DIMENSIONS AND AREAS 1. GENERAL This section describes those diagrams and text which shows the area, dimensions, stations, access doors, and physical locations of the structural members of the airplane. Also included is the cardinal rigging dimensions. 2. AIRPLANE DIMENSIONS AND AREAS The airplane is divided into reference points in inches. These reference points provide a means of quickly identifying the locations of components. Three axes are used as reference points. The following terms are used for the reference points: Fuselage Station is a horizontal reference designation starting in front of the nose of the airplane WS Wing Station is measured outboard from the centerline of the fuselage to the wing tip. WL Water Line is a vertical reference designation measured parallel to the ground. BL Buttock Line is a horizontal reference designation starting at the airplane centerline. Right or left is added to indicate direction from airplane centerline. A. General Length (Overall)... 25.92 ft... 7.90 m Height (Maximum)... 8.80 ft... 2.70 m Wing Span (Overall)... 38.25 ft... 11.65 m Propeller Diameter (Maximum)... 6.50 ft... 1.98 m B. Cabin Cabin Width... 49.00 in.... 124.00 cm Cabin Height... 0 in.... 127.00 cm Cabin Length... 122.00 in.... 309.00 cm Cabin Volume... 137.00 ft³... 3.83 m³ Baggage Compartment Height... 39.00 in.... 99.00 cm Baggage Compartment Width... 40.00 in.... 101.00 cm Baggage Compartment Length... 36.00 in.... 91.00 cm Baggage Compartment Volume... 32.00 ft³... 0.90 m³ C. Wings Span... 38.25 ft... 11.65 m Area... 144.90 ft²... 13.46 m² Wing Loading... 23.46 lb/ft²... 114.45 kg/m² Aspect Ratio... 10.00... 10.00 Wing Dihedral Serials 0002 thru 2437... 4.50... 4.50 Wing Dihedral Serials 2438 & subs... 5.50... 5.50 D. Flaps Span... 8.80 ft... 2.68 m Area... 10.80 ft²... 1.00 m² E. Ailerons Span... 4.70 ft... 1.43 m Area... 4.37 ft²... 0.41 m² All 0600 Page 1
F. Horizontal Stabilizer Span... 13.17 ft... 4.01 m Area... 25.75 ft²... 2.39 m² Aspect Ratio... 5.59... 5.59 G. Elevator Span... 12.00 ft... 3.66 m Area... 7.73 ft²... 0.72 m² H. Vertical Stabilizer Span... 5.52 ft... 1.65 m Area... 15.93 ft²... 1.48 m² Aspect Ratio... 1.84... 1.84 I. Rudder Span... 5.42 ft... 1.65 m Area... 5.26 ft²... 0.49 m² J. Landing Gear Wheel Track (Main To Main) Serials 0002 thru 2437... 10.83 ft... 3.30 m Wheel Track (Main To Main) Serials 2438 & subs... 9.10 ft... 2.77 m Wheel Base (Main To Nose)... 7.26 ft... 2.21 m 3. ACCESS PANELS A. Cabin Floor (See Figure 06005) Maintenance practices pertinent to the cabin floor access panels are found in Chapter 53, Fuselage. (Refer to 5320) B. Wing (See Figure 06006) Maintenance practices pertinent to the wing access panels are found in Chapter 57, Wings. (Refer to 5730) C. Empennage (See Figure 06007) Maintenance practices pertinent to the empennage access panels are found in Chapter 53, Fuselage. (Refer to 5330) 0600 Page 2 All
4. CONTROL SURFACE TRAVELS AND CABLE TENSION SETTINGS A. Aileron Aileron Up Travel: 12.5 ±1.0 Aileron Down Travel: 12.5 ±1.0 Aileron Trim Deflection: 6.0 ±1.0 Aileron Cable Tension: 3040 lb B. Elevator Elevator Up Travel: 25.0 +0 / 1.0 Elevator Down Travel: 15.0 ±1.0 Elevator Trim Deflection: 10.5 ±1.0, +17 Minimum Elevator Cable Tension: 3040 lb C. Rudder Maximum Right Rudder Deflection: 20.0 ±1.0 Maximum Left Rudder Deflection: 20.0 ±1.0 D. Flaps Flap UP: 0.0 ±0.5 Flap 50%: 16.0 ±0.5 Flap 100%: 32.0 ±0.5 All 0600 Page 3
WATER LINE (WL) 55.6 222.0 350.2 WL 165.5 38.3 WL 0.0 157.4 2 NOTE Reference datum located at fuselage station 0.0. 300.0 3 () FUSELAGE STATION BUTTOCK LINE (BL) 230.0 LEMAC 133.1 RBL 229.5 RBL 87.7 Typical LBL MAC 47.7" RBL 63.1 RBL 77.3 BL 0.0 BL 0.0 LBL 63.1 LBL 77.3 0600 Page 4 230.0 BUTTOCK LINE (BL) LBL 229.5 Serials 0002 thru 2333, 2335 thru 2419, 2421 thru 2437. Figure 06001 Airplane Principal Dimension Serials 0002 thru 2437 (Sheet 1 of 2) Serials 0002 thru 2437 SR22_MM06_1322A
WATER LINE (WL) 55.6 222.0 350.2 WL 165.5 38.3 WL 0.0 157.4 2 NOTE Reference datum located at fuselage station 0.0. 300.0 3 () FUSELAGE STATION BUTTOCK LINE (BL) 230.0 LEMAC 133.1 RBL 229.5 RBL 87.7 Typical LBL MAC 47.7" RBL 77.3 RBL 54.8 BL 0.0 BL 0.0 LBL 54.8 LBL 77.3 230.0 BUTTOCK LINE (BL) LBL 229.5 SR22_MM06_2609 Serials 2438 & subs Figure 06001 Airplane Principal Dimension Serials 2438 & subs (Sheet 2 of 2) 0600 Page 5
Water Line (WL) 38.3 55.6 121.4 130.3 200.8 218.1 222.0 249.3 291.3 350.2 WL 165.5 WL 159.5 WL 83.9 WL 105.8 WL 94.0 WL 56.5 WL 61.9 157.5 0.0 2 300.0 3 () Fuselage Station Serials 0002 thru 2333, 2335 thru 2419, 2421 thru 2437. Water Line (WL) 38.3 55.6 121.4 130.3 200.8 218.1 222.0 249.3 291.3 350.2 WL 165.5 WL 159.5 WL 83.9 WL 105.8 WL 94.0 WL 57.7 WL 61.9 157.5 0.0 2 300.0 3 () Fuselage Station Serials 2334, 2420, 2438 & subs. Note Reference datum located at fuselage station 0.0. SR22_MM06_1323A 0600 Page 6 Figure 06002 Fuselage Stations All
WS 240.0 WS 220.0 QTR CHORD WS WS 180.0 WS 197.5 REAR SHEAR WEB AILERON HINGES WS 160.0 WS 140.0 WS 141.4 WS 120.0 WS WS 80.0 WS 88.6 FLAP HINGES WS 60.0 WS 40.0 WS 20.0 WS 0.0 WS 20.0 MAINSPAR WS 40.0 WS 60.0 WS 80.0 WS WS 120.0 WS 88.6 FLAP HINGES WS 140.0 WS 160.0 WS 180.0 WS 141.4 REAR SHEAR WEB AILERON HINGES WS WS 197.5 WS 220.0 Serials 0002 thru 2437 WS 240.0 Serials 0002 thru 2333, 2335 thru 2419, 2421 thru 2437. Figure 06003 Wing Stations Serials 0002 thru 2437 SR22_MM06_1324 0600 Page 7
WS 240.0 WS 220.0 QTR CHORD WS WS 180.0 WS 160.0 WS 196.0 REAR SHEAR WEB AILERON HINGES WS 140.0 WS 140.2 WS 120.0 WS WS 80.0 WS 86.6 FLAP HINGES WS 60.0 WS 40.0 WS 20.0 WS 0.0 WS 20.0 MAINSPAR WS 40.0 WS 60.0 WS 80.0 WS WS 120.0 WS 86.6 FLAP HINGES WS 140.0 WS 140.2 WS 160.0 WS 180.0 WS REAR SHEAR WEB WS 196.0 AILERON HINGES WS 220.0 WS 240.0 SR22_MM06_2580 0600 Page 8 Figure 06003 Wing Stations Serials 2438 & subs Serials 2438 & subs
BL 80 BL 72.0 BL 60 REAR SPAR ELEVATOR HINGES BL 40 BL 36.0 BL 20 MID SPAR MAINSPAR BL 0.0 BL 20 BL 40 BL 36.0 FORWARD SPAR BL 60 ELEVATOR HINGES BL 80 BL 72.0 NOTE Bottom view lower skin removed for clarity. SR22_MM06_1968 All Figure 06004 Elevator Stations 0600 Page 9
CF8 CF1L CF1R CF2L CF2R CF3C CF3L CF3R CF4C CF4L CF4R CF5 CB6 CB7 LEGEND CF1L CF1R CF2L CF2R CF3L CF3C CF3R CF4L CF4C CF4R CF5 CB6 CB7 CF8 Engine Mount ThroughBolt Engine Mount ThroughBolt Pilot Seat CoPilot Seat Passenger Seat RudderAileron Interconnect PitotStatic Water Trap Flight Control Cables Trim System Relays Flight Control Cables Marker Beacon Antenna ELT CAPS Transponder Antenna Serials 0002 thru 1601, 1603 thru 1820, 1822 thru 1839, 1841 thru 1862. SR22_MM06_1832 Figure 06005 Floor Access Panels Serials 0002 thru 1601, 1603 thru 1820, 1822 thru 1839, 1841 thru 1862 0600 Page 10 Serials 0002 thru 1601, 1603 thru 1820, 1822 thru 1839, 1841 thru 1862
CF8 CF1L CF1R CF2L CF2R CS1L CF3L CS1R CF3C CF3R CF4L CF4C CF4R CF5 CB6 CB7 LEGEND CF1L CF1R CF2L CF2R CF3L CF3C CF3R CF4L CF4C CF4R CF5 CB6 CB7 CF8 CS1L CS1R Engine Mount ThroughBolt Engine Mount ThroughBolt Pilot Seat CoPilot Seat Passenger Seat RudderAileron Interconnect PitotStatic Water Trap Flight Control Cables Trim System Relays Flight Control Cables Marker Beacon Antenna ELT CAPS Transponder Antenna Spar Tunnel Spar Tunnel SR22_MM06_2277 Figure 06005 Floor Access Panels Serials 1602, 1821, 1840, 1863 & subs (Sheet 2 of 2) Serials 1602, 1821, 1840, 1863 & subs 0600 Page 11
LW15 LW13 LW12 LW14 LW16 LW11 LW6 LW10 LW4 LW9 LW8 LW7 LW5 LW3 LW1 RW1 RW3 RW7 RW5 RW8 RW9 RW12 LW2 RW2 RW4 RW13 RW6 RW10 RW11 RW16 RW14 LEGEND LW1/RW1 Wing Root, Aft LW2/RW2 Wing Root, Fwd LW3/RW3 Fuel Tank, Root LW4/RW4 Wing Inboard LW5/RW5 WS 37 LW6/RW6 Wing Mid, Fwd LW7/RW7 Wing Mid, Aft LW8/RW8 WS 68 LW9/RW9 WS 89 LW10/RW10 Fuel Tank, Mid LW11/RW11 Fuel Tank, Outboard LW12/RW12 WS 121 LW13/RW13 Wing Outboard, Aft LW14/RW14 NACA Vent LW15 Aileron Cove LW16/RW16 Wing Outboard, Fwd Serials 0002 thru 2333, 2335 thru 2419, 2421 thru 2437. SR22_MM06_1325B 0600 Page 12 Figure 06006 Wing Access Panels Serials 0002 thru 2437 (Sheet 1 of 2) Serials 0002 thru 2437
LW13 LW12 LW11 LW8 LW7 LW10 LW9 LW6 LW5 LW3 RW3 LW4 LW2 LW1 RW1 RW4 RW5 RW6 RW7 RW8 RW10 RW12 RW9 RW13 LEGEND LW1/RW1 Wing Root LW2 Deicing Fluid Tank LW3/RW3 Fuel Tank, Root LW4/RW4 Wing Inboard LW5/RW5 NACA Vent, Inboard LW6/RW6 Fuel Tank, Inboard LW7/RW7 Fuel Tank, Mid LW8/RW8 Fuel Tank, Outboard LW9/RW9 Wing Mid LW10/RW10 NACA Vent, Outboard LW11 Aileron Cove LW12/RW12 Wing Outboard LW13/RW13 Aileron Hinge SR22_MM06_2455 Serials 2438 & subs Figure 06006 Wing Access Panels Serials 2438 & subs (Sheet 2 of 2) 0600 Page 13
LE2 LE1 RE3 RE2 NOTE Serials 0821 & subs. RE1 LEGEND LE1 Elevator Push Pull Rod LE2 Pitch Trim Cartridge RE1 Pitch Trim Motor Assembly RE2 Rudder Push Pull Rod RE3 Avionics Bay SR22_MM06_1833A 0600 Page 14 Figure 06007 Empennage Access Panels All