TIME AND MATERIAL RATE SHEET 1/01/12 12/31/12 Straight Time Time and One-Half Double Time Project Manager $125.00 $187.50 $250.00 Superintendent $110.00 $165.00 $220.00 Foreman $78.00 $117.00 $156.00 Lead Hand $71.50 $107.25 $143.00 Fitter/Welder $65.00 $97.50 $130.00 Safety Advisor $80.00 $120.00 $160.00 QCI $90.00 $135.00 $180.00 Crane Operator 0-64T $80.00 $120.00 $160.00 All time over 40 hours per week will be billed at time and one-half. Holidays and Sunday s will be billed at double time or per the established project labor agreement. 1) Living Out Allowance Foreman will be billed at $110.00 dollars per 8 hour day and all other classifications will be billed at $100.00 dollars per 8 hour day with the exception of firewatch or Confined space classifications. BMT makes every effort to hire, train and utilize local labor for this classification. If local personell are utilized, there will not be a LOA adder. If local personnel cannot be utilized then LOA will apply. If project or regional agreements are in affect that supercede the above, the established agreements will apply. 2) Show Up Time Will be billed accordingly per worker. If unable to start a regularly scheduled day, will be billed at two (2) manhours at the applicable labor rates plus full day subsistence. If work commences and is stopped prior to four (4) hours of work, will be billed four (4) man-hours at the applicable labor rates. If work continues past four (4) hours will be at actual man-hours worked at the applicable labor rates. Superintendents and foreman are guaranteed 8 hours a day, 40 hours a week. If project or regional agreements are in affect that supercedes the above, the established agreements will apply 3) Shift Differential Should it be necessary to work additional shifts, a shift differential will be applicable as follows: $4.60 per hour for all hours worked. 4) Travel Round trip miles per employee at.50 per Kilometer. Round trip per vehicle at.50 per mile. (NOTE: If crew is already on site when time and material work begins, travel would not apply.) 5) BMT Supplied Equipment and Supplies See attached Rental Rates Sheets. BMT ULC (2012 T&M) Page 1 of 6
6) Special Equipment Cranes, Cherry Pickers, and other items not normally carried in BMT Company s Equipment Pool or not available due to changes in the original Scope of Work. Actual cost plus 10% 7) Material Material, weld rod, weld wire, flux, and off road diesel fuel will be charged at Actual cost plus 10% 8) Subcontractors Actual cost plus 10% 9) Freight Actual cost plus 10% 10) Tax Actual Cost 11) Engineering $185.00/hour NOTES: A charge of $5.50 per manhour worked will be made to cover the cost of all consumables, which will include all cutting gas (excluding breathing air, which will be charged at cost), grinding disk, drinking water, ice, etc. There may be an additional charge for cleaning and purifying fresh air equipment if exposed to excessive contact with crude oil or other heavy products. If this occurs, it will be documented with a third party invoice for the additional charges. No markup or handling charge will be added to these charges. For loading and unloading of equipment and materials, actual time spent will be billed at applicable labor and equipment rates. Shop personnel billable to customer at Mechanic/Welder labor rate. The equipment rates listed below include maintenance, but do not include an operator. These rates are in effect from January 01, 2012 through December 31, 2012 or upon thirty-(30) day s prior notice. Equipment Rental Rates are based on single shift usage and the following criteria: Daily Rate = Up to 8 hours Weekly Rate = 4 to 5 days of continuous Daily Rate rental Monthly Rate = 3 to 4 weeks of continous Weekly Rate Rental Transportation Equipment day week month pick up 4x4 $75.00 $487.00 $1,375.00 1 ton crew cab 4x4 $95.00 $617.00 $1,595.00 1/2 ton crew cab 4x4 $85.00 $552.00 $1,425.00 Storage container 40' $200.00 Welding Equipment Portable welding machines 200 amp propane $53.00 $157.00 $438.00 200 amp gas $53.00 $157.00 $438.00 300 amp diesel $93.00 $359.00 $876.00 BMT ULC (2012 T&M) Page 2 of 6
400 amp diesel $134.00 $527.00 $1,217.00 Generator 5kw Diesel $88.00 $347.00 $1,022.00 150kw Silenced 3ph $633.00 $2,496.00 $7,093.00 Eletric welders 4 pack $85.00 $85.00 $236.00 6 pack $97.00 $97.00 $354.00 8 pack $110.00 $110.00 $403.00 Welding cables 2/0x 50' $10.00 $17.00 $41.00 2/0x 100' $10.00 $23.00 $65.00 Torches Cutting oxy/ace cw regulators $40.00 $62.00 $120.00 Torch propane c/w hose /regulator $31.00 $60.00 $166.00 Welder/compressor 500amp $ 269.00 $1,052.00 $2,498.00 LN 22 Suitcase feeder $62.00 $179.00 $387.00 Wire feeder $76.00 $305.00 $600.00 Plasma cutter w torch 3/4'' $121.00 $477.00 $1,404.00 AIR COMPRESSOR AND TOOLS AND EQUIPMENT 185cfm diesel $134.00 $525.00 $1,434.00 250cfm diesel $ 202.00 $789.00 $2,190.00 Air hose 50' 3/4'' $12.00 $48.00 $144.00 Blower Manhole 8'' gas $49.00 $145.00 $398.00 Blower Manhole 8"eletric" $49.00 $145.00 $398.00 Blower Eletric 2900 explosion proof $80.00 $236.00 $657.00 Air tugger 2000lb $119.00 $524.00 $1,144.00 3000lb $131.00 $572.00 $1,279.00 4000lb $144.00 $ 607.00 $1,717.00 Frost wedge $15.00 $26.00 $44.00 Ground rod driver $14.00 $27.00 $46.00 Digging chisel $15.00 $18.00 $33.00 Rock drill $10.00 $19.00 $34.00 Grinders 4'' Straight $15.00 $53.00 $135.00 BMT ULC (2012 T&M) Page 3 of 6
4 5R/angle $19.00 $72.00 $166.00 7''R/Angle $28.00 $106.00 $194.00 9''R/angle $28.00 $106.00 $194.00 Impact Wrenches Air ratchet 1/2'' $19.00 $55.00 $149.00 Air ratchet 3/4'' $33.00 $126.00 $341.00 Air ratchet 1'' $43.00 $152.00 $419.00 Drills 3/8 2100 2400RPM $26.00 $77.00 $143.00 1/2'' 750 950RPM $29.00 $84.00 $198.00 3/4'' Reverse $38.00 $109.00 $298.00 1'' 11/4'' Reverse $68.00 $264.00 $730.00 Saws Hacksaw portable $68.00 $199.00 $549.00 Reciporcating saw $79.00 $233.00 $579.00 cutoff saw 14'' $62. 00 $238.00 $552.00 Jack hammer 17 lb chipping $30.00 $116.00 $268.00 40 60 lb Paving $33.00 $131.00 $365.00 90 lb Paving $43. 00 $157.00 $419.00 TESTING EQUIPMENT Drager Test Pump $24.00 $97.00 $290.00 Ultrasonic Thickness Meter $82.00 $330.00 $990.00 Explosion Meter $25.00 $100.00 $303.00 Lead in Air Tester $82.00 $330.00 $990.00 Hydrostatic Test Pump $96.00 $387.00 $1,161.00 Roof drain kit $24.00 $97.00 $290.00 Vaccum box $46.00 $187.00 $554.00 Magnetic Partical Test Kit $82.00 $330.00 $990.00 Constant Monitor $50.00 $198.00 $594.00 SAFETY FRESH AIR CLEANING EQUIPMENT 30 MIN AIR PACK $56.00 $224.00 $673.00 One person fresh air kit $165.00 $660.00 $1,980.00 Respirators 1/2 mask $14.00 $14.00 $14.00 LIFTING EQUIPMENT Porta power kit 50 ton $43.00 $106.00 $232.00 BMT ULC (2012 T&M) Page 4 of 6
10 ton Hydraulic jack $19.00 $37.00 $88.00 50 ton Hydraulic jack $43.00 $106.00 $232.00 100 ton Hydraulic jack $46.00 $119.00 $258.00 20 ton air pillow jack $44.00 $176.00 $528.00 Chain hoist 3 ton $67.00 $190.00 $428.00 Chain hoist 6 ton $ 123.00 $384.00 $1,071.00 20 ton roof jack ass $77.00 $308.00 $924.00 Hatzel airfan $72.00 $290.00 $871.00 Spreader bar 5 10 ton $44.00 $176.00 $528.00 Pipe Fitting Tools Threading Machine (1/2" 2") $21.00 $41.00 $98.00 Threading Machine (2" 4") $53.00 $157.00 $438.00 Power Treading Machine $59.00 $229.00 $643.00 Beveling Machine (1 1/2 4) $44.00 $84.00 $232.00 Beveling Machine (4 8) $44.00 $84.00 $232.00 Beveling Machine (8" 12") $55.00 $109.00 $289.00 Beveling Machine (12" 20") $24.00 $96.00 $288.00 Beveling Machine (14" 20") $93.00 $199.00 $579.00 Cold Cutter (2" 6") $10.00 $40.00 $118.00 Cold Cutter (6" 12") $14.00 $53.00 $158.00 Cold Cutter (8" 16") $20.00 $79.00 $237.00 Line Up Clamps (2" 6") $15.00 $26.00 $48.00 Line Up Clamps (8 12) $21.00 $84.00 $252.00 Pipe Stands $15.00 $33.00 $62.00 Hot Tap Machine (1" 4") $108.00 $432.00 $1,296.00 Hot Tap machine (4" 12") $108.00 $432.00 $1,296.00 Ladders & Scaffolding Ladder (Extension) $41.00 $109.00 $196.00 Shell Ladder (Clip) $22.00 $86.00 $259.00 Vert Ladder (Hook) $22.00 $86.00 $259.00 Portable Scaffold ( to 15' height per section) $32.00 $ 129.00 $388.00 Tank Scaffold, Boards and Brackets per span $22.00 $86.00 $259.00 Shell Buggy $29.00 $115.00 $346.00 Safety Cage (OSHA) $22.00 $86.00 $259.00 Small Man Basket $43.00 $172.00 $518.00 Large Man Basket $65.00 $259.00 $785.00 Cribbing Blocks (50 Pieces) $14.00 $58.00 $172.00 Shell Plate Buggy $36.00 $144.00 $432.00 Roof Plate Buggy $22.00 $86.00 $259.00 BMT ULC (2012 T&M) Page 5 of 6
Pumps & Hose 1 1/2 " Air Pump $29.00 $115.00 $346.00 3" Diaphragm Air Driven $86.00 $382.00 $876.00 4" Diaphragm Air Dirven $108.00 $400.00 $900.00 4" x 40HP Diesel Pump $106.00 $421.00 $1,094.00 6" x 40HP Diesel Pump $400.00 $1,161.00 $3,185.00 3" Pump Gasoline Driven $76.00 $264.00 $583.00 3" Pump Electric $43.00 $173.00 $518.00 6" Screw Pump Electric 220/440 $324.00 $1,296.00 $3,888.00 1 1/2 " Hose per 50' section $23.00 $65.00 $191.00 3" Suction Hose $17.00 $45.00 $102.00 3" Discharge Hose per 50' section $19.00 $45.00 $84.00 Fire Hose 50' section $19.00 $45.00 $84.00 Miscellaneous OSHA Retrieval Tripod $100.00 $403.00 $1,210.00 Internal Tank Lighting Kit Halogen $25.00 $101.00 $302.00 Survey Transit/Level $80.00 $317.00 $511.00 Chain Saw $43.00 $119.00 $218.00 Electric Light Strings of 50' section $19.00 $54.00 $102.00 Space Heater $17.00 $24.00 $56.00 Standard Set of Foremans Tools $72.00 $288.00 $864.00 New Tank Set Small Tools Grinders, Torches, Foreman's Tools, etc. $270.00 $1,080.00 $3,240.00 100' Electric Cord $5.00 $19.00 $58.00 Two WAY Radio $18.00 $72.00 $216.00 Mobile Phone Communications (Local Airtime) $22.00 $86.00 $259.00 Explosion Proof Light $25.00 $101.00 $302.00 Explosion Proof Cord $18.00 $72.00 $216.00 Incandescent Light Stand $29.00 $72.00 $115.00 Drill Press/Rotary Drill $43.00 $172.00 $518.00 Pop Rivet Gun $29.00 $125.00 $345.00 Electric Grinder $15.00 $33.00 $66.00 Flood Light Set (AC) $62.00 $179.00 $497.00 Dog House Dog House 6x8 $28.00 $106.00 $293.00 Dog House 8x10 $58.00 $211.00 $577.00 BMT ULC (2012 T&M) Page 6 of 6