Fisher Engineering 0 Gordon Drive, Rockland, Maine 08- www.fi sherplows.com 000 080 November, 0 Lit. No. 08, Rev. Blade and Off-Truck Kit XLS Snowplow Parts List A DIVISION OF FISHER, LLC
Lit. No. 08, Rev. November, 0
XLS BLADE... XLS OFF-TRUCK KITS... Headgear and A-Frame... Hydraulic Unit... 8 Cover Assembly... 0 Lift and Angle Rams... Hoses and Fittings... Electrical Components... Vehicle-Side Wiring Diagram -Port, -Plug Systems... Vehicle-Side Wiring Diagram -Port, -Plug Systems... Headlamp Kit... Lit. No. 08, Rev. November, 0
Blade Components 8 0 0 0 8 8 * * Does not include Retainer Bar (Item ) Lit. No. 08, Rev. November, 0
000/080 XLS Blade Item Part Description Item Part Description 0 Bolt Kit, Urethane Edge 8 0 XLS Blade 0 Retainer Bar 00 Label Warning/Caution, Snowplows 0 Kit, Urethane Edge Assembly 0 Label Identity, STORM GUARD (Does not include Retainer Bar.) 00 Label 8' 0', XLS 0 Urethane Edge 08 Rubber Defl ector Kit, XLS 0 DS Blade Wing, XLS 08 Cutting Edge Kit ns 08 PS Blade Wing, XLS 000 / x -/8 Hex Shoulder Bolt G 0 /8 x Pin Kit 0 /- Hex Locknut GB 0 /8 x -/ Pin Kit 08 / x -/ Pin 8 0 Wing Spring 8 0 Removable Spring Disk 0 Eyebolt Kit 0 Blade Guide Bracket Kit 0 0 DS Blade Slide Box, XLS 0 Flexible Blade Guide Kit " ns 0 PS Blade Slide Box, XLS Label Multiple Pinch Points 00 Wing Pin B0 Hydraulic Cylinder, Slide Box 0 Stop Bolt Kit ns B0 Combo Seal Kit, Cylinder B0 0 Base Angle 0 Wear Strip Wing Top 88 / x -/ Machine Pin w/cotter 08 Wear Strip Wing Bottom 0 Trip Spring ns Label XLS Wings 0 Spring Bar ns 08 Label FISHER Splatter 0 Spring Assembly Kit ns Label XLS ID ns = not shown G = Grade Lit. No. 08, Rev. November, 0
Headgear and A-Frame Components 8 0 0 8 0 8 8 0 Lit. No. 08, Rev. November, 0
XLS Headgear and A-Frame Components Item Part Qty Description Item Part Qty Description 8 Headgear 00 /8- x Hex Cap Screw G - Lift Arm Service Kit Yellow /8- Hex Locknut GB Nameplate Label Minute Mount 08 Kit, Pivot Bolt 8 Stop Link Kit 0 Kit, A-Frame 0 /8 x -/8 Clevis Pin w/cotter 8 0 Kit, Stacking Stops Jack /8 OD x -/ Clevis Pin Kit K Bushing Kit (pkg of ) 0 A8K U-Bolt Assembly Packet 8 8K / x -/8 Machine Pin Packet Spring/U-Bolt Kit 08 / x -/ Cotter Pin K /8 x Clevis Kit 0 8 Handle, Link Arm Assembly K Cable Kit Label Minute Mount Headgear 0 /8 Wire Rope Clip K Wire Cam Kit DS 88 Thimble, /8 Wire Rope K Wire Cam Kit PS K Clamp Loop Kit 8 Jack Lock -/ Round Flat Washer Compression Spring, / OD x -/ 8 K Step Pin Kit 8K Connecting Pin Kit K Handle Kit 8 Compression Spring, ID x -/ 0 00 /8- x Carriage Bolt G 8 8 x -/ Pin 0K x -/ Anchor Pin Packet w/cotter 0 /8 Flat Washer 0 x -/ Clevis Pin 0 0 /8 x Cotter Pin 00 / x -/ Cotter Pin K Stop Clip Kit 0 x -/ Clevis Pin HT Handle Cover Kit 8 Label SECURITY GUARD Link Arm ns Chain Bag ns = not shown HT = Heat Treated G = Grade Lit. No. 08, Rev. November, 0
Hydraulic Unit Components 8 8 0 0 Lit. No. 08, Rev. 8 November, 0
Hydraulic Unit XLS Item Part Qty Description Item Part Qty Description - Breather Pressure Control Valve, SV08- w/nut - Reservoir Kit 8 Valve, SV08- w/nut 0 0- x / Machine Screw Valve, PC08-0 w/nut 0 /8 Plug NPTF Square 0 Quill Assembly /- Thread O-Ring -0 8 Quill Assembly /-0 Thread 8 Magnet /-0 Socket O-Ring Boss Plug 0080 /-8 x -/ Hex Cap Screw G K- -/ Relief Valve Kit ( sets) 8 - Pump Kit K- Cartridge 0 w/jam Nut 8- Suction Filter Crossover Relief Valve 000 psi 0 O-Ring -0 08 /-0 x Socket Cap Screw 8 O-Ring - ns 0 /-0 x / Hex Washer-Head Pump Shaft Seal Thread-Rolling Screw 00K- Motor Assembly, -/" ns /-0 x / -Lobe Round K- 8 Coil With Spade Terminals Washer-Head Screw (pkg of ) Valve, SVCV08-0 w/nut ns /-0 x /8 Hex Washer-Head K- Valve, SV08-00 w/jam Nut Thread-Rolling Screw O-Ring Service Kits K- Back-Up/O-Ring Kit (Does not - Seal Kit, Valves SV08-0,,,, contain O-rings for cartridge valves.) 0,,, SVCV08-0 & PC08-0 8- Seal Kit, Valves SV08-00, Seal Kit, Crossover Relief Valve CV08-0, SF08-0 ns = not shown G = Grade Lit. No. 08, Rev. November, 0
Hydraulic Unit Cover Assembly 8 Cover Assembly Item Part Qty Description Item Part Qty Description Top Retainer Ring Cover Side 0 Bottom Retainer Ring Cover Side 0 /-0 x / -Lobe Round 8 0 Label Information Washer-Head Screw (pkg of ) 0 Label Information Cover Side 0 ns Label Identity, XLS Hydraulic Unit Cover Side 0 ns Cable Tie, " ns = not shown Lit. No. 08, Rev. 0 November, 0
Lift and Angle Ram Components 00K Lift Ram Assembly -/ x 0 Item Part Qty Description 0 Cylinder 08K Split Bearing 8 Rod Assembly Spacer Gland Nut PolyPak Seal Kit Angle Ram Assembly -/ x 0 Item Part Qty Description 0 Cylinder 08K Split Bearing 8 Rod Assembly Spacer Gland Nut PolyPak Seal Kit Hoses and Fittings To DS Wing Rod (inside) To DS Angle Ram To DS Wing Base (outside) To Lift Ram 8 To PS Angle Ram To PS Wing Rod (inside) To PS Wing Base (outside) Hoses and Fittings Item Part Qty Description Item Part Qty Description 88 Hose, /8 x 0 w/f JIC Ends Elbow, Extra Long 0 M JIC/ Hose, /8 x w/f JIC Ends M ORB 8 Hose, /8 x w/f JIC Ends 8 Drain Cap, F JIC Hose, / x 8 w/f JIC Ends Orifi ce Kit 8 Hose, /8 x w/f JIC Ends ns 8 Hose Wrap, Polyethylene Elbow, 0 M JIC/ M ORB ns 00 /8- x Hex Cap Screw G ns B Label Hose Install Warning F = Female G = Grade M = Male ns = not shown Lit. No. 08, Rev. November, 0
Electrical Components 8 Plow-Side Electrical Components Item Part Qty Description Item Part Qty Description Plow Control Harness, -Solenoid 8 - Plow Module 0 Cable Assembly 8" /-0 x /8 Hex Washer-Head 0 Snowplow Battery Cable Thread-Rolling Screw 0 Motor Relay Kit FLEET FLEX ns 88K Cable Boot 0 /-0 x / Hex Washer-Head ns 8K Dielectric Grease (pkg of ) Thread-Rolling Screw ns Fuse, A Mini Automotive Plow Control Harness, -Solenoid Blade-Style (for items and ) 08 Spacer Module Vehicle-Side Electrical Components * 0 Vehicle Battery Cable ns 8K Plug Cover * 88 Vehicle Control Harness ns = not shown * For diagram see Vehicle-Side Harness Diagram Lit. No. 08, Rev. November, 0
Vehicle-Side Harness Diagram -Port, -Plug System To Snowplow Control RED To Switched Accessory Fire Wall Factory Vehicle Harness Battery BLK Vehicle Control Harness Vehicle Lighting Harness (-Pin) Turn Signal Configuration Plug Typical Plug-In Harness 0.0 A Fuses (Snowplow Park/Turn & Snowplow Control) Park/Turn Lamps Vehicle Headlamps Vehicle Headlamps RED Park/Turn Lamps Vehicle Battery Cable BAT -Port Module (Non-DRL or DRL) Factory Vehicle Harness Lit. No. 08, Rev. November, 0
Vehicle-Side Harness Diagram -Port, -Plug System To Snowplow Control To Switched Accessory RED Battery RED Factory Vehicle Harness BLK Vehicle Battery Cable Adapter Park/Turn Lamps Vehicle Headlamps Vehicle Headlamps Park/Turn Lamps Vehicle Control Harness. A Fuse (Control) A Fuse (Park/Turn) Fire Wall Vehicle Lighting Harness (-Pin) BAT Short Plug-In Harness Isolation Module Factory Vehicle Harness Long Plug-In Harness Lit. No. 08, Rev. November, 0
Headlamp Kit 8 8800- Headlamp Kit (Pair) Item Part Qty Description Item Part Qty Description 880- Headlamp Service Kit PS Park/Turn Bulb (Trade No. NAK) ns 880- Headlamp Service Kit DS 880 H Headlamp Bulb Service Kit 880- Rear Cover Kit (fi ts - or -screw) 8808- Cover Screws Service Kit (pkg of ) 880 Mounting Hardware Kit 8 8K Harness Service Kit 880 Park/Turn Socket Service Kit ns = not shown Lit. No. 08, Rev. November, 0
Copyright 0 Douglas Dynamics, LLC. All rights reserved. This material may not be reproduced or copied, in whole or in part, in any printed, mechanical, electronic, fi lm, or other distribution and storage media, without the written consent of Fisher Engineering. Authorization to photocopy items for internal or personal use by Fisher Engineering outlets or snowplow owner is granted. Fisher Engineering reserves the right under its product improvement policy to change construction or design details and furnish equipment when so altered without reference to illustrations or specifi cations used. Fisher Engineering or the vehicle manufacturer may require or recommend optional equipment for snow removal. Do not exceed vehicle ratings with a snowplow. Fisher Engineering offers a limited warranty for all snowplows and accessories. See separately printed page for this important information. The following are registered ( ) or unregistered ( ) trademarks of Douglas Dynamics, LLC: FISHER, Minute Mount, SECURITY GUARD, STORM GUARD, XLS. Printed in U.S.A. Lit. No. 08, Rev. November, 0