BLACKMAX Item No. BM011 Mfg No. 0001 Replacement Parts List 10000-1-1 (Rev:01) OWT INDUSTRIES, INC. P.O. Box, Highway Pickens, SC 71 1-00-7-70
BLACK MAX GENERATOR BM011 1 7 10 11 1 1 1 1 1 SEE FIGURE B 0 SEE FIGURE C 1 71 7 1 71 1 0 1 SEE NOTE A 70 0 71 7 1 7 7 7 11 1 1 7 17 7 0 7 1 7 7 7 77 7 1 SEE FIGURE A 7 7 0
BLACK MAX GENERATOR BM011 The item number will be found on a label attached to the engine. Always mention the model number in all correspondence regarding your GENERATOR or when ordering replacement parts. KEY P/N DESCRIPTION QTY KEY P/N DESCRIPTION QTY KEY P/N DESCRIPTION QTY 1 17100 End Cap (1 mm)... 700 Pivot Pin, Handle (/1-1 x.7 in.)... 100 Washer (/1 in.)... 700 Hex Nut (M)... 700 Washer (1/ in.)... 100 Bolt (M x mm, Flange Hex Hd.)... 7 0700 Fire Danger Label...1 0100 CPSC Label...1 0700 E Label...1 10 070 Fuel Stabilizer Label...1 11 0700 Fire Distance Label (Eng/Sp)... 1 0710 Warning Hangtag...1 1 0001 Logo Label (Black Max, Long)...1 1 070 Fuel Stabilizer Label (Spanish)...1 1 0 Danger Label...1 1 070 Logo Label (Black Max, Small) 17 0700 Handle Release Label...1 1 010010 Handle Release Pin...1 1 7000 Lock Nut (M)... 0 77001 Lock Nut (M10)... 1 7000 Engine Isolator (Large)...1 7000 Engine Isolator...1 77700 Flange Lock Nut (M)... 100 Inquires label...1 000 Lubricant Label...1 07017 Bolt (M x mm, Hex Hd.)... 7 71001 Lock Washer (ID. x OD1. x t)... 7001 Isolator... 071 Start Label...1 0 0771 Performance Label...1 1 7070000 On/Off Switch...1 11017 Fuel Valve Bezel...1 0700 Fuel Label...1 01071 Frame Assembly...1 0700 Combustion Label (Eng/Sp)...1 100 Axle... 7 010 Wheel... 00 Washer (ID10 x OD1.7 x t)... 7100 Hitch Pin... 0 010 Ground Warning Label...1 1 0700 Bolt (M x 1 mm, Flange Hex Hd.)...1 00001 Ground Wire Assembly...1 77700 Lock Nut (M)... 010 Foot Assembly... 1007 Bolt (M x mm, Flange Hex Hd.)... 100 Handle Assembly...1 7 1071001 Release Pin...1 1071001 Lanyard...1 0100 Lock and Pin Label...1 0 0001 Screw (-0 x / in., Pan Hd.)... 1 000 Control Panel Assembly (See Fig. C)...1 0000 Wire Assembly (Black)...1 07001 Wire Assembly (Green)...1 7000 Ground Lug...1 0100 Ground Label...1 107071 Generator Head Assembly (See Fig. A)...1 7 0700 Bolt (M x mm, Flange Hex Hd.)... 70 Heat Shield...1 001 Muffler...1 0 1700 Spark Arrestor...1 1 10001 Screw (- x / in., Pan Hd.)... 7001 Hex Nut (M)... 7700 Exhaust Gasket...1 001 Fan Cover (Generator Head)...1 7001 Washer (ID x OD. x t)...1 0700 Bolt (M x 1 mm, Flange Hex Hd.)...1 7 10001 Bolt (M x 10 mm, Flange Hex Hd.)...1 00001 Plug (Generator Head)...1 See Note A Engine (Ducar 0cc)...1 70 00 Recoil Housing Label...1 71 707100 Handle Bumper... 7 0001 Hot Surface Label...1 7 7100 Lock Nut (1/-0)...1 7 07 Data Label...1 7 107011 Carbon Canister...1 7 77000 Canister Bracket...1 77 071700 Zip Tie, (-1/ in., Black)... 7 1000 Screw (10-1 x / in.)... 7 7017 Purge Hose (0 mm)...1 Not Shown: 10001 Hardware Kit (Inc. Key Nos., - and -) 10000 Operator s Manual 10000 Quick Reference Guide 01000 Quick Release Pin Assembly (Inc. Key Nos. 1 and 7) NOTE A: OWT Industries, Inc., will not provide engines as replacement parts. Engines are covered through the engine manufacturer s warranty. Consult the accompanying engine manual or contact our service department for assistance. WARNING: To avoid possible personal injury or equipment damage, a registered electrician or an authorized service representative should perform installation and all service. Under no circumstances should an unqualified person attempt to wire into a utility circuit.
BLACK MAX GENERATOR BM011 10 11 1 1 7 10 1 1 17 1 1 1 FIGURE A
BLACK MAX BM011 The item number will be found on a label attached to the engine. Always mention the item number in all correspondence regarding your GENERATOR or when ordering replacement parts. FIGURE A PARTS LIST KEY PART NO. NUMBER DESCRIPTION QTY. 1 0011 Bolt (M x 1 mm, Flange Hex Hd.)... 700 Brush Cover...1 001 Bolt (M x 1 mm, Flange Hex Hd.)... 00010 Automatic Voltage Regulator...1 0100 Brush Assembly Kit...1 70700 Rubber Boot...1 7 0000 Terminal Block...1 170 Rotor Bolt (M x mm, Flange Hex Hd.)...1 701 Washer (ID. x OD.1 x t)...1 KEY PART NO. NUMBER DESCRIPTION QTY. 10 1001 Stator Bolt (M x 10 mm, Flange Hex Hd.)... 11 00 Bolt (M x 00 mm, Hex Hd.)... 1 700 Bearing Support...1 1 0 Generator Head Cover...1 1 107710 Stator Assembly...1 1 0000 Hex Nut (M)... 1 10770 Rotor Assembly...1 17 1001 Ball Bearing (10 mm)...1 1 0771001 Fan (10 mm)...1 NOTE A: OWT Industries, Inc., will not provide engines as replacement parts. Engines are covered through the engine manufacturer s warranty. Consult the accompanying engine manual or contact our service department for assistance. WARNING: To avoid possible personal injury or equipment damage, a registered electrician or an authorized service representative should perform installation and all service. Under no circumstances should an unqualified person attempt to wire into a utility circuit.
BLACK MAX GENERATOR BM011 1 1 1 1 1 1 10 7 11 FIGURE B
BLACK MAX BM011 The item number will be found on a label attached to the engine. Always mention the item number in all correspondence regarding your GENERATOR or when ordering replacement parts. FIGURE B PARTS LIST KEY PART NO. NUMBER DESCRIPTION QTY 1 10700 Fuel Cap...1 7007 Ring Clip...1 100 Spacer (Fuel Tank Isolator)... 100 Bushing (Fuel Tank Isolator)... 107111 Fuel Tank...1 7000 Fuel Line Clamp (1/ in.)... 7 70071 Fuel Line (1 mm)...1 000 Fuel Shut Off Valve...1 700 Fuel Line ( mm)...1 10 07001 Fuel Filter...1 11 70070 Fuel Line ( mm)...1 1 7000 Fuel Line Clamp (7/1 in.)... 1 7010 Vapor Hose (0 mm)...1 1 7001 Fuel Hose Protector...1 1 1000 Fuel Tank Vapor Vent...1 NOTE A: OWT Industries, Inc., will not provide engines as replacement parts. Engines are covered through the engine manufacturer s warranty. Consult the accompanying engine manual or contact our service department for assistance. WARNING: To avoid possible personal injury or equipment damage, a registered electrician or an authorized service representative should perform installation and all service. Under no circumstances should an unqualified person attempt to wire into a utility circuit. 7
BLACK MAX GENERATOR BM011 7 11 1 10 1 1 FIGURE C
BLACK MAX BM011 The item number will be found on a label attached to the engine. Always mention the item number in all correspondence regarding your GENERATOR or when ordering replacement parts. FIGURE C PARTS LIST KEY PART NO. NUMBER DESCRIPTION QTY 1 0001 Screw (-0 x / in., Pan Hd.)... 07007 Label (Power Outlet)...1 0 Front Panel...1 7001 U-Clip Nut... 770001 Hex Nut (-)... 70100 Outlet Cover (10 Volt)... 701007 Outlet Cover (0 Volt)...1 7 0000 Duplex Receptacle (10 Volt)... 700001 Circuit Breaker, 0 Amp... 70100 Circuit Breaker, Amp... 10 00100 Twist Lock Receptacle (0 Volt)...1 11 170700 Control Box (Back Panel)...1 1 70700 Rubber Boot...1 1 0001 Wire Sleeve...1 NOTE A: OWT Industries, Inc., will not provide engines as replacement parts. Engines are covered through the engine manufacturer s warranty. Consult the accompanying engine manual or contact our service department for assistance. WARNING: To avoid possible personal injury or equipment damage, a registered electrician or an authorized service representative should perform installation and all service. Under no circumstances should an unqualified person attempt to wire into a utility circuit.
10 BLACK MAX GENERATOR BM011 7 7 1 1 7 0 77 0 7 7 1 1 7 1 7 7 7 7 1 1 1 17 17 71 1 7 7 7 7 1 1 1 10 11 7 0 1 1 0 1 0 7 7 7 70 0 0
BLACK MAX GENERATOR BM011 The item and manufacturing numbers will be found on a label attached to the engine. Always mention the item and manufacturing number in all correspondence regarding your GENERATOR or when ordering replacement parts. PARTS LIST FIGURE E KEY P/N DESCRIPTION QTY KEY P/N DESCRIPTION QTY 1 DP00 Crankcase... 1 DP00 Ball Bearing... DP11 Oil Seal... DP1 Governor Arm Shaft Seal... 1 DP01 Governor Arm Shaft... 1 DP0 Governor Arm Shaft Washer... 1 7 DP0 Lock Pin... 1 DP117 Drain Plug Bolt... DP00 Drain Plug Washer... 10 DP10 Oil Level Switch Assembly... 1 11 DP1 Bolt (M x1 mm)... 1 DP001 Casecover Dowel Pin... 1 DP10 Piston... 1 1 DP10 Piston Scraper Ring Set... 1 1 DP10 Connecting Rod Assembly... 1 1 DP01 Piston Pin... 1 17 DP101 Piston Clip... 1 DP0111 Crankcase Cover Assembly... 1 1 DP01 Ball Bearing... 1 0 DP01 Governor Assembly... 1 1 DP100 Cylinder Head... 1 DP170 In Valve... 1 DP0 Exhaust Valve... 1 DP107 Intake Valve Returner... DP1 Oil Seal Valve... DP00 Valve Spring... 7 DP01 Starter Assembly Rubber... 1 DP10 Exhaust Valve Spring Seat... DP01 Push Rod Guide Plate... 1 0 DP101 Rocker Assembly... 1 DP10 Rotator... DP101 Stud Bolt... DP1007 Stud Bolt... DP0 Exhaust Packing... 1 DP010 Flywheel Assembly... 1 DP0 Spring Washer... 7 DP0011 Nut (M)... DP Carburetor Assembly... 1 DP1 Fuel Line... 1 0 DP0 Fuel Line Clip (. mm)... 1 1 DP001 Governor Arm... 1 DP1 Governor Arm Bolt... 1 DP001 Nut (M)... DP01 Crankshaft Assembly... 1 DP101 Valve Lifter... DP07 Casecover Package... 1 7 DP001 Balancing Shaft... 1 DP00 Camshaft Assembly... 1 DP01 Wire Harness Clip... 0 DP1 Bolt (M x 0 mm)... 7 1 DP001 Dowel Pin... DP0 Cylinder Head Gasket... 1 DP11 Bolt (M10 x 0 mm)... DP710 Spark Pulg... 1 WARNING: To avoid possible personal injury or equipment damage, a registered electrician or an authorized service representative should perform installation and all service. Under no circumstances should an unqualified person attempt to wire into a utility circuit. 11
BLACK MAX GENERATOR BM011 The item and manufacturing numbers will be found on a label attached to the engine. Always mention the item and manufacturing number in all correspondence regarding your GENERATOR or when ordering replacement parts. PARTS LIST FIGURE E KEY P/N DESCRIPTION QTY KEY P/N DESCRIPTION QTY DP101 Push Rod... DP001 Shroud... 1 7 DP1 Bolt (M x 1 mm)... DP110 Cylinder Head Cover Comp... 1 DP07 Headcover Packing... 1 0 DP11 Lock Bolt... 1 1 DP0 Upper Shroud Assembly... 1 DP01 Recoil Starter Fan... 1 DP01 Starter Pulley... 1 DP000 Nut... 1 DP71 Ignition Coil Assembly... 1 DP11 Bolt (M x mm)... 7 DP07 Intake Packing... 1 DP01 Carburetor Insulator... 1 DP01 Carburetor Packing... 1 70 DP7 Carburetor Spacer... 1 71 DP701 Governor Rod... 1 7 DP01 Throttle Return Spring... 1 7 DP70-07A Recoil Starter Assembly... 1 7 DP11 Rocker Arm Adjuster... 7 DP001 Clip... 7 DP11 Air Cleaner Assembly... 1 77 DP Breather Tube... 1 7 DP00 Locking Flaps... 7 DP101 Governor Spring... 1 0 DP10 Amplifier... 1 1 DP1 Dipstick... 1 DP Fiberglass Tube... 1 DP01 Fuel Rubber... 1 Not Shown D10 High Alt Kit (DUCAR 0CC,000-7,000 FT) WARNING: To avoid possible personal injury or equipment damage, a registered electrician or an authorized service representative should perform installation and all service. Under no circumstances should an unqualified person attempt to wire into a utility circuit. 1
BLACK MAX GENERATOR BM011 RED WHITE BATTERY CHARGER PCBA BREAKER A BREAKER 0A TO GENERATOR HEAD L N G L BLACK WHITE Y G N BLACK X BLACK WHITE WHITE WHITE 10V OUTLET GREEN/YELLOW GREEN/YELLOW GREEN/YELLOW RED RED BREAKER A BREAKER 0A BLACK 10V OUTLET DIGITAL DISPLAYER RED Neutral-Ground Bond WIRING DIAGRAM 1