installation, Piping & Wiring CAUTION Piping Always hold the socket with a spanner, etc., if the NO side is a socket. CAUTION Maintenance USB/USG When disassembling or assembling, tighten the core assembly and socket with the following tightening torques. USB USG USB USG Core assembly tightening torque Socket tightening torque 0 to N m 0 to N m 8 to N m 8 to N m to 8 N m <<Precautions for each model>> USB/USG (resin body type) CAUTION Metal is wetted. (This is not a metal free valve.) Do not use a metal (M6) joint because it could damage the port. Use a PP or fluorine resin joint. Refer to the recommended torque below. Recommended tightening torque: 0. to 0. N m Voltage USB, USG HNB, HNG AC AC diode DC 00 V 00 V 00 V 00 V V V 0. ma 0. ma ma ma ma ma
3 MEMO K S/ NP/N PD/F/ Compact direct acting, port solenoid valve
4 HNB Series Compact direct acting port solenoid valve HNB Series NC (normally closed) type : JIS symbol NC (normally closed) type Specifications Item HNB Working fluid Air, water,, low vacuum (. x 0 Pa (abs)) Working pressure differential range MPa 0 to 0.7 Withstanding pressure (water) MPa.0 Fluid temperature C 0 to 0 (no freezing) Ambient temperature C 0 to 0 (no freezing) Valve seat leakage cm /min. 0 (water pressure) Mounting attitude Free Weight g Orifice mm.0 Cv flow factor 0.0 C [dm /(s bar)] 0. b 0. Electric specifications Rated voltage VDC (option: VDC ) Allowable voltage fluctuation ±0% Power consumption W. Leakage current ma Heat class B *: Effective sectional area S and sonic conductance C are converted as S.0 x C. How to HNB DCV A Rated voltage Symbol Descriptions A Rated voltage DCV VDC DCV VDC
5 HNB Series Internal structure and parts list HNB No. Parts name Core assembly Material PPS, STKM, SUS Plunger assembly SUS, NBR Spring O ring Body SUS0 NBR SUS0 (Page 0) Dimensions HNB Resin, stainless steel, nitrile rubber K S/ NP/N ø (00) PD/F/ depth M depth 6 0 ø Compact direct acting port solenoid valve
6 Compact direct acting port solenoid valve HNG Series Universal type : JIS symbol Universal type COM NCNO Specifications Item HNG Working fluid Air, water,, low vacuum (. x 0 Pa (abs)) Working pressure differential range MPa 0 to 0.7 (NO pressurization: 0 to 0.) Withstanding pressure (water) MPa.0 Fluid temperature C 0 to 0 (no freezing) Ambient temperature C 0 to 0 (no freezing) Valve seat leakage cm /min. 0 (water pressure) Mounting attitude Free Weight g 6 Orifice mm.0 Cv flow factor 0.0 C [dm /(s bar)] 0. b 0. Electric specifications Rated voltage VDC (option: VDC ) Allowable voltage fluctuation ±0% Power consumption W. Leakage current ma Heat class B *: Effective sectional area S and sonic conductance C are converted as S.0 x C. How to HNG DCV A Rated voltage Symbol Descriptions A Rated voltage DCV VDC DCV VDC
7 HNG Series Internal structure and parts list HNG NO COM NC No. Parts name Core assembly Plunger assembly Spring O ring Body Material PPS, STKM, SUS SUS, NBR SUS0 NBR SUS0 Resin, stainless steel, nitrile rubber K Dimensions HNG (Page 0) S/ NP/N NO ø (00) PD/F/ depth COM M depth 6 NC 0 ø Compact direct acting port solenoid valve
8 USB Series Compact direct acting port solenoid valve USB Series NC (normally closed) type : JIS symbol NC (normally closed) type Specifications Item USB USB Working fluid Air, water,, low vacuum (. x 0 Pa (abs)) Working pressure differential range MPa 0 to to 0. Withstanding pressure (water) MPa. Fluid temperature C 0 to 60 (no freezing) Ambient temperature C 0 to 0 Valve seat leakage cm /min. 0. (pneumatic pressure) Mounting attitude Free Weight kg 0.07 Orifice Cv flow factor C [dm /(s bar)] b mm Electric specifications Rated voltage VDC, VDC (option: 00 VAC 0/60 Hz, 00 VAC 0/60 Hz) Allowable voltage fluctuation ±0% Power consumption W DC AC Heat class B *: use with water when the solenoid valve is not used for a long time, the high corrosion resistant solenoid valve HB Series (page 807) is recommended. *: Effective sectional area S and sonic conductance C are converted as S.0 x C. How to USB 0 DCV A Orifice B Body/ sealant combination Symbol Descriptions A Orifice ø.0 ø. B Body/sealant combination Body Sealant Blank L 0 Brass Treatment Oil free C Voltage C Voltage DCV DCV AC00V AC00V Std. Option VDC VDC 00 VAC 0/60 Hz 00 VAC 0/60 Hz
9 USB Series Internal structure and parts list USB 9 0 Dimensions USB (Page 0) No. Parts name Clip Bonnet Sub core Core assembly Coil assembly 6 Plunger assembly 7 Waving washer 8 Core B 9 O ring 0 Plunger spring Body ( ) shows option. Material PBT SPC SPC SUS0 or equivalent, SUS6L SUS0 or equivalent, SUS0, NBR S6CM SUM NBR SUS0 SUS0 (C60) PBT, nitrile rubber Free cutting steel (brass) K S/ NP/N ø0. (00) PD/F/ 7 M depth 6 8 depth ø0 (0) 0 Lead wire Rectification stack The alternating current (AC) type has a rectification stack assembled into the lead wire. Compact direct acting port solenoid valve
10 USB Series Compact direct acting port solenoid valve USB Series NC (normally closed) type : Rc/8 JIS symbol NC (normally closed) type Specifications Item USB6 USB6 USB6 Working fluid Air, water,, low vacuum (. x 0 Pa (abs)) Working pressure differential range MPa 0 to to 0. 0 to 0. Withstanding pressure (water) MPa Fluid temperature C 0 to 60 (no freezing) Ambient temperature C 0 to 0 Valve seat leakage cm /min. 0. (pneumatic pressure) Mounting attitude Free Weight kg 0. Rc/8 Rc/8 Rc/8 Orifice mm.6.. Cv flow factor C [dm /(s bar)] b Electric specifications Rated voltage VDC, VDC (option: 00 VAC 0/60 Hz, 00 VAC 0/60 Hz) Allowable voltage fluctuation ±0% Power consumption W DC AC Heat class E (molded coil: B) *: use with water when the solenoid valve is not used for a long time, the high corrosion resistant solenoid valve HB Series (page 807) is recommended. *: Effective sectional area S and sonic conductance C are converted as S.0 x C. How to USB 6 B DCV A Orifice Symbol A Orifice ø.6 ø. ø. Descriptions Rc/8 B Body/sealant/coil combination B Body/sealant/coil combination Body Sealant Std. Brass Fluoro rubber Stainless steel Fluoro rubber Blank B V D E W H J L M Option Brass Stainless steel Fluoro rubber Fluoro rubber Coil Taped Molded coil Taped Molded coil Treatment Vacuum inspection * Vacuum inspection * Oil free C Voltage C Voltage DCV DCV AC00V AC00V Std. Option VDC VDC 00 VAC 0/60 Hz 00 VAC 0/60 Hz *: option symbols V and W, vacuum is inspected at "leakage amount:. x 0 6 Pa m /s ".
11 USB Series Internal structure and parts list USB6 9 0 Dimensions USB6 (Page 0) No. Parts name Material Clip Bonnet Bonnet piece Core assembly Plunger assembly Coil assembly Waving washer Core B O ring Plunger spring Body PBT SPC SPC SUS6, SUS0 or equivalent SUS0 or equivalent, NBR (FKM) S6CM SUM NBR (FKM) SUS0 C60 (SUS0) ( ) shows option. PBT, nitrile rubber (fluoro rubber) Free cutting steel (fluoro rubber) Brass (stainless steel) K S/ NP/N ø (00) PD/F/ ø 8 8 Rc/8 M depth 6 Lead wire 0 (00) Rectification stack The alternating current (AC) type has a rectification stack assembled into the lead wire. Compact direct acting port solenoid valve
MYB1/MYG1 Series DC12V. Metal free 2, 3 port solenoid valve for chemical liquid
Metal free, port solenoid valve for chemical liquid MY/MYG Series NC (normally closed) type, universal type Working fluid: water, pure water, chemical liquids Port size: M JIS symbol MY ( port) : NC (normally
Discrete direct acting 3 port solenoid valve (general purpose valve) AG31/AG41 Series. Universal type Port size: Rc1/8, Rc1/4, Rc3/8
G3141 Series iscrete direct acting 3 port solenoid valve (general purpose valve) G31/G41 Series Universal type Port size: Rc1/8, Rc1/4, Rc3/8 JIS symbol G31/41: Universal type COM NO NC Common specifications
NO (normally closed) type Common supply type (port C pressurization) MPa MPa MPa C C
Direct acting port solenoid valve, manifold and actuator (general purpose valve) NO (normally closed) type Common supply type (port C pressurization) Manifold circuit structure Common specifications B
PD3/PDV3-20A/25A/40A Series
Pilot operated 2-port valve for dust collector control (Large port size dust collector valve) PD3/PDV3-20A/25A/40A Series Air operated/with solenoid valve Port size: Rc3/4, Rc1, : Rc1 1 /2-: φ48, Rc1 1
General purpose direct acting 2, 3 port solenoid valve
eneral purpose direct acting, 3 port solenoid valve (eneral purpose valve) eneral purpose Direct acting, 3 port solenoid valve / Pilot operated/pilot kick type port solenoid valve P/D/PK/DK Page 9 9 P/
Discrete direct acting 3 port solenoid valve (general purpose valve) Universal type Port size: Rc1/8, Rc1/4, Rc3/ to to 60 B
G31/41 Series iscrete direct acting 3 port solenoid valve (general purpose valve) G31/41 Series Universal type Port size: Rc1/8, Rc1/4, Rc3/8 Refer to nding 17 for more details. JIS symbol G31/41: Universal
HVB/HVL. Solenoid valve for high vacuum. For vacuum, inert gas, air, nitrogen CONTENTS. Overview
HV/HVL For vacuum, inert gas, air, nitrogen HN/G US/G F/G Overview dvanced technology, such as stability in the leak amount (vacuum holding force) and increased seal life, is required when the degree of
Discrete direct acting 2 port solenoid valve (general purpose valve) AB31 AB41 Series NC (normally closed) type AB42 Series NO (normally open) type
31414 Series iscrete direct acting port solenoid valve (general purpose valve) 31 41 Series NC (normally closed) type 4 Series NO (normally open) type Port size: Rc1/8 to Rc1/ JIS symbol Common specifications
Pilot operated 2 port solenoid valve (general purpose valve) AP11/AP12 Series. Air, water, kerosene, oil (50 mm 2 /s or less) -10 to to 60 B
Pilot operated port solenoid valve (general purpose valve) P/P Series NC (normally closed) type, NO (normally open) type Port size: Rc/4 to Rc Piston structure Refer to Ending 7 for more details. JIS symbol
Pilot kick type 2 port solenoid valve for dry air (general purpose valve) ADK11-Z Series. NC (normally closed) type
Pilot kick type 2 port solenoid valve for dry air (general purpose valve) DK11-Z Series NC (normally closed) type Port size: Rc1/4 to Rc1 Diaphragm structure JIS symbol NC (normally closed) type OUT IN
Discrete direct acting 3 port solenoid valve (general purpose valve) NC pressurization type. Port size: Rc1/8, Rc1/4, Rc3/8
iscrete direct acting 3 port solenoid valve (general purpose valve) 33/43 Series pressurization type Port size: Rc1/8, Rc1/4, Rc3/8 Refer to nding 17 for more details. JIS symbol 33/43: pressurization
CVE2/CVSE2 CVE3/CVSE3
Overview This is a reliable 2, 3 port coolant valve with cylinder drive method. This valve for tool machine cutting oil or coolant control incorporates a metal seal to prevent the entry of cutting chips,
AB41E4-Z Series. Pressure and explosion proof structure d2g4 (flame-proof grade 2, ignitability G4) NC (normally closed) type. Port size: Rc1/4, Rc3/8
Explosion proof type direct acting port solenoid valve for dry air (general purpose valve) B41E4-Z Series Pressure and explosion proof structure dg4 (flame-proof grade, ignitability G4) Port size: Rc1/4,
New Products COMPACT PILOT OPERATED SOLENOID VALVE FOR WATER. Lightweight and large flow rate, low power consumption Improved corrosion resistance!
New Products Compact Pilot Operated Solenoid Valve for Water FWD Series New Product COMPACT PILOT OPERATED SOLENOID VALVE FOR WATER Lightweight and large flow rate, low power consumption Improved corrosion
Discrete air operated 2 port valve (compact cylinder valve) NC (normally closed) type
N Series Discrete air operated port valve (compact cylinder valve) N* Series N (normally closed) type, NO (normally open) type, double acting type Port size: Rc/, Rc/ Working fluid: air, water, gas JIS
Pilot operated 2 port valve for dust collector control (pulsejet valve) Common specifications Air operated type. Solenoid valve mounted type Item OUT
PD3/PDV3 Series Pilot operated 2 port valve for dust collector control (pulsejet valve) PD3/PDV3 Series Air operated type, solenoid valve mounted type Port size: Rc3/4, Rc1, : Rc1 1/2 - : ø48, Rc1 1/2
5 Port Direct Operated Poppet Solenoid Valve, Rubber Seal
Port Direct Operated Poppet Solenoid Valve, Rubber Seal Series 3000 or details about certified products conforming to international standards, visit us at www.smcworld.com. C: 0.4 dm 3 /(s bar) (Passage
GENERAL PURPOSE VALVE AB31 AB41 AB42 SERIES Discrete valve. Direct acting poppet structure Port size : Rc1/8, Rc1/4, Rc3/8, Rc1/2.
Series port direct acting solenoid valve : Open when energized, close when energized NRL PURPOS VLV SRIS iscrete valve irect acting poppet structure Port size : Rc/, Rc/, Rc/, Rc/ JIS symbol / (normally
Compact Direct Operated 2/3 Port Solenoid Valve for Water and Air
Compact Direct Operated / Port Solenoid Valve for Water and Air 0/0/0: Port, 00/00: Port 0/0/0 -port type has been remodeled to new compact and lightweight series. For details about new series, refer to
5 Port Solenoid Valve Direct Operated Poppet Type. Specifications
Port Solenoid Valve Direct Operated Poppet Type 000 Series Rubber Seal [Option] C: 0. dm /(s bar) (Passage {/ / (A/B R/R)}) Compact: Width 8 x Length 8 (mm) Low power consumption W DC (Standard type) W
3 Port Solenoid Valve Direct Operated Poppet Type
3 Port Solenoid Valve Direct Operated Poppet Type VK300 Series Rubber Seal [Option] Universal porting Available for N.C. valve, N.O. valve, divider valve, selector valve, etc. C: 0.80 dm 3 /(s bar) (Passage
Compact Proportional Solenoid Valve
Compact Proportional Solenoid Valve Series Repeatability: % or less Hysteresis:1% or less Fluid Flow rate control range Note) Series Air, Inert gas to L/min to L/min Note) Varies depending on the model.
Vacuum applications possible (up to 100kPa) Base mounted. Cylinder bore size (mm) Series CM2. Pressure: 0.5MPa Load ratio: 50% Cylinder stroke: 300mm
4 Port Direct Operated Poppet Solenoid Valve Series D1000 High speed coil with stable response times ON: 4ms, OFF: 2ms, Dispersion accuracy: ±1ms (With light and surge voltage suppressor at a supply pressure
5 Port Solenoid Valve Direct Operated Poppet Type. Specifications
Port Solenoid Valve Direct Operated Poppet Type Series 000 Rubber Seal [Option] C: 0. dm /(s bar) (Passage {/ / (A/B R/R)}) Compact: Width 8 x Length 8 (mm) Low power consumption W DC (Standard type) W
Body width of 10mm, Nl/min (49.08) 2W (Standard) Nl/min (78.52) 4W (U type: Large flow) Vacuum applications possible (up to 100kPa) 3 S.
High speed coil with stable response times ON: 4ms, OFF: 2ms, Dispersion accuracy: ±1ms (With light and surge voltage suppressor at a supply pressure of 0.5MPa, subject to clean, dry air) 4 Port Direct
3MA0/3MB0. Small pneumatic valve. 3 port direct acting valve CONTENTS. Space saving Valves are compactly designed with widths of 10 mm
M0/MB0 Small pneumatic valve M Overview The M0 and MB0 Series port valve is a 0 mm wide miniature direct-acting poppet valve compatible with system downsizing. variety of types, including discrete and
MICRO EJECTORS ME12, ME25, ME60. Specifications. Mass MICRO EJECTORS. Vacuum switches. Micro ejectors. Single and twin solenoid valves.
ME12, ME25, ME60 Specifications Micro ejectors Media Operating pressure range MPa [psi.] Operating temperature range C [ F] Nozzle diameter Note mm [in.] kpa [in.hg] flow rate Note R/min [ft. 3 /min.]
3 Port Solenoid Valve Pilot Operated Poppet Type. External pilot
3 Port Solenoid Valve Pilot Operated Poppet Type Series VG342 Rubber Seal [Option] Low power consumption 4.8 W DC (Standard type) 2 W DC (Energy-saving type) No lubrication required Possible to use in
Energy efficiency and Flow
Energy efficiency and Flow or more Estimating figure with ø6 push-in fittings Primary pressure: 0.5MPa Secondary pressure: Release to atmospheric pressure Oil-prohibition type Suitable for oil-restricted
Pilot Operated 2 Port Solenoid Valve for Dry Air
Pilot Operated Port Solenoid Valve for Dry Air Series VQ0/30 Compact and lightweight with large flow capacity VQ0 Mass (g) 46 80 C [dm 3 /(s bar)].5 (C8) 3.0 (C) Series VQ0 High frequency operation possible
3 Port Solenoid Valve
Port Solenoid Valve V00 Series Rubber Seal Power consumption 0. W (with power saving circuit) Note) Refer to page 7 for details. temperature rises: C (with power saving circuit) Sonic conductance Series
Pilot Operated 2 Port Solenoid Valve for Dry Air
Pilot Operated Port Solenoid Valve for Dry ir VQ0/30 Series Compact and lightweight with large flow capacity [Option] VQ0 Weight (g) 46 80 C [dm 3 /(s bar)].5 (C8) 3.0 (C) Series VQ0 Series VCH VDW SX0
Series VZ Port Solenoid Valve Body Ported. How to Order VK VZ VF VFR VP4 VZS VFS VS4 VQ7 EVS VFN Type of actuation. Option.
Port Solenoid Valve Body Ported Series 000 For details about certified products conforming to international standards, visit us at www.smcworld.com. Type of actuation Type of actuation Body option Body
4F0/1/2/3 Series. Min. working pressure MPa Refer to the individual specifications below to 60 Lubrication Not required (when lubricating,
MNE0 M MN W L/ QV JIS symbol 5 port valve position single solenoid position double solenoid position all ports closed position //R connection position P// connection Common specifications Descriptions
Series VZ Port Solenoid Valve Body Ported. How to Order VK VZ VF VFR VP4 VZS VFS VS4 VQ7 EVS VFN. Body ported VZ L
Port Solenoid Valve Body Ported Series 000 For details about certified products conforming to international standards, visit us at www.smcworld.com. Type of actuation Type of actuation Rated voltage Body
Series VKF300 VV061 V100 S070 VQD VKF VK VT VS
Rubber Seal 3 Port Solenoid Valve Series VKF300 Direct Operated Poppet Type Compact yet provides a large flow capacity Body width 18 mm Various manifold piping directions Output port: Manifold set-up allowing
Series VZ Port Solenoid Valve Body Ported. How to Order VK VZ VF VFR VP4 VZS VFS VS4 VQ7 EVS VFN. Body ported VZ L
Port Solenoid Valve Body Ported Series 000 For details about certified products conforming to international standards, visit us at www.smcworld.com. Type of actuation Type of actuation Rated voltage Body
3 Port Solenoid Valve Direct Operated Poppet Type 02 1 G VT325. For manifold: Enter VO. Valve option. Nil Standard V For vacuum Option.
3 Port Solenoid Valve Direct Operated Poppet Type Series VT325 Rubber Seal [Option] Note) Applicable only for DIN terminal type. Compact yet provides a large flow capacity Dimensions (W x H x D) 55 x 118
Series VP4 50/4 70. Large Size 5 Port Solenoid Valve Rubber Seal SJ SY SY SV SYJ SZ VF VP4 S0700 VQ VQ4 VQ5 VQC VQC4 VQZ SQ VFS VFR VQ7 VP4
Type of actuation 4 Piping 0 Side ported Bottom ported 4 Without sub-plate Large Size 5 Port Solenoid Valve Rubber Seal Series 50/4 70 Series VP 5 port solenoid valve 5 7 position single position double
PDVE4 Series PDVE4 20A 3T AC100V. Explosion proof 2 port solenoid valve for dust collector control (explosion proof pulsejet valve)
Explosion proof port solenoid valve for dust collector control (explosion proof pulsejet valve) PDVE Series Pressure and explosion proof structure dg (flame-proof grade, ignitability G) NC (normally closed)
5.0 MPa Pilot Operated 2/3 Port Solenoid Valve & Check Valve
5.0 MPa Pilot Operated /3 Port Solenoid Valve & Check Valve VCH Series VCH4/4: Port VCH40: 3 Port VCHC40: Check Valve Pilot Operated Port Solenoid Valve [Option] VCH40 Series Stable responsiveness Response
Exhausting equipment for pilot valve not required. Common exhaust port for main and pilot valve (VF1000/3000)
5 Port Pilot Operated Solenoid Valve Rubber Seal Series 1000/3000/5000 Large flow capacity Yet compact size. Low power consumption 1.8 W (DC) Exhausting equipment for pilot valve not required. Common exhaust
1 Pneumatics. Transmitters VR4151 VR4152 VR1210 VR1220 VR1210F VR1220F VR1211F VR VR3200 VR3201 VR3100 VR3110
Best 1 Pneumatics Transmitters Relay valve P. 1900 Side piping: 30 x 53 x 91 Bottom piping: 30 x 8 x 91 VR151 VR152 Effective area (mm 2 ) Number of ports Function 7 5 Metal Spool Shuttle valve P. 1902
Indicate VO for manifold. Port size. Nil 1/8 02 1/4. Specifications. Option Description Bracket (With screw) Part no. DXT060-27A
1 3 Port Air Operated Valve Series VTA301 JIS Symbol VTA 301 Indicate VO for manifold. Port size Specifications How to Order Without connection port (For manifold) 01 1/8 02 1/4 Option Fluid Air Operating
VX Z. Zero Differential Pressure Type Pilot Operated 2 Port Solenoid Valve VXZ22/23. For Air, Water, Oil. New. Series
Zero Differential Pressure Type Pilot Operated Port Solenoid Valve For Air, Water, Oil Reduced power consumption ( spec.) VXZ: 8 W 7 W VXZ:.5 W.5 W New VX Z Z Series VXZ/ CAT.ES7-A Solenoid valves for
Fluid Internal pilot Operating pressure range (MPa) External pilot Operating pressure range (MPa) 2 position single
Valve Manifold Common Specifications Solenoid Valve Specifications Made to Order Specifications (For details, refer to page --08.) JIS Symbol position single solenoid position double solenoid position
5 Port Pilot Operated Solenoid Valve Rubber Seal. Specifications Fluid Operating pressure range (1) Response time 3 position (2) Enclosure
For details about certified products conforming to international standards, visit us at www.smcworld.com. Port Pilot Operated Solenoid Valve Series 000 Compact and lightweight: 3 mm width Compact yet provides
2 port pilot operated solenoid valve
General purpose solenoid valve port pilot operated solenoid valve KZV3 Series General purpose solenoid valve for steam and water Features Heat-resistance and water-proof molded coil are used (heat resistance
Design and selection. Installation and adjustment
High vacuum components Safety precautions lways read this section before starting use. Refer to Intro 9 for the general cautions. Design and selection 1. Confirming specifications. Selection WRNING Incorrect
MULTISTAGE MICRO EJECTORS CONTENTS ACCESSORIES GENERAL CATALOG AIR TREATMENT, AUXILIARY, VACUUM, AND FLUORORESIN PRODUCTS. Caution
ACCESSORIES GENERAL CATALOG AIR TREATMENT, AUXILIARY, VACUUM, AND FLUORORESIN PRODUCTS MULTISTAGE MICRO EJECTORS CONTENTS MED07-E, MED10-E Series Specifications 715 Order Codes 716 Operation Principle
EV2100V Series OUT VAC EV2100V. Specifications. 196kPa 196kPa Control pressure range Assured pressure range Power voltage Current consumption
pneumatic regulator (solenoid type for vacuum) EVV Series JIS symbol EVV CAD DATA AVAILABLE. How to order Overview For electro pneumatic regulator EVV series, feedback control with semiconductor pressure
3 Port Solenoid Valve Direct Operated Poppet Type. Body type. Body ported. Manifold. Valve option
Port Solenoid Valve Direct Operated Poppet ype Series V17 Rubber Seal [Option] Compact yet provides a large flow capacity Dimensions (W x H x D) 45 x 89.5 x 45 (Grommet) C:.6 dm /(s bar) (Passage ) Suitable
Plug-in manifold W4G4 Series
Low profile Plug-in manifold W4G4 Series PLUG-IN MANIFOLD W4G4 SERIES Easier to use with additional options CC-845A Do more with less Less power consumption, less man hours, less footprint, allowing you
Transmitters: Relay Valve
Relay Valve VR5/5 Series Appropriate output sequences are affected according to the signal received from the mechanical valve. It is equivalent to the auxiliary relay of an electrical system. Specifications
Manual override. Non-locking push type (Tool required) Nil: B: Locking type (Tool required) C: Locking type (Manual) Electrical entry
Plug-in nit Series 0 1 2 3 4 Series Type of actuation Metal Rubber 2 position single 3 position closed 3 position pressure Manifold Option How to Order Valves VQ 1 1 1 0 Y 5 LO Body type 1 0 1 Seal Metal
3-in-1 package (solenoid valve + governor + solenoid valve) realizes compact piping in double shutoff application.
CC-1104A GHV Series 3-in-1 package (solenoid valve + governor + solenoid valve) realizes compact piping in double shutoff application. Main features Space-saving integrated structure Two solenoid valves
Series SV1000/2000/3000/4000
Valve/Sub-plate Type IP67 Compliant Series 000/000/000/000 How to Order C () () () () () () (E) (E) () (E) (E) () () (E) (E) () () (E) (E) () () (E) (E) Type of actuation position single position double
Process Valve. 2 Port Valve For Compressed Air and Air-hydro Circuit Control
Process Series Port For Compressed Air and Air-hydro Circuit Control Exclusively for air pressure system and air-hydro circuit control Universal Port Cylinder actuation by external air he balance poppet
5.0 MPa Pilot Operated 2/3 Port Solenoid Valve & Check Valve
5.0 MPa Pilot Operated / Port Solenoid Valve & Check Valve Series VCH VCH4/4: Port VCH40: Port VCHC40: Check Valve Pilot Operated Port Solenoid Valve Series VCH40 Stable responsiveness Response time dispersion
2/3 Port Valve for Various Fluids Control
Equipment for Fluid Control 2/ Port Valve for Various Fluids Control 2/ Port Solenoid/ir Operaed Valve for Various Fluids Control (For Water/ir/Oil/Gas/Vacuum/Steam) 2/ Port Solenoid Valve Direct operated
MULTISTAGE MICRO EJECTORS
MULTISTAGE MICRO EJECTORS MED07-E, MED10-E Specifications Basic model Item Media Operating pressure range MPa [psi.] Proof pressure MPa [psi.] Operating temperature range (atmosphere and media) C [ F]
Series VP3145/3165/3185
Large Size 3 Port Solenoid Valve Series VP345/365/385 Rubber Seal Large flow capacity, small exhaust resistance (Refer to Flow Characteristic table.) Easy conversion to N.C. or N.O. Function plate makes
3 Port Solenoid Valve
Rubber Seal Port Solenoid Valve Series Manifold Single Unit ase Mounted Manifold VV01 V100 ar base P.18 ody Ported P.10 ase Mounted P.10 VQD VKF VK VT VS Separable base ody Ported Manifold P.1 Stacking
3 Port Air Operated Valve
Port Air Operated Valve 00/500/00 Series RoHS 1555 00/500/00 Series Model Selection by Operating Conditions q Air Operated Valve: Single Unit Series Sonic conductance C [dm /(s bar)] Type of actuation
MMD. Chemical liquid manual valve/toggle valve/flow control valve. Overview. Features FMD00
Chemical liquid manual valve/toggle valve/flow control valve MMD Overview This chemical liquid manual valve for semiconductor manufacturing equipment is available in 1/8 to 1 inch port sizes and different
Specifications. Fluid Ambient and fluid temperature ( C)
Series 0-V00 Rubber seal port direct operated solenoid valve Specifications Fluid Ambient and fluid temperature ( C) Note ) Response time (DC) ms Max. operating frequency (Hz) Manual override Lubrication
1.8 w. 3 Port Solenoid Valve. VT307 Series. Direct Operated Poppet Type. Power consumption. A single valve with various valve functions
Port Solenoid Valve VT07 Series Direct Operated Poppet Type Power consumption 4 Standard wtype (Current product: 4.8 W) Energy-saving type.8 w (Current product: 2 W) Vacuum applications 0.2 kpa [Option]
3 Port Solenoid Valve Direct Operated Poppet Type. Body type. T Body ported O Manifold. Valve option
3 Port Solenoid Valve Direct Operated Poppet Type VT317 Series Rubber Seal [Option] Note) CE-compliant: Electrical entry is applicable only for the DIN terminal. Compact yet provides a large flow capacity
5.0 MPa Pilot Operated 2/3 Port Solenoid Valve & Check Valve
5.0 Ma ilot Operated /3 ort Solenoid Valve & Check Valve Series VCH VCH4/4: ort VCH40: 3 ort VCHC40: Check Valve ilot Operated ort Solenoid Valve [Option] Series VCH40 Stable responsiveness Response time
Direct acting 3-port valve 3Q Series
New Products Direct acting -port valve Q Series Handles compact -port valve applications across the board QE/Z Series Air operated valve drive Cylinder drive Suction transport Air blow QB Series QRA/B
Series VQ Port Solenoid Valve
Port Solenoid Valve Series VQ00 Outstandingly high speed, stable response, and long service life. ON:. ms, OFF: ms, Dispension accuracy ms (; supply pressure 0. MPa) 00 million cycles or more (Factors
New Products. 3 Port Solenoid Valve with Spool Position Detection SNP Series
New roducts 3 ort Solenoid Valve with Spool osition Detection SN Series New roduct Reliable detection of open and close status by spool position detecting. Two safety cut off by modular connection! Main
Series variation. Auxiliary valve. Quick exhaust, and circuit switchover valves, etc. are available. Port size (Rc) Page. Model Product appearance
Series variation Quick exhaust, and circuit switchover valves, etc. are available Model Product appearance Model no. Port size (Rc) Page 4 dia. dia. M /8 /4 /8 / /4 /4 / QEV-A Quick exhaust valve QEV-8A
Transmitters: Relay Valve VR4151/4152
Relay Valve VR4151/4152 Appropriate output sequences are affected according to the signal received from the mechanical valve. VR4151 VR4152 Precautions Be sure to read before handling. Refer to pages 5-11-2
10 VQ F. Nil Latching type: Push-locking type (Tool required) B. Nil. Electrical entry
Series 0-VQ00 port solenoid valve How to Order Valves 0 VQ 0 F ir cylinder Clean series Series VQ Compact port valve Type of actuation Normally closed Note) Normally open Note) Normally open type is available
Flow characteristics Max. (1) b Standard Specifications. P Manual override.
Port Direct Operated Solenoid Valve Series 0 Metal Seal Model Number of positions (Single) (Double) ( position) JIS Symbol Model Port size Rc (Nominal size) 0-0 8 ( A) 0- ( 8A) 0-0 8 (0A) 0-0 8 ( A) 0-
Vacuum pump system type
type VS*P Vacuum component C O N T E N T S Series variation 166 20 mm width universal type (/M) 168 10.5 mm width universal type (/M) 184 31.5 mm width discrete type (VSQP) 214 11 mm pitch manifold dedicated
Specifications VH600. Ambient temperature and operating fluid temperature. Operating angle Lubrication. Semi-standard
Hand Valve Series VH Specifications Fluid Proof pressure Max. operating VH00/00/00 pressure VH00 Ambient temperature and operating fluid temperature Air.5 MPa.0 MPa MPa -5 to 0 C (No freezing) VH0 VH00
5 Port Pilot Operated Solenoid Valve Metal Seal, Plug-in/Non Plug-in. Flow characteristics (1) 1 4/2 (P A/B) 4/2 5/3 (A/B R1/R2)
For details about certified products conforming to international standards, visit us at www.smcworld.com. 5 Port Pilot Operated Solenoid Valve Metal Seal, Plug-in/Non Plug-in Model 2 position 3 position
Free position locking flat and compact cylinder UFCD Series
Space-saving cylinder ensures safety during work in power failures or accidents. Free position locking flat and compact cylinder UFCD Series Free position locking flat and compact cylinder UFCD Series
3 Port Solenoid Valve
Port Solenoid Valve Series VQ00 Courtesy of Steven Engineering, Inc.-0 Ryan Way, South San Francisco, C 9080-0-Main Office: (0) 88-900-Outside Local rea: (800) 8-900-www.stevenengineering.com Outstandingly
Specification. Bore No.
MVSD-180 Series Specification Bore No. Medium Operating perssure range Operating pressue () External pilot pressure () Proof pressure Effective orifice Ambient temperature Reponse time Weight E1 E 4E1
5 Port Pilot Operated Solenoid Valve Metal Seal, Body Ported. Flow characteristics 1 4/2 (P A/B) 4/2 5/3 (A/B R1/R2)
For details about certified products conforming to international standards, visit us at www.smcworld.com. 5 Port Pilot Operated Solenoid Valve Metal Seal, Body Ported Series VFS3000 Model position 3 position
5.0 MPa Pilot Operated 2/3 Port Solenoid Valve & Check Valve
5.0 MPa Pilot Operated / Port Solenoid Valve & Check Valve Series VCH VCH4/4: Port VCH40: Port VCHC40: Check Valve Pilot Operated Port Solenoid Valve Series VCH40 Stable responsiveness Response time dispersion
Specifications. Construction. Component Parts No. 1. Description. Body. Knob. Cover Cam ring Stem Spring guide Spring Seal O-ring Valve Cassette
Finger Valve Series RoHS Large effective area:.0 to 7.5 mm Small knob operating force: 0.04 to 0.4 N m Poppet valve construction seldom suffers seal defection. The series begins with the min. tubing O.D.
HMV/HSV. Manual selector valve. 4-port valve CONTENTS
4-port valve Overview The / series manual selector valves are 4-port valves with a sliding valve method for the main valve. Suitable for operating cylinders of φ0 to φ0. Features Simple ease of operation
Process Valve/Series VN
For General Purpose /3 Port Valve Process Valve/Series VN The cylinder operation by external pilot air Can be operated with pressure differential zero. Wide variations Series VNA For controlling pneumatic
0.45 ms. 9mm. High Speed 2 Port Valve. SX10 Series. 2 mounting types
Speed 2 Port Valve Series RoHS speed speed speed response response response 5 ms 9mm Width ±0.05 ms ±0.05 ms type VCH : : 5 ms * The response time is measured based on SMC test conditions. (Not guaranteed
Series VCHR. Direct Operated Regulator for 6.0 MPa (Relieving Type) Service life: 10 million cycles. How to Order
Direct Operated Regulator for (Relieving Type) Series Service life: 0 million cycles Using NSF-H-certified grease on the guide ring (sliding) part. Improved durability under a high environment with a polyurethane
Flow sensor for compressed air
for compressed air PFD/PFK (display separate type ) Sensor / CONTENTS Product introduction 1432 Applications 1434 Safety precautions 1435 (PFD)display separate type 1440 Tester kit (PFK) 1446 Electric
5.0 MPa Pilot Operated 2/3 Port Solenoid Valve & Check Valve
5.0 MPa Pilot Operated / Port Solenoid Valve & Check Valve Series VCH VCH4/4: Port VCH40: Port VCHC40: Check Valve Pilot Operated Port Solenoid Valve Series VCH40 Stable responsiveness Response time dispersion
Process Valve/Series VN The cylinder operation by external pilot air Can be operated with pressure differential zero.
For General Purpose /3 Port Valve Process Valve/Series VN The cylinder operation by external pilot air Can be operated with pressure differential zero. Wide variations Series For controlling pneumatic
5 Port Pilot Solenoid Valve/Body Ported Type Base Ported Type. Closed Center DS3330/DS3300. How to Order - Body Ported Type
5 Port Pilot Solenoid Valve/Body Ported Type Base Ported Type COMPACT SIZE AND LIGHT WEIGHT LARGE FLOW CAPACITY LOW POWER CONSUMPTION DESIGNED FOR NON-LUBRICATED SERVICE DV000 Symbol Single DS330/ How
SOLENOID VALVES, SERIES
VALVES GENERAL CATALOG SOLENOID VALVES, SERIES INDEX Features 365 Basic Models and Configuration 366 Solenoid Valve Order Codes 367 Manifold Order Codes 368 112 Series Specifications 369 Operating Principles
Series VVXA21/22. Direct Air Operated 2 Port Valve/Manifold For Air, Gas, Vacuum and Oil VC VDW VQ VX2 VX VX3 VXA VN LVC LVA LVH LVD LVQ LQ LVN PA PAX
The VX series will be revised shortly. 1 Direct Operated 2 Port Valve/ For, Gas, Vacuum and Oil Series VVXA21/22 Common SUP type and individual SUP type (for vacuum use) standard models Compatible with
Balanced Valve Series Multi-Purpose Direct-Acting Solenoid Valves
Balanced Valve Series Multi-Purpose Direct-Acting Solenoid Valves www.humphrey-products.com Humphrey Products Company P.O. Box 008 Kalamazoo, MI 4900 USA P.69.8.5500 F.69.8.4 BVSa-07 A privately owned
Flow sensor for compressed air
for compressed air PF-F/PFU (display integrated type ) Sensor / Overview Compressed air consumption could reach 1/5 of energy used in manufacturing plant. Controlling air is very important for energy saving.
3 Port Air Operated Valve VTA. Indicate VO for manifold. Port size. Nil 02 1/4. Specifications Fluid. Option Description Bracket (With screw)
Series VTA301 How to Order VTA 301 Indicate VO for manifold. Port size Without connection port (For manifold) 01 1/8 02 1/4 F N T Option B Rc G NPT NPTF Without bracket Foot bracket JIS Symbol Specifications
5 Port Pilot Operated Solenoid Valve Metal Seal, Body Ported
For details about certified products conforming to international standards, visit us at www.smcworld.com. 5 Port Pilot Operated Solenoid Valve Metal Seal, Body Ported Series VFS2000 Model 2 position 3
Linear slide cylinder Double acting single rod type. Bore size: 4.5, 6, 8. Descriptions Bore size mm
Linear slide cylinder Double acting single rod type LCM Series Bore size:.5, 6, 8 JIS symbol Specifications Descriptions LCM Bore size mm.5 6 8 Actuation Double acting Working fluid Compressed air Max.