8 6 2 OUTLET-DEFR,W/SWIVEL,2" 22-0-0A (UP TO 09--09)RVRSTN 22-0-0A (AFTER 09-6-09)BLK CLAMP-HOSE 620-02-000 SCREW G-08-2U (2) REGISTER 9-02-02A CLAMP-HOSE 620--000 SCREW G-08-2U (2) REDUCER-"-2" 86-0-000 CONNECTOR 06966-02-000 CLAMP 620--000 CLAMP 620-0-000 RELEASE REV ZONE REV DATE A REVISION RECORD DWG NO 6860 DATE DFTR-ORIG D D CONNECTOR 06966-02-000 CLAMP 620--000 REGISTER 9-0-02A CLAMP-HOSE 620--000 SCREW G-08-2U (2) C C REGISTER 9-02-02A CLAMP-HOSE WORMGEAR 620--000 SCREW G-08-2U (2) DUCT-2" 998-02-000 (800) CONNECTOR 06966-02-000 CLAMP 620--000 CONNECTOR 06966-02-000 CLAMP 620--000 B DUCT-" 998-0-000 (,00) FURNACE-20,000 BTU 9980--000 EXTR 00226--00 (2) DOOR-FURNACE 9980-0-0A SCREW G6806-6-0 () B COPYRIGHT 2009 WINNEBAGO R INDUSTRIES, INC. DFTR ORIG. DATE DUCT-" 998-0-000 (00) CHKR P.E. ALL DIMENSIONS ARE IN MILLIMETERS A. SECURE ALL TEES OR SPLICES WITH A FLEXIBLE DUCT TO FLOOR OR WALL USING CABLE TIE 0806-02-000.. ALL FLEXIBLE DUCTS TO BE SECURED TO FLOOR OR WALL AT 29 INTERVALS MAXIMUM USING CABLE TIE 0806-02-000. DUCT-" 998-0-000 (600) M.E. DSNR UNSPECIFIED TOLERANCES ARE: WHOLE DIM (X) ONE-PLACE (X.X). TWO-PLACE (X.XX) 0.0 MATERIAL: FIRST USED 09 2DL A. ALL EXPOSED EDGES MUST BE COVERED WITH TAPE 889-0-000. ANGLE THIRD ANGLE PROJECTION 2. USE SEAL 900-0-000 ON ALL SURFACES THAT CONTACT FLOOR. DO NOT SCALE DRAWING. FURNACE WILL BE INSTALLED TO VENDORS SPECIFICATIONS. TITLE: HEATING SYSTEM INSTL NOTES: SHEET OF PART NO 6860 REV 8 6 2 REF: 0//2009
2 9 6 28 26 2 2 2 6 8 22 2 6 2 6 0 2 9 9 0 8 9 6 66 6 62 9980-0-000
9980-0-000 (CONTINUED) 9 9980-0-00 EA MANIFOLD ASSEMBLY 09009-0-0 EA ORIFICE-MAIN BURNER 809 2 098668-22-0 EA GASKET - BURNER ACCESS COVER 008 22 9980-0-0 EA ELECTRODE 22286 2 098668-0-0 EA BURNER ASSEMBLY 0062 26 098668-0-8 EA VALVE-GAS SF S.N.99009 622 2 9980-0-02 EA PIPE ASSEMBLY/GAS INLET 098668-0-0 EA TUBE ASSEMBLY, EXHAUST W/CAP 2602 9980-0-0 EA HOUSING/COMB. - FRONT/HALF 9082 6 098668-0-06 EA WHEEL-COMBUSTION AIR 08 9980-0-0 EA HOUSING/COMB. - REAR/HALF 9088 9 9980-0-0 EA GASKET/FIREWALL-COMB AIR 008 0 9980-0-06 EA MOTOR ASSEMBLY W/GASKET 22682 2 0990-0- EA GASKET-MICROSWITCH 208 098668-2-00 EA SWITCH-MICRO-W/O FLAG /" 2226 6 9980-0-08 EA BLOWER ASSEMBLY - ROOM AIR 909BK 098668-0- EA WHEEL-BLOWER, ROOM AIR 029 8 9980-0-09 EA ORFICE RING 90696 0 9980-0-0 EA SWITCH - ON/OFF 22 2 9980-0- EA PANEL ASSEMBLY-MODULE BD 066 9980-0-2 EA INSULATOR - MODULE BD 0080 098668-22-0 EA MODULE BD W/RELAY TIME DELAY 20820 9980-0- EA CAP/INSULATOR-MODULE BD 009 9980-0- EA BUSHING - UNIVERSAL 0062 8 9980-0- EA BUSHING - STRAIN RELIEF 2809 9 098668-0-6 EA GASKET-FIREWALL,CHAMBER SIDE 00808 6 9980-0-6 EA CHAMBER ASSEMBLY - FINAL 029BK 62 098668-2-0 EA SWITCH - LIMIT 220 66 098668-0- EA TUBE ASSEMBLY, INTAKE 028 098668-9-00 EA DOOR/CABINET ACCESS 0888 9980-02-00 EA BLOWER ASM-/2 HOUSING/OUTER 908 9980-02-0 EA BLOWER ASM-/2 HOUSING/INNER 9082
2 9 6 28 26 2 2 2 6 8 22 2 6 2 6 0 2 9 9 0 8 9 6 66 6 62 9980-02-000
9980-02-000 (CONTINUED) 9 9980-0-00 EA MANIFOLD ASSEMBLY 09200-02-0 EA ORIFICE-MAIN BURNER (NT-0BW 802 2 098668-22-0 EA GASKET - BURNER ACCESS COVER 008 22 9980-0-0 EA ELECTRODE 22286 2 098668-02-00 EA BURNER ASSEMBLY,SF-0 & SF 00 26 098668-0-8 EA VALVE-GAS SF S.N.99009 622 2 9980-0-02 EA PIPE ASSEMBLY/GAS INLET 098668-0-0 EA TUBE ASSEMBLY, EXHAUST W/CAP 2602 9980-0-0 EA HOUSING/COMB. - FRONT/HALF 9082 6 098668-0-06 EA WHEEL-COMBUSTION AIR 08 9980-0-0 EA HOUSING/COMB. - REAR/HALF 9088 9 9980-0-0 EA GASKET/FIREWALL-COMB AIR 008 0 9980-0-06 EA MOTOR ASSEMBLY W/GASKET 22682 2 0990-0- EA GASKET-MICROSWITCH 208 098668-2-00 EA SWITCH-MICRO-W/O FLAG /" 2226 6 9980-0-08 EA BLOWER ASSEMBLY - ROOM AIR 909BK 098668-0- EA WHEEL-BLOWER, ROOM AIR 029 8 9980-0-09 EA ORFICE RING 90696 0 9980-0-0 EA SWITCH - ON/OFF 22 2 9980-0- EA PANEL ASSEMBLY-MODULE BD 066 9980-0-2 EA INSULATOR - MODULE BD 0080 098668-22-0 EA MODULE BD W/RELAY TIME DELAY 20820 9980-0- EA CAP/INSULATOR-MODULE BD 009 9980-0- EA BUSHING - UNIVERSAL 0062 8 9980-0- EA BUSHING - STRAIN RELIEF 2809 9 098668-0-6 EA GASKET-FIREWALL,CHAMBER SIDE 00808 6 9980-0-6 EA CHAMBER ASSEMBLY - FINAL 029BK 62 098668-2-0 EA SWITCH - LIMIT 220 66 098668-0- EA TUBE ASSEMBLY, INTAKE 028 9980-02-00 EA BLOWER ASM-/2 HOUSING/OUTER 908 9980-02-0 EA BLOWER ASM-/2 HOUSING/INNER 9082
2 9 28 26 2 2 2 2 A 6 22 6 9 8 9 0 2 6 2 8 6 9 0 6 8 9 2 62 9980--000
9980--000 (CONTNUED) 098668-20-0 EA CABINET - 0,000 0889 0696-02-0 EA COLLAR-DUCT 00 9980--0 EA ORFICE - MAIN BURNER 800 6-02-02 EA PLATE-SECONDARY AIR/TOP BACK 0698 6 6-02-0 EA PLATE-SECONDARY AIR/TOP FRT 0629 9 6-02-0 EA PLATE-SECONDARY AIR/BOTTOM 0629 22 9980-0-0 EA ELECTRODE 22286 2 9980--0 EA BURNER ASSEMBLY 006 26 098668-0-8 EA VALVE-GAS SF S.N.99009 622 9980--0 EA VENT CAP & EXHAUST TUBE ASM 260 2 098668-0- EA TUBE ASSEMBLY, INTAKE 028 9980-0-0 EA COMBUSTION AIR HOUS FRT/HALF 9082 9980--0 EA HOUSING/COMB/AIR - REAR/HALF 9089 8 9980--02 EA WHEEL-COMBUSTION AIR 089 9 9980-0-0 EA GASKET/FIREWALL-COMB AIR 008 0 9980-0-06 EA MOTOR ASSEMBLY W/GASKET 22682 2 9980-02-0 EA BLOWER ASM-/2 HOUSING/INNER 9082 9980-02-00 EA BLOWER ASM-/2 HOUSING/OUTER 908 098668-2-00 EA SWITCH-MICRO-W/O FLAG /" 2226 8 9980-0-0 EA SWITCH - ON/OFF 22 0 098668-22-0 EA MODULE BD W/RELAY TIME DELAY 20820 9980-0- EA CAP/INSULATOR-MODULE BD 009 2 098668-0- EA WHEEL-BLOWER, ROOM AIR 029 9 9980--00 EA SWITCH - LIMIT 220 CONTACT WINNEBAGO PART SALES FOR UNLISTED COMPONENTS
8 6 2 DWG NO 6986 COOL HIGH LOW GROUND Y GL GH B D XP JM D XS XR AIR CONDITIONER 86-0-CHT AIR CONDITIONER 86-02-CHT HE 29P WIRE ASM-ROOF DETAIL DA C COOL HEAT PUMP HIGH LOW GROUND C Y W GH GL B XP BBH XR XS JM 00-SERIES 00-SERIES H-SERIES 6986-0 WIRE ASM-ROOF DETAIL DB B B BOARD-DIVIDER 8-02-CHT CEILING ASM 8-06-CHT DETAIL DA CEILING ASM 8-0-CHT DETAIL DB HE HE 29P 29P 29P AC HEAT PUMP-HI EFF, LOW PFL HE A/C ROOF-HI EFF LOW PROFILE 26 CODES/STANDARDS-CSA/CMVSS A B CODES/STANDARDS USA A B 26 FOR ELECTRICAL TORQUE SPECIFICATIONS SEE DWG NO. 288-0-000 8 6 2 FIRST USED TITLE: SHEET 0 MOTORHOMES DO NOT SCALE DRAWING WIRING INSTL-ROOF A/C PART NO 6986 REV 0/2/2009
2 2 6 9 8 0 8-06-0A 8-0-00 EA PLUG ASSEMBLY 0A89 8-0-0 EA TERMINAL BOARD 0B20 6 8-0-02 EA ISOLATOR - BLANK 0C6 8-0-00 EA BOARD - P.C. 0D2 9 08892-0-0 EA FILTER 698A6 0 08892-0-0 EA GRILLE 6 /8X6 /8 RETURN 698-0 0620-2-9 EA COIL SENSOR 0A2 2 8-0-0 EA JUNCTION BOX ASSEMBLY 0B 8-0-0 EA SMALL PARTS PKG 80-96 8-0-06 EA NUT/WING 200-0
9 0 2 6 8 2 8-0-0A 8-0-0 EA BOX - JUNCTION 0-8-0-00 EA PLUG ASSEMBLY 0A0 6 8-0-02 EA BOARD - TERMINAL 0B20 8-0-02 EA ISOLATOR - BLANK 0C6 8 8-0-0 EA BOARD - P.C. 0B 0 08892-0-0 EA FILTER 698A6 08892-0-0 EA GRILLE 6 /8X6 /8 RETURN 698-0 2 8-0-06 EA JUNCTION BOX ASM.(HEAT PUMP) 0-08 0620-2-9 EA COIL SENSOR 0A2 8-0-06 EA NUT/WING 200-0 8-0-00 EA SMALL PARTS PKG 80-9
6 2 0 22 2 2 9 2 2 8 9 8 2 2 26 2 20 6 86-0-0A 86-0-0 EA OVERLOAD 0-0 2 86-0-02 EA COMPRESSOR 0A289 86-0-0 EA MOTOR - BLOWER 68A29 0620-0-0 EA PTCR (START DEVICE) - W/CAP. 8A902 096-0-0 EA CAPACITOR-FAN (INDOOR MOTOR) 99-6 6 88-0-0 EA RUN CAP. (COMP-0MFD/0V) 99-2 86-0-0 EA COIL-CONDENSER 2-20 8 86-0-0 EA COIL - EVAPORATOR 2-2 9 02-0-0 EA BLOWER WHEEL 2-0 02-0-06 EA FAN BLADE 2-02 068-0- EA GASKET PACKAGE 82-0 2 86-0-00 EA SHROUD - (ARCTIC WHITE) 92A6 86-02-02 EA GRILLE - F/FAN 92A
86-0-02A 86-0-0 EA OVERLOAD 0-0 2 86-0-02 EA COMPRESSOR 0A289 86-0-0 EA MOTOR - BLOWER 68A29 0620-0-0 EA PTCR (START DEVICE) - W/CAP. 8A902 096-0-0 EA CAPACITOR-FAN (INDOOR MOTOR) 99-6 6 88-0-0 EA RUN CAP. (COMP-0MFD/0V) 99-2 86-0-0 EA COIL-CONDENSER 2-20 8 86-0-0 EA COIL - EVAPORATOR 2-2 9 02-0-0 EA BLOWER WHEEL 2-0 02-0-06 EA FAN BLADE 2-02 068-0- EA GASKET PACKAGE 82-0 2 86-0-06 EA SHROUD - (BLACK) 92A9 86-02-02 EA GRILLE - F/FAN 92A
6 26 2 22 2 2 0 9 2 8 2 6 8 86-02-0A 86-0-0 EA OVERLOAD 0-0 2 86-0-02 EA COMPRESSOR 0A289 86-02-00 EA COIL - CONDENSER 2-2 0620-2-08 EA COIL - SOLENOID 60-08 86-0-0 EA MOTOR - BLOWER 68A29 6 0620-0-0 EA PTCR (START DEVICE) - W/CAP. 8A902 096-0-0 EA CAPACITOR-FAN (INDOOR MOTOR) 99-6 8 88-0-0 EA RUN CAP. (COMP-0MFD/0V) 99-2 0 86-02-0 EA COIL - EVAPORATOR 2-26 02-0-0 EA BLOWER WHEEL 2-2 02-0-06 EA FAN BLADE 2-02 068-0- EA GASKET PACKAGE 82-0 6 86-02-02 EA GRILLE - F/FAN 92A 26 86-0-00 EA SHROUD - (ARCTIC WHITE) 92A6 20 9 2
86-02-02A 86-0-0 EA OVERLOAD 0-0 2 86-0-02 EA COMPRESSOR 0A289 86-02-00 EA COIL - CONDENSER 2-2 0620-2-08 EA COIL - SOLENOID 60-08 86-0-0 EA MOTOR - BLOWER 68A29 6 0620-0-0 EA PTCR (START DEVICE) - W/CAP. 8A902 096-0-0 EA CAPACITOR-FAN (INDOOR MOTOR) 99-6 8 88-0-0 EA RUN CAP. (COMP-0MFD/0V) 99-2 0 86-02-0 EA COIL - EVAPORATOR 2-26 02-0-0 EA BLOWER WHEEL 2-2 02-0-06 EA FAN BLADE 2-02 068-0- EA GASKET PACKAGE 82-0 6 86-02-02 EA GRILLE - F/FAN 92A 26 86-0-06 EA SHROUD - (BLACK) 92A9