Replacement Parts List No. 779200300 Revision C 04/2011 McQuay Climate Control Singer Rooftop Unit ER, R 080 Vintage A, B, C, D Last Manufactured: 1996 To find your Daikin Applied parts distributor, call 1-800-377-2787 or visit www.daikinapplied.com
Contents Parts List Revision History... 3 Nomenclature Model Number... 4 Serial Number- Prior to 1988... 4 Serial Number- 1988 and later... 4 Unit Layout and Panels... 5 Evaporator Coil and Blower Components... 6 Refrigeration Section Compressor, HP Switch, LP Switch,Condenser Coil, Condenser Fan and Motor, Condenser Pressure Switch, TXV, Drier,... 7 Compressors and Compressor Components... 8 Gas Heat Burner Assy, Pilot & Electrode, Gas Valve, Ventor, Limit Switch, Sight Glass... 9, 10 Manifold, Collector Box, Fluebox, Filter... 10 Heat Exchangers... 10 Gas Valves- Natural Gas Units...11 Gas Valves- Propane Units...11 Hydronic Heat...11 Electric Heat Section 47/20 KW Electric Heat- 208/230 Volt... 12 47/20 KW Electric Heat- 460 Volt... 12 14/27 KW Electric Heat- 208/230 Volt... 12 14/27 KW Electric Heat- 460 Volt... 12 40 KW Electric Heat- 208/230 Volt... 13 40 KW Electric Heat- 460 Volt... 13 47/60 KW Electric Heat- 208/230 Volt... 13 47/60 KW Electric Heat- 460 Volt... 14 Economizer Components... 14 Pump Down and Suction Line Filters, Filter Flag, Solenoid... 14 Controls Compressor Contactor, Blower Motor Contactor, Terminal Blocks, Fan Motor Capacitors, Transformer, Guard-A-Matic, Relay, Unit Fuses... 15, 16 Rooftop Unit; ER,R 080 Vintages A, B, C, D Rev. C 04/11 RPL 7792003 / Page 2
Parts List Revision History Revision Date Description 04/89 Last Revision from Red Bud A 03/02 Converted to electronic format. Part numbers converted to current McQuay Style. All new drawings used. Added model number and serial number nomenclature definitions. Added to cover panel, lower closeout panel, compressor access panel, evaporator bearing grommet, evaporator motor mounting plate, condenser top panel- front and rear, burner box panel, burner viewport safety glass and frame, venter housing, venter motor mounting band, venter motor mounting plate, fluebox, fluebox birdscreen, fluebox gasket, fluebox panel, heat exchanger gaskets, collector box assembly, manifold pipe for vintages A- C, filter replacement kit, filter mounting angle, heat exchangers for vintage D, hot-water coil, steam coil, hydronic heating coil brackets, drain pan, outside air economizer hood, economizer filter mounting parts, remote thermostats, remote stat bulb, failure relay package field installation kit. Updated/changed part number for freezestat, 3.0 hp evaporator motor, all evaporator sheaves and belts, condenser fan motors, condenser pressure switches, all electric heat and control fuses, compressor and blower motor contactors, condenser fan capacitor. B 05/02 Page 10: Filter- 16 X 25 X 2 part number was changed from 0002373974 to 0002373979 Page 12: Incorrect headings on top two tables; both were titled 47/20KW and are now changed to read correctly as 7/20KW. C 04/11 Converted form to current software and corrected various formatting issues. Page 1, 3: Updated Logo to current design. Added "ER" (Electric Heat option) to title. Page 4: Added "ER" description to Model Nomenclature. Page 8: Changed 460V BR compressor p/n 802003279 to 802003275-2 places. Daikin Applied, 13600 Industrial Park Blvd., P.O. Box 1551, Minneapolis, MN 55440 (763) 553-5330 Rooftop Unit; ER,R 080 Vintages A, B, C, D Rev. C 04/11 RPL 7792003 / Page 3
Nomenclature Model R= Rooftop Unit ER= Rooftop unit, Electric Heat Capacity 080= 8 Ton Vintage A, B, C, or D Voltage 0= 208/230/60/3 1= 460/60/3 Heating Section Natural Gas N19= 187.5 mbh input N25= 250 mbh input N30= 300 mbh input Propane P20= 200 mbh input P25= 250 mbh input P30= 300 mbh input Hydronic Heat H2W= 2-Row Hot Water H1S= 1-Row Steam Model Number R 080 C 1 N25 1 Electric Heat 007= 7 KW 014= 14 KW 020= 20 KW 040= 40 KW 047= 47 KW 060= 60 KW Cooling Only 000= Cooling Only Options 1= Standard Motor 2= Oversize Motor 3= Double Oversize Motor 8= Suction Line Filter & Pumpdown cycle B= D.S. Switch E= Failure Relay Package G= Horiz. Disch. Economizer T= Tracking Return Air Damper X= Economizer w/spring Return Motor Serial Number (Prior to 1988) 10 digit Number M 15 4 digit number Year Manufactured A= 1974 H= 1981 B= 1975 J= 1982 C= 1976 K= 1983 D= 1977 L= 1984 E= 1978 M= 1985 F= 1979 N= 1986 G= 1980 P= 1987 R= 1988 Week of Manufacture Serial Number (1988 and later) R 88 12 12345 Plant Identification R= Red Bud, IL Year Manufactured 88= 1988 89= 1989 90= 1990 etc. Sequence Week of Manufacture Rooftop Unit; ER,R 080 Vintages A, B, C, D Rev. C 04/11 RPL 7792003 / Page 4
Unit Layout, Select Panels A Electric Heat Section Controls Section Filter Section E Compressor & Condenser Compartment C Panels Bub. Description Qty. Part Number A Top Cover Assy- Insulated 1 0599781400 C Lower Closeout Panel 1 0599686200 E Compressor Access Panel 1 0700749300 Rooftop Unit; ER,R 080 Vintages A, B, C, D Rev. C 04/11 RPL 7792003 / Page 5
Evaporator Coil and Blower Components Diagram 6 8 7 51 50 17 9A 9 18 16 19 15A 15 4 Bub. # Description Qty. Part Number 4 Freezestat- Ranco 1 071301801 6 Blower Wheel 2 0002121030 7 Shaft- 1.00" Diameter 1 0002790928 8 Key- Blower Shaft 1 0002344335 9 Bearing 2 000829904 9A Grommet- Bearing 2 0002110273 15 Evaporator Motor 1 Standard Size (Option Code= 1) 1.5 HP 1 0001131501 Oversize Motor (Option Code= 2) 2.0 HP 1 0001132501 Double Oversize Motor (Option Code= 3) 3.0 HP 1 071300701 15A Mounting Plate w/bolts- Evaporator Motor 1 0699800600 16 Motor Sheave, VM50 X 5/8"- 1.5 HP Motor 1 0002750690 Motor Sheave, VP56 X 3/4"- 2.0 HP Motor 1 0002750725 Motor Sheave, VP62 X 7/8"- 3.0 HP Motor 1 0002750750 17 Blower Sheave, AK64 X 1.00" 1 000145100 18 Belt, AP38-1.5 and 2.0 HP Motors 1 0002102013 Belt, AP40-3.0 HP Motors 1 0002102001 19 Evaporator Coil- Vintages A, B 1 0002280833 Evaporator Coil- Vintages C, D 1 0002280852 50 Blower Housing 2 0599635000 51 Tri Arm Bracket 2 071012901 1 For Gas Heat Units with a 300 mbh furnace (N25, P25), the standard motor is 2.0 HP and the oversize motor is 3.0 HP. Rooftop Unit; ER,R 080 Vintages A, B, C, D Rev. C 04/11 RPL 7792003 / Page 6
Refrigeration Section Compressor, HP Switch, LP Switch,Condenser Coil, Condenser Fan and Motor, Condenser Pressure Switch, TXV, Drier, 14 3 H J 52 53 20 10 13 11 1 12 Compressor Compartment Condenser Fan Detail H Top Condenser Panel- Front 1 0700480600 J Top Condenser Panel- Rear (w/hinges) 1 0700480500 1 Compressor- (See Compressor Components) 3 High Pressure Switch TI # 20PS037MB425K30K (pre serial number P08) 1 0001390896 TI # 20PS031KB435K310W (s.n. P08 and later) 1 0001390942 N/S Low Pressure Switch TI # 20PS106FA040K010D 1 0001390904 10 Condenser Fan Blade- Torin 4- blade (pre serial number K33) 2 0002325501 Lau 3- blade (serial number K33 and later) 2 0002325510 11 Condenser Fan Motor- 1/3 HP 208/230 Volt 2 071300101 460 Volt 2 071300201 12 Mount- Condenser Motor (pre serial number K33 & K35) 2 0002110210 Mount, 4- leg- Condenser Motor (serial no. K35 and later) 2 0699800600 13 Slinger- 1/2" bore 2 0002326741 14 Pressure Switch- Condenser Adjustable (pre serial number K49) 2 0008P04007 150 PSI (serial number K49 and later) 1 071270403 170 PSI (serial number K49 and later) 1 071270402 20 Expansion Valve- Vintages A & B 1 071302702 Expansion Valve- Vintages C & D 1 0001580318 52 Bolt- Condenser Mounting 8 0002356130 53 Washer- Condenser Mounting 8 0002364200 N/S Condenser Coil Vintages A & B 30" X 66" 1 0002270524 Vintages C & D 40" X 66" 1 0002270533 N/S=Not shown Rooftop Unit; ER,R 080 Vintages A, B, C, D Rev. C 04/11 RPL 7792003 / Page 7
Refrigeration Section, Continued Compressors and Compressor Components Unit Vintages A & B Bub.# Description Voltage Vendor Number Qty. Part Number 1 Compressor- Copeland* 208/230 BRG2-0900-TFC 1 047135304 Compressor- Copeland* 380/460 BRG2-0900-TFD 1 802003276 N/S Crankcase Heater ALL 1 0001950426 N/S Filter Drier- Liquid Line- ½" 1 0002319430 *Motor Protector is part of the compressor and is not available separately. Unit Vintage C- Pre Serial Number L16 Bub.# Description Voltage Vendor Number Qty. Part Number 1 Compressor- Copeland* 208/230 BRE2-0750-TFC 1 802003282 1 Compressor- Copeland* 460 BRE2-0750-TFD 1 802003275 N/S Crankcase Heater ALL 1 0001950426 N/S Filter Drier- Liquid Line- ½" 1 0002319430 * Motor Protector is part of the compressor and is not available separately. Unit Vintage C- Serial Number L16 and later Bub.# Description Voltage Vendor Number Qty. Part Number 1 Compressor- Bristol 208/230 700446-07-0444 1 0001223590 1 Compressor- Bristol 460 700456-07-0444 1 0001223595 N/S Crankcase Heater ALL 1 0001950724 N/S Motor Protector ALL 1 0001340550 N/S Filter Drier- Liquid Line- ½" 1 0002319430 Unit Vintage D- Units with Gas Heat Bub# Description Voltage Vendor Number Qty. Part Number 1 Compressor- Tecumseh** 208/230 AN111ST-037-A4 1 0001220877 1 Compressor- Tecumseh** 460 AN111UT-037-A4 1 0001220878 N/S Filter Drier- Liquid Line- ½" 1 0002319430 ** Crankcase Heater and Motor Protector are part of the compressor and are not available separately. Unit Vintage D- Units with Electric, Hydronic, or No Heat Bub# Description Voltage Vendor Number Qty. Part Number 1 Compressor- Copeland* 208/230 BRE2-0750-TFC 1 802003282 1 Compressor- Copeland* 460 BRE2-0750-TFD 1 802003275 N/S Crankcase Heater ALL 1 0001950426 N/S Muffler*** 1 0002319453 N/S Filter Drier- Liquid Line- ½" 1 0002319430 * Motor Protector is part of the compressor and is not available separately. *** Muffler used on units serial number R8901 and later. N/S= Not Shown. Rooftop Unit; ER,R 080 Vintages A, B, C, D Rev. C 04/11 RPL 7792003 / Page 8
Gas Heat Section Burner Assy, Pilot & Electrode, Gas Valve, Ventor, Limit Switch, Sight Glass 46 47 48 42 44 40 39 41 38 41A 41B 37 37 Gas Valve- See Gas Heat section 38 Burner Box Panel 1 0700440700 39 Burner- Vintages A, B, C 1 0002990421 Burner- Vintage D 1 0002145706 40 Burner Orifice- Vintages A, B, C N19- Orifice #45 10 0002700403 P19- Orifice #55 10 0002700411 N25- Orifice #41 10 0002700818 P25- Orifice #53 10 0002700296 N30- Orifice #41 12 0002700818 P30- Orifice #53 12 0002700296 Burner Orifice- Vintage D N15- Orifice #40 6 0002700395 P15- Orifice #53 6 0002700296 N20- Orifice #40 8 0002700395 P20- Orifice #53 8 0002700296 N25- Orifice #40 10 0002700395 P25- Orifice #53 10 0002700296 41 Spring Retainer 1 0002344227 41A Viewport Frame- Safety Glass 3 0700382700 41B Safety Glass 3 071207301 42 Pilot & Electrode- Vintage A Natural (Until Serial Number D50) 1 1 0001380572 Propane (Until Serial Number D50) 1 1 0001380573 Natural & Propane (after Serial Number D50) 1 1 0001380603 Pilot & Electrode- Vintages B, C 1 0001380603 Pilot & Electrode- Vintage D 1 0001380635 N/S Pilot Orifice- Vintages A, B, C White Rogers F69-1915 1 0002700831 Pilot Orifice- Vintages D- Natural White Rogers F69-2063 1 0002700841 Pilot Orifice- Vintages D- Propane White Rogers F69-2067 1 0002700842 1 Pilot & Electrode Assembly includes ignition leads. N/S=Not shown Rooftop Unit; ER,R 080 Vintages A, B, C, D Rev. C 04/11 RPL 7792003 / Page 9
Gas Heat Section Burner Assy, Pilot & Electrode, Gas Valve, Ventor, Limit Switch, Sight Glass, Continued 44 Ignition Control- Vintage A Until Serial Number D50 1 0001380570 After Serial Number D50- White Rogers 5059-25 1 0001380600 Ignition Control- Vintages B, C- White Rogers 5059-25 1 0001380600 Ignition Control- Vintage D- White Rogers 5059-34 1 0001380636 N/S Limit Switch- All Vintages- Thermo-Disc 60T01B3 1 071270201 46 Fan Limit Switch Vintages A, B, C- White Rogers 40TC33444 1 0001002744 Vintage D- Honeywell L4064-1665 1 0001300158 47 Ventor Assy Blower Wheel- Vintages A, B, C 1 0001708502 Blower Wheel- Vintage D 1 0001708513 Blower Motor- Vintages A, B, C (until s.n. E50)- Fasco 7162-0102C 1 0001708500 (after s.n. E50)- Fasco 7121-4066A 1 0001708507 Blower Motor- Vintage D (pre s.n. P19)- N/P15- Fasco 7121-5854 1 0001708516 (pre s.n. P19)- N/P20, N/P25 mbh- Fasco 7121-4066 1 0001708507 (post s.n. P19)- N/P15- Fasco 7121-5854 1 0001708518 (post s.n. P19)- N/P20, N/P25 mbh- Fasco 7121-4066 1 0001708520 N/S Mounting Band, Ventor Motor - pre s.n. P19 1 071241601 Mount Plate, Ventor Motor - post s.n. P19 1 071241701 48 Ventor Housing- Vintages A, B, C 1 071205201 Ventor Housing- Vintage D 1 0001708514 N/S Mounting Bracket- Ventor Housing 1 0001149777 Manifold, Collector Box, Fluebox, Filter Bub # Description Qty. Part Number N/S Manifold Pipe- Vintages A, B, C Up to 150,000 BTUH 1 0002710868 200,000 BTUH and greater 1 0002710913 Manifold Pipe- Vintage D 1 0002710868 N/S Collector Box Assy 1 0699687900 N/S Fluebox Components Fluebox 1 0599484700 Flue Restrictor 1 0700485700 Flue Bird Screen 1 071308501 Gasket- Fluebox Outlet 1 0002480896 Panel- Upper Flue Outlet 1 0700486400 N/S Filter- 16 X 50 X 2 1 0002373987K Filter- 16 X 25 X 2 2 0002373979 N/S Filter Mounting Angle 1 0700396600 Bub # Description Qty. Part Number N/S Heat Exchanger Vintage A, B, C 10 Cell- N19, P19, N25, P25 1 0008855001 12 Cell- N30, P30 1 0008855006 Vintage D 6 Cell- N15, P15 1 0599818901 8 Cell- N20, P20 1 0599818903 10 Cell- N25, P25 1 0599818904 N/S Gasket for Heat Exchanger 3 071197601 N/S=Not shown Heat Exchangers Rooftop Unit; ER,R 080 Vintages A, B, C, D Rev. C 04/11 RPL 7792003 / Page 10
Gas Heat Section Gas Valves- Natural Gas Units 37 Vintage A Until Serial Number D50- White Rogers 36C38-401 1 0001585930 After Serial Number D50- White Rogers 36C93-402 1 0001585938 Vintages B, C- White Rogers 36C93-402 1 0001585938 Vintage D 150 mbh input- White Rogers 36C93-202 1 0001585966 200, 250 mbh input- White Rogers 36C93-301 1 0001585967 Gas Valves- Propane Units 37 Vintage A Until Serial Number D50- White Rogers 36C11-402 1 0001585931 After Serial Number D50- White Rogers 36C69-402 1 0001585939 Vintages B, C- White Rogers 36C69-402 1 0001585939 Vintage D 150 mbh input- White Rogers 36C96-206 1 0001585969 200, 250 mbh input- White Rogers 36C93-301 1 0001585968 Hydronic Heat Bub # Description Qty. Part Number N/S 1- Row Steam Coil 1 0002272107 N/S Hot Water Coil 1 0002273116 N/S Lower "Z" Bracket- Hydronic Coil 1 0700398500 N/S Upper Bracket- Hydronic Coil 1 0699704600 N/S Drain Pan- Vintages A, B 1 0599785200 Drain Pan- Vintages C, D 1 0599566000 N/S=Not shown Rooftop Unit; ER,R 080 Vintages A, B, C, D Rev. C 04/11 RPL 7792003 / Page 11
Electric Heat Section 7/20 KW Electric Heat- 208/230 Volt N/S Element- 20 KW 1 0001950700 N/S Limit Switch- TOD 60T11 1 0001320502 N/S Limit Switch- TOD 60T01B3 1 0001320500 N/S Terminal Block 1 0001821015 N/S Fuse Block- 3 Pole, 60A, 250V 1 0001821006 N/S Fuse- 60 A, 250V- FRN60 3 025860514 N/S Contactor- 3 Pole, 40A, 240V 1 071301501 N/S Relay- RBM 91-907 1 0001420807 N/S Control- TOD 71F14-209507-L-200 2 0001320518 7/20 KW Electric Heat- 460 Volt N/S Element- 20 KW 1 0001950701 N/S Limit Switch- TOD 60T11 1 0001320502 N/S Limit Switch- TOD 60T01B3 1 0001320500 N/S Terminal Block 1 0001821016 N/S Fuse Block- 3 Pole, 30A, 600V 1 0001821018 N/S Fuse- 30 A- JKS30 6 0001946022 N/S Contactor- 3 Pole, 25A, 460V 1 071301401 N/S Relay- RBM 91-907 1 0001420807 N/S Control- TOD 71F14-209507-L-200 2 0001320518 14/27 KW Electric Heat- 208/230 Volt N/S Element- 40 KW 1 0001950705 N/S Limit Switch- TOD 60T11 1 0001320502 N/S Limit Switch- TOD 60T01B3 1 0001320500 N/S Terminal Block 1 0001821015 N/S Fuse Block- 3 Pole, 60A, 250V 1 0001821006 N/S Fuse- 60 A, 250V- FRN60 3 025860514 N/S Contactor- 3 Pole, 40A, 240V 1 071301501 N/S Relay (until s.n. P49)- RBM 84-20103-301 1 0001420805 Relay (after s.n. P49)- RBM 134-22803-301 1 0001420855 N/S Relay- RBM 91-907 1 0001420807 N/S Control- TOD 71F14-209507-L-200 4 0001320518 14/27 KW Electric Heat- 460 Volt N/S Element- 40 KW 1 0001950703 N/S Limit Switch- TOD 60T11 1 0001320502 N/S Limit Switch- TOD 60T01B3 1 0001320500 N/S Terminal Block 1 0001821016 N/S Fuse Block- 3 Pole, 30A, 600V 1 0001821018 N/S Fuse- 30 A- JKS30 6 0001946022 N/S Contactor- 3 Pole, 25A, 460V 1 071301401 N/S Relay (until s.n. P49)- RBM 84-20103-301 1 0001420805 Relay (after s.n. P49)- RBM 134-22803-301 1 0001420855 N/S Relay- RBM 91-907 1 0001420807 N/S Control- TOD 71F14-209507-L-200 4 0001320518 N/S=Not shown Rooftop Unit; ER,R 080 Vintages A, B, C, D Rev. C 04/11 RPL 7792003 / Page 12
Electric Heat Section, Continued 40 KW Electric Heat- 208/230 Volt N/S Element- 40 KW 1 0001950705 N/S Limit Switch- TOD 60T11 1 0001320502 N/S Limit Switch- TOD 60T01B3 1 0001320500 N/S Terminal Block 1 0001821015 N/S Fuse Block- 3 Pole, 60A, 250V 2 0001821006 N/S Fuse- 60A, 250V- FRN60 6 025860514 N/S Fuse Block- 3 Pole, 100A 1 0001821011 N/S Fuse- 70A, 250V- FRN70 3 735045536 N/S Contactor- 3 Pole, 40A, 240V 2 071301501 N/S Relay (until s.n. P49)- RBM 84-20103-301 1 0001420805 Relay (after s.n. P49)- RBM 134-22803-301 1 0001420855 N/S Relay- RBM 91-907 1 0001420807 N/S Control- TOD 71F14-209507-L-200 4 0001320518 40 KW Electric Heat- 460 Volt N/S Element- 40 KW 1 0001950703 N/S Limit Switch- TOD 60T11 1 0001320502 N/S Limit Switch- TOD 60T01B3 1 0001320500 N/S Terminal Block 1 0001821016 N/S Fuse Block- 3 Pole, 60A, 600V 2 0001821012 N/S Fuse- 35A, 600V- FRS35 3 025860410 N/S Fuse Block 2 0001821018 N/S Fuse- 30A, 600V- JKS30 6 0001946022 N/S Contactor- 3 Pole, 25A, 460V 2 071301401 N/S Relay (until s.n. P49)- RBM 84-20103-301 1 0001420805 Relay (after s.n. P49)- RBM 134-22803-301 1 0001420855 N/S Relay- RBM 91-907 1 0001420807 N/S Control- TOD 71F14-209507-L-200 4 0001320518 47/60 KW Electric Heat- 208/230 Volt Bub # Description Qty. Part Number N/S Element- 20 KW 1 0001950700 N/S Element- 40 KW 1 0001950705 N/S Limit Switch- TOD 60T11 1 0001320502 N/S Limit Switch- TOD 60T01B3 1 0001320500 N/S Terminal Block 1 0001821015 N/S Fuse Block- 3 Pole, 60A, 250V 3 0001821006 N/S Fuse- 60A, 250V- FRN60 9 025860514 N/S Fuse Block- 3 Pole, 100A 1 0001821011 N/S Fuse- 70A, 250V- FRN70 3 735045536 N/S Contactor- 3 Pole, 40A, 240V 3 071301501 N/S Relay (until s.n. P49)- RBM 84-20103-301 1 0001420805 Relay (after s.n. P49)- RBM 134-22803-301 1 0001420855 N/S Relay- RBM 91-907 1 0001420807 N/S Control- TOD 71F14-209507-L-200 6 0001320518 N/S=Not shown Rooftop Unit; ER,R 080 Vintages A, B, C, D Rev. C 04/11 RPL 7792003 / Page 13
Electric Heat Section, Continued 47/60 KW Electric Heat- 460 Volt Bub # Description Qty. Part Number N/S Element- 20 KW 1 0001950701 N/S Element- 40 KW 1 0001950703 N/S Limit Switch- TOD 60T11 1 0001320502 N/S Limit Switch- TOD 60T01B3 1 0001320500 N/S Terminal Block 1 0001821016 N/S Fuse Block- 3 Pole, 60A, 600V 1 0001821012 N/S Fuse- 35A, 600V- FRS35 3 025860410 N/S Fuse Block 1 0001821017 N/S Fuse- 60A, 600V- JKS60 3 0001946023 N/S Fuse Block 1 0001821018 N/S Fuse- 30A, 600V- JKS30 3 0001946022 N/S Contactor- 3 Pole, 25A, 240V 1 071301401 N/S Contactor- 3 Pole, 40A, 240V 1 071301501 N/S Relay (until s.n. P49)- RBM 84-20103-301 1 0001420805 Relay (after s.n. P49)- RBM 134-22803-301 1 0001420855 N/S Relay- RBM 91-907 1 0001420807 N/S Control- TOD 71F14-209507-L-200 6 0001320518 Economizer Components Bub # Description Manuf./Number Qty. Part Number Pre Serial Number P30 N/S Damper Motor- Standard Honeywell W889E-1036 1 0001480940 N/S Damper Motor- Spring Return 1 Honeywell W899G-1042 1 0001480950 Damper Motor- Spring Return 1 White Rogers 3913-4 1 071302001 N/S Crank Arm for Honeywell Motor 1 0002344290 N/S Crank Arm for White Rogers Motor 1 0002344292 N/S Enthalpy Control Honeywell H205A 1 0001515785 Post Serial Number P30 N/S Damper Motor Honeywell M7415A1006 1 0001480970 N/S Logic Module Honeywell W7459A1001 1 0001480974 N/S Enthalpy Sensor Honeywell C7400A1004 1 0001480975 N/S Mixed Air Sensor Honeywell C7150B1004 1 0001480973 Common Components N/S Damper Relay (pre s.n. P49) RBM84-20103-301 1 0001420805 Damper Relay (after s.n. P49) Essex 134-22803-301 1 0001420855 N/S Outside Air Economizer Hood 1 0699697100 N/S Gravity Damper 1 0002311365 N/S Outside Air Birdscreen 1 0700388900 N/S Filter- Permanent 12 X 48 X 1 1 0002373995 N/S Filter Mounting Angle 2 0700396600 N/S Screws- Filter Mounting Angle 4 047663701 1 When replacing a Honeywell Motor with a White Rogers Motor, the crank arm must also be replaced. Pump Down and Suction Line Filters, Filter Flag, Solenoid N/S Solenoid Valve 1 0001580240 N/S Solenoid Valve Coil 1 735048442 N/S Suction Line Filter 1 071304301 N/S Filter Flag 1 0001520979 N/S=Not shown Rooftop Unit; ER,R 080 Vintages A, B, C, D Rev. C 04/11 RPL 7792003 / Page 14
Controls Compressor Contactor, Blower Motor Contactor, Terminal Blocks, Fan Motor Capacitors, Transformer, Guard-A-Matic, Relay, Unit Fuses Diagram 34 31 30 24 29 28 23 22 36 26 35 35A 25 25A xxxxxxxxxxxx xxxxxxxxxxxx xxxxxxxxxxxx 27* 35A 32 33 *Quantity Varies Rooftop Unit; ER,R 080 Vintages A, B, C, D Rev. C 04/11 RPL 7792003 / Page 15
Controls Compressor Contactor, Blower Motor Contactor, Terminal Blocks, Fan Motor Capacitors, Transformer, Guard-A-Matic, Relay, Unit Fuses Components Bub# Description Qty. Unit Voltage 208/230 460 22 Transformer, Line Voltage- 24V- Gas Heat Units 1 0001540949 0001540956 Transformer, Line Voltage- 24V- Non Gas Heat Units 1 0001540949 0001540955 23 Contactor- Compressor 40A 3 Pole 1 071301501 Contactor- Compressor 25A 3 pole 1 071301401 24 Contactor- Blower Motor 1 071400501 071400501 25 Capacitor- Condenser Fan 10MFD/370V 1 071219001 071219001 25A Capacitor- Condenser Fan 10MFD/370V (pre s.n. N27) 1 071219001 071219001 Capacitor- Condenser Fan 11.5 MFD/370V (post s.n. N27) 1 0001200585 0001200585 26 Guard-A-Matic Timer 5 minutes 1 0001395304 0001395304 27 Relay- Condenser Fan Essex 91-103006-11058 2 0001420838 0001420838 Relay- 24V DPDT RBM 91-907 1 0001420807 0001420807 Relay- 24 V SPDT- Cooling Only Units Pre Serial Number P49- RBM 84-20103-301 1 0001420805 0001420805 Post Serial Number P49- Essex 134-22803-301 1 0001420855 0001420855 Relay- 24 V SPDT- Gas Heat Units Pre Serial Number P49- RBM 84-20103-301 3 0001420805 0001420805 Post Serial Number P49- Essex 134-22803-301 3 0001420855 0001420855 28 Fuse Block- Blower Motor 1 0001821005 0001821003 29 Fuse- Blower Motor 3 025860507 025860405 30 Fuse Block- Pre Serial Number L40 1 0001821001 0001821001 Fuse Block- Post Serial Number L40 1 0001821001 0001821030 31 Fuses- Gas Heat Units 2 0001946070 042753111 Fuses- Electric Heat, Hydronic Heat, Cooling Only Units 2 0001946070 042753105 32 Fuse Holder- 24V Control Circuit 1 0001945396 0001945396 33 Fuses- 24V Control Circuit 2 071203801 071203801 34 Terminal Block 1 0001821019 0001821019 35 Terminal Strip- 10 Pole 1 0001821029 0001821029 35A Terminal Strip- 5 Pole 2 0001822040 0001822040 36 Ground Lug 1 0001820610 0001820610 N/S Remote Thermostat- White Rogers 1 0001515820 0001515820 Remote Thermostat- Honeywell T874-D1116 1 0001505719 0001505719 Sub base for Honeywell Stat 1 0001520503 0001520503 N/S Bulb for Remote Thermostat 1 0001520983 0001520983 N/S Failure Relay Package- Complete Package for Field Install. 1 0008450173 0008450173 Terminal Strip- 6 Pole 1 0001822030 0001822030 Relay- 24V SPDT RBM 84-20103-301 (pre s.n. P49) 1 0001420805 0001420805 Relay- 24V SPDT Essex 134-22803-301 (post s.n. P49) 1 0001420855 0001420855 Relay- 240V DPDT RBM 91-903 1 0001420808 0001420808 Relay- 240V SPDT RBM 84-20303-302 1 0001420806 0001420806 Relay (post serial number R06) Essex 134-22303-301 1 0001420857 0001420857 N/S=Not shown Rooftop Unit; ER,R 080 Vintages A, B, C, D Rev. C 04/11 RPL 7792003 / Page 16