CUTWATER 26/28 OWNERS ANUAL
TABLE OF CONTENTS Table Of Contents... 2 Congratulations... 3 Safety... 3 Symbol Glossary... 4 Specifications (Subject To Change Without Notice)... 5 Equipment Location... 6 Starboard Fittings... 6 Port Fittings... 7 ain Cabin Top Deck Components... 8 Stern Components... 9 Fuse Location & Values... 10 ain Cabin And Cockpit... 12 Battery Compartment... 13 Power Distribution Center... 14 AC Distribution Panel, Rotary Switch & DV Volt eter... 15 Fuel System, Engine, Generator & Webasto Furnace... 16 Webasto Furnace... 17 Air Conditioning System... 18 Generator... 19 Solar Panel... 20 Shore Power... 21 Closed Engine Cooling System... 22 Sea Strainer System... 23 Raw Water Wash Down... 24 Fresh Water Plumbing System... 25 Shower Sump... 26 Bilge Pump System... 27 Waste System... 28 ast Set Up And Takedown... 29 Cutwater 28 Wiring Schematic (Acc. 1)... 30 Cutwater 28 Wiring Schematic (Acc. 2)... 31 Cutwater 28 Wiring Schematic (Acc. 3)... 32 Cutwater 28 Wiring Schematic (Lighting)... 33 Cutwater 28 Wiring Schematic (P.D.P.)... 34 Cutwater 26 Wiring Schematic (Acc. 1)... 35 Cutwater 26 Wiring Schematic (Acc. 2)... 36 Cutwater 26 Wiring Schematic (Acc. 3)... 37 Cutwater 26 Wiring Schematic (Lighting)... 38 Cutwater 26 Wiring Schematic (P.D.P.)... 39 Working Deck... 40 Care And aintenance... 41 Example Of A Preparation For The Road Checklist... 41 Example Of A Spring Pre-Launch Checklist... 42 Example Of Winter Storage Checklist... 43 Reference aterial... 44 Contacts... 45 2
CONGRATULATIONS The Cutwater family has a passion for boating. We are committed to continuous process improvement in all areas that affect our customer s satisfaction with our products and providing great customer service. SAFETY Safety is always a concern at Cutwater. Please read all manuals to insure that equipment is used in a safe manner. We highly recommend attendance in a Coast Guard approved boating safety course. Such courses are available from the Coast Guard directly or from boating organizations. Owners should have annual inspections to ensure that all safety equipment is current. 3
SYBOL GLOSSARY Attention! Important Operating or aintenance Instructions Attention! Electrical Shock Hazard Fresh Water Black Water Fuel STD Standard Equipment OPT Optional Equipment Hints 4
SPECIFICATIONS C28 LOA molded...28 4 8.63 m LOA rigged (with swim & pulpit)...32 4 9.85 m LOA including trailer...37 5 11.4 m Height on trailer (with folded mast)...12 9 3.9 m Bridge clearance (with folded mast)...9 1 2.76 m Beam...8 6 2.59 m Draft...28.71 m Fuel capacity...100 U.S. Gal 378.5 L Water capacity...40 U.S. Gal 151.4 L Holding tank capacity...30 U.S. Gal 113.6 L Weight (Dry)...8,000 lbs 3,629 kg Engine...Volvo D4 260 HP Diesel C26 LOA molded...26 1 7.95 m LOA rigged (with swim & pulpit)...30 4 9.25 m LOA including trailer...35 5 10.8 m Height on trailer (with folded mast)...12 9 3.9 m Bridge clearance (with folded mast)...9 1 2.76 m Beam...8 6 2.59 m Draft...28.71 m Fuel capacity...80 U.S. Gal 302.8 L Water capacity...40 U.S. Gal 151.4 L Holding tank capacity...30 U.S. Gal 113.6 L Weight (Dry)...6,750 lbs 3,062 kg Engine...Volvo D3 220 HP Diesel (Subject to Change Without Notice) 5
EQUIPENT LOCATION STARBOARD FITTINGS 1 2 3 4 5 6 (C28 only) 7 8 9 Keep all vents, drains and exhausts clear of any obstructions to ensure proper performance of each system. ➊ ➌ ➋ ➍ ➎ ➏ ➐ ➒ ➑ ➊ Diesel Fill ➋ Fresh Water Fill ➌ Fuel Vent ➍ Water Vent ➎ Docking ➏ Aft Sink Drain (C28 only) ➐ Head Sink Drain ➑ Keel Drain Plug ➒ Bow Thruster 6
1 2 3 4 5 6 10 11 12 13 14 7 8 9 Keep all vents, drains and exhausts clear of any obstructions to ensure proper performance of each system. ➊ ➍ 13 ➋ ➌ ➎➏➐ ➑➒➓ 11 12 14 ➊ Docking ➋ Waste Pumpout ➌ Waste Vent ➍ Anchor Locker Drain ➎ Shower Sump ➏ Air Conditioner Drain ➐ Cabin Sink Drain ➑ Generator Exhaust ➒ Forward Bilge Drain ➓ Aft Bilge Drain 11 12 13 14 acerator Forward Sink Drain Bow Thruster Engine Exhaust 7
AIN CABIN TOP DECK COPONENTS 1 2 3 6 4 5 ➌ ➎ ➏ ➍ ➊ ➋ ➐ ➊ Searchlight ➋ Horn ➌ Digital TV Antennae (satellite ready - not included) ➍ Radar ➎ GPS ➏ Anchor Light ➐ Port Navigation Light 8
STERN COPONENTS 1 2 3 4 5 7 8 9 10 11 12 6 ➌ ➌ ➊➋ ➋➊ ➍ ➍ ➒ ➎ ➎ ➏ ➓ ➑ 11 ➓ ➏ ➐ 12 ➊ Brake ➋ Backup ➌ Running ➍ Courtesy ➎ Cockpit Drains ➏ Underwater ➐ Prop Zinc ➑ Stern Thruster ➒ Swim Platform Retractable Ladder ➓ Trim Tabs 11 12 Prop Rudder 9
FUSE LOCATION & VALUES The dash fuse blocks are located behind the hinged mirror located inside of the bathroom. Fuses are automotive blade type and all values are shown in amps. Dash Fuse Block #1 Dash Fuse Block #2 10
FUSE LOCATIONS AND VALUES CONTINUED These five blocks and fuses are located behind the carpeted panel that is removable on the aft wall just below the Power Distribution Panel. The bilge pumps operate automatically with electronic float switches when all switches and breakers are in the OFF position. However, the BILGE PUP and BILGE PUP2 will run continuously once their switches are placed in the on position. onitor the outflow accordingly. Do not run when dry. Stern Thruster Fuse Bow Thruster Fuse House Breaker 11
AIN CABIN AND COCKPIT LIGHTS ➊ Courtesy ➋ Deck Aft ➌ Chart ➍ Cabin ➎ V-Berth ➏ V-Berth Bed ➐ Head Light Courtesy Light Switch V-Berth Light Switch Cabin Light Switch Head Light Switch Chart Light Switch ➎ ➏ Switch ➍ ➊ ➊ ➊ ➊ ➊ ➊ ➋ ➋ ➌ ➍ ➌ ➍ ➌ ➍ ➋ ➍ ➍ ➌ ➏➎ ➎ ➎ ➐ ➐ ➎ ➏ ➏ ➊ Switch ➋ ➍ Switch ➌ Switch ➐ Switch 12
BATTERY COPARTENT House Batteries, Engine Battery, Thruster Battery, Inverter/Charger, Engine EC, Inverter Fuse (150 AP), Inverter/Charger Cutoff Switch Inverter 2 3 1 1 Non-Generator Inverter Switch Inverter Fuse Charging Relays Batteries 1 = House 2 = Engine 3 = Thruster 2 3 Generator Charging Relays Inverter Fuse Inverter Switch 1 1 Inverter Charger 13
POWER DISTRIBUTION CENTER Located under aft dinette seat. House, Engine, Thruster crossover switch Generator Panel, Solar Display, Diesel Heater Control, Air Conditioning Display The crossover switch should always remain in the off position. While in the on position, the house and engine batteries will be combined as one. SOLAR GENERATOR INVERTER DIESEL HEAT AIR CON CONTROL 14
AC DISTRIBUTION PANEL, ROTARY SWITCH & DC VOLT ETER AC Distribution Panel AC Rotary Selector Switch. Available with Generator The AC Rotary Switch Selector Switch will determine which source of incoming 120 Volt power to use for your AC Distribution Panel. 12V BATTERY ONITOR AC VOLTS DC VOLTS 1 = House 2 = Engine 3 = Thruster 30A AC AIN REVERSE POLARITY STBD OUTLETS PORT OUTLETS WATER HEATER BATTERY CHARGER STOVE ACCESSORY ICROWAVE ACCESSORY 25A AIR CONDI- TIONER ACCESSORY 15
FUEL SYSTE, ENGINE, GENERATOR & WEBASTO FURNACE C28 Volvo D4 260 H.P. Diesel C26 Volvo D3 220 HP Diesel Generator 2.7 KW ase, Webasto Furnace There is a secondary on engine fuel filter that is not shown on this drawing. You will be able to find information about this filter in the diesel engine manual supplied with your boat. Fuel shutoff and all fuel fittings are located inside the floor hatch as you enter the main cabin. Engine P/V Generator P/ V (opt.) Webasto P/V Engine return Generator return (opt.) Vent Fill Fuel shut off valve Primary fuel filter Engine 16
WEBASTO FURNACE Webasto furnace & pump are located behind an access panel in the quarter berth. The controller is located at the power distribution panel. Heat Vent Heat Vent Fuel Pump / Filter Webasto Furnace Exhaust 17
AIR CONDITIONING SYSTE Air Conditioning System Shower Sump Box 120 Volt Control Box Raw Water Discharge Air Conditioner (Accessed from mid cabin) Condensate Drain Air Conditioner Pump Air Conditioner Sea Strainer Air Conditioner Dislpay (See page 14 for location) Air Conditioner Thru-Hull 18
GENERATOR Generator 2.7 KW ase *Generator will start off of thruster battery #3 Generator Fuel Pickup (shut off valve at tank) Generator Fuel Return Generator Exhaust Generator Fuel Filter Silencer Water Lock 19
SOLAR PANEL Solar panel 140 watt, with control panel The solar panel is designed to provide charging to the house & engine batteries. 90% of its charge is dedicated to the house battery and 10% is dedicated to the engine battery. The green light on the solar display indicates proper operation. The solar controller is located behind the Velcro access panel inside the mid cabin at the aft bulkhead. * House battery location shown with generator option equipped. Solar Panel Solar Controller Engine Battery (10% Charge) + - 3 1 + 2-1 House Battery (90% Charge) 20
SHORE POWER LAYOUT Shore Power ELCI Breaker (Located un access hatch underneath stove/oven) AC Panel Rotary Switch Inverter + - Shore Plug 21
CLOSED ENGINE COOLING SYSTE Provides alternate heating system for the Fresh Water Heater and provides primary heating source for the Forced Air Cabin Heater. This system is also designed to provide cooling to the internal components of your engine. Please refer to your engine operations manual for more information. C26 C28 Cabin Heater Cabin Heater Shut Off Valves Engine Hot Water Heater Engine Hot Water Heater Shut Off Valve Shut Off Valve 22
SEA STRAINER SYSTE ulti Port Sea Strainer for Engine, arine Toilet and Raw Water Washdown C26 C28 Head Head Engine Engine Raw water washdown Raw water washdown 23
RAW WATER WASH DOWN Johnson Aqua Jet 5.2 GP The raw water washdown pump and all components shown are accessible from the rear of the engine compartment. 24
FRESH WATER PLUBING SYSTE 40 Gallon Fresh Water Tank, 6 Gallon Hot Water Heater, 4.0 GP Fresh Water Pump. Breakfast nook cold (C28 only) Head sink cold Head sink hot Galley sink hot Galley sink cold Tank Fresh water fill Fresh water vent Fresh water pump Hot Water Heater Cockpit sink cold (C28 only) Cockpit sink hot (C28 only) 25
SHOWER SUP 12V, 500 GPH (Sump should be inspected for debris on a regular basis if shower is used frequently.) The shower sump box is located underneath the teak and holly floor. Shower Sump 26
BILGE PUP SYSTE 12V 750GPH The bilge pumps operate automatically with electronic float switches when all switches and breakers are in the OFF position. However, the BILGE PUP and BILGE PUP2 will run continuously once their switches are placed in the on position. onitor the outflow accordingly. Do not run when dry. 2 High Bilge Alarm Forward Bilge Pump One Way Check Valve 1 Aft Bilge Pump 27
WASTE SYSTE WITH ACERATOR PUP 30 Gallon Tank with acerator Pump Out, Standard Pump Out, and Vent Waste tank fill level can be checked by lifting the engine access hatch and viewing the translucent waste tank. Pump out can be done with the macerator or standard pump out. The Y-Valve that switches between the two can be accessed through the Engine Hatch, aft of the engine. Waste tank pump out stations are widely available. Please follow the directions carefully for the pump out equipment you are using to avoid damage to the waste system. Boat owner is responsible for following all applicable laws when using the macerator system to pump out into the surrounding waters. acerator out (optional) Waste tank vent Pump out Waste Tank acerator Y valve Check valve Sea strainer arine Head Blackwater hose to tank Clamps from soft hose to ABS Clamps from soft hose to ABS 28
AST SET UP AND TAKEDOWN AST SET UP PROCEDURE 1. Remove the two black plastic wing nuts from the mast base. 2. While supporting the mast, remove the pin in the support bar. 3. Raise the mast to its full extension and ensure that it fits correctly over the mounting studs on the roof mounting plate. 4. Secure the stainless steel retaining bar in the appropriate clip attached next to the v-berth escape hatch. 5. Attach the two black plastic wing nuts to the mounting studs and hand tighten securely. AST TAKE DOWN PROCEDURE 1. Remove the two black plastic wing nuts from the mast base mounting studs. 2. Carefully lower the mast onto the stainless steel support bar and attach retaining pin. 3. Attach the black plastic wing nuts back onto the screws on the mast mounting plate and secure them for storage by hand tightening. 4. Recommend securing the mast with a tie down. 29
CUTWATER 28 WIRING SCHEATIC (ACC. 1) +12V GND Helm Fuse Blocks #1 Buss (Helm) Sub Panel 8 Switch Horn Chart Nav. acerator Pump 30A 30A 10A 20A ELECTRICAL SCHEATIC ORG/WHT 16 + - BRN 10 To Lighting Schematic To Lighting Schematic acerator YEL 10 Bilge Pump 1 5A RED/BRN 16 To Acc. 3 Schematic Bilge Pump 2 5A PUR/BRN 16 To Acc. 3 Schematic V-Berth Sub Panel 4 Switch 12V Outlet Dinette Wiper Wiper Defrost Fans 30A 10A 10A RED 16 (ss) RED 16 (sf) off RED 16 (ps) off 10A Wiper Park BLU/BLU 16 To Lighting Schematic PUR/WHT 16 RED 16 (pf) Dock To Lighting Schematic Spare Spare 20A ORG/WHT 10 YEL 10 12V T.V.#1 7.5A PUR/GRY 16 T.V. - see FR Schematic Head 25A RED/BLK 10 Head - see FR Schematic YEL 10 SYBOL KEY Breaker Speaker Light Outlet Unit otor Prompt to Switch DPST On-On Horn + - Switch DPDT On-Off-On 12V Float Switch Description of unit Switch SPST Off-On Switch SPST Off-(On) Level Sensor A B C Fuse 30
CUTWATER 28 WIRING SCHEATIC (ACC. 2) +12V Fuse Block #2 (Helm) ELECTRICAL SCHEATIC GRD Buss (Helm) Refrigerator ORG/PUR 10 YEL 10 Refrigerator - see FR Schematic Wine Cooler 10A ORG/BLU 16 Wine Cooler - see FR Schematic Heater Trim Tabs ORG/GRY 16 Heater - see FR Schematic RED 16 ORG 16 OFF 20A ORG/PNK 16 Trim Tab - see FR Schematic VHF 7.5A RED 16 VHF Radio - see FR Schematic Stereo Stereo emory 3A RED/WHT 16 Stereo Deck - see FR Schematic To House Battery WHT/ arine Head To Lighting Schematic LF RF LR RR 12V Outlet Helm 20A ORG/WHT 10 12V YEL 10 12V Outlet V-Berth 20A ORG/WHT 10 YEL 10 12V Wine Cooler 10A ORG/BLU 16 Wine Cooler - see FR Schematic S.P. Shower Pump 5A BRN 16 Charger To A.C. Panel Charger - see FR Schematic YELLOW 10 YELLOW 8 To House Battery To Aft. Ground Buss To House Battery To Engine Battery To Thruster Battery 30A 30A 30A 31
CUTWATER 28 WIRING SCHEATIC (ACC. 3) +12V P.D.P. Fuse Block Downrigger (port) Downrigger (star) 1/4 Berth 12V Outlet 40A 40A 20A Cutwater C-28 Accessories 3 RED/WHT 10 RED/WHT 10 RED/PUR 10 12V ELECTRICAL SCHEATIC Downrigger Downrigger GRD Buss (Aft) YEL 10 YEL 10 YEL 10 Webasto Heater 20A ORG/PNK 10 Webasto - see FR Schematic YEL 10 Auto Pilot Pump Sub Panel 3 Switch Water Gauge Cabin Water Pressure isc. Wash Down 40A Underwater 20A 10A 10A 20A +12V Fuse Block (Thruster Batt.) Bilge 5A Pump 1 Deck BRN/BLK 10 ORG/RED 16 To Lighting Schematic BRN/YEL 10 To Lighting Schematic To Acc. 1 Schematic BRN/RED 16 Auto Pilot - see FR Schematic To Lighting Schematic To Lighting Schematic Water Gauge BRN/YEL 10 ORG 16 Bilge Pump To Lighting Schematic A B C Water Pump Blge Pump WashDown YEL 10 YEL 10 BRN/GRN 16 GRN/BRN 16 To Acc. 1 Schematic Bilge Pump 2 5A BRN/BLU 16 C.O. onitor 3A RED/BLK 16 C.O. onitor - see FR Schematic Bilge Alarm 3A 3A Voltmeter +12V Fuse Block (House Batt.) 3A Voltmeter WHT/BLK 16 RED/GRN 16 RED/PUR 16 Voltmeter Bilge Alarm - see FR Schematic BRN/WHT 16 WHT/BRN 16 RED/BLU 16 3A To Engine Battery A B C Stove Switch (LPG) 1A ORG/BLK 16 Stove - see FR Schematic WHT/ORG 16 To Propane Sensor To Propane Sensor 32
CUTWATER 28 WIRING SCHEATIC (LIGHTING) Cutwater C-28 Lighting +12V GND Dash Fuse Block #1 ELECTRICAL SCHEATIC Buss (Helm) Sub Panel 8 Switch 30A Chart Horn acerator Pump 10A BLU/ To Acc. 1 Schematic To Acc. 1 Schematic Nav/Inst 10A Spot Light Remote - see FR Schematic GRY/RED 16 AC-DC Panel - see FR Schematic Water Gauge - see FR Schematic GRY/BLK 16 Anchor Volt eter Compass ELCI Panel Sub Panel 4 Switch Defrost Fans 30A Dock PUR/WHT 16 To Acc. 1 Schematic Spare Spare 10A BLU/PINK 16 V-Berth 10A WHT/BLU 16 BLU/WHT 16 V-Berth (port side) BLU/ORG 16 +12V P.D.P. Fuse Block arine Head Sub Panel 3 Switch Porch (Dog House) To Acc. 2 Schematic Under Water 20A Deck 10A GREY/BLU 16 Spare 10A BLU/BLK 16 Buss (Aft) 10A BLU/PUR 16 10A PUR/ PUR/ Cabin BLU/RED 16 GND Spot Light ics. 10A ORANGE 16 Spot Light - see FR Schematic 10A BLU/BRN 16 BLU/BRN 16 33
CUTWATER 28 WIRING SCHEATIC (P.D.P.) Cutwater C-28 Power Distribution Fuse #1 Block. Fuse #2 Block. Wendlass Breaker. 6 red 6 red 6 red Helm To A.C. panel. 2 red 100A P.D.P. Fuse Block. 1/4 Berth HOUSE 2 red 1 red 1 red 6 red ELECTRICAL SCHEATIC SWITCH 1 red To generator control panel. GENERATOR To A.C. panel. PARALLEL SWITCH 1 red - + 6 red - INVERTER See Inverter schematics for wire sizes and fuse size. 2 yellow 1 yellow + Thruster Thruster Engine Battery Fuse Block. Thruster Battery Fuse Block. See thruster schematic for fuse sizes. 1 red 1 red 1 red GRD BUSS 1 red 1/4 Berth INVERTER 1 red 175A 1 red Aft SWITCH ENGINE 1 red SWITCH 6 red 6 red THRUSTER 1/O red SWITCH 1 red 2 yellow 1 yellow 1 red 1/O red Refer to Engine Schematic for wire size 6 yellow + ALTERNATOR To engine schematic. + STARTER Helm To engine schematic. Fuse Block #2 Wendlass CHARGE RELAY CHARGE RELAY 1 red 1 red 1 red 1 red 1 yellow 1 yellow 1 yellow Thruster Thruster 1 red 1 yellow 1 yellow 1 yellow Engine 3 2 1 THRUSTERS ENGINE. HOUSE 1 HOUSE 34
CUTWATER 26 WIRING SCHEATIC (ACC. 1) +12V GND Helm Fuse Blocks #1 Buss (Helm) Sub Panel 8 Switch Horn Chart Nav. acerator Pump 30A 30A 10A 20A ELECTRICAL SCHEATIC ORG/WHT 16 + - BRN 10 To Lighting Schematic To Lighting Schematic acerator YEL 10 Bilge Pump 1 5A RED/BRN 16 To Acc. 3 Schematic Bilge Pump 2 5A PUR/BRN 16 To Acc. 3 Schematic V-Berth Sub Panel 4 Switch 12V Outlet Dinette Wiper Wiper Defrost Fans 30A Dock 10A 10A RED 16 (ss) RED 16 (sf) off RED 16 (ps) off 10A Wiper Park BLU/BLU 16 To Lighting Schematic PUR/WHT 16 Spare RED 16 (pf) Spare 20A ORG/WHT 10 YEL 10 12V To Lighting Schematic T.V.#1 7.5A PUR/GRY 16 T.V. - see FR Schematic Head 25A RED/BLK 10 Head - see FR Schematic YEL 10 SYBOL KEY Breaker Speaker Light Outlet Unit otor Prompt to Switch DPST On-On Horn + - Switch DPDT On-Off-On 12V Float Switch Description of unit Switch SPST Off-On Switch SPST Off-(On) Level Sensor A B C Fuse 35
CUTWATER 26 WIRING SCHEATIC (ACC. 2) +12V Fuse Block #2 (Helm) GRD Buss (Helm) Refrigerator ORG/PUR 10 YEL 10 Refrigerator - see FR Schematic Heater Trim Tabs ORG/GRY 16 Heater - see FR Schematic RED 16 ORG 16 OFF 20A ORG/PNK 16 Trim Tab - see FR Schematic VHF 7.5A RED 16 VHF Radio - see FR Schematic Stereo Stereo emory 3A RED/WHT 16 Stereo Deck - see FR Schematic To House Battery WHT/ arine Head To Lighting Schematic LF RF LR RR 12V Outlet Helm 20A ORG/WHT 10 12V YEL 10 12V Outlet V-Berth 20A ORG/WHT 10 YEL 10 12V Wine Cooler 10A ORG/BLU 16 Wine Cooler - see FR Schematic S.P. Shower Pump 5A BRN 16 Charger To A.C. Panel Charger - see FR Schematic YELLOW 10 YELLOW 8 To House Battery To Aft. Ground Buss To House Battery To Engine Battery To Thruster Battery 30A 30A 30A 36
CUTWATER 26 WIRING SCHEATIC (ACC. 3) Cutwater C-26 Accessories 3 +12V P.D.P. Fuse Block Downrigger (port) Downrigger (star) 1/4 Berth 12V Outlet 40A 40A 20A RED/WHT 10 RED/WHT 10 RED/PUR 10 12V ELECTRICAL SCHEATIC Downrigger Downrigger GRD Buss (Aft) YEL 10 YEL 10 YEL 10 Webasto Heater 20A ORG/PNK 10 Webasto - see FR Schematic YEL 10 Auto Pilot Pump Sub Panel 3 Switch Water Gauge Cabin Water Pressure isc. Wash Down 40A Underwater 20A 10A 10A 20A +12V Fuse Block (Thruster Batt.) Bilge 5A Pump 1 Deck BRN/BLK 10 ORG/RED 16 To Lighting Schematic BRN/YEL 10 To Lighting Schematic To Acc. 1 Schematic BRN/RED 16 Auto Pilot - see FR Schematic To Lighting Schematic To Lighting Schematic Water Gauge BRN/YEL 10 ORG 16 Bilge Pump To Lighting Schematic A B C Water Pump Blge Pump WashDown YEL 10 YEL 10 BRN/GRN 16 GRN/BRN 16 To Acc. 1 Schematic Bilge Pump 2 5A BRN/BLU 16 C.O. onitor 3A RED/BLK 16 C.O. onitor - see FR Schematic Bilge Alarm 3A 3A Voltmeter +12V Fuse Block (House Batt.) 3A Voltmeter WHT/BLK 16 RED/GRN 16 RED/PUR 16 Voltmeter Bilge Alarm - see FR Schematic BRN/WHT 16 WHT/BRN 16 RED/BLU 16 3A To Engine Battery A B C Stove Switch (LPG) 1A ORG/BLK 16 Stove - see FR Schematic WHT/ORG 16 To Propane Sensor To Propane Sensor 37
CUTWATER 26 WIRING SCHEATIC (LIGHTING) Cutwater C-26 Lighting +12V GND Dash Fuse Block #1 ELECTRICAL SCHEATIC Buss (Helm) Sub Panel 8 Switch 30A Chart Horn acerator Pump 10A BLU/ To Acc. 1 Schematic To Acc. 1 Schematic Nav/Inst 10A Spot Light Remote - see FR Schematic GRY/RED 16 AC-DC Panel - see FR Schematic Water Gauge - see FR Schematic GRY/BLK 16 Anchor Volt eter Compass ELCI Panel Sub Panel 4 Switch Defrost Fans 30A Dock PUR/WHT 16 To Acc. 1 Schematic Spare Spare 10A BLU/PINK 16 V-Berth 10A WHT/BLU 16 BLU/WHT 16 V-Berth (port side) BLU/ORG 16 +12V P.D.P. Fuse Block arine Head Deck To Acc. 2 Schematic 10A Under Water BLU/BLK 16 Buss (Aft) 10A BLU/PUR 16 GREY/BLU 16 BLU/BLK 16 GND Porch (Dog House) Spot Light ics. 10A PUR/ PUR/ Cabin BLU/RED 16 10A ORANGE 16 Spot Light - see FR Schematic 10A BLU/BRN 16 BLU/BRN 16 38
CUTWATER 26 WIRING SCHEATIC (P.D.P.) Fuse #1 Block. Fuse #2 Block. Wendlass Breaker. Cutwater C-26 Power Distribution 6 red 6 red 6 red Helm To A.C. panel. 2 red 100A P.D.P. Fuse Block. 1/4 Berth HOUSE 2 red 1 red 1 red 6 red ELECTRICAL SCHEATIC SWITCH 1 red To generator control panel. GENERATOR To A.C. panel. PARALLEL SWITCH 1 red - + 6 red - INVERTER See Inverter schematics for wire sizes and fuse size. + Thruster Thruster Engine Battery Fuse Block. Thruster Battery Fuse Block. See thruster schematic for fuse sizes. 1 red 1 red 1 red 1 red 1/4 Berth INVERTER 1 red 175A 1 red SWITCH ENGINE 1 red SWITCH 6 red 6 red THRUSTER 1/O red SWITCH 1 red 1 red 1/O red Refer to Engine Schematic for wire size 6 yellow + ALTERNATOR To engine schematic. + STARTER 2 yellow 1 yellow CHARGE RELAY GRD BUSS Aft CHARGE RELAY 2 yellow 1 yellow Helm To engine schematic. Fuse Block #2 Wendlass 1 red 1 red 1 red 1 red 1 yellow 1 yellow 1 yellow Thruster Thruster 1 red 1 yellow 1 yellow 1 yellow Engine 3 2 1 THRUSTERS ENGINE. HOUSE 39 1 HOUSE
WORKING DECK 40
CARE AND AINTENANCE The following checklists are examples and are not all inclusive and are provided only as a guide. Please customize to your personal needs. Consult your engine and trailer user manuals for additional information. EXAPLE OF A PREPARATION FOR THE ROAD CHECKLIST TOW VEHICLE PRIOR TO USE Test. Check brakes. Check tire pressure and condition. Check hitch related electrical connections. TRAILER PRIOR TO USE Check registration Check rollers and bed rails. Check wheel bearings and lubricate as required. Check winch. Test electrical connection and lights. Check tire pressure and condition. Check safety chains. Check boat straps. Check braking system. Check hitch for proper connection and lock down. Install safety chains (cross under hitch). Remove tire blocks. BOAT PRIOR TO USE WITH TRAILER Lower mast. Lower VHF antenna. Secure the Bimini awning frame. Raise and secure swim platform ladder. Set all switches and breakers to the OFF position, Including Thruster/Windlass cutoff switch Close and secure all windows, ports and vents. Lock cabin. Center rudder. Remove Drain Plug 41
EXAPLE OF A SPRING PRE-LAUNCH CHECKLIST CLEANING Remove debris from scuppers and scupper drains. Clean hull using a mild biodegradable detergent and then wax. Clean topsides and decks using a mild biodegradable detergent and then wax. Clean and polish all bright work. Clean and oil teak. Clean windows, ports, and hatches. Clean bimini cover. Check and clean anchor, rode, and anchor storage compartment. INSPECTION Check Drain Plug Check spare parts and tools and replace as necessary. Check wiper blades. Check swim platform. Inspect and test trim tabs. Check condition of bottom paint. Check windlass. Verify electronics for correct operation. Check all inside and outside lights. acerator Y-Valve in proper position and secured. Inspect and verify position of all sea cocks and shut off valves. Check alarms for proper operation. Check fluid levels. SAFETY EQUIPENT Sound signaling device. Check flares and their expiration dates. Check personal flotation devices. Check fire extinguishers and their fill dates. First aid kits. GALLEY Check stove for proper operation. Check everyday utensil stock. DOCUENTS Registration sticker. Insurance papers and Passports. Boat Inspection sticker. Charts and float plan forms. 42
EXAPLE OF WINTER STORAGE CHECKLIST GENERAL AINTENANCE Fill Fuel Tank and add a fuel stabilizer. Empty and clean black water tank. Empty fresh water tank use a non-toxic antifreeze per manufacturer s directions. Winterize black and fresh water tanks as necessary based on weather. Check bilge area for oil and for proper operation Check zincs and replace as necessary. Check impeller. Check and clean water strainer. Clear barnacles and debris from hull fittings. Trickle charge batteries every 30-60 days. Vent boat to prevent mildew. Check trailer tire pressure and condition. Check trailer braking system. Check trailer bearings. Remove Drain Plug. Turn off all battery cutoff switches. ENGINE Flush sea strainer system with fresh water. Check all fluid levels. Check all hose fittings. Check engine maintenance requirements. Inspect and verify position of all sea cocks and shut off valves. GALLEY Empty, clean and freshen refrigerator. Remove all dry food from storage. 43
REFERENCE ATERIAL The following table contains a list of reference materials provided by Cutwater that are contained under separate manuals. EQUIPENT ORIGINAL ANUFACTURER Navigation System Garmin Engine C28 Volvo D4 260 H.P., gear model D4-ZF 63 Engine C26 Volvo D3 220 H.P., gear model D3-ZF 15 Furnace, diesel Webasto Trim Tabs Bennett Thrusters Side Power Search Light ITT Raw Water Wash Down Johnson Pump Water Pump Johnson Pump Heater Heater Craft Water Heater Seaward Products Refrigerator Nova Kool Y-Valve Jabsco Compass Ritchie Power Cord Furion Kitchen Faucet ITC Head Faucet ITC Sea Strainer arine Hardware Battery Charger/Inverter (Pro ariner) AC Rotary Switch Blue Sea AC Distribution Panel Blue Sea DC Distribution Panel Blue Sea Steering System Ultraflex Windlass Lewmar Generator ase 2.7kw 44
CONTACTS Customer Service Andrew Custis Customer Service anager Phone 253-839-5213 andrewcustis@cutwaterboats.com Web Site www.cutwaterboats.com 45
NOTES 46
All rights reserved. Reproduction or translation by any means in whole or in part is not permitted without written authorization from Cutwater. The information contained herein is correct to the best of Cutwater knowledge and the contents may change without notice and without incurring obligation. 47
Phone 800.349.7198 Fax 866.408.9516 cutwaterboats.com 17341 Tye St. S.E onroe, Washington 98272