GD5-2 2V5AH Applications Electric tools Vehicle in place of walking Lawn mowers Golf trolleys and golf cart Portable apparatus, lights and instruments; Electric toys Illumination light Fire alarms Portable power Wheelchairs Solar energy systems Marine RV Medical equipments. 91 141 OHSAS 181 Specification Nomial Voltage Nomial Capacity(1HR) Dimension Approx Weight Terminal Container Material Max. Discharge Current Internal Resistance Operating Temp.Range Nominal Operating Temp. Range Float charging Voltage Recommended Maximum Charging Current Limit Equalization and Cycle Service Capacity affected by Temperature Self Discharge 2V 5.AH @1hr-rate to 1.8V per cell @25 Length Width Container Height Total Height (with Terminal) Approx 26.7 Kg (58.86 Ibs) T11 ABS 25A (5s) Approx.62mΩ Discharge : -2 6 (-4 14 ) Charge : 5 (32 122 ) Storage : -2 6 (-4 14 ) 25 5 (77 41 ) 2.27 to 2.3 VDC/unit Average at 25 1 A 2.43 to 2.47 VDC/unit Average at 25 4 (14 ) 25 ( 77 ) ( 32 ) 24 2mm (9.45 inches) 175 2mm (6.89 inches) 33 2mm (12.99 inches) 35 2mm (13.78 inches) 13% 1% 86% JYC GD series batterys may be stored for up to 6 months at 25 (77 ) and then a freshening charge is required. For higher temperatures the time interval will be shorter. Constant Current Discharge Characteristics: A (25 ) 1.6V 1.7V 1.8V 15MIN 3MIN 1HR 2HR 3HR 4HR 5HR 6HR 8HR 1HR 678.9 5.7 312.2 191.5 142.6 12.3 89.58 8.43 64.92 52.8 645.5 48.7 38.2 184.5 136.7 98.8 88.68 78.49 62.2 51.58 61.9 453.2 32.2 181.5 133.7 97.9 87.41 76.55 61.5 51.9 534.4 47.8 278.3 171.6 126.7 92.5 86.28 72.68 59.11 5.54 46. 371.5 262.3 163.6 121.7 91.6 84.79 71.71 58.14 5.7 389. 334.4 242.4 154.6 115.7 84.39 79.8 67.83 55.23 47.1 Constant Power Discharge Characteristics: W(25 ) 1.6V 1.7V 1.8V 15MIN 3MIN 1HR 2HR 3HR 4HR 5HR 6HR 8HR 1HR 1188 912.4 58.9 358.3 265.8 192.3 178.1 155.2 123.5 13.8 1157 97.5 577.9 353.2 26.6 189.5 176.4 153.2 122.5 12.8 193 858.9 572.2 348. 256.6 188.7 174.3 149.6 12.6 12.2 973.8 774. 536.7 329.4 247.4 179.3 171.9 142.3 116.8 11.1 842.9 76.2 51.4 314.6 237.2 178.4 168.9 14.6 114.9 1.3 718.8 636.7 473.4 297.8 226. 165.3 159.4 133.2 19.2 94.5 Note The above data are average values, and can be obtained with 3 charge/discharge cycles. These are not minimum values. Page 1 of 2
GD5-2 2V5AH Dimensions 7 [.276] T11 Terminal Unit: mm [inches] 2 [.787] M8 [.315] 175 2 Life characteristics of cyclic use Storage characteristic Capacity(%) 12 1 8 6 4 2 1% 5% 3% Capacity (%) 1 8 6 4 2 4 3 2 1 (Carry out supplementary charge before use if 1% capacity is requires) before use. This supplementary charge will help to recover the capacity and should be made as early as possible. Supplementary charge may often fail to recover the capacity. The battery should never be left standing till this state is reached 3 6 9 12 15 18 Number of Cycle(Times) 21 2 4 6 8 1 12 14 16 18 2 22 24 Storage Time (months) Supplementary charge and storage guidelines Charge characteristic Curve for standby use Discharge characteristic Curve 2.5 Charge Volume 12.24 2.1 2.33 Charge Voltage 1.2 2. Charge Voltage( V ) 2.17 2. 1.83 1.67 1.5 1 Discharge 1%(.5CA 2h) 5%(.5CA 1h) 2 Charge Charge Voltage2.275V/C Charge Current.1CA 3 Temperature 25 Charge Current 2 4 6 8 1 12 14 16 18 Charge Time(h) 2 24 28 8 6 4 2 C harge V olum e (% ).16.12.8.4 Charge Current (CA) Term inal Voltage (V ) 1.9 1.8 1.7 1.6.6 1.2 3 6 12 3 1 2 5 min 2C 1C.6C Discharge Time.35C.16C Hr.5C.94C 1 2 24 JYC GD BATTERIES 2 This information is generally descriptive only and is not intended to make or imply any representation, guarantee or warranty with respect to any cells and batteries. Cell and battery designs/ specification are subject to modification without notice. Contact JYC for the latest information. Page 2 of 2
GD6-2 2V6AH Applications Electric tools Vehicle in place of walking Lawn mowers Golf trolleys and golf cart Portable apparatus, lights and instruments; Electric toys Illumination light Fire alarms Portable power Wheelchairs Solar energy systems Marine RV Medical equipments. 91 141 OHSAS 181 Specification Nomial Voltage Nomial Capacity(1HR) Dimension Approx Weight Terminal Container Material Max. Discharge Current Internal Resistance Operating Temp.Range Nominal Operating Temp. Range Float charging Voltage Recommended Maximum Charging Current Limit Equalization and Cycle Service Capacity affected by Temperature Self Discharge 2V 6.AH @1hr-rate to 1.8V per cell @25 Length Width Container Height Total Height (with Terminal) Approx 33. kg ( 72.753 lbs) T11 ABS 3A (5s) Approx.62mΩ Discharge : -2 6 (-4 14 ) Charge : 5 (32 122 ) Storage : -2 6 (-4 14 ) 25 5 (77 41 ) 2.27 to 2.3 VDC/unit Average at 25 12 A 2.43 to 2.47 VDC/unit Average at 25 4 (14 ) 25 ( 77 ) ( 32 ) 3 2mm (11.81 inches) 175 2mm ( 6.89 inches) 33 2mm (12.99 inches) 35 2mm (13.78 inches) 13% 1% 86% JYC GD series batterys may be stored for up to 6 months at 25 (77 ) and then a freshening charge is required. For higher temperatures the time interval will be shorter. Constant Current Discharge Characteristics: A (25 ) 1.6V 1.7V 1.8V 15MIN 3MIN 1HR 2HR 3HR 4HR 5HR 6HR 8HR 1HR 814.6 6.8 374.6 229.8 171.2 122.8 17.5 96.51 77.91 62.49 774.6 576.8 369.9 221.4 164. 118.5 16.4 94.19 74.42 61.9 722.3 543.8 362.7 217.9 16.4 117.4 14.9 91.86 73.26 61.3 641.3 489.4 334. 25.9 152. 111. 13.5 87.21 7.93 6.65 552. 445.7 314.8 196.3 146. 19.9 11.7 86.5 69.77 6.8 466.8 41.3 29.9 185.5 138.9 11.3 95.76 81.4 66.28 56.41 Constant Power Discharge Characteristics: W(25 ) 1.6V 1.7V 1.8V 15MIN 3MIN 1HR 2HR 3HR 4HR 5HR 6HR 8HR 1HR 1426 195 697.1 43. 319. 23.8 213.7 186.2 148.3 124.5 1389 189 693.5 423.8 312.7 227.4 211.7 183.8 147. 123.3 1312 131 686.6 417.6 38. 226.5 29.2 179.6 144.7 122.6 1169 928.8 644. 395.3 296.9 215.1 26.3 17.7 14.2 121.4 111 847.4 612.4 377.5 284.6 214.1 22.7 168.7 137.9 12.4 862.6 764. 568.1 357.4 271.2 198.3 191.2 159.8 131.1 113.4 Note The above data are average values, and can be obtained with 3 charge/discharge cycles. These are not minimum values. Page 1 of 2
GD6-2 2V6AH Dimensions 7 [.276] T11 Terminal Unit: mm [inches] 2 [.787] M8 [.315] Life characteristics of cyclic use Storage characteristic Capacity(%) 12 1 8 6 4 2 1% 5% 3% Capacity (%) 1 8 6 4 2 4 3 2 1 (Carry out supplementary charge before use if 1% capacity is requires) before use. This supplementary charge will help to recover the capacity and should be made as early as possible. Supplementary charge may often fail to recover the capacity. The battery should never be left standing till this state is reached 3 6 9 12 15 18 Number of Cycle(Times) 21 2 4 6 8 1 12 14 16 18 2 22 24 Storage Time (months) Supplementary charge and storage guidelines Charge characteristic Curve for standby use Discharge characteristic Curve 2.5 Charge Volume 12.24 2.1 2.33 Charge Voltage 1.2 2. Charge Voltage( V ) 2.17 2. 1.83 1.67 1.5 1 Discharge 1%(.5CA 2h) 5%(.5CA 1h) 2 Charge Charge Voltage2.275V/C Charge Current.1CA 3 Temperature 25 Charge Current 2 4 6 8 1 12 14 16 18 Charge Time(h) 2 24 28 8 6 4 2 C harge V olum e (% ).16.12.8.4 Charge Current (CA) Term inal Voltage (V ) 1.9 1.8 1.7 1.6.6 1.2 3 6 12 3 1 2 5 min 2C 1C.6C Discharge Time.35C.16C Hr.5C.94C 1 2 24 JYC GD BATTERIES 2 This information is generally descriptive only and is not intended to make or imply any representation, guarantee or warranty with respect to any cells and batteries. Cell and battery designs/ specification are subject to modification without notice. Contact JYC for the latest information. Page 2 of 2
GD8-2 2V8AH Applications Electric tools Vehicle in place of walking Lawn mowers Golf trolleys and golf cart Portable apparatus, lights and instruments; Electric toys Illumination light Fire alarms Portable power Wheelchairs Solar energy systems Marine RV Medical equipments. 91 141 OHSAS 181 Specification Nomial Voltage Nomial Capacity(1HR) Dimension Approx Weight Terminal Container Material Max. Discharge Current Internal Resistance Operating Temp.Range Nominal Operating Temp. Range Float charging Voltage Recommended Maximum Charging Current Limit Equalization and Cycle Service Capacity affected by Temperature Self Discharge 2V 8.AH @1hr-rate to 1.8V per cell @25 Length Width Container Height Total Height (with Terminal) Approx 45.1 kg ( 99.428 lbs) T11 ABS 32A (5s) Approx.6mΩ Discharge : -2 6 (-4 14 ) Charge : 5 (32 122 ) Storage : -2 6 (-4 14 ) 25 5 (77 41 ) 2.27 to 2.3 VDC/unit Average at 25 16 A 2.43 to 2.47 VDC/unit Average at 25 4 (14 ) 25 ( 77 ) ( 32 ) 41 3mm (16.14 inches) 175 3mm (6.89 inches) 33 3mm (12.99 inches) 351 3mm (13.82 inches) 13% 1% 86% JYC GD series batterys may be stored for up to 6 months at 25 (77 ) and then a freshening charge is required. For higher temperatures the time interval will be shorter. Constant Current Discharge Characteristics: A (25 ) 1.6V 1.7V 1.8V 15MIN 3MIN 1HR 2HR 3HR 4HR 5HR 6HR 8HR 1HR 186 81. 499.5 36.4 228.2 163.7 143.3 128.7 13.9 83.32 133 769.1 493.2 295.3 218.7 158. 141.9 125.6 99.23 82.53 963.1 725. 483.6 29.5 213.9 156.6 139.9 122.5 97.68 81.74 855. 652.5 445.3 274.5 22.7 147.9 138.1 116.3 94.57 8.86 736. 594.3 419.7 261.7 194.7 146.5 135.7 114.7 93.2 8.11 622.4 535. 387.8 247.4 185.1 135. 127.7 18.5 88.37 75.22 Constant Power Discharge Characteristics: W(25 ) 1.6V 1.7V 1.8V 15MIN 3MIN 1HR 2HR 3HR 4HR 5HR 6HR 8HR 1HR 192 146 929.5 573.3 425.3 37.7 285. 248.3 197.7 166. 1852 1452 924.6 565.1 417. 33.1 282.3 245.1 196. 164.4 1749 1374 915.5 556.8 41.6 32. 279. 239.4 193. 163.5 1558 1238 858.7 527.1 395.9 286.8 275. 227.6 186.9 161.8 1349 113 816.6 53.4 379.5 285.5 27.2 224.9 183.9 16.5 115 119 757.5 476.5 361.5 264.4 255. 213.1 174.7 151.2 Note The above data are average values, and can be obtained with 3 charge/discharge cycles. These are not minimum values. Page 1 of 2
GD8-2 2V8AH Dimensions T11 Terminal Unit: mm [inches] 41 3 7 [.276] 2 [.787] M8 [.315] 41 3 119 3 175 3 351 3 33 3 Life characteristics of cyclic use Storage characteristic Capacity(%) 12 1 8 6 4 2 1% 5% 3% Capacity (%) 1 8 6 4 2 4 3 2 1 (Carry out supplementary charge before use if 1% capacity is requires) before use. This supplementary charge will help to recover the capacity and should be made as early as possible. Supplementary charge may often fail to recover the capacity. The battery should never be left standing till this state is reached 3 6 9 12 15 18 Number of Cycle(Times) 21 2 4 6 8 1 12 14 16 18 2 22 24 Storage Time (months) Supplementary charge and storage guidelines Charge characteristic Curve for standby use Discharge characteristic Curve 2.5 Charge Volume 12.24 2.1 2.33 Charge Voltage 1.2 2. Charge Voltage( V ) 2.17 2. 1.83 1.67 1.5 1 Discharge 1%(.5CA 2h) 5%(.5CA 1h) 2 Charge Charge Voltage2.275V/C Charge Current.1CA 3 Temperature 25 Charge Current 2 4 6 8 1 12 14 16 18 Charge Time(h) 2 24 28 8 6 4 2 C harge V olum e (% ).16.12.8.4 Charge Current (CA) Term inal Voltage (V ) 1.9 1.8 1.7 1.6.6 1.2 3 6 12 3 1 2 5 min 2C 1C.6C Discharge Time.35C.16C Hr.5C.94C 1 2 24 JYC GD BATTERIES 2 This information is generally descriptive only and is not intended to make or imply any representation, guarantee or warranty with respect to any cells and batteries. Cell and battery designs/ specification are subject to modification without notice. Contact JYC for the latest information. Page 2 of 2
GD1-2 2V1AH Applications Electric tools Vehicle in place of walking Lawn mowers Golf trolleys and golf cart Portable apparatus, lights and instruments; Electric toys Illumination light Fire alarms Portable power Wheelchairs Solar energy systems Marine RV Medical equipments. 91 141 OHSAS 181 Specification Nomial Voltage Nomial Capacity(1HR) Dimension Approx Weight Terminal Container Material Max. Discharge Current Internal Resistance Operating Temp.Range Nominal Operating Temp. Range Float charging Voltage Recommended Maximum Charging Current Limit Equalization and Cycle Service Capacity affected by Temperature Self Discharge 2V 1.AH @1hr-rate to 1.8V per cell @25 Length Width Container Height Total Height (with Terminal) Approx 52. Kg (114.64 Ibs) T11 ABS 4A (5s) Approx.55mΩ Discharge : -2 6 (-4 14 ) Charge : 5 (32 122 ) Storage : -2 6 (-4 14 ) 25 5 (77 41 ) 2.27 to 2.3 VDC/unit Average at 25 2 A 2.43 to 2.47 VDC/unit Average at 25 4 (14 ) 25 ( 77 ) ( 32 ) 13% 1% 86% 475 3mm (18.7 inches) 175 3mm (6.89 inches) 328 3mm (12.91 inches) 35 3mm (13.78 inches) JYC GD series batterys may be stored for up to 6 months at 25 (77 ) and then a freshening charge is required. For higher temperatures the time interval will be shorter. Constant Current Discharge Characteristics: A (25 ) 1.6V 1.7V 1.8V 15MIN 3MIN 1HR 2HR 3HR 4HR 5HR 6HR 8HR 1HR 1358 11 624.4 383. 285.3 24.7 179.2 16.9 129.8 14.2 1291 961.4 616.5 369.1 273.3 197.5 177.4 157. 124. 13.2 124 96.3 64.5 363.1 267.3 195.7 174.8 153.1 122.1 12.2 169 815.6 556.6 343.1 253.4 184.9 172.6 145.4 118.2 11.1 92. 742.9 524.7 327.2 243.4 183.1 169.6 143.4 116.3 1.1 778.1 668.8 484.8 39.2 231.4 168.8 159.6 135.7 11.5 94.2 Constant Power Discharge Characteristics: W(25 ) 1.6V 1.7V 1.8V 15MIN 3MIN 1HR 2HR 3HR 4HR 5HR 6HR 8HR 1HR 2377 1825 1162 716.7 531.7 384.6 356.2 31.4 247.1 27.5 2315 1815 1156 76.3 521.2 378.9 352.9 36.4 245. 25.6 2187 1718 1144 696. 513.3 377.4 348.7 299.3 241.2 24.3 1948 1548 173 658.8 494.9 358.5 343.8 284.5 233.6 22.3 1686 1412 121 629.2 474.4 356.9 337.8 281.2 229.9 2.6 1438 1273 946.8 595.6 451.9 33.6 318.7 266.4 218.4 189. Note The above data are average values, and can be obtained with 3 charge/discharge cycles. These are not minimum values. Page 1 of 2
GD1-2 2V1AH Dimensions 7 [.276] T11 Terminal Unit: mm [inches] 2 [.787] M8 [.315] 175 3 Life characteristics of cyclic use Storage characteristic Capacity(%) 12 1 8 6 4 2 1% 5% 3% Capacity (%) 1 8 6 4 2 4 3 2 1 (Carry out supplementary charge before use if 1% capacity is requires) before use. This supplementary charge will help to recover the capacity and should be made as early as possible. Supplementary charge may often fail to recover the capacity. The battery should never be left standing till this state is reached 3 6 9 12 15 18 Number of Cycle(Times) 21 2 4 6 8 1 12 14 16 18 2 22 24 Storage Time (months) Supplementary charge and storage guidelines Charge characteristic Curve for standby use Discharge characteristic Curve 2.5 Charge Volume 12.24 2.1 2.33 Charge Voltage 1.2 2. Charge Voltage( V ) 2.17 2. 1.83 1.67 1.5 1 Discharge 1%(.5CA 2h) 5%(.5CA 1h) 2 Charge Charge Voltage2.275V/C Charge Current.1CA 3 Temperature 25 Charge Current 2 4 6 8 1 12 14 16 18 Charge Time(h) 2 24 28 8 6 4 2 C harge V olum e (% ).16.12.8.4 Charge Current (CA) Term inal Voltage (V ) 1.9 1.8 1.7 1.6.6 1.2 3 6 12 3 1 2 5 min 2C 1C.6C Discharge Time.35C.16C Hr.5C.94C 1 2 24 JYC GD BATTERIES 2 This information is generally descriptive only and is not intended to make or imply any representation, guarantee or warranty with respect to any cells and batteries. Cell and battery designs/ specification are subject to modification without notice. Contact JYC for the latest information. Page 2 of 2
GD15-2 2V15AH Applications Electric tools Vehicle in place of walking Lawn mowers Golf trolleys and golf cart Portable apparatus, lights and instruments; Electric toys Illumination light Fire alarms Portable power Wheelchairs Solar energy systems Marine RV Medical equipments. 91 141 OHSAS 181 Specification Nomial Voltage Nomial Capacity(1HR) Dimension Approx Weight Terminal Container Material Max. Discharge Current Internal Resistance Operating Temp.Range Nominal Operating Temp. Range Float charging Voltage Recommended Maximum Charging Current Limit Equalization and Cycle Service Capacity affected by Temperature Self Discharge 2V 15.AH @1hr-rate to 1.8V per cell @25 Length Width Container Height Total Height (with Terminal) Approx 85.5 Kg (188.495 Ibs) T11 ABS 6A (5s) Approx.5mΩ Discharge : -2 6 (-4 14 ) Charge : 5 (32 122 ) Storage : -2 6 (-4 14 ) 25 5 (77 41 ) 2.27 to 2.3 VDC/unit Average at 25 3 A 2.43 to 2.47 VDC/unit Average at 25 4 (14 ) 25 ( 77 ) ( 32 ) 13% 1% 86% 43 3mm (15.87 inches) 354 3mm (13.94 inches) 339 3mm (13.35 inches) 349 3mm (13.74 inches) JYC GD series batterys may be stored for up to 6 months at 25 (77 ) and then a freshening charge is required. For higher temperatures the time interval will be shorter. Constant Current Discharge Characteristics: A (25 ) 1.6V 1.7V 1.8V 15MIN 3MIN 1HR 2HR 3HR 4HR 5HR 6HR 8HR 1HR 237 152 936.6 574.6 427.9 37. 268.7 241.3 194.8 156.2 1937 1442 924.7 553.6 41. 296.3 266. 235.5 186. 154.7 186 1359 96.7 544.6 41. 293.6 262.2 229.7 183.1 153.3 163 1223 834.9 514.7 38. 277.4 258.8 218. 177.3 151.6 138 1114 787. 49.8 365.1 274.7 254.4 215.1 174.4 15.2 1167 13 727.2 463.8 347.1 253.2 239.4 23.5 165.7 141. Constant Power Discharge Characteristics: W(25 ) 1.6V 1.7V 1.8V 15MIN 3MIN 1HR 2HR 3HR 4HR 5HR 6HR 8HR 1HR 3565 2737 1743 175 797.5 577. 534.3 465.5 37.6 311.3 3472 2723 1734 16 781.8 568.4 529.3 459.6 367.5 38.3 328 2577 1717 144 769.9 566.2 523. 448.9 361.8 36.5 2922 2322 161 988.3 742.3 537.8 515.7 426.8 35.4 33.4 2529 2119 1531 943.8 711.6 535.3 56.6 421.7 344.8 3.9 2156 191 142 893.5 677.9 495.8 478.1 399.5 327.6 283.5 Note The above data are average values, and can be obtained with 3 charge/discharge cycles. These are not minimum values. Page 1 of 2
GD15-2 2V15AH Dimensions 7 [.276] T11 Terminal Unit: mm [inches] 2 [.787] M8 [.315] Life characteristics of cyclic use Storage characteristic Capacity(%) 12 1 8 6 4 2 1% 5% 3% Capacity (%) 1 8 6 4 2 4 3 2 1 (Carry out supplementary charge before use if 1% capacity is requires) before use. This supplementary charge will help to recover the capacity and should be made as early as possible. Supplementary charge may often fail to recover the capacity. The battery should never be left standing till this state is reached 3 6 9 12 15 18 Number of Cycle(Times) 21 2 4 6 8 1 12 14 16 18 2 22 24 Storage Time (months) Supplementary charge and storage guidelines Charge characteristic Curve for standby use Discharge characteristic Curve 2.5 Charge Volume 12.24 2.1 2.33 Charge Voltage 1.2 2. Charge Voltage( V ) 2.17 2. 1.83 1.67 1.5 1 Discharge 1%(.5CA 2h) 5%(.5CA 1h) 2 Charge Charge Voltage2.275V/C Charge Current.1CA 3 Temperature 25 Charge Current 2 4 6 8 1 12 14 16 18 Charge Time(h) 2 24 28 8 6 4 2 C harge V olum e (% ).16.12.8.4 Charge Current (CA) Term inal Voltage (V ) 1.9 1.8 1.7 1.6.6 1.2 3 6 12 3 1 2 5 min 2C 1C.6C Discharge Time.35C.16C Hr.5C.94C 1 2 24 JYC GD BATTERIES 2 This information is generally descriptive only and is not intended to make or imply any representation, guarantee or warranty with respect to any cells and batteries. Cell and battery designs/ specification are subject to modification without notice. Contact JYC for the latest information. Page 2 of 2