RYOBI Item No. RYiLP Mfg. No. 000 Replacement Parts List 000 -- (Rev:0) TECHTRONIC INDUSTRIES POWER EQUIPMENT Pearman Dairy Road Anderson, SC USA -00-0-00
FIGURE A RYOBI DIGITAL INVERTER GENERATOR MODEL NO. RYiLP 0 0 0 See Figure B See Figure C 0 0 0 0
RYOBI DIGITAL INVERTER GENERATOR MODEL NO. RYiLP The model number will be found on a label attached to motor housing. Always mention the model number in all correspondence regarding your DIGITAL INVERTER GENERATOR or when ordering replacement parts. FIGURE A PARTS LIST NOTE Engine... 00 Side Engine Isolator... 00000 Rubber Washer (ID. x OD. x t)... 000000 Lock Flange Nut (M)... 000 Starter Cover... 000 Recoil Handle... 000 Recoil Handle Cover... 000 Recoil Handle Support... See Figure B Control Panel Assembly... 0000000 Stepper Motor Extended Wire Harness... See Figure C Fuel System & Bracket Assembly... 000 Panel Housing (Right)... 000000 U-Clip... 00 Screw (M x mm, T- Torx Pan Hd.)... 00 Rubber Grommet Handle... 00 Rubber Grommet... 00 Rubber Foot w/metal Insert... 000 Panel Housing (Left)... 0000 Maintenance Panel (Left)... 0 000 Maintenance Panel (Right)... 00 Rubber Grommet... 000 Internal Tooth Washer (ID)... 000 Spark Plug Door... 00 Screw (M x mm, T- Torx Pan Hd.)... 00 Fuel Hose Clamp... 00 E-Clip Lock Washer... 00 Rubber Handle (Upper)... 0 Side Lock (U-Shaped)... 000 Muffler Cover... 0 00 Screw (M x mm, T- Torx Pan Hd.)... 0 Washer (ID. x OD x t)... 00 Screw (M x mm, T- Torx Pan Hd.)... Not Shown: 000 Propane Hose Adapter 00 Spark Plug Wrench 000 Screw Driver 000 Operator s Manual NOTE: OWT Industries, Inc., will not provide engines as replacement parts. Engines are covered through the engine manufacturer s warranty. Consult the accompanying engine manual or contact our service department for assistance. * Not all parts shown on the exploded view are available. Some parts are shown to identify position and location of parts that are available.
FIGURE B RYOBI DIGITAL INVERTER GENERATOR MODEL NO. RYiLP
RYOBI DIGITAL INVERTER GENERATOR MODEL NO. RYiLP The model number will be found on a label attached to motor housing. Always mention the model number in all correspondence regarding your DIGITAL INVERTER GENERATOR or when ordering replacement parts. FIGURE B PARTS LIST 00 Screw (M x mm, Flat Hd.)... 00000000 Wingnut (M)... 00 Washer (ID x OD x.t)... 0 Washer (ID. x OD x t)... 00 Lock Nut (M)... 00000 On/Off Switch... 00 Screw (M x mm, T-0 Torx Pan Hd.)... 00 Indicator (Red LED)... 000 Reset Button... 0000 V-A Single Receptacle... 0000 Control Panel Label... 000 Control Panel Faceplate... 00 Lock Nut (M)... 00 Screw (M x mm, Flange Hex Hd.)... 000 Control Panel Housing... 00 Rubber Grommet... 0000 Ignition Module (00W)... 0 Washer (ID. x OD x t)... 00 Screw (M x mm, T- Torx Pan Hd.)... Not Shown: 0000000 Unit Wire Harness 0000 AC Socket Wire Harness 000 Overload/Momentary Switch Wire Harness
RYOBI DIGITAL INVERTER GENERATOR MODEL NO. RYiLP FIGURE C SEE FIGURE D FIGURE D Note: add loctite on the hose's thread prior to assembly
RYOBI DIGITAL INVERTER GENERATOR MODEL NO. RYiLP The model number will be found on a label attached to motor housing. Always mention the model number in all correspondence regarding your DIGITAL INVERTER GENERATOR or when ordering replacement parts. FIGURE C PARTS LIST 00 Screw (M x mm, T- Torx Pan Hd.)... 0 Washer (ID. x OD x t)... 000 Metal Cover... 0 Rubber Pad... 00 Screw (M x mm, T-0 Torx Pan Hd.)... 0 Washer (ID. x OD x 0.t)... 000 LP Tank Assembly... 0 Metal Tube... 000 Screw (M x mm, T- Torx Pan Hd.)... 00 Screw (M x mm, T- Torx Pan Hd.)... 00 Rubber Support... 00 Bracket... 0 Inverter Module (00W)... 00 Bolt (/ in. x 0-/ in., Flanged Hex Hd.)... FIGURE D PARTS LIST 0 Propane Regulator (nd Stage)... 0 Propane Regulator (st Stage)... 0 Propane Fuel Hose... 000 Propane Fuel Hose... NOTE: OWT Industries, Inc., will not provide engines as replacement parts. Engines are covered through the engine manufacturer s warranty. Consult the accompanying engine manual or contact our service department for assistance. * Not all parts shown on the exploded view are available. Some parts are shown to identify position and location of parts that are available.
FIGURE E RYOBI DIGITAL INVERTER GENERATOR MODEL NO. RYiLP FIGURE F 0
RYOBI DIGITAL INVERTER GENERATOR MODEL NO. RYiLP The model number will be found on a label attached to motor housing. Always mention the model number in all correspondence regarding your DIGITAL INVERTER GENERATOR or when ordering replacement parts. FIGURE E PARTS LIST 0000000 Screw (M 0 mm)... 00000 Cylinder Head Cover... 00000 Cylinder Head Cover Seal... 000 Valve Oil Seal... 000000 Dual-Head Bolt (M 0 mm)... 00000 Dual-Head Bolt (M mm)... 000000 Cam... 000000 Screw (M mm)... 0000 Upper Crankcase... 00000 Washer (ID0 OD t)... 0000 Oil Seal... 00 Oil Gauge... 0 Oil Gauge Gasket... 00000000 Dowell Pin... 00000 Ventilation Nozzle... 0000 Lower Crankcase... 0000000 Screw (M mm)... 00000000 Screw (M 0 mm)... 000 Rubber Valve... 0 000000 One-Way Valve Component... 0000 Dual-Head Bolt (M mm)... 00000 Bolt (M mm, Flange Hex Hd.)... 0000 Aluminium Gasket... 0000 Oil Pan... 0000 Oil Level Sensor... 000000 Screw (M mm)... FIGURE F PARTS LIST 000000 Bushing... 0000 Cam Assembly... 00000 Rocker Gasket... 000000000 Pin (G 0 mm)... 000000000 Pin (G 0 mm)... 0000000 Lower Rocker... 0000000 Tappet... 0000000 Upper Rocker Assembly... 000000 Pin (G mm)... 0000000 Valve Spring Seat... 0000000 Valve Spring... 000000 Intake Valve... 0000000 Exhaust Valve... NOTE: OWT Industries, Inc., will not provide engines as replacement parts. Engines are covered through the engine manufacturer s warranty. Consult the accompanying engine manual or contact our service department for assistance. * Not all parts shown on the exploded view are available. Some parts are shown to identify position and location of parts that are available.
RYOBI DIGITAL INVERTER GENERATOR MODEL NO. RYiLP FIGURE G FIGURE I FIGURE H FIGURE J b a
RYOBI DIGITAL INVERTER GENERATOR MODEL NO. RYiLP The model number will be found on a label attached to motor housing. Always mention the model number in all correspondence regarding your DIGITAL INVERTER GENERATOR or when ordering replacement parts. FIGURE G PARTS LIST 0000000 Connecting Rod... 00000 Woodruff Key... 000000 Piston Pin Clip... 0000000 Piston Pin... 000 Needle Bearing (K)... 000 Piston... 00000 Piston Ring... FIGURE I PARTS LIST 000000 Bolt (M mm)... 000000 Muffler... 00000 Muffler Pipe Gasket... 000000 Bolt (M mm)... 000000 Muffler Gasket... 0000000 Muffler Pipe... 0000000000 Washer (M)... 0000000 Hex Flange Nut (M)... FIGURE H PARTS LIST 00000 Deaerator... 0000000 Hose Clip ()... 000000 Respiratory Hose... 000000 Outlet Tube... 0000000 O-Ring... 000000 Bolt (M mm, Flange Hex Hd.)... 00000 Upper Lubricant Hose... 000000 Hose Clip ()... FIGURE J PARTS LIST 000000 Air Filter Assembly (Inc. Key Nos. a-b)... a 00000 Foam... b 0000 Chrome Plated Screw (Big Head)... 0000000 Air Filter Gasket... 0000000 Carburator Gasket... 0000000 Bolt (M mm, Flange Hex Hd.)... 000000 Insulation Board Component... 0000000 Bolt (M mm, Flange Hex Hd.)... 000000 Rubber Block... 0000 Insulation Board Gasket... 00000 Fan Volute Bushing... 00000000 Nut (M)... 0000 Screw (M. mm)... NOTE: OWT Industries, Inc., will not provide engines as replacement parts. Engines are covered through the engine manufacturer s warranty. Consult the accompanying engine manual or contact our service department for assistance. * Not all parts shown on the exploded view are available. Some parts are shown to identify position and location of parts that are available.
RYOBI DIGITAL INVERTER GENERATOR MODEL NO. RYiLP FIGURE K FIGURE M FIGURE L
RYOBI DIGITAL INVERTER GENERATOR MODEL NO. RYiLP The model number will be found on a label attached to motor housing. Always mention the model number in all correspondence regarding your DIGITAL INVERTER GENERATOR or when ordering replacement parts. FIGURE K PARTS LIST 00000 Vaporizer... 000000 Stepper Motor... 00000 Screw (M x mm)... FIGURE L PARTS LIST 00000 Locating Plate... 0 Stator Assembly (Inc. Key No. a)... 0000000000 Washer (M)... 0000000 Bolt (M mm, Flange Hex Hd.)... 00 Rotor... 0000000 Hex Flange Nut (M)... 00000000 Bolt (M mm, Hex Flange Hd.)... 000000 Trigger... 0000 Ignition Coil... 0000 Screw (M. mm)... 000000 Ignition Coil Cap Seal... 000000 Spark Plug (CMRA)... Not Shown: a 000000 Bushing FIGURE M PARTS LIST 0000 Air Guide Sleeve (A)... 0000 Air Guide Sleeve (B)... 0000 Bolt (M. mm)... 00000 Pad... 0000 Cooling Fan... 0000000 Starting Hub... 00000 Screw (M mm, Hex Hd.)... 00000 Fan Volute... 000000 Recoil Starter... 00000000 Recoil Starter Bushing... 000 Bolt (M mm, Flange Hex Hd.)... NOTE: OWT Industries, Inc., will not provide engines as replacement parts. Engines are covered through the engine manufacturer s warranty. Consult the accompanying engine manual or contact our service department for assistance. * Not all parts shown on the exploded view are available. Some parts are shown to identify position and location of parts that are available.
FIGURE N RYOBI DIGITAL INVERTER GENERATOR MODEL NO. RYiLP
RYOBI DIGITAL INVERTER GENERATOR MODEL NO. RYiLP The model number will be found on a label attached to motor housing. Always mention the model number in all correspondence regarding your DIGITAL INVERTER GENERATOR or when ordering replacement parts. FIGURE N PARTS LIST 00 Combustion Label... 00 Maintenance Label... 000 Hot Surface Label (English/Spanish)... 000 Hot Surface (French)... 0 Warning Hangtag... 0 Storage Tips Label... 00 CPSC Label (English)... 000 CPSC Label (French/Spanish)... 00 Inquiries Label... 0 Starting Instructions Label... 000 LP Warning Label... 0 Primer Button Label... 00 Fire Distance Label... 0 Primer Button... 0 Performance Label (Bottom)... 0 Primer Reminder Label... 0 Logo Label... 0 Performance Label (Top)... 000 Lubricant Label...
SPRING WINDING OIL SENSOR R Pl Br RYOBI DIGITAL INVERTER GENERATOR MODEL NO. RYiLP TO GENERATOR HEAD CONTROL PANEL BLOCK MAIN WINDING BL BL BL INVERTER UNIT BL W GROUND TERMINAL V OUTLET SUB WINDING W W OUTPUT RESET Bu R Y/G IGNITION WINDING Y/G BL BR GR BU Y/G W P O R OVERLOAD OUTPUT OVERLOAD LOW OIL O Bu IGNITION CONTROLLER M STEPPER MOTOR ASSEMBLY W BL BL W P O P Y/G R Y/G ENGINE BLOCK SPARK PLUG IGNITION COIL G W Bu Y R PI Green White Blue Yellow Red Pink WIRES COLOR CODES O BI P Br Gr Y/ G Orange Black Purple Brown Gray Yellow / Green WIRING DIAGRAM