Illustrated Parts Manual Models 522D LoPro 524D LoPro S/N 0900 P/N - 948-403 Revised July 6, 2007
INTRODUCTION Table of Contents SECTION INTRODUCTION Table of Contents... - thru -4 Alphabetical Index... -5 thru -8 Service Kits... -9, -0 Part Number Index... - thru -22 SECTION 2 CHASSIS & ATTACHING PARTS Frame Shrouding & Trim...2- Open Cab...2-2 Rear Axle & Attaching Parts...2-3 Front Axle Mounting...2-4 SECTION 3 BOOM First Boom Section... 3- Second Boom Section...3-2 Quick Switch...3-3 SECTION 4 ATTACHMENTS Carriage Assembly... 4- Quick Switch Carriage Assembly...4-2 Buckets... 4-3 0 Truss Boom Assembly...4-4 Truss Boom w/winch...4-5 6 Mast Assembly...4-6 00 Degree Swing Fork Assembly...4-7 66 Slope Piler Carriage Assembly...4-8 48 Slope Piler Carriage Assembly...4-9 Carriage Forks...4-0 Personnel Platform Assembly...4- -
INTRODUCTION Table of Contents SECTION 5 ENGINE & ATTACHING PARTS Engine Left Side View... 5- Engine Right Side View... 5-2 Engine Pump Mount & Flywheel Housing... 5-3 Fuel Tank & Lines... 5-4 Radiator Assembly... 5-5 Air Cleaner Piping... 5-6 Air Cleaner... 5-7 Exhaust System... 5-8 SECTION 6 DRIVE TRAIN Front Axle Assembly... 6- Front Axle Housing... 6-2 Front Axle Differential Carrier... 6-3 Brake Assembly... 6-4 Front Axle Shaft & Planetary Wheel End...6-5 Rear Steering Axle Drive Hub...6-6 Wheels & Tires... 6-7 SECTION 7 CONTROLS Tilt Lever Assembly... 7- Accelerator Pedal Assembly...7-2 Steering Column & Attaching Parts...7-3 Floorplate Components...7-4 Brake & Inching Linkage...7-5 SECTION 8 BRAKES Service/Parking Brake Lines.... 8- -2
INTRODUCTION Table of Contents SECTION 9 HYDRAULIC CIRCUITS Oil Supply & Pressure Lines... 9- Dump Circuit... 9-2 Drive Circuit (front)...9-3 Drive Circuit (rear)...9-4 Lift Cylinder... 9-5 Crowd Cylinder... 9-6 Tilt & Tilt Compensating Cylinder... 9-7 Steering Cylinder...9-8 Joystick Circuit... 9-9 SECTION 0 HYDRAULIC COMPONENTS Lift Cylinder...0- Crowd Cylinder...0-2 Tilt Cylinder...0-3 Compensating Cylinder...0-4 Steering Cylinder...0-5 Main Hydraulic Control Valve...0-6 Rear Drive Motor...0-7 Priority Flow Control Valve...0-8 Flow Divider Valve...0-9 Brake Valve... 0-0 Solenoid Valve... 0- Inching Valve... 0-2 Main Hydraulic Pump... 0-3 Hydrostatic Transmission Pump... 0-4 Front Drive Motor... 0-5 Hydraulic Reservoir & Filter...0-6 Joystick Assembly...0-7 Traction Lock Valve...0-8 Quick Start Cylinder & Valve Assembly...0-9 Truss Boom Winch... 0-20 Winch Motor...0-2 Crossover Valve...0-22 -3
INTRODUCTION Table of Contents SECTION ELECTRICAL Dash Panel...- Engine Wiring Harness...-2 Dash Harness Assembly...-3 Gauge Panel Assembly...-4 Battery & Cables...-5 SECTION 2 MISCELLANEOUS Cab & Frame Decals... 2- Boom Decals...2-2 SECTION 3 OPTIONAL EQUIPMENT Cab Enclosure Kit (featuring Skylight and Wiper Assembly)... 3- Cab Enclosure Kit (featuring Left Hand Side Assembly)... 3-2 Cab Enclosure Kit (featuring Cab Glass)... 3-3 Cab Enclosure Installation Kit... 3-4 Cab Enclosure Installation Kit... 3-5 Cab Heater Option... 3-6 Heater Assembly... 3-7 Inline By-pass... 3-8 Tow Hook Installation... 3-9 Joystick Installation (Tilt on Joystick)... 3-0 Main Control Valve w/ Auxiliary Hydraulics... 3- Auxiliary Hydraulics Assembly (2 Section Boom)... 3-2 Auxiliary Electronics Assembly (2 Section Boom)... 3-3 R.H. Auxiliary Hydraulic Assembly (2 Section Boom)... 3-4 Foam Filled Tire Assembly (2 Section Boom)... 3-5 L.H. Tilt Assembly... 3-6 3 Section Boom Assembly... 3-7 Crowd Cylinder Assembly (3 Section Boom)... 3-8 R.H. Auxiliary Hydraulic Assembly (3 Section Boom)... 3-9 Auxiliary Hydraulic Assembly (3 Section Boom)... 3-20 Auxiliary Electronics Assembly (3 Section Boom)... 3-2 Beacon Light Package... 3-22 Work Light Package... 3-23 Windshield/Top Window Kit Installation... 3-24 -4
INTRODUCTION Alphabetical Index ACCELERATOR CABLE... 5- ACCELERATOR PEDAL... 7-2 AIR CLEANER... 5-7 AIR CLEANER ELEMENT... 5-7 AIR CLEANER SERVICE INDICATOR... 5-6 AIR FILTER, OPTIONAL... 3-0 ALTERNATOR... 5-2 ATTACHMENTS... 4- thru 4-9 AUXILIARY ELECTRONICS (2 Section Boom)... 3-3 AUXILIARY ELECTRONICS (3 Section Boom)... 3-2 AUXILIARY HYDRAULICS (2 Section Boom)... 3-2 AUXILIARY HYDRAULICS (3 Section Boom)... 3-20 BATTERY... -5 BATTERY HOLD DOWN... -5 BATTERY CABLES... -5 BEACON LIGHTS... 3-22 BOOM DECALS... 2-2 BOOM SECTIONS (2 Section Boom)... 3- thru 3-2 BOOM, OPTIONAL (3 Section Boom)... 3-7 BRAKE PEDAL... 7-5 BRAKE VALVE... 0-0 BRAKE WARNING LIGHT... -4 BREATHER (Filler cap)... 0-6 BUCKETS... 4-3 CAB ENCLOSURE KIT... 3- thru 3-3 CARRIAGE... 4- COMPENSATING CYLINDER... 0-4 COMPENSATING CYLINDER HYDRAULIC CIRCUIT... 9-7 CONTROL VALVES... 0-6, 0-8, 0-9 CROWD CYLINDER... 0-2 CROWD CYLINDER (3 Section Boom)... 3-8 CROWD CYLINDER HYDRAULIC CIRCUIT... 9-6 DASH HARNESS... -3 DECALS... 2- thru 2-2 DECK... 2- DRIVE CIRCUIT (Front)... 9-3 DRIVE CIRCUIT (Rear)... 9-4 DUMP CIRCUIT... 9-2 -5
INTRODUCTION Alphabetical Index ELECTRICAL SYSTEMS... - thru -4 ENGINE LEFT SIDE VIEW... 5- ENGINE MOUNT... 5- ENGINE RIGHT SIDE VIEW... 5-2 ENGINE THROTTLE CONTROL... 5- EXHAUST PIPE... 5-8 EXHAUST SYSTEM... 5-8 EXTENSION & RETRACTION CABLE ASSEMBLY... 3-7 FILTERS (Hydraulic)... 0-6 FILTER ELEMENT... 0-6 FIRST BOOM SECTION... 3- FIRST BOOM SECTION MOUNTING PIN... 3- FLOORPLATE COMPONENTS... 7-4 F-N-R SHIFTER... 7-3 FOAM FILLED TIRE, OPTIONAL (2 Section Boom)... 3-5 FRAME... 2- FRAME SHROUDING & TRIM... 2- FRONT AXLE... 6- FRONT AXLE MOUNTING... 2-4 FRONT AXLE DIFFERENTIAL CARRIER... 6-3 FRONT AXLE DRIVE MOTOR... 0-5 FRONT AXLE HOUSING... 6-5 FRONT AXLE SHAFT & PLANETARY WHEEL END... 6-5 FRONT BRAKE ASSEMBLY... 6-4 FRONT DISC WHEEL & RIM... 6-7 FUEL GAUGE... -4 FUEL LEVEL SENDER... 5-4 FUEL LINES... 5-4 FUEL TANK & CAP... 5-4 HEATER, OPTIONAL... 3-7 HOOD... 2- HORN... 2- HORN BUTTON... -3 HORN WIRING... -3 HOURMETER... -4 HYDRAULIC CIRCUITS... 9- thru 9-9 -6
INTRODUCTION Alphabetical Index IGNITION SWITCH... -3 INCHING VALVE... 7-4, 7-5, 0-2 INLINE BYPASS... 3-8 INSTRUMENT PANEL... -, -4 JOYSTICK... 9-9, 0-7 KITS... -9, -0 LEFT HAND TILT CONTROL... 3-6 LIFT CYLINDER... 0- LIFT CYLINDER HYDRAULIC CIRCUIT... 9-5 MAIN BOOM SECTIONS... 3-, 3-2 MAIN HYDRAULIC CONTROL VALVE... 0-6 MAIN CONTROL VALVE W/ AUXILIARY HYDRAULICS... 3- MAIN HYDRAULIC PUMP... 5-, 0-3 MUFFLER... 5-8 NEGATIVE BATTERY CABLE... -5 OIL COOLER... 5-5, 9-2 OIL FILTER... 5-, 0-6 OIL PRESSURE GAUGE... -4 OIL PRESSURE SENDER... 5- OIL RESERVOIR... 0-6 OIL SUPPLY & PRESSURE LINES... 9- PERSONNEL PLATFORM... 4- POSITIVE BATTERY CABLE... -5 PRIORITY FLOW CONTROL VALVE... 0-8 QUICK SWITCH ASSEMBLY... 3-3 QUICK SWITCH MOUNTED CARRIAGE ASSEMBLY... 4-2 RADIATOR & HOSES... 5-5 REAR AXLE FRAME... 2-3 REAR AXLE MOUNTING PIN... 2-3 REAR DRIVE MOTOR.... 0-7 REAR STEERING AXLE... 2-3 REAR STEERING AXLE DRIVE HUB... 6-6 -7
INTRODUCTION Alphabetical Index REPAIR KITS... -9, -0 RESERVOIR FILLER-BREATHER...0-6 RESERVOIR SUPPLY CIRCUIT... 9- RESERVOIR...0-6 RESERVOIR FILTER...0-6 RIGHT HAND AUXILIARY HYDRAULIC (2 Section Boom)...3-4 RIGHT HAND AUXILIARY HYDRAULIC (3 Section Boom)...3-9 SEAT... 2- SEAT BELT... 2- SECOND BOOM SECTION... 3-2 SERVICE BRAKE LINES... 8- SERVICE KITS... -9, -0 SOLENOID VALVE...0- STARTER MOTOR... 5-2 STEERING COLUMN... 7-3 STEERING CYLINDER... 0-5 STEERING CYLINDER HYDRAULIC CIRCUIT... 9-8 STEERING KNUCKLES... 2-3 STEERING ORBITROL... 7-3 STEERING WHEEL... 7-3 SUPPLY HYDRAULIC CIRCUIT... 9- THERMAL BYPASS... 3-8 THREE SECTION BOOM...3-7 THREE SECTION BOOM AUXILIARY HYDRAULICS...3-20 TIE ROD ARM... 2-3 TILT CONTROL LEVER & LINKAGE... 7- TILT CYLINDER... 0-3 TILT CYLINDER HYDRAULIC CIRCUIT... 9-7 TOW HOOK... 3-9 TRACTION LOCK VALVE... 5-2, 0-8 TRAVEL ALARM... 2- WATER TEMPERATURE GAUGE... -4 WATER TEMPERATURE SENDER... 5-2 WHEELS & TIRES... 6-7 WHEELS & TIRES, OPTIONAL (Foam Filled)...3-5 WIRING HARNESS... 5-, -2, -3 WORKLIGHTS, OPTIONAL...3-23 -8
INTRODUCTION Service Kits SECTION PAGE NO. PART NUMBER DESCRIPTION 2 2-3 94-5040 Steering Cylinder Pin Kit 5 5-933-5033 Engine Filter Kit 6 6-3 94-4382 Limited Slip Plate Stack Kit 6 6-3 94-4383 Pinion Cage Shim Kit 6 6-3 94-4384 Drive Pinion Shim Kit 6 6-3 94-4385 Limited Slip Shim Kit 6 6-4 94-4442 Brake Seal Kit 6 6-4 94-4369 Brake Piston Plate Kit 6 6-4 94-4370 Brake Plate & Seal Kit 6 6-4 94-437 Piston Brake Shim Kit 7 7-2 94-4432 Cable Attachment Kit 7 7-2 94-497 Boot Kit 7 7-2 94-4433 Heel Rest Kit 7 7-3 94-490 Steering Control Unit Seal Kit 7 7-3 94-4448 Tie Strap & Boot Kit 0 0-92-407 Lift Cylinder Seal Kit 0 0-2 908-4306 Crowd Cylinder Seal Kit 0 0-3 908-4370 Tilt Cylinder Seal Kit 0 0-4 903-4339 Compensating Cylinder Seal Kit 0 0-5 908-4305 Steering Cylinder Seal Kit 0 0-6 908-4203 Main Control Valve Stud Kit 0 0-6 940-478 MVC Section Seal Kit 0 0-6 940-479 MVC Main Relief Seal Kit 0 0-6 908-420 MVC Plug Seal Kit 0 0-6 940-480 MVC Seal Retainer Kit 0 0-6 940-48 MVC Spool Seal Kit 0 0-9 908-4386 Flow Divider Valve Seal Kit 0 0-0 908-4043 Brake Valve Repair Kit 0 0-2 94-4459 Inching Valve Seal Kit 0 0-3 908-428 Main Hydraulic Pump Seal Kit 0 0-4 908-4385 Hydrostatic Transmission Pump Seal Kit 0 0-5 96-409 Front Drive Motor Seal Kit -9
INTRODUCTION Service Kits SECTION PAGE NO. PART NUMBER DESCRIPTION 0 0-7 930-400 Joystick Seal Kit 0 0-7 930-4025 Joystick Plunger Kit 0 0-8 908-4284 Traction Lock Valve Seal Kit 2 2-948-5007 Decal Kit 3 3-940-477 Main Control Valve w/ Aux Hyd Stud Kit 3 3-940-478 MCV w/ Aux Hyd Valve Section Seal Kit 3 3-940-479 MCV w/ Aux Hyd Main Relief Seal Kit 3 3-908-420 MCV w/ Aux Hyd Plug Seal Kit 3 3-940-480 MCV w/ Aux Hyd Seal Retainer Kit 3 3-940-48 MCV w/ Aux Hyd Spool Seal Kit 3 3-8 933-3029 Crowd Cylinder Packing Kit -0
INDEX INTRODUCTION Part Number Index PART NUMBER PAGE PART NUMBER PAGE PART NUMBER PAGE 050-44... 4-8, 4-9 440-346... -5 2443-386... 4-6 2460-472... 2-2464-328... 3-5, 3-6 2474-047... 5-2477-004... -3 2486-67...3-23 2486-70... 5-2, - 2492-332... 5-6 749-242... 5-4, 9-2 7207-980... 5-7208-8049...3-7 773-3052... 9-2, 9-4, 9-8, 3-7 773-3053... 9-2, 9-4 773-3073... 9-8 773-336... 7-4, 9-7 773-337... 7-4, 8-, 9-4, 9-7, 9-8 773-339... 9-5, 9-6, 3-2, 3-3,...3-4 773-340... 4-7, 9-3, 9-5, 9-6, 9-7,... 3-2, 3-3, 3-4,...3-2 773-34... 3-3, 3-2 773-366... 9-773-368... 9-7, 3-3, 3-2 773-377... 4-7, 9-3, 9-5, 9-6, 9-7,... 3-2, 3-3, 3-4,...3-2 773-320... 4-7 773-3209... 9-4, 9-8, 3-7 773-3279... 9-4 773-3306... 8-, 9-8 773-3390... 8-, 9-8 773-3447... 5-, 9-4 773-3497... 9-3, 9-5 773-3498... 7-4, 9-3, 9-4, 9-5, 9-8 773-3499... 7-4, 9-3, 9-4, 9-8 773-3893... 9-8, 3-7 774-3003... 2-, 9-9, -, -5 774-3004... 3-4, 3-6 774-3006... 2-, 5-5, -, -5,... 3-4, 3-6 774-303... 2-774-305... 4-8, 4-9, 0-9, -5 774-307... 3-4 776-302... 3-4 776-3204... 3-3, 3-2 7732-274... 5-7732-3029... 8-, 9-8 7733-004... 2-7733-3027... 2-7734-4055... 6-6 7736-3223... -4 7736-3225... -3 7736-3263... -3 7736-3264... -3 7736-3267...3-22 7736-3268...-3, 3-5, 3-6, 3-23,... 3-24 7736-3302...3-23 7736-436...0-7 7736-4320...0-7 7738-38... 2-7738-3303... 5-7738-3377... 5-2 7738-340...3-23 7738-3467... -4, 3-22, 3-23 7738-3470... -4, 3-5, 3-6,... 3-3, 3-2, 3-22,... 3-23 7738-3540... 3-5, 3-6 7738-3567... -5 7738-3580... 6-7738-3744...-4, 3-5, 3-6 8000-3082...3-8 8000-352...3-8 8000-3227...3-8 8000-3337...3-8 8000-3447...3-8 802-4343...0-5 8026-4033... 3-2 8026-4034... 3-2 8026-4046... 3-2 8026-4052... 3-2 8026-4060... 3-2 8026-406... 3-2 8026-4062... 3-2 8026-4066... 3-8026-4074... 3-2 8026-4078... 3-2 8026-4082... 3-2 8026-4084... 3-2 8026-409... 3-2 8026-408... 3-2 8027-4006... 5-7 8036-4009... 2-2, 3-8036-4024... 3-2 8036-4096...0-7 8036-4098...0-7 8036-40...0-7 8036-40...0-7 8038-485... 3-2 8038-487... 3-2 8038-49... 3-2 8038-4206... 3-8038-4207... 3-8038-420... 3-8038-42... 3-8038-424... 3-8060-3022... 2-8060-3026... 2-8060-3037... 2-2 8062-306... 9-4 8063-3030...5-3, 9-8093-4035...0-8093-4036...0-8093-4038...0-8093-4228...0-7 8093-4230...0-7 8093-423...0-7 8093-4233...0-7 8093-4234...0-7 8093-4235...0-7 8093-4236...0-7 8093-4237...0-7 8093-4240...0-7 8093-424...0-7 8093-4242...0-7 8093-4244...0-7 8093-4256...0-7 8093-4257...0-7 8093-4258...0-7 8093-4259...0-7 8093-4263...0-7 8093-4264...0-7 8096-3050...3-23 8096-3055...3-23 8096-3056...3-23 8096-3057... -2, -3, 3-4, 3-7 8096-3058...5-, 0-9, -2 8096-3059... -2 8096-3060...9-9, -2, 3-0 8096-3062...3-23 8096-3065...5-, 0-9, -3 8096-3066...3-23 8096-3067...-2, 3-4, 3-7 8096-3068... -2, -3, 3-4, 3-7,... 3-23 8096-3069... 5-, 9-9, 0-9, 3-0,... 3-23 8096-30... -4, 3-5, 3-24 8096-405... 3-2 -
INDEX INTRODUCTION Part Number Index PART NUMBER PAGE PART NUMBER PAGE PART NUMBER PAGE 8203-3996... 3-4, 3-7, 3-22, 3-23 8209-28... 5-8307-3828... 6-3 839-004... 5-2 839-005... 5-2 839-006... 5-2 839-00... 5-, 5-2 839-03... 5-2, 5-8 839-02... 5-2, 5-8 839-028... 5-6, 3-0 839-032... 5-839-038... 5-839-04... 5-839-057... 5-839-059... 7-3 8320-006... 2-3 8320-07...3-7 8320-02... 2-3 8320-024... 4-7 8320-026... 4-7, 3-7 8320-038...3-7 8320-039...3-7 8320-057...0-2 8320-073...3-7 8320-20... 9-3, 3-9 8320-23... 3-3, 3-7, 3-9, 3-20 8320-35... 5-, 5-2, 9-3, 9-4 8320-44... 2-3 8320-55... 5-2, 9-3, 9-4 8320-58... 2-8320-72... 2-4 8345-04... 4-5 8348-285... -3 8348-286... -3 8348-3497... 5-2 8348-3584... 6-3 8362-283... 3-2, 3-7 8362-3032... 9-2, 0-6 8363-3002... 7-4 8364-675... 2-8365-33... 5-3, 9-2, 9-4 8366-36... 4-8, 4-9, 9-8366-336...3-23 8367-475... 5-6, 3-0 8368-3085... 3-4, 3-24 8368-375... 5-8 8368-3246... 5-8368-3254... -2 8368-329... 2-8368-3308... 5-5 8395-3028...0-9 8452-056... 5-5 8452-062...4-8, 4-9 847-2738... 5-, 5-2, 9-3, 9-4 847-2739... 9-3 847-2746... 5-4 847-4006...5-, 9-3 847-6434...4-8, 4-9 847-679... 9-2 847-7304...7-4, 9-3 847-7306...3-0 847-7344... 9-3 847-7458... 9-9 847-759... 9-9 847-7537...3-0 847-7563... 9-7, 3-2, 3-4 847-7640... 4-6 847-764... 7-4 847-7644... 4-5 847-7803... 9-847-7824... 9-4 847-7832...9-, 9-3 847-7839...5-3, 9-2 847-785...5-, 9-847-7852...5-3, 9-3 847-7854... 9-8 847-7859... 9-7 847-7860... 9-5 847-7878... 9-4 847-7886... 9-7 847-7889...5-2, 9-2 847-7893... 7-4, 3-0 847-7896...3-7 847-79...9-2, 9-3 847-7934...5-, 9-847-7983... 9-3 847-8026... 3-2, 3-4, 3-9, 3-20 847-8032... 3-2, 3-4 847-804... 3-9, 3-20 847-8067... 4-7 847-864... 9-2 847-885...5-2, 9-4 847-889... 9-8 847-8280... 3-7, 3-9, 3-20 847-828... 3-7, 3-9, 3-20 847-8439... 9-8 847-8657... 9-3 847-8688... 7-4 847-8689... 7-4 847-8735... 9-9 847-8736... 9-9 847-8759... 8-847-886... 9-3 847-8925... 3-8 847-8926... 3-8 847-9038... 9-847-9042... 9-8 847-907... 9-2 847-909...5-5, 9-2 847-90... 9-2 847-95... 8-847-94...5-2, 9-2 847-942...5-2, 9-4 847-969... 9-4 847-9380... 9-4 847-9429...9-2, 9-4 847-9430... 9-2 847-943... 9-4 847-9432... 9-4 847-9646... 9-8 847-9647... 9-8 847-9650... 9-6 847-965...3-7 847-9689... 9-3 847-9698... 9-4 8507-28... 5-5 850-098... 2-3 852-088... 2-8540-340... 2-3 8594-06... 9-4, 9-8, 3-3 8594-07... 5-, -5 8654-38... 5-4 8656-308...3-7 8662-230...3-23 8664-58...3-7 8668-572... 2-3 8668-322... 2-, 5-4, 7-3, 9-2 8668-393...3-4, 3-5, 3-6 8668-3480... 3-4, 3-22 8688-42... 6-4 8688-3074... 5-8688-3075... 5-8688-306...5-, 5-4 8688-3260...3-23 8688-3327... 5-5 8688-3469... 9-8698-3643...3-5 8698-445... 6-5 8698-4452... 6-5 8820-00... 5-2 8820-002...3-23 8820-003... 5-, 7-2, 0-8, 0-9,... 3-4, 3-7, 3-24 -2
INDEX INTRODUCTION Part Number Index PART NUMBER PAGE PART NUMBER PAGE PART NUMBER PAGE 8820-005... 3-3, 3-2 8820-006... 9-4 8820-007... 9-4 8820-008... 4-7, 7-4, 9-2 8820-009... 9-5 8820-00... 9-2 8820-0...3-0 8820-02... 3-2, 3-6, 3-20 8820-06... 2-, 5-5 8820-07...3-2 8820-08... 5-2, 5-6, 9-4, 3-23 8820-09... 3-9, 3-20 8820-020... 2-, 5-2, 5-5, 0-6,... 0-6, 3-, 3-7 8820-02... 4-4, 4-5, 5-5 8820-022... 7-5, 3-2, 3-4, 3-9,...3-20 8820-023... 7-4, 8-, 9-4, 9-7, 9-8 8820-027... 4-5 8820-028... 0-6, 3-8820-029... 0-9 8820-030... 0-8 8820-033... 7-3 8820-034... 3-7, 3-9, 3-20 8820-035... 2-3, 4-4, 4-5, 7-3, 9-4,... 0-9, 0-20 8820-036... 4-4, 4-5, 0-6, 0-20 8820-037... 4-6, 0-20 8820-040... 4-8, 4-9 8820-043...3-7 8820-046...3-7 8820-050... 2-8820-065... 3-2, 4-8, 4-9, 5-2, 9-5,... 9-7, 3-7 8820-066... 4-, 4-5, 9-6 8820-067... 5-5 8820-073... 4-4, 4-5 8820-095... 5-4, 0-6 8820-096... 4-5 8820-05... 4-, 4-2, 4-7, 4-8, 4-9 8820-07... 3-8820-2... 5-3 8820-532... 3-, 3-2, 3-7 8820-533... 3-, 3-2 8820-534...3-7 8820-535...3-7 8820-536... 4-8, 4-9, 3-7 8820-537... 3-2, 4-8, 4-9 8820-538...3-7 8820-562...3-7 8820-563...3-7 8820-564... 3-2, 3-7 8820-565...3-7 8820-566...3-7 8820-568... 3-, 3-7 8820-569... 3-8820-607... 3-8820-608...3-7 8820-66... 6-8820-492... 2-882-028... 5-2 882-030... 3-4 882-044...3-6 882-068... 2-3, 5-3, 3-8 882-2228...7-4, 7-5 882-2272... 2-3 882-2285... 2-3 882-232... 2-3 8826-04... 2-8826-07...7-5, 9-9 8826-022... - 8830-073... 2-8830-088... 3-3, 3-2 8830-93...2-, 3-3 8830-3... 7-3 8830-225... 2-8832-022...3-23 8832-029... - 8834-022... 4-, 4-2, 4-4, 4-5, 4-6,... 4-7, 4-8, 4-9 884-036... 9-7 884-037... 3-2, 3-4 8844-00... 7-5 8850-004... 9-2, 9-5, 0-9, 3-4,... 3-0, 3-23, 3-24 8850-005... 4-4, 4-5, 5-2, 7-5, 9-8,... 0-6, 0-8, 3-, 3-7,... 3-9, 3-20 8850-006... 2-3, 4-4, 4-5, 4-6, 0-6,... 0-20, 3-7 8850-007... 2-8850-008... 4-4, 4-5, 0-20, 3-7,... 3-9, 3-20, 3-2 8850-00...3-, 4-5 8850-02...3-7 8850-06...4-8, 4-9 8850-06...4-4, 4-5 8850-08... 3-7, 3-9, 3-20,... 3-2 8850-0... 2-3 8850-304... 5-8850-34...3-7 8850-405... 7-5 8850-406... 7-, 7-5, 3-4, 3-9 8850-408...0-0 8850-420... 2-3 8850-60...3-23 8850-62...2-, 5-2 8850-63... 2-8850-66... 5-, 7-3, 2-8852-06... 2-4, 4-8, 4-9 8852-204... 2-8852-205... 5-2, 9-7, 3-2, 3-4 8852-206... 5-5 8852-208...3-7 8852-20... 2-3 8852-24... 5-8852-304... 9-9, 3-2, 3-3, 3-6,... 3-20, 3-2 8852-306... 2-3, 3-7 8852-30... 4-, 4-2, 4-7, 4-8, 4-9 8852-32... 2-3 8852-604... 2-8855-004...3-25 8855-007...2-, 5-2 8855-009... 5-, 5-2, 7-2, 7-4, 9-2,... 9-5, 0-8, 0-9, 3-4,... 3-7, 3-23 8855-00... 2-, 5-2, 5-5, 5-6, 7-5,... 9-8, 0-6, 0-8, 0-6,... 3-, 3-7, 3-9,... 3-20, 3-2, 3-23 8855-0... 2-3, 4-6, 4-8, 4-9, 5-3,... 7-3, 9-4, 0-6, 0-20,... 3-7, 3-9, 3-20 8855-02... 5-, 5-2, 9-3, 9-4 8855-03... 3-2, 4-, 4-8, 4-9, 5-2,... 5-5, 9-3, 9-5, 9-6, 9-7,... 3-9, 3-7 8855-05... 5-4, 0-6 8855-54... 2-3 8856-00... 9-2, 0-8 8856-002...4-7, 9-5 8856-003... 2-, 5-5, 5-6, 0-6, 0-8,... 0-6, -, 3-8856-004... 4-6, 0-6 8856-006... 5-5 8856-008... 5-4, 0-6 8856-009...3-24 8856-05... 3-3, 5-2, 3-3, 3-2 8856-07... 2-, 5-2, 7-4, 9-2, 0-9,... 3-23 8856-08... 4-5, 5-, 9-4, 3-2, -3
INDEX INTRODUCTION Part Number Index PART NUMBER PAGE PART NUMBER PAGE PART NUMBER PAGE... 3-4, 3-9, 3-20,...3-23 8856-09... 4-8, 4-9, 5-, 5-2, 3-7,... 3-9, 3-20 8856-... 3-3, 5-2 8856-3... 4-5, 7-8858-36... 4-7 8858-40... 9-6 8858-30...3-7 8858-320... 3-7, 3-9, 3-20 8858-325... 2-3 8859-09... 2-3 8859-036...3-8 8859-04... 2-3 8859-08... 2-3 8859-202... 9-3, 9-8 8859-204... 4-7, 5-2, 5-3, 6-, 7-4,... 9-2, 9-3, 9-4, 9-8, 9-9,...3-0 8859-205... 4-7, 6-, 9-6, 9-7, 9-8,... 3-7, 3-8 8859-206... 4-5, 5-, 9-4, 9-5, 9-6,... 9-7, 9-8 8859-207... 5-2, 5-3, 9-, 9-2, 9-3,... 9-4, 9-7, 3-8, 3-7 8859-209... 5-, 9-, 9-4 8859-20... 5-, 5-3, 9-, 0-6 8859-508... 9-4 8863-30... 3-4, 3-9 8863-302... 7-2 8863-338... 7-8863-449... 4-7 8863-509... 3-3 8863-300... 7-2 8866-00... 4-8, 4-9 8866-03... 4-5, 4-6, 4-7, 9-2, 0-6 8866-06... 4-6 8866-065... 3-2, 3-4, 3-9,...3-20 8866-084...0-6 8866-03... 9-4 8866-80... 4-6 8866-345... 5-5, 9-2 8866-362... 9-2 8866-364... 9-2 8866-365... 9-2 8866-384... 5-2, 9-3 8866-408... 5-5, 9-2 8866-2003... 9-3 8866-2005... 5-2, 6-, 9-2, 9-4, 9-9,...3-0 8866-2006...6-, 9-8 8866-2007...9-5, 9-6 8866-2008... 5-3, 9-, 9-2, 9-4 8866-200...5-, 9-8866-20...5-3, 9-8866-207... 9-3 8866-208...4-7, 9-8 8866-209... 4-5, 9-7, 9-8 8866-2020... 9-4 8866-2025... 9-8866-2026... 9-8 8866-206... 9-8866-2062... 9-8 8866-2064... 5-2, 7-4, 9-2, 9-3, 9-4,... 9-8, 3-0 8866-2065... 9-6, 9-7, 9-8 8866-2067... 9-8866-2084... 4-7, 5-3, 9-3, 3-0 8866-2087... 3-8 8866-2090...5-, 9-8866-205... 4-7, 4-8, 4-9, 5-3, 7-4,...9-2, 9-4, 9-7, 9-8,... 3-7 8866-206... 4-7, 6-, 9-, 9-2, 0-6 8866-207... 4-5 8866-208... 9-2, 3-8 8866-20... 3-8 8866-239... 7-4 8866-252...4-7, 7-4 8866-293...3-8 8866-2222... 9-4 8866-2224... 5-2, 6-, 9-2, 9-4 8866-2227...5-5, 9-2 8866-2239... 5-, 5-3, 9-, 9-2, 9-3,... 9-4, 3-0 8866-2240... 9-8 8866-2242...5-3, 9-2, 9-4, 3-8 8866-2244... 3-8 8866-2306... 9-4 8866-242...5-2, 9-4 8866-2425... 9-4 8867-00... 2-3, 3-, 3-3, 4-4, 4-5,... 9-4, 0-20, 3-7 8867-008...3-3, 4-7 8867-022... 4-7, 4-8, 4-9 8870-02... 2-3 8870-023... 9-7 887-00... 9-7 887-20... 9-7 887-280... 2-3 887-283... 5-4 887-284...5-2, 6-2 887-383... 3-5, 3-6 887-385... 5-2 887-20...3-7 887-2034... 3-5, 3-6 887-2305... 3-2, 3-4, 3-9,... 3-20 8882-004... 7-, 7-5, 3-4, 3-9 8998-036...3-23 9002-0247... 2-3 9002-552... 7-, 3-4, 3-9 9002-705...3-22 9002-2042... 9-8 9002-355... 9-4 9002-649... 2-2 9002-6803... -2 9002-6965... 4-5 9002-779... 9-7, 3-2, 3-4, 3-7,... 3-9, 3-20 9002-787... 5-, 5-2, 9-2, 9-4, 3-2,... 3-3, 3-4, 3-9,... 3-20, 3-2 9002-724... 3-4, 3-22, 3-23 9002-739... 3-4, 3-22, 3-23 9002-7470...3-, 3-2 9002-747... 3-, 3-2, 5-, 3-7,... 3-9, 3-20 9002-7473... 3-, 5-3, 6-, 3-7 9002-7684...5-, 7-2 9002-7906...5-3, 9-3 9002-7987... 7-, 7-5, 3-4, 3-9 9002-8482... 9-9002-8660...5-2, 5-4 9002-8662... 7-9002-8740... 2-3 9002-8935... 2-4 9002-8990... 4-5 9002-9935... 4-5 9002-9955... 3-22, 3-23, 3-24 9003-027...5-, 5-5 9006-3269... 4-0 905-300... 4-, 4-2, 4-4, 4-5, 4-6,... 4-7, 4-8, 4-9 9020-0003... 4-, 4-2, 4-7, 4-8, 4-9 9020-0284... 7-5 9020-0440... 6-3 9020-0445... 2-2 9020-0602... 3-9 9020-0638... 7-, 3-4, 3-9 9020-0680... 3-4 9020-0688... 2-2 -4
INDEX INTRODUCTION Part Number Index PART NUMBER PAGE PART NUMBER PAGE PART NUMBER PAGE 9020-0755... 2-9020-2230... 7-3 9020-2548... 6-6 9020-3040... 3-7, 3-9, 3-20 9020-3437...0-22 9020-3438...0-22 9020-3439...0-22 9020-3440...0-22 9020-3543... 6-5 9020-4007... 4-8, 4-9 9020-4097... 4-7 9020-4244... 4-5, 4-6, 4-7, 4-8, 4-9,... 3-2, 3-4, 3-9,...3-20 9020-4245... 4-5, 4-7, 4-8, 4-9, 3-2,... 3-4, 3-9, 3-20 9020-52... 4-5 9020-5792... 5-, 5-2, 9-3, 9-4 9020-5870... 3-, 3-2, 4-8, 4-9, 3-7 9020-589... 2-4 9020-598... 5-5 9020-669... 3-4, 3-6 9020-694... 3-2, 3-4, 3-7,... 3-9, 3-20 9020-695... 7-4 9020-696... 2-9020-699... 7-4, 9-9, 3-2, 3-4,... 3-7, 3-9, 3-20 9020-6548... 0-8 9020-6553... 0-8 9020-6846... 2-3 9020-7046... 4-9020-7204... 6-3 9020-7220...3-23 9020-7352... 2-4 9020-7458... 2-9020-7463... 9-7, 3-2, 3-4,...3-20 9020-7464... 9-6 9020-766... 3-3, 3-2 9020-779...3-0 9020-7856... 7-4 9020-7878... 4-5, 0-20 9020-7879... 4-5, 0-2 9020-7880... 4-5 9020-788... 4-5 9020-7882... 4-5 9020-7884... 4-4, 4-5 9020-7902... 3-3 9020-842...0-20 9020-843...0-20 9020-844...0-20 9020-845...0-20 9020-846...0-20 9020-847...0-20 9020-848...0-20 9020-849...0-20 9020-850...0-20 9020-85...0-20 9020-852...0-20 9020-853...0-20 9020-854...0-20 9020-855...0-20 9020-856...0-20 9020-857...0-20 9020-858...0-20 9020-859...0-20 9020-860...0-20 9020-86...0-20 9020-862...0-20 9020-863...0-20 9020-864...0-20 9020-865...0-20 9020-866...0-20 9020-867...0-20 9020-868...0-20 9020-869...0-20 9020-870...0-20 9020-87...0-20 9020-872...0-20 9020-873...0-20 9020-874...0-20 9020-875...0-20 9020-876...0-20 9020-877...0-20 9020-878...0-20 9020-879...0-20 9020-880...0-20 9020-88...0-20 9020-882...0-20 9020-883...0-20 9020-884...0-20 9020-885...0-20 9020-886...0-20 9020-887...0-20 9020-888...0-20 9020-889...0-20 9020-890...0-20 9020-8203...0-2 9020-8204...0-2 9020-8206...0-2 9020-8207...0-2 9020-8208...0-2 9020-8209...0-2 9020-820...0-2 9020-82...0-2 9020-822...0-2 9040-2478... 4-2 9040-2948...4-4, 4-5 9040-3056... 4-5 9040-3437...4-4, 4-5 9045-039... 4-6 9045-047...4-4, 4-5 9045-053... 4-4 9045-058... 4-, 4-2, 4-9 9045-3002... 4-, 4-0 9045-306... 4-5 9045-3030... 4-6 9045-303... 4-6 9045-3032... 4-6 9045-3034... 4-7 9045-3040... 4-4 9045-304... 4-4 9045-3045... 4-0 9045-50... 4-4 9045-502... 4-5 9045-5035... 4-6 9045-5037... 4-6 9045-5044... 4-7 9045-5049... 4-3 9045-505... 4-2 9045-5052... 4-2 9045-6002... 4-6 9045-6009... 4-2 9045-600... 4-2 9055-03... 4-7 9055-3005... 4-0 9055-3008... 4-0 9055-308... 4-0 9055-3026... 2-2 9055-3027... 2-9055-3028... 2-9055-400... 2-9055-5020... 4-3 9060-0273... 7-3 9060-0390... 4-, 4-0 9060-0832... 4-0 9060-0833... 4-0 9060-05... 4-0 9060-29... 4-0 9060-89... 4-0 9060-873... 4-0 9060-874... 4-0 -5
INDEX INTRODUCTION Part Number Index PART NUMBER PAGE PART NUMBER PAGE PART NUMBER PAGE 9060-2706... 4-5, 0-22 9060-2904... 4-4, 4-5 9060-2905... 4-4, 4-5 9080-353... 4-4, 4-5 900-306... 2-2 900-308... 2-2 900-3020... 2-2 900-303... 2-2 903-009... 2-3 903-04... 2-4 903-236... 3-, 3-2, 4-8, 4-9, 3-7 903-268... 2-903-27... 4-6 903-52... 3-4, 3-7 903-3029... 2-903-3038... 3-3, 4-7 903-3039... 4-7 903-3089... 2-903-304... 6-7 903-337... 5-5 903-338... 7-4, 9-4, 9-8 903-385...3-7 903-386... 3-, 3-2, 4-8, 4-9, 3-7 903-387...3-7 903-389... 3-903-3240... 0-8 903-337... -3 903-3320... 2-903-3380... 3-22, 3-23 903-3425...3-23 903-3445...3-7 903-3485... 2-903-4028... 6-6 903-439... 0-4 903-453... 0-, 0-4 903-4267... 0-2 903-4276... 0-, 0-3 903-4339... 0-4 903-4374... 4-6 903-4375... 4-6 904-322... 4-7 904-323... 4-7 904-324... 4-7 904-325... 4-7 904-326... 4-7 904-327... 4-7 904-356... 4-7 904-36... 4-7 904-362... 4-7 904-365... 3-3 904-45...3-7 904-732... 2-3 904-325... 4-5, 4-7, 4-8, 4-9, 3-2,... 3-4, 3-9, 3-20 904-326... 4-5, 4-6, 4-7, 4-8, 4-9,... 3-2, 3-4, 3-9,... 3-20 904-334... 2-2 904-335... 2-2 904-336... 2-2 904-346... 6-7 904-347... 3-4, 3-9, 3-20 904-374...3-2 904-386... 4-7 904-324... 7-5 904-322... 4-7 904-3222... 2-3 904-3237... 2-904-3246... 2-3 904-3298... 6-7 904-3429... 3-4, 3-7 904-3446...0-904-4274... 0-3 904-606... 4-7 904-6062... 4-7 905-3020... 5-3, 9-3, 9-4 905-349...3-22 905-3426... 9-, 9-2, 9-3, 9-7, 3-7 905-3450... 9-7, 3-7 905-4002...9-3, 9-4 906-3039... 9-4 906-3040... 9-4 906-406... 0-3 906-407... 0-3 908-087...3-7 908-48... 3-908-58... 5-908-7... 3-908-72... 3-, 3-7 908-76... 2-4 908-77... 2-3 908-8... 5-5 908-33... 4-8, 4-9, 9-5, 9-7 908-326... 3-7, 3-9, 3-20 908-332... 7-5 908-354... 7-908-368... 4-908-369... 4-908-388... 5-908-397... 3-908-45... 2-3 908-432... 4-8, 4-9, 9-5, 9-7 908-433... 9-5 908-437... 9-6 908-438... 9-6 908-445...0-0 908-447... 3-2, 3-7 908-457... 3-2 908-475... 2-908-499... 3-4 908-54... 5-5 908-577...4-8, 4-9 908-594...4-8, 4-9 908-622...4-8, 4-9 908-640... -5 908-654... 5-5 908-69... 2-3 908-309... 5-3 908-3050... 9-5 908-3063... 3-, 3-7 908-3069...0-6 908-3070...0-6 908-3085... 5-5 908-3094... 5-5 908-306... 5-, 5-2, 9-3, 9-4 908-324... 5-6 908-326... 5-6 908-328... 5-6, 3-0 908-336... 7-, 7-5, 3-4, 3-9 908-345... 9-908-355... 3-5, 3-6 908-373... 2-908-39... 9-4 908-394... 9-4 908-3200...0-6 908-326... 9-7, 3-3, 3-2 908-327... 9-6 908-328...5-, 5-2 908-3222... 5-3, 9-3, 9-4 908-3224... 9-5 908-3225... 9-5 908-3232... 9-908-3240...9-3, 9-5 908-3246...5-3, 9-908-3248...4-8, 4-9 908-3249... 4-7 908-3250... 5-8 908-3262...4-8, 4-9 908-3266...5-2, 9-4 908-3289... 2-908-3290... 9-7, 3-2, 3-4 908-3293... 9-908-3296...0-3 -6
INDEX INTRODUCTION Part Number Index PART NUMBER PAGE PART NUMBER PAGE PART NUMBER PAGE 908-3297... 3-2, 3-7 908-3298... 3-, 3-7 908-330...0-6 908-3304... 0-, 0-4 908-3306... 5-, 7-4, 9-4 908-3307... 3-2 908-330... 7-4 908-332... 7-5 908-334... 2-908-337... 2-908-3338... 5-908-3339... 9-3 908-3364... 5-5 908-3385... 6-7, 3-5 908-3425...3-0 908-3426...3-0 908-343...3-7 908-3432...3-7 908-3440... -2 908-3449... 2-3 908-3456... 5-2 908-3459...0-8 908-3468... 0-2 908-3470... 0-4 908-347... 4-8, 4-9 908-3473... 0-, 0-3 908-3480... 2-4 908-348... 5-2, -5 908-3482... 5-2, -5 908-3490...3-0 908-349... 5-4 908-3492... 2-908-3493... 5-908-3503... 5-2 908-3504... 5-2 908-35... 4-4, 4-5 908-353... 0-3, 3-7 908-358...0-6 908-359...0-6 908-352... 0-9 908-3533... 2-, 5-5 908-3536... 5-3, 9-908-3547... 3-4, 3-9 908-3550... 3-3, 3-2 908-3560... 5-8 908-356... 2-2 908-3562... 2-2 908-3573... 5-5 908-400... 5-908-4008... 0-6, 3-908-4009... 0-6, 3-908-402... 0-6, 3-908-4022...0-6 908-4032...0-4 908-4038... -2 908-4042...0-0 908-4043...0-0 908-4046... 6-2 908-4047... 6-2 908-435...0-3 908-436...0-3 908-437...0-3 908-438...0-3 908-439...0-3 908-440...0-3 908-44...0-3 908-442...0-3 908-443...0-3 908-444...0-3 908-445...0-3 908-455... 0-9 908-456... 0-9 908-457... 0-9 908-458... 0-9 908-459... 0-9 908-460... 0-9 908-46... 0-9 908-498... 5-5 908-499... 0-6, 3-908-420... 0-6, 3-908-4203... 0-6 908-424... 0-7 908-425... 0-7 908-428...0-3 908-4277... 0-6, 3-908-4278... 0-6, 3-908-4279... 0-6, 3-908-4284...0-8 908-4297...0-8 908-430...0-8 908-4302...0-8 908-4305... 0-5 908-4306... 0-2 908-43... 5-3 908-432... 5-3 908-4324...0-4 908-4330...0-4 908-4347... 0-2 908-4348... 0-2 908-435... 0-2 908-4352... 0-2 908-4368... 0-2 908-4369... 0-2 908-4370... 0-3 908-437... 0-3 908-4372... 0-3 908-4373... 0-3 908-4375...0-3 908-4376...0-3 908-4377...0-4 908-4378...0-4 908-4379...0-4 908-4380...0-4 908-438...0-4 908-4382...0-4 908-4383...0-4 908-4384...0-4 908-4385...0-4 908-4386... 0-9 908-4387... 0-9 908-4388... 0-9 908-5033... 4-908-5058... 4-9 908-507...3-0 908-509... 3-3 908-55... 3-9 908-525...3-3 908-528...3-2 908-539... 5-5 908-6055... 5-8 908-608... 7-, 3-4, 3-9 908-6085... 9-6 908-60... 3-908-602... 3-2 908-66... 4-908-62... 4-9 908-622...4-8, 4-9 908-63... 5-2 908-638...3-8 908-639...3-8 908-640...3-7 908-64...3-7 908-642...3-7 908-65... 3-3 908-652... 3-3 908-674... 5-5 908-675... 2-909-00... 5-2 909-308...3-5 909-303... - 909-3037... -4 909-4022...0-5 909-4033...0-5 -7
INDEX INTRODUCTION Part Number Index PART NUMBER PAGE PART NUMBER PAGE PART NUMBER PAGE 92-022...3-7 92-023...3-7 92-024...3-7 92-04...3-7 92-045...3-7 92-056...3-7 92-066...3-7 92-079...3-7 92-080...3-7 92-08... 3-2, 3-7 92-082...3-7 92-083...3-7 92-22...3-7 92-24... 4-92-25... 3-7, 3-9, 3-20 92-34... 3-7, 3-9, 3-20,...3-2 92-45...3-23 92-46...3-23 92-5...3-22 92-76...3-8 92-78...3-8 92-79...3-8 92-80...3-8 92-96...3-7 92-97...3-7 92-26...3-22 92-264... 0-8 92-283... 3-3, 3-2 92-307...3-8 92-308... 3-3 92-309... 3-3 92-30... 3-3 92-306... 3-7, 3-9, 3-20 92-308...3-7 92-309...3-7 92-302...3-7 92-3022...3-7 92-3037... 2-2 92-3038... 2-2 92-3042... 2-2 92-3043... 2-2 92-3054... 3-7, 3-9, 3-20,...3-2 92-3055...3-2 92-306... 3-2, 3-4, 3-9,...3-20 92-3062... 3-2, 3-6, 3-20 92-3075...3-0 92-308...3-8 92-3082...3-8 92-3085...3-8 92-3086...3-8 92-3089...3-8 92-3092... 2-3 92-39... 6-2 92-324...2-, 5-4 92-326... 7-3 92-327... 6-92-330... 6-92-332... 4-0 92-336...3-7 92-337...3-8 92-349... 9-2 92-350...0-6 92-354... 3-3, 3-2 92-355... 3-3, 3-2 92-368... 5-5 92-372... 2-92-377...3-22 92-38... -4 92-382... 3-5, 3-6 92-407... 0-92-4073... 0-92-4074... 0-92-4076... 0-3 92-4078... 0-3 92-4079... 0-4 92-408... 0-4 92-4082... 0-4 92-4087... 0-5 92-4088... 0-5 92-4089... 0-5 92-4090... 0-5 92-4094... 6-4 92-4096... 0-, 0-2, 0-3, 0-4,... 0-5 92-407... 2-92-408... 0-5 92-5002... 6-7 92-5003... 6-7 92-5030...3-7 92-503...3-7 92-5056... 3-8 92-5069...0-6 92-506... 3-4, 3-7 92-6008... 3-7, 3-9, 3-20 92-6009...3-7 92-600...3-7 92-6029...3-2 92-603...3-2 92-6032...3-2 92-607...3-7 92-6080... 3-9, 3-20 94-28... 2-94-259...3-22 94-329... 2-94-350... 4-7 94-364...3-23 94-429... -5 94-436... 2-94-459... 3-4, 3-6 94-480... - 94-5... 6-2 94-52...3-23 94-3055... 5-, 9-3, 9-4 94-305... 3-3, 3-2 94-308... -3, 3-22 94-37...3-23 94-320... 2-94-322... 5-2 94-327... -4 94-328... -4 94-333...0-6 94-344...0-6 94-362... 2-94-372... 6-, 0-6 94-382... 2-94-387... 9-9, 3-0 94-320...0-0 94-3202... 2-94-328...0-6 94-3269... 5-5 94-3280... 2-94-328... 2-94-3282... 4-7, 2-, 2-2 94-3283... 2-94-3284... 2-94-3285... 2-94-3286... 2-94-3288... 2-94-3290... 2-2 94-3292... 2-94-334... 5-2 94-335... 5-94-336... 5-4 94-333... -4, 3-5 94-3333... -4, 3-5, 3-24 94-3335... 3-5, 3-24 94-3342... 7-2 94-3357... 2-94-336...-4, 3-5, 3-6 94-3372...0-2 -8
INDEX INTRODUCTION Part Number Index PART NUMBER PAGE PART NUMBER PAGE PART NUMBER PAGE 94-405...0-8 94-4042... 0-5 94-4098...0-4 94-428... 0-, 0-3, 0-4, 0-5 94-458...0-94-490... 7-3 94-49... 7-3 94-492... 7-3 94-497... 7-2 94-4326... 6-2 94-4327... 6-2, 6-4 94-4328... 6-2 94-4329... 6-2 94-4332... 6-2 94-4333... 6-5 94-4334... 6-5 94-4335... 6-5 94-4336... 6-5 94-4337... 6-5 94-4338... 6-5 94-4339... 6-5 94-4340... 6-5 94-434... 6-5 94-4342... 6-5 94-4343... 6-5 94-4344... 6-5 94-4345... 6-5 94-4346... 6-5 94-4347... 6-5 94-4348... 6-5 94-4349... 6-5 94-4350... 6-5 94-435... 6-5 94-4352... 6-5 94-4353... 6-5 94-4354... 6-5 94-4355... 6-5 94-4356... 6-5 94-4357... 6-5 94-4358... 6-5 94-4359... 6-5 94-4360... 6-5 94-436... 6-5 94-4362... 6-5 94-4363... 6-5 94-4364... 6-5 94-4365... 6-5 94-4366... 6-5 94-4367... 6-5 94-4368... 6-5 94-4369... 6-4 94-4370... 6-4 94-437... 6-4 94-4372... 6-4 94-4373... 6-4 94-4374... 6-4 94-4376... 6-4 94-4377... 6-4 94-4378... 6-4 94-4379... 6-4 94-4380... 6-4 94-438... 6-4 94-4382... 6-3 94-4383... 6-3 94-4384... 6-3 94-4385... 6-3 94-4386... 6-3 94-4387... 6-3 94-4388... 6-3 94-4389... 6-3 94-4390... 6-3 94-439... 6-3 94-4392... 6-3 94-4393... 6-3 94-4394... 6-3 94-4395... 6-3 94-4396... 6-3 94-4397... 6-3 94-4398... 6-3 94-4399... 6-3 94-4400... 6-3 94-440... 6-3 94-4402... 6-3 94-4403... 6-3 94-4404... 6-3 94-4405... 6-3 94-4406... 6-3 94-4407... 6-3 94-4408... 6-3 94-443... 7-2 94-4432... 7-2 94-4433... 7-2 94-4439... 2-94-4442... 6-4 94-4448... 7-3 94-4458... 7-3 94-4459...0-2 94-4460...0-2 94-446...0-2 94-4462...0-2 94-4463...0-2 94-4464...0-2 94-4465...0-2 94-4466...0-2 94-4467...0-2 94-528... 3-5 94-6052... 3-2, 3-7 94-6053... 4-7 94-6054... 4-7 94-6058... 5-2 94-608... 2-94-6099... 3-4, 3-24 94-60... 5-94-602... 7-5 94-608... 7-5 95-303... 5-4 95-506... 5-4 96-20...0-6 96-302... 7-3 96-3028... 2-96-3044...0-5 96-3087... 2-96-3093... 7-5 96-3098...5-2, 9-4 96-309... 7-4 96-32... 3-8 96-329... 5-6 96-330... 2-96-384... 2-96-39... 3-8 96-320... 5-2, 9-3, 9-4 96-3260... 5-96-3268... 5-8 96-4023... 0-2 96-4086... 2-2 96-4087... 2-2 96-4094... 2-2, 2-96-4096... 3-2 96-402... 3-3 96-409...0-5 96-40...0-5 96-4...0-5 96-6062... 3-3 920-4460... 0-5 92-3002...8-, 9-8 930-09... 9-7 930-020... 7-930-065...3-0 930-083... 4-8 930-086... 5-5 930-3006... 9-6 930-3007... 9-7 930-3008... 9-7 -9
INDEX INTRODUCTION Part Number Index PART NUMBER PAGE PART NUMBER PAGE PART NUMBER PAGE 930-3009... 9-6 930-309... 3-2, 3-6, 3-20 930-302... 2-930-3037...0-7 930-3038...3-0 930-304...3-0 930-3047... 2-930-3049... 9-4 930-3056... 5-930-400...0-7 930-402...0-7 930-4022...0-7 930-4023...0-7 930-4025...0-7 930-4026...0-7 930-506... 4-8 930-6030... 4-8 932-3022... 5-, 9-932-3023... 5-, 9-932-3030... 2-933-002... 5-933-04... 5-2 933-08...0-9 933-020... 5-933-3002... 5-933-3003... 5-933-3004... 5-2, 9-3 933-303... -2 933-3023...0-6 933-3029...3-8 933-303... 5-, 5-2, 5-3 933-3036... 2-2 933-3043... 7-3 933-4003... 2-2 933-4004... 2-2 933-4005... 2-2 933-4008... 3-933-4009... 3-933-400... 3-933-40... 3-933-402... 3-2 933-404... 3-933-405... 3-933-407... 3-933-408... 3-, 3-2 933-4024... 3-933-4028... 3-933-4030... 3-933-403... 3-933-4032... 3-933-4033... 3-, 3-2 933-4035... 3-933-4038... -2 933-5020...0-9 933-5033... 5-933-6003... 5-2 933-6004... 5-934-02...3-22 934-03...3-22 934-303...3-22 934-3040... 3-6 934-3052... 2-3 934-3074... -4 934-4006... 3-3 934-4009... 3-934-40... 3-2 934-403... 3-2 934-404... 3-2 934-405... 3-2 934-406... 3-2 934-407... 3-2 934-408... 3-2 934-409... 3-2 934-4020... 3-2 934-402... 3-2 934-4022... 3-2 934-4023... 3-2 934-4024... 3-2 934-4025... 3-2 934-4026... 3-2 934-4027... 3-2 934-4028... 3-2 934-4029... 3-2 934-4030... 3-2 934-403... 2-2, 3-2, 3-3 934-4032... 3-2 934-4033... 3-2 934-4043... 3-2 934-4045... 3-2 934-4046... 3-2 934-4047... 3-2 934-5008... 5-2 934-500... 3-2, 3-6, 3-20 934-503...3-22 936-00...3-23 936-002...3-23 936-003...3-23 936-004...3-23 936-005... 2-936-008... - 936-08... 3-5, 3-24 936-3002... 9-9 936-3008...3-23 936-3009...3-23 936-302... -2, -3 936-3025... 7-3 936-3026...0-9 936-3027...0-9 936-3028...0-9 936-3029... 5-936-3030...0-9 936-303... 5-936-3034... -4 936-3035... -3 936-3036... 7-936-3040...3-6 936-3043... 3-2, 3-6, 3-20 936-3045... 3-2, 3-20 936-3054... -3 936-3065... 2-936-3066... 5-2 936-3070... 2-936-3073...3-23 936-3087...3-23 936-328... 2-936-340... 2-936-4004... -4 936-4005... -4 936-4006... -4 936-4007... -4 936-4008... -4 936-4009... -2, -3 936-400... -3 936-40... -3 936-402... -3 936-403... -3 936-404... -3 936-503... -3 936-504... 5-936-507... 3-6 936-5045...3-23 936-6007... 3-2, 3-6, 3-20 937-3009... 5-2 937-30...3-24 937-5005...3-24 938-009... 0-6, 3-938-3039... 3-4, 3-7, 3-9,... 3-20 938-305...3-5 938-3054... 9-4 938-3055... 9-4 938-3056... 9-4 938-3057... 9-4 -20
INDEX INTRODUCTION Part Number Index PART NUMBER PAGE PART NUMBER PAGE PART NUMBER PAGE 938-3059... 9-4 938-3060... 9-4 938-306... 9-4 938-3065... 5-7 938-3075... 0-5 938-3076... 0-7 938-400... 5-7 938-40... 2-938-5004...3-23 938-5008... 3-4, 3-9 938-5009... 7-938-506... 3-7, 3-8 938-5020... 5-, 5-2, 5-3 938-5022... 9-4 938-5024...3-5 938-6002... 2-938-6006... 3-4, 3-9 938-6007... 7-938-6009... 2-3 938-600... 2-3 939-3003... 9-3 939-3007...3-5 939-5006...3-5 939-5007... 5-, 5-2, 5-3 940-08... 2-3 940-303... 2-3 940-3033... 2-3 940-3034... 2-3 940-3065... 2-3 940-3066... 2-3 940-3067... 2-3 940-3078... 2-3 940-3082... 2-3 940-302... 5-, 5-7 940-303... 5-, 5-7 940-345... 2-3 940-346... 2-3 940-362... 2-3 940-363... 2-3 940-364... 2-3 940-365... 2-3 940-366... 2-3 940-3230... 2-940-3372... 2-3 940-352... 5-6 940-354...0-4 940-3574... 2-940-402...0-4 940-4024...0-4 940-4025...0-4 940-4026...0-4 940-4027...0-4 940-4029...0-4 940-4030...0-4 940-403...0-4 940-4033...0-4 940-4034...0-4 940-4035...0-4 940-4038...0-4 940-4040...0-5 940-404...0-5 940-4042...0-5 940-4043...0-5 940-4044...0-5 940-4046...0-5 940-4047...0-5 940-4048...0-5 940-4049...0-5 940-4050...0-5 940-405...0-5 940-4053...0-5 940-4054...0-5 940-4055...0-5 940-4056...0-5 940-4057...0-5 940-4058...0-8 940-4059...0-8 940-4060...0-8 940-406...0-8 940-4062...0-8 940-4063...0-8 940-4064...0-8 940-4065...0-8 940-4066...0-8 940-4067...0-8 940-477...3-940-478... 0-6, 3-940-479... 0-6, 3-940-480... 0-6, 3-940-48... 0-6, 3-940-483... 0-6, 3-940-484... 0-6, 3-940-485... 0-6, 3-940-490... 0-6, 3-940-424... 0-6, 3-940-6099...2-3, 9-4 94-4004... 6-6 94-4005... 6-6 94-4006... 6-6 94-4007... 6-6 94-4008... 6-6 94-4009... 6-6 94-400... 6-6 94-40... 6-6 94-402... 6-6 94-403... 6-6 94-404... 6-6 94-405... 6-6 94-406... 6-6 94-407... 6-6 94-408... 6-6 94-409... 6-6 94-4020... 6-6 94-402... 6-6 94-4022... 6-6 94-4023... 6-6 94-4024... 6-6 94-4025... 6-6 94-4026... 6-6 94-4027... 6-6 948-000... 2-3 948-0002... 2-3 948-005... 5-6 948-006... 9-2 948-300... 2-2 948-3004...3-948-30... 5-8 948-302... 0-6 948-303... 2-2 948-304... 2-2 948-305... 5-6 948-3020... 6-6 948-302... 9-8 948-3022... 9-8 948-3023... 9-4 948-3024... 2-3 948-3025... 0-948-3026... 2-948-3027... 2-948-3028... 2-948-3029... 2-948-3030... 2-948-303... 2-948-3032... 2-948-3033... 2-948-3034... 2-948-3035... 2-948-3036... 3-, 3-2, 3-3, 3-4,... 3-5 948-3037... 2-948-3038... 2-948-3039... 2-948-3040... 2- -2
INDEX INTRODUCTION Part Number Index PART NUMBER PAGE PART NUMBER PAGE PART NUMBER PAGE 948-304... 5-8 948-3042... 2-948-3043... 2-948-3044... 2-948-3045... 2-948-3046... 2-948-3047... 2-948-400... 2-2 948-4002... 2-2, 2-948-4003... 2-2, 3-3 948-4004... 2-2, 3-3 948-4005... 2-2, 3-948-4006... 6-6 948-4007... 6-6 948-4008... 6-6 948-4009... 6-6 948-400... 6-6 948-40... 0-948-402... 0-948-403... 2-948-404... 2-948-405... 2-948-406...3-948-407...3-948-408... 3-2 948-409... 3-948-4020... 3-948-402... 3-948-4022... 3-2 948-4023... 3-2 948-4024... 3-2 948-4025... 3-3 948-4026... 3-2 948-4027... 3-3 948-4028... 3-2 948-4029... 3-2 948-4030... 3-2 948-403... 3-2 948-4032... 3-3 948-4033... 3-3 948-4034... 3-2 948-4035... 3-2 948-4036... 3-2 948-5003... 3-4, 3-5 948-5007... 2-, 2-2 948-5008...3-2 948-5009...3-20 948-50...3-0 948-502...3-6 948-503...3-4 948-504...3-9 948-508... 6-948-5020...3-7 948-600... 2-948-6006... 2-948-6007... 2-948-6008... 2-948-60...2-3, 9-4 -22
CHASSIS & ATTACHING PARTS Frame Shrouding & Trim Revised 03-3-06 JD * Changed part number on item 23. 2-
CHASSIS & ATTACHING PARTS Frame Shrouding & Trim Revised 03-3-06 948-600 Ref FRAME WELDMENT 8820-06 HEX HD CAPSCREW, 5/6-8X/2, 2 9020-696 64" TRIM-LOK, (pre-packaged in 25' lengths) 3 A/R ADHESIVE 4 8368-329 MIRROR 5 948-6006 RADIATOR COVER 6 92-372 GRAB HANDLE 7 9020-0755 24" WEATHERSTRIP, (pre-packaged in 35' rolls) 8 774-3003 45 WHIZ LOCK SCREW, 5/6-8X5/8 9 9020-7458 3 DRAW LATCH 0 8830-93 2 ROUND HEAD MACHINE SCREW, #0-32X/2 8855-007 7 LOCKWASHER, #0 2 8850-63 6 HEX NUT, #0-32 3 908-675 TANK COVER 4 936-3065 HOSE GUARD, (located under dash panel, beneath steering column, not shown) 5 8855-00 LOCKWASHER, 5/6 6 774-3006 7 WHIZ LOCKNUT, 5/6-8, (use 2 with item 4, not shown) 7 908-373 5 RUBBER HD SCREW BUMPER 8 8850-62 5 HEX NUT, #0-24 9 94-28 HINGE 20 8852-604 2 HEX LOCKNUT, #8-32 2 8856-003 9 FLAT WASHER, 5/6 22 92-324 4 WHIZ LOCK SCREW, 5/6-8X/2 * 23 948-06 ENGINE COVER 24 930-302 T-HANDLE 25 8830-073 2 RD HD MACHINE SCREW, #8-32X3/4 26 Ref OPEN CAB ASSEMBLY, (see page 2-2 for details) 27 940-3574 BACK-UP ALARM 28 8820-06 2 HEX HD CAPSCREW, 5/6-8X/2, 29 908-3289 COUNTERWEIGHT PLATE 30 948-6007 DECK COVER 3 852-088 2 RUBBER BUMPER 32 94-436 REAR CAB COVER 33 8820-050 2 HEX HD CAPSCREW, 7/6-4X, 34 903-3029 SEAT BELT, (not used with optional seat) 35 8850-007 2 HEX NUT, 7/6-4 36 903-3485 SEAT W/ARMREST, (std) 92-407 SLIDE ADJ KIT, (used with std seat) 904-3237 GRAMMER SEAT, (opt) 8820-020 4 HEX HD CAPSCREW, 5/6-8X,, (use with opt seat) 37 774-3006 8 WHIZ LOCK NUT, 5/6-8 38 908-475 HEATER COVER PLATE 39 94-329 VALVE ACCESS COVER 40 936-005 BELLY PAN 4 908-3533 0 FENDER WASHER, -/2, O.D. 42 940-3230 MANUAL CASE 43 774-303 4 WHIZ LOCK NUT, /4-20 44 8320-58 4 HEX HD CAPSCREW, 7/8-9X-3/4, (torque to 450-475 ft lbs) 45 903-3320 TILT GAGE 46 8820-492 HEX HD CAPSCREW, /4-20X, 47 8856-07 FLAT WASHER, /4 48 8852-204 HEX LOCKNUT, /4-20 49 7738-38 4 HARDENED WASHER, 7/8 50 94-3357 HORN, (includes items 5 & 52) 5 94-4439 HORN BRACKET 52 NUT 53 8668-322 TIE STRAP 54 94-608 DIP-STICK COVER 55 8826-04 4 SOCKET BUTTON HD CAPSCREW, /4-20X/2 56 938-6002 SHEET METAL SUPPORT 57 938-40 GRADALL MATERIAL HANDLER SAFETY MANUAL 58 903-268 EMI ROUGH TERRAIN FORKLIFT SAFETY MANUAL 59 948-404 OPERATOR'S MANUAL 60 2460-472 GRADALL/EMI OPERATOR ORIENTATION VIDEO 6 948-403 PARTS MANUAL 62 7733-004 ENGINE MANUAL 63 9055-400 PLATFORM MANUAL 64 948-405 SERVICE MANUAL NOTE: ONLY ITEMS WITH PART NUMBERS ARE AVAILABLE FOR SERVICE. JD * Changed part number on item 23. 2-
CHASSIS & ATTACHING PARTS (948-300) Open Cab 948-300 Ref OPEN CAB, (includes all items) 948-400 CAB WELDMENT 2 948-4002 SERIAL TAG 3 933-4003 2 WINDOW CLIP, FLAT 4 948-4003 REAR WINDOW 5 948-4004 RH SIDE WINDOW 6 96-4086 3 HOLE PLUG,.33 7 96-4087 HOLE PLUG,.750 8 933-4004 8 SCREW, #0-32X 9 934-403 9.5' SEAL 0 96-4094 ROPS WARNING 933-4005 2 WINDOW CLIP 2 948-4005 AR POWER BOND 3 8036-4009 AR HI VISCOSITY URETHANE 2-2
FRAME & ATTACHING PARTS Rear Axle & Attaching Parts 25 2 4 6 3 5 24 3 7 8 9 8 23 UPPER 22 2 20 9 9 2 0 4 3 8 7 LOWER 3 4 5 6 ENLARGED VIEW 39 37 38 40 39 42 0 44 46 33 34 35 0 36 UPPER 52 LOWER 45 50 47 53 5 48 60 26 27 3 32 8 48 28 3 55 43 49 54 56 57 58 59 Front of Machine 30 29 2-3
FRAME & ATTACHING PARTS Rear Axle & Attaching Parts NOTE #: Cylinder base end must be free to rotate. Shim Steering Cylinder base end as required to maintain a total maximum gap of /6". NOTE #2: Shim bottom Knuckles as required to maintain no more than /32" movement. Shim top Knuckles to maintain no more than /6" gap. Must have a minimum of one shim. NOTE #3: Install 5/8 long thread on Stud into Drive Hub (shortest length threads on Stud) 94-5040 AR STEERING CYLINDER PIN KIT, (includes one each of items thru 8, one kit needed for each side) 8852-32 2 LOCKNUT, 3/4-0, (torque to 60-75 ft-lbs) 2 908-45 2 DIRT SHIELD 3 904-732 2 SPACER 4 8859-09 2 O-RING 5 8859-04 2 O-RING 6 934-3052 2 ROD END STEER CYLINDER PIN 7 940-362 2 HARDENED WASHER 8 8850-420 2 HEX JAM NUT, -/4-2, (torque to 280-305 ft-lbs) 9 940-3082 2 TIE ROD PIN 0 8855-0 8 LOCKWASHER, 3/8 8320-02 2 HEX HD CAPSCREW, 3/8-6X3 2 8852-306 2 HEX LOCKNUT, 3/8-6 3 940-345 8 WIPER SEAL 4 940-3034 2 LOWER BUSHING 5 940-346 2 O-RING 6 8859-08 2 O-RING 7 940-08 2 THRUST BUSHING 8 938-6009 REAR AXLE WELDMENT, (includes items 4, 23 & 28) 9 940-363 AR KINGPIN SHIM, (see note # 2) 940-364 AR KINGPIN SHIM, (see note # 2) 940-365 AR KINGPIN SHIM, (see note # 2) 940-366 AR KINGPIN SHIM, (see note # 2) 20 940-3078 2 LOWER KINGPIN 2 940-3067 2 RETAINING WASHER 22 882-068 2 SOCKET HD CAPSCREW, 3/8-6X5/8, GR8 23 940-303 2 UPPER BUSHING 24 948-3024 2 UPPER KINGPIN 25 8858-325 2 SNAP RING 26 92-3092 4 STUD, (see note #3) 27 8540-340 4 HARD WASHER 28 940-3033 2 PIVOT TUBE BUSHING 29 Ref DRIVE HUB, (524D), (see page 6-6 for details) Ref NON-DRIVE HUB, (522D), (see page 6-6 for details) 30 948-0002 R.H. KNUCKLE 3 8850-0 2 HEX NUT, 5/8-32 882-232 2 SOCKET HD CAPSCREW, 5/8-X3-3/4, GR8 33 9002-8740 2 GREASE FITTING, FEMALE 34 8870-02 2 NIPPLE, /8X2 35 8850-006 2 HEX NUT, 3/8-6 36 8320-44 2 HEX HD CAPSCREW, 3/8-6X5-3/4 37 940-3372 2 BASE END STEER CYLINDER PIN 38 887-280 2 HEX SOCKET PIPE PLUG, /8 39 940-3065 AR KINGPIN SHIM, (see note # ) 940-3066 AR KINGPIN SHIM, (see note # ) 40 Ref STEERING CYLINDER, (see page0-5 for details) 4 948-60 L.H. TUBE SUPPORT 940-6099 R.H. TUBE SUPPORT 42 8820-035 4 HEX HD CAPSCREW, 3/8-6X, 43 882-2285 2 SOCKET HD CAPSCREW, 3/4-0X5, GR8 44 882-2272 2 SOCKET HD CAPSCREW, 5/8-X8, GR8 45 8852-20 2 HEX LOCKNUT, 5/8 46 948-000 L.H. KNUCKLE 47 904-3246 2 SELF-ALIGNING BUSHING, (tie rod) 48 8867-00 4 LUBE FITTING, STRAIGHT, /8 49 938-600 TIE ROD WELDMENT, (includes item 47) 50 8668-572 2 HARDENED WASHER, 3/4 5 8320-006 2 HEX HD CAPSCREW, 3/4-0X2 52 904-3222 4 2 POINT SCREW, 3/4-0X2 53 8855-54 2 LOCKWASHER, 3/4, (hi-collar) 54 908-77 REAR AXLE PIN 55 9002-0247 HEX HD CAPSCREW, -/4-7X6, 56 850-098 LOCKNUT, -/4-7 57 908-69 SHIM, (.046 thick) 58 903-009 SHIM, (.0598 thick) 59 9020-6846 SHIM, (.345 thick) 60 908-3449 4 HEX NUT, /2-3 2-3
CHASSIS & ATTACHING PARTS Front Axle Mounting Revised 2-2-06 * Ref FRONT AXLE, (see page 6-2 for details) 2 908-76 FRONT SWAY PIN 3 9020-589 2 SPACER 4 903-04 SHIM WASHER 5 8320-72 HEX HD CAPSCREW, -8X5, GR8 6 8852-06 HEX LOCKNUT, -8 7 908-3480 SHIM WASHER 8 940-3225 PIN 9 9002-8935 2 RETAINING RING JD * Changed part number on item 8. 2-4
BOOM 2 Section Boom (std) First Boom Section 908-60 FIRST BOOM SECTION 2 908-48 BOOM BASE PIN 3 8820-07 HEX HD CAPSCREW, 5/8-X5 4 8852-00 HEX LOCKNUT, 5/8-5 8820-532 8 HEX HD CAPSCREW, 3/8-24X3/4,, (torque to 32-37 ft lbs) 8820-533 AR HEX HD CAPSCREW, 3/8-24X7/8,, (torque to 32-37 ft lbs) 6 9002-7470 8 HARDENED FLATWASHER, 3/8 7 903-386 2 BEARING PAD 8 903-236 4 SPACER 9 9020-5870 4 SHIM 0 903-389 2 BEARING PAD 8820-568 4 HEX HD CAPSCREW, /2-20X2,, (torque to 68-78 ft lbs) 8820-569 AR HEX HD CAPSCREW, /2-20X2-/4,, (torque to 68-78 ft lbs) 2 9002-747 4 HARDENED FLATWASHER, /2 3 908-3063 2 BEARING PAD 4 908-72 2 SPACER 5 908-7 2 SHIM 6 908-3298 2 BUSHING 7 908-397 BEARING PLATE 8 8820-607 2 HEX HD CAPSCREW, 3/4-6X-/4, 9 9002-7473 2 WASHER 20 8867-00 2 LUBE FITTING, STRAIGHT, /8 3-
BOOM 2 Section Boom (std) Second Boom Section 908-602 SECOND BOOM SECTION 2 8820-564 4 HEX HD CAPSCREW, /2-20X,, (torque to 68-78 ft lbs) 3 9002-747 4 HARDENED WASHER 4 908-3297 2 BEARING PAD 5 908-447 2 SPACER 6 92-08 AR SHIM 7 8820-532 4 HEX HD CAPSCREW, 3/8-24X3/4,, (torque to 32-37 ft lbs) 8820-533 AR HEX HD CAPSCREW, 3/8-24X7/8,, (torque to 32-37 ft lbs) 8 9002-7470 8 HARDENED FLAT WASHER 9 903-386 2 BEARING PAD 0 903-236 2 SPACER 9020-5870 2 SHIM 2 8820-537 4 HEX HD CAPSCREW, 3/8-24X-3/4,, (torque to 32-37 ft lbs) 3 908-457 2 SPACER 4 908-3307 2 BEARING PAD 5 94-6052 PIN WELDMENT 6 8855-03 LOCKWASHER, /2 7 8820-065 HEX HD CAPSCREW, /2-3X 8 8362-283 SPECIAL WASHER 3-2
BOOM (908-509) Quick Switch Assembly 908-509 QUICK SWITCH ASSEMBLY, (includes items thru 6, 5 and 6) 908-652 QUICK SWITCH WELDMENT 2 908-65 PLUNGER WELDMENT 3 9020-7902 QUICK RELEASE PIN 4 903-3038 JACK CHAIN, 5" LONG, SIZE 2 5 8863-509 ROLL PIN, /4X2 6 8867-008 LUBE FITTING, STRAIGHT, /4-28 7 Ref SECOND BOOM SECTION, (see page 3-2) 8 936-3085 2 BUSHING 9 92-308 HEX HD CAPSCREW, 5/8-X5, 0 904-365 HEAD PIN 92-309 HEX LOCKNUT, 5/8-, (torque to 85-200 ft lbs) 2 96-6062 TILT CYLINDER PIN 3 8320-23 2 HEX HD CAPSCREW, /2-3X, GR8 4 8856-2 WASHER, /2 5 8830-93 ROUND HD MACHINE SCREW, #0-32X/2 6 8856-05 FLAT WASHER, #0 7 92-30 2 WASHER, 5/8 8 8867-00 2 LUBE FITTING, STRAIGHT, /8 3-3
ATTACHMENTS (908-5033) 48" Tilt Carriage Assembly NOTE: MANY DIFFERENT FORK ASSEMBLIES ARE AVAILABLE FOR THE CARRIAGE ASSEMBLIES USED ON 522D/524D LO-PRO. PLEASE SEE FORK INFORMATION ON PAGE 4-0 FOR A LIST OF FORKS. Item 908-5033 Ref 48" TILT CARRIAGE ASSY, (includes items thru 4) 908-66 CARRIAGE WELDMENT 2 9045-058 FORK PIN 3 9020-0003 2 COLLAR 4 8820-05 2 HEX HD CAPSCREW, 5/8-X4, 5 8852-30 2 HEX LOCKNUT, 5/8-6 908-369 HEAD PIN 7 908-368 RETAINER BAR 8 8820-066 2 HEX HD CAPSCREW, /2-3X-/4, 9 9020-7046 TILT PIN 0 905-300 SERIAL NUMBER PLATE 8834-022 4 DRIVE SCREW, #0X3/8 2 8855-03 2 LOCKWASHER, /2 3 92-24 SLEEVE 4 9045-3002 2 FORK, (see note) 9060-0390 2 CUBING FORK 4-
ATTACHMENTS (9045-505) & (9045-5052) Q.S. Carriage Assemblies NOTE: MANY DIFFERENT FORK ASSEMBLIES ARE AVAILABLE FOR THE CARRIAGE ASSEMBLIES USED ON 522D/524D LO-PRO. PLEASE SEE FORK INFORMATION ON PAGE 4-0 FOR A LIST OF FORKS. 9045-505 48" CARRIAGE ASSEMBLY, (includes items thru 7) 9045-6009 CARRIAGE WELDMENT 2 9045-058 FORK PIN 3 9020-0003 2 COLLAR 4 8820-05 2 HEX HD CAPSCREW, 5/8-X4, 5 8852-30 2 HEX LOCKNUT, 5/8-6 905-300 SERIAL NUMBER PLATE 7 8834-022 4 DRIVE SCREW, #0X3/8 9045-5052 66" CARRIAGE ASSEMBLY, (includes items thru 7) 9045-600 CARRIAGE WELDMENT 2 9040-2478 FORK PIN 3 9020-0003 2 COLLAR 4 8820-05 2 HEX HD CAPSCREW, 5/8-X4, 5 8852-30 2 HEX LOCKNUT, 5/8-6 905-300 SERIAL NUMBER PLATE 7 8834-022 4 DRIVE SCREW, #0X3/8 4-2