1 MAIN EHICLE SPECIFICATIONS NOTE: * Computed values. ** Frame point next to steer tire. 10 13 1 Manufacturer TOYOTA TOYOTA 2 10 13 3 Capacity kg 120 4 Center mm 00 00 Power Type attery attery 6 Operator Position Rider Seated Rider Seated 7 Tire Type Front/Rear Pneumatic Pneumatic 8 Wheels (x = driven) Front/Rear 2x/2 2x/2 9 Maximum Fork (MFH) mm 10 Free Lift mm 14 13 Fork Size T x W x L mm 30x100x770 3x100x80 Fork Spread (Outside) MAX./MIN. mm /200 /200 14 Tilt Range FWD/WD deg /6. /6. 1 Length to Fork Face mm 170 17 16 Overall Width mm 107 107 17 Mast Lowered mm 18 Mast Extended mm 19 Overhead Guard mm 1980 1980 21 Turning Radius (Outside) mm 136 0 22 Distance (Centerline of front axle to front face of forks) mm 34 30 Rear Overhang mm 1 190 23 asic Right Angle Stacking Aisle Width (Add load length and clearance) mm 1710 170 24 Travel, Max. Full km/h 1/1 1/1 (FWD/RS) No km/h 16./16. 16./16. 2 Speeds Lifting Full mm/sec 490 40 No mm/sec 610 610 26 Lowering Full mm/sec 00 00 No mm/sec 0 0 27 Drawbar Pull * Full / No 3-Minute Ratings N 9600/9100 900/9100 -Minute Ratings N 9600/9100 900/9100 60-Minute Ratings N 300/100 200/100 29 Gradeability * 3-Minute Ratings % (tanθ) 32/24 27/22 Full / No -Minute Ratings % (tanθ) 32/24 27/22 30-Minute Ratings % (tanθ) 24/24 20/22 32 Total Weight attery kg 1690 1890 33 Weight Front kg 28 3280 Full Distribution Rear kg 370 39 34 ( STD Front kg 1160 110 attery) No Rear kg 106 127 3 Number Front/Rear 2/2 2/2 36 Tires Front 18x7-8-10PR (I) 18x7-8-14PR (I) Size 37 Rear 1x4.1/2-8-12PR (I) 1x4.1/2-8-12PR (I) 38 Wheelbase mm 1210 1210 39 Tread Front mm 89 89 Rear mm 17 17 mm Overhead Guard Clearance mm 102 102 Counterweight mm 92 92 Step /Floor mm 430/4 430/4 40 Underclearance Min. <Frame>** (No ) mm 60 60 41 Center of Wheelbase (Full ) mm 80 80 Grade Clearance Frame % (tanθ) 28 28 42 rake Service (Foot) Mechanical Mechanical 43 Parking Hand Hand oltage/capacity STD /AH 48/280 48/280 4 attery (-hour rating) High /AH 48/36 48/36 46 Weight (STD Capacity Type) kg 3 3 47 Electric Motors Drive kw 4.9x2 4.9x2 48 Handling kw 9.2 9.2 4 Control Type Drive Transistor inverter Transistor inverter Handling Transistor inverter Transistor inverter 7 Operating Pressure For Attachments Mpa (psi) 13.7 (2000) 13.7 (2000) S-FE10-1 -1 October 2008
DIMENSIONAL DRAWINGS 10 RATED CAPACITIES 10 W 10 17 107 89 200 100 A A: Max. Fork : Center W: Capacity 6. 136 160 102 1980, S, F Mast Unit: kg (W) A (mm) 300 400 000 00 90 80 800 600 890 890 80 760 720 700 810 810 770 690 60 (mm) 800 740 740 700 630 90 900 680 680 60 80 40 630 630 600 30 00 FS Mast Unit: kg (W) A (mm) 4700 000 00 6000 00 90 900 80 70 700 00 600 80 810 760 670 630 40 700 770 730 690 610 70 410 (mm) 800 710 670 630 60 20 370 900 60 620 90 20 480 340 610 70 40 480 40 320 28% 92 30 34 1210 1 770 170 18x7-8-10PR (I) 1x4.1/2-8-12PR (I) UNDERCLEARANCE Mast (Full )------------------------------ 7 Drive Axle (Full )----------------------- 90 Center of Wheelbase (Full ) -------- 80 Counterweight (No ) ------------------ 8 SPECIAL MAST Wide isible Mast (, S), Wide isible Full-Free Lift Two-Stage Mast (F), Wide isible Full-Free Lift Three-Stage Mast (FS) 10 Type of Mast, S F FS PERFORMANCE Power Mode H P S H P S H P S Speeds Lifting Full mm/sec 490 410 340 460 390 320 460 390 320 No mm/sec 610 40 480 60 490 430 60 490 430 Lowering Full mm/sec 00 00 00 480 480 480 480 480 480 No mm/sec 0 0 0 420 420 420 40 40 40 DIMENSIONS Distance (Centerline of front axle to front face of forks) mm 34 34 38 NOTE: H High power mode. P Power mode. S mode. S-FE10-2A -2 September 2008
DIMENSIONAL DRAWINGS 13 RATED CAPACITIES 13 W 13 17 107 89 A A: Max. Fork : Center W: Capacity 6., S, F Mast FS Mast Unit: kg (W) Unit: kg (W) 102 92 200 100 0 1600 1980 A (mm) 300 400 000 00 120 120 1200 1100 90 600 1120 1120 1070 980 80 700 1010 1010 970 890 770 (mm) 800 890 810 700 900 80 80 820 70 60 790 790 760 690 600 A (mm) 4700 000 00 6000 00 110 1100 900 800 600 600 1030 990 900 810 720 40 700 940 900 820 730 60 490 (mm) 800 860 820 70 670 600 40 900 790 760 690 620 0 410 740 700 640 80 10 380 14 28% 3 30 1210 190 80 17 18x7-8-14PR (I) 1x4.1/2-8-12PR (I) UNDERCLEARANCE Mast (Full )------------------------------ 7 Drive Axle (Full )----------------------- 90 Center of Wheelbase (Full ) -------- 80 Counterweight (No ) ------------------ 8 SPECIAL MAST Wide isible Mast (, S), Wide isible Full-Free Lift Two-Stage Mast (F), Wide isible Full-Free Lift Three-Stage Mast (FS) 13 Type of Mast, S F FS PERFORMANCE Power Mode H P S H P S H P S Speeds Lifting Full mm/sec 40 380 300 430 290 430 290 No mm/sec 610 40 480 60 490 430 60 490 430 Lowering Full mm/sec 00 00 00 480 480 480 480 480 480 No mm/sec 0 0 0 420 420 420 40 40 40 DIMENSIONS Distance (Centerline of front axle to front face of forks) mm 30 30 390 NOTE: H High power mode. P Power mode. S mode. S-FE10-2 -3 September 2008
MAST SPECIFICATIONS & RATED CAPACITIES Wide isible Mast (), Wide isible Mast (S), Wide isible Full-Free Lift Two-Stage Mast (F), Wide isible Full-Free Lift Three-Stage Mast (FS) 10 Mast Type S F FS Maximum Fork Lowered NOTE: of standard load backrest is mm. * with A4 piping, plus 8 mm. ** with A4 piping, minus 90 mm. ( ) for Windshield s. Overall Extended Free Lift Tilt Range Capacity at 00 mm LC FWD WD mm mm mm mm mm mm deg deg kg 200 300 400 000 300 200 300 400 4700 000 00 6000 270 2820 3070 270 1770 1870 2040 270 30* 32* 3* 38* 40* 42* 4* 0* * 368 398 418 3080 3280 380 3880 4080 4280 480 427 47 487 07 27 7 607 67 420 220 420 620 6420 6 1170** 1270** 1420** 170** 1670** 1830** 2020** 122 132 142 149 17 167 183 202 830 930 1080 1230 1330 1490 1680 880 980 1080 110 1230 1330 1490 1680 6. 6. () 6. () 6. () 6. () 6. () 6. () 6. () 6. () 6. () 6. () 6. 6. () 6. () 6. () 6. () 6. () 6. 6. 6. () 6. () 6. () 6. () 6. () 6. () 90 80 800 90 90 90 900 80 80 70 700 00 10.13 13 Mast Type S F FS Maximum Fork Lowered NOTE: of standard load backrest is mm. * with A4 piping, plus 8 mm. ** with A4 piping, minus 70 mm. ( ) for Windshield s. Overall Extended Free Lift Tilt Range Capacity at 00 mm LC FWD WD mm mm mm mm mm mm deg deg kg 200 300 400 000 300 200 300 400 4700 000 00 6000 270 2820 3070 270 1770 1870 2040 270 30* 32* 3* 38* 40* 42* 4* 0* * 368 398 418 3100 0 3900 4100 4600 427 47 487 07 27 7 607 67 420 220 420 620 6420 6 14 14 14 14 14 14 14 14 14 36 36 36 11** 12** ** 1** 16** 181** 200** 122 132 142 149 17 167 183 202 14 14 14 14 14 14 14 14 14 36 36 36 83 93 108 123 133 149 168 88 98 108 11 123 133 149 168 6. 6. () 6. () 6. () 6. () 6. () 6. () 6. () 6. () 6. () 6. () 6. 6. () 6. () 6. () 6. () 6. () 6. 6. 6. () 6. () 6. () 6. () 6. () 6. () 120 120 120 120 120 120 1200 1100 90 120 120 120 120 120 120 120 120 120 1200 110 110 1100 900 800 600 S-FE10-3 -4 October 2002
MAIN EHICLE SPECIFICATIONS NOTE: * Computed values. ** Frame point behind drive tire. PSC: Pneumatic-Shaped Cushion 1 18 1 Manufacturer TOYOTA TOYOTA TOYOTA 2 1 18 3 Capacity kg 100 170 2000 4 Center mm 00 00 00 Power Type attery attery attery 6 Operator Position Rider Seated Rider Seated Rider Seated 7 Tire Type Front/Rear Pneumatic Pneumatic PSC/Pneumatic 8 Wheels (x = driven) Front/Rear 2x/2 2x/2 2x/2 9 Maximum Fork (MFH) mm 10 Free Lift mm 14 14 12 13 Fork Size T x W x L mm 3x100x 3x100x 38x120x Fork Spread (Outside) MAX./MIN. mm /200 /200 1020/240 14 Tilt Range FWD/WD deg /6. /6. /6. 1 Length to Fork Face mm 187 190 204 16 Overall Width mm 107 107 107 17 Mast Lowered mm 18 Mast Extended mm 19 Overhead Guard mm 1980 1980 1980 21 Turning Radius (Outside) mm 11 10 167 Distance 22 (Centerline of front axle to front face of forks) mm 30 30 36 Rear Overhang mm 20 240 27 asic Right Angle Stacking Aisle Width 23 (Add load length and clearance) mm 186 1900 2040 24 Travel, Max. Full km/h 1/1 14./14. 14/14 (FWD/RS) No km/h 16./16. 16/16 1./1. 2 Speeds Lifting Full mm/sec 430 390 340 No mm/sec 610 610 00 26 Lowering Full mm/sec 00 00 00 No mm/sec 0 0 00 27 Drawbar Pull * Full / No 3-Minute Ratings N 9400/9000 9400/9000 0/0 -Minute Ratings N 9400/9000 9400/9000 0/0 60-Minute Ratings N 100/000 000/000 4800/100 29 Gradeability * 3-Minute Ratings % (tanθ) 24/21 21/20 19/20 Full / No -Minute Ratings % (tanθ) 24/21 21/20 19/20 30-Minute Ratings % (tanθ) 18/21 16/20 14/20 32 Total Weight attery kg 2010 216 2480 33 Weight Front kg 3680 4070 44 Full Distribution Rear kg 0 20 610 34 ( STD Front kg 1210 118 130 attery) No Rear kg 147 16 180 3 Number Front/Rear 2/2 2/2 2/2 36 Tires Front 18x7-8-14PR (I) 18x7-8-16PR (I) 18x7-8/4.33 Size 37 Rear 16x6-8-10PR (I) 16x6-8-10PR (I) 16x6-8-10PR (I) 38 Wheelbase mm 1310 1310 0 39 Tread Front mm 89 89 89 Rear mm 20 20 20 mm Overhead Guard Clearance mm 102 102 102 Counterweight mm 92 92 92 Step /Floor mm 430/4 430/4 430/4 40 Underclearance Min. <Frame>** (No ) mm 60 60 60 41 Center of Wheelbase (Full ) mm 80 80 80 Grade Clearance Frame % (tanθ) 30 30 27 42 rake Service (Foot) Mechanical Mechanical Mechanical 43 Parking Hand Hand Hand 4 oltage/capacity STD /AH 48/390 48/390 48/390 attery (-hour rating) High /AH 48/6 48/6 48/64 46 Weight (STD Capacity Type) kg 67 67 67 47 Electric Motors Drive kw 4.9x2 4.9x2 4.9x2 48 Handling kw 9.2 9.2 9.2 4 Control Type Drive Transistor inverter Transistor inverter Transistor inverter Handling Transistor inverter Transistor inverter Transistor inverter 7 Operating Pressure For Attachments Mpa (psi) 13.7 (2000) 13.7 (2000) 13.7 (2000) S-FE1-1 - October 2008
DIMENSIONAL DRAWINGS 1 RATED CAPACITIES 1 W 1 107 89 200 100 20 A A: Max. Fork : Center W: Capacity 6. 11 1680 102 1980, S, F Mast Unit: kg (W) A (mm) 300 400 000 00 100 100 100 130 120 600 1340 1340 1340 1210 1120 700 1210 1210 1210 1090 1010 (mm) 800 1110 1110 1110 900 1020 1020 1020 80 940 940 940 80 790 FS Mast Unit: kg (W) A (mm) 4700 000 00 6000 00 100 0 130 1200 900 700 600 130 1260 1210 1080 810 630 700 1220 1 1100 980 730 70 (mm) 800 1120 100 1010 900 670 20 900 1030 970 930 830 620 480 960 900 860 770 80 40 14 30% 92 3 30 1310 20 187 18x7-8-14PR (I) 16x6-8-10PR (I) UNDERCLEARANCE Mast (Full )------------------------------ 7 Drive Axle (Full )----------------------- 90 Center of Wheelbase (Full ) -------- 80 Counterweight (No ) ------------------ 8 SPECIAL MAST Wide isible Mast (, S), Wide isible Full-Free Lift Two-Stage Mast (F), Wide isible Full-Free Lift Three-Stage Mast (FS) 1 Type of Mast, S F FS PERFORMANCE Power Mode H P S H P S H P S Speeds Lifting Full mm/sec 430 30 280 400 330 270 400 330 270 No mm/sec 610 40 480 60 490 430 60 490 430 Lowering Full mm/sec 00 00 00 480 480 480 480 480 480 No mm/sec 0 0 0 420 420 420 40 40 40 DIMENSIONS Distance (Centerline of front axle to front face of forks) mm 30 30 390 NOTE: H High power mode. P Power mode. S mode. S-FE1-2A -6 September 2008
DIMENSIONAL DRAWINGS 18 RATED CAPACITIES 18 W 18 107 89 200 100 20 A A: Max. Fork : Center W: Capacity 6. 10 169 102 1980, S, F Mast FS Mast Unit: kg (W) A (mm) 300 400 000 00 170 170 1700 10 1300 600 170 170 120 1390 1160 700 1420 1420 1380 1260 100 (mm) 800 1290 1290 1260 110 960 900 1190 1190 1160 100 880 1100 1100 1070 980 820 Unit: kg (W) A (mm) 4700 000 00 6000 00 1600 10 0 1300 90 70 600 1440 1390 1260 1170 80 670 700 1310 1270 1 1060 780 610 (mm) 800 1200 1160 100 970 710 60 900 1100 1070 970 900 660 20 1020 990 900 830 610 480 14 30% 92 3 30 1310 240 190 18x7-8-16PR (I) 16x6-8-10PR (I) UNDERCLEARANCE Mast (Full )------------------------------ 7 Drive Axle (Full )----------------------- 90 Center of Wheelbase (Full ) -------- 80 Counterweight (No ) ------------------ 8 SPECIAL MAST Wide isible Mast (, S), Wide isible Full-Free Lift Two-Stage Mast (F), Wide isible Full-Free Lift Three-Stage Mast (FS) 18 Type of Mast, S F FS PERFORMANCE Power Mode H P S H P S H P S Speeds Lifting Full mm/sec 390 320 20 380 310 240 380 310 240 No mm/sec 610 40 480 60 490 430 60 490 430 Lowering Full mm/sec 00 00 00 480 480 480 480 480 480 No mm/sec 0 0 0 420 420 420 40 40 40 DIMENSIONS Distance (Centerline of front axle to front face of forks) mm 30 30 390 NOTE: H High power mode. P Power mode. S mode. S-FE1-2 -7 September 2008
DIMENSIONAL DRAWINGS RATED CAPACITIES W 20 107 1020 6. Mast FS Mast A: Max. Fork : Center W: Capacity Unit: kg (W) Unit: kg (W) 102 92 89 240 120 167 1790 1980 A (mm) 400 000 00 2000 180 1600 600 1790 1660 1430 700 1630 100 1300 (mm) 800 1490 1370 1190 900 1370 1270 1090 1270 1170 1010 A A (mm) 4700 000 00 6000 00 2000 190 180 1700 100 120 900 600 1800 1760 1670 130 130 1130 810 700 1640 1600 120 1390 1230 1020 740 (mm) 800 100 1460 1390 1280 1130 940 680 900 1390 130 1280 1180 1040 870 620 1290 1260 1190 1100 970 810 80 12 27% 38 36 0 27 204 18x7-8 /4.33 16x6-8-10PR (I) UNDERCLEARANCE Mast (Full )------------------------------ 7 Drive Axle (Full )----------------------- 90 Center of Wheelbase (Full ) -------- 80 Counterweight (No ) ------------------ 8 SPECIAL MAST Wide isible Mast (), Wide isible Full-Free Lift Three-Stage Mast (FS) Type of Mast FS PERFORMANCE Power Mode H P S H P S Speeds Lifting Full mm/sec 340 280 220 320 270 210 No mm/sec 00 40 400 470 420 Lowering Full mm/sec 00 00 00 480 480 480 No mm/sec 00 00 00 40 40 40 DIMENSIONS Distance (Centerline of front axle to front face of forks) mm 36 41 NOTE: H High power mode. P Power mode. S mode. S-FE1-2C -8 September 2008
MAST SPECIFICATIONS & RATED CAPACITIES Wide isible Mast (), Wide isible Mast (S), Wide isible Full-Free Lift Two-Stage Mast (F), Wide isible Full-Free Lift Three-Stage Mast (FS) 1 Mast Type S F FS Maximum Fork Lowered NOTE: of standard load backrest is mm. * with A4 piping, plus 8 mm. ** with A4 piping, minus 70 mm. ( ) for Windshield s. Overall Extended Free Lift Tilt Range Capacity at 00 mm LC FWD WD mm mm mm mm mm mm deg deg kg 200 300 400 000 300 200 300 400 4700 000 00 6000 270 2820 3070 270 1770 1870 2040 270 30* 32* 3* 38* 40* 42* 4* 0* * 368 398 418 3100 0 3900 4100 4600 427 47 487 07 27 7 607 67 420 220 420 620 6420 6 14 14 14 14 14 14 14 14 14 36 36 36 11** 12** ** 1** 16** 181** 200** 122 132 142 149 17 167 183 202 14 14 14 14 14 14 14 14 14 36 36 36 83 93 108 123 133 149 168 88 98 108 11 123 133 149 168 6. 6. () 6. () 6. () 6. () 6. () 6. () 6. () 6. () 6. () 6. () 6. 6. () 6. () 6. () 6. () 6. () 6. 6. 6. () 6. () 6. () 6. () 6. () 6. () 100 100 100 100 100 100 100 130 120 100 100 100 100 100 100 100 100 100 100 100 0 0 130 130 1200 900 700 1.18 18 Mast Type S F FS Maximum Fork Lowered Overall Extended Free Lift Tilt Range Capacity at 00 mm LC FWD WD mm mm mm mm mm mm deg deg kg 200 300 400 000 300 200 300 400 4700 000 00 6000 270 2820 3070 270 1770 1870 2040 270 3160* 3* 3660* 3960* 4160* 4* 4660* 160* 660* 368 398 418 3100 0 3900 4100 4600 427 47 487 07 27 7 607 67 NOTE: of standard load backrest is mm. * with A4 piping, minus 20 mm. ** with A4 piping, minus 70 mm. ( ) for Windshield s. 420 220 420 620 6420 6 14 14 14 14 14 14 14 14 14 36 36 36 11** 12** ** 1** 16** 181** 200** 122 132 142 149 17 167 183 202 14 14 14 14 14 14 14 14 14 36 36 36 83 93 108 123 133 149 168 88 98 108 11 123 133 149 168 6. 6. () 6. () 6. () 6. () 6. () 6. () 6. () 6. () 6. () 6. () 6. 6. () 6. () 6. () 6. () 6. () 6. 6. 6. () 6. () 6. () 6. () 6. () 6. () 170 170 170 170 170 170 1700 10 1300 170 170 170 170 170 170 170 170 170 1700 1600 1600 10 0 0 1300 90 70 S-FE1-3A -9 October 2002
MAST SPECIFICATIONS & RATED CAPACITIES Wide isible Mast (), Wide isible Full-Free Lift Three-Stage Mast (FS) Mast Type FS Maximum Fork Lowered NOTE: of standard load backrest is mm. ( ) for Windshield s. Overall Extended Free Lift Tilt Range Capacity at 00 mm LC FWD WD mm mm mm mm mm mm deg deg kg 200 300 400 000 400 4700 000 00 6000 270 2820 3070 1770 1870 2040 270 320 340 370 400 420 440 470 20 70 438 468 498 18 38 68 618 668 420 220 420 620 6420 6 12 12 12 12 12 12 12 12 12 1120 1220 1320 1390 1470 170 1730 1 12 12 12 12 12 12 12 12 12 88 98 108 11 123 133 149 168 6. 6. () 6. () 6. () 6. () 6. () 6. () 6. () 6. 6. 6. () 6. () 6. () 6. () 6. () 6. () 2000 2000 2000 2000 2000 2000 2000 180 1600 2000 190 180 1700 1700 100 120 900 S-FE1-3 -10 January 2003
10.13.1.18.20 STANDARD EQUIPMENT 10.13.1.18.20 Wide isible Mast () [MFH: mm] backrest (, S and FS masts) [: mm] Operator Presence Sensing System (OPS) Easy-down system ( and S masts) Power select function Power keep function ORS seat Memory tilt steering column Dual-action parking brake Full hydraulic power steering Electric horn attery hood damper Floor mat Overhead guard Drawbar pin Digital multifunction display (attery capacity indicator, Speedometer, 2-speed travel speed control setting indicator, Parking brake indicator, Power select function indicator, Overcharge indicator, OPS indicator, Power select function, Traveling power control, handling power control, 2-speed travel speed control, Key switch ON hour meter, Calender & clock, attery overdischarge warning (Lift interrupt), attery remaining-charge warning, attery electrolyte level warning, Overheat warning, Low temperature warning indicator, Parking brake off alarm, Parking brake on alarm, Return-to-neutral warning, Diagnostic digital indicator) SAS ( Active Mast Function Controller and Active Steering Synchronizer) INDEX: Available OPTIONS AAILAILITY CHART Item LOAD HANDLING Wide isible Mast (S) M00C Full-free Lift 2-stage Mast (F) w. M00F w/o M00F Full-free Lift 3-stage Mast (FS) w. M00D Fully Oil Charged Lift Cylinder M09A Long Forks M20A w/o Fork Set M20N Long Forkbar M30A High (Flat Steel Type) M33A Tilt Cylinder oots K11A Mast Tilt Indicator N14A ATTERY AND CONTROLLER attery D00 Spare attery (Wet Cell) D20A Spare attery (Dry Cell) D20J attery Case D80 attery Roll-out D6A attery Charger On Truck Type C30E Off Truck Type 1) C30L/M attery Connector Cable DA attery Code Adapter D8A Single Overall Electrolyte Filler Ports D40A LIGHT AND INDICATORS Headlights J24A Front Combination Lights 2) J20 Rear Combination Lights 3) J21A Rear Working Light J26A Yellow eacon On The Overhead Guard J19A ack-up uzzer K21D Adjustable-volume ack-up uzzer K21H Forward Chime K21 ack-up Chime K21C Digital multifunction display (All-round type) L09 ODY Rear-view Mirror, Right and Left Sides J10 Suspension Seat w/ Damper G40E Overhead Guard Sheet H01 Front Windshield w/ Wiper 4) H02H Name Plate ) S31A Static Strap 6) K64A S.A.S. Equipped Decal S28A OPS Decal S3A CHASSIS Wide rake Pedal E32C WHEELS AND TIRES Pneumatic Tire Pneumatic-Shaped Cushion Tire Code 10 13 NOTE: 1) Must specify D8A. 2) Front combination lights are composed of turn signal lights and clearance lights (Headlights are not included). 3) Rear combination lights are composed of turn signal lights, stop lights, tail lights and back up light. 4) Not available on and F mast at a maximum fork height 200 and mm. Not available on FS mast at a maximum fork height and mm. ) Available for English, Spanish, Chinese, French, Russian, Taiwanese, Portuguese, and Lithuanian. 6) When selecting Color Tire (Green, White), K64A is equipped as standard (Not necessary to specfy). Please see the Matching Options. Please see the chart below for the item. 1 18 20 S-FE1-4A -11 January 2009
OPTIONS AAILAILITY CHART Item SPECIAL MODELS E.E.C. Spec. 6) A10A China Certification Spec. A10R E Mark (for EC) 6) A13A Australian Spec. A20 Cold-Storage (Type 4S) 7) 30E Rust-Proof (Fisherman Special) 7) 30F Rust-Proof 8) 30H NOTE: 6) Must specify for Israel and Lithuania. 7) Includes 30H (Not necessary to specify). 8) Includes K11A and M09A (Not necessary to specify). Please see the Matching Options. Please see the chart below for the item. Code 10 13 1 18 20 10.13.1.18.20 INDEX: Available FULLY OIL CHARGED LIFT CYLINDER 10.13.1.18 Mast Type S F FS FS MAST INTERCHANGEAILITY Mast Type 10.13.1.18 S F FS FS 10.13.1.18 NOTE: Only the same mast type as the originally mounted type on the forklift can be mounted. MAST WEIGHT Mast Type S F FS Maximum Fork 10.13.1.18 mm kg kg 200 300 400 000 300 200 300 400 4700 000 00 6000 300 310 330 380 390 410 460 490 370 400 420 30 390 420 440 40 470 40 60 90 610 630 660 680 70 380 400 430 40 460 490 0 90 660 690 720 70 770 800 830 CAUTION: The figures are without load backrest and forks. The figures presented in this chart have been rounded off to the nearest number. Use caution when applying them to specific products. LONG FORKS Length Width Thickness Long Forks 770 Unit: mm 80 30 10 100 1070 1220 3 * 80 13 100 3 1070 1220 80 1.18 1070 100 3 1220 1370 120 1070 1220 120 38 1370 120 NOTE: * Free Lift and Distance, Plus mm. S-FE1-4 -12 September 2008
LONG FORKAR AND HIGH LOAD ACKREST 10.13.1.18 L 970 1070 1220 1370 120 H W 1020 1170 1320 1470 1070 1220 1370 120 1670 1070 1220 1370 120 1670 W L L: Outside width of load backrest W: Length of forkbar H: of load backrest H 10.13.1.18.20 INDEX: Available ATTERY AAILAILITY NOTE: * KOE only ** GS YUASA only < > Pneumatic-shaped cushion tires must be installed. AAILAILITY OF ATTERY CHARGER Off-Truck Type (GS YUASA) attery oltage On-Truck Type attery Capacity AC Input oltage AC Power Supply Capacity A ka of Charger 10 13 1 18 AH/HR 0Hz 60Hz 0Hz 60Hz 280-312 200 20 20.4 4.7 36-390 200 30 20 7.3 6. 476-6 200 30 30 9.2 8.1 48 64 200 40 40 12.0 11.0 280-312 400 10 10.4 4.7 36-390 400 1 10 7.3 6. 476-6 400 1 1 9.2 8.1 64 400 20 20 12.0 11.0 attery oltage 10.13 48 1.18 48 48 attery Capacity attery AH/HR 280/ 312/ 36/ * 370/ ** 390/ 476/ 6/ 390/ <476/> <6/> <64/> NOTE: 1. The indicated input voltage means the available range of three-phase AC input voltages applied to the battery charger: 200 denotes the range of 200 to 230 and 400 the range of 340 to 460, respectively. 2. In AC power sources where there is appreciable variance between the rated and the measured line voltage values, be sure to measure actual input voltage to a battery charger and then order it with correct power requirements for operation. Usually re-charging is done at night when incoming voltage is relatively high without line voltage drops, and it is a good practice, therefore, to measure the line voltage at night. AC Input oltage AC Power Supply Capacity A ka of Charger 10 13 1 18 AH/HR 0Hz 60Hz 0Hz 60Hz 280-312 200 1 1 4.0 4.2 48 36-390 200 1 1 4. 4.8 476-64 200 30 30 7.1 7.3 NOTE: The indicated input voltage means the available range of three-phase AC input voltages applied to the battery charger: 200 denotes the range of 200 to 230. S-FE1-4C -13 April 2006
10.13.1.18.20 TIRE AAILAILITY 10 13 1 18 Tire Arrangement Front Rear Front Rear Front Rear Front Rear Front Rear Pneumatic Tire Tire Size Rim Size (Type) 18x7-8-10PR (I) 8x4.2DT 1x4.1/2-8-12PR (I) 8x3.00D DT 18x7-8-14PR (I) 8x4.2DT 1x4.1/2-8-12PR (I) 8x3.00D DT 18x7-8-14PR (I) 8x4.2DT 16x6-8-10PR (I) 8x4.2DT 18x7-8-16PR (I) 8x4.33R (Side-Ring) 16x6-8-10PR (I) 8x4.2DT 16x6-8-10PR (I) 8x4.2DT NOTE: * Snow tire is available (Mast height less than mm). ** Color tire is available (Green, White). Pneumatic-Shaped Cushion Tire J-Lug Rib-Lug Tire Size Rim Size (Type) U-Lug** * 18x7-8/4.33 8x4.2DT 1x4.1/2-8/3.00 8x3.00D DT * 18x7-8/4.33 8x4.2DT 1x4.1/2-8/3.00 8x3.00D DT * 18x7-8/4.33 8x4.2DT * 16x6-8/4.33 8x4.2DT * 18x7-8/4.33 8x4.33R T (Side-Ring) * 16x6-8/4.33 8x4.2DT 18x7-8/4.33 8x4.33R T (Side-Ring) 16x6-8/4.33 8x4.2DT J-Lug INDEX: Available MATCHING OPTIONS (Column figures refer to matching with to the items listed at left) Item Code 1 2 3 4 6 7 8 9 10 11 12 13 14 1 16 17 18 19 20 21 22 23 24 2 26 27 28 29 30 31 32 33 34 3 36 E.E.C. Spec. A10A 1 China Certification Spec. A10R 2 X Australian Spec. A20 3 X X Cold-storage (Type 4S) 30E 4 Rust-proof (Fisherman Special) 30F Rust-proof 30H 6 2 2 attery Charger (On ruck Type) C30E 7 X X X attery Charger (Off truck Type) C30L/M 8 X X w/o Charger C30N 9 X X X Spare Charger C37A 10 X Spare attery (Wet Cell) D20A 11 X Spare attery (Dry Cell) D20J 12 X X attery (Wet Cell) D00C 13 X attery (Dry Cell) D00Q 14 X X Single Overall Electrolyte Filler Ports D40A 1 X X X X X X attery Connector Cable DA 16 X attery Code Adapter D8A 17 X Pneumatic Tire 18 Pneumatic-Shaped Cushion Tire 19 X Snow Tire 20 X X Color Tire (Green, White) 21 X X X Front Windshield w/ Wiper H02H 22 Tilt Cylinder oots K11A 23 X X 3 ack-up Chime K21C 24 ack-up uzzer K21D 2 X Adjustable-volume ack-up uzzer K21H 26 X X X Forward Chime K22A 27 X Wide isible Mast () M00 28 Wide isible Mast (S) M00C 29 X Full-free Lift 3-stage Mast (FS) M00D 30 X X Full-free Lift 2-stage Mast (F) M00F 31 X X X Fully Oil Charged Lift Cylinder M09A 32 X X 3 X High (Angle Shape Type) M40A 33 w/o M40N 34 X Name Plate (English) S31A 3 1 Static Strap K64A 36 4 INDEX: Not available. 1. E.E.C. Spec. can be combined with English and Lithuanian. 2. When selecting 30E/F, 30H is equipped as standard. 3. When selecting 30H, K11A and M09A are equipped as standard. 4. When selecting Color Tire (Green, White), K64A is equipped as standard. NOTE: For other matching please consult us. S-FE1-4D -14 January 2009
10.13.1.18.20 SPECIFICATIONS OF ATTERY AND ATTERY CASE The minimum weight of battery with case indicated in the table is the lightest weight of the battery required to satisfy stability requirements of the vehicle in which it is installed. Specifications (GS YUASA) 10 13 ehicle Weight without attery and Case kg 1690 1890 Minimum Weight of attery with Case kg 20 20 attery Connector Type S30A (2 Prong) S30A (2 Prong) Minimum Connector Length * mm 20 20 Truck oltage 48 48 Number of Cells pcs 24 24 Ampere-Hour Capacity AH/HR 280/ 312/ 370/ 280/ 312/ 370/ Total mm 22 2 2 22 2 2 Overall Container Dimensions mm 490 20 20 490 20 20 Specs. Length mm 90 90 90 90 90 90 of Cell Width mm 18 18 18 18 18 18 Weight of Filled Cell Approx. kg 16. 19.0 20.0 16. 19.0 20.0 Quantity of Electrolyte Approx. liter 3.7 4.0 3.8 3.7 4.0 3.8 Weight Total (attery and Case) kg 60 80 60 80 Operating Time 2h4m 3h10m 4h00m 2h40m 3h0m 3h0m NOTE: * The distance from case to the tip of the connector. Dimensions of attery Case 10.13 ATTERY CAPACITY : 280AH/HR, 48 312AH/HR, 48 36AH/HR, 48 Dimensions of attery Compartment 10.13 Width mm 998 Length mm 41 mm 613 φ30 180 44 20 63 48 0 28 200 200 2-φ30 0 8 990 436 S-FE1-4E -1 September 2004
10.13.1.18.20 SPECIFICATIONS OF ATTERY AND ATTERY CASE The minimum weight of battery with case indicated in the table is the lightest weight of the battery required to satisfy stability requirements of the vehicle in which it is installed. Specifications (GS YUASA) 1 18 ehicle Weight without attery and Case kg 2010 216 Minimum Weight of attery with Case kg 6 6 attery Connector Type S30A (2 Prong) S30A (2 Prong) Minimum Connector Length * mm 20 20 Truck oltage 48 48 Number of Cells pcs 24 24 Ampere-Hour Capacity AH/HR 390/ 476/ 6/ 390/ 476/ 6/ Total mm 22 2 2 22 2 2 Overall Container Dimensions mm 490 20 20 490 20 20 Specs. Length mm 109 128 128 109 128 128 of Cell Width mm 18 18 18 18 18 18 Weight of Filled Cell Approx. kg 23.0 26.0 30. 23.0 26.0 30. Quantity of Electrolyte Approx. liter 4..9.4 4..9.4 Weight Total (attery and Case) kg 70 730 820 70 730 820 Operating Time 3h0m 4hm 6h00m 3h30m 4h3m h40m NOTE: * The distance from case to the tip of the connector. Dimensions of attery Case 1.18 ATTERY CAPACITY : 390AH/HR, 48 476AH/HR, 48 6AH/HR, 48 Dimensions of attery Compartment NOTE: ( ) for attery Roll-Out Type. 1.18 Width mm 998 (994) Length mm 1 (1) mm 613 (92) φ30 4 180 20 63 48 0 28 200 200 2-φ30 0 8 990 36 S-FE1-4F -16 September 2004
10.13.1.18.20 SPECIFICATIONS OF ATTERY AND ATTERY CASE The minimum weight of battery with case indicated in the table is the lightest weight of the battery required to satisfy stability requirements of the vehicle in which it is installed. Specifications (GS YUASA) ehicle Weight without attery and Case kg 2480 Minimum Weight of attery with Case kg 6 attery Connector Type S30A (2 Prong) Minimum Connector Length * mm 20 Truck oltage 48 Number of Cells pcs 24 Ampere-Hour Capacity AH/HR 390/ 476/ 6/ 64/ Total mm 22 2 2 0 Overall Container Dimensions mm 490 20 20 19 Specs. Length mm 109 128 128 148 of Cell Width mm 18 18 18 18 Weight of Filled Cell Approx. kg 23.0 26.0 30. 36. Quantity of Electrolyte Approx. liter 4..9.4 6.8 Weight Total (attery and Case) kg 700 74 83 978 Operating Time 3h2m 4h30m h30m 6h2m NOTE: * The distance from case to the tip of the connector. Dimensions of attery Case ATTERY CAPACITY : 390AH/HR, 48 476AH/HR, 48 6AH/HR, 48 64AH/HR, 48 Dimensions of attery Compartment Width mm 998 Length mm 638 mm 613 φ30 632 180 20 63 48 0 200 200 28 2-φ30 0 8 990 623 S-FE1-4G -17 September 2004