Dedication to Excellence Dedication to Excellence Single Seater Golf Buggy Owners Manual www.i-motioncaddys.com sales@i-motioncaddys.com www.i-motioncaddys.com sales@i-motioncaddys.com
Introducing i-m 4 Single seater golf utility vehicle The i-m 4 golf buggy is like any or electrical or mechanical device. Cleaning, care inspection is a "must" which will result in longer life extended reliability! Score Card Holder Assembly Picture 1 Mount score card holder into sleeve on back of golf bag holder. Picture 2 Fix using bakelite knob. General care inspection After every use clean any mud or debris from under body eir with a h brush or a light air hose. Picture 4 Fix using bakelite knob. Use a mild detergent warm water for exterior. DO NOT use a high-pressure wash. Press on score card holder to supprting. Check all bolt nut connections are tight before use, especially wheel nuts. Check tyre pressure maintain recommended pressure at all times. Recharge batteries after every use check battery indicator is full before use. DO NOT allow battery charger to get wet. Let i-m 4 add to your golfing experience. 1 Picture 1. To access batteries, release bakelite knob at rear of buggy, lift body attach fixed hold up arm. 10
Golf bag Bag holder Holder Assembly Scorecard holder Picture 1 Picture 2 Picture 1 Picture 2 1.1. Safety 1. Safety Operation Please read read following following instructions instructions carefully carefully before before using using i-m4 4 golf golf buggy. Hole on bottom Picture 1 Picture 2 Locate pivot arm into slot provided locate bottom pivot arm into fixing on fixing angle. Attach to i-m4 hole provided semi-tighten semi-fasten bakelite knob bakelite Picture knob 4 provided. provided. Bolt on bottom Picture 5 Picture 6 Scorecard Golf bag holder Head of bolt Upper Rectangular hole Bolt on upper Bakelite bolt Tighten both top bottom bakelite knobs for firm fix. Reverse process to remove. Scorecard Finished Assembly Bracket for scorecard DO The NOT i-m 4 use golf buggy throttle is designed hle as to a carry support one when mounting buggy. person. Turn off ignition when not in use. The buggy is NOT road legal. Leave buggy in neutral mode when not in use. Please use throttle to decrease speed The when i-m4 turning golf buggy buggy. is designed to carry one person. The Please buggy use is NOT throttle road legal. to increase speed Please when use climbing throttle a hill. to decrease speed when turning buggy. When driving buggy take care in crowded Please areas, use wet or throttle slippery to surfaces increase tight speed gaps. when climbing a hill. When Do not driving allow ors buggy to use take care i-min 4 crowded buggy areas, wet or slippery without surfaces your permission. tight gaps. Do not allow ors to use i-m4 Please do not st up on i-m 4 buggy without your buggy when permission. in motion as you may lose your balance. Please do not st up on i-m4 buggy when in motion as you may Please lose do your not balance. lean side from side to side on im 4. Please Do not do drive not lean i-m side 4 down from side hills to backwards. side on im4. Do Try not to avoid drive pot i-m4 holes down or uneven hills backwards. paths. Try Keep to avoid i-m pot 4 buggy holes or in uneven a dry area paths. or under cover Keep when not i-m4 in use. buggy in a dry area or under cover when not in use. Do Do not not use use a a mobile phone when when driving buggy. buggy. Do not get off buggy until it has come to a complete st still. Do not get off buggy until it has come to a The direction switch should not be changed when buggy is complete st still. moving. The The Speed direction switch switch should should not be not changed be changed when when buggy is moving. buggy is moving. 9 2
2. Parts List 7. Quick Release Lever for 7. Hlebar Assembly Hlebar Assembly 1 2 Picture 1 Picture 2 Picture 1 Picture 2 3 4 24 7 22 5 6 Fully Hlebar locked lever operation assembly Unlock lever assembly Bolt Picture 4 8 9 10 11 23 12 13 14 Clip Finished head 20 19 18 17 16 15 21 Fold down lever hle Lever hle bar release Picture 1 & 2 Insert hlebar into hole lock bolt Picture 1 & 2 with Flick a spanner. lever on hle over to release tension on Lock fixing in position bolt. clip tightly using clamp. Picture Picture 4 3 & 4 Finished Pull down assembly. lever hle from top fixing. Slide lever to left, releasing holding bolt from top refore releasing hlebars to fold down. 3 8
5. Inspection maintenance Parts Inspection Inspection Golf buggy After use clean any mud or debris from under Golf buggy After use clean any mud or debris from under body eir with a h brush or a light body eir with a h brush or light air air hose. Only use use a a mild mild detergent detergent with with warm warm water water for for exterior. DO NOT use a highpressure jet jet wash. Steering system Ensure Ensure all all parts parts are are functioning properly. Accelerator throttle throttle hle hle Ensure Ensure buggy buggy moves moves when throttle is is turned turned anti-clockwise it stops it stops when when throttle throttle is released. is released. Battery power indicator Ensure Ensure power power has has enough charge remaining before use. Seat Ensure Ensure seat seat is is fixed fixed properly. Brake Brake pedal pedal Ensure Ensure brake brake pedal pedal works works freely. freely. Tyres Ensure tyres are in good condition that Tyres Ensure tyres are in good condition that y y are are at at recommended recommended air air pressure pressure at all at all times. times. Wheels Wheels Check Check all all nuts nuts bolts bolts ensure ensure wheel wheel nuts nuts are are tight tight secure. Batteries Recharge batteries after every use check Batteries Recharge batteries after every use check battery battery indicator indicator is is full full before use. Battery charger DO NOT allow battery charger to get wet. Battery charger DO NOT allow battery charger to get wet. 6. Trouble shooting The buggy won t start 6. Trouble shooting Check key is in on position. Check battery power indicator. The buggy won't start Check Check batteries key is in are connected position. properly. Ensure Check buggy battery is NOT power in indicator. free wheel mode. Ensure Check footbrake batteries is are NOT connected engaged. properly. Battery indicator will not reset Press Ensure Reset buggy indicator is not button in free wheel This is mode. situated after 8 hour charge under body on white controller cover Or Contact your supplier Or Contact your supplier Check charger is working 2.1 Parts list 1) Control panel 2) Golf Golf bag bag holder 3) 3) Hlebar Hlebar release release pin pin 4) 4) Body Body 5) Front suspension 5) Front suspension 6) Front bumper 6) Front bumper 7) Foot brake pedal 7) Foot brake pedal 8) Horn button 8) 9) Horn Battery button power indicator 9) 10) Battery Direction power switch indicator 10) 11) Direction Accelerator switch throttle 11) 12) Accelerator Ignition throttle 12) 13) Ignition Seat suspension 13) 14) Seat Rear suspension carry 14) 15) Rear Electromagnetic carry brake hle (Free wheel lever) 16) 15) Rear tyre Electromagnetic brake hle 17) Padded seat 16) Rear tyre 18) Seat body assembly 17) Padded seat 19) Footplate 18) Seat body 20) Front tyre 19) 21) Footplate Bonnet release catch 20) 22) Front Micro tyre switch 21) 23) Bonnet High/low release speed catch switch 24) Slide cap battery charger point 7 4
3. Operation 4. Specifications 3.1 Operation Please remove charger from buggy before turning ignition key on. Turn ignition key on. Ensure charge indicator is sufficient. Press FWD to move forward. Press REV to move in reverse. Turn throttle anti-clockwise to increase to increase speed. speed. Release throttle to slow down or stop. Brake pedal is for emergency stop only. When throttle is released back wheel is locked automatically for parking on inclines or or declines. Motor brake hle The electro red motor magnetic brake hle brake lever can be (free found wheel under lever) can body be attached found to under motor. body attached to motor. Make sure electro red hle magnetic is in brake vertical lever position is in to vertical engage position motor. engage motor. Dis-engage red electro motor magnetic hle brake to free lever wheel to free vehicle. wheel vehicle. Battery discharging Point The The battery battery charger charger socket socket is is located located under under seat. seat. Ensure cover is replaced after charging. Power Power display display Running time will change according to ground conditions terrain. Running time will change according to ground conditions terrain. FULL CHARGE: LED light/bar is at top FULL CHARGE: All LED lights are on. MINIMAL CHARGE: LED light/bar is at bottom MINIMAL CHARGE: One LED light is on. Seat Seat The seat height can be adjusted to 3 positions using bolts at The top seat end height of can suspension be adjusted spring. to 3 positions using bolts at top Seat end can of have a suspension quick-release spring. system fitted to allow easier seat removal. Golf bag holder The golf bag holder is attached detached using lower upper clamps bakelite at knobs front at of front buggy. of buggy. Rear fold down carrier To open: Release bakelite bolt, fold down rear tighten bakelite bolt. To close: Release bakelite bolt, push up rear re-tighten bakelite bolt. Item Parameter Motor 36V 1200 Watt permanent magnetism Battery 12V 48AH x x 33/ 12V 45AH x 3 / 12V 75AH x 3 Controller Curtis controller 1227-3402 dc36v / 160A Accelerate Hall accelerator continuous variable speed system Charger Full automatic efficiency pulse charger 5 Amp or 8 Amp Dimension 1.27 x x 0.82 x x 1.05m Weight (without batteries) 105kg Carrying capacity 200kg Maximum speed 13-15km/h Low Slope speed climbing capacity 4-6km/h 17 degrees Slope Brake climbing range capacity 17 < degrees 4m 3 secs Brake Turning range radius < 4m 3m 3 secs Turning Brake method radius < Electromagnetic 3m & mechanical brake Brake Micro switch method Electromagnetic Motor protectiory. & mechanical Power cut off brake switch Micro Wheel switch base Motor 90cmprotectiory. Power cut off switch Wheel Minimal base ground clearance 90cm 11cm Minimal Tyre ground clearance 11cm 32.5cm x 15cm 4 Wheels Tyre pressure 32.5cm Front 18 x 15cm psi 4 Wheels Rear 20 psi Tyre pressure Front 20 psi Rear 20 psi i-m 4 Available accessories Mud guards - Front rear Rear golf bag holding Rear Mud basket guards - Front rear Front Rear basket basket assembly Front basket assembly Fold up golf bag holder Fold Waterproof up golf cover bag holder Waterproof Umbrella holder cover Umbrella Scorecard holder Scorecard Back seat holder rest Back Sun shade seat rest canopy Sun Strobe shade lights canopy Strobe Front head lights lights Front Front head lights rear indicator Front rear indicator Ramps Quick release seat system 5 6