Contactors : Wide band AC / DC operated NF / s Wide band AC / DC Operated - with Screw Terminals Description NF / include an electronic coil interface accepting a wide control voltage Uc min.... Uc max. only four coils cover control voltages between 4...5 V 5/6 Hz or...5 V DC NF / can manage large control voltage variations. One coil (e.g....5 V 5/6 Hz - DC) can be used for different control voltages used worldwide without any coil change. NF...Z / AF...Z contactor equipped with a Z coil type allow direct control by 4 V DC 5 ma PLC-output and obtain a reduced holding coil consumption. NF / have built-in surge protection and do not require additional surge suppressors. Control contactors : Wide band AC/DC operated with low power consumption & inbuilt surge suppressor for order code refer page no. 54 Innovative solution from ABB Electronically controlled coil Distinct drop out- and pick up value ms sags and dip immunity Fulfills SEMI - F47- surge suppressors. Specification for processing equipment regarding voltage drop immunity. Position Contactor closed Contactor open V 5 V Nominal range Control voltage Operational limits 85% of lower voltage range level 55% of lower voltage range level Contactors : Wide band AC / DC operated ABB Low voltage Control Products
pole contactors AF range : Wide band AC / DC operated s are built in with Universal coil operable on wide band AC / DC voltages ranging from 7% Uc min - % Uc max Surge Suppressors Low power consumption coil ACduty Amps AC rating at 45V Amps hp kw 5 9 5.5 4 8 7.5 5.5 8.5 7.5 Auxiliary Contacts Type Code Order code NO - AF9--- SBL7R - NC AF9--- SBL7R NO - AF--- SBL57R - NC AF--- SBL57R NO - AF6--- SBL77R - NC AF6--- SBL77R 45 6 5 - - AF6--- SBL7R 5 8 - - AF--- SBL77R 5 8 5 8.5 - - AF8--- SBL97R 7 4 8.5 - - AF4--- SBL47R 5 4 - - AF5--- SBL67R 5 65 5 - - AF65--- SBL87R 5 8 6 7 - - AF8--- SBL97R 96 7 45 - - AF96--- SBL47R 6 6 75 55 NO NC AF6--- SFL47R 4 75 NO NC AF4--- SFL447R 5 46 75 NO NC AF46--- SFL467R 75 49 9 NO NC AF9--- SFL487R 5 5 5 NO NC AF5--- SFL57R 4 65 75 4 NO NC AF65--- SFL547R 5 5 5 6 NO NC AF5--- SFL587R 6 7 7 NO NC AF7--- SFL67R For AF4...AF75 refer Table B for coil codes 6 4 NO NC AF4--** SFL577R 7 46 4 5 NO NC AF46--** SFL597R 8 58 47 55 NO NC AF58--** SFL67R 5 75 57 45 NO NC AF75--** SFL67R Coil voltages and codes: New AF9...AF7 range (AC/DC operated) V 5/6 Hz V DC 4...6...6 48... 48......5...5 5...5 5...5 4 AF4 and above range (AC/DC operated) V 5/6 Hz V DC - 4...6 6 8 48... 48... 6 9...5...5 7 5...5 5...5 7 Old AF range contactor ACduty Amps AC rating at 45V Amps hp kw Auxiliary Contacts Type Code Order code 5 4 5 - - AF5-- ** SBL57R 5 65 5 7 - - AF6-- ** SBL77R 5 75 54 4 - - AF75-- ** SBL47R 45 96 6 55 NO NC AF95--** SFL47R 6 75 59 NO NC AF--** SFL457R 5 45 8 75 NO NC AF45--** SFL477R 75 85 9 NO NC AF85--** SFL497R Coil voltages and codes: Old AF range (AC/DC operated) V 5/6 Hz V DC - 4...6 6 8 48... 48... 6 9...5...5 7 ABB Low voltage Control Products pole contactors AF range : Wide band AC / DC operated
4 pole contactors : Wide band AC / DC operated New AF Contactors: 4 pole AC / DC Operated Rating at 45V AC Amps Main Contact Arrangement Auxiliary Contacts Type Code Reference Order code 5 4NO - - - AF9-4-- SBL7R NO NC - - AF9--- SBL75R 4NO - - - AF6-4-- SBL77R NO NC AF6--- SBL775R 45 4NO - - - AF6-4-- SBL7R NO NC AF6--- SBL75R 55 4NO - - - AF8-4-- SBL97R NO NC - - AF8--- SBL975R 7 4NO - - - AF4-4-- SBL47R NO NC - - AF4--- SBL475R 4NO - - - AF5-4-- SBL67R 5 4NO - - - AF8-4-- SBL97R NO NC - - AF8--- SBL975R 6 4NO - - - AF6-4-- SFL47R 4NO - - - AF4-4-- SFL447R 75 4NO - - - AF9-4-- SFL487R 5 4NO - - - AF5-4-- SFL57R 4 4NO - - - AF65-4-- SFL547R 5 4NO - - - AF5-4-- SFL587R 6 4NO - - - AF7-4-- SFL67R Coil voltages and codes: New AF range (AC/DC operated) V 5/6 Hz V DC 4...6...6 48... 48......5...5 5...5 5...5 4 Old AF Contactors: 4 pole AC / DC Operated Rating at 45V AC Amps Main Contact Arrangement Auxiliary Contacts Type Code Reference Order code 7 4NO - - - AF45-4- SBL7R NO NC AF45-- SBL75R 5 4NO - - - AF75-4- SBL47R NO NC AF75-- SBL475R Coil voltages and codes: AF45... AF75 V - 5/6Hz V d.c. -... 6 7() 48... 48... 69... 5... 5 7 () The connection polarities indicated close to the coil terminals must be respected: A for the positive pole and A for the negative pole. Note: For Non standard coil voltage, other than this please contact us for pricing 4 pole contactors : Wide band AC / DC operated ABB Low voltage Control Products
AF9... AF96 -pole contactors Accessories for s CA4- CA4- VEM4 VEM4 NC A SBCV4 CAL9- KM SBCV4 CA4-E TEF4-ON BER6-4 SBC7V4 Auxiliary AF6... AF7 -pole contactors CAL9- VM9 VEM4 LT7-C LX4 SBC6V4 NC SFC7V SFC5V KM SBC6V4 SFC49V Side Side-mounted instantaneous auxiliary contact NO blocks NC CAL9- SFN8R AF96 AF7 pole AF9... AF96 NO NC CAL4- CAL9-B SFN8R.4 add-on blocks Front-mounted AF9.AF8 instantaneous / NF auxiliary contact NO and A/A NCcoil terminal CAL4- blocks SBNR AF9 Ordering... AF6..-- details () CAT4-M.4 * Please refer AF6 technical catalogue for proper selection. For... contactors AF65..-- Auxiliary contacts Order code CAT4-E P Weight.4 AF9... AF6..-- CAT4-U ( pce).4 Note: CAT4 not suitable for AF..Z contactors with DC control voltage... V DC. Mechanical interlocks Mechanical interlock unit For contactor AF9 Side-mounted... AFtypes instantaneous auxiliary contact Description blocks VM4 Type Code Order Code.5 AF4... AF96 CAL9- VM96-4reference.5.6 AF6... AF7 AF9 AF8 Note: VM4 and VM96-4 include Horizontal fixing clips Mechnical (BB4) to maintain Interlock together both contactors. VM 4 SBN5T Mechanical interlock unit AF9 AF8 Mechanical and electrical Horizontal interlock Mechnical set AF6... AF7 & Electrical VM9Interlock VEM 4.54 SBNR AF4...AF96 AF9 AF6 AF6... AF4 and AF9, Horizontal AF5 Mechnical Interlock VM4/9 VEM4 VM96-4.88 SBN45T.5 AF6 AF9,... AF8 AF5 and AF65... AF7 VM5/65.9 AF6...AF46 and Horizontal Mechnical Interlock VM4/9 SFN44R Note: Terminal - VEM4 shrouds includes a VM4 mechanical interlock unit with fixing clips (BB4), a VE4 electrical interlock block. VE4 block must be used with A-A AF9. AF5 AF9, AF5 AF9, AF5, and with cable clamps LT5-C VM5/65.5 SFN5R AF65... AF9, AF7 AF5, with compression lugs LT5-L. For contactors AF9, AF5, with shorting bar or Time between delay contactor Delay Auxiliary LT5-Y Order code.5 P Weight AF6...AF7 and TOL/EOL in DOL-startersHorizontal range Mechnical type Interlockcontacts VM9 SFNR ( pce) AF65... AF7, with cable clamps selected by LT7-C.5 Note: Please AF65 refer... technical AF7, with compression catalogue switch lugsfor proper selection. LT7-L.8 Electronic AF65... AF7, timers for use with extending cable clamps, LT7-D.5 Electronic timers ATK/ and OZXB4 AF9... AF96... s ON-delay TEF4-ON.65 For contactor types... Time s delay Delay Auxiliary Type Order Code For contactors... Dimensions range s OFF-delay type contacts TEF4-OFF.65 Order code P Weight hole selected Ø bar ( pce) Note: Rated control circuit voltage Uc mm4...4 V 5/6 mm Hz or DC. by switch Connecting Terminal enlargements links with manual motor starters AF9... AF96... s ON-delay NO + NC TEF4-ON SBNR AF9... AF6 with MS6-.6 MS6-5, BEA6-4.5 AF6...AF4 6.5... s x LW4.5 AF9...AF5.5 MS-.6 MS-5 7.5... s OFF-delay x 5 LW5 NO + NC TEF4-OFF.6 SBN4R AF6 AF65...AF7 AF with.5 MS6-.6 MS6-6, x 5 LW7 BEA6-4.4.5 MS-.6... MS- Note: Rated Terminal control extension circuit voltage Uc 4...4 V 5/6 Hz or DC. with MS6- MS6-, BEA8-4. AF6...AF4 6.5 x LX4.7 MS-... MS- AF9...AF5 8.5 7.5 x 5 LX5.8 Connecting AF65...AF7 links with manual.5 motor x starters 5 LX7.4 Connection sets for reversing contactors () For more information, refer to "Accessories" section. For AF9 contactor... AF6 types Used with BER6-4 Type Order Code.45 AF6 For... contactors AF Cable range Order code BER8-4 P Weight ( pce). AF9... AF4 AF6... AF65 MS6-.6 MS6-5, BER65-4BEA6-4 SBN86T.75 AF8 Connector... AF96terminal lug kits MS-.6 MS-5 BER96-4.5 AF9...AF5 6- MCM ATK85 AF6... AF MS6-.6 MS6-6, BEA6-4 SBN86T Connection AF65...AF7 sets for star-delta starting4-4 MCM ATK AF65...AF7 MS-.6 ()... 4-5 MS- MCM ATK/ AF9 AF6 With or without VM4 BEY6-4.5 AF6... AF With or MS6- without VM4 MS6-, BEY8-4BEA8-4 SBN86T. AF4... AF65 With or MS- without VM96-4... MS- BEY65-4. AF8... AF96 With or without VM96-4 BEY96-4.5 SFC4V Connection sets for reversing contactors For contactor types Type Order Code AF9... AF6 BER6-4 SBN8R AF6... AF BER8-4 SBN8R AF4... AF65 BER65-4 SBN84R AF8... AF96 BER96-4 SBN89R 9_ABB_maincatalogue_livre.indb -7- ABB /7 ABB_main_section.indd 7 A SBC7V4 SBCV4 SBC4V4 Ordering details () For contactors Auxiliary contacts Order code P Mounting on Contact Configuration Type Code Description Order Code Contactors NO NC Reference Front-mounted instantaneous auxiliary s Front mounted AF9... AF96 NO - CA4- CA4- SBNR.4 CAL4- CAL4- pole CA4-.4 add-on AF9 blocks... AF6..-- - NC CA4-MCA4- SBNR.55 AF6... AF96..-- CA4-E.55 AF9... AF6..-- AF9.AF8 / NF 4NO - CA4-UCA4-4E SBN4R4.55 Front mounted NO NC CA4-E SBN 4R 4 pole Front-mounted auxiliary s with N.O. leading contact and N.C. lagging contact add-on AF9 blocks... AF96 NO NC CC4- CA4-E SBN 4R.4-4NC CC4- CA4-4E SBN 4R4.4 CAT4-E SBC4V4 BEA6-4 SBCV4 Connection sets for star-delta starting CAL9-B.5 connection to respect the electrical connection diagram. AF6 - VEM4... AF4, not suitable with compression for AF..Z lugs contactors with DC control voltage... LT4-L V DC..7 AF65... AF7, with shorting bar or between contactor and TOL/EOL in DOL-starters () For more information, refer to "Accessories" section. LT7-Y.75 For contactor types Type Order Code AF9... AF6 BEY6-4 SBN8R AF6... AF BEY8-4 SBN87R AF4... AF65 BEY65-4 SBN84R AF8... AF96 BEY96-4 SBN89R 4-6-6 9:4 AM Weight ( pce) ABB / ABB Low voltage Control Products Accessories for s
Accessories AF9... AF96 for -pole s Contactor and main accessories (other accessories available) AF9... AF65 (without top mounted coil terminal block) VEM4 mechanical and electrical interlock set including: VM4 mechanical interlock unit with fixing clips VE4 electrical interlock block with A-A connection AF9... AF96 Fixing clips CAT4- -pole auxiliary contact and A/A coil terminal block BX4-CA VM TEF4 Electronic timer A CAL4- -pole auxiliary BX4 -pole auxiliary CA4 4-pole auxiliary BX4-CA BX4-CA A AF9... AF8 -pole auxiliary TF EF Overload relay Contactors and and motor protection Advanced but simple Main accessory fitting details Advanced but simple Many configurations of accessories are possible depending on whether these are front-mounted or side-mounted. Contactor Main Built-in AF the premium range types poles auxiliary AF9... AF6 AF9... AF6 AF6... AF contacts CAL4- -pole auxiliary Front-mounted accessories Side-mounted accessories Auxiliary s Electronic Electrical and Auxiliary s timer mechanical interlock set -pole CA4 (between contactors) Left side Right side -pole CC4 -pole CAT4-4-pole CA4 TEF4 VEM4 -pole CAL4- Max. N.C. built-in and add-on N.C. auxiliary contacts: 4 N.C. max. on positions,,, 4 and N.C. max. on positions ±, 5 4 max. or or or + max. or or + + max. + + or AF4... AF65 4 max. or or or + + AF8, AF96 4 max. or or + + Overload relays fitting details () Contactor types Thermal overload relays Electronic overload relays AF9... AF TF4 (...8 A) EF9 (...9 A) AF6... AF TF4 (...8 A) EF45 (9...45 A) AF4... AF65 TF65 (...67 A) EF65 (5...7 A) AF8, AF96 TF96 (4...96 A) EF96 (6... A) The addition of an overload relay on the contactor does not prevent fitting of many other accessories as shown above. () Direct mounting - No kit required. -pole auxiliary TF4 EF Overload relay VE4 Interlock The The is compact is compact The The is compact is compact in size in size and and has had has had its width its width reduceduced by up by to up % to % thanks thanks to an to 8% an 8% reduction reduction of the of coil s the coil s re- energy energy consumption. The The is flexible is flexible AF9...AF7 is perfect is perfect for motor for motor starting starting applications and and for for solutions solutions where where space space is limited. is limited. Interlocked reversing reversing pairs pairs require require no spacing no spacing between between contactors contactors meaning meaning you can you fit can fit more more functionality into into cabinets cabinets or other or other small small enclosures. 9_ABB_maincatalogue_livre.indb -7- :9 Accessories for s ABB Low voltage Control Products