Parts Manual RV Generator Set HDCAA (Spec A D) HDCAB (Spec A D) English Original Instructions 0-0 9 09 (Issue 9)
Introduction This parts catalog applies to the standard generator sets listed below. Parts are arranged in groups of related items and each illustrated part is defined by a reference number corresponding to the same reference number in the parts list. Parts illustrations are typical. Using the model and specification number from your generator set nameplate, select parts that apply to your set. Right and left sides are detemined by facing the engine end (front ) of the set. Generator Set Data Table Wiring Diagram Model Identification Rating AC/DC Voltage Hertz Phase 0.0HDCAA0A* 0,000 Watts 0/0 0 0.0HDCAA0C/D* 0,000 Watts 0 0/0 0 0.0HDCAA0A* 0,000 Watts 0/0 0 0.0HDCAA0C/D* 0,000 Watts 0 0/0 0.HDCAB0A*,00 Watts 0/0 0.HDCAB0C/D*,00 Watts 0 0/0 0 * The specification number denotes customer requested options or deviations from a standard (A, B, etc.) model. The specification letter advances (A, to B, to C, etc.) with major manufacturing changes.
THIS PAGE IS INTENDED TO BE BLANK
Index A Actuator, 9 Adapter, Generator, Adapter, Generator (Spec A), Arm, Rocker, 9 B Backplate, Fan, Baffle Assy, Housing, 9, Base, Mounting, Base, Oil, Bearing Set, Connecting Rod, 0 Bearing, Cam Center Needle, 9 Bearing, Camshaft Ball, Bearing, Generator Rotor Ball (Spec A), Bearing, Rotor, Belt, Cooling Fan, 9 Block, AC Terminal, Block, Battery Harness Terminal, Block, Cylinder, 9 Block, Generator Brush, Block, Generator Brush (Spec A), Body, Oil Pump, Bracket, Control, Bracket, Fan Backplate, Bracket, Foam, Bracket, Fuel Filter, Bracket, Generator Mounting, Bracket, Lifting, Bracket, Rocker, 9 Breaker, Circuit,, Brush, Generator, Brush, Generator (Spec A), Bush, Connecting Rod, 0 Bush, Main Spring Lever, C Camshaft, Cap Assy, Oil Fill, Cap Assy, Oil Fill (Gearcase), Cap, Alternator Terminal, 0 Cap, Coolant Fill, Cap, Idle Set, Cap, Oil Fill Push On, Cap, Recovery Tank Push On, Cleaner Assy, Air, Cleaner Assy, Air (Spec A), Clip, Hose, 9 Clip, Injection Pump Fuel Hose, Collar, Split, 9 Collar, Thrust, Components, Alternator, 0 Components, Injection Nozzle, Components, Injection Pump, Connector, Cylinder Block PCV, 9 Connector, Fuel Hose, Connector, Water Pump Hose, 9 Control (Begin Spec C), Control (Spec A), Control Board (Spec A), Cord, Glow Plug, Cover Assy, Cylinder Head, Cover, Air Cleaner, Cover, Air Cleaner (Spec A), Cover, Control, Cover, Cylinder Head, Cover, Gearcase, Cover, Governor Lever, Cover, Housing AC,, Cover, Housing Access, 9, Cover, Injection Pump Housing, 9 Cover, Mounting Base Access, Crankshaft, 0 Cup, Bush Sealing, Cup, Cylinder Block Sealing, 9 Cup, Cylinder Head Sealing, Cup, Gearcase Cover Sealing, Cup, Rocker Sealing, 9 D Disc, Generator Drive,
Index Disc, Generator Drive (Spec A), Door, Door Assy, Housing, 9, Dowel, Cylinder Head, 9 Dowel, Oil Pump, 9 Dowel, Timing Case, 9 Duct, Inlet (Spec A), E Edging, Stator Housing, Edging, Stator Housing (Spec A), Element, Air Cleaner, Element, Air Cleaner (Spec A), Endbell Generator, Endbell Generator (Spec A), Engine, Replacement, 9 Eye, Start Spring, F Fan, Generator, Fan, Generator (Spec A), Fan, Sucker, Filter, Fuel, Filter, Oil, 9 Fitting, Bulkhead, Flyweight, Flywheel, Frame, Housing Door, 9, Frame, Sub Mounting, Fuse (Spec A), 9 G Gasket, Cylinder Block Plug, 9 Gasket, Cylinder Head, Gasket, Cylinder Head Cover, Gasket, Cylinder Head Cover Oil Fill Cap, Gasket, Exhaust Manifold, Gasket, Governor Lever Cover, Gasket, Idle Spring Set Screw, Gasket, Injection Nozzle, Gasket, Injection Nozzle Heat Shield, Gasket, Injection Pump, Gasket, Nozzle Holder, Gasket, Oil Fill Cap, Gasket, Outlet Pipe, 9 Gasket, Rocker Plug, 9 Gauge, Oil Pressure (Remote Panel), Gauge, Water Temperature (Remote Panel), Gear, Crankshaft, 0 Gear, Idle, Gear, Injection Pump/Valve, Gearcase, Generator (Begin Spec C), Generator (Spec A), Governor, Grommet, Engine Harness, 0, Grommet, Engine Harness (Spec A), 9 Grommet, Housing Baffle, 9 Guard, Circuit Breaker, Guard, Fan, Guard, Fan (Spec A), Guide, Valve, H Hardware, Meter Mounting,, Harness, AC, Harness, Adapter, Harness, Battery, Harness, Engine, 9, 0, Harness, Engine (Spec A), 9 Harness, Remote, Harness, Remote Panel, Harness, Remote Panel (Gauges), Harness, Remote Panel (Switch/Hourmeter), Harness, Remote Panel (Switch/Voltmeter), Harness, Remote Panel (W/Switch), Harnesses, Remote, Head Assy, Cylinder, Head, Cylinder, Holder, Fuse (Spec A), 9 Holder, Injection Pump Delivery,
Index Hose, Air Bleed, Hose, Engine, Hose, Intake, Hose, Intake (Begin Spec C), Hose, Intake (Spec A), Hose, Overflow, Hose, PCV, 9 Hourmeter (Remote Gauge Panel), Hourmeter (Remote Switch Panel), Housing (Begin Spec C), Housing (Spec A), Housing End Cap,, Housing, Flywheel, Hub, Generator Rotor Drive (Spec A), I Indicator, Oil Lever, 9 Insulation, Housing, 9, Insulation, Housing Panel, 9, Insulation, Housing Rail Panel, 9, Insulation, Mounting Skid Base, Insulation, Skid Base, 9, Intake, Endbell (Spec A), Isolator, Vibration, K Key, Crankshaft, 0 Kit, Angleich, Kit, Engine Gasket (Top), 9 Kit, Isolator Mounting, Kit, Remote Control Panel (W/Switch), Kit, Remote Panel (Gauges), Kit, Remote Panel (Switch/Hourmeter), Kit, Remote Panel (Switch/Voltmeter), L Labels, Latch, Housing Access Cover, 9, Lever, Floating, Lever, Fuel Cut, Lever, Governor, Lever, Governor Control, Lever, Governor Tension, Lever, Guide, Lever, Main Spring, Line, Fuel, Link, Control, M Manifold, Exhaust, Meter, Hour Housing,, Meter, Voltage (Remote Panel), Mounting, Alternator, Mounting, Fan, Muffler, N Neck, Coolant Fill, Nozzle Assy, Injection, Nozzle, Injection, O O Ring, Fuel Cut Lever, O Ring, Gearcase Cover, O Ring, Generator, O Ring, Governor Control Shaft, O Ring, Injection Pump, O Ring, Oil Drain Plug, O Ring, Oil Fill Cap, O Ring, Oil Pump, O Ring, Radiator Plug, O Ring, Recovery Tank Cap, O Ring, Strainer, P Pan, Oil, Panel Assy, Housing Cap, 9, Panel Assy, Housing Engine, 9, Panel Assy, Housing Rail, 9,
Index Panel Assy, Housing Top, 9, Panel, Engine, Panel, Printed, Panel, Rail, Panel, Remote (W/Switch), Panel, Remote Gauge, Panel, Remote Switch/Hourmeter, Panel, Remote Switch/Voltmeter, Panel, w /Decal, PCB (Control)(Begin Spec C), Piece, Governor Lever Guide Pin, Pin, Camshaft, Pin, Control Link, 9 Pin, Control Spring, Pin, Cylinder Block Straight, 9 Pin, Governor Lever Sprit, Pin, Injection Pump, Pin, Link Plate Snap, Pin, Oil Pump, Pin, Piston, 0 Pin, Rocker, 9 Pipe, Air Inlet (Begin spec C), Pipe, Air Inlet (Spec A), Pipe, Flex Exhaust, Pipe, Fuel, Pipe, Fuel Feed, Pipe, Fuel Leakoff, Pipe, Injection, Pipe, Oil, Pipe, Rocker, 9 Piston, 0 Plate Assy, Alternator, 0 Plate, Alternator Adjusting, Plate, Injection Pump, Plate, Lever Pump Link, Plug, Cylinder Block, 9 Plug, Cylinder Head, Plug, Glow, Plug, Heater, 9 Plug, Heater Switch, Plug, Oil Pan, Plug, Oil Pump Valve, Plug, Radiator Drain, Plug, Rocker, 9 Plug, Shaft (Governor), Plunger, Injection Pump, Pulley, Alternator, 0 Pulley, Crankshaft, 0 Pulley, Fan, 9 Pump Assy, Injection, Pump Assy, Oil, Pump, Fuel, Pump, Injection, Pump, Oil, Pump, Water, 9 R Rack, Injection Pump Control, Radiator, Regulator, Alternator, 0 Relay, 0, Relay (Spec A), 9 Resonator, Intake (Begin Spec C), Resonator, Intake (Spec A), Retainer, Crank Rear, 9 Ring, Camshaft Snap, Ring, Camshaft Wear, Ring, Collector, Ring, Governor Snap, Ring, Idle Spring Snap, Ring, Injection Pump Snap, Ring, Piston Snap, 0 Rod, Connecting, 0 Rod, Push, 9 Rotor Assy, Generator, Rotor Assy, Generator (Spec A), S Scroll, Fan, Seal, Crank Rear Oil, 9 Seal, Crankshaft Front Oil, Seal, Housing Fan, 9
Index Seal, Lead, Seal, Radiator, Seal, Radiator Drain, Seal, Valve, Seat, Injection Nozzle Spring, Seat, Injection Pump Spring, Seat, Valve, Seat, Valve Spring, 9 Sender, Water Temperature, 9 Set, Piston Ring, 0 Shaft, Floating Lever, Shaft, Fuel Cut, Shaft, Idle Gear, Shaft, Lever, Shaft, Rocker, 9 Shaft, Shifter, Shield, Injection Nozzle Heat, Shifter, Governor, Shim, Injection Nozzle, Shim, Injection Pump, Sleeve, Governor Lever, Sleeve, Injection Pump Control, Sleeve, Injection Pump Flange, Spacer, Alternator Mounting, Spacer, Fan, Spacer, Generator Fan, Spacer, Generator Fan (Spec A), Spacer, Injection Nozzle, Spring, Fuel Cut Return, Spring, Generator Brush, Spring, Generator Brush (Spec A), Spring, Governor Idle, Spring, Injection Nozzle, Spring, Injection Pump Delivery, Spring, Injection Pump Plunger, Spring, Main, Spring, Oil Pump Valve, Spring, Return, Spring, Rocker, 9 Spring, Set, Spring, Start, Spring, Valve, 9 Starter, Stator, Generator, Stator, Generator (Spec A), Strainer, Oil, Strap, Electrical, Switch, Housing Rocker,, Switch, Remote Control Panel Rocker, Switch, Start/Stop (Remote Gauge Panel), Switch, Start/Stop (Remote Hourmeter Panel), Switch, Start/Stop (Remote Voltmeter Panel), System, Air Intake, System, Air Intake (Spec A), System, Cooling, System, Exhaust, System, Fuel, System, Ground, System, Mounting, T Tank, Recovery, Tappet, Engine, 9 Tappet, Injection Pump, Thermostat, Water Pump, 9 Transformer, Current, Tube, Air Intake (Spec A), Tube, Oil Fill, V Valve, Check, 9 Valve, Exhaust, 9 Valve, Injection Pump Delivery, Valve, Inlet, 9 Valve, Oil Pump Relief, Valve, Ventilator, W Wire, Lead Seal,
Cylinder Block 9 0 0 9 FRONT 0 9 FRONT 9, 9 0 HDCAA/AB
Cylinder Block 00 09 Engine, Replacement 9 Retainer, Crank Rear 0 Seal, Crank Rear Oil 00 Bolt 0 00 Actuator (E) Dowel, Oil Pump 0 Cup, Sealing (mm Dia.) Pin, Straight Pin, Housing Straight 9 Cup, Sealing (mm Dia.) 0 9 Connector, PCV Valve, Check Clip, Hose Hose, PCV 0 Clip, Hose 0 Clip, Hose Hose, PCV Dowel, Cylinder Head Hose, PCV 9 90 Indicator, Oil Level 0 0 Stud, Injection Pump (0mm) 0 Stud, Injection Pump Housing Cover (mm Lg) 0 Nut, Cover 00 Bolt, Cover Clip, Fuel Pump Lead Wire Cover, Injection Pump Housing 09 Plug, Cylinder Block (M) Gasket, Plug 0 Plug, Oil Gallery (/ PT) 9 90 Pin, Control Link 0 Stud, Injection Pump Housing Cover (9mm Lg) 0 Stud, Oil Filter 000 Filter, Oil 0 Cup, Sealing (mm Dia.) Dowel, Timing Case 0 Bearing, Cam Center Needle 0 Stud, Water Pump (0mm) Stud, Timing Case (0mm) Stud, Timing Case (0mm) 9 Bolt, Metal Cap 0 0 Stud, Oil Pan Plug, Water Drain (/ PT) 9 Plug, Oil Gallery (/ PT) 0 Kit, Engine Repair (Top Overhaul) 9 Switch, Oil (Replacement Switch) 9 HDCAA/AB
Crankshaft 9 0 REF PART QTY PART REF PART QTY PART Ring Set, Piston 9 Standard 0. Oversized 0 Ring, Snap 0 Pin, Piston Piston Standard 0 0. Oversize) Bearing Set Rod, Connecting (Includes Bolts, Bush and Nuts) Bolt 09 Bush 9 9 Nut 0 Key, Woodruff Gear, Crankshaft Pulley, Crankshaft mm OD x mm Width 0* mm OD x mm Width Washer Bolt 0 Washer, Thrust Washer Kit, Standard Thrust 9 Crankshaft * All units after Serial no. K0000, 0 HDCAA/AB
Camshaft/Idle Gear 0 9 Camshaft Assy (Includes Parts Marked *) 0 *Bearing, Rear Ball *Ring, Camshaft Wear 9 *Pin 0 *Bearing, Front Ball Ring, Snap Gear, Injection Pump & Valve 0 Nut, Cam Gear 9 0 Bolt 0 00 Collar, Thrust 00 Gear, Idle (with Bush) 99 Shaft, Idle Gear * Parts Included in Camshaft Assy. HDCAA/AB
Flywheel 0 9 Housing, Flywheel 0 9 Flywheel Washer Bolt 0 Screw, Lock Head Flange (M0 x. x mm) 9 9 Starter (See Separate Page for Components) 0 00 Washer, Lock (M) 00 Screw, Hex Head Cap (M x. x 0mm) HDCAA/AB
Oil Pump 9 0 Pump Assy, Oil (Includes Parts Marked *) 9 *Pump, Oil 9 *O Ring *Pin *Body 00 *Bolt 00 *Bolt 0 *Valve, Relief 9 9 *Spring, Valve 0 0 *Plug, Valve 009 Bolt 09 O Ring, Strainer 0 Strainer, Oil 00 Bolt 0 Pipe, Oil * Parts Included in Oil Pump Assy. HDCAA/AB
Injection Pump 9 0 Pipe, Injection Hose, Fuel Feed Leakoff 0 Clip, Fuel Hose 0 Pipe, Fuel Leakoff 0 Pipe, Fuel Feed 9 Nozzle Assy, Injection (See Separate Page for Components) 00 Bolt Gasket, Nozzle Holder 9 00 Washer, Corrugated 0 0 Shield, Nozzle Heat Gasket, Heat Shield 09 Nut Pump Assy, Injection (See Separate Page for Components) Shim, Injection Pump AR 0.mm AR 0.mm AR 0.mm 9 AR 0.mm 0 AR 0.mm AR 0.mm AR 0.mm AR.0mm AR.mm 0009 Bolt 000 Gasket HDCAA/AB
Injection Pump Components 9 0 9 Pump, Injection 0 Plunger Valve, Delivery 0 Spring, Delivery 09 O Ring 0 Holder, Delivery Seat, Spring 0 Gasket Rack, Control 9 Ring, Snap 0 00 Tappet 0 Seat, Spring (Lower) 0 Spring, Plunger 0 Seat, Spring (Upper) 0 Sleeve, Control Pin O Ring Sleeve, Flange Bolt 9 Plate 0 AR.0 0 AR. 0 AR.0 0 AR. 09 AR.0 00 AR. 0 AR.90 0 AR.9 0 AR.00 0 AR.0 0 AR.0 0 AR. 0 AR.0 0 AR. 09 AR.0 090 AR. 09 AR.0 09 AR. 09 AR.0 09 AR. 09 AR.0 09 AR. 09 AR.0 09 AR. 99 AR.0 00 AR. 0 AR.90 0 AR.9 0 AR.00 0 AR.0 0 AR.0 HDCAA/AB
Injection Nozzle Components 9 9 Nozzle, Injection Shim AR 0. AR 0. AR 0. AR 0. 9 AR 0. 0 AR 0. AR 0. AR 0. AR 0. AR 0. 0 Seat, Spring 9 Spacer Nozzle Nut, Retaining 0 Nut 09 Gasket NFS Body, Nozzle Holder 9 0 Spring, Nozzle HDCAA/AB
Cylinder Head 0 9 0 9 Head Assy, Cylinder (Includes Parts Marked *) 0 *Cup, Sealing (mm Dia.) 9 *Guide, Valve 0 *Cup, Sealing (.mm Dia) 0 *Plug, Drilled (mm Dia.) *Plug, Hot 99 *Seat, Inlet Insert Valve 00 *Seat, Exhaust Insert Valve 9 0 Stud, Water Pump 0 Bolt, Cylinder Head Cord, Glow Plug 9 Plug, Glow (HR) 9 Stud, Rocker Bracket 0 Seal, Valve Bolt, Cylinder Head 00 Plug, Heater Switch (/ PT) 0 Gasket, Cylinder Head 0 09 0 Bracket, Lifting 9 00 0 Screw, Hex Head Cap (M x. x mm) 0 00 Washer, Lock (M) * Parts Included in Cylinder Head Assy. HDCAA/AB
Cylinder Head Cover Cover Assy, Cylinder Head (Includes Ventilator Valve and Screws) Valve, Ventilator 0 Screw, Valve 00 9 Bolt, Cylinder Head Cover Cap Assy, Oil Fill (Includes Gasket) 0 Gasket, Oil Fill Cap 0 Gasket, Cylinder Head Cover HDCAA/AB
Rocker Arm 0 9 0 9 0 Bracket, Rocker Collar, Split Seat, Valve Spring Spring, Valve Valve, Exhaust Valve, Inlet 9 Tappet Rod, Push 9 Pin 0 9 Pipe 0 Cup, Sealing (mm) 9 Spring, Rocker 0 Nut, Rocker Bracket Shaft, Rocker Gasket, Plug Plug, Rocker Shaft 00 Bolt Screw 9 9 Arm, Rocker (Inlet) 0 9 Arm, Rocker (Exhaust) 9 Cup, Sealing (mm) Nut 9 HDCAA/AB
Blank Page 0 HDCAA/AB
Gearcase 9 0, Gearcase 0 Seal, Crankshaft Front Oil 0 Bolt, Timing Case 0 Bolt, Timing Case 09 Nut, Timing Case Bolt, W/ Detent Hole 00 Bolt, Cover 0 Cup, Sealing (mm Dia.) 9 9 Cover, Gearcase 0 O Ring, Gearcase Cover 9 Cap Assy, Oil Fill (Includes Gasket) 0 Gasket, Oil Fill Cap 00 Bolt, Cover Cover, Governor Lever 9 Gasket, Governor Lever Cover HDCAA/AB
Governor 0 9 0 9 0 9 0 9 0 9 HDCAA/AB
Governor Nut, Shaft Lever Washer, Spring Lever, Fuel Cut 0 Washer, Thrust 0 O Ring, Shaft Nut, Set Screw 0 Cap, Idle Set 0 Nut, Set Screw Cap 9 0 Gasket, Set Screw 0 Screw, Idle Spring Set 9 Spring, Fuel Cut Return Shaft, Fuel Cut Nut, Screw Screw, Speed Set Control 9 Ring, Idle Spring Snap Washer, Idle Spring Lower Washer, Idle Spring Upper Spring, Idle 9 0 Eye, Start Spring 0 Lever, Governor Control Nut, Lever to Shaft Washer, Spring 0 Washer, Thrust 0 O Ring, Control Shaft Bush, Main Spring Lever 9 Plug, Shaft (/ PT) 9 Screw, Full Load Set Bush, Main Spring Lever 9 0 Cup, Bush Sealing (0mm Dia.) 0 Pin, Control Spring Shaft, Lever Lever Kit, Governor (Includes Main Spring Lever and Tension Lever) Lever, Main Spring Lever, Governor Tension Spring, Return 09 Nut, Holder 0 Kit, Angleich Wire, Lead Seal 9 0 Seal, Lead 0 Sleeve Flyweight Shaft, Floating Lever 9 Shaft, Shifter 00 Pin, Governor Lever Sprit Spring, Main Lever, Floating 9 Piece, Governor Lever Guide Pin 0 Ring, Snap 9 9 Shifter, Governor 0 Spring, Set Lever, Guide Spring, Start 00 Pin, Link Plate Snap Link, Control 0 Plate, Lever Pump Link HDCAA/AB
Fuel System 0 9 9 0 9 0 Bracket, Fuel Filter 9 Filter, Fuel 0 0 Nut, Self Locking (/ ) 9 0 0 Line, Fuel Injection Pump 0 9 09 Clamp, Hose 0 9 Clamp, Hose 0 0 Line, Fuel 9 0 Line, Fuel Filter 9 09 0 Screw, Lock Flange 0 0 Plug, Pipe 0 9 0 Fitting, Bulkhead 9 90 Pump, Fuel (E) 0 0 Nut, Lock Flange (M x mm) 00 Washer, IT Lock (/ ) 000 Nut, Hex Jam (/ ) 0 99 Connector, Hose 0 0 Clamp, Hose HDCAA/AB
Air Intake System with Control Board (Spec A) & 9 0 0 0 00 Cleaner Assy, Air (Includes Element and Cover) 0 0 Element, Air Cleaner 0 0 Cover, Air Cleaner 0 0 Hose, Intake Resonator, Intake 0 0 0 Hose, Intake 0 0 0 Hose, Intake 0 0 Tube, Air Intake 9 0 00 Nut, Nylon Lock (M x ) 0 0 Band, Hose Clamp 09 0 Screw, Lock Flange (M x. x 0mm) 0 0 Band, Hose Clamp 0 Band, Hose Clamp Pipe, Air Inlet 0 Stud, Inlet Pipe 0 Nut, Inlet Pipe 0 09 0 Control 000 09 Screw, Pan Head Machine (M x 0. x mm) HDCAA/AB
Air Intake System (Begin Spec C D) 9 0 0 0 0 00 Cleaner Assy, Air (Includes Element and Cover) 0 0 Element, Air Cleaner 0 0 Cover, Air Cleaner 0 0 Hose, Intake Resonator, Intake 0 9 Spec C 0 9 0 Begin Spec D 0 Hose, Air 0 Hose, Air 0 Hose, Intake 0 00 Nut, Nylon Lock (M x ) 0 0 Band, Hose Clamp 9 09 0 Screw, Lock Flange (M x. x 0mm) 0 0 Band, Hose Clamp Pipe, Air Inlet 0 Stud, Inlet Pipe 0 Nut, Inlet Pipe Transformer, Current (Begin Spec D) 0 Screw, Pan Head (SDT) (Begin Spec D) HDCAA/AB
Fan Mounting 9 0 0 Scroll, Fan 0 0 Spec A 0 Begin Spec C 0 0 Nut, Lock Flange (M x ) 00 09 Screw, Hex Head Cap (M x. x 0mm) 00 Washer, Flat (M) 0 Fan, Sucker 0 Spacer, Fan 0 0 Nut, Lock Flange (M x.mm) Backplate, Fan 0 0 Spec A 0 00 0 Begin Spec C 9 0 0 Bracket, Backplate 0 0 Screw, Lock Flange (M x. x mm) 0 0 Bracket, Backplate 0 0 Bracket, Backplate 0 0 Bracket, Backplate 00 Screw, Lock Flange (M0 x. x 0mm) 0 0 0 Edging (0mm) 0 09 Edging HDCAA/AB
Cooling System, 0 9 0 9 Screw, Lock Flange (M x x mm) 09 0 Spec A 09 0 Begin Spec C 0 0 *Tank, Recovery 09 09 O Ring 0 0 0 Cap, Push On 0 0 Cap, Fill 0 Neck, Fill 0 9 Clamp, Hose 0 09 Hose, Overflow 9 0 00 Hose, Air Bleed 0 Clamp, Hose 0 Clamp, Hose 0 9 Clamp, Hose Hose, Engine (In) 0 0 Spec A 0 0 Begin Spec C 0 0 Hose, Engine (Out) 0 0 Nut, Lock Flange (M0 x.mm) 9 Clamp, Loop 0 0 Plug, Hex Head Screw (M x.mm) 09 0 O Ring 9 0 Radiator 0 0 9 09 Clamp, Hose 0 99 Hose, Cooling Over Flow (Begin Spec C) 0 0 Bracket, Fill Tube (Begin Spec C) 0 9 Connector, Hose 90 Nylon 0 Connector, Hose Nylon HDCAA/AB
Water Pump 0 9 Screw, Hex Flange 00 M x. x 0mm 09 0 + M x. x mm Housing, Thermostat 0 mm ID 00 +9mm ID w / Bolts 9 0 Sender, Water Temperature (E) 0 0 Connector, Hose Gasket, Outlet Pipe mm ID 000 + 9mm ID Thermostat 0 mm OD + mm OD Pump, Water 9 mm Top Outlet + 9mm Top Outlet Bolt 0 mm 0 0mm 00 0mm 9 09 Nut 0 00 Plug, Heater (PT /) Pulley, Fan 0mm OD x mm Wide 00 ++ mm OD x mm Wide 00 Bolt, Pulley Belt, Cooling Fan 00 * Serial No. J99 and Older 0 ** Serial No. G0 and Newer 0 *** Between J99 and G0 * A pulley that measures / wide uses the 00 on generators with serial numbers J99 and older. ** A pulley that measures / wide uses the 0 on generator with serial numbers G0 and newer. *** Sets with serial numbers between J99 to G0 may have either pulley as we don t have the exact serial number cutoff from the engine supplier (Use Kit 0). + HDCAA after Serial No. J990000 HDCAB after Serial No. H000 HDCAC after Serial No. H00009 ++ All models after Serial No. K0000, Includes all parts marked with one asterisk. 9 HDCAA/AB
Alternator Components 9 0 Alternator (V, 0A, mm Pulley) 9 9 *Alternator (V, 0A,.mm Pulley) Plate Assy (Includes Bushings and Bearings) Pulley mm OD 0.mm OD 0 Screw 0 Washer 0 Washer, Spring 0 Nut Regulator 0 Screw 9 Washer 0 Cap, Terminal * All units after Serial no. K0000 0 HDCAA/AB
Alternator Mounting Spacer 0 Plate, Adjustment 00 Bolt 0 Bolt 00 Nut HDCAA/AB
Oil Fill 0 Tube, Oil Fill 00 0 Screw, Pan Head Torx (M x x 0mm) 0 0 0 Cap, Push On 09 09 O Ring HDCAA/AB
Oil Base 0 Pan, Oil (Includes Plug and O Ring) Plug 0 O Ring, Oil Drain Plug 0 Nut 00 Bolt HDCAA/AB
Exhaust System 0 9 0 0 9 HDCAA/AB
Exhaust System Muffler 0 Pipe, Flex Exhaust 00 Gasket, Exhaust Manifold 0 00 9 Washer, Spring Lock (M) 0 00 Nut, Hex (M x.mm) 00 0 Screw, Hex Head Cap (M x. x mm) 00 Screw, Lock Flange (M0 x. x 0mm) 9 Gasket, Exhaust Manifold 9 0 Manifold, Exhaust 0 00 Bolt (0mm) 09 Stud (0mm) 09 Nut 9 Gasket, Exhaust Manifold 0 Stud, Manifold (9mm) 0 Bolt (0mm) 00 Washer (M) 00 0 Screw, Hex Head (M x. x 0mm) 0 Washer, Flat (/ ) 9 9 Accessory, Exhaust Elbow, 0 Accessory, Exhaust Tube 0 HDCAA/AB
Ground System 0090 Strap, Electrical 00 Screw, Hex Head Cap (M0 x 0) 000 Washer, EIT Lock (/ ) 0 0 Nut, Hex (M0) 00 Washer, Flat (M0) 009 Screw, Round Head Machine (/ 0) 000 Washer, EIT Lock (/ ) 000 Nut, Hex (/ 0) HDCAA/AB
Mounting System 9 9 9 9 0 0 0 0 Kit, Isolator Mounting (Includes Parts Marked *) 0 Kit, Isolator Mounting (Includes Parts Marked +)* Base, Mounting 0 0 All Models Spec A 0 9 0 All Models Begin Spec C 0 00 0 Isolator, Engine 00 0 Screw, Pan Head (M x x mm) 0 Screw, Isolator Mount Seal, Radiator 0 0.mm 0 0 0.mm 0 0 Nut, Lock Flange (M0 x.mm) 0 0 Cover 09 0 Screw, Lock Flange (M x x mm) 9 0 9 Seal, Radiator Drain 0 0 0 *Frame, Sub Mounting HDCAB 0 0 0 +*Isolator, Vibration HDCAB 0 0 0 +*Isolator, Vibration HDCAB 0 +*Washer, Flat (.0mm) HDCAB 0 +*Washer, Flat (.0mm) HDCAB 00 00 +*Screw, Hex Head Cap (/ x. ) HDCAB 0 *Screw, Lock Head Flange (M x. x mm) HDCAB 0 0 Bracket, Mounting 0 9 0 Bracket, Mounting 9 00 Screw, Lock Head Flange (M0 x. x 0mm) 0 0 Insulation, Mounting Skid Base 0 0 Bracket, Foam 0 0 0 Edging 0 9 Seal, Oil Drain 000 Washer, Eit Locking (/ ) 0090 Strap, Electrical 0 09 0 Edging * Parts Included in Isolator Mounting Kit (W/Frame). + Parts Included in Isolator Mounting Kit (W/O Frame). HDCAA/AB
Housing (Spec A),,,, 9 0 9 9 0,,, 0, HDCAA/AB
Housing (Spec A) 0 9 0 Cover Assy, Access (Includes Insulation and Nuts) 0 Insulation, Access Cover 0 Nut, Push On 0 S Panel Assy, Top (Includes Insulation and Nuts) 0 9 Insulation, Top Panel 0 Nut, Push On 0 9 S Panel Assy, Cap (Includes Insulation) All Models 0 Insulation, Cap 9 0 Insulation, Cap 0 0 9 0 Door Assy (Includes Insulation and Latch) 0 Insulation, Access Cover 0 Latch, Access Cover 0 9 0 Frame, Door 0 0 Baffle Assy (Includes Grommets and Seals) 0 Grommet 0 0 Seal, Fan (0mm) 0 0 Seal, Fan (0mm) 0 90 S Panel Assy, Rail (Includes Insulation and Nuts) 9 0 Insulation, Rail Panel 0 0 Nut, Push On 0 9 Insulation, Rail Panel 0 Insulation, Housing Skid Base 0 9 S Panel Assy, Engine (Includes Insulation) 0 Insulation, Panel (9 x mm) 0 0 Insulation, Panel (. x 0.mm) 0 Insulation, Panel ( x 0.mm) 0 0 Nut, Lock Flange (M x ) 09 0 Screw, Lock Flange 9 Cover, Access AC ( See Hous ing End Cap) 0 09 Screw, Pan Head ( UNC x.) 9 HDCAA/AB
Housing (Begin Spec C),, 0,, 9, 0, 9 0,,, 0 HDCAA/AB
Housing (Begin Spec C) 0 0 Panel Assy, Cap (Includes Insulation) All Models 0 Insulation, Panel (End Cap) 0 0 Insulation, Cap 0 9 S Panel Assy, Engine (Includes Insulation) 0 900 0 Panel, Engine 0 Insulation, Panel (9 x mm) 0 0 Insulation, Panel (. x 0.mm) 0 Insulation, Panel ( x 0.mm) 9 0 90 0 Panel Assy, Rail (Includes Insulation and Nuts) 0 0 9 0 Panel, Rail 0 Insulation, Rail Panel 0 Nut, Push On 0 9 Insulation, Rail Panel 0 9 0 Door Assy (Includes Insulation and Latch) 0 0 Door 0 Insulation, Access Cover 0 Latch, Access Cover 0 9 0 Frame, Door 9 0 0 Baffle Assy (Includes Grommets, Baffel and Seals) 0 0 9 0 Baffel 0 Grommets 0 0 Seal, Fan (0mm) 0 0 Seal, Fan (0mm) Cover, Access AC ( See Hous ing End Cap) 0 S Panel Assy, Top (Includes Insulation and Nuts) 0 9 Insulation, Top Panel 0 Nut, Push On 0 9 S Cover Assy, Access (Includes Insulation and Nuts) 9 0 Insulation, Access Cover 0 0 Nut, Push On 09 0 Screw, Lock Flange 0 0 Nut, Lock Flange (M x ) 0 Insulation, Housing Skid Base 09 Screw, Pan Head ( UNC x.) 0 0 Cover, Brush Block (Access) 09 0 Screw, Lock Flange (M x x mm) HDCAA/AB
Housing End Cap (Spec A) 0 9 0 Guard, CB (Spec A) Breaker, Circuit 0 9 0 A (HDCAA ) 0 9 09 0A (HDCAB) 09 0 Screw, Lock Flange 0 0 0 Cover, AC 09 0 Screw, Pan Head x / 0 0 Switch, Rocker 0 00 Meter, Hour 0 09 0 Cover, Access HDCAA/AB
Housing End Cap (Begin Spec C) Breaker, Circuit 0 9 0 A (HDCAA) 0 9 09 0A (HDCAB) 09 0 Screw, Lock Flange 0 0 0 Cover, AC 00 Screw, Pan Head ( x / ) 0 0 Switch, Rocker 0 00 Meter, Hour HDCAA/AB
Generator (Spec A B) 0 9 9 0 9 0 9 HDCAA/AB
Generator (Spec A B) 0 0 S Rotor Assy, Generator (Includes Parts Marked *) 00 0 *Screw, Hex Head Cap (M x. x mm) 00 *Washer, Flat (M) 9 *Disc, Generator Drive 0 00 *Fan, Generator 9 *Spacer, Fan *Hub, Rotor Drive 0 0 *Ring, Collector 9 0 0 *Bearing, Ball 0 09 00 O Ring 09 Adapter, Generator 0 00 Washer, Lock 00 0 Screw, Hex Head Cap (M0 x 0mm) 00 Washer, Flat (M) 0 00 Washer, Lock 00 00 Screw, Hex Head Cap (M x mm) 0 Guard, Fan 00 09 Screw, Hex Head Cap (M0 x. x 0mm) 9 00 Screw, Pan Head 0 0 Intake, Endbell 09 0 Duct, Inlet 000 Nut, Hex (/ ) 009 Washer, Flat (/ ) 099 Washer, Flat (M) 00 009 9 Screw, Hex Head Machine (M x 0. x ) S0 Block Assy, Generator Brush (Includes Spring, Block and Brush) 0 Spring, Generator Brush S0 Block, Brush 9 00 Brush, Generator 0 0 Endbell 0 000 0 Stud (mm) 0 09 0 Edging Stator, Generator 0 0 HDCAA, HDCAB 0 0 HDCAB 90 00 Screw, Hex Head Cap (M x. x 0mm) Plug ( Pin) Plug, Wedge 9 Plug, Seal* * Parts Included in Generator Rotor Assy. HDCAA/AB
Generator (Begin Spec C) 0 9 0 9 0 0 0 9 HDCAA/AB
Generator (Begin Spec C) Rotor Assy, Generator (Includes Parts Marked *) 0 0 S HDCAA (mm) 0 0 0 HDCAB (mm) 00 0 *Screw, Hex Head Cap (M x. x mm) 00 *Washer, Flat (M) *Disc, Generator Drive 0 00 *Fan, Generator 9 *Spacer, Fan 00 Screw, Hex Head Cap (M x. x 0mm) *Rotor, Wound 0 9 0 HDCAA (mm) 0 9 0 HDCAB (mm) 9 00 Adapter, Generator 0 0 00 Washer, Lock (M0) 00 0 Screw, Hex Head Cap (M0 x 0mm) 00 Washer, Flat (M) 0 00 Washer, Lock (M) 00 00 Screw, Hex Head Cap (M x mm) 0 Guard, Fan 00 09 Screw, Hex Head Cap (M0 x. x 0mm) 0 Insulation Cover (Endbell) 0 Insulation Cover (Generator) 9 00 Cover, Generator Intake 0 09 0 Screw, Locking Flange (M x 0mm) 000 Nut, Hex (/ ) 009 Washer, Flat (/ ) 0 0 Endbell Assy (Includes Parts Marked #) 0 0 #End, Bell Generator 099 #Washer, Flat (M) 00 009 9 #Screw, Hex Head Machine (M x 0. x ) S0 #Block Assy, Generator Brush (Includes Parts Marked >) S0 >Block, Brush 9 00 >Brush, Generator 0 0 >Spring, Generator Brush Stud 0 000 0 HDCAA (mm) 0 000 0 HDCAB (mm) 0 09 0 Edging Stator, Generator 0 0 0HDCAA 0 0 0 0 HDCAB 0 0 0.HDCAB0 0 0 Bearing, Rotor 09 00 O Ring * Parts Included in Generator Rotor Assy. # Parts Included in Endbell Assy. > Parts Included in Generator Brush Block Assy. HDCAA/AB
Control (Begin Spec C) 00 00 PCB (Control) 0 0 Insulation, Cover Plug 9 00 0 Cover, Control (Generator Intake) 9 99 0 Bracket, Control 09 0 Screw, Hex Thread Form 09 0 Screw, Locking Flange (M x mm) HDCAA/AB
Engine Harness (Spec A) K, K P9 P ÄÄÄÄÄÄÄÄÄ ÄÄÄÄÄÄÄÄÄ ÄÄÄÄÄÄÄÄÄ ÄÄÄÄÄÄÄÄÄ ÄÄÄÄÄÄÄÄÄ ÄÄÄÄÄÄÄÄÄ ÄÄÄÄÄÄÄÄÄ ÄÄÄÄÄÄÄÄÄ ÄÄÄÄÄÄÄÄÄ J, P, P 9 0 Harness, Engine 0 09 Connector, Switch (P9) 0 Holder, Fuse (F) 0 0 Fuse (A, F and F) Connector, Plug ( Pin) (P) 0 Connector, Plug ( Pin ) (P) Wedge, Plug ( Pin) (P, P) Connector, Plug (0 Pin) (P) 9 Lock, Housing 9 AR Connector, Alt 0 9 Plug, Cavity 0 0 Grommet 0 AR Seal, Cable Wedge (J) Connector ( Pin) (J) 0 Relay (K and K) 000 Washer 0 00 Nut, Lock Flange (M x ) 9 HDCAA/AB
Engine Harness (Spec C) K, K, K P9 P ÄÄÄÄÄÄÄÄÄ ÄÄÄÄÄÄÄÄÄ ÄÄÄÄÄÄÄÄÄ ÄÄÄÄÄÄÄÄÄ ÄÄÄÄÄÄÄÄÄ ÄÄÄÄÄÄÄÄÄ 0 ÄÄÄÄÄÄÄÄÄ ÄÄÄÄÄÄÄÄÄ ÄÄÄÄÄÄÄÄÄ J P 9 Harness, Engine 0 09 Connector, Switch (P9) 9 0 Connector, Plug ( Pin) (P) Plug, Cavity (P) 0 AR Socket, Terminal (P) Connector, Plug (0Pin) (P) 9 Lock, Housing AR Connector, Alt 9 Plug, Cavity 9 0 0 Grommet 0 0 AR Seal, Cable Wedge (J) Connector ( Pin) (J) 0 Relay (K and K) 000 Washer 0 00 Nut, Lock Flange (M x ) 0 HDCAA/AB
Engine Harness (Begin Spec D) K, K, K P9 P ÄÄÄÄÄÄÄÄÄ ÄÄÄÄÄÄÄÄÄ ÄÄÄÄÄÄÄÄÄ ÄÄÄÄÄÄÄÄÄ ÄÄÄÄÄÄÄÄÄ ÄÄÄÄÄÄÄÄÄ 0 ÄÄÄÄÄÄÄÄÄ ÄÄÄÄÄÄÄÄÄ ÄÄÄÄÄÄÄÄÄ J P 9 0 Harness, Engine 0 09 Connector, Switch (P9) 9 0 Connector, Plug ( Pin) (P) Plug, Cavity (P) 0 AR Socket, Terminal (P) Connector, Plug (0Pin) (P) 9 Lock, Housing AR Connector, Alt 9 Plug, Cavity 9 0 0 Grommet 0 0 AR Seal, Cable Wedge (J) Connector ( Pin) (J) 0 Relay (K and K) 000 Washer 0 00 Nut, Lock Flange (M x ) HDCAA/AB
Battery/AC Harness 0, Harness, Wiring (Includes Parts Marked *) 0 *Block, Terminal (TB) *Clamp, Insulated Loop 00 *Nut, Hex (/ ) 000 *Washer, EIT Lock (/ ) 09 0 Screw, Lock Flange (M x x mm) 0 0 Nut, Lock Flange (M x ) Harness, AC (Includes AC Terminal Block)(Spec A) 9 Harness, AC (Includes AC Terminal Block)(Begin Spec C) 0 0 Block, AC Terminal (TB) 000 Screw, Round Head Machine ( x / ) 00 Nut, Hex Brass (/ ) 00 Washer, Flat (/ ) * Parts Included in Battery Wiring Harness. HDCAA/AB
Remote Harnesses 9 0 00 9 Harness, Remote (Includes Parts Marked *) Harness, Remote Panel (Includes Parts Marked +) 90 0 0 90 0 0 Harness, Adapter (Includes Parts Marked #) 0 +*Connector, Receptacle +*Plug, Cavity 0 +*Seal, Cable 0 +*Pin, Contact 9 +*Housing, Lock 9 00 AR +#Socket, Contact 0 +#Cap, Connector* Parts Included in Remote Harness (00 9). + Parts Included in Remote Panel Harness ( 90). # Parts Included in Adapter Harness ( ). HDCAA/AB
Remote Control Panel 00 9 Kit, Remote Panel 0 0 Switch, Rocker (S) 9 9 0 Panel, Remote (Includes Label) 090 Screw, Wood (# x ) Harness, Remote Panel 99 Pin, Contact 9 Plug (9 Pin) HDCAA/AB
Remote Switch/Hourmeter Panel 00 9 Kit, Switch/Hourmeter Remote Panel 090 Screw, Wood Mounting (# x ) 9 9 0 Panel, Printed 0 0 Switch, Rocker 0 00 Hourmeter Harness, Remote Panel (Includes Pins and Plug) 99 Pin, Contact 9 Plug (9 Pin) HDCAA/AB
Remote Switch/Voltmeter Panel 00 9 Kit, Remote Switch/Voltmeter Panel 0 0 Switch, Rocker 9 99 0 Panel, Printed 0 Meter, Voltage 090 Screw, Wood Mounting (# x ) 09 Harness, Remote Panel (Includes Pins and Plug) Hardware, Meter Mounting 009 Washer, Nylon (/ ) 009 Washer, Flat (#0) 000 Nut, Hex Brass Machine (#0 ) 0 000 Washer, Lock (#0) 99 Pin, Contact 9 Plug (9 Pin) HDCAA/AB
Remote Gauge Panel 0 9 00 0 Kit, Remote Gauge Panel 9 99 Panel, w /Decal 0 00 Screw, Pan Head Sheet Metal Mounting (# x / ) 0 0 Switch, Rocker (SPDT) 0 Meter, Voltage 9 0 Gauge, Water Temperature 9 0 Gauge, Oil Pressure Harness, Remote Panel (Includes Plug and Pins) 9 Plug (9 Pin) 9 99 Pin, Contact 0 0 00 Hourmeter Hardware, Meter Mounting 009 Washer, Nylon (/ ) 009 Washer, Flat (#0) 000 Nut, Hex Brass Machine (#0 ) 0 000 Washer, Lock (#0) HDCAA/AB
Labels, Miscellaneous Label, Control Panel(Spec A) 9 99 0 A, Pole 9 99 0 0A, Pole Label, Model Ident Voltage 9 Label, Packaged (Includes Parts Marked *)(Spec A) 9 90 Label, Packaged (Includes Parts Marked +) (Begin Spec C) 9 *Label, Service Information 9 +*Label, Coolant Drain 9 +*Label, Warning Hazardous Voltage/Rotational Parts 9 9 0 +*Label, Warning Hazardous Voltage (Terminal ID) 9 +*Label, Fuel Attachment 9 +*Label, Hot / Cold 9 9 0 +*Label, Warning Install 9 0 +*Label, Warning Heat 9 +*Label, Ground 9 9 0 +*Label, Warning Hazardous Voltage (Terminal ID) 9 0 Label, Warning Voltage (Spec A) 9 Label, Certification 9 9 Label, Emissions 0kW HDCAA 9 9 0 Label, Model Ident (0000) 9 9 0 Label, Information (Breaker AMP) 9 9 Label, Information (Control Panel) 9 9 0 Label, Listed kw HDCAB 9 9 0 Label, Model Ident (000) 9 9 0 Label, Information (Breaker 0 AMP) 9 9 Label, Information (Control Panel) 9 9 0 Label, Listed * Parts Included in Label Package Spec A. + Parts Included in Label Package Begin Spec C. HDCAA/AB
Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page Numbers 09, 09, 09, 09 0, 09 9 0, 09 9 0, 09 99 0, 09 99 0, 09, 09, 09, 09, 09 9 0, 09 9 0, 09 9 0, 09 9 0, 09 0, 09 9, 09 90, 09 9, 09 9 0, 09 9 0, 09, 00 09, 9 0 9, 0 9, 0, 0 0, 0, 0 0, 0, 0 0, 0 0 0, 0 0 0, 0, 0 0, 0 0, 0 0, 0 0, 0 0, 9, 0 0, 9, 0, 0 0, 0 0, 0 0, 0 0,, 0, 0 00,, 0 0,, 0 0,, 0 9, 0 9 0, 9, 9 0 0, 9 0, 9 0, 9 90, 0 00, 9 00, 0,, 0,, 9, 000, 9 0009, 000, 9, 9 00, 9 000, 9 00, 9 00, 9,, 00, 9,, 00, 9 00, 00, 00, 009, 00,, 9,, 0, 9 0, 0, 0, 0,,, 9 0, 9, 9,,, 09,,, 9, 00, 0, 9 0, 0, 9, 0, 9 0, 09, 00, 0, 0, 0, 0, 0, 0, 0, 0, 9, 9 09, 9 00,, 9 0, 0, 9 0, 9, 0, 0, 0, 0 0, 0 09, 0 00, 0, 0, 0, 0, 0 0, 0 0, 0 0, 0, 09, 00, 0, 0, 0, 0 0,, 0, 9 0, 0, 09, 00, 0, 0, 0, 0, 0, 0, 0, 0, 09, 00, 0, 0, 0, 0, 0, 0, 0, 0, 09, 090, 09, 09, 09, 09, 9
Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page 09, 09, 09, 09, 00, 0, 0, 0, 0, 0, 0, 0, 0, 09, 0,,,, 0, 0, 9,,, 9, 0,,,,,,, 9, 0, 0 9, 0 0,, 9, 9, 9, 9,,, 0, 9, 9,, 9,,,, 0 9, 0,,, 9,,,,, 9,,,, 0,,,,,, 9, 0,,,,,, 9, 9, 0,,,,, 9, 9, 90, 9 9, 9 9, 9, 9, 9, 0 9, 9 9, 9, 9, 9 99,, 00, 0, 0, 0 0, 0, 0, 0, 0,, 9,,,, 0, 0, 0 9, 0, 9,,, 0,,,, 9,, 9,,,, 9 9, 9 0,,, 0 9,,,,,,,,, 9,,,,,, 9, 0,, 9, 0,,, 9, 9, 9 0, 9, 0, 0, 0, 0, 9, 9, 9, 90, 9 9, 0
Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page 9, 9, 9, 0 9, 9 9, 9 9, 9 9, 9 99, 00, 0, 9 0, 0, 0, 0,, 0 0, 0 0, 9,, 0, 9 09, 0, 9,, 9, 9,,, 9,, 9, 9,,, 9,,,, 0, 9, 0,, 9,, 9, 9,, 9, 9 9,, 9,, 9,,,, 9, 9, 0, 9,, 9, 9 9 9, 9 9, 0 9 0, 9 9 0, 9 0, 0 0 0, 0 0 S,, 0 9 0, 0 9 0, 0 0, 0 00,, 0 00 0, 0 0, 0 0, 0, 0 0, 0, 09 0, 0,, S0,, S0,, 0 0, 00,, 0 0, 0 0, 0 0,, 0 0, 09, 00, 9,,, 0,, 9,, 00, 00 9, 00 9, 00 9, 00 9, 00 0, 00 00, 0,, 0 00,,,, 0 09 0, 0, 9, 0, 0 09, 9, 0, 0 0,, 0 0,,,,, 9 99 0, 9 00 0, 9 9 0, 9 9 0, 9 99 0, 9 99, 0 9 0, 0 9 0,, 0 9 09,, 0 0, 9 0, 9 99,,, 00, 9,,,, 9,,,, 9, 0,,, 9, 0,, 9 0, 9, 9 9,, 9, 0, 0, 0,, 0, 0, 0, 9, 0,, 0,, 9, 0,, 9, 9, 0,,, 9, 0, 9 0, 0,,, 9, 0, 0, 0090,,, 90 0, 90 0, 09,,, 9,,,,, 0, 0, 0 00 0, 0 0 0,
Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page 0 0 0, 0 0, 0 9, 0 0, 0 0, 0 9 0, 0 09 0, 0 0, 0 9, 0 0, 0, 9, 0, 0 0, 0 9 0, 0 09 0, 0 0 0,, 0, 9, 0 9, 9, 0 0, 9, 0, 9 0, 9, 0 0, 0, 9, 0, 9, 0, 9, 0 S, 9, 0, 9 0 0, 0 9 S, 9, 0 90 S, 9, 0 9, 9, 0 9 S, 9 0 9 0, 9, 0 9 0, 0 9 0, 9 0 9 S, 0 900 0, 0 9 0, 0 9 0, 9 0 9 0, 0 0, 9, 0, 9, 0, 0 0, 0, 0, 0 0, 0 9 0, 0 99, 0 0, 9 0, 0 9, 0 0, 0 0, 0, 0, 0,, 0 0, 0 9 09,, 0 9,, 0 9, 0 99, 0 0,, 0 0 0, 0 0 0, 0 0, 0 0, 0 09, 0 00, 0 0, 0, 0, 0, 0 0, 0 09, 0 0 0,, 0 09 0, 0 09 0, 0 09 0, 0 0, 9, 0, 0, 9, 09 09,, 09 0, 09 00,, 0 0, 00, 9 0, 9 00, 9 0, 0 0, 0 0, 0, 9, 0 000 0,, 0 000 0, 000, 9, 0, 009,, 009,, 00, 00, 0, 0, 0, 099,, 009,, 00,, 00,,,,, 0, 9 0, 00 00, 00 009 9,, 00 00,, 00 0,,, 00 0, 00 0, 00 09, 00 0,, 00 09,, 00,,, 0 00, 000, 09, 9, 09 0, 00, 00, 0, 0, 090,,, 09 0, 09 0, 9 0,, 00,,,, 0, 09 0,,,, 9,,,, 09 0,, 09 0, 09 0,, 009, 000 09, 00 0, 00 0, 0 000,, 0 00,, 0 00,, 0 00,, 00, 000, 000, 000,, 0 00, 9, 0, 0 00, 000, 000,, 00, 000, 0 0, 0 00,, 0 0,
Numerical Index Part No. Page Part No. Page Part No. Page Part No. Page 0 0,,, 9,, 0 0, 0 0,,, 000,, 00,
THIS PAGE IS INTENDED TO BE BLANK
Cummins Power Generation 00 rd Ave. NE Minneapolis, MN USA Phone 000 Toll-free 00 Fax 9 Email www.cumminsonan.com/contact www.cumminsonan.com Cummins, Onan, the C logo, and Performance you rely on. are trademarks of Cummins Inc. 0 Cummins Power Generation, Inc. All rights reserved.