2-12 TP20112, rev 7 Older-Jeep & Jeep CJ BOlT TORQue specifications standard BOlTs: size grade Torque 5/16 5 20 ft/lbs. 3/8 5 35 ft/lbs. 7/16 5 56 ft/lbs. 1/2 5 85 ft/lbs. etric BOlTs: size 8 10 12 14 Torque 22 ft/lbs. 42 ft/lbs. 70 ft/lbs. 95 ft/lbs. 1 2 4 5 1 2 3 4 6 3 7 9518112 parts list Ref. Part No. No. Qty. Description 1. 00083 4 1/2 Hex Nut 2. 00084 4 1/2 Lock Washer 3. 01253 4 1/2 x 2 Hex Bolt GR. 5 4. 10674-35 2 Back plate 5. 13119-35 1 Left Pull Pod 6. 13120-35 1 Right Pull Pod 7. 5937 1 Plug Mount Kit 8. 12329 1 Loctite (not shown) Please order replaceent parts by PART NO. and DESCRIPTION. Doing Our Best to Provide You the Best
Warning: Failure to follow these instructions can result in loss of towing vehicle control, separation of the tow BAR fro the towing vehicle, separation of the towed vehicle fro the tow BAR, causing severe personal injury, death, or property daage. CAUTION Safety is of utost iportance at all ties. There are several ites that ust be checked each tie before using and while using a tow bar. Before allowing anyone to hook up or operate a tow bar, be sure they have read and understand the proper operating procedure. DO NOT use worn or daaged cables and/or pins. Be sure the SAFETY CABLES are hooked, chassis to chassis, to both the towing and towed vehicles using the crisscross ethod. Check clearance between vehicles in a turning situation. Check base plate ounting bolts for tightness and frae for etal fatigue. Do not load the towed vehicle with anything as you ay exceed the towing capacity of the tow bar. Keep fingers away fro pivot points to prevent personal injury. Be sure the steering coponents of the towed vehicle are properly aligned. NOTE: This unit can be backed up in oderate increents. Any severe backwards cornering could result in daage to the Tow Bar and/or towed vehicle chassis. For autoatic transissions: Consult your vehicle owners anual for towing suitability with the drive shaft connected. Otherwise, the towed vehicle will have to be equipped with a transission pup or drive shaft disconnect. Check to ake sure that all lights are in proper working order. The inforation on towability of vehicles is reprinted with perission of MotorHoe Magazine, and is believed to be reliable. However, Deco does not warrant the inforation to be correct. Always consult your towed vehicle owner s anual and follow towing instructions. Each year, MotorHoe Magazine, copiles a list of vehicles that can be towed four-down behind a otorhoe with no odifications required. This guide contains only those vehicles that have been approved by their anufacturers for towing. This list is enclosed with this anual. Caution: MotorHoe Magazine left out any vehicles that have towing speed liits slower than 55.p.h., or distance liits of less than 200 iles. At a iniu, these vehicles require significant odification, such as the use of an afterarket product, to ake the towable. The availability of a Deco Tow Bar Base Plate does not iply that these vehicles can be odified or that there is an afterarket product available. Refer to your vehicle owner s anual or consult your dealer to deterine whether your vehicle can be odified to ake it towable. Failure to observe this precaution could result in property daage or personal injury. iportant installation ites DEMCO products and accessories are intended to be installed by professional installers with experience, proper equipent and the ability to do odification work. Installers with these qualifications can be found in RV and Autootive Service Centers. If the car to be towed has been in an accident, the chassis ay be daaged in an area where the Base Plate attaches. It ay no longer be suitable for towing. Extree caution and careful exaination are required in such a situation. It is also likely, even fro a inor accident, that the hole alignent will be ore difficult due to hole alignent probles. Many DEMCO Base Plates are designed to use existing holes and hardware to ount the Base Plate to the towed vehicle. Even though the bolt is there, however, do not assue it is adequate for ounting the Base Plate. Manufacturers ake any changes in hardware both within and between odel years. Be sure the bolt is long enough to protrude past the nut a distance no less than 1/2 the diaeter of the bolt, after the Base Plate is ounted. The threads should be in good condition. We require that Blue be used on all bolts. If a new bolt is required, be sure it is SAE Grade 5 or Metric 8.8. NOTE: The diensional variations between otherwise identical vehicles can be considerable. Soe inor odifications ay have to be ade to ensure a proper fit. installation instructions 1. These brackets should never be attached over rubber or plastic. The brackets should be attached to a flat etal surface. 2. Locate and ark center of buper and easure out 10-9/16 fro each side of center ark. Drill 17/32 holes, aking sure your centered horizontally on the buper. 3. Install pull pod brackets teporarily, so chain anchor hole is towards outside, with 1/2 x 2 bolts, and 1/2 hex nuts for the inside holes. Using bracket as teplate, ark 17/32 holes for the outside holes of bracket. Reove brackets. 4. Drill 17/32 holes where previously arked. Reinstall brackets with back plate on back side of buper, using 1/2 x 2 bolts, 1/2 lock washers, and 1/2 hex nuts. Tighten all bolts. NOTE: Use blue on all bolts and tighten according to chart on front page. 5. Plug ount (ite #7) ay be installed if desired for wiring installation. Location of ount to be deterined by the installer. NOTE: Excess aterial ay be tried fro bracket.
4010 320th Street Box 189 Boyden, Iowa 51234 Toll Free 800-54DEMCO (800-543-3626) FAX 800-845-6420 www.deco-products.co Warranty Registration Very Satisfied Satisfied Dissatisfied Ag RV Rental Brakes Marine Very Dissatisfied How satisfied are you with our product? How satisfied are you with the dealership/distributor sales staff? Dealer/Distributor Nae City State How satisfied are you with the copany sales staff? How satisfied are you with the delivery? Did you have any contact with a Deco Representative? YES NO If YES, how satisfied were you? I would recoend this product to y faily and friends. YES NO Would you purchase again fro DEMCO? YES NO Since taking delivery, have you been contacted by the dealer? YES NO Did you have any probles with this DEMCO product? YES NO If YES, are you satisfied with the copany s resolution of your proble? Please list the specific source of inforation propting this purchase. After purchasing this product, do you see any needed product iproveent? If yes, what iproveent? What other products would you like to see DEMCO offer? Coents Owner s Nae: Mailing Address: City: State: Zip Code: Model#: Serial #: Purchase Date: Owner s Signature: Please return to DEMCO By FAX or tri-folding this for to the backside, it is pre-addressed.
Deco 4010 320th Street, Box 189 Boyden, Iowa 51234 Postage
1. Extent and Duration of this Warranty: Your Deco product has a Lifetie Liited warranty to be free fro defects in aterials and workanship under noral use and service fro date of purchase by the original (first) retail owner, or until it is resold or transferred by the original owner. Any part of the Deco product found in the judgeent of the anufacturer to be defective in aterials or workanship will be repaired or replaced at the anufacturer s option without charge for parts or labor to the original owner. 2. Manufacturer and Warrantor: Deco 4010 320th Street P.O. Box 189 Boyden, IA 51234 (712) 725-2311 3. Repair or Replaceent Procedure: If your Deco product develops a defect during the warranty period, proptly notify Deco custoer service departent. Until such notice is received, Warrantor will not be responsible for any repair or replaceent. Upon receipt of notice fro you, Warrantor will have a choice of options in replacing any part it deterines to be defective: a) Warrantor ay require you at your own expense to deliver or ship the part to its factory or authorized dealer. Any defective part will be repaired or replaced and returned to you free of charge. Any part returned to Warrantor and found not to be defective will be returned to you freight collect with an explanation. DEMCO PRODUCTS ORIGINAL PURCHASERS LIMITED WARRANTY In addition, the warranty does not extend to repairs ade necessary by noral use of parts, accessories or other equipent which in the judgent of Warrantor, are either incopatible with the Deco product, or affect its operation, perforance or durability. This warranty does not cover: 1) noral wear and tear 2) road fil or gravel daage to paint 3) paint 4) rust daage Warrantor has a policy of continuous product iproveent. We reserve the right to change or iprove the design of any Deco product, including but not liited to state of the art changes, without assuing any obligation to odify any product previously anufactured. Warrantor assues no responsibility to the owner for loss of use of the product, loss of tie, inconvenience or other daage consequential or otherwise, including, but not liited to expense for gasoline, expense of transporting the product to the dealer and expense of returning the product, echanic s travel tie, telephone or telegra charges, road service/towing charges, rental of another product during the tie warranty repairs are being perfored, travel, lodging, loss or daage to personal property or loss of revenue or earnings. 5. Liitations of Iplied Warranties: All iplied warranties, if any, expire and terinate upon expiration of this warranty. Soe states do not allow liitation on how long an iplied warranty lasts, so this liitation ay not apply to you. b) Warrantor ay elect to ship a new part to its dealer to be exchanged free of charge for the defective part returned by you to the dealer. c) Warrantor ay elect to ship or deliver a replaceent part to your address. 4. Liitations on Warranty Coverage: Coverage under this warranty will be valid only if the custoer warranty card is returned by the original purchaser within 30 days of purchase. Coverage under this warranty will be effective only when a copy of the original invoice, showing the date and location of purchase, accopanies any clai for warranty. This warranty is liited to the original owner and is NON TRANSFERABLE to a second party. Warrantor has no liability whatsoever and this warranty is null and void if any Deco product has been isassebled or subjected to neglect, negligence, isuse, accident or operated in any way contrary to the operating and aintenance instructions as specified in the Deco Owner s Manual for that odel. 6. Liitation of Consequential Daages: Warrantor s responsibility under this warranty extends solely to repair or replaceent of your Deco product and its coponent parts. Warrantor does not assue responsibility for, nor shall it be liable for, any special, incidental or consequential daages. Soe states do not allow the exclusion or liitation on incidental or consequential daages, so the above exclusion or liitation ay not apply to you. 7. Purchaser s Rights: This warranty gives you specific legal rights, and you ay also have other rights which vary fro state to state. 8. Exclusive Warranty: This is the only express warranty ade by Deco on your Deco product and no agent, eployee, or other person is allowed to change or add to this warranty. This warranty does not cover any product that has been altered or odified so as to affect it s operation, perforance or durability, or that has been odified to change the intended use of the product.
NOTES
NOTES
4010 320th St., P.O. BOX 189, BOYDEN, IA. 51234 PH: (712) 725-2311 FAX: (712) 725-2380 or 1-800-845-6420 TOLL FREE: 1-800-54DEMCO (1-800-543-3626) www.deco-products.co