2582959_C_EN_608 Nortec EL SPARE PARTS LIST Proprietary Notice This document and the information disclosed herein are proprietary data of Nortec Humidity Ltd. Neither this document nor the information contained herein shall be reproduced, used, or disclosed to others without the written authorization of Nortec Humidity Ltd., except to the extent required for installation or maintenance of recipient s equipment. Liability Notice Nortec does not accept any liability for installations of humidity equipment installed by unqualified personnel or the use of parts/ components/equipment that are not authorized or approved by Nortec. Contents Plumbing Parts Nortec EL 005-030 2 Plumbing Parts Nortec EL 050-200 4 Electrical Parts Nortec EL 005-030 6 Electrical Parts Nortec EL 050-200 8 Blower Pack Parts 0 Copyright Notice Copyright 205, Nortec Humidity Ltd. All rights reserved. The contents of this document are subject to change without notice. IMPORTANT! This document to be left with the equipment.
Plumbing Parts Nortec EL 005-030 5 4 8 3 2 0 6 9 7 2 3 Figure : Plumbing Parts Nortec EL 005-030 2 SPARE PARTS LIST 2582959_C_EN_608 Nortec EL
Table : Plumbing Parts List Nortec EL 005-030 Item No. Item Description EL 050 EL 00 EL 020 (~) EL 020 (3~) EL 030 Nortec Part Number 0-20V / ~ 208V / ~ 220-240V / ~ 277V / ~ 380V / ~ 440-480V / ~ 550-600V / ~ 208V / ~ 220-240V / ~ 277V / ~ 380V / ~ 440-480V / ~ 550-600V / ~ Cylinder 202 59002 Cylinder 203 59003 Cylinder 204 59004 Cylinder 32 59020 Cylinder 305 59025 Cylinder 309 59029 Cylinder 3 5903 Cylinder 303 59023 Cylinder 42 59040 Cylinder 407 59047 Cylinder 4 5905 2 Drain Channel 257354 3 Valve, Drain +24V Coil 456000 4 Fill Cup Assembly, Small 257443 5 Steam Line, 7/8 in (22 mm) ID 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 25743 6 Valve, Single Fill 0.3 gal/min (0.5 l/min) 257355 Valve, Single Fill 0.32 gal/min (.2 l/min) 2573522 6* Valve, Dual Fill 0.87 gal/min (3.3 l/min), 0.3 gal/min (0.5 l/min) Valve, Dual Fill 0.87 gal/min (3.3 l/min), 0.32 gal/min (.2 l/min) 7 Fitting, Brass 3/4 in BSPP to /2 in NPT (with washer) 257433 257434 257437 8 Strap, Cylinder 00/200 2553033 Strap, Cylinder 300 2553034 Strap, Cylinder 400 2553035 9 Plug Kit, Cylinder, Qty 2 2577737 Super Plug Kit, R-B, NH-EL 257440 Plug Kit, Cylinder, Qty 3 2573529 0 Plug, High Water Sensor 2577738 Optional Components Outlet, Steam 7/8 in (22 mm) 2584088 2 Hose, Steam Outlet, 200 2584089 Hose, Steam Outlet, 300 2584096 Hose, Steam Outlet, 400 2584090 3 Steam Outlet Kit, 200 258409 Steam Outlet Kit, 300 2584097 Steam Outlet Kit, 400 2584092 N/S Foam Detection Kit, Small 257409 Foam Detection Kit with Built-on Blower Pack 2574093 Fill Cup Extension Kit 258239 Extreme Cooling Kit 0.87 gal/min (3.3 l/min), 0.3 gal/min (0.5 l/min) Extreme Cooling Kit 0.87 gal/min (3.3 l/min), 0.32 gal/min (.2 l/min) 2574079 257408 * Optional component N/S Not shown Nortec EL 2582959_C_EN_608 SPARE PARTS LIST 3
Plumbing Parts Nortec EL 050-200 5 4 8 3 2 0 6 9 7 2 3 Figure 2: Plumbing Parts Nortec EL 050-200 4 SPARE PARTS LIST 2582959_C_EN_608 Nortec EL
Table 2: Plumbing Parts List Nortec EL 050-200 Item No. Item Description EL 050 EL 075 EL 00 EL 50 EL 200 Nortec Part Number Cylinder 62 2 2 2 2 59080 Cylinder 605 2 2 2 2 59085 Cylinder 603 2 2 59083 2 Drain Channel 2 2 2 2 2 2 2 2 2 2 257354 3 Valve, Drain +24V Coil 2 2 2 2 2 2 2 2 2 2 456000 4 Fill Cup Assembly, Large 2 2 2 2 2 2 2 2 2 2 257442 5 Steam Line, -3/4 in (45 mm) ID 2 2 2 2 2 2 2 2 2 2 2 2 2 2 2 24 24 24 24 24 24 24 24 24 24 257432 6 Valve, Single Fill 0.53 gal/min (2.0 l/min) 2 2 2 2 2 2573523 Valve, Single Fill 0.87 gal/min (3.3 l/min) 2 2 2 2 2 2573524 6* Valve, Dual Fill 0.87 gal/min (3.3 l/min), 0.53 gal/min (2.0 l/min) Valve, Dual Fill 0.87 gal/min (3.3 l/min), 0.87 gal/min (3.3 l/min) 7 Fitting, Brass 3/4 in BSPP to /2 in NPT (with washer) 2 2 2 2 2 257435 2 2 2 2 2 257436 2 2 2 2 2 2 2 2 2 2 257437 8 Strap, Cylinder 600 2 2 2 2 2 2 2 2 2 2 2578692 9 Plug Kit, Cylinder, Qty 3 2 2 2 2 2 2 2 2 2 4 4 4 4 2573529 Super Plug Kit, R-Y-B, NH-EL 2 2 2 2 2 2 4 4 4 4 4 4 25744 0 Plug, High Water Sensor 2 2 2 2 2 2 2 2 2 2 2577738 Optional Components Outlet, Steam -3/4 in (45 mm) 2 2 2 2 2 2 2 2 2 2 2584093 2 Hose, Steam Outlet, 600 2 2 2 2 2 2 2 2 2 2 2584094 3 Steam Outlet Kit, 600 2 2 2 2 2 2 2 2 2 2 2584095 N/S Foam Detection Kit, Medium 2574095 Foam Detection Kit, Large 2574099 Fill Cup Extension Kit 2 2 2 2 2 2 2 2 2 2 258239 Extreme Cooling Kit 0.87 gal/min (3.3 l/ min), 0.53 gal/min (2.0 l/min) Extreme Cooling Kit 0.87 gal/min (3.3 l/ min), 0.87 gal/min (3.3 l/min) 2 2 2 2 2 2574083 2 2 2 2 2 2574085 * Optional component N/S Not shown Nortec EL 2582959_C_EN_608 SPARE PARTS LIST 5
Electrical Parts Nortec EL 005-030 5 7 6 4 8 9 3 2 Figure 3: Electrical Parts Nortec EL 005-030 6 SPARE PARTS LIST 2582959_C_EN_608 Nortec EL
Table 3: Electrical Parts List Nortec EL 005-030 Item No. Item Description EL 050 EL 00 EL 020 (~) EL 020 (3~) EL 030 Nortec Part Number 0-20V / ~ 208V / ~ 220-240V / ~ 277V / ~ 380V / ~ 440-480V / ~ 550-600V / ~ 208V / ~ 220-240V / ~ 277V / ~ 380V / ~ 440-480V / ~ 550-600V / ~ Contactor, 30 Amp, -Phase 257448 Contactor, 30 Amp, 3-Phase 257449 Contactor, 40 Amp, 3-Phase 257450 Contactor, 50 Amp, 3-Phase 25745 2 Terminal Block, 2-Pole, 95 Amp 257453 Terminal Block, 3-Pole, 95 Amp 257454 3 Ground Clamp, Small 257458 4 Transformer, 20/24 VAC, 75 VA 257459 Transformer, 208/24 VAC, 75 VA 257460 Transformer, 240/24 VAC, 75 VA 25746 Transformer, 277/24 VAC, 75 VA 257462 Transformer, 380/24 VAC, 75 VA 257463 Transformer, 480/24 VAC, 75 VA 257464 Transformer, 600/24 VAC, 75 VA 257465 5 PCB, Fault Remote (optional) 25747 6 IC Assembly, EL (+ SIM) 2584072 IC Assembly, EL 2584073 7 Driver Board, EL 2584074 8 Power Switch, Blue 2576748 N/S Fuse, 4 Amp 2559753 Fuse, Amp 453004 Cable, EL Driver Board 2584098 Cable Ribbon, 0-Pin Fault 257474 Space Model Only N/S Transformer, 208, 240 V to 20 V, 50 VA 257460 Transformer, 277, 380 V to 20 V, 50 VA 25746 Transformer, 480, 600 V to 20 V, 50 VA 257462 Optional Components 9 Primary Fuse, JJN50 (JLLN50) 2 509692 Primary Fuse, JJN40 (JLLN40) 2 2 2 2 2 2 3 3 3 3 42373 Primary Fuse, JJS40 (JLLS40) 2 2 2 2 2 2 3 3 3 3 3 3 42360 * Optional component N/S Not shown Nortec EL 2582959_C_EN_608 SPARE PARTS LIST 7
Electrical Parts Nortec EL 050-200 5 7 6 4 8 9 3 2 Figure 4: Electrical Parts Nortec EL 050-200 8 SPARE PARTS LIST 2582959_C_EN_608 Nortec EL
Table 4: Electrical Parts List Nortec EL 050-200 Item No. Item Description EL 050 EL 075 EL 00 EL 50 EL 200 Nortec Part Number Contactor, 30 Amp, 3-Phase 2 2 2 2 257449 Contactor, 40 Amp, 3-Phase 2 257450 Contactor, 50 Amp, 3-Phase 2 2 4 4 2 2 2 25745 Contactor, 62 Amp, 3-Phase 2 2 4 4 2 2 257452 2 Terminal Block, 3-Pole, 95 Amp 257454 Terminal Block, 3-Pole, 50 Amp 257455 Terminal Block, 3-Pole, 30 Amp 257456 3 Ground Clamp, Small 257458 Ground Clamp, Large 2574370 4 Transformer, 208/24 VAC, 75 VA 257460 Transformer, 240/24 VAC, 75 VA 25746 Transformer, 380/24 VAC, 75 VA 257463 Transformer, 480/24 VAC, 75 VA 257464 Transformer, 600/24 VAC, 75 VA 257465 Transformer, 208/24 VAC, 50 VA 257466 Transformer, 240/24 VAC, 50 VA 257467 Transformer, 380/24 VAC, 50 VA 257470 Transformer, 480/24 VAC, 50 VA 257468 Transformer, 600/24 VAC, 50 VA 257469 5 PCB, Fault Remote (optional) 25747 6 IC Assembly, EL (+ SIM) 2584072 IC Assembly, EL 2584073 7 Driver Board, EL 2 2 2 2 2 2 2 2 2 2 2584074 8 Power Switch, Blue 2576748 N/S Fuse, 4 Amp 2 2 2 2 2 2 2 2 2 2 2559753 Fuse, Amp 2 2 2 2 2 2 2 2 2 2 453004 Cable, EL Driver Board 2584098 Cable, EL Driver Board, Large 2584099 Cable Ribbon, 0-Pin Fault 257474 Space Models Only N/S Transformer, 208, 240 V to 20 V, 50 VA 257460 Transformer, 277, 380 V to 20 V, 50 VA 25746 Transformer, 480, 600 V to 20 V, 50 VA 257462 Optional Components 9 Primary Fuse, JJN60 (JLLN60) 6 6 2 2 42376 Primary Fuse, JJN50 (JLLN50) 6 6 2 2 509692 Primary Fuse, JJN40 (JLLN40) 6 6 42373 Primary Fuse, JJS40 (JLLS40) 6 3 3 6 3 2 6 42360 Primary Fuse, JJS50 (JLLS50) 3 3 6 6 509693 Primary Fuse, JJS60 (JLLS60) 3 3 6 6 509694 * Optional component N/S Not shown Nortec EL 2582959_C_EN_608 SPARE PARTS LIST 9
Blower Pack Parts 2 3 7 4 5 6 7 8 6 9 5 0 3, 4 2 Figure 5: Blower Pack Parts 0 SPARE PARTS LIST 2582959_C_EN_608 Nortec EL
Table 5: Blower Pack Parts List Item No. Item Description Quantity Nortec Part Number Filter Assembly (includes filter element), optional 2579375 2 Filter Element (only), optional 5 2579670 3 Cover Assembly 2579532 4 Fan Assembly, 5V 257953 5 Safety Relay Assembly, 5V 2579528 6 Capacitor Assembly, 8μF 2579529 7 Capacitor Assembly, 20μF 2579530 8 Safety Connector Kit (includes hardware and spare fasteners) 257939 9 Power Connector Assembly (includes receptacle) 2579390 0 Fuse Assembly 2579392 Speed Switch 258228 2 Spacer Assembly, optional 2579533 3 Steam Adaptor Kit, -3/4 in (45 mm) (includes O-ring) 258248 4 Steam Adaptor Kit, 7/8 in (22 mm) (includes O-ring) 258247 5 O-ring, Steam Inlet 3 257968 6 Distributor Assembly (includes O-ring) 2579384 7 Thermostat Assembly 2579527 Nortec EL 2582959_C_EN_608 SPARE PARTS LIST
Warranty Nortec Humidity Inc. and/or Nortec Humidity Ltd. (hereinafter collectively referred to as THE COMPANY), warrant for a period of two years after installation or 30 months from manufacturer s ship date, whichever date is earlier, that THE COMPANY s manufactured and assembled products, not otherwise expressly warranted (with the exception of the cylinder), are free from defects in material and workmanship. No warranty is made against corrosion, deterioration, or suitability of substituted materials used as a result of compliance with government regulations. THE COMPANY s obligations and liabilities under this warranty are limited to furnishing replacement parts to the customer, F.O.B. THE COMPANY s factory, provided that the defective part(s) is returned freight prepaid by the customer. The replacement parts are warranted for the balance of the term of the warranty on the original humidifier or 90 days, whichever is longer. The warranties set forth herein are in lieu of all other warranties expressed or implied by law. No liability whatsoever shall be attached to THE COMPANY until said products have been paid for in full and then said liability shall be limited to the original purchase price for the product. Any further warranty must be in writing, signed by an officer of THE COMPANY. THE COMPANY s limited warranty on accessories, not manufactured by the COMPANY, such as controls, humidistats, pumps, etc., is limited to the warranty of the original equipment manufacturer from date of original shipment of humidifier. THE COMPANY makes no warranty and assumes no liability unless the equipment is installed in strict accordance with a copy of the catalog and installation manual in effect at the date of purchase, and by a contractor approved by THE COMPANY to install such equipment. THE COMPANY makes no warranty and assumes no liability whatsoever for consequential damage or damage resulting directly from misapplication, incorrect sizing or lack of proper maintenance of the equipment. THE COMPANY makes no warranty and assumes no liability whatsoever for damage to the humidifier, supply lines, drain lines, or steam distribution systems caused by freezing. THE COMPANY reserves the right to change the design, specifications and performance criteria of its products without notice or obligation. CONSULTING, SALES AND SERVICE: U.S.A. 826 Proctor Avenue Ogdensburg, NY 3669 CANADA 2740 Fenton Road Ottawa, ON, KT 3T7 Tel:.866.NORTEC Fax: 63.822.7964 Email: nortec@humidity.com Website: www.humidity.com