VON SOFTTOP escription min. 200 cm max. 500 cm 0 min. 200 cm max. 600 cm Terrace pavilion consisting of a surrounding cubic frame profile (aluminium extruded profile dimension 230 x mm) and a folding awning as canopy. The construction is held up by 4 support profiles ( x mm). range of foot plates adds the perfect finish. The frame profile can be fixed directly onto a building. This means that wall or ceiling installation (with an additional angle profile) is possible. Water is drained away through a built-in gutter in the frame profile, into which the water flows over the cover. The gutter is drained via drainage pipes in the supports. The folding awning, consisting of separate cover tracks held by Keder profiles (30 x 65 mm), can be extended and retracted using the front rail (70 x 65 mm). patented distance sensor system with trimmers and rolls is also used. This extends the fabric webs and then folds them again in a controlled manner. over: Fabric covering consisting of polyester fabric (630 g/m²) with polyvinyl chloride coating and high-grade surface texture making it suitable for permanent outdoor use. Material thickness 0.5 mm. Washable and watertight up to a water column of 3000 mm. Flammability: Flame-resistant class 1 in accordance with IN 4102-1. Wind resistance: The system fulfils wind resistance class 4 when extended or up to 150 km/h when retracted (in acc. with IN 13561). rive: riven by an electrical drive with mechanical end stop. Power feed 230 V, IP protection class 54. Force transfer to a motor shaft 6-kant 16 mm Ø, which uses toothed wheels to pass on the movement to a plastic toothed belt with Kevlar reinforcement on both sides on the drop profile. Options: rainage: The water can either be drained through two supports directly through the foot plates or via a lateral recess on the supports. In the case of a cover area of up to 17 m 2 only 1 water run-off is needed, up to 30 m 2 both are necessary. daptive LE lighting: triangular aluminium LE profile can be hung on the built-in gutter on the frame profile. The integrated LE strip light (colour temperature warm white) is covered by a reflective plastic profile. Flexible assembly allows you to choose either direct or indirect illumination. The lighting can be turned on and off or dimmed via an external light switch/dimmer. It is also possible to switch the lighting on and off or dim it via remote control. Glazing: For side glazing, the all-glass sliding panel system SV1020 up to max. 15 m 2 per side is used. I.S.L.. concept: Using specific connection fittings, the supports can optionally be installed in the corners of the frame profile on the floor system S4700. METHO OF ELIVERY Guides pre-mounted in carrier, supports, cord profile in packages with maximum of 4 pieces, cover board and remaining single parts loose, without fasteners 7.1
VON SOFTTOP Side and support position 4 1 3 2 UTION Motor drive: lways central on side rainage: lways on side (corner 1 / corner 2) View / min. 2000 max. 6000 min. 1000 max. 3000 2400 230 (Standard) 23 110 / = Total width / = Total projection 7.2
VON SOFTTOP View / min. 2000 max. 5000 min. 1000 max. 3000 230 23 2400 (Standard) S4700 ssembly on system flooring Fabric track with cover board 2000 2400 3000 3500 4000 4500 5000 6000 x = 287 317 347 377 407 437 467 497 n = 2 3 4 5 6 7 8 9 y = 480 510 540 570 600 630 660 690 ~20 750 / 900 x 100 (n x 30) + 10 117 30 61 110 230 23 y 7.3
VON SOFTTOP TP313 Foot plate (Standard) 67.25 250 20 210 20 250 20 210 20 / 67.25 / 67.25 TP314 Foot plate (Floor system S4700) / S4700 / / = Total width / = Total projection 7.4
VON SOFTTOP TP314 Foot plate (Hole pattern) 48.6 48.6 43.55 44.25 27.75 43.55 26.25 38.25 21.25 16.75 1.8 48.6 44.25 43.55 21.25 38.25 18.25 16.75 1.8 48.6 43.55 27.75 26.25 3 TP314-1 Foot plate (alustrade) / 29.75 56 29.75 30 55.5 30 30 55.5 30 29.75 56 29.75 / 7.5
VON SOFTTOP TP319 Foot plate (orner) / 64.5 180 30 120 30 30 120 30 180 64.5 / 64.5 / = Total width / = Total projection 61 230 ø10.5 ø25 50 Wall installation 61 54 7.6
VON SOFTTOP ssembly (superior) 61 ø10.5 50 230 ø25 61 54 ssembly (suspended) 61 230 ø10.5 ø25 50 61 54 7.7
VON SOFTTOP Wall connection variants with 2 support 1 2 4 1 3 4 2 3 orner connection on two long walls with 1 support 1 2 3 4 7.8
VON SOFTTOP Wall connection on a shortened wall with 3 supports 3 2 1 2 4 1 1 4 2 3 3 4 orner connection on two short walls with 3 supports 3 2 1 2 4 1 1 4 2 3 3 4 7.9
VON SOFTTOP Wall connection mounting (long wall) Lateral profile with gutter TP310 68.5 30 X X 30 68.5 476-651 476-651 230 10.5 25 TP310 End profile with gutter TP318 68.5 30 X X 30 68.5 476-651 476-651 230 10.5 25 TP318 68.5 30 X X 30 68.5 476-651 476-651 Total width ( / ) Total projection ( - ) 10.5 X = 2000-2100 mm 25 601-635 mm 4 2201-2800 mm TP310 476-651 mm 5 230 Holes Piece 2801-3400 mm 521-641 mm 6 3401-4100 mm 534-651 mm 7 4101-4700 mm 558-644 mm 8 4701-5400 mm 563-651 mm 9 5401-6000 mm 579-645 mm 10 7.10
VON SOFTTOP Wall connection mounting (short wall) Lateral profile with gutter TP310 (left / right) Y = min. 500-650 68.5 30 X X X 68.5 155 155 155 230 10.5 25 TP310 End profile with gutter TP318 (left / right) Y = min. 500-650 68.5 X X X 30 68.5 155 155 155 25 10.5 230 TP318 Total width ( / ) Total projection ( - ) X = Holes Piece Y = 2000-2500 mm 155 mm 3 500 2501-4100 mm 155 mm 4 650 4101-6000 mm 155 mm 4 650 7.11
VON SOFTTOP rainage 4 3 1 2 rainage always on side (corner 1 / corner 2) 0 17 m 2 One run-off required for fabric area 17 30 m 2 Two run-offs required for fabric area W3, W4 = from the side of the support rainage large W5 = through the support below Not possible to combine with system flooring S4700 50 50 10 10 45 60.5 60.5 45 45 60.5 60.5 45 rainage small 18 18 50 50 10 10 86 ø46.2 18 18 15 15 40 60.5 40 60.5 60.5 40 60.5 40 For the small drainage gutter, two water outlet holes per support are always required 15 15 86 7.12
VON SOFTTOP rainage P734 P735 P733 P730 P732 rainage always on side (corner 1 / corner 2) 0 17 m 2 One run-off required for fabric area 17 30 m 2 Two run-offs required for fabric area 7.13
VON SOFTTOP Power supply line 4 3 1 2 P3, P4 = from the side of the support P5 = through the support below Not possible to combine with system flooring S4700 11 11 34 81.5 55 ø10 55 7.14
VON SOFTTOP TP317-2 Electrical corner cover (Wall connection) 34.4 34 P8 P6 11 11 225 P9 P7 11 7.15
VON SOFTTOP Gutter illumination SL300 direct indirect LE Lighting SL315 - SL350 SL315 SL320 SL325 SL330 SL335 SL340 SL345 SL350 Total projection = Lenghts LE Lighting = 2 x 12W = 24W 2 x 16W = 32W 2 x 20W = 40W 2 x 24W = 48W 2 x 28W = 56W 2 x 32W = 64W 2 x 36W = 72W 2 x 40W = 80W 229-282 335 388 441 494 544 597 600 cm 150 12W 200 250 300 350 400 450 500 cm 12W 16W 16W 20W 20W 24W 24W 28W 28W 32W 32W 36W 36W 40W 40W 7.16
VON SOFTTOP Exploded view TP334/2 GP537 TP326 TP111 S120 TP735 S227/3 TP327 TP703 S227/3 TP318 TP334/1 TP348/. TP345 TP702 TP342/. TP122 TP704 TP318 TP720 TP710 TP343-... TP340 TP310 TP705 TP108-2 TP341 TP707 TP TP321 TP317-2 TP307 TP713 TP323-2 TP316 P713 TP313 TP314 TP314/1 TP319 7.17
VON SOFTTOP omponents list TP108/1 TP108/2 for TP310 for TP310 End cover gutter left End cover gutter right TP111 Motor holding bracket TP for TP720 Holding bracket TP122 rive fitting TP307 rip tray fitting TP307-1 rip tray fitting TP310 Side profile with gutter 400 cm 500 cm 600 cm TP313 ase plate fittings (standard) TP314 ase plate fittings (floor system) TP314-1 ase plate fittings (floor covered installation) TP316 Support profile 300 cm TP317-1 orner cover (with support) 227.5 mm TP317-2 orner cover (with wall connection) 225 mm TP317-1 orner cover (electrical connection with support) 227.5 mm TP317-2 orner cover (electrical connection with wall connection) 225 mm TP318 End profile with gutter 400 cm 500 cm 600 cm TP319 ase plate fittings (corner) TP321 for TP317-. End cover fitting TP323-2 orner connector set (with supports) TP323-5/1 for corner 1 / 3 orner connector set TP323-5/2 for corner 2 / 4 orner connector set TP326 for S120 End profile 700 cm TP327 for S120 ngled bracket fittings TP334/1 for S120 Roof mounting fittings, left TP334/2 for S120 Roof mounting fittings, right TP335 over fitting TP340 -profile 650 cm TP341 Idler fittings TP342/1 TP342/2 left right Guide profile TP343-... Trimmer 247.5 mm 259.0 mm 270.5 mm 282.0 mm 294.0 mm 306.o mm TP345 for TP348/. Visible panel TP347 for TP348/. over panel fittings TP348/1 TP348/2 left right over panel TP702 ord profile 500 cm pair 7.18
VON SOFTTOP TP703 Roller tube ø 60 mm (powder-coated) 700 cm TP704 Wide cord profile 500 cm TP705 for TP704 End cover fitting TP707 for TP702 End cover fitting TP709-20 Motor 20NM TP710 for TP310 Guide profile 500 cm 600 cm TP713 Pulley kit TP720 Toothed belt TP735 racket fittings S120-75 S120-90 Flat cover board 750 x 5000 cm 900 x 5000 cm GP537 Glass sealing strip 700 cm S227/3 Hexagonal shaft 250 cm S359 V plastic cover P703 for P713 racket to water hose P713 Water hose lm P730 Roof drain pipe 100 cm 200 cm P731 for P730 Roof drain angle bracket 85 P732 for P730 Roof drain bracket 70 P733 for P730 Pipe clamp for drain P734 for P730 ase plate P735 for P730 Threaded bar lm EZ6074 EZ6075 EZ6076 open/closed Radio RTS Radio io Insert drive EZ6063 EZ6064 EZ6065 EZ6066 SL315 SL320 SL325 SL330 SL335 SL340 SL345 SL350 on/off 90W on/off 120W Radio io 90W Radio io 120W Insert lighting SL300 LE lighting complete 150 cm 200 cm 250 cm 300 cm 350 cm 400 cm 450 cm 500 cm 7.19
VON SOFTTOP TP108/1 / TP108/2 TP307-1 TP316 TP111 TP310 TP317-1 / TP317-2 TP TP313 TP317-1 / TP317-2 TP122 TP314 TP318 TP307 TP314-1 TP319 7.20
VON SOFTTOP TP321 TP327 TP341 TP323-2 TP334/1 TP342/1 / TP342/2 TP323-5/1 TP334/2 TP343-... TP323-5/2 TP335 TP345 TP326 TP340 TP347 7.21
VON SOFTTOP TP348/1 / TP348/2 TP707 TP735 TP702 TP709-20 S120-75 / S120-90 TP703 TP710 GP537 TP704 TP713 S227/3 TP705 TP720 S359 7.22
VON SOFTTOP P703 P733 SL315 - SL350 P713 P734 P730 P735 P731 EZ6074 - EZ6076 P732 EZ6063 - EZ6066 7.23