TRACTOR - - MODEL NUMBER PDH4ST (PDH4STB) SCHEMATIC RED BATTERY A AMMETER (OPTIONAL) RED FUSE RED M STARTER WHITE RED B G L S M A A CLUTCH / BRAKE (PEDAL UP) SOLENOID WHITE IGNITION SWITCH WHITE SEAT SWITCH (NOT OCCUPIED) BLUE HOUR METER (OPTIONAL) FUEL LINE ATT'MENT CLUTCH (CLUTCH OFF) IGNITION UNIT GROUNDING CONNECTOR SPARK PLUG GAP ( PLUGS ON TWIN CYL. ENGINES) CHARGING SYSTEM OUTPUT 3 AMP DC @ 300 RPM VOLTS AC MIN. @ 300 RPM (CHARGING SYSTEM DISCONNECTED) FUEL SHUT-OFF SOLENOID (IF SO EQUIPPED) ORANGE RED LIGHTING SYSTEM OUTPUT AMP AC @ 300 RPM DIODE ALTERNATOR IGNITION SWITCH POSITION CIRCUIT MAKE OFF M+G+A NONE RUN/LIGHT B+A A+L RUN B+A NONE START B + S + A NONE NOTE YOUR TRACTOR IS EQUIPPED WITH A SPECIAL ALTERNATOR SYSTEM. THE LIGHTS ARE NOT CONNECTED TO THE BATTERY, BUT HAVE THEIR OWN ELECTRICAL SOURCE. BECAUSE OF THIS, THE BRIGHTNESS OF THE LIGHTS WILL CHANGE WITH ENGINE SPEED. AT IDLE THE LIGHTS WILL DIM. AS THE ENGINE IS SPEEDED UP, THE LIGHTS WILL BECOME THEIR BRIGHTEST. 7 4 VOLTS AC MIN. @ 300 RPM (LIGHTS OFF) BROWN HEADLIGHTS NON-REMOVABLE CONNECTIONS REMOVABLE CONNECTIONS WIRING INSULATED CLIPS NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE REPLACED TO PROPERLY SECURE YOUR WIRING.
TRACTOR - - MODEL NUMBER PDH4ST (PDH4STB) ELECTRICAL 4 4 4 43 7 7 40 7 7 33 30 D.C. AMPERES 4 9 7 90
TRACTOR - - MODEL NUMBER PDH4ST (PDH4STB) ELECTRICAL 34 Battery 74704 Bolt Hex Hd /4-0 unc x 3/4 79 Box Battery 7 Switch Interlock 379 Harness Socket Light 4J Bulb, Light # 4 4799J Cable Battery 447 Cable Battery Ga. Red w/ wire 44" 7 Fuse 7 730400 Nut Keps Hex /4-0 unc 407J Cable Ground " Blk Ga. 9 0X Switch Plunger Nc Gray 30 7 Switch Ign 33 4040 Key Ign Molded Generic 40 7970 Harness Ign 4 7040 Bolt Fin Hex /4-0 unc x / 4 3 Cover Terminal Red 43 7 Solenoid 4 433X Ammeter Rectangular 4940 Protection Loop 90 0449 Cover Terminal inch =.4 mm 9
CHASSIS TRACTOR - - MODEL NUMBER PDH4ST (PDH4STB) 9 4 3 7 9 30 4 39 4 3 09 09 9 09 0 0 07 4 09 09 33 0 3 4 37 4 37 09 4 09 0 0 09 4 3 4 3 34 chassis_elite sv_pro_4 30
CHASSIS TRACTOR - - MODEL NUMBER PDH4ST (PDH4STB) 749 Chassis 74 Drawbar 7 Bumper Hood/Dash 9 74X0 Dash P/L 0 7400 Bolt Carriage 3/- x 7499 Panel Dash Lh 7974X00 Panel Dash Rh 4 74900 Screw Thdrol 3/- x / 7 3393X4 Hood 93X Bumper Hood 4 7470 Bolt Fin Hex 3/- unc x Gr. 730000 Nut Lock Hex W/Ins 3/- unc 3 Grille/Lens Asm 30 9470X4 Fender 3 9 Bracket Fender 33 797X4 Footrest LH 34 7977X4 Footrest RH 3 700 Bolt RDHD SHT SQNK 3/- x 3/4 37 74900 Screw Thdrol /- x / TYT 3 770 Bracket Asm Pivot Mower Rear 39 7474 Bracket Pivot 43 Duct Air 4 479 Dash Lower STLT 4 770 Plate Reinforcement STLT 4 4 Rod Pivot Chassis/Hood 9 9473X4 Cupholder 77 Screw Hwhd Hi-Lo #- x 3/4 0 70 Bolt Shoulder /- 0 7700 Screw Thdrol 3/- x / 09 7000 Screw Hexwsh Thdr 3/- x 3/4 33X99 Lens Grille Pro RH 9 334X99 Lens Grille Pro LH 39Z4 Insert Grille 3 33 Bezel Grille LH 4 333 Bezel Grille RH - - 479J Plug BTN BlK - - 70 Plug Dome Plastic inch =.4 mm 3
3 TRACTOR - - MODEL NUMBER PDH4ST (PDH4STB) DRIVE 9 3 30 3 9 3 4 3 3 3 3 3 39 34 77 77 30 4 3 70 7 9 4 7 7 7 74 7 37 0 3 47 4 3 4 7 4 0 49 47 0 0 3 4 0 3 9 9 9 0 97 9 9 90 9 drive-hydro_7
DRIVE TRACTOR - - MODEL NUMBER PDH4ST (PDH4STB) - - - - - - Transaxle Peerless LTH 000 (Order Parts From Transaxle Manufacturer) 9 Rod Shift 0 7004 Pin Cotter / x CAD 4 0040400 Washer Lock Hvy Helical 7449044 Bolt, Hex FLGHD /- Gr. 730000 Nut Lock Hex W/Ins /- unc 9 730000 Nut Lock Hex W/Wsh 3/- unc 404 Knob, Round /- 74 Rod, Brake Hydro 4 733000 Nut 0X Spring, Brake Rod 7 7004 Pin Cotter / x 3/4 CAD. 77 Rod, Parking Brake 9 773 Cap, Parking Brake 30 99 Bracket, Transaxle 3 7470 Bolt Hex Hd /- unc x 3/4 34 77 Shaft, Foot Pedal 3 03X Bearing, Nylon 3 9 Washer 37 7H Pin, Roll 3 794 Pulley, Composite 39 70 Bolt Rdhd 3/- unc x -3/4 Gr. 4 7 Keeper, Belt Idler 47 773 Pulley, Idler, V-Groove 4 4407 Bellcrank Clutch Grnd Drv STL 49 0X Retainer, Belt 0 70 Bolt Carr Sh 3/- x -/ Gr. 73000 Nut Crownlock 3/- unc 73000 Nut Crownlock /- unc 3 070X Link, Clutch 0709X Spring, Return, Clutch 7000 Screw 3/- x -/4 7 7 V-Belt, Ground Drive 9 99 Keeper, Center Span 704 Screw 3/- x.7 3R Cover, Pedal 3 740 Pulley, Engine 4 73937 Bolt Hex 7/-0 x 4 x Gr. -. Thr 0040700 Washer 477 Keeper Belt Engine 70 43 Guide Belt 74 707 Spacer, Axle 7 749X Washer /3 x -/4 x Ga. 7 00000 E-Ring 77 3X Key, Square 7 74X Washer /3 x -/ x Ga. 79 Shaft Asm. Cross Hydro 7X Spring Torsion T/A 3 97 Washer 7/3 x 3/4 x Ga. 030 Nut Lock Center /4-9 9373X4 Console, Shift 90 443 Screw Hex Wsh Hi-Lo /4-/ unc 9 74 Disconnect Asm. Rod Bypass LTH 9 4497H Retainer Spring " Zinc/Cad 9090 Washer 9/3 x 3/4 x 0 Ga. 7400 Bolt RDHD SQNK 3/- unc x 0 7390000 Nut Lock Flg 3/- unc 0 74 Spacer Retainer 930 Washer /3 x x 0 Ga. 00 Washer Srrted / ID x. 9 Bracket Shift Mount 9 3900 Hub Shift 74040 Bolt Rdhd Sqnk /4-0 x 3/4 Gr. 730400 Nut Crownlock /4-0 unc 3 74704 Bolt Hex Fin /4-0 unc x Gr. 3 Bracket Pivot Lever 74900 Screw /- x / 49 Bolt Shoulder /- x. 9 0 Plate Fastening Lt 97 9 Nyliner Snap-In /" ID 9 993 Washer Nyl 7/ ID x.0 0 704 Bolt Carr Sh 3/- x -3/4 Gr. 4 Nut Hex flange Lock 4 7 Strap Torque LH 4 7 Strap Torque RH 47 4 Link Shift Transaxle 700 Screw /- x 9 Washer /3 x x Ga. 3 7000 Screw Hex Wsh Thdr 3/- x 3/4 inch =.4 mm 33
TRACTOR - - MODEL NUMBER PDH4ST (PDH4STB) STEERING ASSEMBLY 3 39 4 4 37 37 3 44 4 9 43 7 7 7 9 4 7 7 4 7 3 3 7 9 4 43 9 40 0 30 43 9 steering_pl.lt_47 34
TRACTOR - - MODEL NUMBER PDH4ST (PDH4STB) STEERING ASSEMBLY 4704X4 Wheel Steering 470 Axle Asm Cast Iron LT 3 940 Spindle Asm LH 4 939 Spindle Asm RH H Bearing Race Thrust Harden 74X Washer /3 x -/ x Ga. 00009 Ring Klip #t304-7 0 7 Link Drag 004000 Washer Lock Hvy Hlcl Spr 3/ 7394000 Nut Hex Jam Toplock /-0 unf Spacer Brg Axle Front 4 Nut Hex Flange Lock 7 04 Shaft Asm Steering 47X Bushing Link Drag 94 Washer /3 x 7/ x Ga. 9 7000 Screw 3/- x.7 30 7004 Pin Cotter / x 3/4 3 04 Rod Tie 3 099 Bushing Strg 37 97 Screw 3 994X4 Insert Cap Strg Wh 39 94 Washer 9/ x /0 x Ga. 40 734000 Crownlock nut 4 994 Adaptor Wheel Strg 4 404X4 Boot Steering Dash 43 749X Washer /3 x /4 x Ga. 44 040 Extension Steering Shaft 4 X Cap Spindle Fr Top Blk 7340400 Nut Crownlock /4-4 7040 Bolt Hex /4- unf x -/4 Gr. 037 Spacer Brace Axle 7 70 Bolt RDHD SQNK 3/- x /4 7 74 Steering Asm 97 Axle, Brace 93 Bracket Susp Chassis Front 7 739 Washer Flat.7 x -/ x.4 7 Bolt Shoulder 7/-0 unc 9 73 Clip Steering 9 97 Washer Harden.739 x.37 x.00 inch =.4 mm 3
TRACTOR - - MODEL NUMBER PDH4ST (PDH4STB) SEAT ASSEMBLY 4 0 9 7 9 7 4 seat_lt.knob_ 7 4 3 7 Seat 40 Bracket Pivot Seat 70 3 70 Bolt Fin Hex 3/- unc x 4 90 Washer /3 x x 0 Ga. 400 Clip Push-In 730000 Nut Hex w/ins. 3/- unc 7 4X Spring Seat Cprsn 0 Blk Zi 7000 Screw 3/- x. Smgml 9 94 Washer /3 x x 4 Ga. 0 493 Pan Seat 39 Knob Seat 4X Bracket Mounting Switch 4X Bushing Snap Blk Nyl 0 Id 4 7004 Bolt Rdhd Sqnk /4-0 x -/ 4300 Spacer Split x 0X Spring Cprsn 7 97X Nut Lock /4 Lge Flg Gr. Zinc 7 Bolt Shoulder /- unc 730000 Nut Hex Lock W/Ins /- 4 979 Washer 7/3 x -3/ x Ga. 70X Bolt Shoulder /- x inch =.4 mm 3
DECALS TRACTOR - - MODEL NUMBER PDH4ST (PDH4STB) 7 4 4 3 0 0 9 4 703 Decal Oper 3 4 Decal Hood LH 4 99 Decal Side Panel Logo 9 Decal HP Engine 703 Decal Warning, Keep Hand Away 7 909 Decal Replacement Parts 79 Decal Deck "B" 4" 9 7740 Decal Fender Logo 0 740 Decal Fender Danger E/F 7743 Decal Ins Strg Whl 737 Decal Fend Reflector Rh 739 Decal Fend Reflector Lh 4 039 Decal V-Belt Schematic 3 Decal Hood Rh 0 400 Decal Bat Dan/Psn - - 797X4 Pad Footrest LH - - 7979X4 Pad Footrest RH - - 739 Decal Chass Disconnect LTH 000 - - 3 Decal Handle Lft Height Adjust - - 90944 Manual Owner's (English) - - 9094 Manual Owner's (French) WHEELS AND TIRES, 7 4,0 3,9 99 Cap Valve Tire 9 Stem Valve 3 0X Tire F T x 0 - Service 4 9904 Tube Front (Service Item Only) 073X4 Rim Asm " front Service 7H Fitting Grease (Front Wheel Only) 7 9040H Bearing Flange (Front Wheel nly) 00X4 Rim Asm " rear Service 9 0X Tire R T 0 x 0- Service 0 7J Tube Rear (Service Item Only) 0477X4 Cap Axle Blk 0 x 00 - - 44334 Sealant, Tire ( 0 oz. Tube) inch =.4 mm 37
ENGINE TRACTOR - - MODEL NUMBER PDH4ST (PDH4STB) 3 7 4 7 3 3 4 44 7 4 33 3 37 33 4 9 3 OPTIONAL EQUIPMENT Spark Arrester engine-bs.cyl_4 70 Control, Throttle 77040 Screw Hex Thd Cut /4-0 x / 3 - - - - - - - Engine Briggs Model 3P777 (Order Parts from Engine Mfg.) 4 73 Muffl er 9 Muffl er Gasket 4 44 Tube Oil Drain 3 937 Shield, Browning/Debris Guard 9 70 Arrester, Spark 3 34 Tank, Fuel 3 407 Cap, Fuel 33 47X Clamp, Hose Blk 37 7040 Line, Fuel 3 4 Plug Drain Oil Easy 44 7704 Screw Hex Wsh THDROL /4-0 x 3/4 3 4 7000 Screw Hex Wsh Thdrol 3/- x 3/4 4 9094 Washer 9/3 x 7/ x Ga. 7 390 Screw Socket Head /- x 7 7000 Screw 3/- x -/4 730400 Nut Keps Hex /4-0 unc inch =.4 mm For engine service and replacement parts, call the toll free number for your engine manufacturer listed below: Briggs & Stratton -00-33-373 Kohler Co. -00-44-444 Tecumseh Products -00--40 Honda Engines -00-4-770 Kawasaki -949-40-
TRACTOR - - MODEL NUMBER PDH4ST (PDH4STB) MOWER LIFT 7 4 3 4 9 0 0 7 0 3 3 3 3 9 0 lift-rh.piece_3 94 Wire Asm Inner/Sprg W/plunger 947 Shaft Asm Lift RH w/inf 3 Pin Groove / Dia x.7 4 00000 E Ring #3-9 Washer /3 x x Ga. 03X Bearing Nylon Blk 9 Id 7 3X Grip Handle 4X Button Plunger 9 Link Lift LH Fixed Length 9 Link Lift RH Fixed Length 4939M Retainer Spring 73 Link Front 733000 Nut Jam Hex /- unc 7 79 Trunnion 730000 Nut Lock W/Wsh /- unc 9 9 Arm Suspension Rear 0 3 Retainer Spring 3 9 Bearing Pvt Lift 3 734000 Nut Crownlock 3/ - 4 inch =.4 mm 39
40 4 0 9 30 3 3 33 4 4 4 0 4 44 47 47 4 49 4 4 3 34 4 44 4 7 9 3 0 4 9 9 4 3 40 43 3 40 40 9 40 4 4_deck_man-t-path_4. 9 9 7 4 4 7 9 TRACTOR - - MODEL NUMBER PDH4ST (PDH4STB) MOWER DECK 7 4_clutch_mod_7 0 0 04 03 0 0 04 0 0 03 0
TRACTOR - - MODEL NUMBER PDH4ST (PDH4STB) MOWER DECK 03X4 Mower Deck Assembly, 4" 7400 Bolt 3 07 Bracket Asm Fr. Sway Bar 3/4 4 40 Bracket Asm Deck 4" Sway Bar 4939M Retainer Spring 704 Bar Sway Deck 07 Bolt 3/-4 x. Gr. patched 9 003000 Washer, Lock 0 409 Washer, Hardened (The following Blades are available) 449 Blade, Mulching 4 Std (for mulching mowers only) - - 977 Blade Mulching 4 Premium (For better wear when mulching) - - 97 Blade Mower 4 Hi-Lift (for bagging and discharging) 74 Shaft As sembly, Mandrel, Vented 4 774 Housing, Mandrel, Vented 04X Bearing, Ball, Mandrel 74493 Stripper, Mandrel Deck 7400 Bolt, Carriage /- x / 9 7 Bolt, Shoulder 0 9770 Baffl e, Vortex 73000 Nut 3 773 Bracket, Deflector Mower 4" 4 0304X Cap, Sleeve 0 x Blk Mower 7X Spring, Torsion, Deflector 04X Nut, Push Phos & Oil 7 09X4 Shield, Deflector 4" Blk 90 Washer /3 x / x Ga. 9 49 Rod, Hinge 4" 7 W/G 30 7394 Screw Thdrol 3 790 Washer, Spacer Mower Vented 3 7343 Pulley, Mandrel 33 734 Nut, Toplock 34 70 Bolt Carr SH 3/- x -/ Gr. 3 7343 Pulley, Idler, Flat 40 7390000 Nut Lock 3/- 44 400 Guard, Mandrel, LH 4 4497H Retainer 4 779 Screw, Thdrol /4-0 x / T 4 3944 Washer, Hardened 9 Bolt, Shoulder /- unc 3 4907 Arm Assembly, Pad, Brake 4 7 Washer, Hardened 04 Arm, Idler 0X Spacer, Retainer 9 7344 Guard TUV Idler 7 79 Knob Round 4499 V-Belt, 4" Mower 0 40 Mulcher Cover 0 7000 Screw, Pan Hd Phillip 0-4 x / 03 90 Washer, Flat 04 007000 Washer, Lock 0 0793 Latch Assembly 0 09J Nut, Weld 700 Screw /- x 3/4 49 Bolt, Shoulder 7 397 Wheel, Gauge 7393000 Nut Centerlock 3/- 9 944 Washer 3/ x 7/ x 4 Ga. 4 94 Pin Head Rivet 97X4 Bracket Asm. Whl Ga. R LH 9 Bar Adjusting Gauge Wheel 973X4 Bracket Asm Whl Ga. R RH 9 977X4 Bracket Asm. Whl Ga. F RH 40 97X4 Bracket Asm Whl Ga. F LH 4 90 Arm Spring Brake Mower 43 709 Bracket Arm Idler 4" 44 7344 Keeper Belt 4" Clutch Cable 4 73437 Pulley Idler Flat 4 73443 Bolt Carriage Idler 47 3 Spring Extension 4 90 Spring Return Idler 49 9 Retainer Spring Yellow 0 9090 Washer 9/3 x 3/4 x 0 Ga. 97 Clutch Cable 4" 77040 Screw Hex Thd Cut /4-0 x / 9 7404 Bolt Rdhd Sqn 3/- unc x -3/4 4 940 Washer /3 x 7/ x 0 Ga. 34 Head Asm Cable Clutch - - 0794 Mandrel Assembly (Includes Housing Shaft and Shaft Hardware Only - Pulley Not Included) - - 97 Replacement Mower, Complete (Std. deck Order separately mulcher cover and gauge wheel components Key Nos. 0-0 and - 9) inch =.4 mm 4