2005 AND 2006 MATRIX / MATRIX XX
|
|
|
- Thomasina Kelly
- 5 years ago
- Views:
Transcription
1 2005 AND 2006 MATRIX / MATRIX XX
2 INDEX ENGINE FRAME SECTION FIG # HEAD LIGHT F01 SECTION FIG # SPEEDOMETER F02 FAN COVER SHROUD E01 HANDLE LEVER/SWITCH/CABLE F03 CYLINDER HEAD E02 FR. MASTER CYLINDER F04 CAMSHAFT E03 STEERING HANDLE/HANDLE COVER F05 CAMSHAFT TENSIONER E04 FR. COVER/INNER BOX F06 CYLINDER HEAD COVER E05 FR. FENDER F07 CYLINDER E06 STTERING STEM F08 CRANKSHAFT PISTON E07 FR. FORK F09 RIGHT CRANKCASE COVER E08 FR. BRAKE CALIPER F10 LEFT CRANKCASE COVER E09 FR. WHEEL F11 GENERATOR OIL PUMP E10 RR, WHEEL F12 STARTING MOTOR, CLUTCH E11 SEAT F13 DRIVER, STARTER E12 FLOOR SIDE COVER/UNDER COVER F14 BELT, DRIVEN PULLEY E13 FUEL TANK F15 REAR DRIVE SET E14 BATTERY F16 CRANKCASE E15 LUGGAGE BOX F17 CARBURETOR E16 CENTER COVER/BODY COVER F18 AIR CLEANER/FLOOR PANEL F19 EXHAUST MUFFLER F20 MAIN STAND/KICK STARTER ARM F21 RR. CUSHION F22 FR. TURN SIGNAL F23 RR. COMBINATION LIGHT F24 WIRE HARNESS/IGNITION COIL F25 FRAME BODY F26 REAR BRAKE ASSY F28 MATRIX XX PLASTICS F29 MATRIX XX PLASTICS 2 F30 MIRRORS & SEAT & RR CARRIER F31
3 CONTENTS ENGINE GROUP E01 FAN COVER SHROUD E02 CYLINDER HEAD E03 CAMSHAFT E04 CAMSHAFT TENSIONER E05 CYLINDER HEAD COVER E06 CYLINDER E07 CRANKSHAFT PISTON E08 RIGHT CRANKCASE COVER E09 LEFT CRANKCASE COVER
4 E10 GENERATOR OIL PUMP E11 STARTING MOTOR, CLUTCH E12 DRIVER, STARTER E13 BELT, DRIVEN PULLEY E14 REAR DRIVE SET E15 CRANKCASE E16 CARBURETOR
5 CONTENTS FRAME GROUP F01 HEAD LIGHT F02 SPEEDOMETER F03 HANDLE LEVER/SWITCH/CABLE F04 FR. MASTER CYLINDER F05 STEERING HANDLE/HANDLE COVER F06 FR. COVER/INNER BOX F07 FR. FENDER F08 STEERING STEM F09 FR. FORK
6 F10 FR. BRAKE CALIPER F11 FR. WHEEL F12 RR. WHEEL F13 SEAT F14 FLOOR SIDE COVER/UNDER COVER F15 FUEL TANK F16 BATTERY F17 LUGGAGE BOX F18 CENTER COVER/BODY COVER
7 F19 AIR CLEANER/FLOOR PANEL F20 EXHAUST MUFFLER F21 MAIN STAND/KICK STARTER F22 RR. CUSHION F23 FR. WINKER F24 RR. COMBINATION LIGHT F25 WIRE HARNESS/IGNITION COIL F26 FRAME BODY
8 E01 FAN COVER/SHROUD REF PART NUMBER DESCRIPTION QTY T COVER BREATHE T CLAMPER, OIL DRAIN HOSE T BOLT T SHROUD, BELOW T SEAL, BELOW GB ST SCREW, TAPPING 4.8 X 16-F-H T SEAL, TAPPING T RUBBER GROMMET T CLIP, HIGH TENSION CORD T CLIP, HIGH TENSION CORD T SHROUD ASSEMBLY, VP T BREATHER HOSE T CLAMPER, STARTER CABLE T GROMMET, OBSIVE /06 Enlarged figure next page
9 E01 FAN COVER/SHROUD
10 E02 CYLINDER HEAD REF# PART # DESCRIPTION QTY T CYLINDER HEAD ASSEMBLY T CAMSHAFT HOLDER T WASHER, CYLINDER HEAD T NUT, CYLINDER HEAD T SPARK PLUG T CARBURETOR GASKET T INSULATOR, CARBURETOR T O-RING 18 X T CARBURETOR INTAKE GB SCREW M4 X T CARBURETOR BAND TT CYLINDER HEAD GASKET T PIN, DOWEL 10 X T BOLT /06 Enlarged figure next page
11 E02 CYLINDER HEAD
12 E03 CAMSHAFT REF# PART # DESCRIPTION QTY T VALVE EXHAUST T SEAL ASSEMBLY, VALVE T VALVE SPRING, VP T SPRING, VALVE OUTER T SPRING VALVE INNER T VALVE SPRING, BELOW T COTTER, VALVE T SHAFT, IN. ROCKER ARM T CAMSHAFT ASSEMBLY T SHAFT, EXHAUST ROCKER ARM T ROCKER ARM T SCREW, TAPPET ADJUSTING T NUT, TAPPET ADJUSTING T STOPPER PLATE ASSEMBLY T VALVE, INTAKE /06 Enlarged figure next page
13 E03 CAMSHAFT
14 E04 CAMSHAFT TENSIONER REF PART NUMBER DESCRIPTION QTY T TIMING CHAIN T TENSIONER ASSEMBLY T GASKET, TENSIONER LIFTER T LIFTER ASSEMBLY, TENSIONER T BOLT T O-RING T SCREW T GUIDE ASSEMBLY /06 Enlarged figure next page
15 E04 CAMSHAFT TENSIONER
16 E05 CYLINDER HEAD COVER REF PART NUMBER DESCRIPTION QTY T BREATHER HOSE, CRANKCASE T CLIP HOSE ASSEMBLY T COVER ASSEMBLY T BOLT T CLIP HOSE (10) /06 Enlarged figure next page
17 E05 CYLINDER HEAD COVER
18 E06 CYLINDER REF PART NUMBER DESCRIPTION QTY T CYLINDER ASSEMBLY T GASKET, CYLINDER T PIN, DOWEL 10 X GB WASHER COPPER GB BOLT 06 X /06 Enlarged figure next page
19 E06 CYLINDER 3 3
20 E07 CRANKSHAFT PISTON REF PART NUMBER DESCRIPTION QTY T CRANKSHAFT COMPLETE T WOODRUFF KEY T PISTON PIN T CLIP, PISTON PIN T PISTON T PISTON RING SET /06 Enlarged figure next page
21 E07 CRANKSHAFT PISTON
22 E08 RIGHT CRANKCASE COVER REF PART NUMBER DESCRIPTION QTY T COVER, R T GASKET, R. COVER T OIL SAL T SPRING, OIL SEAL T PIN, DOWEL 8 X T OIL FILTER SCREEN T SPRING, OIL FILTER SCREEN T O-RING T COVER, OIL FILTER SCREEN T BOLT T BOLT T BOLT T BOLT T CLAMPER, GENERATOR CORD T GAUGE, OIL LEVEL T O-RING T BOLT /06 Enlarged figure next page
23 E08 RIGHT CRANKCASE COVER
24 E09 LEFT CRANKCASE COVER REF PART NUMBER DESCRIPTION QTY T GASKET, L. COVER T B COVER, L T C COVER, L. CHROME T BOLT T BOLT T CLAMPER, BRAKE CABLE T HOLDER, OIL DRAIN HOSE T CLAMPER ASSEMBLY T PIN, DOWEL T PLATE, L. COVER GB ST SCREW, TAPPING 4.2 X 8-F-H /06 Enlarged figure next page
25 E09 LEFT CRANKCASE COVER
26 E10 GENERATOR OIL PUMP REF PART NUMBER DESCRIPTION QTY T BOLT T FAN, COOLING T NUT, CRANKSHAFT T GENERATOR ASSEMBLY 1 1 A-C125T STATOR ASSEMBLY 6 PHASE T STATOR ASSEMBLY 11 PHASE T BOLT GB BOLT M5 X T OIL PUMP ASSEMBLY T BOLT T SPROCKET, OIL PUMP DRIVEN GB NUT M T CHAIN, OIL PUMP T COVER, OIL PUMP GB SCREW M6 X /06 Enlarged figure next page
27 E10 GENERATOR OIL PUMP
28 E11 STARTING MOTOR, CLUTCH REF PART NUMBER DESCRIPTION QTY T STARTER MOTOR ASSEMBLY T BOLT (M6 X 16) T GEAR T STARTER REDUCTION GEAR N/A WOODRUFF KEY N/A FLANGE STARTING CLUTCH N/A SPRING N/A PIN N/A ROLLER 10 X 10 III +³/b N/A OUTER ASS'Y, STARTING CLUTCH N/A SCREW M6 X N/A BEARING N/A PIN, DOWER N/A INNER GEAR, STARTING DRIVEN T WASHER, LOCK NUT T NUT, LOCK T STARTING CLUTCH COMP /06 Enlarged figure next page
29 E11 STARTING MOTOR, CLUTCH
30 E12 STARTER CLUTCH REF PART NUMBER DESCRIPTION QTY T PLATE, SPRING STOP T FACE DRIVE T BOSS, DRIVER T FACE COMP., MOVABLE DRIVE T ROLLER SET T PLATE, RAMP T BUFFER, PLATE RAMP T GEAR, KICK DRIVEN T CLIP T IDLE GEAR COMP T SHAFT, STARTER IDLE T SPRING, STARTER IDLE T KICK SHAFT COMP T BUSH, 12 X 16 X T BUSH, 14 X 18 X T SPRING, TORSION T PIN, 4.6MM T THRUST, FLANGE, 12MM T WASHER, 14.1MM T WASHER, 12.5MM T THRUST, FLANGE, 12MM GB578F86 BOLT M ROLLER, 3 X T COLLAR T CLIP B POLE, ANCHOR M6 X 22 BOLT /06 Enlarged figure next page
31 E12 STARTER CLUTCH
32 E13 BELT, DRIVEN PULLEY REF PART NUMBER DESCRIPTION QTY T OUTER CLUTCH T PLATE COMP DRIVE T COCER, CLUTCH T SPRING CLUTCH T WEIGHT CLUTCH T DAMPER COMP T V-BELT T LEFT COMP, DRIVEN T PIN, ROLLER GUIDE T ROLLER GUIDE T SPRING, DRIVEN T RIGHT SEAT, SPRING T LEFT SEAT, SPRING T NUT, FLANGE, 12MM T NUT, SPEVIAL, 28MM T WASHER, 12.2 X 25 X T CIRCLIP, 7MM T SEAL, DRIVEN PULLEY T O-RING, DRIVEN T PULLEY ASSEMBLY, DRIVEN T PLATE-ASSEMBLY, DRIVEN T RIGHT COMP., DRIVEN T BEARING, NEEDLE, 20 X T LEFT BEARING, DRIVEN GB CIRCLIP, 28MM /06 Enlarged figure next page
33 E13 BELT, DRIVEN PULLEY
34 E14 REAR DRIVE SET REF PART NUMBER DESCRIPTION QTY T COVER, REAR DRIVE T GASKET, REAR COVER T SHAFT, DRIVE T COUNTERSHAFT COMP T SHAFT, FINAL T GEAR, FINAL T BOLT M6 X T BOLT M6 X T BOLT, SPECIAL, 8MM T WASHER, 8MM T SEAL, 20 X 32 X T SPRING, SEAL T PIN, 8 X GB CIRCLIP, 20MM GB BEARING, BALL GB BEARING, BALL T L-BEARING /06 Enlarged figure next page
35 E14 REAR DRIVE SET
36 E15 CRANKCASE REF PART NUMBER DESCRIPTION QTY T CRANKCASE ASSEMBLY, R T BUSH, HANGE T GASKET T CRANKCASE ASSEMBLY, L T BLICK T BUSH HANGE T HOSE, BREATHER T STUD 8 X T STUD 8 X T R-BEARING GB BEARING, BALL GB BEARING SEAL T SEAL, 27 X 42 X T SPRING, SEAL T PIN, DOWER 8 X T NBOLT M6 X T SEAL, 19.8 X 30 X T SPRING, SEAL T PIN, BRAKE SHOE T O-RING 7.5 X T NUT, FLANGE 8MM T DRAIN PLUG 12MM T WASHER, PLUG 12MM /06 Enlarged figure next page
37 E15 CRANKCASE
38 E16 CARBURETOR REF PART NUMBER DESCRIPTION QTY 16-1 ORDER REF GASKET SET T VALVE SET, FLOAT ORDER REF NEEDLE SET ORDER REF FLOAT CHAMBER ORDER REF CHAMBER SET, FLOAT ORDER REF SCREW SET A T SCREW SET B ORDER REF PLATE SET, VALVE ORDER REF VALVE SET, STARTER T VALVE SET, AIRCUT ORDER REF SPRING ORDER REF SCREW, PAN, 5 X T CARBURETOR ASSEMBLY ORDER REF TOP COMP T PISTON COMP, VACUUM T HOLDER, JET ORDER REF BINDER ORDER REF CAP, STARTER ORDER REF HOSE ORDER REF HOSE ORDER REF SCREW, PAN 4 X ORDER REF SCREW, PAN 4 X ORDER REF SCREW-WASHER, 4 X ORDER REF SCREW-WASHER, 5 X ORDER REF CLIPB ORDER REF CLIPB ORDER REF HOSE, 4 X T JET, MAIN # T JET, SLOW # /06 Enlarged figure next page
39 E16 CARBURETOR
40 F01 HEAD LIGHT REF PART NUMBER DESCRIPTION QTY SA-0000 HEAD LIGHT ASSEMBLY KN COVER, RUBBER SA UNIT, HEAD LIGHT SA SOCKET COMP HEAD LIGHT KN SOCKET POSITION LIGHT RUBBER JOINT KN BULB, HEAD LIGHT BM0T000 BULB, HEAD LIGHT 2006 XX MODEL KCK-9000 BULB MARKER LIGHT (12V 4W) BOLT FLANGE 6 X KV COLLAR HD/LT HOUSING BOLT WASHER 6 X /06 Enlarged figure next page
41 F01 HEAD LIGHT
42 F02 SPEEDOMETER REF PART NUMBER DESCRIPTION QTY GA77010M1 BULB WEDGE BASE (12V 3.4W) MB98710M1 BULB WEDGE BASE (12V 1.7W) SA SPEEDOMETER ASSEMBLY SA1-RC00 SPEEDOMETER ASSEMBLY WITH TACHOMETER SA SPEEDOMETER COMP SA CASE ASSEMBLY SA LENS N/A NOT SOLD SEPARATELY SA SOCKET COMP KE SCREW WASHER 3 X A RELAY COMP TURN SIGNAL SA1-000H CABLE COMP SPEEDOMETER SCREW, SPECIAL WASHER /06 Enlarged figure next page
43 F02 SPEEDOMETER
44 F03 HANDLE LEVER/SWITCH/CABLE REF PART NUMBER DESCRIPTION QTY SA THROTTLE CABLE COMP GW SWITCH ASSEMBLY LIGHTING GW STARTER SWITCH GW SWITCH ASSEMBLY DIMMER GW HORN SWITCH SA HAZARD SWITCH GW TURN SIGNALS SWITCH GW SWITCH ASSEMBLY RR. STOP SA CABLE COMP RR. BRAKE SA CLAMP RR BRAKE CABLE SA THROTTLE GRIP COMP A-GN HOUSING THROTTLE SA GRIP, L. HANDLE GN HOUSING UNDER THROTTLE GN HOUSING UPPER THROTTLE A-SA BRACKET ASSEMBLY L. HANDLE GW HANDLE BRACKET GZ BAND HANDLE BRACKET GW LEFT LEVER BLACK GW4-CHR LEFT LEVER CHROME SA R. REAR VIEW MIRROR MODEL A&B SA1-00BK R. REAR VIEW MIRROR BLACK MODEL C SA1-00RD R. REAR VIEW MIRROR RED MODEL C SA1-00YW R. REAR VIEW MIRROR YELLOW MODEL C SA1-00BU R. REAR VIEW MIRROR BLUE MODEL C SA1-00MT R. REAR VIEW MIRROR MUSTARD MODEL C SA1-00OR R. REAR VIEW MIRROR ORANGE MODEL C /06 Enlarged figure next page
45 REF PART NUMBER DESCRIPTION QTY SA L. REAR VIEW MIRROR MODEL A&B SA1-00BK L. REAR VIEW MIRROR MODEL C SA1-00RD L. REAR VIEW MIRROR MODEL C SA1-00YW L. REAR VIEW MIRROR MODEL C SA1-00BU L. REAR VIEW MIRROR MODEL C SA1-00MT L. REAR VIEW MIRROR MODEL C SA1-00OR L. REAR VIEW MIRROR MODEL C GW SCREW HANDLE LEVER PIVOT BOLT WASHER 6 X SCREW PAN 5 X S NUT HEX 5MM /06 Enlarged figure next page
46 F03 HANDLE LEVER/SWITCH/CABLE
47 F04 FRONT MASTER CYLINDER REF PART NUMBER DESCRIPTION QTY MA SWITCH ASSEMBLY FR. STOP SA FR. BRAKE HOSE SA CYLINDER ASSEMBLY FR. MASTER BOOT COMP HA CAP OIL CUP GM HOLDER MASTER CYLINDER MG DIAPHRAGM HA PLATE DIAPHRAGM CYLINDER SET MASTER GW RIGHT LEVER BLACK GW4-CHR RIGHT LEVER CHROME 1 1 Enlarged figure next page KN CLIP A BRAKE HOSE GW BOLT FLANGE 6 X BOLT HANDLE LEVER GZ BOLT OIL 10 X WASHER OIL BOLT CIRCLIP INTERNAL 18 MM G SCREW PLATE 4 X SCREW WASHER 4 X NUT, FLANGE 6 MM BOLT FLANGE 6 X /06
48 F04 FRONT MASTER CYLINDER
49 F05 STEERING HANDLE/HANDLE COVER REF PART NUMBER DESCRIPTION QTY SA HANDLE COMP STEERING SA COVER ASSEMBLY HANDLE RR SA1-00RD COVER FR. HANDLE (RED) MODEL A&B SA1-00C1 COVER FR. HANDLE (YELLOW) MODEL A&B SA1-00BU COVER FR. HANDLE (BLUE) MODEL A&B SA1-00BL COVER FR. HANDLE (BLACK) MODEL A&B SA1-00SV COVER FR. HANDLE (SILVER) MODEL C SA1-00RD LID BRAKE FLUID MAINTENANCE (RED) SA1-00YW LID BRAKE FLUID MAINTENANCE (YELLOW) SA1-00BK LID BRAKE FLUID MAINTENANCE (BLACK) SA1-00BU LID BRAKE FLUID MAINTENANCE (BLUE) SA1-00SV LID BRAKE FLUID MAINTENANCE (SILVER) SA WINDOW BRAKE FLUID SA FR. HANDLE COVER R SIDE SA FR. HANDLE COVER L SIDE GE NUT, U, 10MM KM SCREW, WASHER 5 X SCREW TAPPING 5 X SCREW TAPPING 4 X SCREW TAPPING 5 X GN COLLAR HANDLE SET GN BOLT FLANGE 10 X /06 Enlarged figure next page
50 F05 STEERING HANDLE/HANDLE COVER
51 F06 FRONT COVER INNER BOX REF PART NUMBER DESCRIPTION QTY SA1-01BK COVER FR. (BLACK) SA1-00RD COVER FR. (RED) SA1-00BU COVER FR. (BLUE) SA1-00YW COVER FR. (YELLOW) SA1-00MT COVER FR. (MUSTARD) SA1-00OR COVER FR. (ORANGE) SA GRILL FR. COVER R SA GRILL FR. COVER L A-SA1-00RD FRONT COVER (RED) MODEL A & B A-SA1-00BU FRONT COVER (BLUE) MODEL A & B A-SA1-00BK FRONT COVER (BLACK) MODEL A & B A-SA1-00GY FRONT COVER (GREY) MODEL A & B A-SA1-00YW FRONT COVER (YELLOW) MODEL A & B A-SA1-SVOR FRONT COVER (ORANGE) MODEL C A-SA1-SVRD FRONT COVER (RED) MODEL C A-SA1-SVYW FRONT COVER (YELLOW) MODEL C A-SA1-SVMT FRONT COVER (MUSTARD) MODEL C A-SA1-SVBU FRONT COVER (BLUE) MODEL C A-SA1-SVBK FRONT COVER (BLACK) MODEL C SA BOX ASSEMBLY INNER SA CAP NUMBERING A-SA LID ASSEMBLY INNER BOX SA SEAL INNER BOX SA LID INNER BOX GE BOLT FLANGE 6 MM GE SCREW UPPER COVER SET 5 X GR NUT FLANGE CAP 6MM GK NUT CHIP 6 MM GR NUT CLIP 5MM SCREW WASHER 5 X SCREW TAPPING 4 X /06 Enlarged figure next page
52 F06 FRONT COVER INNER BOX
53 F07 FRONT FENDER REF PART NUMBER DESCRIPTION QTY GROMMET WIRE COLLAR FR. FENDER SA1-00GY FENDER A ASSEMBLY FR (GRAY) SA1-00YW FENDER A ASSEMBLY FR (YELLOW) SA1-RDSV FENDER A ASSEMBLY FR (SILVER/RED) SA1-SVBU FENDER A ASSEMBLY FR (SILVER/BLUE) MODEL C SA1-SVBK FENDER A ASSEMBLY FR (SILVER/BLACK) SA1-SVYW FENDER A ASSEMBLY FR (SILVER/YELLOW) SA1-SVMT FENDER A ASSEMBLY FR (SILVER/MUSTARD) SA1-SVOR FENDER A ASSEMBLY FR (SILVER/ORANGE) MODEL C SA1-00SV FENDER A ASSEMBLY FR (SILVER) B-SA1-00BU FENDER B ASSEMBLY FR (BLUE) B-SA1-00GY FENDER B ASSEMBLY FR (GRAY) MODEL A B-SA1-00OR FENDER B ASSEMBLY FR (ORANGE) B-SA1-00RD FENDER B ASSEMBLY FR (RED) B-SA1-00SV FENDER B ASSEMBLY FR (SILVER) B-SA1-00YW FENDER B ASSEMBLY FR (YELLOW) B-SA1-00BK FENDER B ASSEMBLY FR (BLACK) SA1-00C1 FENDER B COMP FR. (RED/SILVER) MODEL C SA1-00SV FENDER B COMP FR. (SILVER) SA1-00MT FENDER B COMP FR. (MUSTARD) SA1-00RD FENDER B COMP FR. (RED) SA1-00GY FENDER B COMP FR. (GRAY) MC NUT CLIP 6MM GW SCREW, SPECIAL 6 X BOLT FLANGE 6 X /06 Enlarged figure t
54 F07 FRONT FENDER
55 F08 STEERING STEM REF PART NUMBER DESCRIPTION QTY GN RACE STEERING TOP BALL GS NUT, STEERING STEM LOCK SA STEM COMP STEERING GS BALL ASSEMBLY STEERING UPPER GN RACE, STEERING TOP CONE SA BEARING STEERING BOTTOM GS THREAD COMP TOP BOLT FLANGE 10 X SA DUST SEAL STEERING HEAD /06
56 F09 FRONT FORK REF PART NUMBER DESCRIPTION QTY SA FORK ASSEMBLY R FR SA SPRING FR. SUCTION SA PIPE COMP FR FORK GF M1 RING BACK UP SPRING REBOUND SA CASE COMP R. BOTTOM DUST SEAL KM PIECE OIL LOCK RING PISTON SA PIPE SEAT KN6-9100S1 SEAL SET FR. FORK SA FORK ASSEMBLY L FR SA CASE COMP L. BOTTOM SA BOLT SOCKET 8 MM SA BOLT FR. FORK WASHER SPECIAL 8 MM RING OIL SEAL STOPPER O-RING /06 Enlarged figure next page
57 F09 FRONT FORK
58 F10 FRONT BRAKE CALIPER REF PART NUMBER DESCRIPTION QTY SA BRACKET RR SCREW BLEEDER M1 CAP BLEEDER PADS COMP FOR 1 PISTON CALIPER PISTON SPRING PAD DUST SEAL GE36021M1 PIN SLIDE GE36010M1 SHIM R PIN BOLT BUSH PIN BUSH BOOT PIN GE36010M1 DUST PLUG SA CALIPER ASSEMBLY FR. SINGLE PISTON KN CALIPER COMP SINGLE PISTON SEAL PISTON PIN HANGER WASHER WAVE WASHER TONGUED WASHER CONICAL SPRING BOLT FLANGE 8 X SA1-002P CALIPER ASSY FR. 2 PISTON (W/O PADS) P PADS COMP FOR 2 PISTON CALIPER /06 Enlarged figure next page
59 F10 FRONT BRAKE CALIPER SINGLE PISTON CALIPER NEW 2-PISTON CALIPER. SINGLE PISTON CALIPER PARTS WILL NOT FIT THIS SYSTEM. 2 PISTON CALIPER COMES FULLY ASSEMBLED, W/O BRAKE PADS.
60 F11 FRONT WHEEL REF PART NUMBER DESCRIPTION QTY KCK-9000 VALVE RIM TR SA AXLE FR WHEEL COLLAR FR WHEEL SIDE SA1-00RD WHEEL FR. CASTING RED SA1-00BU WHEEL FR. CASTING BLUE SA1-00YW WHEEL FR. CASTING YELLOW SA1-00BK WHEEL FR. CASTING BLACK SA1-00MT WHEEL FR. CASTING MUSTARD SA1-00OR WHEEL FR. CASTING ORANGE SA COLLAR FR DISTANCE RETAINER GEAR BOX SA TIRE ASSEMBLY FR SA GEAR BOX ASSEMBLY SPEEDOMETER SA GEAR SPEEDOMETER WASHER GEAR SA DISC FR BRAKE MZ BOLT, SPECIAL FLANGE 8 X KFO-0030 NUT FLANGE 12MM OIL SEAL 23 X 37 X OIL SEAL 40 X 50 X OG SCREW OVAL 5 X BEARING BALL 6301D /06
61 F11 FRONT WHEEL
62 F12 REAR WHEEL REF PART NUMBER DESCRIPTION QTY SA1-00BK WHEEL RR CASTING BLACK W/ DRUM BRAKE SA1-00RD WHEEL RR CASTING RED W/ DRUM BRAKE SA1-00BU WHEEL RR CASTING BLUE W/ DRUM BRAKE SA1-00YW WHEEL RR CASTING YELLOW W/ DRUM BRAKE SA1-00OR WHEEL RR CASTING ORANGE W/ DRUM BRAKE SA1-00MT WHEEL RR CASTING MUSTARD W/ DRUM BRAKE KCK-9000 VALVE RIM TR A-SA10000EU BRAKE SHOE ASSEMBLY GW CAM RR. BRAKE SA ARM RR BRAKE SA SPRING RR. BRAKE ARM SA FR.TIRE ASSEMBLY SPRING BRAKE SHOE SEAL BRAKE CAM DUST GE NUT, U, 14MM GAH-0001 WASHER 24 X 14 X JOINT B, BRAKE ARM KN69600M1 NUT B, BRAKE ROD ADJUSTING BOLT FLANGE 6 X REAR WHEEL FOR DISC BRAKE PR1-00BK WHEEL RR CASTING BLACK W/ DISC BRAKE PR1-00RD WHEEL RR CASTING RED W/ DISC BRAKE PR1-00BU WHEEL RR CASTING BLUE W/ DISC BRAKE PR1-00YW WHEEL RR CASTING YELLOW W/ DISC BRAKE PR1-00OR WHEEL RR CASTING ORANGE W/ DISC BRAKE PR1-00MT WHEEL RR CASTING MUSTARD W/ DISC BRAKE /06 Enlarged figure next page
63 F12 REAR WHEEL
64 F13 SEAT REF PART NUMBER DESCRIPTION QTY GN SPRING LOCK KEY SETTING SA SEAT ASSEMBLY DOUBLE BLACK MODEL A SA1-010B1 SEAT ASSEMBLY DOUBLE RED MODEL B SA1-010B2 SEAT ASSEMBLY DOUBLE GRAY MODEL B SA1-010B3 SEAT ASSEMBLY DOUBLE BLACK MODEL B SA1-010B4 SEAT ASSEMBLY DOUBLE BLUE MODEL B SA1-010B5 SEAT ASSEMBLY DOUBLE YELLOW MODEL B SA1-010B6 SEAT ASSEMBLY DOUBLE ORANGE MODEL B SA1-010C1 SEAT ASSEMBLY DOUBLE BLACK/SILVER MODEL C SA PIN SEAT HINGE SA CATCH COMP SEAT SA KEY SEAT LOCK SA CABLE SEAT LOCK KAB-0000 STAY SEAT LOCK BOLT FLANGE 6 X /06
65 F14 FLOOR SIDE COVER/UNDER COVER REF PART NUMBER DESCRIPTION QTY SA BASE COMP R. FLOOR SA BASE COMP L. FLOOR SA COVER R. FLOOR SIDE (BLACK) MODEL A&B SA1-SVRD COVER R. FLOOR SIDE (SILVER/RED) SA1-SVBL COVER R. FLOOR SIDE (SILVER/BLACK) SA1-SVBU COVER R. FLOOR SIDE (SILVER/BLUE) SA1-SVOR COVER R. FLOOR SIDE (SILVER/ORANGE) SA1-SVMT COVER R. FLOOR SIDE (SILVER/MUSTARD) SA1-SVYW COVER R. FLOOR SIDE (SILVER/YELLOW) SA COVER L. FLOOR SIDE (BLACK) MODEL A&B SA1-SVBL COVER L. FLOOR SIDE (SILVER/BLACK) SA1-SVBU COVER L. FLOOR SIDE (SILVER/BLUE) SA1-SVOR COVER L. FLOOR SIDE (SILVER/ORANGE) SA1-SVMT COVER L. FLOOR SIDE (SILVER/MUSTARD) SA1-SVRD COVER L. FLOOR SIDE (SILVER/RED) MOD. C SA1-SVYW COVER L. FLOOR SIDE (SILVER/YELLOW) SA COVER UNDER SA STEP R. PILLION SA STEP L. PILLION SA FLOOR MAT SA1-00AL ULTRA-LIGHT ALUMINUM FLOOR BOARD SB SCREW SPECIAL 5 X GR NUT CLIP 5MM BOLT, WASHER 6 X BOLT, WASHER 6 X SCREW, WASHER 5 X SCREW, TAPPING 5 X BOLT FLANGE 6 X /06 Enlarged figure next page
66 F14 FLOOR SIDE COVER/UNDER COVER
67 F15 FUEL TANK REF PART NUMBER DESCRIPTION QTY D16 COCK ASSEMBLY D19 STRAINER D19 GASKET, COCK BODY B50 FUEL TANK COMP B50 SEAL COMP, FUEL FILLER B50 CAP COMP FUEL FILLER B50 SEAL RIGHT FUEL TANK D19 HOSE COMP., FUEL D19 HOSE COMP, VACUUM A SENSOR, FUEL LEVEL B50 POSITION PLATE FUEL SENCER B5 POSITION PLATE FUEL SENCER D19 JOINT, THREE WAY C10 HOSE A C10 HOSE B C10 HOSE C D19 HOSE GB NUT GB BOLT D19 FILTER /06 Enlarged figure next page
68 F15 FUEL TANK
69 F16 BATTERY REF PART NUMBER DESCRIPTION QTY A UNIT ASSEMBLY CDI SB BATTERY ASSEMBLY SA COVER BATTERY SCREW TAPPING 5 X /06
70 F17 LUGGAGE BOX REF PART NUMBER DESCRIPTION QTY SA RUBBER FUEL GUIDE SA B1 LABEL, LUGGAGE BOX CAUTION A-SA BOX ASSEMBLY LUGGAGE SA CENTER BOX (UNDER SEAT) SA LABEL, FUEL CAUTION NUT, OPEN STAY 6MM SA TOOL SET PUM-150XX-00RD LUGGAGE BOX RED 1 1 PUM-150XX-00YW LUGGAGE BOX YELLOW 1 1 PUM-150XX-00BK LUGGAGE BOX BLACK 1 1 PUM-150XX-00BU LUGGAGE BOX BLUE 1 1 PUM-150XX-00OR LUGGAGE BOX ORANGE 1 1 PUM-150XX-00MT LUGGAGE BOX MUSTARD /06
71 F18 CENTER COVER/BODY COVER REF PART NUMBER DESCRIPTION QTY SA MUD GUARD RR. WHEEL KE NUT CLIP 4MM SA PLATE SPLASH GUARD SA COVER CENTER SA COVER CENTER SA RR. CARRIER SA1-00BK RR. CARRIER COVER (BLACK) MODEL B SA1-00RD RR. CARRIER COVER (RED) MODEL B SA1-00YW RR. CARRIER COVER (YELLOW) MODEL B SA1-00BU RR. CARRIER COVER (BLUE) MODEL B SA1-00OR RR. CARRIER COVER (ORANGE) SA1-000SV RR. CARRIER COVER (SILVER) SA COVER PLUG MAINTENANCE SA COVER ASSEMBLY SPARK PLUG MAINTENANCE SA1-RB00 COVER ASSEMBLY SPARK PLUG MAINTENANCE SA1-RDGY R. SIDE COVER ( GRAY WITH RED STICKERS) SA1-BUGY R. SIDE COVER (GREY WITH BLUE STICKERS) SA1-RDSV R. SIDE COVER (SILVER /RED ) MODEL C SA1-SVYW R. SIDE COVER (YELLOW/SILVER) MODEL C SA1-BUSV R. SIDE COVER (SILVER /BLUE ) MODEL C SA1-SVMT R. SIDE COVER (SILVER/MUSTARD ) MODEL C SA1-ORSV R. SIDE COVER (ORANGE/SILVER) MODEL C SA1-BKSV R. SIDE COVER (SILVER/BLACK) MODEL C SA1-00YW R. SIDE COVER (SILVER WITH YELLOW STICKERS) MODEL B SA1-00RD R. SIDE COVER (SILVER WITH RED STICKERS) MODEL B SA1-00BK R. SIDE COVER (SILVER WITH BLACK STICKERS) MODEL B SA1-00BU R. SIDE COVER (SILVER WITH BLUE STICKERS) MODEL B SA1-BKGY R. SIDE COVER (GREY W/BLACK STICKERS) SA1-BKWH R. SIDE COVER ( BLACK W/WHITE STICKERS) SA1-YWGY R. SIDE COVER (GREY W/YELLOW STICKERS) SA1-PLAIN R. SIDE COVER (PLAIN WITHOUT STICKERS) /06 Enlarged figure 2 pages down
72 REF PART NUMBER DESCRIPTION QTY SA1-00GY RR. UPPER COVER (GREY) SA1-00SV RR. UPPER COVER (SILVER) SA1-00GY RR. UNDER COVER (GREY) SA1-00SV RR. UNDER COVER (SILVER) SA GRILLE R. BODY COVER SA1-RDGY L. SIDE COVER ( GRAY W/RED STICKERS) MOD. A SA1-BUGY L. SIDE COVER (GREY W/BLUE STICKERS) MOD. A SA1-RDSV L. SIDE COVER (SILVER /RED ) MOD. C SA1-SVYW L. SIDE COVER (YELLOW/SILVER) MOD. C SA1-BUSV L. SIDE COVER (SILVER /BLUE ) MOD. C SA1-ORSV L. SIDE COVER (ORANGE/SILVER) MOD. C SA1-SVMT L. SIDE COVER (SILVER/MUSTARD) MOD. C SA1-BKSV L. SIDE COVER (SILVER/BLACK) MOD. C SA1-00YW L. SIDE COVER (SILVER W/YELLOW STICKERS) MOD. B SA1-00RD L. SIDE COVER (SILVER W/RED STICKERS) MOD. B SA1-00BK L. SIDE COVER (SILVER W/BLACK STICKERS) MOD. B SA1-00BU L. SIDE COVER (SILVER W/BLUE STICKERS) MOD. B SA1-BKWH L. SIDE COVER (BLACK W/WHITE STICKERS) SA1-YWGY L. SIDE COVER (GREY W/YELLOW STICKERS) SA1-BKGY L. SIDE COVER (GREY W/BLACK STICKERS) MOD. A SA1-PLAIN L. SIDE COVER (PLAIN WITHOUT STICKERS) SA MAT L. SILENCE SA GRILLE L BODY COVER BOLT WASHER 6 X SA SCREW, SPECIAL 4 X SB SCREW, SPECIAL 5 X MJ SCREW, SPECIAL 6 X OA SCREW, PAN 5 X SCREW TAPPING 5 X BOLT FLANGE 8 X BOLT FLANGE 6 X /06 Enlarged figure next page
73 8-10 PR 8-15 PR 8-10 RR 8-15RR PR SIDE COVERS PR1-RDSV R. SIDE COVER (SILVER /RED ) MODEL C PR1-SVYW R. SIDE COVER (YELLOW/SILVER) MODEL C PR1-BUSV R. SIDE COVER (SILVER /BLUE ) MODEL C PR1-SVMT R. SIDE COVER (SILVER/MUSTARD ) MODEL C PR1-ORSV R. SIDE COVER (ORANGE/SILVER) MODEL C PR1-BKSV R. SIDE COVER (SILVER/BLACK) MODEL C PR1-RDSV L. SIDE COVER (SILVER /RED ) MOD. C PR1-SVYW L. SIDE COVER (YELLOW/SILVER) MOD. C PR1-BUSV L. SIDE COVER (SILVER /BLUE ) MOD. C PR1-ORSV L. SIDE COVER (ORANGE/SILVER) MOD. C PR1-SVMT L. SIDE COVER (SILVER/MUSTARD) MOD. C PR1-BKSV L. SIDE COVER (SILVER/BLACK) MOD. C 1 1 RR SIDE COVERS RR1-RDSV R. SIDE COVER (SILVER /RED ) MODEL C RR1-SVYW R. SIDE COVER (YELLOW/SILVER) MODEL C RR1-BUSV R. SIDE COVER (SILVER /BLUE ) MODEL C RR1-SVMT R. SIDE COVER (SILVER/MUSTARD ) MODEL C RR1-ORSV R. SIDE COVER (ORANGE/SILVER) MODEL C RR1-BKSV R. SIDE COVER (SILVER/BLACK) MODEL C RR1-RDSV L. SIDE COVER (SILVER /RED ) MOD. C RR1-SVYW L. SIDE COVER (YELLOW/SILVER) MOD. C RR1-BUSV L. SIDE COVER (SILVER /BLUE ) MOD. C RR1-ORSV L. SIDE COVER (ORANGE/SILVER) MOD. C RR1-SVMT L. SIDE COVER (SILVER/MUSTARD) MOD. C RR1-BKSV L. SIDE COVER (SILVER/BLACK) MOD. C 1 1
74 F18 CENTER COVER/BODY COVER
75 F19 AIR CLEANER/FLOOR PANEL REF PART NUMBER DESCRIPTION QTY A-SA CHAMBER ASSEMBLY INTAKE SA CHAMBER INTAKE SA COUPLING INTAKE BOLT FLANGE 6mm SA BAND A86.5, INTAKE COUPLING A-SA PANEL SET, FLOOR SA PANEL FLOOR SA BAND B54.5 INTAKE COUPLING GR CLIP BODY COVER SA AIR FILTER /06 Enlarged figure next page
76 F19 AIR CLEANER/FLOOR PANEL
77 F20 EXHAUST MUFFLER REF PART NUMBER DESCRIPTION QTY SA MUFFLER ASSEMBLY (INCLUDES EX PIPE) SA COLLAR MUFFLER PROTECTOR SA RUBBER, PROTECTOR SA COLLAR, MUFFLER MOUNT SA WASHER, MUFFLER MOUNT SA RUBBER, MUFFLER MOUNT SA PROTECTOR MUFFLER GZ GASKET, EX PIPE GC GASKET EX PIPE FLANGE SA MUFFLER COMP ( DIMONZA CARBON FIBER, W/O EX PIP SA PIPE COMP EX KCK-9200 SCREW, TORUS 6 X NUT, FLANGE 6MM NUT FLANGE 6MM BOLT, FLANGE 8 X SA BRACKET, MUFFLER W. RUBBER (FOR DIMONZA EXHAU /06 Enlarged figure next page
78 F20 EXHAUST MUFFLER 16
79 F21 MAIN STAND/KICK STARTER ARM REF PART NUMBER DESCRIPTION QTY SA ARM KICK STARTER A-SA STAND ASSEMBLY MAIN SA STAND COMP MAIN SA COLLAR MAIN STAND GR RUBBER STAND STOPPER SA SPRING, MAIN STAND GZ SPRING, MAIN STAND OUTER GZ SPRING MAIN STAND INNER SA BAR COMP., SIDE STAND SA SPRING, SIDE STAND INNER SA SPRING, SIDE STAND OUTER GZ BOLT, SIDE STAND PIVOT OS NUT HEX 10MM WASHER PLAIN 10MM SPRING SIDE STAND A BOLT HEX 6 X BOLT FLANGE 10 X /06 Enlarged figure next page
80 F21 MAIN STAND/KICK STARTER ARM
81 F22 REAR SHOCK REF PART NUMBER DESCRIPTION QTY SA SHOCK ASSEMBLY RR SA SPRING RR SHOCK SA METAL COMP UPPER DAMPER COMP RR ADJUSTER SPRING M1 BUSH RUBBER GA COLLAR RUBBER BUSH RUBBER STOPPER KC BOLT SHOCK UNDER 10 X OS NUT HEX 10MM /06
82 F23 FRONT TURN SIGNAL REF PART NUMBER DESCRIPTION QTY SA TURN SIGNAL ASSEMBLY R. FR SA BASE R FR TURN SIGNAL SA LENS R FR TURN SIGNAL GW SOCKET COMP R SA TURN SIGNAL ASSEMBLY L. FR SA BASE L. FR.TURN SIGNAL SA LENS L. FR. TURN SIGNAL GW SOCKET COMP L GM BULB TURN SIGNAL (12V 10W) SCREW, TAPPING 5 X /06 Enlarged figure next page
83 F23 FRONT TURN SIGNAL
84 F24 REAR COMBINATION LIGHT REF PART NUMBER DESCRIPTION QTY SA LENS R. RR. TURN SIGNAL SA LENS L RR TURN SIGNAL SA LEN COMP RR. COMBINATION LIGHT SA SOCKET COMP RR. COMBINATION LIGHT SA BASE RR. COMBINATION LIGHT SA COVER, LICENSE SA PACKING LICENSE LIGHT SA REFLECTOR, REFLEX SA BULB, TURN SIGNAL (12V 10W) KCK-RB00 BULB, TURN SIGNAL (12V 10W) SA BULB, TAIL LIGHT (12V 21/5W) SA BULB LICENSE (12V 5 W) GR NUT CLIP 5MM GR CLIP, BODY COVER BOLT WASHER 6 X SCREW TAPPING 4 X NUT FLANGE 5 MM SA RR REFLECTOR (SIDES) /06 Enlarged figure next page
85 F24 REAR COMBINATION LIGHT
86 F25 WIRE HARNESS/IGNITION COIL REF PART NUMBER DESCRIPTION QTY SA IGNITION COIL COMP KCK-9002 CAP ASSEMBLY NOISE SUPPRESSOR KN REGULATOR RECTIFIER A REGULATOR RECTIFIER FOR 3 PHASE A/C ALTERNATOR SA WIRE HARNESS SA WIRE HARNESS FOR 3 PHASE A/C ALTERNATOR CASE FUSE (15A) SA CABLE, STARTER MAGNETIC BATTERY A-SA CABLE BATTERY GROUND SA LOCK ASSEMBLY (IGNITION, SEAT, TANK) A STARTER RELAY GW BOLT FLANGE 5 X SBF-0000 HORN COMP S NUT, HEX 6MM WASHER, PLAIN 6MM WASHER, PLAIN 6MM BOLT SOCKET 6 X FUSE A (15A) BOLT FLANGE 6 X NUT FLANGE 6 MM A CHARGING DIODE (TWO CONNECTORS) /06
87 F25 WIRE HARNESS/IGNITION COIL
88 F26 FRAME BODY REF PART NUMBER DESCRIPTION QTY SA BODY COMP, FRAME SA STAY FUEL TANK SUPPORT BOLT FLANGE 8 X SA STAY HEAD LIGHT BOLT FLANGE 10 X SA RUBBER, LINK STOPPER SA HANGER ASSEMBLY ENGINE SA SHAFT, SWING ARM 1 1 ENGMATRIX150 COMPLETE ENGINE /06
89 F28 REAR BRAKE ASSEMBLY REF PART NUMBER DESCRIPTION QTY 2005/06 F17-1 WY150T RR BRAKE DISC 1 1 F17-2 WY150T REAR HYDRAULIC BRAKE ASSEMBLY 1 1 F17-3 WY150T RR BRAKE SCREW M F17-4 WY150T M16 NUT 1 1 F17-5 WY150T BUSH I 1 1 F17-6 WY150T BUSH II 1 1 F17-7 WY150T REAR CONNECTING BOARD 1 1 F17-8 WY150T RR. BRAKE LEVER 1 1 F17-9 WY150T RR. BRAKE HOSE UPPER 1 1 F17-10 WY150T RR. BRAKE HOSE MIDDLE 1 1 F17-11 WY150T RR. BRAKE HOSE LOWER 1 1 F17-12 WY150T RR. BRAKE PADS 2 2 F17-13 WY150T RR. BRAKE MASTER CYLINDER 1 1 F17-14 WY150T RR. CALIPER Enlarged figure next page
90 F28 REAR BRAKE ASSEMBLY
91 F29 MATRIX XX PLASTICS REF PART NUMBER DESCRIPTION QTY F12-1 WY150T FR. HANDLEBAR COVER 1 1 F SA RR. HANDLEBAR COVER 1 1 F12-3 WY150T COVER BOARD,BRAKE DISC 1 1 F SA L, FENDER, HELMET FORWARD 1 1 F SA R,FENDER,HELMET FORWARD 1 1 F12-6 WY150T M5 25 SCREW 1 1 F12-7 WY150T PLASTIC SCREW 3 3 F12-8 WY150T ST SCREW TAPPING 4 4 F12-9 WY150T ST SCREW TAPPING F12-10 WY150T ST SCREW TAPPING 2 2 F12-11 WY150T FRONT PANEL 1 1 F12-12 WY150T CLIP WY150T-3-160RD FR. FENDER RED 1 1 WY150T-3-160BK FR. FENDER BLACK 1 1 F12-13 WY150T-3-160BU FR. FENDER BLUE 1 1 WY150T-3-160YW FR. FENDER YELLOW 1 1 WY150T-3-160OR FR. FENDER ORANGE 1 1 WY150T-3-160CH FR. FENDER CHROME 1 1 WY150T-3-160GR FR. FENDER GREEN 1 1 F12-14 WY150T BACKWARD,,FR FENDER 1 1 F12-15 WY150T M6 16 BOLT 3 3 F12-16 WY150T M6 16 SCREW 6 6 WY150T-3-164RD FRONT COVER RED 1 1 WY150T-3-164BK FRONT COVER BLACK 1 1 F12-17 WY150T-3-164BU FRONT COVER BLUE 1 1 WY150T-3-164YW FRONT COVER YELLOW 1 1 WY150T-3-164OR FRONT COVER ORANGE 1 1 WY150T-3-164CH FRONT COVER CHROME 1 1 WY150T-3-164GR FRONT COVER GREEN 1 1 F SA GRILL FR. COVER L. 1 1 F SA GRILL FR. COVER R. 1 1 F12-20 WY150T ST SCREW TAPPING /06
92 REF PART NUMBER DESCRIPTION QTY F12-21 WY150T BOTTOM COVER 1 1 F12-22 WY150T M6 12 BOLT 4 4 F SA COVER MIDDLE 1 1 F SA CENTER COVER
93 F30 MATRIX XX PLASTICS 2 REF PART NUMBER DESCRIPTION QTY F13-1 F13-2 WY150T-3-172RD L. SIDE COVER RED 1 1 WY150T-3-172BK L. SIDE COVER BLACK 1 1 WY150T-3-172BU L. SIDE COVER BLUE 1 1 WY150T-3-172YW L. SIDE COVER YELLOW 1 1 WY150T-3-172OR L. SIDE COVER ORANGE 1 1 WY150T-3-172CH L. SIDE COVER CHROME 1 1 WY150T-3-172GR L. SIDE COVER GREEN 1 1 WY150T-3-173RD R. SIDE COVER RED 1 1 WY150T-3-173BK R. SIDE COVER BLACK 1 1 WY150T-3-173BU R. SIDE COVER BLUE 1 1 WY150T-3-173YW R. SIDE COVER YELLOW 1 1 WY150T-3-173OR R. SIDE COVER ORANGE 1 1 WY150T-3-173CH R. SIDE COVER CHROME 1 1 WY150T-3-173GR R. SIDE COVER GREEN 1 1 F13-3 WY150T RR.GRILL 1 1 F13-4 WY150T LR,GRILL 1 1 F13-5 WY150T REAR BOARDING 1 1 F13-6 WY150T REAR PROTECTING BAR 1 1 F13-7 WY150T M6 12 BOLT 2 2 F13-8 WY150T PLASTIC, SCREW 2 2 F13-9 WY150T ST SCREW, TAPPING 4 4 F13-10 WY150T ST SCREW, TAPPING 8 8 F13-11 WY150T CLIP 8 8 F13-12 WY150T FOOTREST 1 1 WY150T-3-184RD R. PROTECTING BAR RED 1 1 WY150T-3-184BK R. PROTECTING BAR BLACK 1 1 F13-13 WY150T-3-184BU R. PROTECTING BAR BLUE 1 1 WY150T-3-184YW R. PROTECTING BAR YELLOW 1 1 WY150T-3-184OR R. PROTECTING BAR ORANGE 1 1 WY150T-3-184CH R. PROTECTING BAR CHROME 1 1 WY150T-3-184GR R. PROTECTING BAR GREEN /06
94 REF PART NUMBER DESCRIPTION QTY WY150T-3-185RD L.PROTECTING BAR RED 1 1 WY150T-3-185BK L.PROTECTING BAR BLACK 1 1 WY150T-3-185BU L.PROTECTING BAR BLUE 1 1 F13-14 WY150T-3-185YW L.PROTECTING BAR YELLOW 1 1 WY150T-3-185OR L.PROTECTING BAR ORANGE 1 1 WY150T-3-185CH L.PROTECTING BAR CHROME 1 1 WY150T-3-185GR L.PROTECTING BAR GREEN 1 1 F13-15 WY150T HELMET HANGER COMP 1 1 F13-16 WY150T CLIP NUT 2 2 F13-17 WY150T M5 25 SCREW 2 2 F13-18 WY150T ST SCREW, TAPPING 9 9 F13-19 WY150T M6 30 BOLT 2 2 F13-20 WY150T M6 16 BOLT 4 4 F13-21 WY150T M6 16 SCREW 2 2 F SA CENTER BOX (UNDER SEAT) 1 1 PUM-150XX-00YW LUGGAGE BOX YELLOW PUM-150XX-00BK LUGGAGE BOX BLACK PUM-150XX-00BU LUGGAGE BOX BLUE PUM-150XX-00OR LUGGAGE BOX ORANGE PUM-150XX-00MT LUGGAGE BOX MUSTARD F13-23 WY150T CARBURETOR COVER 1 1 F13-24 WY150T M6,NUT 3 3 F13-25 WY150T FRONT BOX 1 1 F13-26 WY150T FRONT BOX, LOCK 1 1 F13-27 WY150T REAR FENDER /06
95 F30 MATRIX XX PLASTICS 2
96 F31 MIRRORS & SEAT REF PART NUMBER DESCRIPTION QTY F6-1 F6-2 WY150T MIRROR ASSEMBLY,L CARBON FIBER 1 1 WY150T-3-077CH MIRROR ASSEMBLY,L CHROME 1 1 WY150T MIRROR ASSEMBLY,R CARBON FIBER 1 1 WY150T-3-078CH MIRROR ASSEMBLY,R CHROME 1 1 F6-3 WY150T M8 45 SCREW 2 2 F6-4 WY150T WASHER WY150T-3-083RD SEAT RED 1 1 WY150T-3-083BK SEAT BLACK 1 1 F6-7 WY150T-3-083BU SEAT BLUE 1 1 WY150T-3-083YW SEAT YELLOW 1 1 WY150T-3-083OR SEAT ORANGE 1 1 WY150T-3-083CH SEAT CHROME 1 1 WY150T-3-083GR SEAT GREEN 1 1 F6-8 WY150T M8 16 BOLT 2 2 F6-9 WY150T TOOL SET 1 1 F7-10 WY150T RR. CARRIER CARBON FIBER 1 1 WY150T-3-086CH RR. CARRIER CHROME 1 1 F7-11 WY150T REAR TAILSTOCK 1 1 F7-12 WY150T M8 12 BOLT 2 2 F7-13 WY150T M6 12 BOLT /06 Enlarged figure next page
97 F31 MIRRORS & SEAT & RR. CARRIER
98
PARTS CATALOGUE POWERMAX-125T REVISED 08/06/04
PARTS CATALOGUE POWERMAX-125T-7 REVISED 08/06/04 ENGINE INDEX FRAME SECTION FIG # FAN COVER/SHROUD E01 SECTION FIG # CYLINDER HEAD E02 CAMSHAFT VALVE E03 SIDE COVER F01 CAM CHAIN TENSIONER E04 R. & L.
ATV 90 UTILITY GREEN (A2006KUB2BUSG) Page 1 of 60 AIR INTAKE ASSEMBLY
2006 ATV 90 UTILITY GREEN (A2006KUB2BUSG) Page 1 of 60 AIR INTAKE ASSEMBLY 2006 ATV 90 UTILITY GREEN (A2006KUB2BUSG) Page 2 of 60 AIR INTAKE ASSEMBLY Ref # Part Number Qty S/P/F Description 1 3303-005
ATV 50 DVX BLACK-RED (A2008KSA2BUSD) Page 1 of 60 AIR INTAKE ASSEMBLY
2008 ATV 50 DVX BLACK-RED (A2008KSA2BUSD) Page 1 of 60 AIR INTAKE ASSEMBLY 2008 ATV 50 DVX BLACK-RED (A2008KSA2BUSD) Page 2 of 60 AIR INTAKE ASSEMBLY Ref # Part Number Qty S/P/F Description 1 3303-005
ATV 90 UTILITY CALIFORNIA GREEN (A2008KUB2BCAG) Page 1 of 58 AIR INTAKE ASSEMBLY
2008 ATV 90 UTILITY CALIFORNIA GREEN (A2008KUB2BCAG) Page 1 of 58 AIR INTAKE ASSEMBLY 2008 ATV 90 UTILITY CALIFORNIA GREEN (A2008KUB2BCAG) Page 2 of 58 AIR INTAKE ASSEMBLY Ref # Part Number Qty S/P/F Description
SMF / DSF / DTF SMF / DSF / DTF 200
2006 SMF / DSF / DTF 200 1 The drawings in this parts book have been scaled so that parts can be easily recognized. 1 CYLINDER ASSY 2 CYLINDER ASSY Ref # Part # Description 1 410 0001A CYLINDER HEAD COVER
DVX 90 MODEL NUMBER A2008KSB2BUSD (BLACK-RED) MODEL NUMBER A2008KSB2BUSE (BLACK-CAT GREEN) MORE TO GO ON. TM
2008 DVX 90 Illustrated Parts Manual MODEL NUMBER A2008KSB2BUSD (BLACK-RED) MODEL NUMBER A2008KSB2BUSE (BLACK-CAT GREEN) MORE TO GO ON. TM TABLE OF CONTENTS Black-Red (Model No. A2008KSB2BUSD) Black-Cat
Figure 1. - Cylinder / Cylinder Head
Page 1 of 42 Figure 1. - Cylinder / Cylinder Head Figure 1. Cylinder / Cylinder Head 1 11111-STG-00 Cylinder comp 1 2 11121-STG-00 Head comp, cylinder 1 3 11127-CHP-00 Nut, cylinder head 1 4 11141-ROA-00
PARTS CATALOGUE. Rockford Motors inc.
PARTS CATALOGUE Rockford Motors inc. INSTRUCTIONS FOR USING THE PARTS CATALOGUE 1. This catalogue covers all the items of genuine parts and tools of BRIDGESTONE 350 GTR and 350 GTO motorcycles. 2. Please
Honda 1975 Parts List ENGINE GROUP Block Ref. 1F 1 11000-377-000 CRANKCASE ASSY. 1 2F 2 11208-333-000 CAP, OIL PATH 1 2F 3 11210-377-000 PAN, OIL 1 2F 4 11291-377-000 PLUG, OIL PATH 1 1E 5 11331-377-000
CYLINDER HEAD. Ref. Part No. Number Description Qty Remarks
A1 CYLINDER HEAD 1 55V-11101-01-00 CYLINDER HEAD ASSEMBLY. 1 2 30X-11133-10-00. GUIDE, INTAKE VALVE..... 4 3 93440-10109-00. CIRCLIP................. 4 4 99510-08016-00. PIN, DOWEL............. 8 5 90105-06153-00.
HAMMERHEAD KT150. Illustrated Parts Manual
HAMMERHEAD KT0 Illustrated Parts Manual FIG. CYLINDER HEAD ASSY. 0 0 CYLINDER HEAD ASSY. REF NO. PART NO. DESCRIPTION REGD NO. M0-0-0 CYLINDER HEAD SUBASSY 0--00 SPARK PLUG (CHSA NGK) M0-0 CYLINDER HEAD
1. COVER COMP CYLINDER HEAD
CONTENTS FIG. 1 COVER COMP CYLINDER HEAD FIG. 2 CAMSHAFT COMP FIG. 3 HOLDER CAMSHAFT COMP FIG. 4 CYLINDER HEAD COMP FIG. 5 CARBURETOR FIG. 6 AIR CLEANER FIG. 7 LEFT CRANKCASE COVER FIG. 8 DRIVE PULLEY
COMPONENT LOCATIONS B C D G F C D F G
E ABCDEF 0000 COMPONENT LOCATIONS O H B C D G F J M L K P I O N B A C D J H A E I F G N M FIG. CYLINDER HEAD ASSY. 0 0 0 PARTS MANUAL CYLINDER HEAD ASSY. M0-00-0 HEAD CYLINDER SUBASSY 0--00 PLUG SPARK(CHSA
CS340ES. Property of - Not for Resale A1
A1 CYLINDER HEAD - CYLINDER 1 8G8-11111-00-00 HEAD, CYLINDER 1......... 1 2 8G8-11121-00-00 HEAD, CYLINDER 2......... 1 3 NGK-BR9ES-00-00 PLUG, SPARK............. 2 4 8G8-11181-01-00 GASKET, CYLINDER HEAD
90 Utility Model Number A2013KUB2BUSZ SHARE OUR PASSION.
2013 90 Utility Model Number A2013KUB2BUSZ TM SHARE OUR PASSION. TABLE OF CONTENTS 2013 ATV 90 (Model No. A2013KUB2BUSZ) BODY PANEL AND HEADLIGHT ASSEMBLY... 1 FRONT AND REAR RACK ASSEMBLY... 2 FRAME AND
HAMMERHEAD GT200. Page 1 of 9
HAMMERHEAD GT200 Figue Part Number Description F1-1 M200-0101 CYLINDER HEAD SUBASSY F1-2 98056-57713-00 SPARK PLUG (C7HSA NGK) F1-3 M150-1001010 CYLINDER HEAD GASKET F1-4 M150-1001004 CARBURETOR INSULATOR
CYLINDER - CYLINDER HEAD
A1 CYLINDER - CYLINDER HEAD 1 3FA-11110-00-00 CYLINDER HEAD ASSEMBLY. 1 2 95612-06625-00. BOLT, STUD............. 2 3 22F-11134-10-00. GUIDE, EXHAUST VALVE... 2 4 93440-10109-00. CIRCLIP.................
Parts Diagrams RR/RS Models
Parts Diagrams 2008-2009 RR/RS Models Table Of Contents Description Page # front fork 1 handlebar, clutch pump, meter (RR Models) 2 handlebar, clutch pump, meter (RS Models) 3 frame, subframe 4 rear shock,
DVX 300 Euro. Model Number A2012KSF2BEUK SHARE OUR PASSION.
ATV 2012ATV Illustrated Parts Manual DVX 300 Euro Model Number A2012KSF2BEUK TM SHARE OUR PASSION. TABLE OF CONTENTS 2012 ATV DVX 300 Euro (Model No. A2012KSF2BEUK) BODY PANEL AND HEADLIGHT ASSEMBLY...
CYLINDER HEAD. Ref. Part No. Number Description Qty Remarks
A1 A2 A3 A4 CYLINDER HEAD 1 3FA-11110-01-00 CYLINDER HEAD ASSY...... 1 2 90116-06541-00. BOLT, STUD............. 2 3 22F-11134-10-00. GUIDE, EXHAUST VALVE... 2 4 93440-10109-00. CIRCLIP.................
GTS150. Dune Buggy MINIMUM RECOMMENDED OPERATOR AGE: FOR OFF-ROAD USE ONLY. 10th letter in VIN: D-G
0-06 GTS50 0th letter in VIN: D-G Dune Buggy MINIMUM RECOMMENDED OPERATOR AGE: 6 FOR OFF-ROAD USE ONLY This vehicle is designed and manufactured for off-road use only. USA only: It does not conform to
PREFACE INSTRUCTIONS FOR QUOTING THE CATALOGUE. 1. DIMENSIONS Dimensions of the parts in this catalogue are indicated in unit millimeters.
PREFACE When it becomes necessary to replace parts on SUZUKI MOTORCYCLES, always use SUZUKI GENUINE PARTS which have passed a strict inspection which guarantees quality and performance. This parts catalogue
Hammerhead Rave 150. Parts Manual. This Vehicle is designed for off-road use only
Hammerhead Rave 0 Parts Manual This Vehicle is designed for off-road use only FIG. CYLINDER HEAD ASSY. 0 0 0 CYLINDER HEAD ASSY. REF NO. PART NO. DESCRIPTION REGD NO. M0-00-0 CYLINDER HEAD SUBASSY 0--00
CYLINDER HEAD. Ref. Part No. Number Description Qty Remarks
A1 CYLINDER HEAD 1 JN6-11102-00-00 HEAD, CYLINDER.......... 1 2 JN6-11133-10-00. GUIDE, VALVE............ 2 3 JN6-11181-00-00 GASKET, CYLINDER HEAD... 1 4 95817-10070-00 BOLT, FLANGE............ 4 5 99530-14016-00
01 CYLINDER HEAD COVER 4 02 CRANKSHAFT, PISTON 6 03 FAN, AIR SHROUD 8 04 OIL PUMP (EPA) REED VALVE, AIR CLEANER CARBURETOR 14
Parts Manual 1 2 CONTENTS PAGE 01 CYLINDER HEAD COVER 4 02 CRANKSHAFT, PISTON 6 03 FAN, AIR SHROUD 8 04 OIL PUMP (EPA) 10 05 REED VALVE, AIR CLEANER 12 06 CARBURETOR 14 07 EXHAUST 16 08 CRANKCASE 18 09
INDEX REAR SHOCK ABSORBER REAR FENDER HANDLE SWITCH
2005 / 2006 DTF 150 INDEX ENGINE FRAME SECTION FIG # SECTION FIG # CYLINDER HEAD E01 HANDLE BAR F01 CYLINDER E02 STEERING STEM F02 RIGHT CRANKCASE E03 FRONT FENDER F03 RIGHT CRANKCASE 2 E04 FRONT FORK
01 CYLINDER HEADCOVER 4 02 CRANKSHAFT, PISTON 6 03 FAN SHROUD 8 04 OIL PUMP REED VALVE AIR CLEANER CARBURETOR EXHAUST 16
Parts Manual 1 2 CONTENTS PAGE 01 CYLINDER HEADCOVER 4 02 CRANKSHAFT, PISTON 6 03 FAN SHROUD 8 04 OIL PUMP 10 05 REED VALVE AIR CLEANER 12 06 CARBURETOR 14 07 EXHAUST 16 08 CRANKCASE 18 09 STARTER 20 10
ATV 300 DVX CAT GREEN (A2011KSF2BUSZ) Page 1 of 56 AIR INTAKE ASSEMBLY
2011 ATV 300 DVX CAT GREEN (A2011KSF2BUSZ) Page 1 of 56 AIR INTAKE ASSEMBLY 2011 ATV 300 DVX CAT GREEN (A2011KSF2BUSZ) Page 2 of 56 AIR INTAKE ASSEMBLY Ref # Part Number Qty S/P/F Description 1 3303-705
Model NSR125R1 - HEADLIGHT
Model NSR125R1 - HEADLIGHT 1 32101KBS740 SUB CORD 001 34.610 2 33100KBS740 HEADLIGHT ASSY. (12V25/25W) 001 120.570 3 33111KAY600 RUBBER, HEADLIGHT 004 2.190 4 33120KBS740 HEADLIGHT UNIT 001 84.820 5 33125KBS740
CYLINDER HEAD CONTINUED ON NEXT FRAME. Ref. Part No. Number Description Qty Remarks
A1 CYLINDER HEAD 1 3BM-11101-01-00 CYLINDER HEAD ASSEMBLY. 1 2 4H7-11133-10-00. GUIDE, INTAKE VALVE..... 2 3 93440-12052-00. CIRCLIP................. 2 4 3BM-11101-11-00 CYLINDER HEAD ASSEMBLY. 1 5 4H7-11133-10-00.
Illustrated Parts Manual. Model Number A2011KSF2BEUZ (Black-Cat Green) A2011KSF2BEOJ (White-Cat Green)
Illustrated Parts Manual 2 1 10 DVX 300 Euro Model Number A2011KSF2BEUZ (Black-Cat Green) A2011KSF2BEOJ (White-Cat Green) S H A R E O U R PAS S IO N. TM TABLE OF CONTENTS 2011 ATV DVX 300 Euro Black-Cat
CYLINDER. Ref. Part No. Number Description Qty Remarks
A1 CYLINDER 1 3R9-11111-00-00 HEAD, CYLINDER 1......... 1 2 1W2-11161-00-00 ABSORBER 1............. 2 3 (1W2-11127-00-00) ABSORBER 3............. 1 4 2X3-11181-00-00 GASKET, CYLINDER HEAD 1. 1 5 90116-08321-00
CYLINDER HEAD CONTINUED ON NEXT FRAME. Ref. Part No. Number Description Qty Remarks
A1 A2 A3 A4 CYLINDER HEAD 1 3TB-11101-02-00 CYLINDER HEAD ASSY...... 1 2 4H7-11133-10-00. GUIDE, INTAKE VALVE..... 4 3 93440-12052-00. CIRCLIP................. 4 4 90116-06475-00. BOLT, STUD.............
Part list for Kawasaki H2, 1972
Part list for Kawasaki H2, 972 . Cylinder head, cylinder. . Cylinder head, cylinder. 9205-049 NUT 0 m/m 2 2 40B400 WASHER-plain 4 m/m 2 3 46E400 WASHER-spring 4 m/m 2 4 92070-036 SPARK PLUG NGK B9 HS 3
PARTS CATALOGUE EARTHLANDER REVISED 02/25/05
PARTS CATALOGUE EARTHLANDER 200 REVISED 02/25/05 INDEX ENGINE FRAME SECTION FIG # SECTION FIG # FAN COVER, SHROUD E01 FRAME F01 CYLINDER HEAD COVER E02 PLASTIC COVERS F02 CAMSHAFT,VALVE, CYLINDER HEA E03
CYLINDER HEAD CONTINUED ON NEXT FRAME. Ref. Part No. Number Description Qty Remarks
A1 CYLINDER HEAD 1 15A-11110-01-00 CYLINDER HEAD ASSEMBLY. 1 2 93440-10085-00. CIRCLIP................. 2 3 90153-06045-00. SCREW, HEXAGON........ 1 4 90430-06014-00. GASKET................ 1 5 5H0-11133-10-00.
CRANKCASE - CYLINDER CONTINUED ON NEXT FRAME. Ref. Part No. Number Description Qty Remarks
A1 CRANKCASE - CYLINDER 1 1W2-15111-02-00 CRANKCASE 1............ 1 2 1W2-15121-02-00 CRANKCASE 2 (1W2-15121-01) 1 3 99510-20020-00 PIN, DOWEL.............. 1 4 99530-10014-00 PIN, DOWEL..............
CYLINDER HEAD CONTINUED ON NEXT FRAME. Ref. Part No. Number Description Qty Remarks
A1 CYLINDER HEAD 1 4JY-11111-00-00 HEAD, CYLINDER 1 (4JY-11111-01-00).......... 1 2 90116-08394-00 BOLT, STUD.............. 5 3 90176-08026-00 NUT, CROWN............. 5 4 90201-08087-00 WASHER, PLATE...........
CYLINDER. Ref. Part No. Number Description Qty Remarks
A1 A2 A3 A4 CYLINDER 1 2GU-11111-00-00 HEAD, CYLINDER 1......... 1 2 NGK-B8ES0-00-00 PLUG, SPARK (NGK B8ES)... 2 3 90116-08394-00 BOLT, STUD.............. 8 4 95917-08640-00 BOLT, STUD.............. 2
CYLINDER HEAD CONTINUED ON NEXT FRAME. Ref. Part No. Number Description Qty Remarks
A1 A2 A3 A4 CYLINDER HEAD 1 3TB-11101-02-00 CYLINDER HEAD ASSY...... 1 2 4H7-11133-10-00. GUIDE, INTAKE VALVE..... 4 3 93440-12052-00. CIRCLIP................. 4 4 90116-06475-00. BOLT, STUD.............
CYLINDER. Ref. Part No. Number Description Qty Remarks
A1 CYLINDER 1 2GU-11111-00-00 HEAD, CYLINDER 1......... 1 2 NGK-B8ES0-00-00 NGK B8ES 10PK........... 2 3 90116-08394-00 BOLT, STUD.............. 8 4 95912-08640-00 BOLT, STUD.............. 2 5 90179-08491-00
View Catalogs Online at
Catalog ML125-5 2015Edition ML125-5 Frame Parts 12551-1 Grip, LH 12551-2 Clutch Lever Comp. 12551-3 Handlebar Switch, LH 12551-4 Rearview Mirror, LH 12551-5 Rearview Mirror, RH 12551-6 Handlebar Switch,
View Catalogs Online at
ML125-5 Frame Parts 12551-1 Grip, LH 12551-2 Front Brake Lever Comp. 12551-3 Handlebar Switch, LH 12551-4 Rearview Mirror, LH 12551-5 Rearview Mirror, RH 12551-6 Handlebar Switch, RH 12551-7 Clutch Lever
1 of 25 9/19/2016 1:07 PM
1 of 25 9/19/2016 1:07 PM GX610(VD) E-11 RECOIL STARTER 001 28400-ZE3-W01ZA STARTER ASSY., RECOIL *R8 * 1 002 28410-ZE3-W01ZA CASE COMP., RECOIL STARTER *R8 * 1 003 28421-ZE3-W01 PULLEY, RECOIL STARTER
ETON America PARTS CATALOG. Matrix R4-150
ETON America PARTS CATALOG w.getitparts.com Matrix R4-50 www.getitparts.com Parts and drawing are subject to change without notice. ETON America reserves the right to substitute parts that have engineering
SSR200 Zongshen 200cc Dirt Bike (VIN PREVIX LZSJ)
Page 1 of 19 Product Information Baja Web > Product Information > Parts Lists > DIRTBIKE > SSR200 Zongshen 200cc Dirt Bike (VIN PREVIX LZSJ) SSR200 Zongshen 200cc Dirt Bike (VIN PREVIX LZSJ) SSR200 Zongshen
CYLINDER HEAD CONTINUED ON NEXT FRAME. Ref. Part No. Number Description Qty Remarks
A1 CYLINDER HEAD 1 4JY-11111-00-00 HEAD, CYLINDER 1 (4JY-11111-01-00).......... 1 2 90116-08394-00 BOLT, STUD.............. 5 3 90176-08026-00 NUT, CROWN............. 5 4 90201-08087-00 WASHER, PLATE...........
CYLINDER HEAD CONTINUED ON NEXT FRAME. Ref. Part No. Number Description Qty Remarks
A1 CYLINDER HEAD 1 3BM-11101-00-00 CYLINDER HEAD ASSEMBLY. 1 2 4H7-11133-10-00. GUIDE, INTAKE VALVE..... 2 3 93440-12052-00. CIRCLIP................. 2 4 3BM-11101-10-00 CYLINDER HEAD ASSEMBLY. 1 5 4H7-11133-10-00.
GXV620K1(QYF) E-12-1 FAN COVER (2)
GXV620K1(QYF) E-12-1 FAN COVER (2) 001 16715-ZJ1-840 COVER, FUEL PUMP 1 003 19611-ZJ1-850ZA COVER, FAN (RECOIL STARTER) *NH1 * 1 003 19611-ZJ1-850ZB COVER, FAN (RECOIL STARTER) *R8 * 1 2005207 003 19611-ZJ1-850ZC
CYLINDER. Ref. Part No. Number Description Qty Remarks
A1 CYLINDER 1 (3R4-11111-00-00) HEAD, CYLINDER 1......... 1 2 1W3-11181-00-00 GASKET, CYLINDER HEAD 1. 1 3 (CMP-N2G00-00-00) CHAMPION N2G 10PK....... 1 4 90116-08321-00 BOLT, STUD.............. 6 5 90179-08491-00
Ref Partnumber Description GXV610K1 Serial Numbers ZE3-W01ZB STARTER ASSY., RECOIL *NH1 * ZE3-W01ZP STARTER ASSY.
GXV610K1(QWA/A) E-11 RECOIL STARTER 001 28400-ZE3-W01ZB STARTER ASSY., RECOIL *NH1 * 1 001 28400-ZE3-W01ZP STARTER ASSY., RECOIL *R280 * 1 2009863 002 28410-ZE3-W01ZB CASE COMP., RECOIL STARTER *NH1 *
ETON America PARTS CATALOG. Beamer PN-2
ETON America PARTS CATALOG Beamer PN- Table of Contents Beamer PN- PrdImg: \\Nt4serv\EtonData Figure No. 0 03 04 05 06 07 08 09 0 3 4 5 6 7 8 9 0 3 4 9 Content Referance Cylinder, Crankshaft and Piston
CYLINDER HEAD. Ref. Part No. Number Description Qty Remarks
A1 A2 A3 A4 CYLINDER HEAD 1 15A-11110-03-00 CYLINDER HEAD ASSY...... 1 2 93440-10085-00. CIRCLIP................. 2 3 90153-06029-00. SCREW, HEXAGON........ 1 4 90430-06014-00. GASKET................ 1
SPARE PARTS SMC JUMBO 700. WBC d.o.o., Sticna 127, 1295 Ivancna Gorica, Slovenia-Europe WEB PAGE:
SPARE PARTS SMC JUMBO 700 WBC d.o.o., Sticna 127, 1295 Ivancna Gorica, Slovenia-Europe WEB PAGE: www.atv.si, www.atv-quad.si CYLINDER CYLINDER 1 11111-MAX-00 CYLINDER COMP 2 11121-MAX-00 HEAD COMP, CYLINDER
Engine Group Frame Group Color P. Index SYM ORBIT AV05W-6
SYM ORBIT AV05W-6 ORBIT AV05W-6 COLOR PARTS INDEX N MODEL BASIC COLOR AV05W-6 BLACK AV05W-6 RED O CODE BK001 KC R010CA RD Item Parts Number Description Basic Color Code Basic Color Code 1 53205-AAA-000
F01 SPEEDOMETER HEAD LIGHT HANDLE COVER
F01 SPEEDOMETER HEAD LIGHT HANDLE COVER BLOCK NO..A-2 CHANGE L R 1 35150-GW0-900 1 Lighting sw. unit 2 35160-GW0-900 1 Start sw. unit 3 35170-GW0-900 1 Dimmer & passing sw. unit 4 35180-GW0-900 1 Horn
11/14/ U. Baja Motorsports Inc. P.O. Box Phoenix, AZ Toll Free: PARTS AND PRICES ARE SUBJECT TO CHANGE 1 of 53
250U Toll Free: 888-863-2252 PARTS AND PRICES ARE SUBJECT TO CHANGE 1 of 53 FIG. 1 PNEUMATIC MECHANISM 1-1 250U-100 883099019951 CAMSHAFT 1 1 1-2 250U-101 883099019968 KEY, WOODRUFF 1 1 1-3 250U-102 883099019975
X4 (GREEN) (A2000ATF2AUSG) Page 1 of 80 AIR INTAKE ASSEMBLY
2000 300 2X4 (GREEN) (A2000ATF2AUSG) Page 1 of 80 AIR INTAKE ASSEMBLY 2000 300 2X4 (GREEN) (A2000ATF2AUSG) Page 2 of 80 AIR INTAKE ASSEMBLY Ref # Part Number Qty S/P/F Description 1 3570-001 1 /P Intake,
CYLINDER HEAD - CYLINDER
A1 CYLINDER HEAD - CYLINDER 1 (1W6-11111-00-00) HEAD, CYLINDER 1......... 1 (2K9-11111-00-00) HEAD, CYLINDER 1......... 1 2 1W3-11181-00-00 GASKET, CYLINDER HEAD 1. 1 500-11181-00-00 GASKET, CYLINDER HEAD
ETON America PARTS CATALOG
ETON America PARTS CATALOG Beamer Parts and drawing are subject to change without notice. ETON America reserves the right to substitute parts that have engineering changes that can alter the appearance
CYLINDER HEAD. Ref. Part No. Number Description Qty Remarks
A1 A2 A3 A4 CYLINDER HEAD 1 1UY-11110-02-00 CYLINDER HEAD ASSY...... 1 2 3Y1-11133-11-00. GUIDE, INTAKE VALVE..... 2 3 93440-12052-00. CIRCLIP................. 2 4 90401-06001-00. BOLT, UNION............
PARTS CATALOGUE AX-100
PARTS CATALOGUE AX-100 2005. REVISED 08/25/04 INDEX ENGINE FRAME SECTION FIG # CYLINDER E01 SECTION FIG # CRANKCASE E02 METER ASSY F01 CRANKCASE COVER E03 HEADLIGHT F02 CRANKSHAFT E04 TURNING SIGNAL F03
Model NSR125RK HEADLIGHT
Model NSR125RK HEADLIGHT Part Ref Genuine Part # 1 SUB CORD, HEADLIGHT 322-KY4-880 2 4 330-KY4-880 HEADLIGHT ASSY. (12V 25/25W) 5 336-KY4-880 NUT, ADJUSTING 6 338-KY4-880 PLATE, ADJUSTING 33120-KY4-880
400 4x4 Euro MODEL NUMBER A2008IDG4BEUR (RED) MODEL NUMBER A2008IDG4BEUG (GREEN) MODEL NUMBER A2008IDG4BEUZ (CAT GREEN) MORE TO GO ON.
2008 400 4x4 Euro Illustrated Parts Manual MODEL NUMBER A2008IDG4BEUR (RED) MODEL NUMBER A2008IDG4BEUG (GREEN) MODEL NUMBER A2008IDG4BEUZ (CAT GREEN) MORE TO GO ON. TM TABLE OF CONTENTS 2008 ATV 400 4x4
CYLINDER HEAD CONTINUED ON NEXT FRAME. Ref. Part No. Number Description Qty Remarks
A1 A2 A3 A4 CYLINDER HEAD 1 4BD-11101-02-00 CYLINDER HEAD ASSY...... 1 2 93440-10085-00. CIRCLIP................. 2 3 90153-06029-00. SCREW, HEXAGON........ 1 4 90430-06014-00. GASKET................ 1
CYLINDER. Ref. Part No. Number Description Qty Remarks
A1 CYLINDER 1 J38-11102-00-00 CYLINDER HEAD ASSEMBLY. 1 2 J38-11133-09-00. GUIDE, INTAKE VALVE..... 2 3 99510-12016-00 PIN, DOWEL.............. 2 4 95811-08070-00 BOLT, FLANGE............ 3 5 95811-08045-00
400 2x4/4x4 EFT SHARE OUR PASSION ṬM
SHARE OUR PASSION ṬM 400 2x4/4x4 EFT Model Number A2009IDG2BETR (Red - 2x4) Model Number A2009IDG2BETZ (Cat Green - 2x4) Model Number A2009IDG4BETR (Red - 4x4) Model Number A2009IDG4BETG (Green - 4x4)
Honda SFX Reservedelskatalog
Honda SFX Reservedelskatalog Nummer på delen. Navn på delen. Honda varenummer. Pris i. (CA) 1 1 COVER COMP., FAN 19600-GBM-850 35.08 2 SHROUD COMP. 19620-GAV-701 14.41 3 BOLT, 6X25 90003-GAV-701 1.75 4
ETON America PARTS CATALOG
ETON America PARTS CATALOG Matrix 50 Parts and drawing are subject to change without notice. ETON America reserves the right to substitute parts that have engineering changes that can alter the appearance
CYLINDER. Ref. Part No. Number Description Qty Remarks
A1 CYLINDER 1 J38-11102-00-00 CYLINDER HEAD ASSEMBLY. 1 2 J38-11133-09-00. GUIDE, INTAKE VALVE..... 2 3 99510-12016-00 PIN, DOWEL.............. 2 4 95811-08070-00 BOLT, FLANGE............ 3 5 95811-08045-00
PARTS MANUAL DVX 300 EU A2015KSF2BEUZ.
PARTS MANUAL DVX 300 EU A2015KSF2BEUZ www.arcticcat.com Contents AIR INTAKE ASSEMBLY [92559] 1 BODY PANEL AND HEADLIGHT ASSEMBLY [300511] 3 CAM CHAIN ASSEMBLY [90409] 5 CARBURETOR ASSEMBLY [300515] 6 CLUTCH
ETON America PARTS CATALOG
ETON America PARTS CATALOG Parts and drawing are subject to change without notice. ETON America reserves the right to substitute parts that have engineering changes that can alter the appearance of the
10th letter in VIN: J
08 0th letter in VIN: J Headlight G Br Speedometer Headlight Light Switch B Br Ignition Switch R B Y/R Brake Light Switch B G/Y Starter Relay Fuse A + G Starter Motor Rear Brake Light G/Y Br G Speed Sensor
ATV 50 Y-6 YOUTH CAT GREEN (A2004ATA2BUSZ) Page 1 of 50 A-ARM, FLOOR PANEL, AND BUMPER ASSEMBLY
2004 ATV 50 Y-6 YOUTH CAT GREEN (A2004ATA2BUSZ) Page 1 of 50 A-ARM, FLOOR PANEL, AND BUMPER ASSEMBLY 2004 ATV 50 Y-6 YOUTH CAT GREEN (A2004ATA2BUSZ) Page 2 of 50 A-ARM, FLOOR PANEL, AND BUMPER ASSEMBLY
E-12-1 FAN COVER (TAE2,TAF2)
E-12-1 FAN COVER (TAE2,TAF2) 001 16715-ZJ1-840 COVER, FUEL PUMP 1 003 19611-ZJ1-850ZC COVER, FAN (RECOIL STARTER) *R280 * 1 1003896 004 19612-ZJ1-841 PLATE, SIDE 1 005 19614-ZJ1-841 PLATE, SIDE 1 006 19621-ZJ1-801ZC
ATV I l. l u. r a. Parts Manual ARCTIC CAT. 250 cc/300 cc
2000 I l l u st ATV 250 cc/300 cc Model No. A2000ATE2AUSG (250 - Green) Model No. A2000ATE2AUSR (250 - Red) Model No. A2000ATF2AUSG (300 2x4 - Green) Model No. A2000ATF2AUSR (300 2x4 - Red) Model No. A2000ATF4AUSG
B B B
FIG CYLINDER Suzuki Worldwide Motorcycle-ATV Page: of -0B00-00 0-00 0-000 0-00 0-0B0-0B0 0-0 0-0 Head, Cylinder Gasket, Cylinder Head Spark Plug (ngk,bphs) Spark Plug (nd,wfp-u) Cylinder Gasket, Cylinder
CYLINDER. Ref. Part No. Number Description Qty Remarks
A1 CYLINDER 1 25Y-11111-01-00 HEAD, CYLINDER 1......... 1 2 25Y-11181-00-00 GASKET, CYLINDER HEAD 1. 1 3 NGK-B8EG0-00-00 PLUG, SPARK (NGK B8EG) (94702-00323-00)........... 1 U.R. LM FOR U.S.A. 4 90116-08394-00
CYLINDER 11/14/2008. Item No.
WD90S Toll Free: 888-863-2252 (BAJA) PARTS AND PRICES ARE SUBJECT TO CHANGE 1 of 41 CYLINDER Part UPC Number Description 1 WD90S-100 883099036699 GASKET, CYLINDER BLOCK 1 1 2 WD90S-101 883099036743 DOWEL
GX200(SMG2) E-11 RECOIL STARTER (1)
E-11 RECOIL STARTER (1) 016 91406-166-000 CLIP, WIRE 1 1961501 016 91406-166-000 CLIP, WIRE 1 1961501 016 91406-671-000 CLIP, WIRE HARNESS 1 1937022 016 91406-671-000 CLIP, WIRE HARNESS 1 1961500 E-12
hentet hos:
SKY TEAM CORPORATION LTD. 0 CARNIVAL COMMERCIAL BLDG. JAVA ROAD NORTH POINT HONGKONG TEL:00 09 FAX:00 09 EMAIL:SKYTEAM_HK@HOTMAIL.COM HTTP://WWW.SKYTEAM.NET.CN WWW.SKYTEAM.CN Please make reference to this
CYLINDER HEAD - CYLINDER
A1 CYLINDER HEAD - CYLINDER 1 8AY-11111-00-00 HEAD, CYLINDER 1......... 1 2 8A7-12499-00-00 JOINT................... 1 3 NGK-BR9ES-00-00 PLUG, SPARK............. 2 4 8AY-11181-00-00 GASKET, CYLINDER HEAD
Description. Copyright 2005 Suzuki Worldwide Motorcycle-ATV. All Rights Reserved.
LT0K (LT0K P) FIG GASKET SET Suzuki Worldwide Motorcycle-ATV Page: of 0 0-0 -00-0B0-0B0 -A0 -E00-000 -0B0 0-000 0-000 0-00 00-00 00-00 00-00 Gasket Set Gasket, Cylinder Head Gasket, Cylinder Gasket, Clutch
XC 450 EFT Model Number A2013KCK4CETT SHARE OUR PASSION.
2013 XC 450 EFT Model Number A2013KCK4CETT TM SHARE OUR PASSION. TABLE OF CONTENTS 2013 XC 450 EFT Green (Model No. A2013KCK4CETT) FRONT BODY ASSEMBLY... 1 REAR BODY AND TAILLIGHT ASSEMBLY... 2 BUMPER,
CYLINDER - CRANKCASE. Ref. Part No. Number Description Qty Remarks
A1 CYLINDER - CRANKCASE 1 (374-15111-00-00) CRANKCASE 1............ 1 2 374-15121-02-00 CRANKCASE 2............ 1 3 99510-12016-00 PIN, DOWEL.............. 2 4 98580-06550-00 SCREW PAN HEAD (92503-06050).............
90 Y-12 Youth. Model Number A2005H4B2BUSR (Red) Model Number A2005H4B2BUSZ (Cat Green) Illustrated Parts Manual
90 Y-12 Youth Model Number A2005H4B2BUSR (Red) Model Number A2005H4B2BUSZ (Cat Green) Illustrated Parts Manual 2005 TABLE OF CONTENTS 2005 ATV 90 Y-12 Youth Red (Model No. A2005H4B2BUSR) Cat Green (Model
PW50 (5PG8) EUROPE,SOUTH AFRICA,JAPAN
PW50 (5PG8) OPE,SOUTH AFRICA,JAPAN 1C5PG-300E1 ( 2C5PG-300E1 ) A2 PW50 PARTS CATALOGUE 2003 by Yamaha Motor Co., Ltd. 1st edition, May 2003 All rights reserved. Any reprinting or unauthorized use without
R th letter in VIN: B-G. Illustrated Parts Manual
0-06 R-50 0th letter in VIN: B-G Illustrated Parts Manual 0 0 0 R-50 Wire Diagram o Turn Signal Switch Ignition Switch Hazard Light Switch Head Light switch G Brake Light Switch G sb o Gr o Gr Gr sb L
BR150S Howhit Baja Reaction 150cc Go Kart (VIN PREFIX L6K)
Page 1 of 16 Product Information Baja Web > Product Information > Parts Lists > GOKART > BR150S Howhit Baja Reaction 150cc Go Kart (VIN PREFIX L6K) BR150S Howhit Baja Reaction 150cc Go Kart (VIN PREFIX
American Honda Motor Co., Inc.
PROGRAMS AND DATA ARE THE PROPERTY OF AMERICAN HONDA MOTOR CO., INC. Parts List 001 COVER, CRANKCASE W 001 11100-812-020 0100001-1004270 001 COVER, CRANKCASE 001 11100-812-030 1004271-1018081 001 COVER,
CYLINDER. Ref. Part No. Number Description Qty Remarks
A1 CYLINDER 1 2J2-11181-09-00 GASKET, CYLINDER HEAD 1. 1 2 99530-14016-00 PIN, DOWEL.............. 2 3 90116-10222-00 BOLT, STUD.............. 2 4 90116-10223-00 BOLT, STUD.............. 1 5 90116-08190-00
Description. Copyright 2006 Suzuki Worldwide Motorcycle-ATV. All Rights Reserved.
RVK (RVK E) FIG GASKET SET Suzuki Worldwide Motorcycle-ATV Page: of 0 0-0 -G00-0 -0 -G00-0 -C00 -F00 0-00 00-00 00-00 00-000 00-00 Gasket Set. Gasket, Cylinder Head. Gasket, Cylinder. Gasket, Clutch Cover.
PARTS CATALOGUE AN125HKK5 (CF47C) P71 AN125 PRODUCED BY DACHANGJIANG MOTORCYCLE CO.LTD RD EDITION
PARTS CATALOGUE AN125HKK5 (CF47C) AN125 P71 PRODUCED BY DACHANGJIANG MOTORCYCLE CO.LTD 2012-11 3RD EDITION This part catalogue supersedes all the following part catalogue with immediate effect Model of
ETON America PARTS CATALOG
ETON America PARTS CATALOG Yukon II CXL-50 Parts and drawing are subject to change without notice. ETON America reserves the right to substitute parts that have engineering changes that can alter the appearance
Illustrated Parts Manual. Model Number A2011ICS4BUSG (Green) A2011ICS4BOSG (Green - International)
Illustrated Parts Manual 2 1 10 650 Model Number A2011ICS4BUSG (Green) A2011ICS4BOSG (Green - International) S H A R E O U R PAS S IO N. TM TABLE OF CONTENTS 2011 ATV 650 Green (Model No. A2011ICS4BUSG)
10th letter in VIN: H
0 0th letter in VIN: H Headlight G Br Speedometer Headlight Light Switch B Br Ignition Switch R B Y/R Brake Light Switch B G/Y Starter Relay Fuse A + G Starter Motor Rear Brake Light G/Y Br G Speed Sensor
E03 CYLINDER HEAD ASSY 1 BN0030 Dowel Pin 4
E01 FAN COVER ASSY 1 BN0061-1 Clip 1 2 150ZT-E01.02 BN0064 Fan Cover 1 3 BN0061-2 Bracket 1 4 150ZT-E01.04 BN0064-4 Carburetor Cooling Duct 1 5 150ZT-E01.05 BN0064-3 Decorative Cover 1 6 150ZT-E01.06 BN0063-2
D-1: FAN COVER. DESCRIPTION 1 Asm., Shroud, Upper
D-: FAN COVER Asm., Shroud, Upper 9639-000 Screw, Tappinmg 9390-305068-00K 3 Clamp 9689-000 Plug, Rubber 96339-000 5 Elbow, Outlet 9650-000 6 Bolt 96000-06058-08C 3 7 Cover Set, Fly Wheel 9609-00 8 Cap
CYLINDER HEAD CONTINUED ON NEXT FRAME. Ref. Part No. Number Description Qty Remarks
A1 CYLINDER HEAD 1 1TA-11102-00-00 CYLINDER HEAD ASSEMBLY. 2 2 93440-14086-00. CIRCLIP, OUTER.......... 2 3 4X7-11133-10-00. GDE, INTK VLV 1 O/S...... 2 1ST 0/S 4 4X7-11127-00-00 ABSORBER 3.............
ABOUT THIS PARTS LIST
ABOUT THIS PARTS LIST THIS PARTS LIST IS COMPILED FOR ALL SERVICE PARTS FOR MODEL MINI ATV 50C.C. SERIES. ANY DIFFERENCE BETWEEN COLOR CHART AND MOTORCYCLE WILL BE REVISED ACCORDING TO MOTORCYCLE. WHEN