MTS-T4-6 APU Warranty SRT Time Guide (Caterpillar/Perkins Engines) Air Conditioning System A/C Condenser Replacement RP9-011 A/C Condenser 2.5 RP9-027B Receiver/Dryer Filter 0.5 A/C Compressor Replacement RP9-132 A/C Compressor 1.0 RP9-027B Receiver/Dryer Filter 0.5 A/C Hose and Schrader Valve Replacement RP9-121 Schrader Valve 0.2 RP9-400 Compressor to Condenser Hose (Discharge) 0.3 RP9-401 Bulkhead to Compressor (Suction) 0.5 RP9-402 Condenser to Bulkhead Hose (Liquid) 0.3 RP9-403 Bulkhead to Receiver/Dryer 0.5 RP9-404 Bulkhead to Evaporator (Discharge) 0.7 RP9-405 Bulkhead to Evaporator (Suction) 0.7 RP9-014 #10 O-ring 0.0 Receiver/Dryer Filter Cartridge Replacement RP7027B Receiver/Dryer Filter with Valve 0.5 Note: Please provide compressor serial numbers when filing a warranty claim along with full diagnosis and pressures. August 2015 RigMaster Power International Ltd. Page 1 of 5
Engine Cooling System RP5-028 Radiator 2.5 RP12-048 Radiator Rubber Mount 0.0 Cooling System (Glycol) Pressure Test 0.5 Hose Clamps 0.0 Coolant 0.0 RP5-024 Upper Radiator Hose 0.3 RP5-027 Lower Radiator Hose 1.0 RP5-017 Coolant Reservoir Hose 0.2 RP5-018 5/8" x 6 3/4" hose 0.2 RP5-018b 5/8 x 14" hose 0.2 RP5-011 Hose Fitting 5/8 x 14" Straight 0.2 Cooling System (Glycol) Pressure Test 0.5 RP5-029 Rad Cap -13psi (includes Pressure Testing Cooling System) 0.2 RP5-1002-AL Aluminum Overflow Tank 0.3 Mounting Brackets & Stiffeners, and APU Cover RP10-001-34 Rear Mounting Plate 2.0 RP10-001-33 Front Mounting Plate 1.5 RP10-001-2 Stiffener - Right Side (Short) 0.8 RP10-001-4 Stiffener - Left Side (Long) 1.0 RP11-002 Vibration Mount - each mount 0.5 RP10-001-61 60 Amp Alternator Bracket 0.7 RP10-001-58 Condenser Tube Bracket 0.5 RP10-001-22 Receiver/Drier Bracket 0.5 RP10-001-18K 22" Aluminum Cover 0.2 RP10-001-SSK 22" Stainless Steel Cover 0.2 RP10-001-12K Cover Button - Single 0.2 RP10-001-12K Cover Button - Kit 0.4 RP12-056-K Cover Latch - Single 0.3 RP12-056K Cover Latch - Kit 0.5 Note: Cracks in the frame or RigMaster mounting brackets is the result of over torque of the bolts and is not covered by warranty. August 2015 RigMaster Power International Ltd. Page 2 of 5
Electrical Harness and Cables RP13-001 J2 Harness 0.5 RP13-010 60 Amp Alternator Harness 0.2 LG7-008 Main Harness 1.3 RP13-079 Fan Harness 0.7 RP7-069 T4 Main Harness 2.5 RP7-072 T2 Main Harness 2.5 RP7-041 Starter Cable 0.2 RP7-9003 Shielded Communications Cable 1.0 RP7-015A Cable Support 0.0 RP7-057 GFCI Electrical Outlet 1.0 RP7-028 Insulated 12V Stand 0.7 RP7-038 Battery Cable - Red - 17' length 0.7 RP7-039 Battery Cable - Black - 17' length 0.7 RP7-004 J1 Connector - 10 Pin 1.0 RP7-005 J2 or J4 Connector - 8 Pin 0.7 RP7-002 Starter Cable - Red - 16" length 0.5 RP7-041 Starter Cable - Red - 8" length 0.5 RP7-051 Terminal #8 Spade 0.2 RP7-044 Terminal Ring 1/4" 0.2 RP7-012 Female Terminal for J1, J2, and J4 Connector (per terminal) 0.2 RP7-003 Ground Cable - Black - 11" length 0.2 Fans RP7-230 Electric Cooling Fan - Bottom 1.7 RP9-102 Blower Fan - HVAC Box in cabin 1.5 RP9-122 Dual Blower Fan - HVAC Box in cabin 0.5 Power Module RP50-250 Power Module 0.5 RP50-201 Cabin Controller (display) 0.3 RP7-9003 Communication Cable (Cat5e Network Cable) 1.0 Sensors and Switches RP7-021 APU Cover Sensor 0.5 RP7-103 Speed Sensor (includes RP10-001-47) 0.5 RP7-214 Fan Temp. Sensor 0.7 RP7-904 External Temp. Sensor 0.3 RP5-1005 Low Coolant Level Sensor 0.5 RP7-029 Binary Switch for RP9-027B 0.2 Fuel RP2-003 Fuel Check Valve 1.0 RP2-005 5/16" Fuel Hose - 25" length 0.2 RP2-004B 1/4" Fuel Hose - 3' length 0.2 RP2-004 1/4" Fuel Hose - 12' length 0.2 August 2015 RigMaster Power International Ltd. Page 3 of 5
Intake and Exhaust 00-C1140 Air Filter 0.0 135996610 Manifold Gasket 0.0 RP6-009 Muffler 0.7 RP6-008 Flex Pipe Assembly 0.7 RP6-004 1-1/2" Exhaust Clamp 0.0 Generator RP7-019 6000 Watt, 110 Volt Generator (includes below) 3.0 Separately: RP8-102 Generator Pulley 1.0 RP8-111 Generator Pulley Set Screws 0.0 RP7-023 Capacitor for 110 Volt Generator 1.25 RP7-090 20 Amp Generator Breaker 0.6 Note: Please provide the old and new generator serial numbers when filing a warranty claim. HVAC Box in Cabin RP9-201 Evaporator Core 1.5 RP9-112 Expansion Valve 1.3 RP9-113 Thermostatic Switch 1.2 RP9-202 Heater Core 1.5 RP9-120 Electric Coolant Control Valve (Water Valve) 1.0 Coolant 0.0 Hose Clamps 0.0 RP9-200 HVAC Box Assembly 1.8 Serpentine Belt Drive System RP8-106 Tensioner 0.5 RP12-057 Tensioner Bolt (includes tensioner labor) 0.5 RP8-107 Tensioner Bracket (includes tensioner labor) 0.7 RP8-103 Idler Pulley 0.2 Idler Bolt (includes pulley labor) 0.2 RP8-104 Idler Pulley Standoff (includes pulley labour) 0.2 RP8-101 Drive Pulley 0.5 RP8-100 Drive Pulley Adapter (includes drive pulley labor) 0.7 August 2015 RigMaster Power International Ltd. Page 4 of 5
Non Warranty Parts MTS-T4-6 (H) RigMaster APU Unit No Warranty Replacement of Unit PF1233 Oil Filter Maintenance Item RP10-001-1 Frame Assembly Installation Related Failures RP10-001-28 Frame Mount Clamp Installation Related Failures RP10-001-31 Generator Cover RP10-001-32 Bottom Cover Drain hole RP10-001-5 Bottom Plate RP10-001-56 Right S Bracket Installation Related Failures RP10-001-57 Left S Bracket Installation Related Failures RP12-023 Cover Sound Insulation RP12-024 Side Insulation RP12-025 Frame Plugs RP12-055 Weather Stripping RP12-097 Generator Cover Plugs RP2-001 1/4" Hose Barb Fitting RP2-002 1/4" Hose Barb Fitting RP2-006 Fuel Pickup Tube RP2-007 Hex Nipple 1/4" RP2-008 Bushing 3/8 x 1/4" RP2-009 Bushing 1/2 x 1/4" RP2-010 Street Tee 3/8" RP2-011 Street Tee 1/2" RP2-012 1/8" Fitting Adapter RP2-013 1/8" Fuel Fitting RP2-014 5/16" Straight Fitting RP3-001 Air Cleaner Outlet Hose RP7-039 17' Negative Battery Cable RP7-045 17' Positive Battery Cable RP7-059 Electrical Outlet Mount Plate Installation Related Failures RP8-009 Fan Belt Maintenance Item RP9-006 4" Flex Duct RP9-015 4" Louvered Vent RP9-016 Vent Kicker Panel RP9-105 HVAC Drain Hose RP9-116 Low Side Charging Caps RP9-117 High Side Charging Caps August 2015 RigMaster Power International Ltd. Page 5 of 5