TECHNICAL SERVICE BULLETIN 866 - GO-BASTA www.bastaboatlifts.com TROUBLESHOOTING A DEAD BATTERY disconnect and charge battery overnight with charger of at least 4 amp capacity CURRENT DRAIN TEST FIGURE 2 examine wiring for damage if current is less than 10 ma, red wire may be open, more than 20 ma, red wire may be rubbing on chassis if wiring is OK, replace REMOTE CONTROL RECEIVER current between 10 and 20 milliamps? CHARGING VOLTAGE TEST FIGURE 3 PANEL CURRENT TEST FIGURE 4 voltage between 12.8 and 20.0 volts? current between 50 and 600 milliamps? replace have a qualified shop TEST THE BATTERY UNDER LOAD ISOLATION DIODE TEST FIGURE 5 replace with appropriate size DEEP DISCHARGE BATTERY successful? voltage between 0.45 and 0.65 volts? replace REMOTE CONTROL RECEIVER solar panel needs more light or frequent lift operation requires use of trickle charger examine wiring for damage and loose or corroded connections - repair as necessary
Serial Number Raise Control Pendant Lower failure, injury or death may result in structural capacity lift Exceeding to become unstable boat on lift could cause lift position properly to Failure that lift frame is level check always use Before 90.0 when not in use off power Switch lift humans to use not Do if boat is on lift unattended (TM) Over-Center upright fully lift raise Always Basta Over-Center Gravity Locking Lifts (TM) injury or death to prevent serious parts moving all Avoid DANGER! Maid in the USA. Manufactured under one or more of the following patents #6318929, #6837651 #4895479, #4900187, # 5143182 #5184914 #5311970, Canada #2089044 other PatentsPending FIGURE 1 866 - GO-BASTA www.bastaboatlifts.com TYPICAL INSTALLATION BEFORE BEGINNING: 1. CAUTION! When measuring current, always set the meter to its highest range, then adjust it if it is not sensitive enough. Most meters have a special jack for readings over 200 ma. It is very easy to blow the fuse inside the meter - In order to prevent meter damage, turn the power switch on the lift control panel to OFF during these s. 2. DISCONNECT THE FOR THE CURRENT DRAIN TEST (fig. 2). 3. THE IS VERY SENSITIVE TO SHADOWING. Covering up just a small section of the panel can drastically lower its output. When ing the s, it is important that the panel is in direct light and is not shawed at all. Close the power unit lid as much as practical and move the power unit if necessary. Do not place anything, even something as small as a screwdriver on the panel during ing. 4. The Isolation Diode Test (fig. 5) requires a digital meter with a diode setting. - using the Ohms or continuity settings will provide inaccurate results. An analog meter with an R x 1 scale can be used, but that technique is beyond the scope of this bulletin. Motor Pump Motor Relay Tank Control Panel bottom view 'Down' Solenoid 1-866-GO BASTA GOBASTA.COM Battery jumper! CAUTION! WARNING on lower on raise Off ON Fuse 15 Amp To Auxiliary Lights (if used) Group 27 marine deep cycle Remote control receiver ORANGE OR YELLOW RAISE > AND = 12V LOWER >,, = 12V ORANGE IS TURNED ON AND OFF BY THE "LIGHT" BUTTONS ON THE KEY FOB - IT IS T AUTOMATIC TURN POWER SWITCH OFF WHEN UNATTENDED BLK Solar Panel Connector OR BLK WHT
Serial Number Raise Control Pendant Lower 90.0 Basta Over-Center Gravity Locking Lifts (TM) Maid in the USA. Manufactured under one or more of the following patents #6318929, #6837651 #4895479, #4900187, # 5143182 #5184914 #5311970, Canada #2089044 other PatentsPending FIGURE 2 866 - GO-BASTA www.bastaboatlifts.com CURRENT DRAIN TEST Motor Pump Tank MILLIAMPS 10 20 DISCONNECTED DO T USE REMOTE! Motor Relay A ma 1 2.8 'Down' Solenoid Control Panel bottom view DANGER! 1-866-GO BASTA GOBASTA.COM Avoid all moving parts to prevent serious injury or death Battery! CAUTION Always raise lift fully upright Over-Center (TM) if boat is on lift unattended Do not use to lift humans Switch power off when not in use jumper! WARNING Before use always check that lift frame is level Failure to properly position boat on lift could cause lift to become unstable Exceeding lift capacity may result in structural failure, injury or death on lower on raise Off ON Fuse 15 Amp To Auxiliary Lights (if used) Group 27 marine deep cycle Remote control receiver ORANGE OR YELLOW DO T USE REMOTE! BLK Solar Panel Dis
Serial Number Raise Control Pendant Lower 90.0 Basta Over-Center Gravity Locking Lifts (TM) Maid in the USA. Manufactured under one or more of the following patents #6318929, #6837651 #4895479, #4900187, # 5143182 #5184914 #5311970, Canada #2089044 other PatentsPending FIGURE 3 866 - GO-BASTA www.bastaboatlifts.com CHARGING VOLTAGE TEST Motor Pump Tank VOLTS 13.0 19.0 FULL SUN CONNECTED DO T USE REMOTE! Motor Relay V1 3.6 2 V 'Down' Solenoid Control Panel bottom view DANGER! 1-866-GO BASTA GOBASTA.COM Avoid all moving parts to prevent serious injury or death! CAUTION Battery Always raise lift fully upright Over-Center (TM) if boat is on lift unattended Do not use to lift humans Switch power off when not in use jumper! WARNING Before use always check that lift frame is level Failure to properly position boat on lift could cause lift to become unstable Exceeding lift capacity may result in structural failure, injury or death on lower on raise Off ON Fuse 15 Amp To Auxiliary Lights (if used) Group 27 marine deep cycle Remote control receiver ORANGE OR YELLOW DO T USE REMOTE! BLK Solar Panel Connected
FIGURE 4 866 - GO-BASTA www.bastaboatlifts.com PANEL CURRENT TEST TE: PLUG MUST BE UNPLUGGED MILLIAMPS 100 600 FULL SUN A A.435 TE: METER MAY HAVE SPECIAL CONNECTION FOR CURRENT MEASUREMENTS ABOVE 200mA
FIGURE 5 866 - GO-BASTA www.bastaboatlifts.com ISOLATION DIODE TEST DIODE TEST 0.45 0.65 DIODE TEST DISCONNECT AND WIRE FOR THIS TEST YELLOW