REPLACEMENT PARTS MANUAL GROUND SOURCE and GROUND WATER SOURCE HEAT PUMP MODELS: GVSAA GV8SAA GV5SAA GVSAA GVSAA General Notes Contents Revised and/or additional pages may be issued from time to time. A complete and current manual consists of pages shown in the following contents section. Description Cabinet Components Page Exploded View... Usage List... Important Contact the installing and/or local distributor for all parts requirements. Make sure you have the complete model and serial number available from the unit rating plates. Functional Components Exploded View... 4 Usage List... 5 Control Panel Exploded View... Usage List... BMC, Inc. Bryan, Ohio 450 Manual: 0-E Supersedes: 0-D File: Tab 8 Date: 0-0- Page of
CABINET COMPONENTS 8 8 0 SEP-5 5 4 5 4 0 Page of
CABINET COMPONENTS Drawing No. Part No. Description S-- Base Assembly S-5- Base Assembly S50-0-4 Back Assembly S50--4 Back Assembly S54-0-4 Left Corner Assembly S54--4 Left Corner Assembly 4 S54-08-4 Right Corner Assembly 4 S54-0-4 Right Corner Assembly 5 5-4 Partition Assembly 5 5-4 Partition Assembly S5-8 Drain Pan Assembly with Fitting S5-0 Drain Pan Assembly with Fitting 50--4 Top Assembly 50-4-4 Top Assembly 8 55-4-4 8 50-50-4 50-58-4 50-50-4 0 S55-4-4 Upper Door Assembly 0 S55-45-4 Upper Door Assembly S55-4-4 Lower Door Assembly S55-44-4 Lower Door Assembly Control Panel (See Control Panel Drawing) -55 Control Panel Fill -5 Control Panel Fill 4-4 Control Panel Door 5 40-0 Water Coil Support Channel 40-0 Blower Side 40- Blower Slide End 40-05 Blower Slide End 8 44- Blower Slide 8 45-8 Blower Slide 05-05-4 Plenum Angle Assembly 05--4 Plenum Angle Assembly 4 4 4 0-5-4 Filter Rack Wrapper 0-58-4 Filter Rack Wrapper 5-5-4 Filter Rack Channel S-5-4 Filter Rack Door S-5-4 Filter Rack Door GVS GV8S GV5S GVS GVS Page of
FUNCTIONAL COMPONENTS 0 8 5 4 4 8 5 0 SEP-5 Page 4 of
FUNCTIONAL COMPONENTS Drawing No. Part No. Description 04-0 Right Blower Angle 04- Right Blower Angle 04-04 Left Blower Angle 04- Left Blower Angle 44-8 Diffuser 44- Diffuser 4 5- Blower Housing 4 5-8 Blower Housing 5 55-04 Blower Wheel 5 55-0 Blower Wheel 50-5B 50-58B 50-5B -08B 004-040 Filter 0 x 5 x MERV 004-05 Filter x 5 x MERV 8 80-04 Motor Mount Kit 80-04 Motor Mount Kit 0 S805-05-0054 / HP Programmed Motor with Control 0 S80-045-0055 / HP Programmed Motor with Control 0 S80-045-005 / HP Programmed Motor with Control 0 S80-0-005 /4 HP Programmed Motor with Control 0 S80-0-0058 /4 HP Programmed Motor with Control 505-0 Desuperheater Coil 550-04 550-04 Reversing Valve Solenoid, Red Casing (Ranco) Reversing Valve Solenoid, Black Casing (San Hua) 550-08 Reversing Valve with 4V Solenoid Coil 550-0 Reversing Valve with 4V Solenoid Coil 550-040 Reversing Valve with 4V Solenoid Coil 550-04 Reversing Valve with 4V Solenoid Coil 4 50-00 Bi-Direct Filter Drier 4 50-00 Bi-Direct Filter Drier 5 55-0 5 55-5 55-0 5 55-0 8000-4 8000-8000-8 8000-85 8000-5 S-0 Water Coil Assembly (Copper-Closed Loop) S-08 Water Coil Assembly (Cupronickel-Open Loop) S-05 Water Coil Assembly (Copper-Closed Loop) S-0 Water Coil Assembly (Cupronickel-Open Loop) S-004 Water Coil Assembly (Copper-Closed Loop) S-004 Water Coil Assembly (Cupronickel-Open Loop) S-0 Water Coil Assembly (Copper-Closed Loop) S-04 Water Coil Assembly (Cupronickel-Open Loop) 8 804-0405 Low Pressure Switch (840-) Ground Water 0# Cut-Out, Blue Wires 804-0404 Low Pressure Switch (840-0) Ground Loop 45# Cut-Out, Yellow Wires 0 804-0 High Pressure Switch (840-) 00-5-00 00--00 00--00 00-8-00 00-8-00 04-0 /4" Barbed Drain Pan Fitting S800-04 S800-04 S800-00 S800-0 000-000- 04-04 04-05 Staging Solenoid Power Plug Double O-Ring Retaining Cap for Plug Seal GVSAAC GVSAAN GV8SAAC GV8SAAN GV5SAAC GV5SAAN GVSAAC GVSAAN GVSAAC GVSAAN Page 5 of
CONTROL PANEL 4 5 0 8 SEP-54 A Drawing No. Part No. Description 5-88 Control Panel (Sheet Metal) 80-0 Terminal Block 84-0 Mini Circuit Breaker -Amp 4 840-04 40VA Transformer 40/08 x 4V 5 80-088 Control Module 80-05 Relay PNO, PNC A 4V Coil 80-0 4V Terminal Strip 8 80-8 Blower Control 0 0 855-08 855-05 855-045 855-00 840-0 840-04 Capacitor 5MFD 0V Capacitor 40MFD 0V Capacitor 0MFD 0V Capacitor 40MFD 440V Contactor -Pole 0 Amp with Lugs Contactor -Pole 40 Amp with Lugs GVS GV8S GV5S GVS GVS Page of