ILLUSTRATED PARTS LIST MODEL NO. 90000500 CUSTOMER CATALOG NO. PBGTH54 950 Rev. 03.3.05 TR
DECALS 9 3 5 5 4 5 0 9 4 3 3 9450 Decal, Dash 939 Decal, Eng. 3 Decal, Hood, RH 4 3 Decal, Hood, LH 5 94 Decal, Hood Sides 053 Decal, Warning 9303 Decal, Upstop 50 Decal, Deck Caution 9 40 Decal 0 540 Decal, Danger 53 Ft. Rest 95454 Decal, Repl. 4 9 Decal, V-Belt Schematic 5 43 Decal, Ins. Whl. Strg. 403 Decal, Saddle Brake Parking 9 45005 Decal, Battery 3 00X Refl ector - - 90 Decal, Bypass - - 99X4 Pad Footrest RH - - 9X4 Pad Footrest LH - - 950 Manual, Operator's E&F - - 950 Manual, Parts E&F WHEELS & TIRES 3 4 0 5 9 599 Cap, Valve, Tire 539 Stem, Valve 3 0X4 Rim Assembly, Front 4 34H Tube, Front (Ser vice Item Only) 5 030X Tire, Front H Fitting, Grease (Front Wheel nly) 9040H Bearing, Flange (Front Wheel Only) 045X4 Cap, Axle (Front Wheel Only) 9 055X Tire, Rear 0 54J Tube, Rear (Service Item Only) 0X4 Rim Assembly, Rear 5M Fitting, Grease - - 44334 Sealant, Tire (0 oz. Tube) wheel_art_-vgt NOTE: All component dimensions given in U.S. inches inch = 5.4 mm
SCHEMATIC BATTERY SOLENOID RED A RED RED M AMMETER (OPTIONAL) WHITE FUSE PTO (DISENGAGED) STARTER B S M G A L A WHITE IGNITION SWITCH CLUTCH / BRAKE (PEDAL UP) GRAY SEAT SWITCH (NOT OCCUPIED) GRAY REVERSE SWITCH SHORTING CONNECTOR NOT IN REVERSE ELECTRIC CLUTCH RED / WHITE BLUE FUEL SHUT-OFF SOLENOID FUEL LINE IGNITION UNIT HOUR METER (OPTIONAL) SPARK PLUGS GAP ( PLUGS ON TWIN CYL. ENGINES) BLUE RED (IF SO EQUIPPED) CHARGING SYSTEM OUTPUT AMP DC @ 300 RPM REGULATOR YELLOW ALTERNATOR ORANGE VOLTS AC @ 300 RPM (REGULATOR DISCONNECTED) LIGHT SW BROWN IGNITION SWITCH POSITION CIRCUIT MAKE OFF M+G+A RUN/OVERRIDE B+A RUN B+A L+A START B+S+A 033 NOTE YOUR TRACTOR IS EQUIPPED WITH A SPECIAL ALTERNATOR SYSTEM. THE LIGHTS ARE NOT CONNECTED TO THE BATTERY, BUT HAVE THEIR OWN ELECTRICAL SOURCE. BECAUSE OF THIS, THE BRIGHTNESS OF THE LIGHTS WILL CHANGE WITH ENGINE SPEED. AT IDLE THE LIGHTS WILL DIM. AS THE ENGINE IS SPEEDED UP, THE LIGHTS WILL BECOME THEIR BRIGHTEST. HEADLIGHTS NON-REMOVABLE CONNECTIONS REMOVABLE CONNECTIONS WIRING INSULATED CLIPS NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE REPLACED TO PROPERLY SECURE YOUR WIRING. 3
ELECTRICAL 9 4 4 4 43 40 30 33 5 34 0 D.C. AMPERES 45 50 9 4 94 9 9 93 9339ROS 4
ELECTRICAL 449 Battery 404 Bolt Hex Head /4-0 x 3/4 03J Tray, Bat tery 0 45 Bolt Btr Frt /4-0 x.5 zinc 5009 Holdown Battery Front Mount 459 Nut Push Nylon /4" 3 Switch Interlock Push-In 5 Harness Headlight w/bulbs 45J Bulb Light 4 449 Cable Ga. Red.5" w. Wire 5 544 Cable, Battery 04X Fuse 350400 Nut Keps Hex /4-0 unc 09 Cable, Ground 9 949 Switch, Seat 30 93350 Switch, Ign 33 4040 Key 34 0X Switch Light/Reset 40 9339 Harness, Ignition 4 040 Screw Thd Cut /4-0 x / 4 353 Cover, Terminal 43 Solenoid 45 X Ammeter 4 935 Hourmeter Snap-In 50 453 Switch, PTO 9 54 Socket, Light Bulb 9 939 Bracket Snap-In 9 9345 Harness Pigtail Reverse Switch 93 9540 Screw Plastite 0-4 x.0 94 934 Module Reverse ROS NOTE: All component dimensions given in U.S. inches inch = 5.4 mm 5
CHASSIS AND ENCLOSURES 4 5 53 30 5 3 5 4 30 5 4 3 35 3 50 30 5 44 5 5 4 43 5 30 30 5 43 39 4 34 9 3 33 39 4 30 9 4 0 3 9 3 4 45 0 99 3 4 3 3 3 9 45 4 50 44 4 39 4 chassis-stealth II_
CHASSIS AND ENCLOSURES 035 Rail, Frame RH 5 Drawbar, Gt 5 933X4 Dash 5 Dash Asm., Lower 040 Screw, Thd Cut /4-0 x / 4 Support, Battery 4 50X4 Hood Asm., Pnt 94X Cover, Access 00 Screw, 3/- x 3/4 59X4 Grille 9 933 Washer 3/3 x 3/ x Ga. 0 40 Bolt, Fin Hex 3/- x 30000 Nut, Lock Hex w/ins. 3/- unc 4 9X4 Footrest, RH 9X4 Footrest, LH 30 4505 Saddle, Hydro 995 3 49 Bracket, Supt -pc VGT Steering 3 3 Bracket, Pivot Chassis LH 33 3 Bracket, Pivot Chassis RH 34 0 Plate Asm. Engine Chassis 35 9 Washer /3 x / x Ga. 3 005 Screw 5/- x 3/4 3 939X4 Fender, Pnt. 39 5 Bracket, Axle Front 43 3939 Bracket, Spnsn Front Lh 44 3940 Bracket, Spnsn Front Rh 45 0 Bracket Arm Susp. 4 4900 Screw Thdrol 3/- x / TYT 50 54 Bracket, Chassis Front 5 359 Bracket Asm., Fender 49050 Screw, Thd 5/- x / 4 4 Upstop 40 Bolt, Fin Hex /-4 unc x 9 034 Rail, Frame Lh 99 43 Rod By Pass 30 9 Screw 0 x 3/4 Single Lead Hex 95 Screw Hex Wshd 0-3 x 5/ 3 9X4 Cupholder YTGT 39 3 Bolt Shoulder 5/- TT 4 9 Bracket Dash RH 43 94X4 Skirt Grill RH 44 900 Bracket Dash LH 4 94X4 Skirt Grill LH 4 455 Extrusion Bumper 50 535 Duct Heat Hood 5 95 Shield Browning 53 9 Light Box Asm. w/lens 5 0005 Screw 5/- x 3/4 5 40 Lens, Bar 5 00 Screw Thdrol 3/- x / 59 000 Screw 3/- x 3/4 9X4 Console Fuel Window 443 Screw /4-/ 5 3554 Bracket Support Tank 3000 Nut, Crownlock /-4 unc 4 Bushing 9 59 Bracket Chassis Sway 0 94 Rod Bracket Sway Brace 04 Screw 3/- x.5 3 405 Bolt Fin Hex 5/- x 3/4 4 0040500 Washer Lock Hvy Hlcl Spr 5/ NOTE: All component dimensions given in U.S. inches inch = 5.4 mm
GROUND DRIVE 39 4 0 40 4 9 3 3 3 3 4 4 5 35 4 3 3 5 53 4 0 50 4 43 55 5 9 4 30 34 3 9 5 35 3 0 5 9 9 4 0 4 4 5 4 33 0 9 3 3 3 94 94 43 4 9 9 0 33 3 45 0 45 3 3 9 33 0 drive_-vgt 0
GROUND DRIVE - - - - - - - Transaxle Hydro Gear 33-3000 (Order Parts From Transaxle Manufacturer) 00E Key Sq. /4 x.5 3 53R Washer Thrust 004 Pin, Cotter 4050 Wheel, Hub Assembly 9 4000 Bolt, Hub 0 394000 Nut 035 Lever Asm Shift 3 4045 Knob 9 00 Brake, Rod 33 000053 Ring E 34 3 Cap, Parking Brake 35 34 Rod, Parking Brake 3 494 Spring, Drive Ground 3 49X Washer 5/3 x -/4 x Ga. 3 50035 Nyliner 39 430 Screw, Fin. #0-4 x 40 55 Actuator, Interlock Switch 4 393000 Nut Centerlock 0-4 unc 4 3533X Cover, Pedal 4 450 Retainer, Spring 4 04 Bolt Carr. Shoulder 3/- x -3/4 Gr. 5 50 3494 Pulley, Idler, Flat 5 3 Pulley, Idler, Grooved 55 050X Bearing, Idler 5 59 V-Belt 5 404 Bolt Fin Hex /-4 x -/ 43995 Pulley, Transaxle 4 0 Shaft, Brake Pedal 5 93 Bolt, Shoulder 54H Pin, Roll 9 300X Washer 0 9390X4 Console Shift 3 449054 Bolt Hex Flghd 5/- x 3 Gr. 5 4 443 Screw Hex Wsh. Hi-Lo /4-/ 40 Bolt Fin Hex /-4 x 9 3000 Nut Crownlock /-4 unc 94 3335 Fastener Christmas Tree 9 4004 Bracket Shift 0 49 Cap Asm Vent Hydro Gear 0 5439 Line Fuel Hydro 5 VGT 0 49 O-Ring Asm Hydro Gear 540 Spacer Shift Lever VGTH 55 Washer Nylon High Temp 4 300500 Nut Lock Hex W/Ins 5/- unc 390000 Nut, Lock Flg. 3/- 5 Bracket Strap Torque 0050 Bolt 5/- x.50 3 943 Rod Shift 4 549 Bolt Shoulder 5/- x.5 00 Washer Srrtd 5/ ID x.0 x.5 3 Link Control Clutch 4 Spring Drive GRND 9 943 Bracket Asm Idler Tensioning 30 930 Washer 3/3 x 5/ x Ga. 3 003 Pin Cotter 3/3 x 3/4 3 54 Bracket Mtg Hydro 3500 LH VGT 33 54 Bracket Mtg Hydro 3500 RH VGT 35 34 Link Asm Control Hydro 3500 3 5H Nut Lock 5/- NC Thd. 3 30H Washer Thrust 5/ x.0 x /3 4 549 Strap Torque HG-3500 43 0005 Screw 5/- x 3/4 45 3 Washer Axle Flange HG-3000 4 404 Fan " Hydro 4 43 Washer 0 000 Screw 3/- x.5 5 4054 Bolt Fin Hex 5/- x / 5 05 Bolt Hex 5/- x 53 449H Spring Retainer NOTE: All component dimensions given in U.S. inches inch = 5.4 mm 9
STEERING ASSEMBLY 5 9 3 45 4 5 4 0 9 3 0 4 5 3 5 34 33 3 4 3 3 9 3 4 5 3 3 53 4 9 4 49 4 50 5 5 4 35 steering_-vgt 0
STEERING ASSEMBLY 094X4 Wheel, Steering 55 Axle Asm., Front 3 3 Fitting, Grease 4 49 Spindle Asm, LH 5 4 Spindle Asm., RH H Bearing, Race Thrust Harden 4X Washer 5/3 x -5/ x Ga. 00009 Ring, Klip #T5304-5 9 494X505 Cap, Spindle 0 4044 Bolt, Fin Hex 5/- x -3/4 35 Spacer, Brg. Axle Front 390000 Nut, Lock Flange 5/- unc 3 49X Washer 5/3 x -/4 x Ga. 4 004000 Washer, Lock Hvy Hlcl Spr 3/ 5 354000 Nut Crownlock 3/-4 4 Shaft Asm., Steering 99 Draglink 9 50 Support Asm., Steering Vgt 0 3X4 Boot Steering Stealth 3 Adapter, Wheel Steering 5505 Bushing, Strg. 3 59 Screw 095X4 Insert Cap Strg WH 33R Bearing, Col. Strg. 000 Screw Hexwsh thdr 3/- x 3/4 9 0439X Bearing, Flange 3 33 Bushing, Nyliner Snap 3 90 Washer /3 x x 0 Ga. 33 0040500 Washer, Lock Hvy Hlcl Spr 5/ 34 405 Bolt, Hex Hd 5/- x 3/4 35 039 Gear, Sector Steering 3 99 Tie Rod 4 554 Bracket Switch Interlock Vgt 9 4 49050 Screw Thdrol 5/- x / Tyt 45 93 Washer 9/ ID -3/ OD Ga. 4 930 Washer 3/3 x x 0 Ga. 4 94 Bracket Asm. Idler Stationary 49 50 Pulley Idler Flat 50 390000 Nut Lock Flg. 3/- unc 5 394000 Nut Hex Jam Toplock /-0 unf 5 5553 Clip Steering 53 9 Washer Hardened NOTE: All component dimensions given in U.S. inches inch = 5.4 mm
ENGINE 3 9 45 0 4 0 4 9 5 4 4 3 4 0 5 9 9 engine_els_3-vgt 3 39 3 40 SPARK ARRESTER KIT
ENGINE - - - - - - - Engine B&S, Model No. 449 (Order parts from engine manuf.) 493 Muffl er Side 3X Pulley V-Idler 9 4 Keeper Asm. Belt Engine VGT 0 5 Bushing 9335 Clutch Electric 4399 Pulley Engine VGT Elect Clutch 5 95 Tank Fuel Rear 5.0 94X4 Cap Asm. Fuel 0 543X4 Control Throttle 9 Screw 0 x 3/4 Single Lead Hex X4 Control Choke 345J Bushing 39 Stem Tank Fuel 34R Fuel Line 9 30 Spark Arrester Kit 3 4500 Clip 3 34X Clamp Hose 39 4903 Screw TT 3/- x -/4 unc 40 4904 Screw TT 3/- x 4 unc 4 9X Washer -/ OD x 5/3 ID x.50 4 004000 Washer Lock / 45 350400 Nut Keps Hex /4-0 unc 4 5 Spacer 49 Shield Heat Muffl er CV-Intek 9 539 Gasket 0 09 Tube Exhaust LH 00 Tube Exhaust RH 9 390 Screw Socket Head 5/- x 00 Tube Drain Oil 99 Valve Oil Drain 3 Bolt 5/- Unc x -3/4 W/Sems 4 004 Screw Thdrol 3/- x -/ 5 9953 Bolt Hex /-0 x 3.5 Gr. 5 43 Nut Hex Flange Toplock M-.5 NOTE: All component dimensions given in U.S. inches inch = 5.4 mm For engine service and replacement parts, call the toll free number for your engine manufacturer listed below: Briggs & Stratton -00-33-33 Kohler Co. -00-544-444 Tecumseh Products -00-55-540 Honda Engines -00-4-0 Kawasaki -949-40-5 3
LIFT ASSEMBLY 40 43 3 35 3 34 39 3 3 30 0 4 0 4 5 5 4 9 33 3 0 9 3 5 4 4 5 4 0 4 5 3 lift_rh_ 4
LIFT ASSEMBLY 00X Rod Asm., Lever 0045 Shaft Asm., Lift Vgt 3 599 Lever Asm., Lift Rh 4 0000 E-Ring Truarc #533-5 990 Washer 9/3 x -/4 x Ga. 04 Bolt, Fin Hex 3/- x -/ 530 Grip, Handle 53X4 Button Plunger 0 394 Spring 0. OD x.5 535 Link Lift 355 Retainer, Spring 3 4939M Retainer, Spring 4 335000 Nut, Jam Hex /-3 unc 3000 Nut, Crownlock /-3 unc 9 5033 Trunnion Inf. Height 30 00X Nut, Special 3 930 Washer 3/3 x 5/ x Ga. 3 350 Spring, Compression Inf Hgt 33 0030 Pin, Cotter 3/3 x / 34 3 Rod, Adj Lift 35 305 Knob, Inf 3/- unc 3 5509 Pointer, Height Indicator 39 3935X Plug, Hole 40 005 Screw 5/- x 3/4 4 5994 Nut, Lift Link /-0 4 940 Washer /3 x -/ x 0 Ga. 43 3934X Scale, Indicator Height 0 45 Nut, Hexfl ange Lock 045X Nut, Push Phos & Oil 3 335000 Nut Hex Jam 3/- unc 4 Arm Susp. Rear RH 5 505 Plate Asm Susp. Front 550 Pin Flange 05 Trunnion Susp. Arm 59 Trunnion Susp. Front 9 Arm Susp. Rear LH 5 903 Insert Wear 5 Bolt Shoulder NOTE: All component dimensions given in U.S. inches inch = 5.4 mm 5
MOWER DECK 4 4 34 3 90 95 4 4 4 43 49 5 4 0 94 54 / 4_nose_roller_ 0 3 9 90 9 5 5 3 3 33 9 50 5 33 53 40 39 4 33 30 3 3 9 5 3 35 3 5 59 49 9 5 0 5 4 5 3 mower_deck-54_
MOWER DECK 944 Deck Weldment Mower 5 4939M Retainer Spring 9 Cover Mandrel LH Cover Mandrel RH 435 Bolt / Asm. Blade 54 Blade, Standard (For mulching mowers only) 3 9 Shaft Asm. w/lower Bearing 4 Housing, Mandrel 5 045X Bearing, Ball, Mandrel 40505 Bolt, Carriage 5/- x 5/ 30500 Nut, Crownlock 5/- unc 5 0 Spring, Torsion 045X Nut, Push 5X4 Defl ector Shield 9 349 Rod, Hinge 30 394 Screw, Thdroll Washer Head 3 90 Washer, Spacer Mower Vented 3 343 Pulley, Mandrel 33 34 Nut, Flg. Top Lock Cntr. 9/ 34 3000 Nut 35 35 Pin Suspension Rear 3 933 Washer 3/3 x 3/ x Ga. 3 5 Spring Compression 39 4 Pulley, Idler, Stationary 40 933 Washer 3/3 x 3/ x Ga. 4 9303 Washer 3/3 x -3/ x 3 Ga. 4 05X Spacer, Retainer 43 9 Arm, Idler 4 39 Screw, Thdroll. /4-0 x 5/ 4 93 V-Belt, Mower, Secondary 49 390000 Nut, Lock Flg. 3/- unc 50 0 Bolt, Carr. 3/- x 5 00 Bolt 5 40 Pulley Idler Clutching 53 403 Bolt Fin Hex 3/- unc x -/4 5 559 Bar Pnt Adj. 5 594 Pin Head Rivet 5 34 Baffl e Right 59 344 Baffl e Left 0 0 Baffl e Center 90 405 Bolt 5/- x 9 0535 Bracket Asm N Roller RH 94 0 Roller Nose 4" 95 0534 Bracket Asm N Roller LH 9 9330 Washer Hardened 9 Spring Clutch Drive 3 050 Bolt Rdhd Sqnk 5/- x 3/4 4 55 Rod Tension Relief 9340 Bolt, Shoulder 43 Gauge Wheel 393000 Nut, Centerlock 3/- unc 9 944 Washer 3/ x / x 4 Ga. 55 Bushing Tension Relief 0 300500 Nut 5/- 9 Rod Roller Nose Narrow 3 355 Retainer Spring - - 9 Mandrel Asm. Service (Includes Key Nos. 3-5 and 33) - - 90 Replacement Mower, Complete (Std. Deck-Order separately nose roller components key nos. 90, 9, 94, 95, 0,, 3) NOTE: All component dimensions given in U.S. inches inch = 5.4 mm
SEAT ASSEMBLY 0 4 0 0 5 4 5 5 3 9 3 3 seat_-vgt 90 Seat 4055 Bracket, Pivot Seat 3 405 Strap Asm. Fender 4 0X Bolt, Shoulder 5/- x. 5 4500 Clip, Push-In Hinged 30000 Nut, Crownlock 3/- 4X Spring, Seat Cprsn. Bolt 5/- unc x 3/4 w/sems 0 493 Pan, Seat 44 Bracket, Mounting Switch 3 4X Bushing, Snap 4 0504 Bolt, Carriage /4-0 x -/ 5 49X Spacer, Split 340X Spring, Cprsn. 39X Nut, Lock /4 Lg. Flg. Gr. 5 99 Washer /3 x -3/ x Ga. 9 39 Knob, Seat 0 43X Cap, Spring Seat Blk 5 Bolt 5/- unc-a 3 300500 Nut, Crownlock 5/- NOTE: All component dimensions given in U.S. inches inch = 5.4 mm