Cxx Features: Universal AC input with active PFC Compatible with Lead Acid, Li-ion, Gel and AGM batteries Support optional remote controller (CR-) Voltage / temperature compensation with battery temp. sensor (Optional) -stage fan speed control Dry contact for alarm High efficiency and high reliability Built-in battery rescue function Built-in Engine Start Battery (ESB) output function Protection: Short Circuit / Over Voltage / Over Temperature / Brown-out Withstand G vibration test RS- communication interface Output power OK signal Output Input Protection Function Environment Safety & EMC Others Note Note. MODEL Battery Type Standard Boost Charge Voltage Standard Float Charge Voltage Main Rated Current Current Range Main Output Battery Charging Mode Single Output Current Limit Voltage Range Power Factor (Typ.) Frequency Range Efficiency (Typ.) at 0VAC AC Current (Typ.) Leakage Current Short Circuit Over Voltage Over Temperature Remote Controller Working Temp. Working Humidity Storage Temp., Humidity Temp. Coefficient Vibration Dimension (WxHxD) Packing.A 0 ~.A.A C C C0 - stage charging capability (IUoU) 90 ~ 6VAC (refer to de-rating curve) PF > 0.9 at full load 7 ~ 6Hz 90%.A / 00VAC.7A / 0VAC For earth < ma / 0VAC V ±%, Protection type: Shut down output (recovery after resetting AC power on) -0 ~ 60 C (refer to de-rating curve) 0 ~ 90% RH non-condensing -0 ~ +7 C, 0 ~ 90% RH ±0.0% (0 ~ 0 C) 0 ~ 00Hz, G 0min. / cycle period for 60min. each along, Y, Z axes 8x7xmm.6kg A 0 ~ A A 90% 8.A/ 00VAC.6A / 0VAC Current is reduced to < A continued 0sec., will operate 0 seconds then turn off Safety Standards Certified EN 60-, EN 60--9 Withstand Voltage I/P-O/P: VDC, I/P-FG: 768VDC, O/P-FG: 700VDC Isolation Resistance I/P-O/P: 00M Ohms / 00VDC Harmonic Current Certified EN 0; EN 60-; EN 0- Certified EN 6000--, --; EN 60-; EN 6000-6- x77x7mm.9kg Lead Acid / Li-ion / Gel / AGM 8.8V / 9.V (Select by S-) 7.6V / 7V (Select by S-) Charger Over Temperature 00 ± C detected by heat sink 0A 0 ~ 0A 0A 90%.A / 00VAC.A / 0VAC Battery Over Temperature ± C (Optional device - COTEK temperature sensor), connect on CN Alarm Signal NC. / NO. Relay contact output ( Please refer to page Alarms Signal & Fan Control ) Power Mode Supply 6.V Current limit output voltage Temperature Compensation -0mV / 0. C with COTEK temperature sensor Charging Sleep Mode Note. By Remote Controller and S- DIP switch ( Please refer to page ~) Note. Protection type: Auto recovery after heat sink temperature goes down to 0 C Support COTEK Remote Controller CR- setting Function (CN or CN) Certified EN 0; IEC 6000--,,,, 6, 8, ; ENV 00; EN 6000-6-; EN 0- x77xmm. All parameters not specially mentioned are measured at 0VAC input, rated load and C of ambient temperature.. The charger is considered a component which will be installed into a final equipment. The final equipment must be re-confirmed that it still meets EMC directives.. Before charging, make sure the battery charger and battery specifications are compatible.. When using sleep mode, please refer to charging current vs. Ambient temperature de-rating curve.. Optional Remote Controller (CR-)..9kg
Cxx Mechanical Drawings: Unit : mm[inch] MODEL: C 7.mm.0mm mm Air Flow 9.0mm.mm 6.mm TEMP / CN STATUS S CN DC OUTPUT CN AC INPUT 7mm ESB 8mm
Cxx Unit : mm[inch] MODEL: C/0 0.mm C.0mm C0 8.0mm C 7mm C0 mm Air Flow 9.0mm C 60.mm C0 6.mm 6.mm STATUS S CN DC OUTPUT TEMP / CN CN AC INPUT 77mm mm
Cxx Charging Mode Setting (S): Status V/V CC/CV V / V Float CC turn to CV voltage.v / 8.8V.7V / 9.V Float voltage.v / 7.0V.8V / 7.6V Power Mode (Current limit output voltage).v / 6.V.8V / 7.6V.V / 8.8V REMOTE Fan force / : Not applicable ---: Not applicable Charging Status and Indicator: Charging status LED Status Alternation in the charging Status Default setting Bulk- Orange fast Charging voltage >0.V and < float voltage NO Bulk- Orange slow.charging voltage > Float voltage and charging current >= Rating current.charging voltage = CV voltage and charging current < Rating current -- minutes 6 hours Absorption- Orange solid Charging current > 6% of r ating current ( ±%) 6 hours Absorption- Green solid Charging current < 6% of rating current ( ±%) 8 hours Green flash Float LED colour change by the status change Float to Bulk- -- Note:. IBS Sensor is feedback 00% charge to change Status. Failure Indicator:.Charging voltage >.6V. The voltage goes up to CV voltage to charge the battery once every 6 hours Charging voltage <.6V 6 hours 8 minutes 0 sec. Unlimited circle Failure status LED Status Description Activate Recovery Input or Output Temperature Red solid Red fast Voltage is reduced to <V,Continued 0 sec., FAN turn on 0 sec then turn off. AC I/P unstable Output FUSE blown Battery over heat ( the indicator available when COTEK temperature sensor connected only) Battery in cold condition (the indicator is available when COTEK temp. sensor is connected) Output <V <8V,>70V Voltage difference >0.V,>0. sec. > <-8 AC Reset, Output>8V >90V,<6V AC Reset < >-0 Charger over heat (Heat Sink) >00 <0 Battery Voltage Red slow Battery over voltage Battery under voltage or output under voltage in CC mode. >V AC Reset, <.V <0.V >V Fan Abnormality Red light flash twice Fan abnormality ----- -----
Cxx TEMP/CN: 6 R_VCC GND TEMP BAT- DATA I/O NC. TEMP/CN 6 RJ- 6P6C CN: 6 R_VCC BAT- NC. BAT- DATA I/O NC. CN 6 RJ- 6P6C Alarms Signal and Fan Control Connectors Pin Definition(CN): Normally Closed Normally Open COM Sleep Mode Control GND CN - SHORT Sleep Mode - OPEN Sleep Mode Charging Curve at Temperature Compensation: 0.0 9.6VDC 9.0 8.8VDC 8.0 8.VDC 8.0VDC Volt system : -0mV / 0. 7.0 7.6VDC 6.8VDC -.mv / per cell 6.0.0.0 U Rer 0 In the CV=8.8V and float =7.6V situation. Please follow this rule in other situation.
Cxx Charging Curve: Charging Current vs. Input Voltage Temperature De-rating Curve: Charging current (%) 00% 0% 90 0 0 0 0 70 AC Voltage (V) Charging current vs. Inpu t voltage Charging Current vs. Ambient Temperature De-rating Curve: Charging current (%) 00% 80% 0% 0% 0% Normal S pin or CN pin- Short CR Sleep mode -0 C 0 C 60 C Ambient Temperature Charging current vs. Ambient Temperature 6
Cxx Rescue Battery Curve: Rating Current.% Rating Current.8V.6V 0V 0V REV. B0 7/07/ 7