State of New Jersey BOARD OF PUBLIC UTILITIES 44 SO. CLINTON STREET 7 TH FLOOR P.O. BOX 350 TRENTON, NEW JERSEY

Transcription

1 State of New Jersey BOARD OF PUBLIC UTILITIES 44 SO. CLINTON STREET 7 TH FLOOR P.O. BOX 350 TRENTON, NEW JERSEY CHRIS CHRISTIE GOVERNOR KIM GUADAGNO Lt. Governor January 18, 2011 LEE A. SOLOMON PRESIDENT JOSEPH SULLIVAN Director of Economic Development & Energy Policy Attn: Mr. Roger Kliemisch Market Manager 900 Route 9 North Woodbridge, NJ Re: Conditional Buy American Compliance Approval Please note: The NAED codes for the most commonly installed products are shown in bold and their corresponding Buy American compliant batch numbers are shown in red. PLEASE NOTE THAT SYLVANIA PRODUCTS MUST HAVE BATCH NUMBERS THAT CORRESPOND WITH AN AMERICAN SITE OF ASSEMBLY IN ORDER TO BE BUY AMERICAN COMPLIANT. Please call Osram Sylvania at to request information on certain NAED code batches. (The following Osram Sylvania product SKU s... NAED Codes are available by batch as manufactured in Versailles, KY: ,1,4, 22141, 22175, 21998, 21997, 21942, 21941, 21937, 21770, 21769, 21918, 21667, 21666, 22102, 22103, 22104, 22030, 21737, 21736, , 20949, 20862, 20935, 20936, 20937, 20904, 20903, 20934, 20933, 20932, 20931, 20929, 20928, ,1,2, 22184, 22063, 22060, 22062, 22202, , 22235, 22233, 22232, 22397, 22396, 22395, 22394, 22408, 22407, 22406, 22405, 22167, 22166, 22223, 22222, 22349, 22166, 22167, 22326, 22420, 22421, 22422, 22100, ,1,2, 22347, ,7,1, 22143, 22144, 22145, 22146, 22147, 22148, 22149, 22173, 22179, 21777, 22140, 22139, 22138, 22137, 22136, 22135) To Whom It May Concern: As the designated State Energy Office in New Jersey, the NJBPU has been tasked by the US Department of Energy to oversee all ARRAfunded projects in the state. As part of this supervisory role, the BPU will review compliance to the Buy American initiative for these projects. Attached please find a submittal cut sheet or compliance document that we received from your office, provided initially by one of your Direct Install Contractors. We have reviewed this document in light of ARRA Section 1605 and its appendices. At this time, we are pleased to qualify a conditional approval for the above-referenced materials based specifically on the manufacturers representations contained on each document. By no means is this an endorsement of a specific manufacturer or brand. Be advised that this conditional approval does not finalize the approval for this item. It is only a limited approval based upon the specific information given and applies only to the equipment mentioned in the subject line of this letter. Full compliance to Section 1605 remains in effect despite this conditional approval. Nevertheless, you may direct your Direct Install Contractor to proceed to utilize the above referenced equipment without exception at this time. Please contact me should this approval require further clarification. Very Truly Yours, Benjamin P. Fram Buy American Compliance Analyst - ARRA (609)

2 OCTRON 800 ECOLOGIC Fluorescent Lamps Key Features & Benefits Passes Federal TCLP test* Energy efficient T8 lamp Made in the USA Lead free RoHS compliant Compatible with QUICKTRONIC electronic ballasts QUICK 60+ System Warranty ECOLOGIC is a comprehensive program of OSRAM SYLVANIA focused on addressing environmental issues at all stages of lamp life. * Regulations may vary. Check your local and state regulations. OCTRON 800 ECOLOGIC T8 lamps offer a high quality solution for general purpose fluorescent lighting applications where color is important. These lamps are available in a wide range of color temperatures: 3000K, 3500K, 4100K and 5000K that feature improved color rendering and lumen maintenance when compared to 700 series lamps. When paired with QUICKTRONIC electronic ballasts, these systems are a good alternative to T12 fluorescent systems and are covered by the comprehensive QUICK 60+ system warranty. Product Offering Ordering Abbreviation Wattage Lumens CRI FO17/800/ECO FO25/800/ECO FO32/800/ECO FO40/800/ECO FO96/800/ECO Application Information Applications Cove Recessed troffer Strip light fixture Valance Application Notes 1. Lamps starting down to -20 F (dependent on ballast) 2. Operation below 50 F may affect lumen output or lamp operation. 3. For cold temperature applications, use in enclosed fixture or use tube to maximize lamp performance. 4. For rapid start operation, check with ballast manufacturer for ground plane requirement. 5. For maximum energy savings, operate on electronic instant start ballast. FL085R1 11/10

3 Ordering Information Rated Life Instant Start Programmed Rapid Start Item Ordering Nominal Initial Mean 3 hrs/ 12 hrs/ 3 hrs/ 12 hrs/ Number Abbreviation Length Lumens Lumens 1 start start start start CCT CRI FO17/830/ECO 24 1,350 1,269 24,000 28,000 30,000 36, K FO17/835/ECO 24 1,350 1,269 24,000 28,000 30,000 36, K FO17/841/ECO 24 1,350 1,269 24,000 28,000 30,000 36, K FO25/830/ECO 36 2,150 2,021 24,000 28,000 30,000 36, K FO25/835/ECO 36 2,150 2,021 24,000 28,000 30,000 36, K FO25/841/ECO 36 2,150 2,021 24,000 28,000 30,000 36, K FO32/830/ECO 48 2,950 2,773 24,000 28,000 30,000 36, K FO32/835/ECO 48 2,950 2,773 24,000 28,000 30,000 36, K FO32/841/ECO 48 2,950 2,773 24,000 28,000 30,000 36, K FO32/850/ECO 48 2,950 2,773 24,000 28,000 30,000 36, K FO40/830/ECO 60 3,650 3,431 24,000 28,000 30,000 36, K FO40/835/ECO 60 3,650 3,431 24,000 28,000 30,000 36, K FO40/841/ECO 60 3,650 3,431 24,000 28,000 30,000 36, K FO96/830/ECO 96 5,900 5,428 18,000 24, K FO96/835/ECO 96 5,900 5,428 18,000 24, K FO96/841/ECO 96 5,900 5,428 18,000 24, K FO96/850/ECO 96 5,900 5,428 18,000 24, K Mean lumens measured at 40% of rated life. Ordering Guide FO 32 / 8 35 / ECO Fluorescent Wattage: 8 = CRI 30 = 3000K CCT ECOLOGIC OCTRON 17, 25, 32, 40 or 96 watts 35 = 3500K CCT 41 = 4100K CCT 50 = 5000K CCT Specification Data Catalog # Type Project Comments Prepared by Date Sample Specification Lamp(s) shall be an OCTRON ECOLOGIC lamp(s) (FO17/ECO, FO25/ECO, FO32/ECO, FO40/ECO and FO96/ECO) having medium bi-pin bases. Lamp(s) shall be designed to pass the Federal TCLP test in force at the time of manufacture. Lamp(s) shall have a correlated color temperature of (3000K, 3500K, 4100K or 5000K) and a CRI of (80, 82 or 85). The OCTRON lamp(s) shall be operated on dedicated QUICKTRONIC ballast(s) with complete system warranty from one manufacturer covering lamp(s) and ballast(s). Technical Information Typical Fluorescent Lamp Mortality PERCENT SURVIVING PERCENT RATED LIFE Related Literature For maximum energy savings consider pairing with the following electronic ballast: Ballast Technology Applications & Specification Guide (Literature Code: ECS-Electronic2009) QUICK 60+ System Warranty (Literature Code: ECS140) United States OSRAM SYLVANIA 100 Endicott Street Danvers, MA Phone: Fax: National Accounts Phone: Fax: OEM/Special Markets Phone: Display/Optic Phone: Canada OSRAM SYLVANIA LTD Drew Road Mississauga, ON L5S 1S4 Phone: OEM/Special Markets/Display/Optic Phone: OSRAM SYLVANIA 11/10 Photography FL085R1 11/10 SYLVANIA is a registered trademark of OSRAM SYLVANIA Inc. SEE THE WORLD IN A NEW LIGHT is a registered trademark of OSRAM SYLVANIA Inc. OCTRON, ECOLOGIC and QUICK 60+ are registered trademarks of OSRAM SYLVANIA Inc. QUICKTRONIC is a registered trademark of OSRAM GmbH.

4 OCTRON 800 XP SUPERSAVER ECOLOGIC 3 EXtended Performance Fluorescent Lamps Key Features & Benefits Energy savings compared to standard 32W T8 lamp 22% with the 25W XP /SS 12% with the 28W XP /SS 6% with the 30W XP /SS 94% lumen maintenance Lead free Made in the USA Dimmable (see application note 5) TCLP and RoHS compliant Retrofit lamp for existing T8 instant start systems 40,000 hours rated 12 hours per start Increased life on SYLVANIA QUICKTRONIC PROStart PSX and PSN programmed rapid start ballasts 42,000 hours rated 12 hours per start Available in 2, 3, 4 and 8-foot and extended Life (XL) types The OCTRON 800XP SUPERSAVER T8 fluorescent offering includes a full complement of lengths and wattages, ensuring there is an energy-saving lamp to satisfy nearly all applications. These lamps operate on standard T8 instant start systems and provide up to 22 percent energy savings over 32 Watt lamps. At 10 /kwh and 4000 hours of operation per year, the 22 percent energy savings translate to a savings of $11.20 per fixture per year for a 4-lamp fixture. The initial lumen output, lumen maintenance and high color rendering of the OCTRON 800 XP SUPERSAVER/ECO3 lamps help ensure that lighting quality is maintained while energy is saved. These lamps pass the Federal TCLP test, classifying them as non-hazardous waste in most states and feature lead-free glass, bases and manufacturing process, reducing overall environmental impact. For optimal performance and system warranty, pair with QUICKTRONIC electronic ballast systems. SYLVANIA OCTRON ECOLOGIC3 T8 fluorescent lamps pass the Federal Toxic Characteristic Leaching Procedure (TCLP) 1 criteria for classification as non-hazardous waste in most states 2. ECOLOGIC3 represents a more comprehensive approach to sustainability encompassing high efficiency, long life and RoHS/TCLP compliance. 1. TCLP test results are based on NEMA LL Series standards and are available on request. 2. Lamp disposal regulations may vary; check your local & state regulations. Product Offering Lamp Type Wattage CCT FO17/15W/800XP/SS/ECO K, 3500K, 4100K, 5000K FO25/21W/800XP/SS/ECO K, 3500K, 4100K, 5000K FO32/25W/800XP/SS/ECO K, 3500K, 4100K, 5000K FO28/800XP/SS/ECO K, 3500K, 4100K, 5000K FO30/800XP/SS/ECO K, 3500K, 4100K, 5000K FO32/25W/800/XP/XL/SS/ECO K, 3500K, 4100K FO28/800/XP/XL/SS/ECO K, 4100K, 5000K FO96/50W/800/XP/SS/ECO K, 4100K, 5000K FO96/54W/800/XP/SS/ECO K, 4100K, 5000K Application Information Applications Cove Direct/indirect luminaires Recessed troffers Schools Valance Application Notes 1. FO25, FO28 and FO30 SUPERSAVER lamps are recommended to be used on F32T8 instant start ballast with minimum open circuit voltage of 550V RMS at the lamp. a. Electronically ballasted fixture configurations which operate lamps remotely, such as Master/Satellite applications, can cause reduction of lamp open circuit voltage, in the remote fixture, below the minimum required for reliable lamp starting. For more information, please call LIGHTBULB and ask for Ballast Technical Assistance or call your fixture manufacturer. b. Not recommended to be used: (1) in remotely ballasted fixtures with lamp open circuit voltages below 550V, (2) with Rapid Start ballasts unless the lamp open circuit voltage is greater than 570V, (3) in air handling fixtures, (4) on low power factor ballasts or (5) inverter operated emergency lighting systems unless the equipment is specifically listed for the particular lamps. Any of the above situations could result in lamp starting and stabilization problems, or system compatibility issues. 2. FO96 SUPERSAVER lamps are recommended to be used on F96T8 instant start ballast with minimum open circuit voltage of 725V. 3. If an operating lamp is exposed to drafts or the ambient temperature falls below 60 F (70 F for 25W), striation (a rhythmic pulsing pattern of light running down the tube) and/or reduction in lamp brightness may occur. While visually disconcerting, neither behavior is damaging to the lamp and removing the cause (draft or temperature) will return the lamp to normal operation. 4. Fixture must conform to ANSI C requirements for luminaire design. 5. FO96 types are not dimmable. For all other types, contact OSRAM SYLVANIA for approved dimming ballasts. FL056R14 1/11

5 Ordering Information Average Rated Life Nominal Instant Start Prog. Rapid Start Item Ordering Length Initial Mean Lumens 3 hrs/ 12 hrs/ 3 hrs/ 12 hrs/ Number Abbreviation Watts (in) Lumens Lumens 1 per Watt start start start start CCT CRI OCTRON 800 XP SUPERSAVER F017/15W/830/XP/SS/ECO ,000 40,000 40,000 42, K F017/15W/835/XP/SS/ECO ,000 40,000 40,000 42, K F017/15W/841/XP/SS/ECO ,000 40,000 40,000 42, K F017/15W/850/XP/SS/ECO ,000 40,000 40,000 42, K F025/21W/830/XP/SS/ECO ,000 40,000 40,000 42, K F025/21W/835/XP/SS/ECO ,000 40,000 40,000 42, K F025/21W/841/XP/SS/ECO ,000 40,000 40,000 42, K F025/21W/850/XP/SS/ECO ,000 40,000 40,000 42, K FO32/25W/830/XP/SS/ECO ,000 40,000 40,000 42, K FO32/25W/835/XP/SS/ECO ,000 40,000 40,000 42, K FO32/25W/841/XP/SS/ECO ,000 40,000 40,000 42, K FO32/25W/850/XP/SS/ECO ,000 40,000 40,000 42, K FO28/830/XP/SS/ECO ,000 40,000 40,000 42, K FO28/835/XP/SS/ECO ,000 40,000 40,000 42, K FO28/841/XP/SS/ECO ,000 40,000 40,000 42, K FO28/850/XP/SS/ECO ,000 40,000 40,000 42, K FO30/830/XP/SS/ECO ,000 40,000 40,000 42, K FO30/835/XP/SS/ECO ,000 40,000 40,000 42, K FO30/841/XP/SS/ECO ,000 40,000 40,000 42, K FO30/850/XP/SS/ECO ,000 40,000 40,000 42, K 80 OCTRON 800 XP XL SUPERSAVER FO32/25W/830/XP/XL/SS/ECO ,000 50,000 52,000 55, K FO32/25W/835/XP/XL/SS/ECO ,000 50,000 52,000 55, K FO32/25W/841/XP/XL/SS/ECO ,000 50,000 52,000 55, K FO28/835/XP/XL/SS/ECO ,000 50,000 52,000 55, K FO28/841/XP/XL/SS/ECO ,000 50,000 52,000 55, K FO28/850/XP/XL/SS/ECO ,000 50,000 52,000 55, K 80 OCTRON FO96 XP SUPERSAVER FO96/50W/835/XP/SS/ECO ,000 36, K FO96/50W/841/XP/SS/ECO ,000 36, K FO96/50W/850/XP/SS/ECO ,000 36, K FO96/54W/835/XP/SS/ECO ,000 36, K FO96/54W/841/XP/SS/ECO ,000 36, K FO96/54W/850/XP/SS/ECO ,000 36, K Measured at 40% of rated life. Ordering Guide FO 30 / 8 35 XP / SS / ECO3 Fluorescent Actual Wattage Actual CRI Color Temperature EXtended SUPERSAVER ECOLOGIC3 OCTRON 15, 21,25, 80 or = 3000K CCT, 35 = 3500K CCT Performance 28, 30, 50 and = 4100K CCT, 50 = 5000K CCT Lamp Dimensions (A) Max. (B) Base Face (C) Max. Base (D) Max. Lamp Overall to Opposite Face to Base Outside Type Length (in.) Pin (in.) Face (in.) Diameter (in.) FO Min Max FO Min Max FO Min FO32/25W Max FO28 FO30 FO Min Max Related Literature For maximum energy savings consider pairing with the following electronic ballasts: Ballast Technology Applications & Specification Guide (Literature code: ECS-Electronic2009) QUICKTRONIC High Efficiency NEMA Premium Guide (Literature code: ECS112) QUICK 60+ System Warranty (Literature code: ECS140) A B C A B C D D Specification Data Fixture Description Type Project/Job SYLVANIA lamp SYLVANIA ballast Notes Sample Specification Lamp shall be OCTRON 800 XP SUPERSAVER ECOLOGIC 3 (15W, 21W, 25W, 28W, 30W, 50W, 54W) lamp having medium bi-pin bases or 50W and 54W lamp having single pin bases. Lamp shall be designed to pass the Federal TCLP test in force at the time of manufacture. Lamps shall have initial lumens of (1200, 1925, 2400, 2475, 2600, 2725, 2850, 5400, 5700), mean lumens of (1128, 1810, 2304, 2327, 2496, 2562, 2679, 5076, 5360) and a correlated color temperature of (3000, 3500, 4100) Kelvin or initial lumens of (2400, 2600, 2800, 5700) and mean lumens of (2256, 2444, 2632, 5360) and a correlated color temperature of 5000K. Lamp shall have an average rated life of (24,000, 40,000, 42,000) on (instant start, programmed rapid start) ballasts, 94% lumen maintenance at 40% of rated life and a CRI of (85, 80). The OCTRON XP SUPERSAVER ECOLOGIC3 lamp shall be operated on QUICKTRONIC electronic, high frequency ballasts with complete system warranty from the manufacturer covering lamps and ballast. United States OSRAM SYLVANIA 100 Endicott Street Danvers, MA Phone: Fax: National Accounts Phone: Fax: OEM/Special Markets Phone: Display/Optic Phone: Canada OSRAM SYLVANIA LTD Drew Road Mississauga, ON L5S 1S4 Phone: OEM/Special Markets/Display/Optic Phone: OSRAM SYLVANIA 1/11 Photography FL056R14 SYLVANIA, ECOLOGIC, OCTRON, QUICK 60+, SUPERSAVER and XP are registered trademarks of OSRAM SYLVANIA Inc. SEE THE WORLD IN A NEW LIGHT is a registered trademark of OSRAM SYLVANIA Inc. QUICKTRONIC is a registered trademark of OSRAM GmbH.

6 PENTRON HO ECOLOGIC High Output T5 Linear Fluorescent Lamps Key Features & Benefits High Performance T5 lamps 94 Lumens per Watt 93% Lumen maintenance Peak lumen output at 35 C (95 F) Long life Up to 40,000 hours life Greater luminaire design flexibility Small lamp profile allows for more compact, high light output options Nominal 2', 3', 4', and 5' Approx. 2" shorter than T8 lengths Miniature bi-pin bases TCLP & RoHS Compliant Lead free glass Made in the USA PENTRON HO ECOLOGIC T5 linear fluorescent lamps offer a high quality lighting solution for applications where aesthetics and/or high lumen output and long life are important. With a small lamp profile of 5/8" and lumen output that is almost twice that of T8 fluorescent lamps, these lamps offer the prospect of small luminaire designs capable of delivering illuminance levels satisfying general ambient lighting requirements ranging from general office and classrooms to industrial manufacturing. PENTRON HO ECOLOGIC T5 linear lamps are available in 2, 3, 4 and 5-foot lengths and offer a wide range of color temperatures: 3000K, 3500K, 4100K, 5000K and 6500K with up to 40,000 hours life and excellent lumen maintenance and CRI. These lamps are ideally paired with QUICKTRONIC QHE PROStart ballasts and the system is covered by a comprehensive QUICK 60+ system warranty. ECOLOGIC is a comprehensive program of OSRAM SYLVANIA focused on addressing environmental issues at all stages of lamp life. Product Offering Ordering Abbreviation Watts CCT FP24/800/HO/ECO K, 3500K, 4100K FP39/800/HO/ECO K, 3500K, 4100K FP54/800/HO/ECO K, 3500K, 4100K, 5000K, 6500K FP80/800/HO/ECO K, 3500K, 4100K Application Information Applications Canopy High bay fixtures Indirect luminaires Security lighting Signage Application Notes 1. PENTRON HO ECO lamps are about 2" shorter than T8 & T12 Bi-Pin lamps. 2. Miniature Bi-Pin bases will not install into T8 & T12 sockets. 3. Miniature Bi-Pin bases require UL Listed 600 Volt rated sockets. 4. Requires high frequency programmed rapid start electronic ballasts for T5s equipped with end-of-life sensing circuit. 5. Apply thermal factor in calculations for use in exterior or unheated applications. FL092 12/10

7 Specification Data Fixture Description: Project/Job: SYLVANIA lamp: SYLVANIA ballast: Notes: Type Ordering Information Item Ordering Nominal Initial Initial Programmed Rapid Start Number Abbreviation Watt Length (in) 35 C 25 C MOL (mm) 3 hrs/start 12 hrs/start CCT CRI FP24/830/HO/ECO ,000 1, ,000 30, K FP24/835/HO/ECO ,000 1, ,000 30, K FP24/841/HO/ECO ,000 1, ,000 30, K FP39/830/HO/ECO ,500 3, ,000 30, K FP39/835/HO/ECO ,500 3, ,000 30, K FP39/841/HO/ECO ,500 3, ,000 30, K FP54/830/HO/ECO ,000 4, ,000 40, K FP54/835/HO/ECO ,000 4, ,000 40, K FP54/841/HO/ECO ,000 4, ,000 40, K FP54/850/HO/ECO ,900 4, ,000 40, K FP54/865/HO/ECO ,750 4, ,000 40, K FP80/830/HO/ECO ,000 6, ,000 30, K FP80/835/HO/ECO ,000 6, ,000 30, K FP80/841/HO/ECO ,000 6, ,000 30, K 85 Ordering Guide FP 80 / 8 30 / HO / ECO Fluorescent Wattage: 8 = 85 CRI 30 = 3000K CCT High Output ECOLOGIC PENTRON T5 HO 24, 39, = 3500K CCT, 41 = 4100K CCT or 80 watts 50 = 5000K CCT, 65 = 6500K CCT FL092

8 Technical Information Dimensions (A) Max. Overall (B) Base Face to (C) Base Face (D) Max. Outside Ordering Overall Length Opposite Pin to Base Face Diameter Abbreviation mm (in.) mm (in.) mm (in.) mm (in.) FP24/HO (22.17) ( ) ( ) 17.0 (0.67) FP39/HO (33.89) ( ) ( ) 17.0 (0.67) FP54/HO (45.80) ( ) ( ) 17.0 (0.67) FP80/HO (57.61) ( ) ( ) 17.0 (0.67) A B C D Typical Fluorescent Lamp Mortality Fluorescent Lamp Lumen Maintenance PERCENT SURVIVING PERCENT RATED LIFE PERCENT RATED LUMENS 100 T5 90 T8 80 CW/HO ,000 15,000 20,000 BURNING HOURS * Lumen output continues to decrease throughout the life of a fluorescent lamp. Related Literature For optimum system performance and warranty pair with QUICKTRONIC electronic ballast systems: Ballast Technology Applications & Specification Guide (Literature Code: ECS-Electronic2009) QUICK 60+ System Warranty (Literature Code: ECS140) FL092

9 Sample Specification Lamps shall be PENTRON T5 HO ECOLOGIC lamps having miniature bi-pin bases and a minimum of 93% lumen maintenance. Lamps shall have a correlated color temperature of (3000K, 3500K, 4100K, 5000K and 6500K) and a CRI of 82 or 85. The PENTRON T5 HO ECO lamps shall be operated on dedicated QUICKTRONIC PHO ballasts having a primary voltage of (120V, 277V) with complete system warranty from the manufacturer covering lamps and ballasts. SYLVANIA is a registered trademark of OSRAM SYLVANIA Inc. SEE THE WORLD IN A NEW LIGHT is a registered trademark of OSRAM SYLVANIA Inc. ECOLOGIC, ECO, PENTRON and QUICK 60+ are registered trademarks of OSRAM SYLVANIA Inc. QUICKTRONIC is a registered trademark of OSRAM GmbH. FL092 United States OSRAM SYLVANIA 100 Endicott Street Danvers, MA Phone: Fax: National Accounts Phone: Fax: OEM/Special Markets Phone: Display/Optic Phone: Canada OSRAM SYLVANIA LTD Drew Road Mississauga, ON L5S 1S4 Phone: OEM/Special Markets/Display/Optic Phone: OSRAM SYLVANIA 12/10 Photography