M O missions ontrol ystem Maintenance... 452 Required Maintenance ntervals... 454 Maintenance chedule... 452 M
M 452 M MO ORO YM M he cheduled Maintenance services listed in bold type must be done at the times or mileages specified to ensure the continued proper functioning of the emissions control system. hese and all other maintenance services included in this manual, should be done to provide best vehicle performance and reliability. More frequent maintenance may be needed for vehicles in severe operating conditions, such as dusty areas and very short trip driving. nspection and service should also be done anytime a malfunction is suspected. O: Maintenance, replacement or repair of the emissions control devices and systems on your vehicle may be performed by any automotive repair establishment or individual using any automotive part that has been certified pursuant to.. P or in the tate of alifornia, alifornia ir Resources Board regulations. M he oil change indicator system will remind you that it is time to take your vehicle in for scheduled maintenance. On on-v equipped vehicles, ng O will flash in the instrument cluster odometer and a single chime will sound, indicating that an oil change is necessary. Based on engine operation conditions the oil change indicator message will illuminate, this means that service is required for your vehicle. ave your vehicle serviced as soon as possible, within the next 500 miles (05 km). O: he oil change indicator message will not monitor the time since the last oil change. hange your vehicle s oil if it has been six months since your last oil change even if the oil change indicator message is O illuminated.
hange your engine oil more often if you drive your vehicle off-road for an extended period of time. nder no circumstances should oil change intervals exceed 6,000 miles (10 000 km) or six months, whichever comes first. Your dealer will reset the oil change indicator message after completing the scheduled oil change. f this scheduled oil change is performed by someone other than your dealer, the message can be reset by referring to the steps described under Odometer/rip Odometer in the nstrument luster escription section of this manual. t ach top for Fuel heck the engine oil level about five minutes after a fully warmed engine is shut off. hecking the oil level while the vehicle is on level ground will improve the accuracy of the oil level reading. dd oil only when the level is at or below the or M mark. M 453 heck the windshield washer solvent and add if required. Once a Month heck tire pressure and look for unusual wear or damage. nspect the battery and clean and tighten the terminals as required. heck the fluid levels of coolant reservoir, brake master cylinder, power steering and transmission and add as needed. heck all lights and other electrical items for correct operation. M
M 454 M t ach Oil hange hange the engine oil filter. nspect the brake hoses and lines. heck the manual transmission fluid level. O! Failure to perform the required maintenance items may result in damage to the vehicle. Required Maintenance ntervals Refer to the Maintenance chedules on the following pages for the required maintenance intervals.
6,000 Miles (10,000 km) or 6 Months Maintenance ervice chedule hange the engine oil and engine oil filter. 12,000 Miles (20,000 km) or 12 Months Maintenance ervice chedule hange the engine oil and engine oil filter. f using your vehicle for any of the following: usty or off-road conditions. nspect the engine air cleaner filter, replace if necessary. nspect the brake linings, replace if necessary. nspect exhaust system. Perform the first inspection at 12,000 miles (20 000 km) or 12 months. nspect the V joints. Perform the first inspection at 12,000 miles (20 000 km) or 12 months. nspect the front suspension, tie rod ends and boot seals; replace if necessary. M 455 M ealer ode ealer ode ignature uthorized hrysler ealer ignature uthorized hrysler ealer
M 456 M 1,000 Miles (30,000 km) or 1 Months Maintenance ervice chedule hange the engine oil and engine oil filter. nspect the front & rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing. 24,000 Miles (40,000 km) or 24 Months Maintenance ervice chedule hange the engine oil and engine oil filter. f using your vehicle for any of the following: usty or off-road conditions. nspect the engine air cleaner filter, replace if necessary. nspect the brake linings, replace if necessary. nspect the V joints. nspect exhaust system. nspect the front suspension, tie rod ends and boot seals; replace if necessary. ealer ode ealer ode ignature uthorized hrysler ealer ignature uthorized hrysler ealer
30,000 Miles (50,000 km) or 30 Months Maintenance ervice chedule hange the engine oil and engine oil filter. Replace the engine air cleaner filter. djust parking brake on vehicles equipped with four-wheel disc brakes. hange the manual transmission fluid if using your vehicle for any of the following: trailer towing, snow plowing, heavy loading, taxi, police, delivery service (commercial service), off-road, desert operation or more than 50% of your driving is at sustained high speeds during hot weather, above 90 F (32 ). nspect the transfer case fluid. M 457 M ealer ode ignature uthorized hrysler ealer
M 45 M 36,000 Miles (60,000 km) or 36 Months Maintenance ervice chedule hange the engine oil and engine oil filter. f using your vehicle for any of the following: usty or off-road conditions. nspect the engine air cleaner filter, replace if necessary. nspect the brake linings, replace if necessary. nspect the front & rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing. nspect the front suspension, tie rod ends and boot seals; replace if necessary. 42,000 Miles (70,000 km) or 42 Months Maintenance ervice chedule hange the engine oil and engine oil filter. ealer ode ealer ode ignature uthorized hrysler ealer ignature uthorized hrysler ealer
4,000 Miles (0,000 km) or 4 Months Maintenance ervice chedule hange the engine oil and engine oil filter. f using your vehicle for any of the following: usty or off-road conditions. nspect the engine air cleaner filter, replace if necessary. nspect the brake linings, replace if necessary. nspect the V joints. nspect exhaust system. nspect the front suspension, tie rod ends and boot seals; replace if necessary. M 459 54,000 Miles (90,000 km) or 54 Months Maintenance ervice chedule hange the engine oil and engine oil filter. nspect the front & rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing. M ealer ode ealer ode ignature uthorized hrysler ealer ignature uthorized hrysler ealer
M 460 M 60,000 Miles (100,000 km) or 60 Months Maintenance ervice chedule hange the engine oil and engine oil filter. Replace the engine air cleaner filter. nspect the brake linings, replace if necessary. djust parking brake on vehicles equipped with four-wheel disc brakes. hange the manual transmission fluid if using your vehicle for any of the following: trailer towing, snow plowing, heavy loading, taxi, police, delivery service (commercial service), off-road, desert operation or more than 50% of your driving is at sustained high speeds during hot weather, above 90 F (32 ). hange the automatic transmission fluid and main sump filter if using your vehicle for any of the following: police, taxi, fleet or frequent trailer towing. hange the transfer case fluid if using your vehicle for any of the following: police, taxi, fleet, off-road or frequent trailer towing. Flush and replace the engine coolant at 60 months if not done at 102,000 miles (170 000 km). nspect the front suspension, tie rod ends and boot seals; replace if necessary. ealer ode ignature uthorized hrysler ealer
66,000 Miles (110,000 km) or 66 Months Maintenance ervice chedule hange the engine oil and engine oil filter. 72,000 Miles (120,000 km) or 72 Months Maintenance ervice chedule hange the engine oil and engine oil filter. f using your vehicle for any of the following: usty or off-road conditions. nspect the engine air cleaner filter, replace if necessary. nspect the brake linings, replace if necessary. nspect the front & rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing. nspect the V joints. nspect exhaust system. nspect the front suspension, tie rod ends and boot seals; replace if necessary. M 461 M ealer ode ealer ode ignature uthorized hrysler ealer ignature uthorized hrysler ealer
M 462 M 7,000 Miles (130,000 km) or 7 Months Maintenance ervice chedule hange the engine oil and engine oil filter. 4,000 Miles (140,000 km) or 4 Months Maintenance ervice chedule hange the engine oil and engine oil filter. f using your vehicle for any of the following: usty or off-road conditions. nspect the engine air cleaner filter, replace if necessary. nspect the brake linings, replace if necessary. nspect the front suspension, tie rod ends and boot seals; replace if necessary. ealer ode ealer ode ignature uthorized hrysler ealer ignature uthorized hrysler ealer
90,000 Miles (150,000 km) or 90 Months Maintenance ervice chedule hange the engine oil and engine oil filter. Replace the engine air cleaner filter. nspect and replace PV valve if necessary. djust parking brake on vehicles equipped with four-wheel disc brakes. hange the manual transmission fluid if using your vehicle for any of the following: trailer towing, snow plowing, heavy loading, taxi, police, delivery service (commercial service), off-road, desert operation or more than 50% of your driving is at sustained high speeds during hot weather, above 90 F (32 ). nspect the transfer case fluid. nspect the front & rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing. M 463 M ealer ode ignature uthorized hrysler ealer
M 464 M 96,000 Miles (160,000 km) or 96 Months Maintenance ervice chedule hange the engine oil and engine oil filter. f using your vehicle for any of the following: usty or off-road conditions. nspect the engine air cleaner filter, replace if necessary. nspect the brake linings, replace if necessary. nspect the V joints. nspect exhaust system. nspect the front suspension, tie rod ends and boot seals; replace if necessary. 102,000 Miles (170,000 km) or 102 Months Maintenance ervice chedule hange the engine oil and engine oil filter. Replace the ignition cables. Replace the spark plugs. Flush and replace the engine coolant if not done at 60 months. ealer ode ealer ode ignature uthorized hrysler ealer ignature uthorized hrysler ealer
10,000 Miles (10,000 km) or 10 Months Maintenance ervice chedule hange the engine oil and engine oil filter. f using your vehicle for any of the following: usty or off-road conditions. nspect the engine air cleaner filter, replace if necessary. nspect the brake linings, replace if necessary. nspect the front & rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing. nspect the front suspension, tie rod ends and boot seals; replace if necessary. M 465 114,000 Miles (190,000 km) or 114 Months Maintenance ervice chedule hange the engine oil and engine oil filter. M ealer ode ealer ode ignature uthorized hrysler ealer ignature uthorized hrysler ealer
M 466 M 120,000 Miles (200,000 km) or 120 Months Maintenance ervice chedule hange the engine oil and engine oil filter. Replace the engine air cleaner filter. Replace accessory drive belt(s). nspect the brake linings, replace if necessary. nspect exhaust system. nspect the front suspension, tie rod ends and boot seals; replace if necessary. djust parking brake on vehicles equipped with four-wheel disc brakes. nspect the V joints. hange the transfer case fluid if using your vehicle for any of the following: police, taxi, fleet, off-road or frequent trailer towing. hange the manual transmission fluid if using your vehicle for any of the following: trailer towing, snow plowing, heavy loading, taxi, police, delivery service (commercial service), off-road, desert operation or more than 50% of your driving is at sustained high speeds during hot weather, above 90 F (32 ). hange the automatic transmission fluid, and filter(s). ealer ode ignature uthorized hrysler ealer
126,000 Miles (210,000 km) or 126 Months Maintenance ervice chedule hange the engine oil and engine oil filter. nspect the front & rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing. 132,000 Miles (220,000 km) or 132 Months Maintenance ervice chedule hange the engine oil and engine oil filter. f using your vehicle for any of the following: usty or off-road conditions. nspect the engine air cleaner filter, replace if necessary. nspect the brake linings, replace if necessary. nspect the front suspension, tie rod ends and boot seals; replace if necessary. M 467 M ealer ode ealer ode ignature uthorized hrysler ealer ignature uthorized hrysler ealer
M 46 M 13,000 Miles (230,000 km) or 13 Months Maintenance ervice chedule hange the engine oil and engine oil filter. 144,000 Miles (240,000 km) or 144 Months Maintenance ervice chedule hange the engine oil and engine oil filter. f using your vehicle for any of the following: usty or off-road conditions. nspect the engine air cleaner filter, replace if necessary. nspect the brake linings, replace if necessary. nspect the front & rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing. nspect the V joints. nspect exhaust system. nspect the front suspension, tie rod ends and boot seals; replace if necessary. ealer ode ealer ode ignature uthorized hrysler ealer ignature uthorized hrysler ealer
150,000 Miles (250,000 km) or 150 Months Maintenance ervice chedule hange the engine oil and engine oil filter. Replace the engine air cleaner filter. djust parking brake on vehicles equipped with four-wheel disc brakes. hange the manual transmission fluid if using your vehicle for any of the following: trailer towing, snow plowing, heavy loading, taxi, police, delivery service (commercial service), off-road, desert operation or more than 50% of your driving is at sustained high speeds during hot weather, above 90 F (32 ). nspect the transfer case fluid. M 469 M ealer ode ignature uthorized hrysler ealer
M 470 M his maintenance is recommended by the manufacturer to the owner, but is not required to maintain emissions warranty. WRG! You can be badly injured working on or around a motor vehicle. o only service work for which you have the knowledge and the right equipment. f you have any doubt about your ability to perform a service job, take your vehicle to a competent mechanic. Failure to properly inspect and maintain your vehicle could result in a component malfunction and effect vehicle handling and performance. his could cause an accident