International Perfecto2VAW (IRC5PO2VAW)

Transcription

1 Parts Catalog Issued: Feb 27, 2017 International Perfecto2VAW (IRC5PO2VAW) Oxygen Concentrator

2 Parts Catalog Usage Guide The information contained in this document is subject to change without notice. This catalog contains service parts for. If you have any questions regarding this catalog, please contact one of our Customer Service Representatives. SYMBOL DEFINITION For Customer Service Support Call: For Faxed In Orders Call: or For Technical Service Call: Literature Can Be Found at: or Throughout this catalog you will notice letters to draw your attention to specific footnotes which are located at the bottom of the page or below specified charts. Examples: A,B,C etc. NOTE: NLA = Special Comments = General information pertaining to that specific page = No Longer Available HARDWARE MEASUREMENTS The measurements for the hardware will be listed as follows: Screws, Bolts Diameter X Thread Count/Pitch X Length Washers Inside Diameter X Outside Diameter X Thickness Spacers Inside Diameter X Outside Diameter X Length For your convenience, we have supplied an area for you to list your Invacare Representatives. Name Phone Numbers 2017 Invacare Corporation. All rights reserved. Republication, duplication or modification in whole or in part is prohibited without prior written permission from Invacare. Trademarks are identified by and. All trademarks are owned by or licensed to Invacare Corporation or its subsidiaries unless otherwise noted. 1

3 TABLE of CONTENTS Description Page Number Cabinet & Base (Perfecto2V AW)... 6 Compressor & Mounting Hardware (Perfecto2VAW)... 8 Control Panel & P.C. Board (Perfecto2VAW) EU Customer Service Contact Information... 3 Packaging and Literature (Perfecto2V AW)... 5 Sieve Bed Assembly & Product Tank (Perfecto2VAW) Sound Box Assembly (Perfecto2VAW)

4 EU Customer Service Contacts European Customer Service Belgium & Luxemburg: Danmark: Deutschland European Distributor Organisation España: France: Invacare Site Invacare nv Autobaan 22, B-8210 Loppem Tel: (32) (0) Fax: (32) (0) Invacare A/S Sdr. Ringvej 37, DK-2605 Brøndby Tel: (45) (0) , Fax: (45) (0) / Invacare Aquatec GmbH Alemannenstraße 10, D Isny Tel: (49) (0) Fax: (49) (0) info@invacare-aquatec.com Invacare Deutschland GmbH Kleiststraße 49, D Porta Westfalica Tel: (49) (0) Fax: (49) (0) edo@invacare.com Invacare SA c/areny s/n, Polígon Industrial de Celrà, E Celrà (Girona) Tel: (34) (0) Fax: (34) (0) contactsp@invacare.com Invacare Poirier SAS Route de St Roch, F Fondettes Tel: (33) (0) Fax: (33) (0) contactfr@invacare.com European Customer Service Nederland: Norge: Österreich: Portugal: Sverige & Suomi: Switzerland: Invacare Site Invacare BV Celsiusstraat 46, NL-6716 BZ Ede Tel: (31) (0) Fax: (31) (0) nederland@invacare.com csede@invacare.com Invacare AS Grensesvingen 9, Postboks 6230, Etterstad, N-0603 Oslo Tel: (47) (0) Fax: (47) (0) norway@invacare.com island@invacare.com Invacare Austria GmbH Herzog Odilostrasse 101, A-5310 Mondsee Tel: (43) Fax: (43) info@invacare-austria.com Invacare Lda Rua Estrada Velha, 949, P Leça do Balio Tel: (351) (0) /47 Fax: (351) (0) portugal@invacare.com Invacare AB Fagerstagatan 9, S Spånga Tel: (46) (0) Fax: (46) (0) sweden@invacare.com finland@invacare.com Mobitec Rehab AG Benkenstrasse 260, CH-4108 Witterswil Tel: (41) (0) Fax: (41) (0) switzerland@invacare.com 3

5 EU Customer Service Contacts European Customer Service Invacare Site European Customer Service Invacare Site Ireland: Italia: Invacare Ireland Ltd Unit 5 Seatown Business Campus, Seatown Road, Swords County Dublin - Ireland Tel: (353) Fax: (353) ireland@invacare.com Invacare Mecc San s.r.l. Via dei Pini 62, I Thiene (VI) Tel: (39) Fax: (39) italia@invacare.com United Kingdom: Invacare Limited Pencoed Technology Park Pencoed, Bridgend CF35 5HZ Switchboard Tel: (44) (0) Fax: (44) (0) Customer services Tel: (44) (0) Fax: (44) (0) UK@invacare.com 4

6 Item Number Note Part Number Description NOTE: Packaging & Literature Perfecto2V AW Quantity Per Package Assembly A,B Kit, Packaging, Perfecto2 1 1 Carton, Shipper 1 1 Insert, Carton, Bottom 1 1 Insert, Carton, Top, Corrugated 1 1 Insert, Carton, Foam 1 1 Bag, Poly (39" L x 33" W) 1 1 A Kit V, Manual/Text Label - Northern Europe 1 1 Owner's Manual - Northern Europe 1 1 Label, Warning, French 1 1 Label, Warning, Italian 1 1 Label, Warning, German 1 1 Label, Warning, Polish 1 1 Label, Warning, Czech 1 1 A Kit V, Manual/Text Label - Southern Europe 1 1 Owner's Manual - Southern Europe 1 1 Label, Warning, French 1 1 Label, Warning, Italian 1 1 Label, Warning, Spanish 1 1 Label, Warning, Dutch 1 1 Label, Warning, Greek 1 1 Label, Warning, Portuguese 1 1 A Kit V, Manual/Text Label - Scandinavian 1 1 Owner's Manual - Scandinavian 1 1 Label, Warning, Danish 1 1 Label, Warning, Norwegian 1 1 Label, Warning, Finnish 1 1 Label, Warning, Swedish 1 1 A A - Not Shown Instruction Sheet, Attaching Cord and Air Scoop 1 1 B - Includes Shipper Carton, Bottom, Top, and Foam Insert and Poly Bag. 5

7 Cabinet and Base Perfecto2V AW 6

8 Item Number Note Part Number Description Cabinet and Base Perfecto2V AW Quantity Per Package Assembly 1 A Top Shroud Assembly Label, Text, English Label, Diagnostic Screw, Hi-Lo Six Lobe Drive (#10-16 x 5/8") Foam, Inlet - Ceiling Filter, Cabinet Door, Cabinet Access, Beige Foam, Inlet - Wall Foam, Shroud - Side Foam, Shroud - Front Clip, Retaining B Inlet Air Scoop Assembly C Base, Concentrator Foam, Damping - Base Foam, Resonator Foam, Damping Outlet Base Grommet, Plastic Cap, End, Dust, Green Screw, Phillips Round Washer Head Tap (8-18 x 1 1 1/2") Label, PO2VAW Spec 230V Label, Recycling Module, Inlet (15A/ 250 VAC) Label, European Rep Address Fitting, Hose Barb with Nut (1/8") Caster Assembly (2") Damper, Sound Base Power Cord Assembly w/ Clip NLA NLA - Baffle, Exhaust Label, PHTHALATE 1 1 NOTE: A - Includes Cabinet and Items B - Includes Inlet Foam and Scoop. C - Includes Base Only. 7

9 Compressor and Mounting Hardware Perfecto2VAW 8

10 Compressor and Mounting Hardware Perfecto2VAW Item Number Note Part Number Description Quantity Per Package Assembly 1 A Compressor Assembly, PO2V AW w/ Capacitor Fitting, Elbow (1/2" Beaded Hose x 1/4" NPT) Elbow, Male Flare B Kit, Capacitor (10 MFD) 1 1 Capacitor, 10 MFD 1 1 Tie Wrap (17-1/2" L) 1 1 Tie Wrap (8" L) 1 2 Instruction Sheet, Capacitor Replacement Screw, Hex Head Flange (1/4-20 x 7/8") Bushing, Mounting Spring, Compression (63/64 x 1-1/4 x 1/16") Tie Wrap (17-1/2" L) PO2VAW Compressor Rebuild Kit w/ Instructions 1 1 NOTE: A - Includes (1) Compressor, and Items 2, 3, and 4. You will also need to order (1) Tie Wrap Part # B - Includes (1) 10MFD Capacitor and (2) Tie Wraps and instructions. 9

11 Control Panel and P.C. Board Perfecto2VAW 10

12 Item Number Note Part Number Description NOTE: Control Panel and P.C. Board Perfecto2VAW Quantity Per Package Assembly Flowmeter without Palnuts - 5 Liter Connector, Barbed (1/4") Horn/Alarm Assembly Hour Meter Assembly with Clip PCB Assembly - PO2V Screw, Phillips Hex Washer Head (#8-16 x 3/8) Circuit Breaker (4 AMP) Tie Wrap (8" L) Tubing, PVC (1/4 x 1-3/4") Valve, Check Tubing, PVC (1/4 x 5") 1 1 P0750X030 Filter, HEPA Outlet Palnut (9/16-18) Switch, Powe On/Off Cord, Elastic Tie Wrap (3-29/32" L) Decal, Invacare Logo (1.6) Label, LED - PO2/PO2V/PO2W Panel, Control Jumper Wire Assembly NLA NLA - Power Jumper Assembly NLA NLA - Seal, Circuit Breaker 1 1 A,B Main Harness Assembly 1 1 A,B Wire Harness Valve Assembly 1 1 A - Not Shown. B - Connects to PC Board. 11

13 Sound Box Assembly Perfecto2VAW 12

14 Item Number Note Part Number Description Sound Box Assembly Perfecto2VAW Quantity Per Package Assembly Filter, Inlet Sound Reduced Tube, Clear (1/2 x 2-3/4") Coupling, Inlet Filter Resonator Assembly Screw, Phillips Hex Washer Head (#8-32 x 3/8") Soundbox, Horizontal Tie Wrap (8" L) NLA NLA - Fan, Exhaust Transformer Assembly, 20V - PO2AW Rivet, Isolator Mount Muffler Assembly Screw, Hi-Lo Six Lobe Drive (#10-16 x 5/8") Mount, Foam Valve 4-Way Foam, Soundbox - Vertical Gusset, Soundbox Heat Exchanger Assembly Clamp, Hose Adjustable (3/8") Foam, Resonator - Top Foam, Resonator - Bottom Foam, Soundbox - Ceiling Tube, Resonator Inlet Preformed Tube, Inlet Silencer Resonator, Inlet Tube, Resonator Outlet Preformed Soundbox, Vertical

15 Sieve Bed Assembly and Product Tank Perfecto2VAW 14

16 Sieve Bed Assembly and Product Tank Perfecto2VAW Item Number Note Part Number Description Quantity Per Package Assembly Product Tank Assembly w/ Senso2 Regulator Tie Wrap (8" L) A Kit, Regulator/Adaptor w/ Bled Adaptor, Foam 1 1 Mount and Check Valve Assy. Kit, Regulator and Adaptor w/ Bled Regulator 1 1 Mount, Foam Product Tank 1 1 Check Valve Assembly (14-1/2") 1 1 Tie Wrap (17-1/2" L) 1 1 Tie Wrap (8" L) 1 2 Instruction Sheet, Contents and Application B Check Valve Assembly (9") C Check Valve Assembly (14-1/2") D Kit, Sieve Beds (Pair) Tie Wrap (8" L) Tie Wrap (17-1/2" L) Sieve Bed Assembly Tie Wrap (8" L) Tie Wrap (17-1/2" L) Adapter, Sieve Bed Top Adapter, Sieve Bed Bottom PE Valve Assembly Tube, Exhaust Tie Wrap (8" L) Tube, F F Manifold, Air 1 1 G Kit, 4-Way Valve w/ Screws 1 1 H Valve, Operator Pilot Low Power O-Ring, Pilot Valve (35/64" I.D.) P0876X026 Clamp, Hose Tube, Polyurethane, Preformed (1/2") 1 2 J Support, Mid 1 1 NOTE: A - Kit includes the Regulator, Adaptor, Tank Mount, Check Valve, Tie Wraps, and Instruction Sheet. B - Includes (1) Valve, (2) Tie Wraps, (1) 6" Tubing and (1) 3" Tubing. C - Includes (1) Valve, (2) Tie Wraps, (1) 10" Tubing and (1) 4-1/2" Tubing. D - Includes items 7-9 F - Order with , , and G - Includes the 4-Way Valve with Screws only H - A new Pilot Valve O-Ring Part # is recommended when ordering a new Operator Pilot Low Power Valve J - Not shown on illustration. 15

17 Invacare Corporation One Invacare Way Elyria, Oh USA Technical Support Customer Service Literature Orders Invacare Corporation. All rights reserved. Republication, duplication or modification in whole or in part is prohibited without prior written permission from Invacare. Trademarks are identified by and. All trademarks are owned by or licensed to Invacare Corporation or its subsidiaries unless otherwise noted. (Revised 2/27/17)