COMMERCIAL MODELS: 489 THRU 630 CATALOG NO. 9300.40 Effective: 02-8-09 Replaces: 05-4-08 RAYPAK ILLUSTRATED PARTS LIST MODEL SIZES: 489, 587, 685, 750, 848, 90, 945, 020, 060, 93, 239, 303, 353, 43, 467,570, 630 MODEL TYPES: T, Ta, Tb, Tc, Td, WT, THWS, TIP, TIPR DATES OF MANUFACTURE: *972 THRU 9--83 EXCEPT AS NOTED. 489 and 587, 972 THRU 2-3-75 90, 93 and 43, --76 THRU 9--83 239 THRU 630 TIPR, 972 THRU 2-3-74 * SERVICE PARTS LISTED IN THIS PAMPHLET ARE FOR UNITS BUILT BEFORE 7-2-80 THE PARTS LISTED ARE FOR STANDARD EQUIPMENT FOR THIS MODEL TYPE. RAYPAK RESERVES THE RIGHT TO SUBSTITUTE, DELETE OR CHANGE ANY PART WITHOUT NOTIFICATION. THE ADDITION OF OPTIONS MAY ALSO CHANGE SOME OF THE PARTS. ORDER REPLACEMENT PARTS FROM ACTUAL HEATER COMPONENTS. FOR DETAILED INSTRUCTIONS, SEE "HOW TO USE YOUR RAYPAK ILLUSTRATED PARTS LIST", CATALOG NO. 900.0 Raypak, Inc., 25 Eastman Ave, Oxnard, CA 93030 (805) 278-5300 Fax (800) 872-925 Litho In U.S.A.
2
CALL 489 587 685 750 848 945 O UT DESCRIPTION (90) B BURNER TRAY** -B Burner Tray w/burners (Sea Level) * Burner Tray w/o Burners (Sea Level)* 2 -B Burner Tray w/burners (Sea Level)* Burner Tray w/o Burners (Sea Level)* 3-B Burner Spacer/Hold Down (Single) Burner Spacer/Hold Down (Double) 4-B Burner 3020/30 3020/36 3020/42 3020/46 3020/52 3020/58 5-B Burner Orifice - Nat. #49 (Sea Level)* 350078F/30 350078F/36 350078F/42 350078F/46 350078F/52 350078F/58 Burner Orifice - Pro. #57 (Sea Level)* 350083F/30 350083F/36 350083F/42 350083F/46 350083F/52 350083F/58 C CONTROLS -C Auto Hi Limit Fixed (T, TA) 008554F 008554F 008554F 008554F 2-C Manual Hi Limit (THWS, TIP) 00744F 00744F 00744F 00744F 00744F 00744F Auto Reset Dualstat (TC, W T) 004092F 004092F 004092F 004092F 004092F 004092F Manual Reset Dualstat (TX) 004092F 004092F 004092F 004092F Adj Auto Hi Limit (TB, TD, TIPR) 0074F 0074F 0074F 0074F 0074F 0074F Controller Modulatin g (TA) 600524 600524 600524 600524 600524 600524 Controller 2-Stage (TA) 007392F 007392F 007392F 007392F Controller B3 (TX) See Chart Page 7 Controller B5 (TX) 600503 600503 600503 600503 600503 600503 3-C Flow Switch (TD, TIP, TIPR) 00742F 00742F 00742F 00742F 00742F 00742F 4-C Low Water Cut Off (Not S hown) 006202F 006202F 006202F 006202F 006202F 006202F 5-C Flow Switch Paddle McDonnel Miller 004079F 004079F 004079F 004079F 004079F 004079F Taco 00026F 00026F 00026F 00026F 00026F 00026F (SEE GAS VALVE REPLACEMENT CHART) H HEAT EXCHANGER -H Heat Exch. Assy. Cast Iron (Complete) Heat Exch. Assy. Brass Heat Exch. Assy. Cast Iron w/pump Hdr. Heat Exch. Assy. Brass w/pump Hdr. Heat Exch. Assy. Cast Iron w/pump Hdr. (TIP) Heat Exch. Assy. Brass w/pump Hdr. (TIP) Heat Exch. Assy. Cast Iron w/pump Hdr. (TIPR) Heat Exch. Assy. Brass w/pump Hdr. (TIPR) Heat Exch. Assy. Cast Iron Cupro Nickle Heat Exch. Assy. Brass Cupro Nickle 2-H Inlet/Outlet Header Cast Iron Inlet/Outl et Header Brass 00293F 00293F 00293F 00293F 00294F 00294F Inlet/Outlet Header Cast Iron (TIP) Inlet/Outlet Header Brass (TIP) 00296F 00296F 00296F 00296F 00296F 00296F Inlet/Outlet Header Cast Iron (TIPR) Inlet/Outlet Header Brass (TIPR) 00293F 00293F 00293F 00293F 00293F 00293F 4-H Re turn Header Cast Iron Return Header Brass 002922F 002922F 002922F 002922F 002922F 002922F 5-H Return Pump Header Cast Iron Return Pump Header Brass 002924F 002924F 002924F 002924F 002924F 002924F 6-H Tube Bundle 00574F 00573F 002858F 002859F 002860F 00286F Tube Bundle Cupro Nickle (TIP) 002869F 002870F 00287F 002872F 7-H Heat Exchange Tube 002880F 00288F 002882F 002883F Heat Exchange Tub e Cupro Nickle 00289F 002892F 002893F 002894F 8-H Baffle Kit 00646F 00647F 00648F 00649F 9-H Stud Bolt Kit 0005F 0005F 0005F 0005F 0005F 0005F 0-H Header Gasket 80000B 80000B 80000B 80000B 80000B 80000B -H Sensor Well 0072F 0072F 0072F 0072F 0072F 0072F 2-H Well Retaining Clip 300203 300203 300203 300203 300203 300203 J J BOX -J J Box D- J Box E-8/E-9 J Box C2 C3 IRI 2-J Transformer Std/E8 E9 40 VA 006533F 006533F 006533F 006533F 006533F 006533F Spark Generator C2 C3 IRI 00736F 00736F 00736F 00736F 00736F 00736F 3-J Relay SPST 007377F 007377F 007377F 007377F 007377F 007377F Relay DPDT (Not Shown) 6507 6507 6507 6507 6507 6507 Relay DPDT IRI (Not Shown) 4-J Toggle Switch (Not Shown) 008079F 008079F 008079F 008079F 008079F 008079F M MISCELLANEOUS COMPONENTS -M PRV 45 PSI 007220F 007220F 007220F 007220F 007220F PRV 60 PSI 007222F PRV 25 PSI (WT, THWS, TIP & TIPR) 007224F 007224F 007224F 007224F 007224F 007224F 2-M Deliming Kit 052870F 052870F 052870F 052870F 052870F 052870F 3-M T & P Gauge (T, TA, TB, TD, TX) 007205F 007205F 007205F 007205F 007205F 007205F T & P Gauge, (TC, WT, THWS, TIP & TIPR) 007399F 007399F 007399F 007399F 007399F 007399F 4-M Integral Pump (Not Shown ) 004844F 004844F 004844F 004844F 004844F 004844F * FOR ALTITUDES ABOVE 2,000 FEET ABOVE SEA LEVEL, CONSULT THE FACTORY. **REPLACEMENT BURNER TRAYS ARE BUILT FOR SEA LEVEL, NATURAL GAS APPLICATIONS UNLESS OTHERWISE SPECIFIED AT THE TIME THE ORDER IS PLACED. 3
CALL 060 239 353 467 630 OUT DESCRIPTION (020) (93) (303) (43) (570) B BURNER TRAY** -B Burner Tray w/burners (Sea Level) * Burner Tray w/o Burners (Sea Level)* 2-B Burner Tray w/burners (Sea Level)* Burner Tray w/o Burners (Sea Level)* 3-B Burner Spacer/Hold Down (Single) Burner Spacer/Hold Down (Double) 4-B Burner 3020/65 3020/76 3020/83 3020/90 3020/00 5-B Burner Orifice - Nat. (Sea Level)* 350078F/65 350078F/76 350078F/83 350078F/90 350078F/00 Burner Orifice - Pro. (Sea Level)* 350083F/65 350083F/76 350083F/83 350083F/90 350083F/00 C CONTROLS -C Auto Hi Limit Fixed (T, TA) 008554F 008554F 008554F 008554F 008 554F 2-C Manual Hi Limit (THWS,TIP) 00744F 00744F 00744F 00744F 00744F Auto Reset Dualstat (TC, WT) 004092F 004092F 004092F 004092F 004092F Manual Reset Dualstat (TX) 004092F 004092F 004092F 0 04092F 004092F Adj Auto Hi Lmi it (TB, TD, TIPR) 0074F 0074F 0074F 0074F 0074F Controller Modulating (TA) 600524 600524 600524 600524 600524 Controller 2-Stage (TA) 600887 600887 600887 600887 600887 Controller B3 (TX) See Chart Page 7 Controller B5 (TX) 600503 600503 600503 600503 600503 3-C Flow Switch (TD, TIP, TIPR) 00742F 00742F 00742F 00742F 00742F 4-C Low Water Cut Off (Not Shown) 006202F 006202F 006202F 006202F 006202F 5-C Flow Switch Paddle McDonnel Miller 004079F 004079F 004079F 004079F 004079F Taco 00026F 00026F 00026F 00026F 00026F (SEE GAS VALVE REPLACEMENT CHART) H HEAT EXCHANGER -H Heat Exch. Assy. Cast Iron (Complete) Heat Exch. Assy. Brass Heat Exch. Assy. Cast Iron w/pump Hdr. Heat Exch. Assy. Brass w/pump Hdr. Heat Exch. Assy. Cast Iron w/pump Hdr. (TIP) Heat Exch. Assy. Brass w/pump Hdr. (TIP) Heat Exch. Assy. Cast Iron w/pump Hdr. (TIPR) Heat Exch. Assy. Brass w/pump Hdr. (TIPR) Heat Exch. Assy. Cast Iron Cupro Nickle (TIP) Heat Exch. Assy. Brass Cupro Nickle (TIP) 2-H Inlet/Outlet Header Cast Iron Inlet/Outlet Header Brass 00294F 00294F 00294F 00294F 00294F Inlet/Outlet Header Cast Iron (TIP) Inlet/Outlet Header Brass (TIP) 00296F 00296F 00296F 00296F 00296F Inlet/Outlet Header Cast Iron (TIPR) Inlet/Outlet Header Brass (TIPR) 00293F 00293F 00293F 00293F 00293F 4-H Return Header Cast Iron Return Header Brass 002922F 002922F 002922F 002922F 002922F 5-H Return Pump Header Cast Iron Return Pump Header Brass 002924F 002924F 002924F 002924F 002924F 6-H Tube Bundle 002862F 002863F 002864F 002865F 002866F Tube Bundle Cupro Nickle (TIP) 002873F 002874F 002875F 002876F 002877F 7-H Heat Exchange Tube 002884F 002885F 002886F 002887F 002888F Heat Exchange Tube Cupro Nickle 002895F 002896F 002897F 002898F 002899F 8-H Baffle Kit 00650F 0065F 00652F 00653F 00654F 9-H Stud Bolt Kit 0005F 0005F 0005F 0005F 0005F 0-H Header Gasket 80000B 80000B 80000B 80000B 80000B -H Sensor Well 0072F 0072F 0072F 0072F 0072F 2-H Well Retaining Clip 300203 300203 300203 300203 300203 J J BOX -J J Box D- J Box E-8/E-9 J Box C2 C3 IRI 2-J Transformer Std/E8 E9 40 VA 006533F 006533F 006533F 006 533F 006533F Spark Generaot r C2 C3 IRI 00736F 00736F 00736F 00736F 00736F 3-J Relay SPST 007377F 007377F 007377F 007377F 007377F Relay DPDT (Not Shown) 6507 6507 6507 6507 6507 Relay DPDT IRI (Not Shown) 4-J Toggle Switch (Not Shown) 008079F 008079F 008079F 008079F 008079F M MISCELLANEOUS COMPONENTS -M PRV 45 PSI PRV 60 PSI 007222F 007222F 007222F 007222F 007222F PRV 25 PSI (WT, THWS, TIP & TIPR) 007224F 007224F 007224F 007224F 007224F 2-M Deliming Kit 052870F 052870F 052870F 052870F 052870F 3-M T & P Gauge (T, TA, TB, TD, TX) 007205F 007205F 007205F 007205F 007205F T & P Gauge, (TC, WT, THWS, TIP & TIPR) 007399F 007399F 007399F 007399F 007399F 4-M Integral Pump (Not Shown ) 004844F 004844F 00 4844F 004844F 004844F * FOR ALTITUDES ABOVE 2,000 FEET ABOVE SEA LEVEL, CONSULT THE FACTORY. **REPLACEMENT BURNER TRAYS ARE BUILT FOR SEA LEVEL, NATURAL GAS APPLICATIONS UNLESS OTHERWISE SPECIFIED AT THE TIME THE ORDER IS PLACED. 4
CALL 489 587 685 750 848 945 O UT DESCRIPTION (90) P PILOT STD/C59 IGN -P Pilot Nat. 00242F 00242F 00242F 00242F 00242F 00242F 00243F 00243F 00243F 00243F 00243F 00243F 2 -P Pilot Orifice Nat. 600552 600552 600552 600552 600552 600552 600003 600003 600003 600003 600003 600003 4-P Ignitor Standing (Piezo) 5-P Ignition Control 60007F 60007F 60007F 60007F 60007F 60007F 6-P Pilot Mounting Bracket 7-P Pilot Tube (Specify Length) 40003 40003 40003 40003 40003 40003 D- A00S IGN -P Pilt Nat. 4-P Ignition Control 5-P Pilot Mounting Bracket 6-P Pilot Tube (Specify Length) 40003 40003 40003 40003 40003 40003 7-P Ignitor E8/E9 G60 IGN -P Pilot Nat. (E8/E9) 002832F 002832F 002832F 002832F 002832F 002832F (E8) (E8/E9) USE -P USE -P USE -P USE -P USE -P USE -P (E8) 3-P Sensor Probe 600560F 600560F 600560F 600560F 600560F 600560F 4-P Sensor Cable (Not Shown) 6- P Ignition Control 600559F 600559F 600559F 600559F 600559F 600559F 7-P Circuit Breaker (E9 Only) 8-P Pilot Mounting Bracet 9-P Pilot Tube (Specify Length) 40003 40003 40003 40003 40003 40003 C RA890F TORCH IGN (Not Shown) -P Pilot Nat. 600003 600003 600003 600003 600003 600003 4-P Ignitio n Control (complete) 008702F 008702F 008702F 008702F 008702F 008702F 5-P Pilot Mounting Bracket 6-P Pilot Tube (Specify Length) 40003 40003 40003 40003 40003 40003 Amplifier-Flame Rectification (not shown) 008092F 008092F 008092F 008092F 008092F 008092F Ignition Control (not shown) C-2 RA890F/C3 RA890H IGN (Not Shown) 007359F 007359F 007359F 007359F 007359F 007359F -P Pilot Nat. 3-P Ignition Control C2 (F), C3 (H) (complete) 008702F 008702F 008702F 008702F 008702F 008702F 4-P Pilot Mounting Bracket 5-P Pilot Tube (Specify Length) 40003 40003 40003 40003 40003 40003 Amplifier-Flame Rectification (not shown) 008092F 008092F 008092F 008092F 008092F 008092F Ignition Control (not shown) 007359F 007359F 007359F 007359F 007359F 007359F R REFRACTORY -R Refractory Kit 000998F 000999F 00000F 0000F 2-R Refractory Retainer Kit 000983F 000984F 000985F 000986F S SHEETMETAL -S Jacket Top (Indoor) 2-S Flat Top Assy. (Outdoor) 3-S Flue Collector (Indoor) 4-S Flue Collector (Outdoor) 5-S Door Assy. (Indoor) Door Assy. (Outdoor) Door Assy. Left (Indoor) Door Assy. Left (Outdoor) 6-S Door Assy. Right (Indoor) Door Assy. Right (Outdoor) 7-S Access Panel Group 2" w/pump Access Panel Group 2-/2" w/pump 002660F 002660F 002660F 002660F 002660F 002660F 8-S Access Panel Group 2" w/pump 002303F 002303F 002303F 002303F 002303F 002303F 9-S Control Cover 0-S Pump Cover 00267F 00267F 00267F 00267F 00267F 00267F -S J-Box Sheetmetal 2-S Gas Train Cover V VENTING -V Stackless Top Kit (Outdoor) 2-V Drafthood (Indoor) 006484 006484 006484 5
CALL 060 239 353 467 630 OUT DESCRIPTION (020) (93) (303) (43) (570) P PILOT STD/C59 IGN -P Pilot Nat. 00242F 00242F 00242F 00242F 00242F 00243F 00243F 00243F 00243F 00243F 600552 600552 600552 600552 600552 600003 600003 600003 600003 600003 4-P Ignitor Standing (Piezo) 5-P Ignition Control 60007F 60007F 60007F 60007F 60007F 6-P Pilot Mounting Bracket 7-P Pilot Tube (Specify Length) 40003 40003 40003 40003 40003 D- A00S IGN -P Pilt Nat. 4-P Ignition Control 5-P Pilot Mounting Bracket 6-P Pilot Tube (Specify Length) 40003 40003 40003 40003 40003 7-P Ignitor E8/E9 G60 IGN -P Pilot Nat. (E8/E9) 002832F 002832F 002832F 002832F 002832F (E8) (E8/E9) USE -P USE -P USE -P USE -P USE -P (E8) 3-P Sensor Probe 600560F 600560F 600560F 600560F 600560F 4-P Sensor Cable (Not Shown) 6-P Ignition Control 600559F 600559F 600559F 600559F 600559F 7-P Circuit Breaker (E9 Only) 8-P Pilot Mounting Bracket 9-P Pilot Tube (Specify Length) 40003 40003 40003 40003 40003 C RA890F TORCH IGN (Not Shown) -P Pilot Nat. 600003 600003 600003 600003 600003 4-P Ignition Control 007359F 007359F 007359F 007359F 007359F 5-P Pilot Mounting Bracket 6-P Pilot Tube (Specify Length) 40003 40003 40003 40003 40003 Amplifier-Flame Rectification (not shown) 008092F 008092F 008092F 008092F 008092F Ignition Control (not shown) C-2 RA890F/C3 RA890H IGN (Not Shown) 007359F 007359F 007359F 007359F 007359F -P Pilot Nat. N A/ 3-P Ignition Control C2 (F), C3 (H) (complete) 008072F 008072F 008072F 008072F 008072F 4-P Pilot Mounting Bracket 5-P Pilot Tube (Specify Length) 40003 40003 40003 40003 40003 Amplifier-Flame Rectification (not shown) 008092F 008092F 008092F 008092F 008092F Ignition Control (not shown) 007359F 007359F 007359F 007359F 007359F R REFRACTORY -R Refractory Kit 00002F 00003F 00004F 00005F 00006F 2-R Re fractory Retainer Kit 000987F 000988F 000989F 000990F 00099F S SHEETMETAL -S Jacket Top (Indoor) 002293F 002294F 002295F 002296F 002297F 2-S Flat Top Assy. (Outdoor) 00232F 00233F 00234F 00235F 00236F 3-S Flue Collector (Indoor) 00297F 4-S Flue Collector (Outdoor) 002258F 002259F 002260F 00226F 002262F 5-S Door Assy. (Indoor) Door Assy. (Outdoor) Door Assy. Left (Indoor) 002265F 002266F 002267F 002268F 002269F Door Assy. Left (Outdoor) 002279F 002280F 00228F 002282F 002283F 6-S Door Assy. Right (Indoor) 002272F 002273F 002274F 002275F 002276F Door Assy. Right (Outdoor) 002286F 002287F 002288F 002289F 002290F 7-S Access Panel Group 2" w/pump Access Panel Group 2-/2" w/pump 002660F 002660F 002660F 002660F 002660F 8-S Access Panel Group 002303F 002303F 002303F 002303F 002303F 9-S Control Cover 0-S Pump Cover 00267F 00267F 00267F 00267F 00267F -S J-Box Sheetmetal 2-S Gas Train Cover V VENTING -V Stackless Top Kit (Outdoor) 002305F 002306F 002307F 002308F 002309F 2-V D rafthood (Indoor) 006485 006485 006486 006486 006486 6
B-3 (W902) CONTROLLER PART NO. Outdoor Reset Controller (W902) Outdoor Temp Sensor Water Sensor Motor (M944J) (B3-) Motor (M944J) (B3-2) Potentiometer Auxilary End Switch (B3-) Auxilary End Switch (B3-2) Actuator 600449 Relay-DPDT 20V 00845F 7
T TA CALL 489 587 685 750 848 945 060 239 353 467 630 489 587 685 750 848 945 060 239 353 467 630 OUT PARTS DESCRIPTION PART NO. 90 020 93 303 43 570 90 020 93 303 43 570 Manual "B" Valve /8" 00795F Manual "A" Valve " 00789F Manual "A" Valve l/4" 00790F Manual "A" Valve l/2" 007933F Pressure Regulator Nat /8" 60027 Pressure Regulator Pro /8" 003568F Pressure Regulator Nat /4" 600035 Pressure Regulator Pro /4" 003639F Pressure Regulator Nat /2" 600044 Pressure Regulator Pro /2" 00367F Pressure Regulator Nat 2" 600036 Pressure Regulator Pro 2" 003604F Pilot Gas Valve /8" 60054 Pilot Gas Valve /8" 600562 Combination Gas Valve Nat " 60063 Combination Gas Valve Pro " Combination Gas Valve Nat " 600668F Combination Gas Valve Pro " 003640F Combination Gas Valve Nat -/4"" 600632 Combination Gas Valve Pro " Auto On/Off Valve -/4" 004094F Auto On/Off Valve -/2" 004095F Combination Gas Valve Nat /2" 600633 Auto On/Off Valve 2" 004096F Mod Valve 20-240 F 2 2 2 2 3 3 3 3 3 4 4 Mod Valve 85-20 F Mod Valve 0-70 F Mod Valve 50-20 F Mod Valve 40 F Max Combination Gas Valve Pro " 600802 Gas Valve Body -/4" 60045 Gas Valve Body -/2" 600452 Gas Valve Body 2" 600453 Combination 2-Stage GV Nat " 600655 Combination 2-Stage GV Nat -/4" 003607F Actuator 600449 * REQUIRED FOR IRI MODELS TB TD CALL 489 587 685 750 848 945 060 239 353 467 630 489 587 685 750 848 945 060 239 353 467 630 OUT PARTS DESCRIPTION PART NO. 90 020 93 303 43 570 90 020 93 303 43 570 Manual "B" Valve /8" 00795F Manual "A" Valve " 00789F Manual "A" Valve l/4" 00790F Manual "A" Valve l/2" 007933F Pressure Regulator Nat /8" 60027 Pressure Regulator Pro /8" 003568F Pressure Regulator Nat /4" 600035 Pressure Regulator Pro /4" 003639F Pressure Regulator Nat /2" 600044 Pressure Regulator Pro /2" 00367F Pressure Regulator Nat 2" 600036 Pressure Regulator Pro 2" 003604F Pilot Gas Valve /8" 60054 Pilot Gas Valve /8" 600562 Combination Gas Valve Nat " 60063 Combination Gas Valve Pro " Combination Gas Valve Nat " 600668F Combination Gas Valve Pro " 003640F Combination Gas Valve Nat -/4"" 600632 Combination Gas Valve Pro " Auto On/Off Valve -/4" 004094F Auto On/Off Valve -/2" 004095F Combination Gas Valve Nat /2" 600633 Auto On/Off Valve 2" 004096F Mod Valve 20-240 F Mod Valve 85-20 F Mod Valve 0-70 F Mod Valve 50-20 F Mod Valve 40 F Max 2 2 2 2 3 3 3 3 3 4 4 Combination Gas Valve Pro " 600802 Gas Valve Body -/4" 60045 Gas Valve Body -/2" 600452 Gas Valve Body 2" 600453 Combination 2-Stage GV Nat " 600655 Combination 2-Stage GV Nat -/4" 003607F Actuator 600449 * REQUIRED FOR IRI MODELS 8
WT THWS CALL 489 587 685 750 848 945 060 239 353 467 630 489 587 685 750 848 945 060 239 353 467 630 OUT PARTS DESCRIPTION PART NO. 90 020 93 303 43 570 90 020 93 303 43 570 Manual "B" Valve /8" 00795F Manual "A" Valve " 00789F Manual "A" Valve l/4" 00790F Manual "A" Valve l/2" 007933F Pressure Regulator Nat /8" 60027 Pressure Regulator Pro /8" 003568F Pressure Regulator Nat /4" 600035 Pressure Regulator Pro /4" 003639F * Pressure Regulator Nat /2" 600044 * Pressure Regulator Pro /2" 00367F Pressure Regulator Nat 2" 600036 Pressure Regulator Pro 2" 003604F * Pilot Gas Valve /8" 60054 Pilot Gas Valve /8" 600562 Combination Gas Valve Nat " 60063 Combination Gas Valve Pro " Combination Gas Valve Nat /4" 600632 Combination Gas Valve Pro " Combination Gas Valve Nat /2" 600633 Mod Valve 20-240 F Mod Valve 85-20 F 2 2 2 2 3 3 3 3 3 4 4 Mod Valve 0-70 F Mod Valve 50-20 F Mod Valve 40 F Max Auto On/Off Valve /4" 004094F Auto On/Off Valve /2" 004095F Auto On/Off Valve 2" 004096F * REQUIRED FOR IRI MODELS TIP TIPR CALL 489 587 685 750 848 945 060 239 353 467 630 489 587 685 750 848 945 060 239 353 467 630 OUT PARTS DESCRIPTION PART NO. 90 020 93 303 43 570 90 020 93 303 43 570 Manual "B" Valve /8" 00795F Manual "A" Valve " 00789F Manual "A" Valve l/4" 00790F Manual "A" Valve l/2" 007933F Pressure Regulator Nat /8" 60027 Pressure Regulator Pro /8" 003568F Pressure Regulator Nat /4" 600035 Pressure Regulator Pro /4" 003639F * Pressure Regulator Nat /2" 600044 * Pressure Regulator Pro /2" 00367F Pressure Regulator Nat 2" 600036 Pressure Regulator Pro 2" 003604F * Pilot Gas Valve /8" 60054 Pilot Gas Valve /8" 600562 Combination Gas Valve Nat " 60063 Combination Gas Valve Pro " Combination Gas Valve Nat /4" 600632 Combination Gas Valve Pro " Combination Gas Valve Nat /2" 600633 Mod Valve 20-240 F Mod Valve 85-20 F Mod Valve 0-70 F 2 2 2 2 3 3 3 3 3 4 4 Mod Valve 50-20 F 2 2 2 2 3 3 3 3 3 4 4 Mod Valve 40 F Max Auto On/Off Valve /4" 004094F Auto On/Off Valve /2" 004095F Auto On/Off Valve 2" 004096F * REQUIRED FOR IRI MODELS 9
www.raypak.com