Miscellaneous K

Transcription

1 Bondo Traffic Loop Sealer A polyester 2-part compound supplied in homogenized, ready to use consistency. Durable, permanently elastic to seal saw cut openings and to hold sensitized wire loops for control of traffic signals, parking lot gates, traffic counters, etc. Rapid curing to minimize length of time a lane must be closed Cures chemically assuring maximum protection of loop wires Excellent adhesion to cement and cured asphalt concrete Withstands the corrosive effects of road salts, auto fluids, jet fuel and gasoline, etc. Unaffected by freeze/thaw cycles. From 3M. Part No One gallon pail. Standard package: 4 cans (49 lbs.) Part No BONIN gallon pail Bondo Sealant Hardener #65 Additional hardener may be purchased separately in.74 oz. tubes. Hardener is used to catalyze Bondo Loop Sealants. Up to twice the normal amount of hardener can be used to catalyze in cooler weather. From 3M, Part No. 609 Instructions for 609: Tubes of.74 oz. Hardener Temperature per Gallon of Sealant 80 or higher Extra hardener is packaged as follows: Part No. 7.BONIN - 12 oz. for five gallon dispensing system Part No. 5-1 gallon for 50 gallon dispensing systems Bondo Speed Set Accelerator Used to accelerate the rate of cure of Bondo Polyester Loop Sealants at temperatures below 40 F. The accelerator makes it possible to use Bondo Polyester Loop Sealers year-round. For use with 1 gallon Bondo Traffic Loop Sealer. Instructions available..5 fl. oz.. From 3M. Part No. 610 Bondo Sealer Dispensing Machine Designed for fast, clean and easy dispensing of Bondo polyester sealers supplied in 5-gallon containers. From 3M. Part No. RCLSD2003 To help estimate the number of gallons needed. One gallon of sealer when mixed with liquid hardener will cover: Loop Size width x depth (in) Loop Length (linear foot) 1/2 x /8 x /4 x /2 x 1-1/ /8 x 1-1/ /4 x 1-1/ Bondo 575 One Part Sealant Reduce container changing, increase work speed. Part No quart cartridge Part No liter sausage pack Part No gallon pail, gray Part No gallon pail, black Bondo Dispensing Guns Speed up your production time by using 1-quart portable battery operated Dispensing Guns. Install more loops with ease - just charge the batteries and pull the trigger. Each gun comes with two rechargeable batteries and a battery charger. Battery operated dispensing guns for the one liter. From 3M. Part No B0NIN Quazite Detector Loop Sealant Q-Seal 290S - Designed for use in both asphalt and concrete pavement to provide a weather- and chemical-resistant waterproof seal. From Chemque. Part No. 290S45BLK gallon pail, black Part No. 290S45GRY gallon pail, gray Part No. 290S30FLOZBLK - 30 fl. oz., black Part No. 290S30FLOZGRY - 30 fl. oz., gray K-1

2 Backer Rod Closed cell foam rope ideal for holding loop wire in place before pouring loop sealant. Use a rod with a larger diameter than the loop slot. Simply stuff small 2" pieces of backer rod into the loop slot every 2' to keep the loop wire in place before installing loop sealant. Many sizes available,.25"-3" diameter. From RAI. Popular Sizes: Part No. Rod Dia. (in) Length (ft) BR14X2500 1/4 2,500 BR12X2500 1/2 2,500 BR38X3600 3/8 3,600 BR58X1550 5/8 1,550 Wire-Pulling Lubricant Yellow 77 Wire Pulling Lubricant Wax base formulation is exceptionally slippery and protects cable during the pulling process. Goes on easily and uniformly - no drips or runs. From Ideal Industries. Part No. Description Unit Weight (lbs) quart squeeze bottle 2-1/ gallon pail quart 3 TechLube Cable Ease Designed for fiber optic cable blowing applications and compatible with cable jackets and conduit/innerduct. TechLube is poured into a conduit/ innerduct opening and pushed by a sponge to provide waterproof lubricity on the inner walls - will not "cement" the cable to the bottom of the conduit/innerduct. Can be used at extreme temperatures, -36 F (2 C) to 220 F (104 C). Nonflammable. 32 fl. oz. bottle. From PT Technologies. Part No PTTEC Multi-Purpose Lubricant Cleans, lubricates and penetrates while displacing and sealing out moisture with a continuous film. Five products in one: moisture displacer, corrosion inhibitor, cleaner, penetrating oil and a lubricant. Safe for use on metals and plastics. 10 oz. Aerosol, 12 per case. From Rainbow Technology. Part No Corrosion Wash Non-conductive rinsing agent that cleans corrosion-causing substances such as moisture, dirt, dust, grease, insect waste and debris from terminal faceplates, housing and other surfaces. 16 oz. Aerosol, 12 per case. From Rainbow Technology. Part No Corrosion Stop Long-term indoor/outdoor corrosion inhibitor formulated to stand up to the most severe weather conditions and offers up to one year of durability. An excellent protector for parts and equipment subjected to long periods of storage or adverse shipping conditions. 10 oz. Aerosol, 12 per case. Use on surfaces including: Electrical Equipment Stored Metal Locks Castings Gears Generators Railroad Equipment Battery Terminals Marine Engines Pipes From Rainbow Technology. Part No K-2

3 Filled Cable Cleaning Kit The Scotchcast 4414 filled cable cleaning kit provides all the necessary materials for cleaning the filling compound from filled cable in an easy-to-transport kit. Includes 15 pads saturated in cleaning solvent in a container, 5 scraper pads and 10 towels. Specially-formulated cleaning solvent is contained in pre-measured portions on the kit s wet pads for fast, easy, convenient solvent application. The solvent is non-toxic and environmentally safe. From 3M. Part No Gel-Off Plus Cable Cleaner Citrus formula quickly and safely removes filling and flooding compounds, gels, greases, c-cement, lubricants, water-blocking compounds and other petroleum-based contaminants from telecommunication cables, splices and utility tools. From Rainbow Technology. Part No Individual towelettes, 144 per case Part No Quart bottle, 12 per case D'Gel Cable Gel Solvent Removes cable gels (icky-pic), blocking, flooding and filling compounds. From PT Technologies. Part No Individual towelettes, 144 per case Part No fl. oz. bottle Part No oz. sealed poly bag in pail D'Gel Fiber Optic Solvent Towel Replaces isopropyl alcohol for use on fiber optic cable where residue of any amount cannot be tolerated. Thoroughly tested and found completely acceptable for compatibility with fiber optic cable and components. From PT Technologies. Part No Individual towelettes, 144 per case Knuckles Hand & Tool Cleaning Towels Tough on dirt! Specially formulated to dissolve and absorb dirty contaminants from hands, tools and equipment. Rough and abrasive on one side to scrub embedded contaminants such as cable filling compounds, icky pic, c-cement, tar, asphalt, heavy greases, etc. The other side is smooth which works to trap and absorb the cleaner and the dirty contaminants back into the towel. From Rainbow Technology. Part No Bucket of 72 towelettes Part No Individual towelettes (144/case) Knuckles Waterless Hand Cleaner Waterless and formulated to remove icky pic, cable jelly, asphalt, carbon, c-cement, and more. May be used with or without water. Contains emollients which prevent drying of the skin. 16 oz. bottle, 12 per case. From Rainbow Technology. Part No Without scrubbers Part No With scrubbers Lens Kleener Convenient and effective cleaner for safety eyewear. Removes cable filling compounds, icky pic and other common workplace lubricants from glass, plastic and polycarbonate. Includes anti-fogging and anti-static compounds. Leaves no residue. 1 oz. Bottle, 24 per case. From Rainbow Technology. Part No INSECTAPE Time-release product designed to slowly release insecticide for years in telco and utility equipment as well as other areas indoors or outdoors. Kills existing infestation and prevents future infestation. Adhesive backing makes INSECTAPE ideal for use in tight enclosed areas. Provides continuous control for up to three years. 1" x 4" strips, 360 per case. From Rainbow Technology. Part No K-3

4 Weed Killer Non-selective, granular herbicide, controls a wide range of annual and perennial weeds. Can be applied at any season of the year to kill existing plants or to prevent weed growth. Use for general weed control around: Buried Cable Closures Transformer Pads Cross-Connect Boxes Utility Poles Power Substations Guywires Telephone Booths Fire Plugs 8 oz. bag, 50 per case; other sizes also available. From Rainbow Technology. Part No BOX All-Weather Tape 88T Black, 8.5-mils thick general purpose vinyl plastic electrical tape for use over a broad temperature range. 10 per package. From 3M. Part No. 88T /2" x 44' Part No. 88T3436-3/4" x 36' Part No. 88T34-3/4" x 60' 33+ Scotch Super Vinyl Tape Stickier, stretchier and highly conformable. Premium grade, 7 mil (0.18mm), applies well at -18 C (0 F) and has an operating range up to 105 C (220 F). Flame-retardant, hot and cold weather resistant. Resists UV rays, abrasion, moisture, alkalies, acids and corrosion. 3/4" x 66'. From 3M Part No Scotchkote Electrical Coating Gives vinyl tapes a flexible extra coating of protection against oil, moisture and corrosion. In brush-top cans for easy application. Standard package contains 10 cans. From 3M. Part No. SCOTCHKOTE Vinyl Mastic 3M's 50-mil-thick two layer blanket consists of an inner tacky layer of white vulcanized rubber bonded to an outer layer of black vulcanized rubber. The inner tacky layer is protected by Holland cloth. For the temporary moisture sealing of open cable splices or making temporary repairs to damaged cable jackets. Part No. Type Size Std. Pkg. Polyethylene Tape This 8-mil (.2mm) thick tape is perfect as a finishing wrap with a high dielectric value. Provides excellent conductor insulation protection, and an extra layer of insulation. 3" W x 35" L. From GMP. Part No Reflective Lettering & Numbering Kits 3M Kit Self-sticking adhesive Each letter/number size 1" x 1.5" Kit contains 25 each A-Z, 0-9, blank and dash characters in 36-compartment box, plus application tool Black letters on safety orange background Conforms to ANSI Z Part No ACP International Kit Kit contains 25 each of letters A-Z Weight (lbs/ea.) VM4 vinyl mastic 4" x 10' VM6 vinyl mastic 6" x 10' VM22X10 vinyl mastic 22" x 10' and 25 each of numbers 1-9 and dash. Seven-year outdoor durability Standard colors are orange with black lettering, optional colors are yellow and white reflective Part No. DN55.KIT K-4

5 Pole Numbers and Letters 1-1/2" high, embossed, oval faced aluminum numerals in a clear-cut, highly legible, full-stroke Gothic. Standard package includes 100 characters, available in Roman or Gothic. Marking Paints Provide bold, bright visible markings. Onecoat coverage, fast-drying, long lasting. VOC compliant, lead-free and biodegradable. Ten colors available. 20 oz. Aerosol, 12 per case. From Rainbow Technology. Call for details. C-Cement Specifically designed for applications where a domed style configuration is preferred. Clifford recommends "C" Cement for the Preformed Line Products Closures. See page B-4. Part No oz. Part No oz. Manhole Cover Hook A simple tool that s been used for years to pry loose conventional manhole covers. Made from octagon tool steel that s been specially hardened to prevent bending. 26" long. Part No Marking Paint Applicator Constructed of durable, rugged plastic and lightweight aluminum Comfortable pistol grip for easy handling and marking Applies a uniform 1" to 1-1/2" width line of paint Will hold 16 oz. or 20 oz. cans Part No " overall length Part No " overall length with detachable wheel Wrap Around Cable Markers Made from curled vinyl Snaps on pipe, cable, duct or tubing and stays curled forever. Special matte-finished surface allows the marker to be permanently written on for customized coding. User-friendly, require no cable ties, no adhesives, no assembly and virtually no time to install Five-to-seven year UV-environment lifespan Custom printing and lengths are available Most popular sizes: Part No. DN33-4" long, fits 1/2" to 1" diameter cable Part No. DN34.1-7" long, fits 1" to 2" diameter cable Call for additional size options. K-5

6 Notes K-6