Supersedes ACT-1101 Dated NOVEMBER 5, 2001
TABLE OF CONTENTS MC SERIES RACK & PINION ACTUATOR PAGE 1 MC SERIES OPTIONS PAGE 2 CB & HD SERIES YOKE PNEUMATIC ACTUATORS PAGE 3 SOLENOID VALVES PAGE 4 LIMIT SWITCHES, POSITIONERS PAGE 5 MC SERIES ELECTRIC ACTUATORS PAGE 6 LB SERIES ELECTRIC ACTUATOR PAGE 7 LB SERIES ACCESSORIES PAGE 8 MOUNTING BRACKETS & TEE LINKS PAGE 9
MC SERIES RACK & PINION ACTUATORS DOUBLE ACTING ACTUATOR LIST PRICE SPRING RETURN ACTUATOR LIST PRICE HIGH TEMP SEAL ADDER (1,2) REVERSE ROTATION ADDER MC1 96.25 MC1S4 N/A N/A 35.00 MC2 147.00 MC2S4 187.00 60.00 35.00 MC3 176.00 MC3S4 204.50 60.00 35.00 MC5 212.00 MC5S4 265.25 64.25 35.00 MC7 249.00 MC7S4 299.00 67.50 35.00 MC10 301.00 MC10S4 359.00 71.75 35.00 MC14 361.00 MC14S4 428.00 77.25 35.00 MC22 471.00 MC22S4 541.00 89.25 35.00 MC29 529.00 MC29S4 625.00 89.25 35.00 MC58 880.00 MC58S4 1022.00 188.00 35.00 MC90 1162.00 MC90S4 1370.00 206.00 58.00 MC121 1467.00 MC121S4 1732.00 293.50 58.00 MC236 3107.00 MC236S4 4195.00 294.00 58.00 MC295 3460.50 MC295S4 5057.00 309.50 58.00 1) HIGH TEMPERATURE SEALS ARE GOOD FOR CONTINUOUS TEMPERATURES FROM 250 DEGREES FARENHEIT TO 300 DEGREES FARENHEIT 2) THE LIST ADDER PRICES ARE TO BE ADDED BEFORE THE DISCOUNTS ARE APPLIED MC SERIES SOLENOID VALVES FOR 4 WAY AND 3 WAY REQUIREMENTS MODEL NEMA RATING ACTUATOR STANDARD VOLTAGE LIST PRICE SPEED CONTROLS SC8551A1MS 4 MC1-MC295 120/60 104.50 27.25 EFSC8551A1MS 4/7/9 MC1-MC295 120/60 226.00 27.25 SC8551A1MS220VAC 4 MC1-MC295 220/60 138.00 27.25 SC8551A1MS24VDC 4 MC1-MC295 24DC 138.00 27.25 SC8551A1MS24VAC 4 MC1-MC295 24/60 138.00 27.25 SC8551A1MS12VDC 4 MC1-MC295 12DC 138.00 27.25 PLEASE CONSULT FACTORY FOR AVAILABILITY ON BETTIS RPC SERIES ACTUATORS PAGE 1
MANUAL GEAR WITH DECLUTCHABLE OVERRIDES ACTUATOR MODEL LIST PRICE MC2-MC29 DT-3-SD 506.00 MC58 DT-6-SD 582.50 MC121 DT-21-SD 1,278.00 MC236-MC295 DT-36-SD 1,711.00 MOUNTING COST FOR GEARS POA MC PNEUMATIC ACTUATORS: SPARE PART PRICES MODEL SPRING CARTRIDGE* BUNA N ** REPAIR KITS VITON *** REPAIR KITS DELRIN **** GUIDE SETS MC2 12.00 14.25 30.50 14.25 MC3 12.00 14.25 50.00 27.25 MC5 12.00 15.25 55.50 27.25 MC7 12.00 16.50 61.00 37.00 MC10 14.50 18.50 68.50 37.00 MC14 16.50 20.50 75.00 40.25 MC22 17.50 23.00 82.75 42.50 MC29 20.75 25.00 98.00 44.75 MC58 36.00 61.00 127.50 68.50 MC90 41.50 77.75 160.50 68.50 MC121 49.00 100.00 190.25 68.50 MC236 143.50 226.00 256.50 99.00 MC295 143.50 226.00 256.50 99.00 * PRICES ARE FOR EACH SPRING CARTRIDGE. UNITS REQUIRE ONE SPRING FOR EACH END (EXAMPLE MC3S2 WILL REQUIRE A TOTAL OF FOUR SPRING CARTRIDGES) ** CONTAINS ALL BUNA O-RINGS SEALS *** CONTAINS ALL VITON O-RING SEALS AND HIGH TEMPERATURE GUIDES **** CONTAINS ALL DELRIN GUIDES EXTENDED FINAL LIMIT STOPS MODEL ACTUATOR PRICE EXTSTOP100 MC2-MC22 19.75 EXTSTOP100 MC29-MC121 24.00 EXTSTOP100 MC236-MC295 31.75 NAMUR ADP PLT 15.25 PAGE 2
CB SERIES SCOTCH YOKE PNEUMATIC OPTIONS DOUBLE LIST LOW HIGH INTERNAL EXTENDED EXTENDED STOPS ACTING PRICE TEMP-11 TEMP-10 OVERRIDE-M STOPS-S W/LOCKING DEVICE-SL CB315 511.00 74.75 110.00 N/A 73.25 305.00 CB420 626.25 120.65 130.25 1,209.00 84.00 350.00 CBL520 801.00 129.00 135.75 1,301.00 96.25 401.25 CB525 1,018.00 164.00 150.00 1,345.00 108.50 452.75 CBL725 1,456.00 183.00 204.00 1,830.00 119.50 499.00 SPRING RETURN LIST PRICE CB315SR 821.50 74.75 110.00 N/A 73.25 305.00 CB415SR 888.00 79.00 122.00 1,070.00 78.75 332.00 CB420SR 1,002.00 120.65 130.00 1,085.00 84.00 350.00 CB520SR 1,059.00 129.00 135.75 1,121.00 96.25 401.25 CB525SR 1,450.00 164.00 140.00 1,260.50 108.50 452.75 CB725SR 2,007.00 183.00 203.50 1,545.00 119.50 499.00 PLEASE SELECT SPRING RATE FOR AIR PRESSURE CB SERIES NOTES LOW TEMP-11 1) ALL STANDARD TRIM ACTUATORS ARE FOR -20 o F TO + 200 o F AMBIENT TEMPERATURE 2) LOW TEMPERATURE CONSTRUCTION (-11) SUITABLE IN AMBIENT TEMPERATURE FROM 40 O F TO +150 O F. CONSULT FACTORY FOR COLDER APPLICATIONS. 3) HIGH TEMPERATURE CONSTRUCTION (-10) SUITABLE FOR OPERATION IN AMBIENT TEMPERATURES FROM 0 O TO +350 O F. ROTATION OF MANUAL HANDWHEEL. HIGH TEMP-10 INTERNAL OVERRIDE-M OPTIONS EXTENDED STOPS-S 4) INTERNAL TYPE MANUAL OVERRIDE WITH HANDWHEEL (-M). UNI-DIRECTIONAL OPERATION ONLY. ORDER MUST STATE "ACTUATOR TO FAIL CCW OR CW" TO ASSURE PROPER 5) EXTENDED STOPS (-S, BOTH ENDS INCLUDED). NOT FOR USE AS AN OVERRIDE. 6) EXTENDED STOPS WITH PAD-LOCKABLE DEVICE (-S, BOTH ENDS INCLUDED). EXTENDED STOPS W/LOCKING DEVICE-SL HD SERIES SCOTCH YOKE PNEUMATIC OPTIONS DOUBLE LIST LOW HIGH JS MANUAL JS & HW MANUAL ACTING PRICE TEMP TEMP OVERRIDE OVERRIDE HYD MANUAL OVERRIDE 521 2,182.00 78.75 146.50 400.00 766.00 2,894.00 721 2,222.00 198.00 159.00 400.00 766.00 2,894.00 722 2,912.00 367.00 251.00 400.00 766.00 N/A 731 2,890.00 207.00 159.00 444.00 851.00 3,141.00 732 3,710.00 391.00 275.00 444.00 851.00 N/A SPRING RETURN LIST PRICE LOW TEMP HIGH TEMP JS MANUAL OVERRIDE OPTIONS JS & HW MANUAL OVERRIDE HYD MANUAL OVERRIDE 521SR 2,731.00 103.00 147.00 224.00 426.00 2,951.00 721SR 2,920.00 259.00 159.00 224.00 426.00 3,108.00 722SR 4,222.00 481.00 251.00 224.00 426.00 N/A 731SR 8,760.00 272.00 159.00 N/A N/A (INCLUDED) 732SR 5,167.00 512.00 276.00 250.00 475.00 N/A PLEASE CONSULT FACTORY FOR OTHER APPLICATIONS. NON-STOCK ITEM PAGE 3
SOLENOIDS AND FILTER REGULATORS 3 WAY ASCO ELECTRIC SOLENOIDS MODEL NEMA RATING VOLTAGE NPT SIZE LIST PRICE 8317G35 4 120VAC 1/4 138.50 8317G36 4 DC 1/4 157.25 EF8317G35 7 120VAC 1/4 196.00 EF8317G35 7 DC 1/4 217.00 8321G2 4 120VAC 3/8 250.50 8321G2 4 DC 3/8 264.75 EF8321G2 7 120VAC 3/8 291.25 EF8321G2 7 DC 3/8 304.50 8316G64 4 120VAC 1/2 289.00 8316G64 4 DC 1/2 300.00 EF8316G64 7 120VAC 1/2 353.00 EF8316G64 7 DC 1/2 371.00 4 WAY ELECTRIC SOLENOID MODEL NEMA RATING VOLTAGE NPT SIZE LIST PRICE 8344G70 4 120VAC 1/4 419.00 8344G70 4 DC 1/4 432.00 EF8344G70 7 120VAC 1/4 464.00 EF8344G70 7 DC 1/4 479.00 8344G1 4 120VAC 3/8 438.00 8344G1 4 DC 3/8 463.00 EF8344G1 7 120VAC 3/8 510.00 EF8344G1 7 DC 3/8 533.00 8344G74 4 120VAC 1/2 528.00 8344G74 4 DC 1/2 534.00 EF8344G74 7 120VAC 1/2 598.00 EF8344G74 7 DC 1/2 619.00 FILTER REGULATORS MODEL NPT SIZE LIST PRICE 342-00-238 1/8 66.50 342-00-239 1/4 67.25 342-00-241 3/8 76.00 342-00-242 1/2 92.00 MATERIALS OF CONSTRUCTION Y-ZINC DIE CASTING NT- POROUS PLASTIC BOWL- POLYCARBONATE ALL ITEMS ON THIS PAGE ARE NON-STOCK; PLEASE CONSULT FACTORY FOR DELIVERY. PAGE 4
LIMIT SWITCHES MC LIMIT SWITCH MODEL DESCRIPTION BEACON LIST AAEAA21110 NEMA 4,4X,2SPTD SWITCHES (MECHANICAL) (MC1 - MC47) YES 170.00 AAWAA21130 NEMA 4,4X,2SPTD SWITCHES (MECHANICAL) (MC58 - MC372) N/C 170.00 MOUNTING BRACKETS INCLUDED FOR MC SERIES ACTUATORS WESTLOCK MODEL DESCRIPTION BEACON LIST 2004N NEMA 4,4X,2SPTD SWITCHES (MECHANICAL) YES 196.00 2007XN NEMA 4,4X,7 AND 9 2 SPDT SWITCHES YES 247.00 2085N NEMA 4,4X,2SPDT SWITCHES (MECHANICAL) NO 165.00 2214N NEMA 4,4X, 2SPST SWITCHES (PROXIMITY) YES 293.50 2217XN NEMA 4,4X,7,9, 2SPDT SWITCHES (PROXIMITY) YES 354.50 ADDERS ADD SUFFIX TO ABOVE NUMBERS FOR ADDERS RS ANALOG OUTPUT (1000OHM) 148.50 CS ANALOG OUTPUT (4-20 MA) 381.00 WESTLOCK MAGNUM STYLE LIMIT SWITCHES MODEL DESCRIPTION BEACON LIST *9044N NEMA 4,4X,2SPDT MAGNUM SWITCHES YES 417.00 *9479N NEMA 4,4X,7,9 2SPDT MAGNUM SWITCHES YES 448.00 ADDERS ADD SUFFIX TO ABOVE NUMBERS FOR ADDERS RS ANALOG OUTPUT (10000HM) 303.50 CS ANALOG OUTPUT (4-20 MA) 536.00 NOTE IF NAMUR SHAFT IS NOT REQUIRED, DELETE THE "N" FROM THE PART NUMBER POSITIONERS MC SERIES MODEL DESCRIPTION LIST MCUT-CRP 3-15 PSI PNEUMATIC POSITIONER RINYTE CASE 416.50 POLYCARBONATE COVER INTEGRAL GAUGE MANIFOLD MCUT-UP1EPR 4-20 MADC ELECTROPNUEMATIC POSITIONER ALUMINUM CASE 1,059.00 POLYCARBONATE COVER INTEGRAL GUAGE MANIFOLD MCUT-GM GAUGE SET (3 GAUGES) FOR MODELS MCUT-CRP AND MCUT-UP1EPR 75.50 PMV POSITIONER MODEL DESCRIPTION LIST P5 3-15 (DOUBLE ACTING) HIGH CAPACITY AND GAIN 733.00 EP5 4-20 MADC ELECTRO-PNEUMATIC 1,467.00 EP5-EX 4-20 MADC ELECTRO-PNEUMATIC EXPLOSION 2,184.00 PROOF NOTE: GAUGES, LIMIT SWITCHES, POTENTIOMETERS AND FEEDBACK TRANSMITTERS ARE AVAILABLE PLEASE CONSULT FACTORY NAMUR BRACKETS FOR LIMIT SWITCHES AND POSITIONERS MODEL DESCRIPTION LIST M30N MOUNTING BRACKET FOR LIMIT SWITCH 31.00 M2366N MOUNTING BRACKET FOR LIMIT SWITCH 31.00 * INDICATES NON-STOCK ITEM; PLEASE CONSULT FACTORY FOR DELIVERY PAGE 5
MC SERIES ELECTRIC ACTUATORS REVERSE ROTATION ELECTRIC ACTUATORS- BALL VALVES MODEL LIST PRICE CYCLE TIME/TORQUE LIST PRICE 120 VAC LB. INCH 230VAC, 24 VAC, 12VDC MCR100I 250.00 2.5 SEC/100 N/A MCR200I 279.00 5 SEC/200 355.00 MCR300I 372.00 5 SEC/300 448.00 MCR675I 618.00 15 SEC/675 693.00 MCR100I 755.00 15 SEC/1000 831.00 NOTE: MCR200I, MCR300I, AND MCR675I HAVE ISO MOUNTING DIMENSIONS WITH US THREADS. STANDARD (1) 1/2 INCH CONDUIT-ALL UNITS WIRED FOR TWO LIGHT INDICATION. REVERSIBLE ROTATION ELECTRIC ACTUATORS WITH BRAKES BUTTERFLY VALVES AND DAMPERS MODEL LIST PRICE CYCLE TIME/TORQUE LIST PRICE 120 VAC LB. INCH 230VAC, 24 VAC, 12VDC MCRB200I 482.00 5 SEC/200 550.00 MCRB300I 602.50 5 SEC/300 678.00 MCRB675I 856.00 15 SEC/675 932.00 MCRB1000I 1,006.00 15 SEC/1000 1,082.00 OPTIONAL EQUIPMENT OPTION CODE ADDER LIST ADDER MODELS AVAILABLE ON ONE SWITCH 1S 38.75 ALL TWO SWITCHES 2S 76.40 EXCLUDES MCR100I HEATER THERMOSTAT HT 114.10 ALL VALVE POSITIONER VP 698.00 EXCLUDES MCR100I 1 K POT 1 144.00 EXCLUDES MCR100I POSITION TRANSMITTER TX 326.00 EXCLUDES MCR100I SPEED CONTROL SC 256.00 EXCLUDES MCR100I THREE POSITION 3P 128.50 ALL MANUAL OVERRIDE WITH FLAT SHAFT MO 105.25 STD ON MCR100I,200I,300I NEMA 4/7 HOUSING N7 175.00 EXCLUDES MCR100I SPRING RETURN ELECTRIC ACTUATORS MODEL LIST PRICE 120 VAC CYCLE TIME/TORQUE LB. INCH MCSRE200 1,535.00 5 SEC/200 MCSRE400 2,420.00 15 SEC/300 MCSRE1000 6,540.00 12 SEC/1000 MCSRE2000 7,935.00 14 SEC/2000 OPTIONAL EQUIPMENT AND MC SERIES SPRING RETURN ACTUATORS ARE NON-STOCK ITEMS; PLEASE CONSULT FACTORY FOR DELIVERY. NOTE: SPRING CLOSE TIME ON ALL UNITS ARE 3-4 SECONDS. NEMA 4/7 HOUSING ADD $150 LIST. CAUTION: ELECTRICAL OPERATION OF ACTUATORS MUST BE THROUGH A SINGLE POLE CONTROL SWITCH TO ISOLATE THE UNUSED MOTOR WINDING. PAGE 6
LB SERIES ELECTRIC ACTUATOR INTERMITTENT SERVICE: QUARTER TURN REVERSIBLE WITH 30% DUTY CYCLE 1PH/60HZ/115VAC MOTOR.CSA APPROVED NEMA 4 MODEL LIST PRICE TORQUE LB/IN SPEED SEC/90O DESCRIPTION Z3* 712.00 300 11 Z3 AND OA MODELS ARE COMPLETE WITH SELF-LOCKING WORM OA6 930.50 640 5 GEAR OUTPUT DRIVE, ADJUSTABLE MECHANICAL POSITION STOPS, OA8 978.00 720 5 TWO SPDT TRAVEL LIMIT SWITCHES, INTERNAL TERMINAL STRIP, 1,081.00 720 10 MECHANICAL DIAL POSITION INDICATOR AND MANUAL OVERRIDE 1,081.00 720 25 HANDWHEEL. 1,081.00 720 50 OA15 1,256.00 1350 15 1,256.00 1350 25 AT25 1,963.00 2250 15 AT AND BS MODELS ARE COMPLETE WITH ALL FEATURES 1,963.00 2250 25 DESCRIBED FOR OA MODELS PLUS TWO AUXILIARY SPDT 1,963.00 2250 50 SWITCHES, TWO SPDT MECHANICAL TORQUE LIMIT SWITCHES, AT50* 2,412.00 4500 25 CONTROL COMPARTMENT SPACE HEATER, AND DECLUTCHABLE AT80* 2,803.00 7000 25 MANUAL OVERRIDE HANDWHEEL WITH MOTOR LOCKOUT SWITCH. BT100* 3,111.00 9000 25 3,111.00 9000 50 SRA6RS250* 3,793.00 22000 85 SRA6 AND SR12 MODELS ARE COMPLETE WITH ALL FEATURES SR126RS600* 4,929.50 52000 (CW) 85 DESCRIBED FOR AT AND BS MODELS EXCEPT DECLUTCHING 31500 (45 O ) MANUAL OVERRIDE HANDWHEEL. THE SRA6 IS SUPPLIED WITH 41000 (CCW) ELECTRIC PREFERENCE LEVER OPERATED OVERRIDE. THE SR12 IS AN ELECTRIC PREFERENCE AUTOMATIC OVERRRIDE. CLASS III MODULATING SERVICE: QUARTER TURN REVERSIBLE WITH 50% DUTY CYCLE 1PH/60HZ/115VAC MOTOR. SINGLE 1000OHM-1/2% LINERITY-4 WATT POTENTIOMETER AND GAM ELECTRONIC POSITIONER TO ACCEPT A 4-20 MADC INPUT SIGNAL FOR CONTINUOUS MODULATING SERVICE. CSA APPROVED. NEMA 4. MODEL LIST PRICE TORQUE BREAK / LB/IN RUN SPEED SEC/90 O DESCRIPTION OA8M 2,595.00 720/520 25 OA MODELS ARE COMPLETE WITH SELF-LOCKING WORM GEAR 2,595.00 720/520 50 OUTPUT DRIVE, ADJUSTABLE MECHANICAL POSITION STOPS, TWO OA15M 2,770.00 1350/1780 25 SPDT TRAVEL LIMIT SWITCHES, INTERNAL TERMINAL STRIP, MECHANICAL DIAL POSITION INDICATOR AND MANUAL OVERRIDE HANDWHEEL AT25M* 3,477.60 2250/1300 25 AT AND BS MODELS ARE COMPLETE WITH ALL FEATURES 3,477.60 2250/1300 50 DESCRIBED FOR OA MODELS PLUS TWO AUXILIARY SPDT SWITCHES, AT50M* 3,926.79 4500/2200 25 TWO MECHANICAL TORQUE LIMIT SWITCHES, CONTROL COMPARTMENT BS100M* 4,625.42 9000/5200 25 SPACE HEATER, AND DECLUTCHABLE MANUAL OVERRIDE HANDWHEEL 4,625.42 9000/5200 50 WITH MOTOR LOCKOUT SWITCH. SRA6RS250M* 5,469.98 22000/14000 85 SRA6 AND SR12 MODELS ARE COMPLETE WITH ALL FEATURES SR12RS600M* 6,937.61 52000 (CW)/26000 85 DESCRIBED FOR AT AND BS MODELS EXCEPT DECLUTCHING MANUAL 41000 (CCW)/26000 OVERRIDE HANDWHEEL. THE SRA6 IS SUPPLIED WITH ELECTRIC *INDICATES NON-STOCK ITEM; PLEASE CONSULT FACTORY FOR DELIVERY ALL UNITS HAVE ISO MOUNT PREFERENCE LEVER OPERATED OVERRIDE. THE SR12 IS AN ELECTRIC PREFERENCE AUTOMATIC OVERRIDE. PAGE 7
LB SERIES ACCESSORIES DESCRIPTION Z3 OA AT BS SRA6 SR12 NOTES DC MOTOR OPTIONS 385.00 919.00 1,302.00 1,845.00 # 4 CONTROL COMPARTMENT OPTIONS SPACE HEATER 68.00 68.00 STD STD STD STD # 7 TWO AUX. SPDT POSITION SWITCHES 112.00 76.00 STD STD STD STD # 8 FOR 6 TOTAL SPDT POSITON SWITCH N/A 199.00 282.00 400.00 567.00 804.00 # 8 STANDARD FEEDBACK POTENTIOMETER SINGLE -100ohm 207.00 207.00 293.00 416.00 589.00 225.00 # 9 DUAL - 1000ohm N/A 399.00 564.00 800.00 1,135.00 385.00 # 9 PRECISION FEEDBACK POTENTIOMETER SINGLE -1000ohm N/A 304.00 304.00 304.00 431.00 611.00 # 9,13 SINGLE MYLAR - 1000ohm N/A 561.00 561.00 561.00 794.00 1,125.00 # 9 DUAL - 1000ohm N/A 758.00 758.00 758.00 1,075.00 1,522.75 # 9 RELAY FOR 2 WIRE CONTROL 109.00 108.75 136.00 136.00 193.00 273.00 # 10 RELAY FOR MAINTAINED TORQUE SWITCH OPERATION N/A N/A 613.00 613.00 869.00 1,233.00 # 11,13 CONTROL COMPONENT OPTIONS TAM POSITION TRANSMITTER W/1000 ohm POT N/A 699.00 990.00 1,404.00 1,989.00 2,818.00 #12 ALL LB SERIES ACCESSORIES ARE NON-STOCK ITEMS; PLEASE CONSULT FACTORY FOR DELIVERY LB SERIES NOTES 1) TORQUE AS STATED IS BOTH STARTING AND RUNNING OUTPUT BASED UPON A PLUS OR MINUS 10% VARIATION. 2) SPEED AS STATED IS NOMINAL AT THE RATED ACTUATOR TORQUE. ACTUAL OPERATING TIME MAY VARY DEPENDING ON THE ACTUATOR TORQUE. 3) AVAILABLE ON ALL MODELS AND ALL SPEEDS, 25 SECONDS OR MORE EXCEPT MODEL Z3. SUPPLIED WITH CLASS F MOTOR INSTALLATION. 4) WHEN ORDERING, BE SURE TO STATE MOTOR VOLTAGE AS 220 OR 440 AND CONTROL VOLTAGE 1ph/115VAC OR 1ph 220VAC. WHEN ACTUAOTR IS SUPPLIED WITH A CONTROL COMPARTMENT HEATER, IT WILL BE SUPPLIED SAME CONTROL VOLTAGE. 5) SUITABLE FOR MODULATING SERVICE AND IS AVAILABLE FOR USE WITH 25 SEC/90o OR GREATER (SLOWER) SPEED OF OPERATION ONLY. CAUTION: MOTOR (ACTUATOR) IS SUPPLIED WITH 50% LESS TORQUE THAN STANDARD 30% DUTY CYCLES. 6) SUPPLIED IN SAME VOLTAGE AS 1ph MOTORS OR IN STATED CONTROL VOLTAGE FOR 3ph MOTORS, SERIES WIRING IS STANDARD. THIS OPTION APPLICABLE TO OA MODELS ONLY AND IS SUPPLIED AS STANDARD ON ALL OTHER MODELS. 7) TWO AUXILLARY SPDT SWITCHES SUPPLIED WITH INDIVIDUALLY ADJUSTABLE CAMS AND FULLY WIRED TO TERMINAL POSITION. THIS OPTION APPLICABLE TO OA MODELS ONLY AND IS SUPPLIED AS STANDARD ON ALL OTHER MODELS. 8) TWO AUXILLARY SPDT SWITCHES SUPPLIED WITH INDIVIDUALLY ADJUSTABLE CAMS AND FULLY WIRED TO TERMINAL POSITION. THIS OPTION APPLICABLE TO OA MODELS ONLY AND IS SUPPLIED AS STANDARD ON ALL OTHER MODELS. ON ALL OTHER MODELS. MAXIMUM NUMBER OF POSITION SWITCHES, ANY MODEL, IS A TOTAL OF 4. 9) POTENTIOMETERS SUPPLIED ARE: 1000ohm - 1/2% LINEARITY - 4 WATT. OTHER VALUES ARE AVAILABLE AT ADDITIONAL COST. PLEASE CONSULT FACTORY FOR ADDITIONAL INFORMATION. 10) SUPPLIED AS A SPDT RELAY, FOR 2 WIRE CONTROL OF A 2 POSITION ACTUATOR OR TO ISOLATE CONTROL VOLTAGE (OTHER THAN 3 PHASE). STATE RELAY COIL VOLTAGE AND EITHER NORMALLY CW (CLOSE) OR COW (OPEN) POSITION WHEN ORDERING. 11) SUPPLIED AS 2 SPDT RELAYS, TO CONVERT STANDARD MOMENTARY OPERATION TORQUE SWITCHES TO MAINTAINED OPERATION WITH OVER TORQUE LIGHT INDICATION. NOT AVAILABLE ON OA MODELS. 12) AN ELECTTRONIC POSITIONER TRANSMITTER MOUNTED AND WIRED INSIDE THE ACTUAOTR WHICH PRODUCES A 4 TO 20 MADC LINEAR SIGNAL PROPORTIONAL TO THE ACTUATOR'S OUTPUT DRIVE POSITION. TAM SUPPLY VOLTAGE IS 7 TO 30 VDC. 13) THESE OPTIONAL ACCESSORIES AND/OR FUNCTIONS ARE INCLUDED, IN ADDITION TO ALL STANDARD FEATURES, IN ACTUATOR PRICES FOR MODULATING SERVICE. CAUTION: ELECTRICAL OPERATION OF ACTUATORS MUST BE THROUGH A SINGLE POLE CONTROL SWITCH IN ORDER TO ISOLATE THE UNUSED MOTOR WINDING. PAGE 8
MOUNTING BRACKETS AND LABOR CHARGES BUTTERFLY VALVES SIZE CARBON STEEL PRICE STAINLESS STEEL PRICE LABOR 2" 75.00 161.00 26.00 2 1/2" 75.00 161.00 26.00 3" 75.00 161.00 26.00 4" 75.00 161.00 26.00 5" 75.00 231.00 26.00 6" 75.00 231.00 26.00 8" 98.50 231.00 26.00 10" 98.50 250.00 26.00 12" 98.50 250.00 26.00 14" 139.25 POA 31.00 16" 139.25 POA 31.00 18" 139.25 POA 37.00 20" 139.25 POA 37.00 24" 139.25 POA 37.00 30" & ABOVE POA POA POA BALL VALVES SIZE CARBON STEEL PRICE STAINLESS STEEL PRICE LABOR 1/4" - 1 1/2" 48.00 107.00 15.50 2" 54.00 107.00 15.50 2 1/2" 64.00 113.00 17.75 3" 64.00 187.00 17.75 4" 118.00 209.00 17.75 6" 118.00 209.00 23.00 8" 192.50 209.00 23.00 10" 192.50 279.00 31.00 12" 246.00 279.00 31.00 14" & ABOVE POA POA POA TEE LINK ASSEMBLY* SIZE LIST 2" - 3" 183.00 4" - 5" 196.00 6" - 8" 241.00 10" - 12" 345.00 14" - 16" 467.00 18" - 20" 647.00 24" - 30" 712.00 36" - 40" 807.00 * WHEN ORDER IS PLACED AN ARRANGEMENT # MUST BE LISTED. FOR A COPY OF ARRANGEMENTS, PLEASE CONSULT FACTORY. PAGE 9