Types Of Containers. Introduction. Multi Mode. Standard. The Standard International Box. Emergency Response Solutions
|
|
- Derek Wheeler
- 6 years ago
- Views:
Transcription
1 Emergency Response Solutions Introduction Copyright 2016 All rights reserved. Types Of Containers Dry Freight Flat Racks Open Top Tunnel Open side Double Door Refrigerated Insulated / thermal Tanks Cargo Storage Roll Half Height Car carriers Intermediate bulk Drums Special Purpose Swap Bodies Intermodal Portable Tanks Slide 2 Multi Mode Intermodal transportation involves the use of two or more modes of transportation in moving a shipment from origin to destination, primarily through the use of the container. Slide 3 Slide 4 Standard Standardization of dimensions, hold-down devices, and related items allowed the service providers to design ships, railcars, and highway chassis, knowing the container or box would fit The Standard International Box Steel boxes with doors, no wheels, brakes, lights, 15 million units exist worldwide Jargon unit is the TEU Twenty-foot Equivalent Unit, i.e. 20 long, 8 wide, 8.5 ft high They stack 9 high Slide 5 Slide 6
2 TEU Intermodal Containers ISO specifications Corner posts take load Corner blocks for rigging Corrugated steel sides & top Doors on one end (or more) Hardwood plywood floor sealed to sides Angle/channel steel support below floor, fork pockets And It s Big Brother Jargon unit is the FEU Forty-foot Equivalent Unit, i.e. 40 long, 8 wide, 8.5 ft high They stack 9 high also Slide 7 Slide 8 Containers stack 9 high fully loaded Bottom container can support 8 Stack 9 high in ship holds Stack 5-6 high on land and above deck on ships Slide 9 Slide 10 Statistics 183 million (TEU s) moved annually 6.7 million are in transit now World Shipping Organization says average since 2011 of 2683 containers lost at sea per year Unofficial estimates as high as 10,000 This does not include tanks Largest Ship (Maersk McKinney Mollar will carry 18,270 TEU s Slide 11 Slide 12
3 Intermodal Containers Highway Rail Ship Air Liquids Solids Gases Cryogenics Slide 13 Slide 14 Slide 15 Slide 15 Slide 16 Slide 17 Slide 18 Slide 18
4 Front / Rear Front The end opposite the bottom discharge. If the tank container is top discharge only, the opposite end from the top discharge is the front. Rear The end where the bottom discharge is located. If the tank container is top discharge only, the end closest to the top discharge is the rear. Left / Right As the observer faces the rear of the tank container, the left side is on the observer s left, and the right side is on the observer s right. Note: When the observer is facing the front of the tank container, this logic does not apply. Slide 19 Slide 20 Beam frame - tank part of frame Heating Coils Box frame - tank not part of frame Slide 21 Slide 22 Emergency Shutoffs Materials Of Construction 90% are stainless steel Aluminum and steel Lined Slide 23 Slide 24
5 Corner Castings Slide 25 Slide 26 Emergency Response Solutions Tank Features Drain Tubes Copyright 2016 All rights reserved. Slide 28 Document Holder Drain Tubes Internal to Jacket Slide 29 Slide 30
6 Mail Box Slide 31 Slide 32 Slide 32 Marking 49CFR IMDG Code 4.2 Proper shipping name Technical names Exemptions TIH Slide 33 Slide 34 Data Plates CSC Plates Data Plate A corrosion resistant metal identification plate that is permanently attached to the tank container and readily accessible for inspection. CSC Plate A corrosion resistant metal plate (not less than 200 mm x 100 mm) permanently attached to frame, indicating type, approval number, basic structural data, allowable stacking and racking values, the owner s structural examination scheme-number and future inspection date (CSC Convention). Slide 35 Slide 36
7 Slide 37 Slide 38 Markings Identification system Owner code Equipment category identifier Serial number Check digit Size and type codes Operational marks Approvals Amount of Material and Container Max gross Tare Net Slide 39 Slide 40 Container Number Container Markings Container Markings American Rail Marine Pollutant Name Canadian Rail Pressure French Rail European Road / Rail Slide 41 Special Markings European Guide UN Number Slide 42
8 Country Codes Common Size Codes CodeLength Height ft 8 ft ft 8 ft 6 in ft >8 ft 6 in MAWP Codes - Bar (psi) Non-dangerous liquids (6.5) (21.8) (38.4) Dangerous liquids (21.8) (38.4) (58.0) (87.0) Dangerous gases (152.3) (319.1) 79 spare New Markings MAWP Codes - Bar (psi) Non-dangerous liquids T (6.5) T1 1.5 (21.8) T (38.4) Dangerous liquids T3 1.5 (21.8) T (38.4) T5 4.0 (58.0) T6 6.0 (87.0) Dangerous gases T (152.3) T (319.1) T9 spare Slide 43 Slide 44 End Marking Examples Types of ISO Containers IMO Type 1 Type 2 Type 5 Type 7 DOT IM 101 IM 102 DOT 51 New DOT Slide 45 Slide 46 Emergency Response Solutions New DOT Copyright 2016 All rights reserved. Domestic 49 CFR (c)(2) (2) A DOT Specification 51, IM101, or IM102 portable tank may not be manufactured after January 1,2003; however, such tanks may continue to be used for the transportation of a hazardous material provided they meet the requirements of this subchapter, including the specification requirements and the requirements of this subchapter for the transportation of the particular hazardous material according to the T codes in effect on September 30,2001 or the new T codes in (c)(7)(i) Slide 48
9 Gases Liquefied compressed gases are assigned to portable tank instruction T50. Refrigerated liquefied gases that are authorized to be transported in portable tanks are specified in tank instruction T75. Slide 49 Slide 50 Slide 51 Slide 52 IM 102 / IMO Type 2 Type 2 Container Design pressure 14.5 psi (1 bar) to 25.4 psi (1.75 bar) Capacities Up to 6000 gallons (23,000 liters) Products Non regulated material, food, low hazard materials Slide 53 Slide 54
10 Slide 55 Slide 56 Slide 57 Slide 58 IM 101 / IMO Type 1 Design pressure 25.4 psi (1.75 bar) to 100 psi (6.8 bar) Capacities Up to 6000 gallons (23,000 liters) Products Solvents, flammable liquids, toxic materials, corrosives Slide 59 Slide 60
11 High Temperature Slide 61 Slide 62 2 Compartment Slide 63 Slide 64 Slide 65 Slide 66
12 End View 10 Foot Container Certification plates Valve box Slide 67 Slide 68 Slide 69 Slide 70 Swing bolt manway Relief devices with frangible disks and telltale Different Style Bottom Outlet Valves Found on IM 101 Containers Slide 71 Slide 72
13 Vapor Line Liquid Line Pressure Gauge IM 101 Top Valves for Ground Unloading Slide 73 Slide 74 IM 101 Top Valve System Liquid Liquid Vapor Vapor Fill Port Slide 75 Slide 76 Load Valve Vent Liquid Level gauge Vapor Liquid Slide 77 Slide 78
14 Don t step on me Rupture disc IM 101 Top Manway Box Slide 79 Slide 80 DOT 51 / IMO Type 5 Design pressure 100 psi (6.9 bar) to 500 psi (34.5 bar) Capacities Up to 5500 gallons (21,000 liters) Products Liquefied gases (anhydrous ammonia, methyl amines, ethylene oxide) and high toxicity materials Slide 81 Slide 82 Typical DOT 51 Relief Devices Sun Shield Frangible disk In combination 10% above RV Appropriate for vacuum pressures Appropriate temperature rating Relief valve Spring loaded Slide 83 Slide 84
15 DOT 51 Container Slide 85 Slide 86 DOT 51 Rear View Studded Boss Manway Container Number DOT 51 Valve Box Product Name Valve Box Slide 87 Slide 88 Valves DOT 51 Valve Arrangement Internal Vapor Valve Internal Liquid Valve Slide 89 Slide 90
16 DOT 51 Valve Arrangement DOT 51 Valve Arrangement Cable Valve Operator External Vapor Valve Vapor External Liquid Valve Liquid Slide 91 Slide 92 Slide 93 Slide 94 End view of DOT 51 / IMO 1 Container Bromine Type 5 Slide 95 Slide 96
17 Slide 97 Slide 98 Slide 99 Slide 100 Sun Shield Relief Valve Slide 101 Slide 102
18 Type 7 - Cryogenic Slide 103 Slide 104 Slide 105 Slide 106 Slide 107 Slide 108
19 Liquid Oxygen Liquid Argon Slide 109 Slide 110 Slide 111 Slide 112 Emergency Response Solutions Intermodal Box Copyright 2016 All rights reserved. Slide 113
20 Typical Boxes 20 ft Dry Freight 40 ft Dry Freight (8' 6" high) 40 ft Dry Freight (9' 6" high) 45 ft Dry Freight 48 ft Dry Freight 53 ft Dry Freight Slide 115 Slide 116 Intermodal Box Containers Material loaded must be in proper condition for transportation Any slack space between packages must be filled with dunnage Slide 117 Slide 118 Intermodal Box Containers Packages secured to prevent shifting in any direction Slide 119 Slide 120
21 Boxes Dry freight Drums Bag in a box Dry Liquid Slide 121 Slide 122 Slide 123 Slide 124 Slide 125 Slide 126
22 Tube Intermodal Tube Trailers Multi - tube configuration, these transport bulk non liquefied compressed gases Pressures up to 5000 psi Slide 127 Slide 128 Slide 129 Slide 130 Slide 131 Slide 132
23 Slide 133 Slide 134 Dry Bulk Container Slide 135 Slide 136 Slide 137 Slide 138
24 Refrigeration /Heating Units Electric shore power Electric own power Combination Refer units Steam Slide 139 Slide 140 Slide 141 Slide 142 Clip On Gen Set Unit Slide 143 Slide 144
Dangerous Goods. Transport Tanks
Dangerous Goods and Rail Safety A Technical Publication from ALBERTA EDGE (ENVIRONMENTAL AND DANGEROUS GOODS EMERGENCIES) Dangerous Goods February 2019 - 1 - This material is meant as a guide to certain
More informationDangerous Goods. Transport Tanks
Dangerous Goods and Rail Safety Dangerous Goods, Rail Safety & 511 A Technical Publication from the Co-ordination and Information Centre Dangerous Goods Transport Tanks July 2017 - 1 - This material is
More informationInner vessels and pipework are made of stainless steel - used for multipurpose transportation of CO2, N2, O2 and Ar.
CO2 Storage 20 ASCO ISO Tank Containers ASCO CO2 and Cryogenic 20 ISO Tank Containers include a high quality vacuum multi-laminar super insulation and are supplied complete with all pipework, valves, safety
More informationFASTENERS, SPRINGS, DETENT BALLS & MISC. HARDWARE PAINT, SEALANT, ADHESIVES, DECALS & LEAK DETECTORS
CROSS REFERENCE LANDING LEG PARTS TWISTLOCK & PINLOCK ASSEMBLIES & PARTS STEEL PANELS & STRUCTURAL STEEL ALUMINUM EXTRUSIONS & STRUCTUAL COMPONENTS DOOR HARDWARE AXLES, SUSPENSION PARTS, 5TH WHEEL & COMPONENTS
More informationSPECIALIZED CARRIERS 2016 RENTAL CATALOG. Updated August 31, :58 AM Tiger Offshore Rentals 1
2016 RENTAL CATALOG SPECIALIZED CARRIERS Updated August 31, 2016 10:58 AM www.tigeroffshorerentals.com 1.877.844.3791 Tiger Offshore Rentals 1 Who is Tiger Offshore Rentals? Tiger Offshore Rentals is America's
More informationGuide to Ocean Freight Containers
Guide to Ocean Freight Containers Select a category: Introduction The following Guide to Ocean Freight Container Specifications is provided courtesy of Hapag- Lloyd America Inc. The container specifications
More informationSpecification Sheet Form Rev
Sales Administration Use Only Customer Quote Number Quote Revision Shop Order Number Serial Number(s) Date : Customer Name Salesperson Model : Salesperson Name : 8400 DDC S1 Part / Drawing Number : 730-8400
More informationContainer. specifications
Container specifications Introduction This list gives technical data on all the types of containers such as: dimensions weights design features All values listed in the tables are given in metric. Ft and
More informationASSOCIATION OF AMERICAN RAILROADS BUREAU OF EXPLOSIVES
ASSOCIATION OF AMERICAN RAILROADS BUREAU OF EXPLOSIVES ANNUAL REPORT OF NON-ACCIDENT RELEASES OF HAZARDOUS MATERIALS TRANSPORTED BY RAIL 2016 (United States & Canada) Published August 2017 Report BOE 16-2
More informationABOUT GAS INNOVATIONS
ABOUT GAS INNOVATIONS Gas Innovations has become a world leading provider of high purity hydrocarbons in the refrigerant, pharmaceutical, industrial, electronics and agricultural chemical industries. Ancillary
More information49 CFR Updates Dangerous Goods Symposium September 6, Brian Beetz Manager, Regulatory Affairs & Corporate Responsibility
49 CFR Updates Dangerous Goods Symposium September 6, 2017 Brian Beetz Manager, Regulatory Affairs & Corporate Responsibility 49 CFR Transitional Exceptions January 7, 2013 HM-215L Final Rule Harmonized
More informationTransportation and Transfer
Participant Guide Module 4 Transportation and Transfer Module Objective Upon completion of this module, participants should be able to describe how ethanol-blended fuels are transported and transferred
More informationSpecification Sheet Form Rev
10000 CDC S1 Sales Administration Use Only Quote Number Quote Revision Shop Order Number Serial Number(s) Date CUSTOMER SALESPERSON MODEL : Customer Name : Salesperson Name : 10000 CDC S1 PART NO./DRAWING
More informationSEA CONTAINER SPECIFICATIONS
SEA CONTAINER SPECIFICATIONS 20 Dry Container Specification Suitable for commodities in bundles, cartons, boxes, loose cargo, furnitures, etc. Width 2,352 mm 7ft 8.6 in Interior Height 2,395 mm 7 ft 10.3
More informationTRANSFER OF ORGANIC COMPOUNDS INTO MOBILE TRANSPORT TANKS (Effect: 5/6/77: Rev. Effect. 7/26/00)
RULE 61.2. TRANSFER OF ORGANIC COMPOUNDS INTO MOBILE TRANSPORT TANKS (Effect: 5/6/77: Rev. Effect. 7/26/00) (a) APPLICABILITY Except as otherwise provided in Section (b), this rule is applicable to the
More informationTECHNICAL SPECIFICATION CLIENT : MCM
TECHNICAL SPECIFICATION CLIENT : MCM A SPECIFICATION NO.: TSGT0951 Rev A As Built WO 100048 DESCRIPTION : 5 x 24 500 LITRE 25,0/27,5 BAR UN PORTABLE TANK Serial Number : MCMU 527021 to MCMU 527025 1.0
More informationDOT CHART 10 HAZARDOUS MATERIALS MARKING, LABELING & PLACARDING GUIDE
FM 55-5 FM 55-5 APPENDIX E DOT CHART 0 HAZARDOUS MATERIALS MARKING, LABELING & PLACARDING GUIDE This appendix contains facsimiles of hazardous materials warning labels, placards, and package markings and
More informationRENTAL AND SALE TANKS, PUMPS, HOSES, BASKETS, CUTTING BOXES, RIG SOAP, CARGO CARRYING EQUIPMENT, FRAC TANKS, PIPE SLINGS AND VACUUM TRUCKS
RENTAL AND SALE TANKS, PUMPS, HOSES, BASKETS, CUTTING BOXES, RIG SOAP, CARGO CARRYING EQUIPMENT, FRAC TANKS, PIPE SLINGS AND VACUUM TRUCKS GULF OF MEXICO PRODUCT INDEX GPS TRACKING CARGO CARRYING EQUIPMENT
More informationLOADING OF ORGANIC LIQUID CARGO VESSELS. (Adopted 10/13/1992, revised 1/18/2001)
RULE 346. LOADING OF ORGANIC LIQUID CARGO VESSELS. (Adopted 10/13/1992, revised 1/18/2001) A. Applicability The provisions of this rule shall apply to the transfer of organic liquids into an organic liquid
More informationMSC Guidelines for Fuel Oil Systems
P. W. Gooding, CDR, Chief, Engineering Division References: Contact Information: a. 46 CFR 56.50-60 Systems containing oil (Subchapter F) b. 46 CFR 56.50-65 Burner fuel-oil service systems (Subchapter
More informationMATERIAL SAFETY DATA SHEET
MATERIAL SAFETY DATA SHEET Section 1: Chemical Product and Company Identification Part Number: Description: Customer Description: Customer Part Number: National Stock Code: U-BPU60-66 Lithium ion rechargeable
More informationEXPLANATORY NOTE LIQUIFIED PETROLEUM GASES TRANSPORTED IN STATIONARY TANKS PERMANENTLY MOUNTED ON TRAILERS
EXPLANATORY NOTE LIQUIFIED PETROLEUM GASES TRANSPORTED IN STATIONARY TANKS PERMANENTLY MOUNTED ON TRAILERS 1. ISSUE Liquefied petroleum gases (LPG) being transported in stationary tanks permanently mounted
More informationPortable. Storage and Transport Dewars. CL/CLPB Series, CH Series, CFN/CFL Series
Portable Storage and Transport Dewars CL/CLPB Series, CH Series, CFN/CFL Series CL/CLPB Series Cryofab s CL series portable liquid cylinders are intended for low-pressure transport and storage of liquid
More informationWestern Plant Health Association Anhydrous Ammonia Facility / Field Tank Safety Self Inspection Safety Checklist Form
Western Plant Health Association Anhydrous Ammonia Facility / Field Tank Safety Self Inspection Safety Checklist Form Portable/Mobile Storage Tanks California Code of Regulations Title 8 CCR Subchapter
More informationTROXELL COMPANY, INC E. HWY. 114 RHOME, TEXAS 76078
GENERAL CONSTRUCTION TROXELL COMPANY, INC. Specification Sheet 9250GL (220bbl) DOT407, Aluminum, Double Conical, Single Compartment, Tandem Axle Crude, Oil Tank Trailer MODEL: TRX407AL-220-1-DC-2-P NV-1407
More information> THE A.P. MOLLER - MAERSK GROUP CONTAINER EQUIPMENT GUIDE
CONTAINER EQUIPMENT GUIDE > THE A.P. MOLLER - MAERSK GROUP Maersk Line is part of the A.P. Moller - Maersk Group, which has 70,000 employees in more than 125 countries around the world. Comprising container
More information26000 litre ISOTANK SPECIFICATION FOR HAZARDOUS CHEMICALS TRANSPORT AND STORAGE SPECIFICATION T11.
26000 litre ISOTANK SPECIFICATION FOR HAZARDOUS CHEMICALS TRANSPORT AND STORAGE SPECIFICATION T11. DESCRIPTION: 26 000 LITRE INSULATED UN PORTABLE TANK, TYPE T11 For transport of product classes 3, 4,
More informationANNUAL REPORT OF NON-ACCIDENT RELEASES OF HAZARDOUS MATERIALS TRANSPORTED BY RAIL 2013
ASSOCIATION OF AMERICAN RAILROADS BUREAU OF EXPLOSIVES ANNUAL REPORT OF NON-ACCIDENT RELEASES OF HAZARDOUS MATERIALS TRANSPORTED BY RAIL 01 (United States & Canada) Published August 014 Report BOE 1- ANNUAL
More information8155 Equipment size and type identification Coded description of the size and type of equipment e.g. unit load device.
8155 Equipment size and type identification Coded description of the size and type of equipment e.g. unit load device. Note: User or association defined code. May be used in combination with 1131/3055.
More informationScript. Visual. Narrative. Module 6C Carrier Requirements (Rail)
Script Visual Narrative 1 Module 6C Carrier Requirements (Rail) 2 Hazardous materials shipments by rail must comply with the requirements of Part 174 as well as those contained in Parts 171, 172, 173 and
More informationMATERIAL SAFETY DATA SHEET & IATA T1 T8 CERTIFICATE. Model(s): AM
MATERIAL SAFETY DATA SHEET & IATA T1 T8 CERTIFICATE Model(s): AM048-040 Version 1.0 Sep. 17, 2008 Page 1 of 10 Document Review Team Names Titles Date Product Steven Hou Supervisor Sep. 17, 2008 Quality
More informationHazard Control Refresher Using the ERG
Hazard Control Refresher Using the ERG The Emergency Response Guidebook (ERG) provides summary information on potential hazards, public safety and emergency response to unintended releases of goods being
More informationHawman Container Services ISO 9001:2008 Certified
Hawman Container Services ISO 9001:2008 Certified Hawman Container Services ISO 9001:2008 Certified Metallic Transportable Bulk Packaging Containers (IBCs) Hazardous and Non-Hazardous Liquids HCS Group
More informationSummaries for Gasoline Distribution Facilities and Gasoline Dispensing Facilities 40 CFR 63 subpart BBBBBB and 40 CFR 63 subpart CCCCCC
2011 Summaries for Gasoline Distribution Facilities and Gasoline Dispensing Facilities 40 CFR 63 subpart BBBBBB and 40 CFR 63 subpart CCCCCC Ohio EPA, Division of Air Pollution Control 1/1/2011 Page 2
More informationGeneral Cargo Tariff 1-D SECTION THREE- WHARFAGE, UNLOADING AND LOADING RATES
General Cargo Tariff 1-D SECTION THREE- WHARFAGE, UNLOADING AND LOADING RATES NOTE: The Alabama State Docks at the Port of Mobile may enter into contracts in writing with shippers, receivers, or carriers
More informationProduct Information Sheet
Product Information Sheet Rockwell Automation 1201 South Second Street Milwaukee, WI 53204 Telephone: 414.382.2000 Internet: www.rockwellautomation.com Date of preparation: May 18, 2015 Product: Type:
More informationSpecification Sheet Form Rev
Quote Name: 8500 EDC S1 Shop Order Number: Sales Administration Use Only Number-001 Serial Number(s): Number Date: 99/99/9999 CUSTOMER : Customer Name SALESPERSON : Salesperson Name MODEL : 8500 EDC S1,
More informationRULES FOR THE CONSTRUCTION AND CLASSIFICATION OF SHIPS IDENTIFIED BY THEIR MISSIONS CHAPTERS APPROACH
PART II RULES FOR THE CONSTRUCTION AND CLASSIFICATION OF SHIPS IDENTIFIED BY THEIR MISSIONS TITLE 47 SUPPLY VESSELS SECTION 6 PIPING CHAPTERS A B C D E F G H T APPROACH MATERIALS AND MANUFACTURE - See
More informationVehicle Care and Maintenance
Because the following regulations change frequently, you are encouraged to check the following website for the most current information. www.fmcsa.dot.gov/documents/08-cargotankbulkpkg.pdf. Vehicle Care
More information2012 Air Emissions Inventory
SECTION 6 HEAVY-DUTY VEHICLES This section presents emissions estimates for the heavy-duty vehicles (HDV) source category, including source description (6.1), geographical delineation (6.2), data and information
More informationLithium cells and batteries. (Instructor s Note: Post HM215N)
173.185 Lithium cells and batteries. (Instructor s Note: Post HM215N) As used in this section, lithium cell(s) or battery(ies) includes both lithium metal and lithium ion chemistries. Equipment means the
More informationDriver Qualifications (DQ)
Office of Freight & Commercial Vehicle Operations 395 John Ireland Blvd. Mail Stop 420 St. Paul, MN 55155 Phone: 651-215-6330 Fax: 651-366-3718 www.mndot.gov/cvo Minnesota Commercial Truck and Passenger
More informationTransportation of Dangerous Goods (TDG) - Transport des marchandises dangereuses (TMD)
Quebec Québec Transportation of Dangerous Goods (TDG) - Transport des marchandises dangereuses (TMD) This material has been extracted from the Acts and Regulations of the Province to help students understand
More informationPart Inspection, Repair, and Maintenance
Part 396 - Inspection, Repair, and Maintenance General Requirements (396.3(a)) Every carrier shall systematically inspect, repair, and maintain all commercial motor vehicles under its control. Record Keeping
More informationPRODUCT SAFETY DATA SHEET
Page 1 / 5 This product is a consumer product which is used in a hermetically sealed state. So, it is not an object of the SDS system. This document is provided to customers as reference information for
More informationFuels Safety Division. Propane Code Adoption Document Amendment
Fuels Safety Division Ref. No.: Rev. No.: FS-201-12 1 Propane Code Adoption Document Amendment Date: December 1, 2012 Date: IN THE MATTER OF: THE TECHNICAL STANDARDS AND SAFETY ACT, 2000, S.O. 2000, c.
More informationForm of IOPP Certificate and Supplements * INTERNATIONAL OIL POLLUTION PREVENTION CERTIFICATE
Appendix II Appendices to Annex I Form of IOPP Certificate and Supplements * Annex I INTERNATIONAL OIL POLLUTION PREVENTION CERTIFICATE (Note: This Certificate shall be supplemented by a Record of Construction
More informationBSS Examination Record Form for Privately Owned and Managed Vessels
BSS Examination Record Form for Privately Owned and Managed Vessels [Edition 1.04 April 2013] Current boat name Former name Reg. number or index Length (m) Berths Hull material Hull colour Superstructure
More informationTank Truck Product Integrity Protection Guidelines 4 th Edition, Revision 1 August 27, Normal Alpha Olefins Polyalphaolefins
Tank Truck Product Integrity Protection Guidelines 4 th Edition, Revision 1 Normal Alpha Olefins Polyalphaolefins These Product Integrity Protection Guidelines (Guidelines) have been developed to assist
More informationChapter 2. The Vehicle-Tank Metering System
Chapter 2 The Vehicle-Tank Metering System Chapter Objectives Upon completion of this chapter, you should be able to: 1. Describe the vehicle-tank metering system, its uses, and its relation to other liquid-volume
More informationSweden. General Information. Art. No XB01 Version:
General Information Art. No XB01 Version: 140630 Company Information Mann Teknik AB is the manufacturer of the, a full range of Dry and bulk powders. Our years of experience in these the opportunity to
More information2014 HEIL DOT407AL 9240GL, DOUBLE CONICAL, TANDEM AXLE, CRUDE OIL TRANSPORT WITH PUMP & CENTRIFUGE NV1309 VIN: 5HTDL4527D7H45530
2014 HEIL DOT407AL 9240GL, DOUBLE CONICAL, TANDEM AXLE, CRUDE OIL TRANSPORT WITH PUMP & CENTRIFUGE NV1309 VIN: 5HTDL4527D7H45530 VESSEL 1) Design Two piece barrel, 5454-H32 aluminum alloy for shell. 5454-0
More informationMSC Guidelines for Fired Thermal Fluid Heaters Procedure Number: E1-28 Revision Date: 06/11/2014
References P. W. Gooding, Chief of Engineering Division a. 46 CFR Part 52 Power Boilers b. 46 CFR Part 54 Pressure Vessels c. 46 CFR Part 63 Automatic Auxiliary Boilers Contact Information If you have
More informationSolutions beyond products...
ORIGINAL INSTRUCTIONS IH102C Installation, Operation & Maintenance Manual Model B177 External Automatic Bypass Valve Model B177 External Automatic Bypass Valve Warning: (1) Periodic inspection and maintenance
More informationPRODUCT INFORMATION SHEET
PRODUCT INFORMATION SHEET Rockwell Automation 1 Allen Bradley Drive Mayfield Heights, OH 44124 Telephone: 440-646-5000 Internet: www.rockwellautomation.com Date of preparation: 15.July.2005 Revised: 19.August.2009
More informationRESOLUTION MEPC.251(66) Adopted on 4 April 2014
RESOLUTION MEPC.251(66) Adopted on 4 April 2014 AMENDMENTS TO THE ANNEX OF THE PROTOCOL OF 1997 TO AMEND THE INTERNATIONAL CONVENTION FOR THE PREVENTION OF POLLUTION FROM SHIPS, 1973, AS MODIFIED BY THE
More informationLITHIUM MANGANESE DIOXIDE
CR2354 LITHIUM MANGANESE DIOXIDE Features & Benefits Good pulse capability High discharge characteristics Stable voltage level during discharge Long-term reliability Dimensions Specifications Nominal Capacity:
More informationNMSU FIRE DEPARTMENT FIRE PUMP ACCEPTANCE TEST
Date Documents Submitted: Log No.: File No.: Plan Examiner: Permit No.: Property Information Building Name: Building Address: Building Manager's Name: Building Manager's Phone: Fax: System Designer/Contractor
More informationIn addition to the definitions contained in 171.8, (a) and of this subchapter, the following definitions apply to this subpart:
Subpart E Qualification and Maintenance of Cargo Tanks 180.401 Applicability. This subpart prescribes requirements, in addition to those contained in parts 107, 171, 172, 173 and 178 of this subchapter,
More informationKunKle SAFETY AND RELIEF VALVE PRODUCTS OVERVIEW
KunKle SAFETY AND RELIEF VALVE PRODUCTS OVERVIEW ISSUED NOVEMBER 2012 KunKle SAFETY AND RELIEF VALVE PRODUCTS OVERVIEW Contents Models 1 and 2 Brass Safety Valves... 4 Models 19, 19M, 20, 20M, 20P, 20MP,
More informationConsistent implementation of the 2020 sulphur limit and work to further address GHG emissions from international shipping
Consistent implementation of the 2020 sulphur limit and work to further address GHG emissions from international shipping IBIA/BMS United A glimpse into the future of shipping 30 May 2018, Athens, Greece
More informationOutline. Purpose. TDG Regulatory Update
TDG Regulatory Update COSTHA Conference, April 2015 Benoit Turcotte Director, Regulatory Affairs Branch Transportation of Dangerous Goods Directorate RDIMS: 10567947 Purpose To provide an update on recent
More informationINSTRUCTIONS FOR HEAVY DUTY AUTOMATIC STOP COIL WINDING MACHINE CROWN MODELS 2015 & 2016
LAYCOCK SYSTEMS, INC. 1601 N. 43 rd Street Tampa, FL 33605-5937 LAYCOCK Phone: 813-248-3555, Fax: 813-242-0514 CROWN MOTOR E-Mail: sales@laycocksystems.com MOTOR WINDING Website: www.laycocksystems.com
More informatione-cfr data is current as of January 5, 2017
ELECTRONIC CODE OF FEDERAL REGULATIONS e-cfr data is current as of January 5, 2017 Title 49 Subtitle B Chapter I Subchapter C Part 173 Subpart E 173.185 Title 49: Transportation PART 173 SHIPPERS GENERAL
More informationFlammability of Bakken Crude Oil: Dangerous. Rail Cargo Even When Empty. (by Dr. Gerard Macri, Expert Witness)
Flammability of Bakken Crude Oil: Dangerous Rail Cargo Even When Empty (by Dr. Gerard Macri, Expert Witness) Suppose for the moment a noteworthy author published a paper dealing with the chemical properties
More information1992 IICL released three reports in 1992: General Specials & Dispositions Chassis & Domestic Containers
1992 IICL released three reports in 1992: General Specials & Dispositions Chassis & Domestic Containers IICL FOURTH ANNUAL LEASED CONTAINER FLEET SURVEY April 6, 1992. IICL has released preliminary figures
More informationPART II RULE FOR THE CONSTRUCTION AND CLASSIFICATION OF SHIPS IDENTIFIED BY THEIR MISSION TITLE 31 SELECTION OF SHIP TYPE FOR LIQUID BULK CARGOES
DE NAVIOS E AERONAVES Identified by their Mission NAVAL ARCHITECTURE - Section 1 RGMM14EN Hull - Part II CHAPTERS - A,B,D, and E PART II RULE FOR THE CONSTRUCTION AND CLASSIFICATION OF SHIPS IDENTIFIED
More informationWater Treatment Pressure Vessel
Water Treatment Pressure Vessel We manufacture tank only Water Treatment Pressure Vessel NOYI Environmental Equipment Manufacturing (Beijing) Co., Ltd. was founded in 2011. The company designs, manufactures
More informationReport No.: Name of Ship: Plans referred during Initial Survey:
Report on the Surveys Concerning International Oil Pollution Prevention Certificate Part 7 Survey of installation for discharges from cargo spaces Initial/ Annual/ Intermediate/ Renewal/ Change of Flag
More informationSafety and Relief Valves Product Overview
Safety and Relief Valves Product Overview Kunkle Valve is a leading supplier of Safety and Relief Valve Products for industrial and commercial applications, such as steam boilers, air, or non-hazardous
More informationPRODUCT SAFETY DATA SHEET
Page 1 / 5 This product is a consumer product which is used in a hermetically sealed state. So, it is not an object of the SDS system. This document is provided to customers as reference information for
More information40 FLAT RACK TECHNICAL SPEC. BULLBOX
40 FLAT RACK TECHNICAL SPEC. BULLBOX STEEL DRY CARGO CONTAINER BULLBOX 40-40 8 8 6 MODELO NO: BULLBOX 40 FLAT RACK COLLAPSIBLE DATE OF ISSUE: October, 2017 Contenedores y Embalajes Normalizados S.A. P.I.
More informationRESOLUTION MEPC.120(52) adopted on 15 October 2004 GUIDELINES FOR THE TRANSPORT OF VEGETABLE OILS IN DEEPTANKS OR IN INDEPENDENT TANKS SPECIALLY
RESOLUTION MEPC.120(52) MEPC 52/24/Add.1 THE MARINE ENVIRONMENT PROTECTION COMMITTEE, RECALLING article 38(a) of the Convention on the International Maritime Organization concerning the function of the
More informationMATERIAL SAFETY DATA SHEET
MATERIAL SAFETY DATA SHEET & UN Manual of Tests and Criteria, Part III, Subsection 38.3 (Test T1-T8) Independent Certificate Model(s): BA-52 Page 1 of 11 Version 1.2 JAN. 3 th, 2017 Revision History Version
More informationDaikin Steam Coils. Installation and Maintenance Manual IM 901. Types HI-F5, HI-F8, & E-F5. Group: Applied Air. Part Number: IM 901
Installation and Maintenance Manual IM 901 Daikin Steam Coils Group: Applied Air Part Number: IM 901 Date: February 2008 Types HI-F5, HI-F8, & E-F5 2008 Daikin Applied Contents Introduction... 3 General
More information1. All aircraft fueling equipment shall have a Filter/Separator or a Full-Flow Fuel Monitor.
No. 401 STANDARD SAFETY PROCEDURES STANDARD EQUIPMENT LIST FOR FUELING VEHICLES OBJECTIVE: To ensure the safety of property and personnel, the following minimum operational/equipment list, for each fueling
More informationPRODUCT SAFETY DATA SHEET
PRODUCT SAFETY DATA SHEET Manufacturer Name of Company : Matsushita Battery Industrial Co., Ltd. Address : 1-1,Matsushita-cho,Moriguchi,Osaka 570-8511 Japan Department : Lithium Ion Battery Business Unit,
More informationMSC.285(86) and Code for gas-fuelled ships (IGF-Code) technical challenges and perspective - Dr Gerd Würsig, Benjamin Scholz,
MSC.285(86) and Code for gas-fuelled ships (IGF-Code) technical challenges and perspective - Dr Gerd Würsig, Benjamin Scholz, GL Your competitive edge Take the lead through innovation GASTECH 2011 March
More informationDecree of the Ministry of Transport and Communications
579/2000 Decree of the Ministry of Transport and Communications on transportable pressure equipment and tanks discharged or filled by pressure and used for the transport of dangerous goods Adopted in Helsinki,
More informationSchedule A to the Memorandum of Understanding. Between the Oil and Gas Commission and British Columbia Safety Authority
Schedule A to the Memorandum of Understanding Between the Oil and Gas Commission and British Columbia Safety Authority Joint Regulation of Pipeline System Unfired Pressure Vessel Clarification of MOU Responsibilities
More informationGeneral Purpose Container 20
General Purpose Container 20 ISO Size Type Code: 22 G0 (22 G1) Suitable for any general cargo. Containers may be equipped with linger bags suitable for bulk cargo, e.g. malt. Fork-li pockets for loaded
More informationTable Fire Prevention Code Permit Requirements
Table 107.2 Fire Prevention Code Permit Requirements 1 3 4 5 Table 107.2 Permit Hourly FIRE PREVENTION FEES AND DETAILED PERMIT REQUIREMENTS Fee Fee Aerosol products, Level 2 or 3: Manufacture, store or
More informationTransportation Regulations for Lithium, Lithium Ion and Polymer Cells and Batteries
Transportation Regulations for Lithium, Lithium Ion and Polymer Cells and Batteries Which organizations and regulations govern the transport of lithium, lithium ion and polymer cells and batteries? The
More informationPRODUCT SAFETY DATA SHEET
51511 PRODUCT SAFETY DATA SHEET 1 Name of Product and Manufacturer Name of Product : Manganese dioxide lithium battery Model name : See table Name of Company : Panasonic Corporation Energy Company Address
More informationMSC Guidelines for Fired Thermal Fluid Heaters Procedure Number: E1-28 Revision Date: April 20, 2018
References C. J. Robuck, LCDR, Chief, Engineering Division a. 46 CFR Part 52 Power Boilers b. 46 CFR Part 54 Pressure Vessels c. 46 CFR Part 63 Automatic Auxiliary Boilers Contact Information If you have
More informationNational Tank Truck Carriers Tank Week FMCSA Update. Paul Bomgardner Chief, Hazardous Materials Division Federal Motor Carrier Safety Administration
National Tank Truck Carriers Tank Week FMCSA Update Paul Bomgardner Chief, Hazardous Materials Division Federal Motor Carrier Safety Administration Topics Electronic Logging Devices: Brief Review Personal
More informationSAFETY TRAINING LEAFLET 04 NITROUS OXIDE
SAFETY TRAINING LEAFLET 04 NITROUS OXIDE Doc 23.04/18 EUROPEAN INDUSTRIAL GASES ASSOCIATION AISBL AVENUE DES ARTS 3-5 B 1210 BRUSSELS Tel: +32 2 217 70 98 Fax: +32 2 219 85 14 E-mail: info@eiga.eu Internet:
More informationTRANSFER FLOW INCORPORATED INSTRUCTION SHEET NUMBER 374 IS DEPARTMENT OF TRANSPORTATION SPECIAL PERMIT SP
Transfer Flow, Inc. 1444 Fortress Street Chico, CA 95973 Phone: (530) 893-5209 Sales/Tech: 1-800-442-0056 Fax: (530) 893-0204 Website: www.transferflow.com Your Legal Fuel Tank Source. Aftermarket & OEM
More informationMATERIAL SAFETY DATA SHEET Page 1 of 5 MSDS#: BA
MATERIAL SAFETY DATA SHEET Page 1 of 5 SECTION 1 IDENTIFICATION OF THE SUBSTANCE/MIXTURE AND OF THE COMPANY/UNDERTAKING Product Name: Product Code: Company Name: Address: Use of the Product: Lithium Ion
More informationBulk storage and handling of solvents and coalescents
Bulk storage and handling of solvents and coalescents Introduction This publication provides information for solvent storage, tank construction materials, and unloading tank cars and tank trucks containing
More informationOverview. Lithium batteries Recent Developments DOT Regulations Firearms Common Household Products International Resources
Overview Lithium batteries Recent Developments DOT Regulations Firearms Common Household Products International Resources 2 Make a Difference Front line information resource to your local offices and businesses.
More informationValves. External Valves, Gages and Fittings. Bulletin No What options are available when stainless steel is not suitable for external parts.
External Valves, Gages and Fittings Bulletin No. 218 What options are available when stainless steel is not suitable for external parts. Unless otherwise specified, the external valves, gages, fittings
More informationY-fl'. MINISTRY OF TRANSPORT AND COMMUNICATIONS DEPARTMENT OF MARINE ADMINISTRATION
MINISTRY OF TRANSPORT AND COMMUNICATIONS DEPARTMENT OF MARINE ADMINISTRATION No-363/421, Corner of Merchant & Theinbyu Road, Botataung Township, Yangon, Myanmar E-mail : d gdma.mm@ gmail.com; dma.myan@smail.com
More informationExplanatory sheet about safety of product for transportation (Safety Data Sheet for transportation) 1. Basic item 2. Product information
Issued/Revised date :June 14 2018 Document No. : LE-180614006 Explanatory sheet about safety of product for transportation (Safety Data Sheet for transportation) 1. Basic item Product name Lithium-Ion
More informationExceptions for passengers, crewmembers, and air operators.
Updated as of 11/3/2013 175.10 Exceptions for passengers, crewmembers, and air operators. (a) This subchapter does not apply to the following hazardous materials when carried by aircraft passengers or
More informationQuality is Behind the Diamond
Quality is Behind the Diamond SKID UNIT OVERVIEW Amerex is pleased to introduce a complete line of Manual Fire Fighting Skid Units for industrial and extreme hazard environments that require maximum capacity
More informationMAC TRAILER MANUFACTURING, INC C PNEU MAC TIC DRY BULK
MAC TRAILER MANUFACTURING, INC. 1050-C PNEU MAC TIC DRY BULK MIKE JOHNSON SERIAL NO. #VALUE! 2016 Spring Dealer Incentive Program Base Model Trailer 252Q MODEL NO. TN1050APB 8/12/14 LAST REVISED WEIGHT
More informationTransportation and Transfer
Instructor Manual Module 4 Transportation and Transfer Module Objective Upon completion of this module, participants should be able to describe how ethanol-blended fuels are transported and transferred
More informationFIRST IN SERVICE Servicing the Gulf of Mexico for 30 Years Member of HOUMA, LA JENNINGS, LA
FIRST IN SERVICE HOUMA, LA 1-800-230-8265 JENNINGS, LA 1-800-200-8265 COAST GUARD APPROVED TANKS IMDG STAINLESS TANKS IM-101 TANKS UN TANKS CARGO TANKS STORAGE TANKS CUTTINGS BOXES D.O.T. SPEC. 57 TANKS
More informationpart five outboard and portable engines
part five outboard and portable engines Fishermans Knot Carrying portable petrol tanks and transferring petrol can be extremely hazardous if care isn t taken. Petrol and its vapour are highly flammable
More information