an ISO 900: 2008 Registered Company 955-59 Chevy Pickup Standard Control Panel Conversion Kit 473258 8865 Goll St. San Antonio, TX 78266 ph: 20-654-77 fax: 20-654-33 909 REV B 9/9/4, INST 55-59 CHEVY PICKUP STANDARD CNTRL PNL PG OF 0
. Cover 2. Table of Contents 3. Packing List/Parts Disclaimer 4. Removing OEM Control Panel 5. Rotary POT Installation 6. Control Panel Installation 7. Final Steps 8. Wiring Diagram 9. Operation of Controls 0. Control Panel Kit Packing List Table of Contents 909 REV B 9/9/4, INST 55-59 CHEVY PICKUP STANDARD CNTRL PNL PG 2 OF 0 2
No. Qty. Part No. Description. 2. 3. 4. 5. 6. 7. 8. 9. 0.. 2. 3. 3 3 5 624990 24608-0 497004 232002-VUA 230-VUP 643085 643086 205550 20555 205552 8258-VUB 825-VUB 8232-VUB Packing List: 955-59 Chevy Pickup Control Kit (473258) 55-59 Chevy Pickup Control Panel Rotary Pot ASM Knob Soft Black Metric Gen IV Universal Control Harness 4 Tie Wrap Brkt 55-59 Chevy Pickup Control Panel Top Brkt 55-59 Chevy Pickup Control Panel Bottom Label Gen IV Rotary Fan Label Gen IV Rotary Mode Label Gen IV Rotary Temp 0-32 X 3/4 PH Pan Head Screw 0-32 Nut w/ Star Washer #6 X /2 PH Pan Head Screw ** Before beginning installation, open all packages and check contents of shipment. Please report any shortages directly to Vintage Air within 5 days. After 5 days, Vintage Air will not be responsible for missing or damaged items. 4 2 3 6 5 7 8 9 3 0 2 3 909 REV B 9/9/4, INST 55-59 CHEVY PICKUP STANDARD CNTRL PNL PG 3 OF 0
. Disconnect cables and wires from control panel (discard). 2. Remove control panel from dash by removing (4) OEM screws (discard). Removing OEM Control Panel OFF FAN HI INSIDE AIR OUTSIDE AIR T E M P D EF R (4) OEM Screws 909 REV B 9/9/4, INST 55-59 CHEVY PICKUP STANDARD CNTRL PNL PG 4 OF 0 4
. 2. Rotary POT Installation Install the (3) rotary POT assemblies, (3) labels, and the control panel top bracket onto the control panel as shown below. Tie wrap the wires to the rotary POTS as shown below. NOTE: Tie the unused wire to the wiring harness as shown below. Rotary POT ASM 24608-0 Orientation of Wiring WHT WHT/GRN RED WHT WHT/YEL RED Control Panel Top Bracket 643085 Control Panel 624990 WHT WHT/RED RED Label: Gen IV Rotary Fan 205550 Label: Gen IV Rotary Mode 20555 Tie Wrap Unused RED, WHT/BLUE, WHT Wire Tie Wrap Label: Gen IV Rotary Temp 205552 (3) Soft Black Metric Knob 497004 5 909 REV B 9/9/4, INST 55-59 CHEVY PICKUP STANDARD CNTRL PNL PG 5 OF 0
. Control Panel Installation Install the bottom control panel bracket into the dash using a 0-32 X 3/4 PH pan head screw and 0-32 nut w/ star washer as shown below. 2. Install the control panel into the dash using a #6 x /2 PH pan head screw as shown below. 0-32 Nut w/ Star Washer 825-VUB Bottom Control Panel Brkt 643086 0-32 X 3/4 PH Pan Head Screw 8258-VUB #6 X /2 PH Pan Head Screw 8232-VUB 909 REV B 9/9/4, INST 55-59 CHEVY PICKUP STANDARD CNTRL PNL PG 6 OF 0 6
. Plug the wiring harness into the ECU module on the sub case (see below). 2. Wire according to the wiring diagram on Page 8. Final Steps Plug From Control Wiring Harness 232002-VUA Plug From Wiring Harness 23200-VUR 7 909 REV B 9/9/4, INST 55-59 CHEVY PICKUP STANDARD CNTRL PNL PG 7 OF 0
232007-VUR JF8 TAN ORA BLK WHT RED WHT/RED WHT/YEL WHT/GRN AC ANNUNCIATOR BACKLIGHT POS BACKLIGHT NEG GND 5V-SW TEMP WIPER MODE WIPER FAN WIPER Wiring Diagram VIEWED FROM WIRE SIDE PRE-WIRED 232002-VUA A/C (IF USED) GEN IV ECU GEN IV WIRING DIAGRAM REV D, 5/6/204 TEMP MODE FAN *** WIDE OPEN THROTTLE SWITCH (OPTIONAL) PROGRAM * DASH LAMP (IF USED) ** CIRCUIT BREAKER 30 AMP HEATER CONTROL VALVE Dash Lamp Is Used Only With Type 232007-VUR Harness. Warning: Always Mount Circuit Breaker As Close to the Battery As Possible. (NOTE: Wire Between Battery and Circuit Breaker Is Unprotected and Should Be Carefully Routed to Avoid a Short Circuit). Wide Open Throttle Switch Contacts Close Only at Full Throttle, Which Disables A/C Compressor. 909 REV B 9/9/4, INST 55-59 CHEVY PICKUP STANDARD CNTRL PNL PG 8 OF 0 8
Operation of Controls The temperature knob toggles between A/C and Heat Modes. For A/C Mode, rotate the temperature knob all the way right to engage the compressor, and then move the knob to select the desired temperature. For heat mode, rotate the knob left to disengage the compressor, and then move the knob to select the desired temperature. NOTE: Each time the system toggles between modes, the blower will momentarily change speeds. All switches are variable between positions, and the system will perform a blend between the functions. A/C Mode Blower Speed Mode Knob Temperature Knob Blower Speed Rotate knob right to desired blower speed, from OFF to HI. Mode Knob Rotate the knob to the left to direct air flow to the dash vents. Temperature Knob In A/C Mode, rotate the temperature knob all the way right to the COLD position to engage compressor (Rotate knob left or right to adjust to desired temperature). Heat Mode Defrost/De-Fog Mode Blower Speed Rotate knob right to desired blower speed, from OFF to HI. Mode Knob Rotate the knob to the center to direct air flow to the floor vents. Temperature Knob In Heat Mode, rotate the temperature knob all the way left to the HOT position (rotate knob left or right to adjust to desired temperature). Blower Speed Rotate knob right to desired blower speed, from OFF to HI. Mode Knob Rotate the knob to the right to direct air flow to the defrost vents. Temperature Knob Rotate knob left or right to adjust to desired temperature (Compressor is automatically engaged). 9 909 REV B 9/9/4, INST 55-59 CHEVY PICKUP STANDARD CNTRL PNL PG 9 OF 0
No. Qty. Part No. Description. 2. 3. 4. 5. 6. 7. 8. 9. 0.. 2. 3. 3 3 5 624990 24608-0 497004 232002-VUA 230-VUP 643085 643086 205550 20555 205552 8258-VUB 825-VUB 8232-VUB Packing List: 955-59 Chevy Pickup Control Kit (473258) 55-59 Chevy Pickup Control Panel Rotary Pot ASM Knob Soft Black Metric Gen IV Universal Control Harness 4 Tie Wrap Brkt 55-59 Chevy Pickup Control Panel Top Brkt 55-59 Chevy Pickup Control Panel Bottom Label Gen IV Rotary Fan Label Gen IV Rotary Mode Label Gen IV Rotary Temp 0-32 X 3/4 PH Pan Head Screw 0-32 Nut w/ Star Washer #6 X /2 PH Pan Head Screw Checked By: Packed By: Date: ** Before beginning installation, open all packages and check contents of shipment. Please report any shortages directly to Vintage Air within 5 days. After 5 days, Vintage Air will not be responsible for missing or damaged items. 2 3 4 6 5 7 8 9 0 2 3 909 REV B 9/9/4, INST 55-59 CHEVY PICKUP STANDARD CNTRL PNL PG 0 OF 0