TEXTRON Lycoming AIRCRAFT ENGINES O-60-AP Wide Cylinder Flange Crankcase Model Engines PARTS CATALOG PC-06-6 MARCH 99
0-60-AP PARTS CATALOG This illustrated parts catalog contains a complete parts listing forthetextron Lycoming O-60-AP wide cylinder flange crankcase model aircraft engines. Major assembly and sub-assembly parts of the engines are listed in the Group Assembly sections in the general sequence of engine build up. A Service Kits section and Oversize and Undersize Parts List are included to aid in ordering parts as necessary during overhaul. The Numerical Index is provided for convenience in finding parts when only the part number is known. Parts coverage of Vendor Accessories used on Textron Lycoming engines may be found in the appropriate Vendor's Parts Catalog. A list of addresses of where to obtain these publications appears in the latest edition of Service Letter No. L. NOTE The illustrations, pictures and drawings shown in the publication are typical of the subject matter they portray. This catalog, when used in conjunction with the appropriate overhaul manual, shall be used for parts identification only. Under no circumstance shall this catalog be used as an assembly or installation document. Any reference in this document to a suppliers/parts manufacturers product, by name, trademark, part number or other description is solely for the purposes of identification and does not indicate or infer that Textron Lycoming accepts responsibility for quality control and/or airworthiness of parts which do not pass through the Textron Lycoming quality control system. All Textron Lycoming Reciprocating Engine Division publications will bear the copyright notice Textron Lycoming 96, "All Rights Reserved", and all Textron Lycoming publications are to be considered copyrighted and may not be reproduced without permission of the company. SERVICE BULLETINS, INSTRUCTIONS AND LETTERS Although the information contained in this parts catalog is up-to-date at time of publication, users are advised to procure current information through all Textron Lycoming distributors or from the factory by subscription. Consult the latest edition of Service Letter No. L for subscription information. HOW TO ORDER PARTS In ordering parts for your engine, observe the following instructions which will expedite shipment of correct parts required without delay. a. Always specify the model and serial number of your engine. b. Always specify part number, nomenclature and quantity required. i
0-60-AP PARTS CATALOG TABLE OF CONTENTS SECTION PAGE Introduction... i Table of Contentsii... Oversize and Undersize Parts Listing... iii. CRANKCASE, CRANKSHAFT AND CAMSHAFT GROUP Crankcase Assem bly... - Oil Level Gage Assembly... - Camshaft Assembly...... - Crankcase Related Parts... -5 Crankshaft Assembly and Related Parts...... -7 Propeller Governor Drive (Crankcase)... -9 Crankshaft Idler Gears... - Crankcase Attaching Parts... -i. ACCESSORY HOUSING AND RELATED PARTS Accessory Housing Assembly... - Oil Pump and Accessory Housing Attaching Parts...... - Fuel Pum p and Prop. Governor Drive Covers...... -5 Vacuum Pum p Drive and Cover... -7 Oil Pressure Screen and Oil Cooler Bypass Valve...... -. CYLINDER, PISTON AND VALVE TRAIN Connecting Rods, Pistons and Ring Assemblies...... - Cylinder Assembly...... - Cylinder Related Parts... - Valve Assembly...... -5 Cylinder Head Drain Tubes and Intercylinder Cooling Baffles... -7. IGNITION SYSTEM Magnetos, Drives, Harnesses and Spark Plugs... - 5. ELECTRICAL COMPONENTS Alternator Assembly and Belt... 5- Starter M otor and Attaching Parts... 5- Alternator M ounting and Attaching Parts...... 5-6. OIL SUMP AND INDUCTION SYSTEM Oil Sum p Assembly and Oil Suction Screen...... 6- Intake Pipes and Attaching Parts... 6- Carburetor Assembly... 6- Priming System...... 6-5 7. SERV ICE K IT SECTION... 7-. NUMERICAL INDEX...... - ii
0-60-AlP PARTS CATALOG Oversize and Undersize Parts Listing Part No. Description Oversize P0 P05 P0 P5 P0 P0 P0.00.005.00.05.00.00.00 P50.050 Undersize M0 M06 M0.00.006.00 66 6660 66796 69796 7057 705 755-S 757 70 7 75656-S 790-S LW-5 LW-79 LW- LW-67 STD-065 A9 GUIDE BUSHING INSERT DOWEL SEAT SEAT BUSHING RING GUIDE RING BUSHING BUSHING BEARING SEAL BEARING BEARING DOWEL BEARING See Latest Edition of Service Instruction No. 56. X X X X X X X X X X X X X See Latest Edition of Service Instruction No. 56. X X X Edition of Service Instruction No.. I Edition of Service Instruction No. 77. X X X X* X* X* X X X X X X * Also available in P0 oversize. In addition to the above, studs are available in P0, P07 & P. NOTE When ordering oversize and undersize parts, be sure to specify the required oversize and undersize dimension along with the proper part number. For example, to order bearing LW- in.00 undersize, order part number LW--M. Oversize code letter is "P" while undersize code letter is "M". These letters are then followed by the number designating the size in thousandths of an inch. iii
TEXTRON Lycoming 0-60-AP PARTS CATALOG CRANKCASE, CRANKSHAFT AND CAMSHAFT GROUP CRANKCASE ASSEMBLY FIG. REF. PART NUMBER DESCRIPTION QTY. PER ASSY. 5 6 7 9 0 5 6 7 9 0 LW-99-755 50-5 - D-7 LW-79 C- C- - STD-557 75 STD-5 69796 0 STD- 6 65007 STD-9 C-7 0 STD-9 CRANKCASE ASSEMBLY (See Note) STUD. /- x 0-/ long STUD. /-0 x -7/ lone STUD. /-6 x -5/ long STUD. /-6 x -/ long. drilled STUD. 5/6- x 5/6 long. drive STUD. 5/6- x -/ long STUD. 5/6- x -5/ long STUD. /-6 x -/ long DOWEL. / dia. x 9/ long. hollow BUSHING. Governor drive idler shaft DOWEL. 5/6 dia. x / long DOWEL. Crankshaft bearing PLUG. /-7 NPT. Allen head INSERT. /-0 Heli-coil x / RETAINER. Shroud tube seal PLUG. /6-7 NPT. Allen head STUD. 5/6- x -/ long (driven height.6-.50) PLUG. /-7 NPT. Allen head PLUG, /6-7 NPT, Allen head NOTE This part is not available as a service item. Refer to Service Kits, Section 7, for applicable Crankcase Assembly and Governor Stud Kit Part Number. -
TEXTRON Lycoming Lycoming 0-60-AP PARTS CATALOG Figure. CRANKCASE ASSEMBLY -
TEXTRON Lycoming 0-60-AP PARTS CATALOG CRANKCASE, CRANKSHAFT AND CAMSHAFT GROUP OIL LEVEL GAGE ASSEMBLY FIG. REF. PART NUMBER 7576 7059 706 LW-75 DESCRIPTION TUBE. Oil level gage. long GASKET. Oil level gage RING. Oil level gage seal GAGE ASSEMBLY, Oil level QTY. PER ASSY. Figure. OIL LEVEL GAGE ASSEMBLY -
TEXTRON Lycoming Lycoming 0-60-AlP PARTS CATALOG CRANKCASE, CRANKSHAFT AND CAMSHAFT GROUP CAMSHAFT ASSEMBLY FIG. REF. PART NUMBER LW- 76 76 LW-667 5 STD- DESCRIPTION CAMSHAFT ASSEMBLY SPACER Tach. shaft centering SHAFT ASSEMBLY. Tachometer PIN. /6 dia. x -/6 long RING, Internal retaining QTY. PER ASSY. Figure. CAMSHAFT ASSEMBLY -
0-60-AP PARTS CATALOG CRANKCASE, CRANKSHAFT AND CAMSHAFT GROUP CRANKCASE RELATED PARTS 0-B 60* LW-7* 666* 7767* LW-05* 06E9769-.5 770 LW-67 LW- A9 LW-79** 7075 709 777 DESCRIPTION BALL. /6 dia. SPRING. Oil pressure relief valve SPRING. Oil pressure relief valve SPRING Oil pressure relief valve SPRING. Oil pressure relief valve SPRING. Oil pressure relief valve GASKET. -/ I.D. x -/ O.D. X / annular VALVE ASSY.. Oil pressure relief, adjustable BEARING. Crankshaft BEARING. Crankshaft. front BEARING. Crankshaft. front (alternate) SEAL, Crankshaft. oil SEAL. Oil. / section x 5/ I.D. RING. Oil seal. /6 I.D. x / dia. section BODY, Hydraulic tappet QTY. PER ASSY. * Select spring to give a minimum of three threads exposed on adjusting screw to allow field adjustment. Reference latest revision of Textron Lycoming Table of Limits, SSP-776, Part I for spring identification. ** Refer to latest edition of Textron Lycoming Service Instruction No. for installation. -5
0-60-AP PARTS CATALOG 0 9 7 5 Figure. CRANKCASE RELATED PARTS -6
0-60-AP PARTS CATALOG CRANKCASE, CRANKSHAFT AND CAMSHAFT GROUP CRANKSHAFT ASSEMBLY AND RELATED PARTS FIG. REF. 5 PART NUMBER DESCRIPTION QTY. PER ASSY. 5 6 7 9 0 B75 STD- STD-065 650 790-S 755-S 75656-S LW-67 7566 S966* LW-69 STD- CRANKSHAFT AND PLUG ASSEMBLY PLUG..00 dia. expansion DOWEL. Stepped. 5/6 and / dia. x 9/6 long PLUG. -/ O.D. BUSHING. Propeller flange. indexing BUSHING. Propeller flange. short BUSHING. Propeller flange. long SUPPORT ASSY.. Starter ring gear. / pitch GEAR. Starter ring. / Ditch GEAR. Crankshaft LOCKPLATE. Crankshaft gear SCREW, 5/6- x.00 long I I * Refer to latest edition of Service Bulletin No. 75 for proper installation. -7
0-60-AlP PARTS CATALOG 9 / No. 6 6 Figure 5. CRANKSHAFT ASSEMBLY AND RELATED PARTS -
TEXTRON Lycoming Lycoming 0-60-AP PARTS CATALOG CRANKCASE, CRANKSHAFT AND CAMSHAFT GROUP PROPELLER GOVERNOR DRIVE (CRANKCASE) FIG. REF. 6 PART NUMBER DESCRIPTION QTY. PER ASSY. 5 6 7 9 0 5 7775 LW-0 777 777 STD-9 STD-79 79 750 75 75 0L AN565B 0H5* 7055 LW-96 705 77 STD-5 STD-75 STD-0 GEAR, Propeller goveror driven SHAFT. Propeller governor idler gear GEAR ASSY.. Propeller governor idler BUSHING. Propeller governor Idler gear DOWEL. / dia. x 7/ long DOWEL. / dla. x 9/ long WASHER, Thrust (.055 -.0595 thick) WASHER, Thrust (.06 -.06 thick) WASHER, Thrust (.0655 -.0665 thick) WASHER, Thrust (.069 -.070 thick) WASHER. Thrust (.055 thick) SET SCREW, No. 0- x 5/6 long GASKET, 5/ I.D. x -/ O.D. x /6 thick PLUG, /-6 hex. hd. GASKET. Governor COVER. Governor drive WASHER, 5/6 plain WASHER, 5/6 lock, internal teeth NUT, 5/6- plain AR AR AR AR AR I I * For alternate set screw and installation information, see latest edition of Textron Lycoming Service Instruction No.. -9
0-60-AP PARTS CATALOG Figure 6. PROPELLER GOVERNOR DRIVE (CRANKCASE) -0
O-60-AP PARTS CATALOG CRANKCASE, CRANKSHAFT AND CAMSHAFT GROUP CRANKSHAFT IDLER GEARS PART NUMBER LW-796 STD-67 STD-6 7996 7709 DESCRIPTION SHAFT. Crankshaft idler gear SCREW. 5/6- x 7/ long. hex. hd.. dr. NUT. 5/6- NC- slotted shear GEAR ASSEMBLY. Crankshaft idler. plain BUSHING, Crankshaft idler gear QTY. PER ASSY. -
TEXTRON Lycoming 0-60-AP PARTS CATALOG ( Figure 7. CRANKSHAFT IDLER GEARS -
0-60-AP PARTS CATALOG CRANKCASE, CRANKSHAFT AND CAMSHAFT GROUP CRANKCASE ATTACHING PARTS FIG. REF. PART NUMBER DESCRIPTION QTY. PER ASSY. 5 6 7 9 0 5 6 7 LW-5-.50 STD- 600 LW-5-.75 LW-5-. STD-60 STD- LW-5S.50 STD- STD-09 STD-* AN960-66L* STD-7 AN6-A STD- STD-67 STD-596 760 BOLT. /-0 x -/ long, hex, hd. WASHER. / plain STRAP. Lifting BOLT. /-0 x -/ long. hex. hd. BOLT. /-0 x -/ long, hex. hd. WASHER. / lock, internal teeth NUT. /-0 plain BOLT. /-0 x -/ long, hex. hd.. dr. end WASHER, / plain (Max. 9) NUT. /-0 slotted shear WASHER, / plain. /6 thick WASHER, / plain, / thick NUT. /- slotted BOLT. /- x -7/6 long, hex. hd. WASHER, / plain WASHER. / lock. internal teeth NUT. /- plain STUD, /-0 x 0-/6 long 0 9 AR AR AR * Use a maximum of total for items no. and no.. -
0-60-AP PARTS CATALOG Figure. CRANKCASE ATTACHING PARTS -
0-60-AP PARTS CATALOG ACCESSORY HOUSING AND RELATED PARTS ACCESSORY HOUSING ASSEMBLY FIG. REF. 9 PART NUMBER DESCRIPTION QTY. PER ASSY. 5 6 7 7 A5-0 5C- C- C-9 CD-7 0 STD-7 GASKET. Accessory housing HOUSING ASSY.. Accessory STUD. /-0 x -/ long STUD. 5/6- x -/ long STUD. 5/6- x -/ long STUD. 5/6- x -/ long. drilled PLUG. / pipe. Allen PLUG, / pipe, Allen 6 -
0-60-AP PARTS CATALOG 5 Figure 9. ACCESSORY HOUSING ASSEMBLY -
0-60-AP PARTS CATALOG ACCESSORY HOUSING AND RELATED PARTS OIL PUMP AND ACCESSORY HOUSING ATTACHING PARTS FIG. REF. 0 PART NUMBER DESCRIPTION QTY. PER ASSY. 5 6 7 9 0 75 05K9-S* 67 STD-5 STD-0 LW-60 STD- STD- 60 LW-5-0.9 LW-5-. LW-5-.50 BODY. Oil pump. KIT. Oil pump impeller SHAFT. Oil pump drive WASHER 5/6 plain NUT. 5/6- slotted SEAL. Tachometer drive, oil WASHER / plain WASHER, / lock. internal teeth BOLT. /-0 x 5/6 long. hex. hd. BOLT. /-0 x -/ long. hex. hd. BOLT, /-0 x -/ long, hex. hd. 9 * Refer to latest edition of Textron Lycoming Service Bulletin No. 56. -
TEXTRON Lycoming 0-60-AP PARTS CATALOG 7,,9 7,,0 - Figure 0. OIL PUMP AND ACCESSORY HOUSING ATTACHING PARTS -
0-60-AP PARTS CATALOG ACCESSORY HOUSING AND RELATED PARTS FUEL PUMP AND PROP. GOVERNOR DRIVE COVERS FIG. REF. PART NUMBER DESCRIPTION QTY. PER ASSY. 5 6 7 9 0 60096 6509 STD- LW--0.75 STD-67 6955 6906 STD-5 STD-75 STD-0 GASKET. Fuel pump COVER. Fuel pump WASHER, / plain BOLT. /-6 x / long, hex. hd. WASHER, Lock GASKET. Accessory drive adapter COVER. Governor drive adapter pad WASHER 5/6 plain WASHER 5/6 lock, internal teeth NUT, 5/6- plain -5
0-60-AP PARTS CATALOG Figure. FUEL PUMP AND PROP. GOVERNOR DRIVE COVERS -6
TEXTRON Lycoming 0-60-AP PARTS CATALOG ACCESSORY HOUSING AND RELATED PARTS VACUUM PUMP DRIVE AND COVER FIG. REF. PART NUMBER DESCRIPTION QTY. PER ASSY. 5 6 7 9 0 6 609 STD-77 06A9956 7970 7596 600 STD- STD-60 STD- GASKET. Accessory adapter ADAPTER ASSY.. Vacuum pump PIN. / dia. x / long OIL SEAL. 7/ I.D. x -/ O.D. x 5/6 wide GEAR ASSY.. Vacuum pump driven WASHER. Accessory driven gear GASKET. Vacuum pump COVER. Vacuum pump WASHER. / plain WASHER / lock. internal teeth NUT, /-0 plain 7. Figure. VACUUM PUMP DRIVE AND COVER -7
0-60-AP PARTS CATALOG ACCESSORY HOUSING AND RELATED PARTS OIL PRESSURE SCREEN AND OIL COOLER BYPASS VALVE FIG. REF. PART NUMBER DESCRIPTION QTY. PER ASSY. 5 6 7 9 0 06E9769-0.6 69675 STD-7 70 67 67 6950 06E9769-0.6 STD- STD-56 5E9600 7650 GASKET. 7/ O.D. x 5/ I.D. x / annular CONNECTOR, Accessory hsg. to oil cooler inlet hose PLUG. / pipe, Allen FITTING, Breather (assemble in accv. hsg.) SCREEN ASSY.. Oil pressure GASKET. Oil pressure housing HOUSING, Thermostatic valve and oil pressure screen GASKET. 7/ O.D. x 5/ I.D. x / annular WASHER / plain SCREW. /-0 x /-.00 long. hex. hd.. slotted VALVE ASSY.. Temp. control oil cooler bypass GASKET, Valve assembly 5 Figure. OIL PRESSURE SCREEN AND OIL COOLER BYPASS VALVE -
TEXTRON Lycoming 0-60-AP PARTS CATALOG CYLINDER, PISTON AND VALVE TRAIN CONNECTING RODS, PISTONS AND RING ASSEMBLIES FIG. REF. PART NUMBER DESCRIPTION QTY. PER ASSY. 5 6 7 9 0 LW-750 LW-9 7506 LW-6 LW-5 7509 LW-077 LW-775 7 757 CONNECTING ROD ASSEMBLY BUSHING. Connecting rod. upper BOLT. Connecting rod NUT. Connecting rod bolt BEARING. Connecting rod PISTON. Compression ratio..50: PIN. Piston PLUG. Piston pin RING. Piston compression RING, Piston, oil regulating, expander type 0 9 Figure. CONNECTING RODS, PISTONS AND RING ASSEMBLIES -
0-60-AP PARTS CATALOG CYLINDER, PISTON AND VALVE TRAIN CYLINDER ASSEMBLY FIG. REF. 5 PART NUMBER DESCRIPTION QTY. PER ASSY. 5 6 7 9 0 LW-7 7057 705 66* 70* 66796 STD-7 STD-5 C- 5C- MS0-6D 6660 0** CYLINDER AND HEAD ASSY.. Nitrided SEAT, Intake valve SEAT. Exhaust valve GUIDE. Valve, intake. flanged GUIDE, Valve, exhaust, flanged INSERT. Spark plug INSERT, /-7 Heli-coil taper pipe thread INSERT, No. 0- x / STUD. 5/6- x.50 long STUD. /-0 x.00 long ELBOW 5, / flared tube BUSHING. Rocker shaft PLUG, /-7 NPT, Allen head 6 * Refer to latest edition of Textron Lycoming Service Instruction No. 56 for application. ** Assemble in cylinder head when no priming lines. 6 Figure 5. CYLINDER ASSEMBLY -
TEXTRON Lycoming 0-60-AP PARTS CATALOG CYLINDER, PISTON AND VALVE TRAIN CYLINDER RELATED PARTS FIG. REF. 6 PART NUMBER DESCRIPTION QTY. PER ASSY. 5 6 7 9 0 5 7* 5F9957-5* 5F9957-6* 77* 7F957** 767 LW-790 LW-9 75906 67 STD-95 7 77 -B STD-090 STD-5 STD-75 STD-0 ROD ASSY.. Push ROD ASSY.. Push ROD ASSY.. Push ROD ASSY.. Push ROCKER ASSY.. Valve BUSHING. Valve rocker SHAFT. Valve rocker THRUST BUTTON. Rocker shaft GASKET. Rocker box cover COVER Rocker box SCREW. /-0 x 5/ long. pan. head. self-locking RING. Oil seal. / dia. x -7/ I.D. SPACER /6 I.D. x 7/ O.D. x / thick NUT. /- plain NUT. /-0 plain WASHER. 5/6 plain WASHER 5/6 lock. internal teeth NUT, 5/6- plain AR AR AR AR 6 * See latest edition of Textron Lycoming Service Instruction No. 060 for complete push rod application. ** Due to the size of the area where the part number is stamped, the last five digits may be all that is shown (957). -
0-60-AP PARTS CATALOG Figure 6. CYLINDER RELATED PARTS -
TEXTRON Lycoming 0-60-All? PARTS CATALOG WIDE CYLINDER FLANGECRANKCASE MODEL ENGINES CYLINDER, PISTON AND VALVE TRAIN VALVE ASSEMBLY FIG. REF. 7 PART NUMBER DESCRIPTION QTY. PER ASSY. 5 6 7 9 0 5 6 7 9 79 LW-900 LW-795 LW-00 65 LW- LW-0077 LW-675 60009 7C9 7C96 790 5B9 LW-5 LW-995 LW-7 STD- LW-66 700 VALVE. Intake VALVE. Exhaust (rotator type) SPRING. Valve. inner SPRING. Valve. outer SEAT. Valve spring. lower. intake SEAT. Valve spring. lower SEAT. Valve spring. upper. Intake SEAT. Valve spring. upper. exhaust (rotator type) KEY. Valve. intake KEY. Valve. exhaust (rotator type) CAP. Valve stem. exhaust (rotator type) PLUNGER ASSY.. Hydraulic tappet SOCKET. Push rod. hydraulic tappet TUBE. Push rod shroud SPRING. Shroud tube LOCKPLATE. Shroud tube NUT. /-0 plain SEAL. Shroud tube SEAL, Shroud tube -5
TEXTRON Lycoming 0-60-AIP PARTS CATALOG 5 Figure 7. VALVE ASSEMBLY -6
0-60-AP PARTS CATALOG CYLINDER, PISTON AND VALVE TRAIN CYLINDER HEAD DRAIN TUBES AND INTERCYLINDER COOLING BAFFLES FIG. REF. PART NUMBER DESCRIPTION QTY. PER ASSY. 5 6 7 9 STD-6 STD- LW-559-5-05 6759 6760 676 759 76 760 NIPPLE, Straight. / I.D. hose HOSE. / I.D. x -/ long CLAMP. Hose TUBE ASSY.. Oil drain. cyl. no. TUBE ASSY., Oil drain. cyl. no. TUBE ASSY.. Oil drain. cyl. nos. & BAFFLE ASSY.. Intercylinder RETAINER Intercvlinder baffle HOOK, Intercylinder baffle retainer -7
0-60-AP PARTS CATALOG Figure. CYLINDER HEAD DRAIN TUBES AND INTERCYLINDER COOLING BAFFLES -
TEXTRON Lycoming 0-60-AP PARTS CATALOG IGNITION SYSTEM MAGNETOS, DRIVES, HARNESSES AND SPARK PLUGS FIG. REF. 9 PART NUMBER DESCRIPTION QTY. PER ASSY. 5 6 7 9 0 ** 6665 6C96 6 LW-706 LW-6 66GP-OSANN 66GC5SFNN 67P0 67P09 66M95 STD-75 STD-0 767 -J* 0P976-- GEAR. Magneto. impulse coupling GEAR, Magneto GASKET. Magneto adapter ADAPTER. Magneto. impulse coupling GASKET. Magneto MAGNETO. Right (Slick Model 70) MAGNETO. Left (Slick Model 7) HARNESS ASSY.. Ignition. right HARNESS ASSY.. Ignition, left CLAMP. Magneto WASHER 5/6 lock, internal teeth NUT. 5/6- plain ZIP STRAP SPARK PLUG (Champion REM-E) Shielded BAG, Magneto harness attaching * Iten no. spark plugs are used in current production only. Additional spark plugs are available for this engine. See latest edition of Textron Lycoming Service Instruction No. 0 for complete listing of all approved spark plugs. ** See page - for a breakdown of individual parts contained In the magneto and harness attaching parts bag. These parts to be attached by customer per engine line drawing included in each bag. -
O-60-AP PARTS CATALOG Part No. P/N 0P976-- Part Name Qty. LW-666-5-5 LW-00 STD- STD-7 767 LW-66-5-50 STD696 AN500-6- LW-M-75 CLIP, One wire CLIP, Two wire WASHER / plain SCREW, / lock (rocker box) ZIP STRAP CLIP, Four wire WASHER, / thin SCREW, / x -/ long PLATE, Baffle 6 ATTACHING HARDWARE 7 Harness Lead (M-95) ' Figure 9. MAGNETOS, DRIVES, HARNESSES AND SPARK PLUGS -
0-60-AP PARTS CATALOG ELECTRICAL COMPONENTS ALTERNATOR ASSEMBLY AND BELT FIG. REF. 0 PART NUMBER DESCRIPTION QTY. PER ASSY. LW-7 6B 9 7A977-76 ALTERNATOR ASSEMBLY PULLEY. Alternator BELT, Alternator drive, / wide NOTE See latest edition of Textron Lycoming Service Instruction No. 5 for complete listing of FAA approved starters, generators, alternators, regulators and relays. Figure 0. ALTERNATOR ASSEMBLY AND BELT 5-
TEXTRON Lycoming 0-60-AP PARTS CATALOG ELECTRICAL COMPONENTS STARTER MOTOR AND ATTACHING PARTS FIG. REF. PART NUMBER DESCRIPTION QTY. PER ASSY. 5 LW-557 STD-5 STD-75 LW--.6 STD-0 STARTER. volt (.: internal reduction) MZ- WASHER 5/6 plain WASHER 5/6 lock. internal teeth BOLT. 5/6- x -5/ long. hex. hd. NUT, 5/6- plain NOTE See latest edition of Textron Lycoming Service Instruction No. 5 for complete listing of FAA approved starters, generators, alternators, regulators and relays. - Figure. STARTER MOTOR AND ATTACHING PARTS 5-
0-60-AlP PARTS CATALOG ELECTRICAL COMPONENTS ALTERNATOR MOUNTING AND ATTACHING PARTS FIG. REF. PART NUMBER DESCRIPTION QTY. PER ASSY. 5 6 7 9 0 5 6 7 9 0 07A97 7 LW--0.9 750 STD-5 LW-H0.75 STD-77 LW- H0.75 7 LW-H0.75 STD-690 AN6- STD-690 STD-7 STD-7 AN6-6 765 STD-690 STD-7 STD-7 BRACKET. Alternator LOCKPLATE. 5/6 bolt x.00 spacing BOLT. 5/6- x 5/6 long, hex. hd. LINK. Alternator adlustlng WASHER, 5/6 plaln BOLT. 5/6- x / long, hex. hd.. dr. WASHER, Plain. / O.D. x / I.D. x / thick BOLT. 5/6- x / long, hex. hd.. dr. STRUT, Alternator support BOLT. 5/6- x / long, hex. hd.. dr. WASHER /6 O.D. x 5/6 I.D. x /6 thick BOLT, /- x -7/6 long, hex. hd., drilled end WASHER, /6 O.D. x 5/6 I.D. x /6 thick NUT. /- slotted PIN, Cotter / dia. x / long BOLT, /- x -5/6 long. hex. hd.. drilled end SHIM. -/ O.D. x / I.D. x.005 thick WASHER /6 O.D. x 5/6 I.D. x /6 thick NUT. /- slotted PIN, Cotter, / dia. x / long AR AR AR 5-
0-60-AP PARTS CATALOG Figure. ALTERNATOR MOUNTING Of AND ATTACHING PARTS Figure. ALTERNATOR MOUNTING AND ATTACHING PARTS 5-
TEXTRON Lycoming 0-60-AP PARTS CATALOG OIL SUMP AND INDUCTION SYSTEM OIL SUMP ASSEMBLY AND OIL SUCTION SCREEN FIG. REF. PART NUMBER DESCRIPTION QTY. PER ASSY. 5 6 7 9 0 5 6 LW-5 795 79 600 C-5 STD-9 STD-55 STD- STD-60 LW-5-0.9 LW-5-. STD- STD-9 70 06E9769-.00 LW-55 GASKET. Oil sump SUMP ASSEMBLY. Oil CONNECTION. Intake pipe STUD. /-0 x -/6 long STUD. 5/6- x -7/ long PLUG. /- NPT. Allen head PLUG. /- NPT. Sq. hd.. drilled WASHER, / plain WASHER / lock, internal teeth BOLT. /-0 x 5/6 long, hex. hd. BOLT. /-0 x -/ long, hex. hd. NUT. /-0 plain PLUG. /- NPT. Allen head SCREEN. Oil suction GASKET..00 I.D. x -/ O.D. x / annular PLUG, 5/ hex. hd. x.00-0 thread 0 6-
0-60-AP PARTS CATALOG 6 - -9 0 Figure. OIL SUMP ASSEMBLY AND OIL SUCTION SCREEN 6-
0-60-AlP PARTS CATALOG OIL SUMP AND INDUCTION SYSTEM INTAKE PIPES AND ATTACHING PARTS FIG. REF. PART NUMBER DESCRIPTION QTY. PER ASSY. 5 6 7 705 6960 LW-559-- 797 76 STD- STD-60 LW-5-.5 PIPE. Intake HOSE. -/ I.D. x -/6 O.D. x -/ long CLAMP. Hose GASKET. bolt flange. -7/ I.D. FLANGE. Intake pipe. upper WASHER, / plain WASHER / lock. internal teeth BOLT, /-0 x -/ long, hex. hd. Figure. INTAKE PIPES AND ATTACHING PARTS 6-
TEXTRON Lycoming 0-60-AP PARTS CATALOG OIL SUMP AND INDUCTION SYSTEM CARBURETOR ASSEMBLY FIG. REF. 5 PART NUMBER DESCRIPTION QTY. PER ASSY. 5 66 709 STD-5 STD-0 STD-75 GASKET. Carburetor CARBURETOR. (0-7) (Model MA--5) WASHER. 5/6 plain NUT. 5/6- plain WASHER. 5/6 lock, internal teeth Figure 5. CARBURETOR ASSEMBLY 6-
0-60-AP PARTS CATALOG OIL SUMP AND INDUCTION SYSTEM PRIMING SYSTEM FIG. REF. 6 PART NUMBER DESCRIPTION QTY. PER ASSY. 5 6 7 9 0 LW-09-0-0 LW-09-0-70 LW-09-0-0 LW-09-0-00 LW-59 0 LW-666-5- LW-959-75-5 STD-55 AN65-6A STD-5 6D0 TUBE ASSY.. Primer. cvl. no. I TUBE ASSY.. Primer. cvl. no. TUBE ASSY.. Primer. cvl. no. TUBE ASSY.. Primer. intermediate SLEEVE. Priming line PLUG. / NPT. Allen (assemble in cylinder head) CLAMP CLAMP. -/ I.D. with / dia. offset SCREW. No. 6- x / long. rd. hd. NUT. No. 6- self-locking TEE. Union. / tube NIPPLE ASSY., Primer 6-5
0-60-AP PARTS CATALOG Figure 6. PRIMING SYSTEM 6-6
TEXTRON Lycoming Lycoming 0-60-AP PARTS CATALOG SERVICE KIT SECTION... SEAL AND GASKET KIT Part No. 759- LW-0 LW-7 LW-6 LW-795 LW-5 LW-79* LW-60 LW-995 LW-69 LW 66 LW-996 STD- 06A9956 06E9769-0.6 06E9769-.00 06E9769-.5 69-C 60096 67 6 6 66 65 696 695 6955 700 7055 7 797 705 7059 7075 707 709 70 7 79 79 7 77 7 7065 706 75906 Part Name SEAL AND GASKET SET LOCKPLATE, Crankshaft gear LOCKPLATE, Shroud tube GASKET, Magneto GASKET, Oil filter adapter GASKET, Oil sump SEAL, Crankshaft oil SEAL, Tachometer drive SPRING, Shroud tube LOCKPLATE, Crankshaft gear SEAL, Shroud tube GASKET, Exhaust flange SEAL, Oil SEAL, Oil GASKET GASKET GASKET GASKET, Fuel pump GASKET, Fuel pump GASKET, Oil pressure housing GASKET, Accessory adapter GASKET, Magneto adapter GASKET, Carburetor GASKET, Accessory drive GASKET, Fuel pump adapter SPACER GASKET, Accessory drive SEAL, Shroud tube GASKET RING, Oil seal GASKET GASKET, Governor GASKET, Oil level gage SEAL, Oil LOCKPLATE RING, Oil seal GASKET, Oil level gage RING, Oil seal LOCKPLATE GASKET LOCKPLATE LOCKPLATE GASKET, Accessory housing RING, Oil level gage seal RING, Oil level gage plug GASKET, Rocker box cover Qty. 6 7-
0-60-AP PARTS CATALOG SERVICE KIT SECTION... SEAL AND GASKET SET Part No. Part Name Qty. 759-7650 7690* 775 776 SEAL AND GASKET SET (CONT.) GASKET, Oil cooler bypass SEAL, Crankshaft oil GASKET, Carburetor GASKET, Exhaust flange GASKET, Vacuum pump * Refer to latest edition of Service Instruction No. for application. 7-
TEXTRON Lycoming 0-60-AP PARTS CATALOG SERVICE KIT SECTION... CYLINDER, PISTON AND RING ASSEMBLY KIT Part No. Part Name Qty. 05K0 LW-7 LW-900 79 LW-00 LW-795 LW-0077 LW-675 65 LW- 60009 7C9 7C96 7509 7 757 LW-077 LW-775 60 7 LW-66 700 75906 KIT - CYLINDER, PISTON AND RING ASSY. CYLINDER AND HEAD ASSY. VALVE, Exhaust VALVE, Intake SPRING, Valve, outer SPRING, Valve, inner SEAT, Valve spring, upper, intake SEAT, Valve spring, upper, exhaust SEAT, Valve spring, lower, intake SEAT, Valve spring, lower, exhaust KEY, Valve, intake KEY, Valve, exhaust CAP, Valve stem, exhaust PISTON RING, Piston, compression RING, Piston, oil regulating PIN, Piston PLUG, Piston pin PLUG, Piston pin RING, Oil seal SEAL, Shroud tube SEAL, Shroud tube GASKET, Rocker box cover 7-
0-60-AP PARTS CATALOG SERVICE KIT SECTION... CRANKCASE ASSY. AND THRU STUD KIT Part No. Part Name Qty. LW-99--S LW-99-760 C- 77 AN565B0H AN565B0H5 STD-090 SSP-5 SSP-576 SSP-769 CRANKCASE ASSY. AND THRU STUD KIT CRANKCASE ASSY. THRU STUD STUD, AN Governor SPACER SET SCREW SET SCREW NUT TAG, Thin wall bearings TAG, Governor drive idler shaft TAG, Governor drive pad studs 7-
TEXTRON Lycoming 0-60-AP PARTS CATALOG WIDE CYLINDER FLANGE CRANKCASE MODEL ENGINE NUMERICAL INDEX PART NO. PART NAME PAGE NO. PART NO. PART NAME PAGE NO. AN65-6A AN565B 0H5 AN6- AN6-6 AN6-A AN960-66L LW-5-0.9 LW-5-0.9 LW-5-. LW-5-. LW-5-. LW-5-.5 LW-5-.50 LW-5-.50 LW-5S.50 LW-5-.75 LW-H0.75 LW--0.9 LW--.6 LW--.75 LW-0077 LW-5 LW-7 LW-750 LW-775 LW-795 LW-00 LW-09-0-00 LW-09-0-0 LW-09-0-70 LW-09-0-0 LW-6 LW-7 LW-7 LW-55 LW-59 LW-6 LW-706 LW-9 LW- Nut Set Screw Bolt Bolt Bolt Bolt Bolt Bolt Bolt Bolt Bolt Bolt Bolt Bolt Bolt Bolt Bolt Bolt Bolt Seat Tube Spring Conn. Rod Assy. Plug Spring Spring Tube Assy. Tube Assy. Tube Assy. Tube Assy. Nut Lockplate Cyl. & Head Assy. Plug Sleeve Gasket Adapter Thrust Button Seat 6-5 -9 5-5- - - - 6- - - 6-6- - - - - 5-5- 5- -5-5 -5-5 - - -5-5 6-5 6-5 6-5 6-5 - -5-6- 6-5 - - - -5 LW-5 LW-5 LW-790 LW-79 LW-79 LW-796 LW- LW-96 LW-9 LW-0 LW-077 LW-60 LW-7 LW-75 LW-995 LW-557 LW-559-5-05 LW-559-- LW-666-5- LW-67 LW-675 LW-67 LW-05 LW-99- LW-69 LW-66 LW-667 LW- LW-959-75-5 LW-900 MS0-6D STD- STD- STD- STD- STD- STD- STD-9 STD- STD- Gasket Bearing Shaft Seal Stud Shaft Bearing Plug Bushing Shaft Pin Seal Alternator Assy. Gage Assy. Spring Starter Hose Clamp Clamp Support Assy. Seat Bearing Spring Crankcase Assy. Lockplate Seal Pin Camshaft Assy. Clamp Valve Elbow Dowel 6- - - -5 - - -5-9 - -9 - - 5- - -5 5- -7 6-6-5-7 -5-5 -5 - -7-5 - - 6-5 -5 - - - -7-6- 6- -9 - -5 -
0-60-AP PARTS CATALOG WIDE CYLINDER FLANGE CRANKCASE MODEL ENGINE NUMERICAL INDEX (Continued) PART NO. PART NAME PAGE NO. PART NO. PART NAME PAGE NO. STD-5 STD-5 STD-5 STD-5 STD-5 STD-5 STD-5 STD-9 STD-60 STD-60 STD-60 STD-60 STD-60 STD-75 STD-75 STD-75 STD-75 STD-75 STD-75 STD-5 STD-55 STD-55 STD-557 STD-596 STD-67 STD-67 STD-6 STD-690 STD-7 STD-7 STD-7 STD-79 STD-5 STD-7 STD-7 STD-065 STD- STD-9 STD-5 STD-09 Plug Dowel Plug Screw Dowel Nut Nipple Pin Plug Plug Dowel Tee Nut Nut Dowel Plug Plug Insert Nut -9 - -5-5- 5-6- 6- - - -7 6-6- -9-5 - - 5-6- - 6-6-5 - - - -5-7 5-5- - - -9 6-5 - 5- -7-7 - - - STD-0 STD-0 STD-0 STD-0 STD-0 STD-0 STD- STD- STD- STD- STD-0 STD-6 STD-77 STD-77 STD- STD-56 STD-7 STD-95 STD-090 STD-67 STD-6 STD- STD-9 STD- 5C- 5C- C- C- C- C- C-5 C-7 C-9 CD-7 - - D-7 50-5 -B 0-B Nut Nut Nut Nut Nut Nut Nut Nut Nut Nut Nut Insert Pin Hose Screw Insert Screw Nut Screw Nut Screw Plug Ring Stud Stud Stud Stud Stud Stud Stud Stud Stud Stud Stud Stud Stud Stud Nut Ball -9-5 - - 5-6- - -7-5 6- - - 5- -7-7 - - - - - - -7 6- - - - - - - - 6- - - - - - - - - -5 -
0-60-AP PARTS CATALOG WIDE CYLINDER FLANGE CRANKCASE MODEL ENGINE NUMERICAL INDEX (Continued) PART NO. PART NAME PAGE NO. PART NO. PART NAME PAGE NO. 0 0 0 0 -J 60009 60096 600 600 60 609 67 67 6 67 600 650 6665 66 6 67 65007 6509 65 66 6660 66796 666 6759 6760 676 6906 6950 6955 6960 69675 69796 700 7055 Plug Plug Plug Plug Spark Plug Gasket Key Gasket Cover Strap Spring Adapter Assy. Gasket Shaft Gasket Cover Stud Plug Gear Guide Gasket Screen Assy. Retainer Cover Seat Gasket Bushing Insert Spring Tube Assy. Tube Assy. Tube Assy. Cover Housing Gasket Hose Connector Dowel Seal Gasket - - - 6-5 - -7-5 -5-7 - -5-7 - - -7-6- -7 - - - - - -5-5 6- - - -5-7 -7-7 -5 - -5 6- - - -5-9 70 705 709 70 7 7596 760 76 797 705 7057 705 7059 7075 709 755-S 75 77 7566 777 7970 79 750 75 75 76 7 7 77 7 757 79 706 70 7 7 767 77 7996 7506 Screen Pipe Carburetor Fitting Ring Hook Retainer Gasket Gasket Seat Seat Gasket Seal Ring Bushing Bushing Cover Gear Body Gear Assy. Flange Lockpl ate Rod Assy. Rod Assy. Gasket Ring Valve Ring Guide Ring Strut Bushing Spacer Gear Assy. Bolt 6-6- 6- - - -7-7 -7 6- -9 - - - -5-5 -7 - -9-7 -5-7 -9-9 -9-9 6-5- - - - - -5 - - - 5- - - - - -
TEXTRON Lycoming 0-60-AP PARTS CATALOG WIDE CYLINDER FLANGE CRANKCASE MODEL ENGINE NUMERICAL INDEX (Continued) PART NO. PART NAME PAGE NO. PART NO. PART NAME PAGE NO. 7509 755 759 750 75656-S 7576 75906 76 76 760 7650 765 767 7709 7767 770 777 777 7775 790 75 79 795 790-S 0L 0P976-- Piston Stud Baffle Assy. Link Bushing Tube Gasket Spacer Shaft Assy. Stud Gasket Shim Zip Strap Bushing Spring Valve Assy. Bushing Gear Assy. Gear Plunger Assy. Body Connection Sump Assy. Bushing Bag - - -7 5- -7 - - - - - - 5- - - -5-5 -9-9 -9-5 - 6-6- -7-9 - 05K9-S 06A9956 06E9769-0.6 06E9769-.00 06E9769-.5 07A97 B75 S966 5B9 5F9957-5 5F9957-6 7C96 7C9 7F957 A9 A5-0 6B9 7A977-76 5E9600 6D0 66GC5SFNN 66GP-OSANN 66M95 67P0 67P09 6C96 Impeller Kit Oil Seal Gasket Gasket Gasket Bracket Cr'shft & Plug Assy. Gear Socket Rod Assy. Rod Assy. Cap Key Rocker Assy. Bearing Housing Assy. Pulley Belt Valve Assy. Nipple Assy. Magneto Magneto Clamp Harness Assy. Harness Assy. Gear - -7-6- -5 5- -7-7 -5 - - -5-5 - -5-5- 5- - 6-5 - - - - - - -