ILLUSTRATED PARTS LIST MFG ID NO. 9022000200 CUSTOMER CATALOG NO. PBGT2254 19405 Rev. 2 3.31.05 RD
DECALS 1 For Parts Call K&T 0--923 or 0-51-493 9 3 2 4 10 11 5 23 14 23 1 243 Decal Steering Wheel 2 195449 Decal, Dash 3 22 Decal, Hood, RH 4 23 Decal, Hood, LH 5 145005 Decal, Battery DNGR/PSN 19414 Decal, RPL 053 Decal, Deck Warning 19450 Decal, SD, PNL 9 240 Decal, Fender 10 15140 Decal, Fender Danger 11 1403 Decal, Clutch/Brake 12 19303 Mwr Dck upstop 12 13 13 502 Decal, Deck 14 129 Decal, V-Belt Schematic 19151 Decal, Engine 23 10202X Refl ector, Taillight - - 11251 Decal, Footrest - - 9X42 Pad, Footrest LH - - 99X42 Pad, Footrest RH - - 190 Decal, By-Pass - - 19404 Manual, Operator (English/French) WHEELS & TIRES 1 2 12 11 3 4 10 5 9 1 59192 Cap, Valve, Tire 2 5139 Stem, Valve 3 1022X421 Rim Assembly, Front 4 134H Tube, Front (Ser vice Item Only) 5 10230X Tire, Front 2H Fitting, Grease (Front Wheel 9040H Bearing, Flange (Front Wheel Only) 1045X421 Cap, Axle (Front Wheel Only) 9 1055X Tire, Rear 10 154J Tube, Rear (Service Item Only) 11 102X421 Rim Assembly, Rear 12 5M Fitting, Grease - - 144334 Sealant, Tire (10 oz. Tube) wheel_art_1-vgt NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm 2
SCHEMATIC For Parts Call K&T 0--923 or 0-51-493 BATTERY SOLENOID RED A RED RED M AMMETER (OPTIONAL) WHITE FUSE PTO (DISENGAGED) STARTER B S M G A1 L A2 WHITE BLACK IGNITION SWITCH BLACK CLUTCH / BRAKE (PEDAL UP) GRAY SEAT SWITCH (NOT OCCUPIED) BLACK BLACK GRAY BLACK REVERSE SWITCH SHORTING CONNECTOR NOT IN REVERSE BLACK ELECTRIC CLUTCH BLACK RED BLACK / WHITE BLUE FUEL SHUT-OFF SOLENOID FUEL LINE IGNITION UNIT HOUR METER (OPTIONAL) SPARK PLUGS GAP (2 PLUGS ON TWIN CYL. ENGINES) BLACK BLUE RED (IF SO EQUIPPED) ORANGE CHARGING SYSTEM OUTPUT 1 AMP DC @ 300 RPM REGULATOR 2 VOLTS AC @ 300 RPM (REGULATOR DISCONNECTED) ALTERNATOR LIGHT SW BROWN BLACK BLACK IGNITION SWITCH POSITION CIRCUIT MAKE OFF M+G+A1 RUN/OVERRIDE B+A1 RUN B+A1 L+A2 START B+S+A1 0232 NOTE YOUR TRACTOR IS EQUIPPED WITH A SPECIAL ALTERNATOR SYSTEM. THE LIGHTS ARE NOT CONNECTED TO THE BATTERY, BUT HAVE THEIR OWN ELECTRICAL SOURCE. BECAUSE OF THIS, THE BRIGHTNESS OF THE LIGHTS WILL CHANGE WITH ENGINE SPEED. AT IDLE THE LIGHTS WILL DIM. AS THE ENGINE IS SPEEDED UP, THE LIGHTS WILL BECOME THEIR BRIGHTEST. 3 HEADLIGHTS NON-REMOVABLE CONNECTIONS REMOVABLE CONNECTIONS WIRING INSULATED CLIPS NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE REPLACED TO PROPERLY SECURE YOUR WIRING.
ELECTRICAL 22 9 21 24 42 41 43 40 2 2 30 33 25 34 D.C. AMPERES 45 2 50 9 9 95 1 11 10 29 12 1 2 2 2 193394 12 4
ELECTRICAL 1 14492 Battery 2 40412 Bolt Hex Head 1/4-20 x 3/4 03J Tray, Battery 10 145211 Bolt 1/4-20 x.5 Zinc 11 150109 Hold down Battery Dash Mount 12 1459 Nut Push Nylon 1/4" 1 13 Switch Interlock 21 5 Harness Socket Light W/4152J 22 4152J Bulb Light 24 1544 Cable Battery 25 14149 Cable Battery 2 1024X Fuse 2 3510400 Nut Keps Hex 1/4-20 Unc 2 09 Cable, Ground 29 19249 Switch, Seat 30 193350 Switch, Ign 33 140401 Key, Ignition 34 11012X Switch Light/Reset 40 193394 Harness Ign. 41 2040 Screw Thd Cut 1/4-20 x 1/2 42 13153 Cover, Terminal 43 1 Solenoid 45 12222X Ammeter 50 453 Switch, PTO 9 5242 Socket Asm. Bulb 95 193 Bracket ROS 9 104445X Switch Intek 9 15292 Screw #10-32 5 3/ NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm 5
CHASSIS For Parts Call K&T 0--923 or 0-51-493 15 14 153 130 5 14 130 11 15 15 152 1 12 3 13 35 31 15 130 15 5 144 1 15 122 150 122 43 130 30 139 32 2 14 143 21 2 4 34 1 33 139 142 3 45 50 130 2 19 20 19 91 13 4 3 19 3 10 0 3 1 45 3 0 4 44 24 chassis-stealth II_3-vgt 5 39 3
CHASSIS For Parts Call K&T 0--923 or 0-51-493 1 1035 Rail, Frame RH 2 522 Drawbar, Gt 4 3000 Nut, Crownlock Hex /1-14 unc 5 1933X42 Dash 152 Dash, Lower Vgt One Piece 2040 Screw, Thd Cut 1/4-20 x 1/2 14 Support, Battery 14 520X15 Hood Asm 1 1294X Cover, Access 00012 Screw 3/-1 x 3/4 Zc 1 529X42 Grille 19 19131312 Washer 13/32 x 13/1 x 12 Ga. 20 401 Bolt Fin Hex 3/-1 x 1 Gr. 5 21 30000 Nut Lock 3/-1 unc 24 9X42 Footrest, RH 2 91X42 Footrest, LH 30 145051X014 Saddle, Slkscr Vgt 31 11419 Bracket Support 1-pc 32 1132 Bracket, Pivot Chassis Lh 33 1132 Bracket, Pivot Chassis Rh 34 01 Plate Asm Engine Chassis 35 1911111 Washer 11/32 x11/1 x 1 Ga. 3 00512 Screw 5/1-1 x 3/4 3 92X42 Fender 39 52 Bracket, Axle Front 43 13939 Bracket, Spnsn Front Lh 44 13940 Bracket, Spnsn Front Rh 45 120 Bracket Chassis 50 54 Bracket, Chassis Front 5 1359 Bracket Fender 0 0020 Screw 3/-1 x 1-1/4 3 1913114 Washer 13/32 x 1 x 14 Ga. 4900 Screw 3/-1 x 1/2 1593 Guide, Belt Gear Drive 49050 Screw Thdrol. 5/1-1 x 1/2 0 15 Guide, Belt 4 114 Up Stop 5 193923 Bracket, Support Transaxle 401 Bolt Fin Hex /1-14 unc x 1 1004000 Washer, Lock Hvy Hlcl Spr /1 91 1034 Rail, Frame Lh 10 50520 Screw Thdrol 5/1-1 x 1.25 122 192512 Screw Wshd Hex 10-32 x 5/ 130 19111 Screw 10 x 3/4 Single Lead-Hex 13 401 Bolt Fin Hex /1-14 x1 Gr. 5 13 191121X42 Cupholder YTGT 139 13 Bolt Shoulder 5/1-1 TT 142 119 Bracket Dash Rh 143 194X42 Skirt Grille RH 144 11900 Bracket Dash Lh 14 194X42 Skirt Grille LH 14 1455 Extrusion Bumper 150 5352 Duct Heat Hood 152 95 Shield Browning 153 91 Light Box Asm w/lens 15 000512 Screw 5/1-1 x 3/4. Blk 15 1140 Lens Bar 15 00 Screw Thdrol. 3/-1 x 1/2 11 912X42 Console Fuel Window 12 142432 Screw Hex Wsh Hi-Lo 1/4-1/2 15 13554 Bracket Support Tank 1 142 Bushing Snap 19 159 Bracket Chassis Sway 2 12014 Screw 3/-1 x.5 NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
DRIVE 39 40 41 42 3 3 30 4 3 29 35 1 4 3 3 50 34 15 2 9 30 51 21 13 1 14 2 11 19 1 52 23 5 4 5 55 54 4 4 2 22 10 24 25 59 23 5 0 9 3 1 15 155 5 4 2 3 drive_9-vgt 2
DRIVE For Parts Call K&T 0--923 or 0-51-493 3 53R Washer, Thrust, Axle 4 49050 Screw Thdrol 5/1-1 x 3/4 5 3000 Nut, Crownlock 3/-1 020412 Pin, Cotter 149 Wheel, Hub Assembly 12000034 Klip, Ring 9 14000 Bolt, Hub 10 142509 Disc, Brake 11 1392 Yoke, Brake Disc 13 139419 Washer, Special 14 13901 Bushing 15 1913131 Washer 13/32x13/1 x 1 Ga. 1 143012 Set, Screw 1/4-2 x 3/4 12909X Spring 1 13104 Lever, Brake 19 1392 Cam, Brake Disc 21 2320412 Screw, Flat Head 1/4-2 x 3/4 22 194121 Gearshift, Lever Assembly 23 10932X Knob 24 13925 Support, Puck Brake 25 13923 Puck, Brake Top 2 13552 Spring, Return 2 193135 Screw, Hexwsh Thd. 5/1-1 x 1-3/4 2 335000 Nut, Hex Jam 3/-1 29 13213 Brake, Rod 30 191311 Washer 13/32 x 1 x 1 Ga. 34 13 Cap, Plunger 35 134 Rod, Parking Brake 3 149412 Spring, Drive Ground 3 1249X Washer 25/32 x 1-1/4 x 1 Ga. 3 150035 Nyliner 39 432101 Screw, Fin. #10-24 x 1 40 55 Actuator, Interlock Switch 41 3931000 Nut, Centerlock #10-24 42 123533X Cover, Pedal 4 1450 Retainer, Spring 4 1322 Clutch Rod 4 211012 Bolt, Carr. 3/-1 x 1-1/2 Gr. 5 50 131494 Pulley, Idler, Flat 51 30000 Nut, Crownlock 3/-1 unc 52 139123 Pulley, Idler, Grooved 54 11590 Clutch, Arm Assembly 55 1050X Bearing, Idler 5 13153 V-Belt 5 145 Bracket, Shift Rod, Hi-Lo 59 122253X Shift Rod, Hi-Lo 0 1222X Spring Clip, Connecting Link 1 14 Pulley, Transaxle 2 1004000 Washer, Lock /1 3 4020 Bolt, Fin Hex /1-14 x 1-1/4 4 15452 Shaft, Clutch/Brake Pedal 5 913 Bolt, Shoulder 14029 Washer, Hardened 19131312 Washer, Flat 5142H Pin, Roll 9 1332 Hub, Cover 1 390000 Nut, Lock Flg. 3/-1 unc 155 1200002 Ring Retainer 15 130H Washer Thrust 5/ x 1.10 x 1/32 NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm 9
STEERING ASSEMBLY 2 51 45 9 2 3 1 4 15 14 10 11 12 9 3 21 20 14 15 23 5 22 34 33 32 2 41 13 31 29 3 14 15 13 13 53 42 19 2 2 1 52 15 14 35 1 steering_15-vgt 10
STEERING ASSEMBLY 1 1094X42 Wheel, Steering 2 55 Axle Asm., Front 3 1322 Fitting, Grease 4 1149 Spindle Asm, LH 5 114 Spindle Asm., RH 2H Bearing, Race Thrust Harden 124X Washer 25/32 x 1-5/ x 1 Ga. 12000029 Ring Klip #T5304-5 9 121232X Cap, Spindle 10 41044 Bolt, Fin Hex 5/-11 x 2-3/4 11 1351 Spacer Bearing Axle Front 12 3901000 Nut, Lock Flange 5/-11 Unc 13 1249X Washer 25/32 x 1-1/4 x 1 Ga. 14 1004000 Washer, Lock Hvy Hlcl Spr 3/ 15 354000 Nut, Crownlock 3/-24 1 191049 Shaft Asm., Steering 1 199 Draglink, Ball Joint Solid Vgt 19 15011 Support Asm., Steering Vgt 20 13X42 Boot, Steering 21 13 Adapter, Wheel Steering 22 155105 Bushing, Strg. Blk 23 15292 Screw 2 1095X42 Cap, Wheel Steering 2 33R Bearing, Col. Strg. 2 00012 Screw 3/-1 x 3/4 29 104239X Bearing, Flange 31 1313 Bushing, Nyliner Snap 32 1911110 Washer 11/32 x 1 x 10 Ga. 33 10040500 Washer, Lock Hvy Hlcl Spr 5/1 34 40512 Bolt, Fin Hex Hd 5/1-1 x 3/4 35 1039 Gear, Sector Steering 3 199 Tie Rod 41 15524 Bracket Switch Interlock VGT 9 42 49050 Screw Thdrol 5/1-1 x 1/2 Tyt 45 191312 Washer 9/1 ID x 2-3/ OD 12 G zin 51 394000 Nut Hex Jam Toplock 1/2-20 unf 52 5553 Clip Steering 53 19 Washer Hardened NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm 11
SEAT ASSEMBLY 1 20 14 20 10 1 15 4 5 1 5 13 12 19 3 2 21 3 seat_1-vgt 12
SEAT ASSEMBLY 1 120 Seat 2 140551 Bracket Pivot Fender 3 1405 Strap, Fender Assy. 4 1201X Bolt Shoulder 5/1-1 x.2 5 14500 Clip, Push In, Hinged 30000 Nut, lock 3/-1 Unc 12411X Spring, Seat Cprsn 1 Bolt 5/1-1 Unc x 3/4 w/sems 10 12493 Pan, Seat 12 44 Bracket, Mounting Switch 13 12124X Bushing, Snap 14 2050412 Bolt, Carriage 1/4-20 x 1-1/2 15 134300 Spacer, Split 1 121250X Spring, Cprsn 1239X Nut, Lock 1/4 Lge Flg Gr. 5 1 191912 Washer /32 x 1-3/1 x 12 Ga. 19 139 Knob, Seat 20 12423X Cap, Spring Seat 21 152 Bolt, Shoulder 5/1-1 3 300500 Nut, Crownlock 5/1-1 Unc NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm 13
ENGINE For Parts Call K&T 0--923 or 0-51-493 22 1 3 9 2 45 21 20 4 2 0 1 4 12 1 9 11 2 1 15 41 42 3 4 10 43 2 9 29 2 engine_els_2-vgt 2 3 39 31 40 SPARK ARRESTER KIT 14
ENGINE 1 - - - - - - - Engine Briggs, Model No. 40H (Order parts from engine manuf.) 2 14923 Muffl er Side 12131X Pulley V-Idler 9 4 Keeper Asm. Belt Engine VGT 10 52 Bushing 11 9335 Clutch 12 14399 Pulley Engine VGT Elect Clutch 15 9115 Tank Fuel Rear 5.0 1 9124X42 Cap Asm. Fuel 20 543X42 Control Throttle 21 19111 Screw 10 x 3/4 Single Hex 22 1X42 Control Choke 2 345J Bushing 2 1392 Stem Tank Fuel 2 19 Fuel Line 29 1310 Spark Arrester Kit 31 14500 Clip Push-In Hinged 3 1234X Clamp Hose 39 4903 Screw TT 3/-1 x 2-1/4 Unc 40 4904 Screw TT 3/-1 x 4 Unc 41 1219X Washer 1-1/2 OD x 15/32 ID x.250 42 1004000 Washer Lock /1 45 3510400 Nut Keps Hex 1/4-20 4 52 Spacer 2 1429 Shield Heat Muffl er CV-Intek 9 15391 Gasket 0 09 Tube Exhaust LH 1 00 Tube Exhaust RH 9 1390 Screw Socket Head 5/1-1 x 1 1 100 Tube Drain Oil 2 199 Valve Oil Drain 3 1 Bolt 5/1-1 Unc x 1-3/4 W/Sems 4 0024 Screw Thdrol 3/-1 x 1-1/2 5 9953 Bolt Hex /1-20 x 3.5 Gr. 5 NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm For engine service and replacement parts, call the tollfree number for your engine manufacturer listed below: Briggs & Stratton 1-00-233-323 Kohler Co. 1-00-544-2444 Tecumseh Products 1-00-55-5402 Honda Engines 1-00-42-01 Kawasaki 1-00-40-5 15
MOWER DECK 90 95 12 4 10 94 54 / 4_nose_roller_1 13 4 34 3 10 91 90 4 114 21 42 49 52 4 122 43 9 33 9 50 49 5 5 1 32 31 51 33 39 33 32 30 31 11 1 119 5 11 113 21 35 3 5 59 50 21 29 25 2 2 1 1 0 15 14 5 21 11 13 1 mower_deck-54_1 1
For Parts Call K&T 0--923 or 0-51-493 MOWER DECK 1 1295 Deck Weldment Mower 5 4939M Retainer Spring 129 Cover Mandrel LH 11 Cover Mandrel RH 435 Bolt /1 Asm. Blade 11 1254 Blade, Standard (For mulching mowers only) 13 1291 Shaft Asm. w/lower Bearing 14 121 Housing, Mandrel 15 11045X Bearing, Ball, Mandrel 2140505 Bolt, Carriage 5/1-1 x 5/ 21 30500 Nut, Crownlock 5/1-1 unc 25 102 Spring, Torsion 2 110452X Nut, Push 2 125X42 Defl ector Shield 29 131491 Rod, Hinge 30 394 Screw, Thdroll Washer Head 31 190 Washer, Spacer Mower Vented 32 343 Pulley, Mandrel 33 342 Nut, Flg. Top Lock Cntr. 9/1 34 3000 Nut 35 135 Pin Suspension Rear 3 1913131 Washer 13/32 x 13/1 x 1 Ga. 3 15 Spring Compression 39 124 Pulley, Idler, Stationary 42 122052X Spacer, Retainer 43 12 Arm, Idler 4 1329 Screw, Thdroll. 1/4-20 x 5/ 4 19123 V-Belt, Mower 49 390000 Nut, Lock Flg. 3/-1 unc NO. NO. DESCRIPTION 50 21101 Bolt, Carr. 3/-1 x 2 51 211010 Bolt 52 140 Pulley Idler Clutching 5 1559 Bar Pnt Adj. 5 15941 Pin Head Rivet 5 1342 Baffl e Right 59 1344 Baffl e Left 0 10 Baffl e Center 90 4051 Bolt Hex HD 5/1-1 UNC x 1 91 10535 Bracket Nose Roller RH 94 0 Roller Nose 95 10534 Bracket Noseroller LH 9 19133210 Washer 13/32 x 2 x 10 Ga. 9 122 Spring Clutch Drive 113 211050 Bolt Rdhd Sqnk 5/1-1 x 3/4 114 155 Rod Tension Relief 11 19340 Bolt, Shoulder 1 43 Gauge Wheel 11 393000 Nut, Centerlock 3/-1 unc 119 19121414 Washer 3/ x / x 14 Ga. 122 155 Bushing Tension Relief 10 300500 Nut Lock HX w/ins 5/1-1 UNC 12 912 Rod Roller Nose 13 13552 Retainer Spring - - 1292 Mandrel Asm. Service (Includes Key Nos. 13-15 and 33) - - 121 Replacement Mower, Complete NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm
MOWER LIFT 40 43 3 35 3 34 39 32 31 30 9 10 42 0 1 12 4 5 5 4 29 2 33 3 11 2 11 0 9 23 5 41 4 5 41 0 12 24 2 5 23 lift_rh_ 1
MOWER LIFT 1 12100X Rod Asm., Lever 2 10045 Shaft Asm., Lift Vgt 3 15919 Lever Asm., Lift Rh 4 12000022 E-Ring Truarc #5133-5 1929201 Washer 29/32 x 1-1/4 x 1 Ga. 111024 Bolt, Fin Hex 3/-1 unc x 1-1/2 530 Grip, Handle Fluted 531X421 Button, Plunger 10 1394 Spring 0.2 OD x 2.125 11 535 Link Lift 12 13552 Retainer Spring 23 4939M Retainer, Spring 24 335000 Nut, Jam Hex 1/2-13 unc 2 30000 Nut, Lock 1/2-13 unc 29 150233 Trunnion, Infi n Height 30 1100X Nut, Special 31 1913101 Washer 13/32 x 5/ x 1 Ga. 32 13150 Spring, Compression Inf Hgt 33 02030 Pin Cotter 3/32 x 1/2 34 131 Rod, Adj Lift 35 1305 Knob, Inf 3/-1 unc 3 15509 Pointer, Height Indicator 39 123935X Plug, Hole 40 0051 Screw 5/1-1 x 1 41 5994 Nut, /1-20 42 19112410 Washer 11/32 x 1-1/2 x 10 Ga. 43 123934X Scale, Indicator Height 0 145212 Nut Hex Flange Lock 2 110452X Nut Push Phos & Oil 3 335000 Nut Hex Jam 3/-1 unc 4 12 Arm Susp. RH 5 505 Plate Asm Susp. Front 550 Pin Flange 205 Trunnion Susp. Arm 59 Trunnion Susp. Front 9 12 Arm Susp. LH 5 19013 Insert Wear 152 Bolt Shoulder NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm 19
TRANSAXLE 20
TRANSAXLE 1 419R Axle Shaft 2 12000034 Retaining Ring 3 4199R Final Drive Gear 4 421R Differential Gear 5 4215R Differential Pinion 42R Differential Carrier 42 Axle Thrust Washer 402052 Bolt, Hex Head 3/-24 x 3-1/4 (1" Thread Length) 9 392M Steel Ball 10 1321 Spring Shift Fork Detent 11 495R Shift Fork, High-Low Range 12 2H Thrust Bearing Race 13 4212R 4th Reduction Pinion 14 13125 Shaft, Brake 15 2H Snap Ring, Crescent Type 1 33A3 High-Low Range Gears 11M Needle Bearing 1 40H1 Sintered Iron Bearing 19 12223X Shift Fork Shaft, High-Low Range 20 421R Differential Pinion Spacer 21 252H1 Differential Pinion Bushing 22 10H Gripco Centerlock Nut 3/-24 23 22H Shift Fork, R.H. 24 393R Oil Seal 25 992R1 Sintered Iron Bearing 2 139111 Shift Fork Shaft 2 49R Shift Fork, L.H. 2 122254X Shift Shaft, High-Low Range 29 29H Oil Seal 30 555H Pressure Relief Valve 31 431 Gearcase, Reverse Idler Shaft and Bearings, R.H. (Includes Key No. s,1, 25, 33, 50, 3, and 2) 32 2H Dowel Pin 33 4225R Needle Bearing 34 39H Thrust Bearing Race 35 419R 4th Reduction Gear Shaft 3 4200R 4th Reduction Gear Spacer 3 395H Thrust Bearing Race 3 109 Gate, Lower, Shift 39 429 Gearcase and Bearings, L.H. (Includes Key umbers 1, 25, 49, 50 (2), 51 and 52) 40 13320400 Pipe Plug 1/2-14 N.P.T. 41 50520 Bolt, Hex 5/1-1 UNC x 1-1/4 45 21H Oil Seal 4 1300200 Pipe Plug 1/4-1 N.P.T. 49 495H Needle Bearlng 50 4222R Needle Bearing 51 1529R Needle Bearing 52 119M Needle Bearing 53 4220R Thrust Bearing Race 54 4209R 3rd Reduction Pinion, Low 55 4213R 4th Reduction Gear 5 4442R 3rd Reduction Pinion Spacer 5 4195R 2nd Reduction Gear Shaft 5 4214R Final Drive Pinion 59 4194R 1st Reduction Gear Shaft 0 52R 1st Reduction Shaft Spacer 1 420R 3rd Reduction Plnion Hlgh 2 420R 2nd Reduction Gear 3 39H Needle Bearlng 4 4203R Low Speed Gear and 2nd Reductlon Pinion Cluster 5 4204R Reverse Gear 29J Key, Hi-Pro 1/ x /32 12000033 Klip Ring 4205R Intermediate Speed Gear 9 420R High Speed Gear 0 130H Thrust Bearing Race 1 33A9 Intermediate and High Speed Cluster Pinions 2 139120 Input Shaft 3 4201R Low Speed Pinion 4 1200000 E-Ring 5 1153R Reverse Idler Gear 03J Needle Bearing 9 11R Sealing Washer 0 33000 Nut, Hex, Jam /1-20 1 20H Oil Seal 2 1394 Reverse Idler Shaft 4 534J Gearshift Lever, Bent 5 29J Gearshift Cap 33A5 Gearshift Ball Cover and Pin 39H1 Shift Lever Guide Ball, Keyed 4924H Spring 9 1915151 Washer 15/32 x 15/1 x 1 Ga. 90 110542X Shift Mechanism Seal 91 1911511 Washer 9/1 x 15/1 x 12 Ga. 92 5J Gearshift Gate and Reinforcement 93 24H Shift Ball Cover Gasket 94 020412 Cotter Pin 1/ x 3/4 9 19403 Bolt Hex 5/1-1 x 1 Epoxy 9 194121 Lever Assembly ROS Gearshift 9 1495 Transaxle, Speed, Complete Assembly 99 19333 Actuator, Shift Lever NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm 21
SERVICE NOTES 22