SPECIFICATIONS: Battery: Suitable age: Maximum Weight: Speed: Dimension: Charger: Battery duration time: 6V, 4.5AH 3-8 years old 30KGS 3.5-4KM/HR FUNCTION AND OPERATION: 88 39 58CM Input 110V/220V 50-60HZ Output: DC 6V/500MA 1-2 hours if fully charged (charges in 8-12 hours) 1.Step on the pedal and the motorcycle will move. And it will stop when you release the pedal. 2.Front/back moving control: Push the forward switch, the motorcycle will move forward.push the backward switch, the motorcycle will move backward. When the motorcycle moves, the front and back lights will shine. 3.The car has 3.5mm input port for MP3 and other music sources. Top cover of tool box Tool box support LIST OF PARTS PACKED Bottom cover of tool box Rear wheel cover Thin axle connecting tool box cover Rear wheel Seat Plastic sleeve pipe TROUBLE SHOOTING: Malfunction Vehicle won t move Check and Eliminate 1.Take off the seat and check whether the fuse is damaged, if so, change it. Fuse is installed in the fuse box outside of battery. 2.Check whether the battery wires are securely connected? 3.Check whether the motor or gearbox is damaged? 4.Check whether the car has a short circuit or the cable is disconnected. Motor Rear shaft Bodywork Panel board Vehicle moves slowly Vehicle can not be charged 1.Check whether the battery is fully charged? 2.Check whether the gearbox is damaged? 1.Check whether the fuse is damaged? 2.Check whether the charger or battery is damaged? Windshield Mirror Car head Front fork Unusual sound 1.Gearbox may be damaged FUSE REPLACEMENT: Only use 15A fuse to replace the damaged one. Fire hazard! The fuse can not be reused. Front fender Iron buckle Front wheel Front wheel shaft OK Damaged Charger M3*10:10pcs M4*14:11pcs Pin :2pcs Washer:10pcs Hardware List Manual Sticker (If necessary) -1- -2-
PARTS PICTURE INSTALLATION 1 2 3 14 15 4 16 5 17 6 1 2 7 8 9 10 11 Top cover of tool box Bottom cover of tool box 12 8 9 18 13 19 Iron washer-10 Rear wheel -2 20 16 17 22 21 Mirror -2 Car head 1.Insert the rear shaft into bodywork. On the left, connect one wheel to the rear shaft. Pay attention to use iron washer in order to fill the gap. Then use the iron pin to fasten it. Affix wheel cover to wheel. On the right, first connect the electric plug. Then connect motor, plastic sleeve pipe, and wheel to the rear shaft. Make sure the inside of wheel fits into the plastic sleeve pipe. Then use the iron pin to fix it and put the wheel cover on the wheel. Pay attention to use the iron washer in order to fill the gap. 2. Fix the tool box support to the body with two screws (M4*14). Then use the thin axle to connect the top cover and the bottom cover to create the tool box. Finally, use four screws (M4*14) to attach the box on the support. 3 Thin axle connecting tool box cover 10 11 Plastic sleeve pipe Motor 18 19 Front fork Front fender 4 Seat 12 Rear shaft 20 Iron buckle 5 Tool box support 13 Bodywork 21 Front wheel 6 Rear wheel cover -2 14 Panel board 22 Front wheel shaft 7 Iron pin -2 15 Windshield -3- -4-
INSTALLATION 3.Connect the battery wires, pay attention to connect red to red, black to black. 6.Fasten the car head to the front fork group with four screws (M4*14). 4.Fix windshield to car head with five screws(m3*10).fix mirrors to car head with four screws( M3*10). 7.Connect the panel board to the head with bodywork. Fasten the seat on bodywork with screw. WARNING 5.Fix front fork with front fender and front wheel. Then use the Iron buckles fasten it. POINTS OF ATTENTION FOR CHARGING: 1. When operating for the first time please open the seat and connect the power wires with the battery, red to red and black to black, then cover them with the seat. Incorrect connection will cause short circuit or malfunction. 2. Charging socket is in the front body. Continuous charging time shouldn t exceed 15 hours. 3. Please charge the car when its speed becomes slow. Battery will be damaged if fully discharged. 4.If out of use for a long period of time, please charge fully before use. Charge at least every 2 months to ensure the full service life of the battery. 5.It is normal for the charger and battery to heat up during charging. 6. Battery disposal should be handled by an adult. Don t burn or disassemble the battery. Please contact local waste removal for proper disposal. 7. Only use manufacturer approved charger and battery. -5- -6-
POINTS OF ATTENTION: WARNING 01.This car must be installed and checked by an adult before use. 02.This car should be used under the supervision of an adult. This car is not a traffic vehicle. It is strictly forbidden to be operated on streets, roads, steps, slopes or near vehicles. The driver should wear shoes. The number of drivers should not exceed one. 03.Please don't let children less than 3 years old operate. 04.Please check the car before using it every time in order to avoid injury. 05.Please teach the child how to operate the car before first use. 06. Please teach the child how to use the pedal and switches and how to deal with the car when the car is stopped by an obstacle. 07.Please make sure the driver sits in the car comfortably before driving. 08.Please don't let other children near the car when the car is moving. It is dangerous! 09. Do not use non-rechargeable batteries. 10. Please don't mix old and new batteries. 11. Battery should be put in the battery box in the correct position. 12. Please don t mix alkaline, standard(carbon-zinc) and re-chargeable batteries. 13.Please don't operate this car outside in inclimate weather. 14.Please turn off the power switch when the car is not in use or being charged. 15.Please clean this car with dry cloths, not water. 16.The electric cable, plug and other parts of charger should be checked frequently. If anything is damaged please repair it before using. 17.The charger is not a toy; please don't let children play with it. 18.The battery should be charged by an adult. 19.Please don't change the forward and backward switch while moving. The forward and backward should be changed when stopped. Otherwise the gear-box and motor will be damaged. 20.Please put the car in a well ventilated place when the car is charging. 21.Short circuiting the battery creates a fire hazard! 22.Dispose of plastic bags to avoid choking hazard. -7-