Safety Data Sheet Red-I EP Super Prem Grease #2 Product Number: Revision Date: 50042-16 07/27/2017 SECTION 1: Identification of the substance/mixture and of the company/undertaking 1.1. Product identifier Red-I EP Super Prem Grease #2 Product Code 50042 1.2. Relevant identified uses of the substance or mixture and uses advised against Intended use See Technical Data Sheet. 1.3. Details of the supplier of the safety data sheet Manufacturer LUBRICATING SPECIALTIES COMPANY 8015 PARAMOUNT BLVD. PICO RIVERA, CA 90660 Telephone No. (562) 776-4000 1.4. Emergency telephone number (800) 424-9300 24hr SECTION 2: Hazards identification 2.1. Classification of the substance or mixture Skin Irrit. 2;H315 Causes skin irritation
2.2. Label elements Using the Toxicity Data listed in section 11 & 12 the product is labeled as follows. Warning H315 Causes skin irritation P280 Wear protective gloves / eye protection / face protection. P302+352 IF ON SKIN: Wash with soap and water P362 Take off contaminated clothing and wash before reuse. HMIS Health: 2 NFPA Health: 2 Fire: 1 Fire: 1 Physical Hazards: 0 Reactivity: 0 PPE: C Special Hazards: -- 2.3. Other hazards This product contains no PBT/vPvB chemicals. SECTION 3: Composition/information on ingredients Ingredient/Chemical Designations Weight % Distillate (petroleum) hydrotreated heavy naphthenic CAS Number: 0064742-52-5 Hydroxyl Containing Saturated Fatty Acids CAS Number: Proprietary or N/A Butene, polymer with 2-methyl-1-propene CAS Number: 0009044-17-1 Proprietary additive CAS Number: Proprietary or N/A Decanedioic Acid CAS Number: 0000111-20-6 <80 Not Classified <10 Not Classified <5 Not Classified <3 Not Classified <3 Not Classified EC No. 1272/2008 / GHS Classification
Lithium hydroxide monohydrate CAS Number: 0001310-66-3 Petroleum distillates, solvent-refined light paraffinic CAS Number: 0064741-89-5 PETROLEUM DISTILLATES, HYDROTREATED HEAVY PARAFFIN CAS Number: 0064742-54-7 Distillates (petroleum), solvent-dewaxed heavy paraffinic CAS Number: 0064742-65-0 *The full texts of the phrases are shown in Section 16. <3 Skin Corr. 1;H314 STOT SE 3;H335 <1 Not Classified <1 Asp. Tox. 1;H304 <1 Not Classified SECTION 4: First aid measures 4.1. Description of first aid measures General In all cases of doubt, or when symptoms persist, seek medical attention. Never give anything by mouth to an unconscious person. Inhalation If inhaled, remove person to fresh air and keep comfortable for breathing. If breathing has stopped, give artificial respiration. If breathing is difficult, give oxygen. If unconscious, place in the recovery position and seek medical attention immediately. Skin In case of contact, immediately rinse skin with plenty of water. Remove contaminated clothing and shoes. If skin irritation occurs, seek medical attention. Launder contaminated clothing before reuse. Eye In case of contact, immediately rinse eyes with plenty of fresh, clean water for at least 15 minutes. Remove contact lenses if present and continue rinsing. Seek medical attention immediately. Ingestion Do not induce vomiting. Call a physician or emergency medical facility immediately. 4.2. Most important symptoms and effects, both acute and delayed No data available 4.3. Indication of any immediate medical attention and special treatment needed No data available
SECTION 5: Fire-fighting measures 5.1. Extinguishing media Use Carbon dioxide (CO2), dry chemical, or foam to extinguish flames. 5.2. Special hazards arising from the substance or mixture Hazardous Decomposition Products: May form CO and CO2. 5.3. Advice for fire-fighters Self-contained full-face positive pressure breathing apparatus (SCBA) should be used. Water can be used to cool and protect exposed material. Do not allow runoff water and contaminants from fire fighting to enter drains or water courses. SECTION 6: Accidental release measures 6.1. Personal precautions, protective equipment and emergency procedures Avoid contact with spilled material. Use suitable personal protective equipment. Ventilate area if spilled in confined space or other poorly ventilated areas. Evacuate personnel to safe areas. Keep unnecessary personnel away. 6.2. Environmental precautions Prevent entry into sewers and waterways. Report spills as required to appropriate authorities in accordance with all applicable regulations. 6.3. Methods and material for containment and cleaning up Ventilate the area and avoid breathing vapors. Take the personal protective measures listed in section 8. Contain and absorb spillage with non-combustible materials e.g. sand, earth, vermiculite. Place in closed containers outside buildings and dispose of according to the Waste Regulations. (See section 13). Clean, preferably with a detergent. Do not use solvents. Do not allow spills to enter drains or water courses. If drains, sewers, streams or lakes are contaminated, inform the local water company immediately. In the case of contamination of rivers, streams or lakes the Environmental Protection Agency should also be informed. Dispose of in accordance with all federal, state, and local environmental regulations. SECTION 7: Handling and storage 7.1. Precautions for safe handling
Handling Avoid skin and eye contact. Wash thoroughly after handling. Avoid breathing vapor. Use with adequate ventilation. In Storage Store in a dry location at room temperature. Keep this container and vapors from the container away from heat and flame. Keep container closed and maintain all original markings and labels. 7.2. Conditions for safe storage, including any incompatibilities Keep away from strong oxidizing and reducing agents. CAUTION!!! Do not use cutting or welding torches on drums, even when empty. Do not reuse container. Containers, even those that have been emptied will retain product residue and vapors. Always obey hazard warnings and handle empty containers as if they were full. 7.3. Specific end use(s) There are no exposure scenarios, see details in section 1. SECTION 8: Exposure controls/personal protection 8.1. Control parameters The following occupational exposure limits have been established. CAS Number Ingredient Source Value 0000111-20-6 Decanedioic Acid OSHA 0001310-66-3 Lithium hydroxide monohydrate OSHA 0009044-17-1 Butene, polymer with 2-methyl-1- propene 0064741-89-5 Petroleum distillates, solventrefined light paraffinic OSHA OSHA 0064742-52-5 Distillate (petroleum) hydrotreated OSHA
heavy naphthenic 0064742-54-7 PETROLEUM DISTILLATES, HYDROTREATED HEAVY PARAFFIN 0064742-65-0 Distillates (petroleum), solventdewaxed heavy paraffinic Proprietary or N/A Proprietary or N/A Hydroxyl Containing Saturated Fatty Acids OSHA OSHA OSHA Proprietary additive OSHA Contains mineral oil. The exposure limits for oil mist are 5 mg/m3 OSHA PEL and 10 mg/m3. Carcinogen Data CAS No. Ingredient Source Value 0000111-20-6 Decanedioic Acid OSHA Select Carcinogen: No 0001310-66-3 Lithium hydroxide monohydrate OSHA Select Carcinogen: No 0009044-17-1 Butene, polymer with 2-methyl-1-propene OSHA Select Carcinogen: No 0064741-89-5 Petroleum distillates, solvent-refined light paraffinic 0064742-52-5 Distillate (petroleum) hydrotreated heavy naphthenic 0064742-54-7 PETROLEUM DISTILLATES, HYDROTREATED HEAVY PARAFFIN 0064742-65-0 Distillates (petroleum), solvent-dewaxed heavy paraffinic Proprietary or N/A Hydroxyl Containing Saturated Fatty Acids OSHA Select Carcinogen: No OSHA Select Carcinogen: No OSHA Select Carcinogen: No OSHA Select Carcinogen: No OSHA Select Carcinogen: No
Proprietary or N/A Proprietary additive OSHA Select Carcinogen: No DNEL/PNEC values No Data Available 8.2. Exposure controls No special requirements under ordinary conditions of use and with adequate ventilation. Eye/face protection Wear safety glasses. If potential for splash or mist exists, wear chemical goggles or face shield. Skin protection Wear chemical resistant gloves. Gloves should be inspected before each use and discarded if they show tears, pinholes, or signs of wear. Other Gloves, overalls, apron, boots, or other suitable protective garments should be worn to minimize contact based on the task being performed. Respiratory protection Use /OSHA approved respirator where high vapor concentrations are present. Thermal hazards No Data Available SECTION 9: Physical and chemical properties Appearance Odor Odor threshold ph RED GREASE Petroleum Odor Not Measured
Melting point / freezing point (C) Initial boiling point and boiling range (C) Not Measured Flash point (C) >200 Evaporation rate (H20 = 1) Flammability (solid, gas) Not Applicable Upper/lower flammability or explosive limits Lower Explosive Limit: Upper Explosive Limit: Vapor pressure (Pa) Vapor density Heavier than air. Relative density 0.92 Solubility(ies) negligible Partition coefficient n-octanol/water (Log Kow) Auto-ignition temperature (C) Decomposition temperature Viscosity (cst) @ 100 C Not Measured @ 40 C Not Measured Pour point temperature (C) Volatile Organic Compounds nil SADT The data listed above are typical physical and chemical properties that do not constitute product specification. 9.2. Other information DMSO extract by IP346: Less than 3.0 wt % (mineral oil component only) SECTION 10: Stability and reactivity 10.1. Reactivity No data available 10.2. Chemical stability Material is normally stable at ambient temperature and pressure. 10.3. Possibility of hazardous reactions May react with: oxidizing agents. 10.4. Conditions to avoid High temperature, sparks, and open flames. 10.5. Incompatible materials
Keep away from strong oxidizing and reducing agents. 10.6. Hazardous decomposition products Hazardous Decomposition Products: May form CO and CO2. SECTION 11: Toxicological information Acute toxicity The preparation has been assessed using the Acute Toxicity Data listed below, and classified for toxicological hazards accordingly. See section 2 for details. Ingredient Butene, polymer with 2-methyl-1-propene - (0009044-17-1) Oral LD50, mg/kg Skin LD50, mg/kg Inhalation vapor LD50, mg/l/4hr Decanedioic Acid - (0000111-20-6) >5,000, Rat 6,000.00, Rabbit Not Available Distillate (petroleum) hydrotreated heavy naphthenic - (0064742-52-5) Distillates (petroleum), solvent-dewaxed heavy paraffinic - (0064742-65-0) Hydroxyl Containing Saturated Fatty Acids - (Proprietary or N/A) Lithium hydroxide monohydrate - (0001310-66-3) PETROLEUM DISTILLATES, HYDROTREATED HEAVY PARAFFIN - (0064742-54-7) Petroleum distillates, solvent-refined light paraffinic - (0064741-89-5) >5,000, Rat 5,000.00, Rabbit Not Available >2,000, Rat >2,000, Rabbit Not Available >5,000, Rat >5,000, Rabbit Not Available >2,000, Rat >2,000, Rabbit Not Available Proprietary additive - (Proprietary or N/A) Classification Category Hazard Description Acute toxicity (oral) Not Classified Not Applicable Acute toxicity (dermal) Not Classified Not Applicable Acute toxicity (inhalation) Not Classified Not Applicable Skin corrosion/irritation 2 Causes skin irritation Serious eye damage/irritation Not Classified Not Applicable
Respiratory sensitization Not Classified Not Applicable Skin sensitization Not Classified Not Applicable Germ cell mutagenicity Not Classified Not Applicable Carcinogenicity Not Classified Not Applicable Reproductive toxicity Not Classified Not Applicable STOT-single exposure Not Classified Not Applicable STOT-repeated exposure Not Classified Not Applicable Aspiration hazard Not Classified Not Applicable SECTION 12: Ecological information 12.1. Toxicity The preparation has been assessed following the conventional method of the Dangerous Preparations Directive 1999/45/EC and is not classified as dangerous for the environment Aquatic Ecotoxicity Ingredient Distillate (petroleum) hydrotreated heavy naphthenic - (0064742-52-5) Hydroxyl Containing Saturated Fatty Acids - (Proprietary or N/A) Butene, polymer with 2-methyl- 1-propene - (0009044-17-1) Proprietary additive - (Proprietary or N/A) Decanedioic Acid - (0000111-20-6) Lithium hydroxide monohydrate - (0001310-66-3) Petroleum distillates, solventrefined light paraffinic - (0064741-89-5) PETROLEUM DISTILLATES, HYDROTREATED HEAVY PARAFFIN - (0064742-54-7) 96 hr LC50 fish, mg/l 5,000.00, Oncorhynchus mykiss 48 hr EC50 crustacea, mg/l 1,000.00, Daphnia magna ErC50 algae, mg/l 1,000.00 (96 hr), Scenedesmus subspicatus Distillates (petroleum), solvent- 5,000.00, Oncorhynchus 1,000.00, Daphnia 1,000.00 (96 hr), Scenedesmus
dewaxed heavy paraffinic - (0064742-65-0) mykiss magna subspicatus 12.2. Persistence and degradability There is no data available on the preparation itself. 12.3. Bioaccumulative potential Not Measured 12.4. Mobility in soil No data available 12.5. Results of PBT and vpvb assessment This product contains no PBT/vPvB chemicals. 12.6. Other adverse effects No data available SECTION 13: Disposal considerations 13.1. Waste treatment methods Consult federal, state and local regulations regarding disposal methods, recycle used oil. Do not contaminate used oil with solvents or other chemicals. SECTION 14: Transport information 14.1. UN number Not applicable 14.2. UN proper shipping name Corrosive Liquid, n.o.s. 14.3. Transport hazard class(es) US DOT Label ADR/RID Not regulated Not regulated IMDG Not regulated Sub Class Not applicable ICAO/IATA Not regulated
14.4. Packing group Not applicable 14.5. Environmental hazards ADR/RID Environmentally Hazardous: No - Not regulated IMDG Marine Pollutant: No - Not regulated 14.6. Special precautions for user No further information 14.7. Transport in bulk according to Annex II of MARPOL73/78 and the IBC Code Not Applicable The above transport information is provided to assist in the proper classification of this product and may not be suitable for all shipping conditions. Shipping description may vary based on mode of transport, quantities, temperature of the material, package size, and/or origin and destination. For information specific to your situation, consult your company's Hazardous Materials/Dangerous Goods expert. SECTION 15: Regulatory information National Legislation United States: The regulatory data in Section 15 is not intended to be all-inclusive, only selected regulations are represented. All ingredients of this product are listed on the TSCA (Toxic Substance Control Act) Inventory or are not required to be listed on the TSCA Inventory. SARA 311/312 (>0.1%): Not applicable SARA 313 (>0.1%): CERCLA (>0.1%): Not applicable Not applicable Inventory - Canada - Non- Domestic Substances List (NDSL): 2-Naphthalenol, 1-[[4-(phenylazo)phenyl]azo]-, ar-heptyl ar',ar''-me derivitives California Proposition 65 Cancer: 4-methylpentan-2-one Cumene Ethyl benzene
Ethyl acrylate Naphthalene California Proposition 65 Developmental: 4-methylpentan-2-one California Proposition 65 Female Reproductive: California Proposition 65 Male Reproductive: Not applicable Not applicable Inventory - Australia - Inventory of Chemical Substances (AICS): Decanedioic Acid Distillate (petroleum) hydrotreated heavy naphthenic Distillates (petroleum), solvent-dewaxed heavy paraffinic Lithium hydroxide monohydrate Olefin Sulfide PETROLEUM DISTILLATES, HYDROTREATED HEAVY PARAFFIN Petroleum distillates, solvent-refined light paraffinic Phosphoric acid esters, amine salt Inventory - Japan Existing and New Chemical Substances (ENCS): Decanedioic Acid (2-878) Distillate (petroleum) hydrotreated heavy naphthenic () Distillates (petroleum), solvent-dewaxed heavy paraffinic (9-1702) PETROLEUM DISTILLATES, HYDROTREATED HEAVY PARAFFIN () Petroleum distillates, solvent-refined light paraffinic (9-1700) Korean Existing Chemicals Inventory: Decanedioic Acid Distillate (petroleum) hydrotreated heavy naphthenic Distillates (petroleum), solvent-dewaxed heavy paraffinic PETROLEUM DISTILLATES, HYDROTREATED HEAVY PARAFFIN Petroleum distillates, solvent-refined light paraffinic Inventory of Existing Chemical Substances in China:
Olefin Sulfide PETROLEUM DISTILLATES, HYDROTREATED HEAVY PARAFFIN Phosphoric acid esters, amine salt Philippines Inventory of Chemicals and Chemical Substances (PICCS) : Butene, polymer with 2-methyl-1-propene Decanedioic Acid Distillate (petroleum) hydrotreated heavy naphthenic Distillates (petroleum), solvent-dewaxed heavy paraffinic Lithium hydroxide monohydrate Olefin Sulfide PETROLEUM DISTILLATES, HYDROTREATED HEAVY PARAFFIN Petroleum distillates, solvent-refined light paraffinic Phosphoric acid esters, amine salt Taiwan List of Toxic Chemical Substances regulated under Toxic Chemical Substances Control Act : EU REACH: Annex XVII, Dangerous Substances and Preparations: Not applicable Distillate (petroleum) hydrotreated heavy naphthenic Distillates (petroleum), solvent-dewaxed heavy paraffinic PETROLEUM DISTILLATES, HYDROTREATED HEAVY PARAFFIN Petroleum distillates, solvent-refined light paraffinic Inventory - European Union - European Inventory of Existing Commercial Chemical Substances (EINECS): Decanedioic Acid (203-845-5) Distillate (petroleum) hydrotreated heavy naphthenic (265-155-0) Distillates (petroleum), solvent-dewaxed heavy paraffinic (265-169-7) Olefin Sulfide () PETROLEUM DISTILLATES, HYDROTREATED HEAVY PARAFFIN (265-157-1) Petroleum distillates, solvent-refined light paraffinic (265-091-3) Phosphoric acid esters, amine salt () EU List of Notified Chemical Not applicable
Substances (ELINCS): Risk Phrases Not Classified. SECTION 16: Other information This information has been compiled from sources considered to be dependable and is accurate to the best of Lubricating Specialties Company knowledge. Lubricating Specialties Company makes no warranty whatsoever, expressed or implied, of MERCHANTABILITY OR FITNESS FOR THE PARTICULAR PURPOSE, regarding the accuracy of such data or the results to be obtained from the use thereof. Lubricating Specialties Company assumes no responsibility for injury to recipient or third persons, or for any damage to any property and recipient assumes all such risks. The full text of the phrases appearing in section 3 is: H304 May be fatal if swallowed and enters airways H314 Causes severe skin burns and eye damage H335 May cause respiratory irritation End of document