DS ommercial 3-5 Ton Packaged Air onditioner 4 SEE / Up to.0 EE ooling apacity: 35,000 58,000 BTU/h ontents Nomenclature... Product Specifications... 4 Expanded ooling Data... 7 Airflow Data... 3 rankercase Heater... Electrical Data / Heat Kit Data... 3 Dimensions... 9 Wiring Diagrams... 33 for Models with DD ontrols... 38 Accessories... 45 Standard Features High-efficiency scroll compressor opper tube/aluminum fin coils High- and low-pressure switches ontactor with lugs High-capacity, steel-cased filter drier Heater kits with single-point entry 4-volt terminal strip onvertible airflow orientation Easy to service Built-in filter rack with standard " filters Bottom utility entry AHI ertified; ETL Listed 3-5 Tons with single speed blower motor units meet the performance specified in Table 6.8.- of ASHAE Standard 90.-03 abinet Features Heavy-gauge, galvanized-steel cabinet with UV-resistant powder-paint finish Full Perimeter ail Sloped drain pan * omplete warranty details available from your local distributor or manufacturer s representative or at www.daikincomfort.com. SS-DS3 www.daikinac.com /7 Supersedes 8/7
Nomenclature D S 060 00 3 B * * * A * 3 4,5,6 7,8,9 0 3 4 5 6 evision Levels Major & Minor Brand Factory-Installed Options D Daikin X No Options A Non-powered convenience outlet onfiguration B Powered convenience outlet Standard Efficiency (6-5 Tons) Low-ambient kit S Standard Efficiency (3-5 Tons) D eturn air smoke detector T High Efficiency (3-5 Tons) E Supply air smoke detector F Non-powered convenience outlet; Application Low-ambient kit ooling G Non-powered convenience outlet; G Gas Heat eturn air smoke detector H Heat Pump H Non-powered convenience outlet; Supply air smoke detector Nominal ooling apacity J Non-powered convenience outlet; 036 3 Tons 0 8½ Tons 300 5 Tons eturn & Supply air smoke detectors 048 4 Tons 0 0 Tons K Non-powered convenience outlet; 060 5 Tons 50 ½ tons Low-ambient kit; Supply air smoke detector 07 6 Tons 80 5 Tons L Non-powered convenience outlet; 090 7½ Tons 40 0 Tons Low-ambient kit eturn & Supply air smoke detectors Nominal Heating apacity M Powered convenience outlet; Gas/Electric A/ H/P Factory-Installed Electric Heat Low-ambient kit 045 45,000 BTU/h XXXNo Heat N Powered convenience outlet; 090 90,000 BTU/h 000 kw 030 30 kw eturn air smoke detector 5 5,000 BTU/h 055 kw 03 30 kw O Powered convenience outlet; 40 40,000 BTU/h 065 kw 045 45 kw eturn & Supply air smoke detectors 0 0,000 BTU/h 088 kw 046 45 kw P Powered convenience outlet; 350 350,000 BTU/h 000 kw 060 60 kw Supply air smoke detector 400 400,000 BTU/h 055 kw Q Powered convenience outlet; Low-ambient See product specifications for heat size(s) available for each capacity. kit; eturn air smoke detector Powered convenience outlet; Low-ambient Voltage kit; Supply air smoke detector 08-30//60 4 460/3/60 T Powered convenience outlet; Low-ambient 3 08-30/3/60 7 575/3/60 kit; eturn & Supply air smoke detectors U Non-powered convenience outlet; Supply Fan/Drive Type/Motor Low-ambient kit; eturn air smoke detector B Belt Drive (single speed) V Two-Speed Belt Drive (also designates 6-Ton V Low-ambient kit; eturn air smoke detector D Direct Drive (3-5 Tons) with two-stage compressor) W Low-ambient kit; Supply air smoke detector H High Static (single-speed Belt Drive models only) Y Low-ambient kit; eturn & Supply Factory-Installed Options air smoke detectors A Ultra Low-Leak Downflow Economizer Ultra Low-Leak Downflow Economizer; Z eturn & Supply air smoke detectors B DD-BAnet protocol DD-BAnet protocol; F Ultra Low-Leak Downflow Economizer; Disconnect Switch (non-fused) DD-BAnet protocol V Low-Leak Downflow Economizer Factory-Installed Options H Disconnect Switch (non-fused) W Low-Leak Downflow Economizer X Standard Aluminized Heat Exchanger J Ultra Low-Leak Downflow Economizer; Disconnect Switch (non-fused) S Stainless-Steel Heat Exchanger Disconnect Switch (non-fused) X No Options D Hinged Panels M Disconnect Switch (non-fused); DD-BAnet protocol K Stainless-Steel Heat Exchanger; Hinged Panels Note: Not all options available for all products. B Phase Monitor X= No Options in character 3th J Stainless Steel Heat Exchanger; Phase Monitor M Hinged Panel; Phase Monitor L Stainless-Steel Heat Exchanger; Hinged Panels; Phase Monitor www.daikinac.com SS-DS3
Factory-Installed Options Stainless-Steel Heat Exchanger (Gas units only): A tubular heat exchanger made of 409-type stainless steel is installed in the unit. Low-Ambient Kit: Allows for cooling operation at lower outdoor temperatures. On the 3- to 6-ton units, cooling operation is extended from 60 F ambient temperature to 35 F outside air temperature. On 7½ -0 ton units, cooling operation is extended from 35 F ambient temperature to 0 F outside air temperature. For 5 ton units, cooling operation is extended from 4 F ambient temperature to 0 F outside air temperature. Economizers (Downflow): Based on air conditions, can provide outside air to cool the space. Electric Heat Kits (A and heat pump units only): Available in all voltage options. Non-powered onvenience Outlet: A 0V, 5A, GFI outlet makes it easier for technicians to service the unit once an electrician runs power to the outlet. Powered onvenience Outlet: A 0V, 5A, GFI outlet powered with a transformer built into the unit. When a factory-installed powered convenience outlet is installed in the equipment, the unit MA (Min. ircuit Ampacity) will increase by 7.A/6.5A for 08/30V units, increase by 3.3A for 460V units, and by.6a for 575V units. The MOP (Max. Overcurrent Protection) device must be sized accordingly. Disconnect Switch (non-fused; 3-phase units only): A disconnect switch is installed in the unit and factory wiring will be complete from the switch to the unit. Please note that for air conditioning (DS units) and heat pump models (DSH units), the appropriate electric heat kit must be ordered to be factory-installed along with the disconnect switch (non-fused) when it is ordered. Please note that for models with a powered convenience outlet option and a disconnect switch (non-fused) option, the power to the powered convenience outlet will be shut off when the disconnect switch (non-fused) is in the off position. eturn Air and/or Supply Air Smoke Detectors: eturn air and/or supply air smoke detectors are installed in the unit. Hinged Access Panels: Allows access to unit s major components. ombined with latches for easy access to control box, compressor, filters and blower motor. Available on all units. Two-speed indoor fan blower models are available on 6, 7½, 8½, 0, ½, 5, 0 & 5 ton units. Section 6.4.3.0.b of ASHAE Standard 90.-00 and Section 6.5.3...a of ASHAE Standard 90.-03 require a minimum of two fan speeds. Section 40.4(m) of alifornia Energy ommission Title 4 03 contains a similar provision. When the units with the two-speed indoor fan blowers operate on a call for the first stage of cooling, the fan operates at low speed, which is 66% of full speed. When the units operate on a call for the second stage of cooling, the fan operates at full speed. In heating operation, the fan operates at full speed. During ventilation operation, the fan operates at low speed. Phase Monitor: Phase monitor (3 phase only), available for 3-5 ton DS, D and DT series models. Phase monitor shall provide protection for motors and compressors against problems caused by phase loss, phase reversal and phase unbalance. Phase monitor is equipped with an LED that provides an ON or FAULT indicator. DD ontroller: DD communicating controller, available for 3-5 ton DS, D and DT series models with on-board BAnet communication interface. SS-DS3 www.daikinac.com 3
Product Specifications 3 Tons DS036 ***D***A* DS036 ***3D***A* DS036 ***3B***A* DS036 ***4B***A* DS036 ***7B***A* ooling apacity Total BTU/h 36,000 36,000 35,000 35,000 35,000 Sensible BTU/h 6,640 6,640 5,600 5,600 5,600 SEE / EE 4 / 4 / 4 / 4 / 4 / Decibels 78 78 78 78 78 AHI eference #s 99675 99678 995 9957 9953 Evaporator Motor / oil Motor Type Direct Drive Direct Drive Belt Drive Belt Drive Belt Drive Indoor Nominal FM,50,50,00,00,00 Motor Speed Tap (ooling) Low Low --- --- --- Indoor Motor FLA (ooling).46.46 3.4.7.3 Horsepower - PM ⅓ - 90 ⅓ - 90.0-75.0-75.5-75 Piston Size (ooling) 0.070 0.070 0.070 0.070 0.070 Filter Size (") (4) 4" x 0" x " (4) 4" x 0" x " (4) 4" x 0" x " (4) 4" x 0" x " (4) 4" x 0" x " Drain Size (NPT) ¾" ¾" ¾" ¾" ¾" -40A efrigerant harge ir # (oz.) 05 05 05 05. 05 Evaporator oil Face Area (ft²) 7.0 7.0 7.0 7.0 7.0 ows Deep / Fins per Inch 4 / 6 4 / 6 4 / 6 4 / 6 4 / 6 Belt Drive Evap Fan Data # of Wheels (D x W) ----- ----- (" x 0") (" x 0") (" x 0") Motor Sheave ----- ----- VL34 X ⅝ VL34 X ⅝ VL34 X ⅝ Blower Sheave / Belt ----- ----- AK6 x / AX5 AK6 x / AX5 AK6 x / AX5 ondenser Fan / oil Quantity of ondenser Fan Motors Horsepower - PM ¼ /,075 ¼ /,075 ¼ /,075 ¼ /,050 ¼ /,050 Fan Diameter/ # Fan Blades / 4 / 4 / 4 / 4 / 4 Outdoor Nominal FM 3,800 3,800 3,800 3,800 3,800 Face Area (ft²) 7. 7. 7. 7. 7. ows Deep/ Fins per Inch / 4 / 4 / 4 / 4 / 4 ompressor Quantity / Type/ Stage / Scroll/Single / Scroll/Single / Scroll/Single / Scroll/Single / Scroll/Single ompressor LA / LA 6.7 / 79.0 0.4 / 73.0 0.4 / 73.0 5.8 / 38.0 3.8 / 36.5 Electrical Data Voltage-Phase-Frequency 08/30--60 08/30-3-60 08/30-3-60 460-3-60 575-3-60 Indoor Blower HP / FLA ⅓ /.46 ⅓ /.46 / 3.4 /.7.5 /.3 Max External Static 0.5" 0.5".0".0".0" Outdoor Fan HP / FLA ¼ /.4 ¼ /.4 ¼ /.4 ¼ / 0.70 ¼ / 0.55 Min. ircuit Ampacity¹ 4.7 / 4.7 6.9 / 6.9 7.9 / 7.9 9.6 7.6 Max. Overcurrent Protection (amps)² 40 / 40 5 / 5 5 / 5 5 5 Power Supply onduit Hole.5".5".5".5".5" Low-Voltage onduit Hole ½" ½" ½" ½" ½" Operating Weight (lbs) 565 565 565 565 565 Ship Weight (lbs) 590 590 590 590 590 ¹ Wire size should be determined in accordance with National Electrical odes. Extensive wire runs will require larger wire sizes. ² May use fuses or HA-type circuit breakers of the same size as noted. Notes Always check the S& plate for electrical data on the unit being installed. 4 www.daikinac.com SS-DS3
Product Specifications 4 Tons DS048 ***D***A* DS048 ***3D***A* DS048 ***3B***A* DS048 ***4B***A* DS048 ***7B***A* ooling apacity Total BTU/h 48,000 48,000 47,000 47,000 47,000 Sensible BTU/h 35,50 35,50 35,000 35,000 35,000 SEE / EE 4 / 4 / 4 /.8 4 /.8 4 /.8 Decibels 78 78 78 78 78 AHI eference #s 99676 99679 995 9958 9954 Evaporator Motor / oil Motor Type Direct Drive Direct Drive Belt Drive Belt Drive Belt Drive Indoor Nominal FM,600,600,600,600,600 Motor Speed Tap (ooling) Low Low -- -- -- Indoor Motor FLA (ooling).80.80 3.4.7.3 Horsepower - PM ¾ -,05 ¾ -,05.0 -,75.0 -,75.5 -,75 Piston Size (ooling) 0.076 0.076 0.074 0.074 0.074 Filter Size (") (4) 4" x 0" x " (4) 4" x 0" x " (4) 4" x 0" x " (4) 4" x 0" x " (4) 4" x 0" x " Drain Size (NPT) ¾" ¾" ¾" ¾" ¾" -40A efrigerant harge ir # (oz.) 0 0 Evaporator oil Face Area (ft²) 7.8 7.8 7.8 7.8 7.8 ows Deep / Fins per Inch 4 / 6 4 / 6 4 / 6 4 / 6 4 / 6 Belt Drive Evap Fan Data # of Wheels (D x W) ----- ----- (" x 0") (" x 0") (" x 0") Motor Sheave ----- ----- VL40 X ⅝ VL40 X ⅝ VL40 X ⅝ Blower Sheave / Belt ----- ----- AK66 x / AX5 AK66 x / AX5 AK66 x / AX5 ondenser Fan / oil Quantity of ondenser Fan Motors Horsepower - PM ¼ -,075 ¼ -,075 ¼ -,075 ¼ -,050 ¼ -,050 Fan Diameter/ # Fan Blades / 4 / 4 / 4 / 4 / 4 Outdoor Nominal FM 3,800 3,800 3,800 3,800 3,800 Face Area (ft²).5.5.5.5.5 ows Deep/ Fins per Inch / 7 / 7 / 7 / 7 / 7 ompressor Quantity / Type/ Stage / Scroll/Single / Scroll/Single / Scroll/Single / Scroll/Single / Scroll/Single ompressor LA / LA 9.9 / 09 3./ 83. 3./ 83. 6./ 4 4.4/ 33 Electrical Data Voltage-Phase-Frequency 08/30--60 08/30-3-60 08/30-3-60 460-3-60 575-3-60 Indoor Blower HP / FLA ¾ /.8 ¾ /.8.0 / 3.4.0 /.7.5 /.3 Max External Static 0.5" 0.5".0".0".0" Outdoor Fan HP / FLA ¼ /.40 ¼ /.40 ¼ /.40 ¼ / 0.70 ¼ / 0.55 Min. ircuit Ampacity¹ 9 / 9 0.6 / 0.6. /. 0 8.3 Max. Overcurrent Protection (amps)² 45 / 45 30 / 30 30 / 30 5 5 Power Supply onduit Hole.5".5".5".5".5" Low-Voltage onduit Hole ½" ½" ½" ½" ½" Operating Weight (lbs) 565 565 570 570 570 Ship Weight (lbs) 590 590 595 595 595 ¹ Wire size should be determined in accordance with National Electrical odes. Extensive wire runs will require larger wire sizes. ² May use fuses or HA-type circuit breakers of the same size as noted. Notes Always check the S& plate for electrical data on the unit being installed. SS-DS3 www.daikinac.com 5
Product Specifications 5 Tons DS060 ***D***A* DS060 ***3D***A* DS060 ***3B***A* DS060 ***4B***A* DS060 ***7B***A* ooling apacity Total BTU/h 58,000 58,000 58,000 58,000 58,000 Sensible BTU/h 4,90 4,90 4,90 4,90 4,90 SEE / EE 4 /.6 4 /.6 4 /.6 4 /.6 4 /.6 Decibels 78 78 78 78 78 AHI eference #s 99677 996730 9953 9959 9955 Evaporator Motor / oil Motor Type Direct Drive Direct Drive Belt Belt Belt Indoor Nominal FM,800,800,800,800,800 Motor Speed Tap (ooling) T3 T3 -- -- -- Indoor Motor FLA (ooling) 6.90 6.90 3..5. Horsepower - PM -,050 -,050-760 - 760-760 Piston Size (ooling) 0.086 0.086 0.086 0.086 0.086 Filter Size (") (4) 4" x 0" x " (4) 4" x 0" x " (4) 4 x 0 x (4) 4 x 0 x (4) 4 x 0 x Drain Size (NPT) ¾" ¾" ¾" ¾" ¾" -40A efrigerant harge ir # (oz.) 00 00 00 00 00 Evaporator oil Face Area (ft²) 7.8 7.8 7.8 7.8 7.8 ows Deep / Fins per Inch 4/6 4/6 4 / 6 4 / 6 4 / 6 Belt Drive Evap Fan Data # of Wheels (D x W) ----- ----- (" x 0") (" x 0") (" x 0") Motor Sheave ----- ----- VL40 x ⅞ VL40 x ⅞ VL40 x ⅞ Blower Sheave / Belt ----- ----- AK6 x / AX5 AK6 x / AX5 AK6 x / AX5 ondenser Fan / oil Quantity of ondenser Fan Motors Horsepower - PM ¼ /,075 ¼ /,075 ¼ /,075 ¼ /,075 ¼ /,075 Fan Diameter/ # Fan Blades / 4 / 4 / 4 / 4 / 4 Outdoor Nominal FM 3,800 3,800 3,800 3,800 3,800 Face Area (ft²) 3 3 3.0 3.0 3.0 ows Deep/ Fins per Inch / 7 / 7 / 7 / 7 / 7 ompressor Quantity / Type/ Stage / Scroll/Single / Scroll/Single / Scroll/Single / Scroll/Single / Scroll/Single ompressor LA / LA 6.4 / 34.0 6.0 / 0.0 6 / 0 7.8 / 5 5.7 / 38.9 Electrical Data Voltage-Phase-Frequency 08/30--60 08/30-3-60 08/30-3-60 460-3-60 575-3-60 Indoor Blower HP / FLA.0 / 6.9.0 / 6.9.0 / 3..0 /.5.0 /. Max External Static 0.9" 0.9".0.0.0 Outdoor Fan HP / FLA ¼ /.40 ¼ /.40 ¼ /.40 ¼ / 0.70 ¼ / 0.55 Min. ircuit Ampacity¹ 4.3 / 4.3 8.3 / 8.3 4.6 / 4.6.9 8.9 Max. Overcurrent Protection (amps)² 60 / 60 40 / 40 40 / 40 5 5 Power Supply onduit Hole.5".5".5".5".5" Low-Voltage onduit Hole ½" ½" ½" ½" ½" Operating Weight (lbs) 570 570 570 570 570 Ship Weight (lbs) 595 595 595 595 595 ¹ Wire size should be determined in accordance with National Electrical odes. Extensive wire runs will require larger wire sizes. ² May use fuses or HA-type circuit breakers of the same size as noted. Notes Always check the S& plate for electrical data on the unit being installed. 6 www.daikinac.com SS-DS3
Expanded ooling Data 3 Tons Outdoor Ambient Temperature 65 F 75 F 85 F 95 F 05 F 5 F Entering Indoor Wet Bulb Temperature IDB Airflow 59 63 67 7 59 63 67 7 59 63 67 7 59 63 67 7 59 63 67 7 59 63 67 7 70 350 00 050 MBh 36.7 38. 4.7-35.9 37. 40.8-35.0 36.3 39.8-34. 35.4 38.8-3.5 33.7 36.9-30. 3. 34. - S/T 0.75 0.63 0.44-0.78 0.65 0.45-0.80 0.67 0.46-0.83 0.69 0.48-0.86 0.7 0.50-0.86 0.7 0.50 - Delta T 9 6-9 7 3-9 7 3-9 7 3-9 6-8 5 - KW.46.5.58 -.63.69.77 -.79.85.93 -.93.99 3.08-3.04 3.0 3.0-3.4 3. 3.3 - AMPS 7.3 7.5 7.7-7.9 8.0 8.3-8.5 8.7 8.9-9.0 9. 9.5-9.6 9.8 0. - 0. 0.3 0.6 - HI P 37 55 70-66 87 303-303 36 344-345 37 39-388 48 44-49 46 487 - LO P 9 30-8 5 37-3 30 4-9 37 49-35 43 57-39 48 6 - MBh 35.7 37.0 40.5-34.8 36. 39.6-34.0 35.3 38.6-33. 34.4 37.7-3.5 3.7 35.8-9. 30.3 33. - S/T 0.7 0.60 0.4-0.74 0.6 0.43-0.76 0.64 0.44-0.79 0.66 0.46-0.8 0.68 0.47-0.8 0.69 0.48 - Delta T 0 7 3-0 7 3-0 7 3-0 7 3-0 7 3-8 6 - KW.44.49.56 -.6.67.75 -.77.8.9 -.90.96 3.05-3.0 3.08 3.8-3. 3.8 3.8 - AMPS 7.3 7.4 7.7-7.8 8.0 8. - 8.4 8.6 8.9-9.0 9. 9.4-9.5 9.7 0.0-0.0 0. 0.6 - HI P 35 53 67-64 84 300-300 33 34-34 368 388-384 43 437-44 457 48 - LO P 0 8 8-7 4 36-9 4-7 36 48-34 4 55-38 47 60 - MBh 3.9 34. 37.4-3. 33.3 36.5-3.4 3.5 35.7-30.6 3.7 34.8-9. 30. 33.0-7.0 7.9 30.6 - S/T 0.69 0.58 0.40-0.7 0.60 0.4-0.74 0.6 0.43-0.76 0.63 0.44-0.79 0.66 0.46-0.80 0.66 0.46 - Delta T 0 7 3-0 7 3-0 8 3-0 8 3-0 7 3-9 6 - KW.39.43.50 -.56.6.68 -.70.76.84 -.84.89.98 -.95 3.0 3.0-3.04 3. 3.0 - AMPS 7. 7.3 7.5-7.6 7.8 8.0-8. 8.4 8.6-8.7 8.9 9. - 9. 9.4 9.7-9.7 0.0 0.3 - HI P 8 45 59-56 75 9-9 33 33-33 356 376-373 40 43-4 443 468 - LO P 07 4 4-3 0 3-8 5 37-4 3 44-30 38 50-34 43 56-75 350 00 050 MBh 37.4 38.5 4.6 44.7 36.5 37.6 40.7 43.7 35.6 36.7 39.7 4.6 34.8 35.8 38.7 4.6 33.0 34.0 36.8 39.5 30.6 3.5 34. 36.6 S/T 0.86 0.77 0.58 0.37 0.89 0.79 0.60 0.39 0.9 0.8 0.6 0.40 0.94 0.84 0.64 0.4 0.97 0.87 0.66 0.4 0.98 0.88 0.67 0.43 Delta T 0 6 0 7 0 7 0 7 0 7 0 9 5 KW.48.53.60.68.65.7.79.87.8.87.96 3.05.95 3.0 3.0 3.0 3.07 3.3 3.3 3.33 3.7 3.3 3.34 3.44 AMPS 7.4 7.6 7.8 8.0 7.9 8. 8.4 8.6 8.6 8.8 9.0 9.3 9. 9.3 9.6 9.9 9.6 9.9 0. 0.5 0. 0.4 0.7. HI P 40 58 7 84 69 89 306 39 306 39 348 363 348 375 396 43 39 4 445 465 433 466 49 53 LO P 3 0 3 39 9 7 38 47 4 3 44 53 30 38 5 6 36 45 58 69 4 50 64 74 MBh 36.3 37.4 40.4 43.4 35.4 36.5 39.5 4.4 34.6 35.6 38.5 4.4 33.7 34.7 37.6 40.4 3. 33.0 35.7 38.3 9.7 30.6 33. 35.5 S/T 0.8 0.73 0.55 0.36 0.85 0.76 0.57 0.37 0.87 0.78 0.59 0.38 0.90 0.80 0.6 0.39 0.93 0.83 0.63 0.40 0.94 0.84 0.63 0.4 Delta T 3 7 3 7 3 7 3 7 3 7 0 6 KW.46.5.58.66.63.69.77.85.79.85.93 3.0.93.99 3.08 3.8 3.04 3. 3.0 3.30 3.4 3. 3.3 3.4 AMPS 7.3 7.5 7.7 8.0 7.9 8. 8.3 8.6 8.5 8.7 8.9 9.3 9.0 9. 9.5 9.9 9.6 9.8 0. 0.4 0. 0.3 0.6.0 HI P 37 55 70 8 66 87 303 36 303 36 344 359 345 37 39 409 388 48 44 460 49 46 487 508 LO P 9 30 38 8 5 37 46 3 30 4 5 9 37 49 59 35 44 57 67 40 48 6 73 MBh 33.5 34.5 37.3 40.0 3.7 33.7 36.4 39. 3.9 3.9 35.6 38. 3. 3. 34.7 37.3 9.6 30.5 33.0 35.4 7.4 8. 30.5 3.8 S/T 0.79 0.70 0.53 0.34 0.8 0.73 0.55 0.36 0.84 0.75 0.57 0.36 0.86 0.77 0.58 0.38 0.90 0.80 0.6 0.39 0.90 0.8 0.6 0.39 Delta T 3 7 3 8 3 8 4 8 3 8 0 6 KW.4.45.5.60.58.63.70.79.73.78.86.95.86.9 3.0 3.0.97 3.03 3.3 3. 3.07 3.3 3.3 3.33 AMPS 7. 7.3 7.5 7.8 7.7 7.9 8. 8.4 8.3 8.5 8.7 9.0 8.8 9.0 9.3 9.6 9.3 9.5 9.8 0. 9.8 0. 0.4 0.7 HI P 30 48 6 73 58 78 94 306 94 36 334 348 335 360 380 397 376 405 48 446 46 448 473 493 LO P 08 5 6 34 4 33 4 9 6 38 47 5 33 45 54 3 39 5 6 35 44 57 67 IDB = Entering Indoor Dry Bulb Temperature Shaded area reflects AA (TVA) conditions kw = Total system power High and low pressures are measured at the liquid and suction service ports. Amps: Unit amps (comp.+ evaporator + condenser fan motors) SS-DS3 www.daikinac.com 7
Expanded ooling Data 3 Tons (cont.) Outdoor Ambient Temperature 65 F 75 F 85 F 95 F 05 F 5 F Entering Indoor Wet Bulb Temperature IDB Airflow 59 63 67 7 59 63 67 7 59 63 67 7 59 63 67 7 59 63 67 7 59 63 67 7 80 350 00 050 MBh 38.0 38.9 4.5 44.4 37. 38.0 40.6 43.3 36.3 37. 39.6 4.3 35.4 36. 38.6 4.3 33.6 34.3 36.7 39. 3. 3.8 34.0 36.3 S/T 0.94 0.88 0.7 0.54.00 0.9 0.74 0.56.00 0.94 0.76 0.57.00 0.97 0.79 0.59.00.00 0.8 0.6.00.00 0.8 0.6 Delta T 4 3 0 6 5 4 6 5 4 6 4 4 7 3 3 0 6 9 5 KW.50.55.6.70.67.73.8.90.83.89.98 3.07.97 3.03 3.3 3.3 3.09 3.5 3.5 3.36 3.9 3.6 3.36 3.47 AMPS 7.5 7.6 7.9 8. 8.0 8. 8.4 8.7 8.6 8.8 9. 9.4 9. 9.4 9.7 0.0 9.7 0.0 0.3 0.6 0.3 0.5 0.8. HI P 4 6 75 87 7 9 309 3 309 333 35 366 35 379 400 47 396 46 450 469 437 47 497 59 LO P 4 3 4 0 8 40 49 5 33 45 55 3 40 53 6 38 46 60 70 4 5 65 76 MBh 36.9 37.7 40.3 43. 36. 36.9 39.4 4. 35. 36.0 38.4 4. 34.3 35. 37.5 40. 3.6 33.3 35.6 38. 30. 30.9 33.0 35.3 S/T 0.90 0.84 0.68 0.5 0.93 0.87 0.7 0.53 0.95 0.89 0.73 0.54 0.98 0.9 0.75 0.56.00 0.96 0.78 0.58.00 0.96 0.78 0.59 Delta T 5 4 7 6 5 7 6 5 7 6 5 7 5 4 7 3 3 0 6 KW.48.53.60.68.65.7.79.87.8.87.96 3.05.95 3.0 3.0 3.0 3.07 3.3 3.3 3.33 3.7 3.3 3.34 3.44 AMPS 7.4 7.6 7.8 8.0 7.9 8. 8.4 8.6 8.6 8.8 9.0 9.3 9. 9.3 9.6 9.9 9.6 9.9 0. 0.5 0. 0.4 0.7. HI P 40 58 7 84 69 90 306 39 306 39 348 363 348 375 396 43 39 4 446 465 433 466 49 53 LO P 3 0 3 39 9 7 38 47 4 3 44 53 30 38 5 6 36 45 58 69 4 50 64 74 MBh 34. 34.8 37. 39.8 33.3 34.0 36.3 38.8 3.5 33. 35.5 37.9 3.7 3.4 34.6 37.0 30. 30.8 3.9 35. 7.9 8.5 30.5 3.6 S/T 0.86 0.8 0.66 0.49 0.90 0.84 0.68 0.5 0.9 0.86 0.70 0.5 0.95 0.89 0.7 0.54 0.98 0.9 0.75 0.56 0.99 0.93 0.76 0.57 Delta T 6 5 7 6 5 7 6 5 7 6 5 8 6 5 7 4 3 0 6 KW.4.47.54.6.59.65.73.8.75.80.89.98.88.94 3.03 3..99 3.06 3.5 3.5 3.09 3.6 3.6 3.36 AMPS 7. 7.4 7.6 7.9 7.7 7.9 8. 8.4 8.4 8.5 8.8 9. 8.9 9. 9.4 9.7 9.4 9.6 9.9 0.3 9.9 0. 0.5 0.8 HI P 33 50 64 76 6 8 97 309 97 39 337 35 338 364 384 40 380 409 43 45 40 45 477 498 LO P 09 6 7 35 6 3 34 43 0 8 39 49 6 34 46 56 3 4 54 63 37 45 59 69 85 350 00 050 MBh 38.7 39.4 4.3 44. 37.8 38.5 40.3 43.0 36.9 37.6 39.4 4.0 36.0 36.7 38.4 4.0 34. 34.9 36.5 38.9 3.7 3.3 33.8 36. S/T 0.98 0.95 0.86 0.70.00 0.98 0.89 0.7.00.00 0.9 0.74.00.00 0.94 0.76.00.00 0.98 0.79.00.00 0.98 0.80 Delta T 6 6 4 6 6 4 5 6 4 5 5 5 3 4 4 3 0 KW.5.56.64.7.69.75.83.9.85.9 3.00 3.0.99 3.06 3.5 3.5 3. 3.8 3.8 3.38 3. 3.9 3.39 3.50 AMPS 7.5 7.7 7.9 8. 8. 8.3 8.5 8.8 8.7 8.9 9. 9.5 9.3 9.5 9.8 0. 9.8 0.0 0.4 0.7 0.4 0.6 0.9.3 HI P 45 63 78 90 74 95 3 35 3 336 355 370 355 383 404 4 400 430 454 474 44 476 50 54 LO P 5 34 4 9 4 50 6 34 47 56 33 4 54 64 39 48 6 7 44 53 67 78 MBh 37.6 38.3 40. 4.8 36.7 37.4 39. 4.8 35.8 36.5 38. 40.8 34.9 35.6 37.3 39.8 33. 33.8 35.4 37.8 30.8 3.3 3.8 35.0 S/T 0.94 0.9 0.8 0.66 0.97 0.94 0.85 0.69.00 0.96 0.87 0.7.00 0.99 0.90 0.73.00.00 0.93 0.76.00.00 0.94 0.76 Delta T 7 7 5 7 7 5 7 7 5 7 7 6 5 6 5 4 4 4 0 KW.50.55.6.70.67.73.8.90.83.89.98 3.07.97 3.03 3.3 3.3 3.09 3.5 3.5 3.36 3.9 3.6 3.36 3.47 AMPS 7.5 7.6 7.9 8. 8.0 8. 8.4 8.7 8.6 8.8 9. 9.4 9. 9.4 9.7 0.0 9.7 0.0 0.3 0.6 0.3 0.5 0.8. HI P 4 6 75 87 7 9 309 3 309 333 35 366 35 379 400 47 396 46 450 469 437 47 497 59 LO P 4 3 4 0 8 40 49 5 33 45 55 3 40 53 6 38 46 60 70 4 5 65 76 MBh 34.7 35.3 37.0 39.5 33.9 34.5 36. 38.6 33. 33.7 35.3 37.7 3.3 3.9 34.4 36.7 30.6 3. 3.7 34.9 8.4 8.9 30.3 3.3 S/T 0.9 0.87 0.79 0.64 0.94 0.9 0.8 0.66 0.96 0.93 0.84 0.68 0.99 0.96 0.86 0.70.00 0.99 0.90 0.73.00.00 0.9 0.73 Delta T 7 7 6 8 7 6 8 7 6 8 8 6 3 7 7 6 5 5 4 KW.44.49.56.64.6.67.75.83.77.8.9 3.00.90.96 3.05 3.5 3.0 3.08 3.8 3.8 3. 3.8 3.8 3.39 AMPS 7.3 7.4 7.7 7.9 7.8 8.0 8. 8.5 8.4 8.6 8.9 9. 9.0 9. 9.4 9.8 9.5 9.7 0.0 0.3 0.0 0. 0.6 0.9 HI P 35 53 67 78 64 84 300 3 300 33 34 355 34 367 388 405 384 43 436 455 44 457 48 503 LO P 0 7 8 37 7 4 36 44 9 4 50 7 36 48 58 33 4 55 65 38 47 60 7 IDB = Entering Indoor Dry Bulb Temperature Shaded area reflects AHI atings conditions kw = Total system power High and low pressures are measured at the liquid and suction service ports. Amps: Unit amps (comp.+ evaporator + condenser fan motors) 8 www.daikinac.com SS-DS3
Expanded ooling Data 4 Tons Outdoor Ambient Temperature 65 F 75 F 85 F 95 F 05 F 5 F Entering Indoor Wet Bulb Temperature IDB Airflow 59 63 67 7 59 63 67 7 59 63 67 7 59 63 67 7 59 63 67 7 59 63 67 7 70 800 600 400 MBh 46.0 47.7 5.3-45.0 46.6 5. - 43.9 45.5 49.9-4.8 44.4 48.6-40.7 4. 46. - 37.7 39. 4.8 - S/T 0.77 0.64 0.45-0.80 0.67 0.46-0.8 0.68 0.47-0.84 0.70 0.49-0.88 0.73 0.5-0.88 0.74 0.5 - Delta T 8 6-8 6-8 6-8 6-8 6-7 5 - KW 3.0 3.7 3.6-3.33 3.40 3.50-3.53 3.60 3.7-3.7 3.78 3.90-3.86 3.94 4.06-3.99 4.07 4.0 - AMPS 8. 8.3 8.6-8.7 8.9 9. - 9.4 9.7 0.0-0. 0.3 0.6-0.7 0.9. -.3.5.9 - HI P 40 59 73-70 90 306-307 330 348-349 376 397-393 43 447-434 467 493 - LO P 9 30-8 6 38-3 3 43-9 38 50-35 44 57-40 49 63 - MBh 44.7 46.3 50.8-43.7 45.3 49.6-4.6 44. 48.4-4.6 43. 47. - 39.5 40.9 44.9-36.6 37.9 4.6 - S/T 0.73 0.6 0.4-0.76 0.64 0.44-0.78 0.65 0.45-0.80 0.67 0.47-0.84 0.70 0.48-0.84 0.70 0.49 - Delta T 9 6-9 7 3-9 7 3-9 7 3-9 6-8 5 - KW 3.08 3.4 3.4-3.3 3.37 3.48-3.50 3.58 3.69-3.68 3.75 3.87-3.83 3.9 4.03-3.95 4.04 4.7 - AMPS 8. 8.3 8.5-8.7 8.9 9. - 9.4 9.6 9.9-0.0 0. 0.5-0.6 0.8. -..4.8 - HI P 38 56 70-67 87 303-304 37 345-346 37 393-389 49 44-430 463 488 - LO P 8 9-7 5 36-30 4-8 36 49-34 43 56-39 48 6 - MBh 4.3 4.8 46.9-40.3 4.8 45.8-39.3 40.8 44.7-38.4 39.8 43.6-36.5 37.8 4.4-33.8 35.0 38.4 - S/T 0.7 0.59 0.4-0.73 0.6 0.4-0.75 0.63 0.44-0.78 0.65 0.45-0.8 0.67 0.47-0.8 0.68 0.47 - Delta T 9 7 3-9 7 3-9 7 3-0 7 3-9 7 3-8 6 - KW 3.0 3.07 3.6-3.3 3.30 3.39-3.4 3.49 3.60-3.59 3.67 3.78-3.73 3.8 3.93-3.86 3.94 4.07 - AMPS 7.9 8.0 8.3-8.5 8.6 8.9-9. 9.3 9.6-9.7 9.9 0. - 0.3 0.5 0.9-0.9..5 - HI P 3 48 6-59 79 94-95 37 335-335 36 38-377 406 49-47 449 474 - LO P 08 5 5-4 3-8 6 37-4 3 44-30 38 5-35 43 56-75 800 600 400 MBh 46.8 48. 5. 56.0 45.7 47. 5.0 54.7 44.6 46.0 49.8 53.4 43.6 44.8 48.5 5. 4.4 4.6 46. 49.5 38.3 39.5 4.7 45.8 S/T 0.87 0.78 0.59 0.38 0.9 0.8 0.6 0.39 0.93 0.83 0.63 0.40 0.96 0.86 0.65 0.4.00 0.89 0.67 0.43.00 0.90 0.68 0.44 Delta T 9 6 9 6 0 6 0 6 9 6 0 8 5 0 KW 3.3 3.9 3.9 3.39 3.36 3.43 3.53 3.64 3.56 3.63 3.75 3.86 3.74 3.8 3.94 4.06 3.89 3.97 4.0 4.3 4.0 4.0 4.4 4.37 AMPS 8. 8.4 8.6 8.9 8.8 9.0 9.3 9.6 9.5 9.7 0.0 0.4 0. 0.4 0.7. 0.8.0.4.8.4.6.0.4 HI P 43 6 76 88 7 93 30 33 30 333 35 367 353 380 40 48 397 47 45 470 439 47 498 50 LO P 3 0 3 40 0 7 39 48 4 3 44 54 3 39 5 6 37 46 59 69 4 5 64 75 MBh 45.5 46.8 50.7 54.4 44.4 45.7 49.5 53. 43.3 44.6 48.3 5.8 4.3 43.5 47. 50.6 40. 4.4 44.8 48. 37. 38.3 4.5 44.5 S/T 0.83 0.75 0.56 0.36 0.86 0.77 0.59 0.38 0.89 0.79 0.60 0.39 0.9 0.8 0.6 0.40 0.95 0.85 0.64 0.4 0.96 0.86 0.65 0.4 Delta T 0 6 0 7 0 7 0 7 0 7 0 9 5 KW 3. 3.7 3.6 3.36 3.33 3.40 3.50 3.6 3.53 3.60 3.7 3.83 3.7 3.79 3.90 4.03 3.86 3.94 4.06 4.0 3.99 4.07 4.0 4.34 AMPS 8. 8.3 8.6 8.9 8.7 8.9 9. 9.5 9.4 9.7 0.0 0.3 0. 0.3 0.6.0 0.7 0.9.3.7.3.5.9.3 HI P 40 59 73 85 70 90 306 30 307 330 349 364 349 376 397 44 393 43 447 466 434 467 493 55 LO P 9 30 39 8 6 38 47 3 3 43 5 9 38 50 60 36 44 57 68 40 49 63 73 MBh 4.0 43. 46.8 50. 4.0 4. 45.7 49.0 40.0 4. 44.6 47.9 39.0 40. 43.5 46.7 37. 38. 4.3 44.4 34.3 35.4 38.3 4. S/T 0.80 0.7 0.54 0.35 0.83 0.75 0.56 0.36 0.85 0.76 0.58 0.37 0.88 0.79 0.60 0.38 0.9 0.8 0.6 0.40 0.9 0.83 0.63 0.40 Delta T 0 7 7 7 3 7 7 9 6 KW 3.04 3.0 3.9 3.8 3.5 3.3 3.4 3.53 3.45 3.5 3.63 3.74 3.6 3.69 3.8 3.93 3.76 3.84 3.97 4.09 3.89 3.97 4.0 4.3 AMPS 7.9 8. 8.4 8.6 8.5 8.7 9.0 9.3 9. 9.4 9.7 0.0 9.8 0.0 0.3 0.7 0.4 0.6.0.3.0..6.0 HI P 33 5 65 76 6 8 97 30 98 30 338 353 339 365 385 40 38 40 433 45 4 453 479 499 LO P 09 6 6 35 5 33 4 9 7 39 48 5 33 46 55 3 40 53 63 36 45 58 68 IDB = Entering Indoor Dry Bulb Temperature Shaded area reflects AA (TVA) conditions kw = Total system power High and low pressures are measured at the liquid and suction service ports. Amps: Unit amps (comp.+ evaporator + condenser fan motors) SS-DS3 www.daikinac.com 9
Expanded ooling Data 4 Tons (cont.) Outdoor Ambient Temperature 65 F 75 F 85 F 95 F 05 F 5 F Entering Indoor Wet Bulb Temperature IDB Airflow 59 63 67 7 59 63 67 7 59 63 67 7 59 63 67 7 59 63 67 7 59 63 67 7 80 800 600 400 MBh 47.7 48.7 5.0 55.6 46.5 47.6 50.8 54.3 45.4 46.4 49.6 53.0 44.3 45.3 48.4 5.7 4. 43.0 46.0 49. 39.0 39.9 4.6 45.5 S/T 0.96 0.90 0.73 0.55.00 0.93 0.76 0.57.00 0.96 0.78 0.58.00.00 0.80 0.60.00.00 0.83 0.6.00.00 0.84 0.63 Delta T 3 9 6 4 3 0 6 3 3 0 6 3 3 0 6 0 6 0 0 8 5 KW 3.5 3. 3.3 3.4 3.38 3.45 3.56 3.67 3.59 3.66 3.78 3.90 3.77 3.85 3.97 4.0 3.9 4.00 4.3 4.6 4.05 4.4 4.7 4.4 AMPS 8.3 8.5 8.7 9.0 8.9 9. 9.4 9.7 9.6 9.8 0. 0.5 0. 0.5 0.8. 0.8..5.9.5.7..5 HI P 45 64 79 9 75 96 33 36 33 337 356 37 356 384 405 4 40 43 456 475 443 477 503 55 LO P 4 33 4 9 40 49 6 34 46 55 3 40 53 63 38 47 6 7 43 5 66 77 MBh 46.3 47.3 50.5 54.0 45. 46. 49.3 5.7 44. 45. 48. 5.5 43.0 44.0 47.0 50. 40.9 4.8 44.6 47.7 37.9 38.7 4.3 44. S/T 0.9 0.86 0.70 0.5 0.95 0.89 0.7 0.54 0.97 0.9 0.74 0.55.00 0.94 0.77 0.57.00 0.98 0.80 0.59.00 0.98 0.80 0.60 Delta T 4 3 0 6 5 4 6 5 4 6 5 4 7 3 3 0 6 9 5 KW 3.3 3.9 3.9 3.39 3.36 3.43 3.53 3.64 3.56 3.63 3.75 3.87 3.74 3.8 3.94 4.06 3.89 3.97 4.0 4.3 4.0 4.0 4.4 4.38 AMPS 8. 8.4 8.6 8.9 8.8 9.0 9.3 9.6 9.5 9.7 0.0 0.4 0. 0.4 0.7. 0.8.0.4.8.4.6.0.4 HI P 43 6 76 88 7 93 30 33 30 333 35 367 353 380 40 48 397 47 45 47 439 47 498 50 LO P 3 0 3 40 0 7 39 48 4 3 44 54 3 39 5 6 37 46 59 69 4 5 64 75 MBh 4.7 43.6 46.6 49.8 4.7 4.6 45.5 48.7 40.7 4.6 44.5 47.5 39.7 40.6 43.4 46.4 37.7 38.6 4. 44.0 35.0 35.7 38. 40.8 S/T 0.88 0.83 0.67 0.50 0.9 0.86 0.70 0.5 0.94 0.88 0.7 0.53 0.97 0.9 0.74 0.55.00 0.94 0.77 0.57.0 0.95 0.77 0.58 Delta T 5 4 6 5 4 7 5 4 7 5 4 7 5 4 7 3 9 5 KW 3.06 3. 3. 3.3 3.8 3.35 3.45 3.56 3.48 3.55 3.66 3.77 3.65 3.7 3.84 3.96 3.79 3.88 4.00 4.3 3.9 4.00 4.3 4.7 AMPS 8.0 8. 8.4 8.7 8.6 8.8 9. 9.4 9.3 9.5 9.8 0. 9.9 0. 0.4 0.8 0.5 0.7..4..3.7. HI P 35 53 68 79 64 84 300 33 30 33 34 356 34 368 389 406 385 44 438 456 45 458 483 504 LO P 0 7 8 36 6 3 35 44 8 40 49 7 35 47 57 33 4 54 64 37 46 60 70 85 800 600 400 MBh 48.5 49.4 5.8 55. 47.4 48.3 50.6 53.9 46. 47. 49.4 5.7 45. 46.0 48. 5.4 4.8 43.7 45.7 48.8 39.7 40.5 4.4 45. S/T.00 0.97 0.88 0.7.00.00 0.9 0.74.00.00 0.93 0.76.00.00 0.96 0.78.00.00.00 0.8.00.00.00 0.8 Delta T 5 4 3 0 4 5 3 0 4 4 3 0 3 3 4 0 3 0 0 9 KW 3.8 3.4 3.34 3.44 3.4 3.48 3.59 3.70 3.6 3.69 3.8 3.93 3.80 3.88 4.00 4.3 3.95 4.04 4.6 4.30 4.08 4.7 4.3 4.45 AMPS 8.3 8.5 8.8 9. 9.0 9. 9.5 9.8 9.7 9.9 0. 0.6 0.3 0.6 0.9.3 0.9..6.0.6.8..6 HI P 48 67 8 94 78 99 36 39 36 340 359 375 360 387 409 47 405 436 460 480 447 48 508 530 LO P 6 3 34 43 30 4 5 7 35 47 57 33 4 55 65 40 49 6 73 44 54 68 79 MBh 47. 48.0 50.3 53.6 46.0 46.9 49. 5.4 44.9 45.8 47.9 5. 43.8 44.6 46.8 49.9 4.6 4.4 44.4 47.4 38.5 39.3 4. 43.9 S/T 0.96 0.93 0.84 0.68 0.99 0.96 0.87 0.70.00 0.98 0.89 0.7.00.00 0.9 0.74.00.00 0.95 0.77.00.00 0.96 0.78 Delta T 6 6 4 6 6 4 6 6 4 5 6 5 4 4 4 3 3 0 KW 3.5 3. 3.3 3.4 3.38 3.45 3.56 3.67 3.59 3.66 3.78 3.90 3.77 3.85 3.97 4.0 3.9 4.00 4.3 4.6 4.05 4.4 4.7 4.4 AMPS 8.3 8.5 8.7 9.0 8.9 9. 9.4 9.7 9.6 9.8 0. 0.5 0. 0.5 0.8. 0.8..5.9.5.7..5 HI P 45 64 79 9 75 96 33 36 33 337 356 37 356 384 405 4 40 43 456 475 443 477 503 55 LO P 4 33 4 9 40 49 6 34 46 55 3 40 53 63 38 47 6 7 43 5 66 77 MBh 43.5 44.3 46.4 49.5 4.4 43.3 45.3 48.3 4.4 4. 44. 47. 40.4 4. 43. 46.0 38.4 39. 4.0 43.7 35.6 36.3 38.0 40.5 S/T 0.9 0.89 0.8 0.65 0.96 0.9 0.83 0.68 0.98 0.95 0.86 0.69.00 0.98 0.88 0.7.00.00 0.9 0.74.00.00 0.9 0.75 Delta T 6 6 5 7 6 5 7 6 5 7 6 5 5 6 5 3 4 3 0 KW 3.08 3.4 3.4 3.33 3.30 3.37 3.48 3.58 3.50 3.58 3.69 3.80 3.68 3.75 3.87 4.00 3.8 3.9 4.03 4.6 3.95 4.04 4.7 4.30 AMPS 8. 8. 8.5 8.8 8.7 8.9 9. 9.5 9.4 9.6 9.9 0. 0.0 0. 0.5 0.9 0.6 0.8..5..4.8. HI P 38 56 70 8 67 87 303 36 304 37 345 360 346 37 393 40 389 49 44 46 430 46 488 509 LO P 8 9 37 7 5 36 45 30 4 5 8 36 49 58 34 43 56 66 39 48 6 7 IDB = Entering Indoor Dry Bulb Temperature Shaded area reflects AHI atings conditions kw = Total system power High and low pressures are measured at the liquid and suction service ports. Amps: Unit amps (comp.+ evaporator + condenser fan motors) 0 www.daikinac.com SS-DS3
Expanded ooling Data 5 Tons Outdoor Ambient Temperature 65 F 75 F 85 F 95 F 05 F 5 F Entering Indoor Wet Bulb Temperature IDB Airflow 59 63 67 7 59 63 67 7 59 63 67 7 59 63 67 7 59 63 67 7 59 63 67 7 70 050 800 550 MBh 57.6 59.7 65.4-56.3 58.3 63.9-54.9 56.9 6.4-53.6 55.6 60.9-50.9 5.8 57.8-47. 48.9 53.6 - S/T 0.74 0.6 0.43-0.77 0.64 0.44-0.78 0.66 0.45-0.8 0.68 0.47-0.84 0.70 0.49-0.85 0.7 0.49 - Delta T 9 7 3-9 7 3-9 7 3-9 7 3-9 7 3-8 6 - KW 3.95 4.04 4.7-4.6 4.35 4.49-4.53 4.63 4.78-4.77 4.87 5.04-4.97 5.08 5.5-5.5 5.6 5.44 - AMPS 0. 0.4 0.7 -.0..6 -.9..6 -.7 3.0 3.5-3.5 3.9 4.3-4.3 4.7 5. - HI P 57 77 9-89 3 38-38 353 373-374 403 45-4 453 478-465 500 58 - LO P 07 4 4-3 0 3-7 5 36-3 3 43-9 37 50-34 4 55 - MBh 55.9 58.0 63.5-54.6 56.6 6.0-53.3 55.3 60.6-5.0 53.9 59. - 49.4 5. 56. - 45.8 47.5 5.0 - S/T 0.70 0.59 0.4-0.73 0.6 0.4-0.75 0.6 0.43-0.77 0.65 0.45-0.80 0.67 0.46-0.8 0.68 0.47 - Delta T 0 7 3-0 8 3-0 8 3-8 3-0 8 3-9 6 - KW 3.9 4.00 4.3-4. 4.3 4.46-4.49 4.59 4.74-4.73 4.83 4.99-4.93 5.04 5. - 5.0 5. 5.39 - AMPS 0. 0.3 0.6-0.9..5 -.8..5 -.6.9 3.4-3.4 3.7 4. - 4. 4.6 5. - HI P 55 74 90-86 308 35-35 350 370-370 399 4-47 448 474-460 495 53 - LO P 06 3 3-9 30-6 4 35-30 4-8 36 49-3 4 54 - MBh 5.6 53.5 58.6-50.4 5.3 57.3-49. 5.0 55.9-48.0 49.8 54.5-45.6 47.3 5.8-4.3 43.8 48.0 - S/T 0.68 0.57 0.39-0.70 0.59 0.4-0.7 0.60 0.4-0.74 0.6 0.43-0.77 0.65 0.45-0.78 0.65 0.45 - Delta T 8 4-8 4-8 4-8 4-8 4-0 7 3 - KW 3.83 3.9 4.03-4. 4. 4.35-4.38 4.48 4.6-4.6 4.7 4.87-4.8 4.9 5.08-4.97 5.09 5.6 - AMPS 9.8 0.0 0.4-0.6 0.8. -.5.8. -.3.6 3.0-3. 3.4 3.8-3.8 4. 4.6 - HI P 47 66 8-77 98 35-35 339 358-359 387 408-404 435 459-447 48 507 - LO P 03 09 9-08 5 6-3 0 3-8 6 37-4 3 44-8 36 49-75 050 800 550 MBh 58.6 60.3 65.3 70. 57. 58.9 63.8 68.5 55.9 57.5 6.3 66.8 54.5 56. 60.7 65. 5.8 53.3 57.7 6.9 48.0 49.4 53.5 57.4 S/T 0.84 0.75 0.57 0.37 0.87 0.78 0.59 0.38 0.89 0.80 0.60 0.39 0.9 0.8 0.6 0.40 0.96 0.85 0.65 0.4 0.96 0.86 0.65 0.4 Delta T 0 7 7 7 3 7 0 7 9 6 KW 3.98 4.07 4.0 4.34 4.9 4.39 4.53 4.68 4.57 4.67 4.8 4.98 4.8 4.9 5.08 5.5 5.0 5.3 5.30 5.48 5.9 5.3 5.49 5.68 AMPS 0.3 0.5 0.8...3.7..0.3.7 3..8 3. 3.6 4. 3.7 4.0 4.5 5.0 4.5 4.8 5.3 5.9 HI P 60 80 95 308 9 34 33 346 33 357 377 393 378 407 49 448 45 458 483 504 470 506 534 557 LO P 08 5 5 34 4 3 4 9 6 38 47 4 3 45 54 30 39 5 6 35 44 57 67 MBh 56.9 58.6 63.4 68.0 55.6 57. 6.9 66.5 54. 55.8 60.5 64.9 5.9 54.5 59.0 63.3 50.3 5.8 56.0 60. 46.6 47.9 5.9 55.7 S/T 0.80 0.7 0.54 0.35 0.83 0.74 0.56 0.36 0.85 0.76 0.58 0.37 0.88 0.79 0.59 0.38 0.9 0.8 0.6 0.40 0.9 0.8 0.6 0.40 Delta T 3 8 4 8 4 8 4 8 3 8 0 6 KW 3.95 4.04 4.7 4.30 4.6 4.35 4.49 4.64 4.53 4.63 4.78 4.94 4.77 4.88 5.04 5. 4.97 5.08 5.5 5.43 5.5 5.6 5.44 5.63 AMPS 0. 0.4 0.7..0..6.0.9..6 3..7 3.0 3.5 4.0 3.5 3.9 4.3 4.9 4.3 4.7 5. 5.8 HI P 57 77 93 305 89 3 38 34 39 354 373 389 374 403 45 443 4 453 478 499 465 50 59 55 LO P 07 4 4 3 3 0 3 40 7 5 36 45 3 3 43 5 9 37 50 60 34 4 55 65 MBh 5.5 54. 58.5 6.8 5.3 5.8 57. 6.3 50. 5.5 55.8 59.9 48.8 50.3 54.4 58.4 46.4 47.8 5.7 55.5 43.0 44.3 47.9 5.4 S/T 0.77 0.69 0.5 0.34 0.80 0.7 0.54 0.35 0.8 0.73 0.56 0.36 0.85 0.76 0.57 0.37 0.88 0.79 0.59 0.38 0.89 0.79 0.60 0.39 Delta T 4 8 3 4 8 3 4 8 3 5 3 9 3 4 8 3 3 7 KW 3.86 3.94 4.06 4.0 4.6 4.5 4.38 4.53 4.4 4.5 4.66 4.8 4.65 4.75 4.9 5.07 4.85 4.96 5. 5.9 5.0 5.3 5.30 5.48 AMPS 9.9 0. 0.5 0.8 0.7 0.9.3.7.6.9.3.7.4.7 3. 3.6 3. 3.5 3.9 4.5 4.0 4.3 4.8 5.3 HI P 50 69 84 96 80 30 38 33 39 343 36 378 363 39 4 430 408 439 464 484 45 486 53 535 LO P 04 0 0 8 0 7 7 35 4 3 4 0 7 39 48 5 33 46 55 30 38 5 60 IDB = Entering Indoor Dry Bulb Temperature Shaded area reflects AA (TVA) conditions kw = Total system power High and low pressures are measured at the liquid and suction service ports. Amps: Unit amps (comp.+ evaporator + condenser fan motors) SS-DS3 www.daikinac.com
Expanded ooling Data 5 Tons (cont.) Outdoor Ambient Temperature 65 F 75 F 85 F 95 F 05 F 5 F Entering Indoor Wet Bulb Temperature IDB Airflow 59 63 67 7 59 63 67 7 59 63 67 7 59 63 67 7 59 63 67 7 59 63 67 7 80 050 800 550 MBh 59.6 60.9 65. 69.6 58.3 59.5 63.6 68.0 56.9 58. 6. 66.4 55.5 56.7 60.6 64.7 5.7 53.9 57.5 6.5 48.8 49.9 53.3 57.0 S/T 0.9 0.86 0.70 0.53 0.95 0.89 0.73 0.54.00 0.9 0.75 0.56.00 0.95 0.77 0.58.00.00 0.80 0.60.00.00 0.8 0.60 Delta T 5 4 6 5 4 7 6 4 7 5 4 7 4 4 6 9 5 KW 4.0 4.0 4.3 4.37 4.33 4.4 4.57 4.7 4.6 4.7 4.86 5.03 4.85 4.96 5. 5.30 5.06 5.7 5.34 5.53 5.4 5.35 5.53 5.7 AMPS 0.3 0.6 0.9.3..4.8.3..4.8 3.3 3.0 3.3 3.7 4. 3.8 4. 4.6 5. 4.6 5.0 5.5 6. HI P 63 83 98 3 95 37 335 349 335 36 38 397 38 4 434 45 49 46 488 509 475 5 539 56 LO P 09 6 7 35 5 3 34 4 0 7 39 48 6 34 46 56 3 40 53 63 36 45 58 69 MBh 57.9 59. 63. 67.6 56.6 57.8 6.7 66.0 55. 56.4 60.3 64.4 53.9 55.0 58.8 6.9 5. 5.3 55.9 59.7 47.4 48.4 5.7 55.3 S/T 0.88 0.8 0.67 0.50 0.9 0.85 0.69 0.5 0.93 0.87 0.7 0.53 0.96 0.90 0.74 0.55.00 0.94 0.76 0.57.00 0.95 0.77 0.57 Delta T 6 5 7 6 5 7 6 5 8 6 5 8 6 5 7 4 3 0 6 KW 3.98 4.07 4.0 4.34 4.9 4.39 4.53 4.68 4.57 4.67 4.8 4.98 4.8 4.9 5.08 5.5 5.0 5.3 5.30 5.48 5.9 5.3 5.49 5.68 AMPS 0.3 0.5 0.8...3.7..0.3.7 3..9 3. 3.6 4. 3.7 4.0 4.5 5.0 4.5 4.8 5.3 5.9 HI P 60 80 95 308 9 34 33 346 33 357 377 393 378 407 430 448 45 458 483 504 470 506 534 557 LO P 08 5 5 34 4 3 4 9 6 38 47 5 3 45 54 30 39 5 6 35 44 57 67 MBh 53.4 54.6 58.3 6.4 5. 53.3 57.0 60.9 5.0 5. 55.6 59.5 49.7 50.8 54.3 58.0 47. 48.3 5.6 55. 43.7 44.7 47.8 5. S/T 0.85 0.79 0.65 0.48 0.88 0.8 0.67 0.50 0.90 0.84 0.69 0.5 0.93 0.87 0.7 0.53 0.96 0.90 0.74 0.55 0.97 0.9 0.74 0.55 Delta T 7 6 8 7 6 3 8 7 6 3 8 7 6 3 8 7 6 8 5 4 7 KW 3.89 3.97 4.0 4.3 4.9 4.8 4.4 4.56 4.45 4.55 4.70 4.86 4.69 4.79 4.95 5. 4.89 5.00 5.6 5.34 5.06 5.7 5.35 5.53 AMPS 0.0 0. 0.5 0.9 0.8.0.4.8.7.0.4.8.5.8 3. 3.7 3.3 3.6 4. 4.6 4. 4.4 4.9 5.5 HI P 5 7 87 99 83 305 3 335 3 346 366 38 367 395 47 435 4 444 469 489 456 490 58 540 LO P 05 30 8 8 37 5 34 4 8 40 49 7 35 47 57 3 39 5 6 85 050 800 550 MBh 60.7 6.9 64.8 69. 59.3 60.4 63.3 67.5 57.9 59.0 6.8 65.9 56.4 57.5 60.3 64.3 53.6 54.7 57. 6. 49.7 50.6 53.0 56.6 S/T 0.96 0.93 0.84 0.68.00 0.96 0.87 0.7.00 0.99 0.89 0.7.00.00 0.9 0.75.00.00 0.96 0.78.00.00 0.96 0.78 Delta T 6 6 4 7 6 5 6 6 5 5 6 5 4 5 5 3 3 0 KW 4.05 4.4 4.7 4.4 4.37 4.46 4.6 4.76 4.64 4.75 4.90 5.07 4.89 5.00 5.7 5.34 5.0 5. 5.39 5.57 5.8 5.40 5.58 5.77 AMPS 0.4 0.7.0.4.3.5.9.4..5 3.0 3.4 3. 3.4 3.9 4.4 3.9 4.3 4.7 5.3 4.8 5. 5.6 6. HI P 65 85 30 34 98 30 338 353 339 364 385 40 386 45 438 457 434 467 493 54 479 56 545 568 LO P 0 7 8 36 6 4 35 44 9 40 50 7 35 48 57 33 4 55 65 38 46 60 70 MBh 58.9 60. 6.9 67. 57.5 58.7 6.4 65.5 56. 57.3 60.0 64.0 54.8 55.9 58.5 6.4 5. 53. 55.6 59.3 48. 49. 5.5 54.9 S/T 0.9 0.89 0.80 0.65 0.95 0.9 0.83 0.67 0.98 0.94 0.85 0.69.00 0.97 0.88 0.7.00.00 0.9 0.74.00.00 0.9 0.75 Delta T 8 7 6 8 8 6 3 8 8 6 3 8 8 6 3 7 7 6 5 5 4 KW 4.0 4.0 4.3 4.37 4.33 4.4 4.57 4.7 4.6 4.7 4.86 5.03 4.85 4.96 5. 5.30 5.06 5.7 5.34 5.53 5.4 5.35 5.53 5.7 AMPS 0.3 0.6 0.9.3..4.8.3..4.8 3.3 3.0 3.3 3.7 4. 3.8 4. 4.6 5. 4.6 5.0 5.5 6. HI P 63 83 98 3 95 37 335 349 335 36 38 397 38 4 434 45 49 46 488 509 475 5 539 56 LO P 09 6 7 35 5 3 34 4 0 7 39 48 6 34 46 56 3 40 53 63 36 45 58 69 MBh 54.4 55.4 58. 6.9 53. 54. 56.7 60.5 5.8 5.8 55.4 59. 50.6 5.6 54.0 57.6 48. 49.0 5.3 54.7 44.5 45.4 47.5 50.7 S/T 0.89 0.86 0.77 0.63 0.9 0.89 0.80 0.65 0.94 0.9 0.8 0.67 0.97 0.94 0.85 0.69.00 0.97 0.88 0.7.00 0.98 0.89 0.7 Delta T 9 8 7 3 9 8 7 3 9 9 7 3 9 9 7 3 9 8 7 3 6 6 5 KW 3.9 4.00 4.3 4.6 4. 4.3 4.45 4.60 4.49 4.59 4.74 4.90 4.73 4.83 4.99 5.6 4.93 5.04 5. 5.38 5.0 5. 5.39 5.58 AMPS 0. 0.3 0.6.0 0.9..5.9.8..5 3.0.6.9 3.3 3.8 3.4 3.7 4. 4.7 4. 4.6 5.0 5.6 HI P 55 74 89 30 86 308 35 339 35 350 369 385 370 398 4 439 47 448 473 494 460 495 53 546 LO P 06 3 3 3 9 30 38 6 4 35 44 30 4 5 8 36 48 58 3 4 54 64 IDB = Entering Indoor Dry Bulb Temperature Shaded area reflects AHI atings conditions kw = Total system power High and low pressures are measured at the liquid and suction service ports. Amps: Unit amps (comp.+ evaporator + condenser fan motors) www.daikinac.com SS-DS3
Airflow Data 3 Tons Direct Drive Horizontal Direct Drive Down Shot FM Static Amps Watts PM Speed Tap FM Static Amps Watts PM Speed Tap 80 0..54 360 755 70 0..53 355 760 5 0..5 345 800 05 0..53 350 80 45 0.3.46 335 830 Low 45 0.3.49 340 840 080 0.4.4 35 870 085 0.4.45 330 875 Low 005 0.5.37 30 895 035 0.5.4 30 900 485 0..98 460 840 460 0.6.96 450 850 40 0..9 440 870 380 0..89 430 885 335 0.3.86 45 900 75 0..8 405 95 55 0.4.8 40 930 Med 75 0.3.73 400 950 70 0.5.75 400 950 075 0.4.68 380 965 Med 075 0.6.68 380 980 005 0.5.63 370 000 945 0.7.6 360 005 95 0.6.59 360 05 445 0.3. 505 940 445 0.3. 500 950 365 0.4.4 490 960 340 0.4.3 480 975 70 0.5.08 470 985 75 0.5.07 465 000 High 80 0.6.0 460 000 75 0.6.0 455 00 High 050 0.7.9 435 030 040 0.7.9 430 045 85 0.8.78 400 055 830 0.8.78 395 070 Notes: Assumes dry coil with filter in place SFM correction for wet coil = 4% SS-DS3 www.daikinac.com 3
Airflow Data 3 Tons ESP ( W..) Standard Belt Drive Down Shot Turns Open 0 3 4 5 FM BHP FM BHP FM BHP FM BHP FM BHP FM BHP 0. --- --- --- --- --- --- --- --- 358 0.3 0 0.4 0. --- --- --- --- --- --- --- --- 03 0.9 044 0.3 0.3 --- --- --- --- --- --- 09 0.34 044 0.7 854 0. 0.4 --- --- --- --- 30 0.34 050 0.3 836 0.4 665 0.0 0.5 --- --- 37 0.37 4 0.3 86 0.9 --- --- --- --- 0.6 --- --- 54 0.34 930 0.8 675 0.5 --- --- --- --- 0.7 70 0.4 99 0.3 685 0.5 --- --- --- --- --- --- 0.8 09 0.37 807 0.8 --- --- --- --- --- --- --- --- 0.9 905 0.34 633 0.5 --- --- --- --- --- --- --- ---.0 660 0.9 --- --- --- --- --- --- --- --- --- --- ESP ( W..) High-Static Belt Drive Down Shot Turns Open 0 3 4 5 FM BHP FM BHP FM BHP FM BHP FM BHP FM BHP 0.6 --- --- --- --- --- --- --- --- --- --- --- --- 0.7 --- --- --- --- --- --- --- --- --- --- --- --- 0.8 --- --- --- --- --- --- --- --- --- --- 40 0.44 0.9 --- --- --- --- --- --- --- --- --- --- 4 0.43.0 --- --- --- --- --- --- --- --- 5 0.48 965 0.39. --- --- --- --- --- --- 80 0.55 063 0.44 804 0.37. --- --- --- --- --- --- 43 0.5 867 0.40 --- ---.3 --- --- --- --- 68 0.59 963 0.48 65 0.36 --- ---.4 --- --- 347 0.69 7 0.55 766 0.43 --- --- --- ---.5 --- --- 0.65 986 0.5 --- --- --- --- --- ---.6 90 0.73 04 0.59 833 0.48 --- --- --- --- --- ---.7 5 0.69 837 0.55 --- --- --- --- --- --- --- ---.8 06 0.66 --- --- --- --- --- --- --- --- --- --- 4 www.daikinac.com SS-DS3
Airflow Data 3 Tons (cont.) ESP ( W..) Standard Belt Drive Horizontal Turns Open 0 3 4 5 FM BHP FM BHP FM BHP FM BHP FM BHP FM BHP 0. --- --- --- --- --- --- --- --- --- --- 375 0.8 0. --- --- --- --- --- --- --- --- 367 0.33 86 0.7 0.3 --- --- --- --- --- --- 374 0.39 86 0.3 97 0.5 0.4 --- --- --- --- --- --- 93 0.36 95 0.8 756 0.3 0.5 --- --- --- --- 77 0.36 980 0.34 78 0.6 --- --- 0.6 --- --- 3 0.39 056 0.33 767 0.3 --- --- --- --- 0.7 --- --- 6 0.36 779 0.9 --- --- --- --- --- --- 0.8 40 0.43 97 0.33 --- --- --- --- --- --- --- --- 0.9 09 0.39 708 0.30 --- --- --- --- --- --- --- ---.0 749 0.34 --- --- --- --- --- --- --- --- --- --- ESP ( W..) High-Static Belt Drive Horizontal Turns Open 0 3 4 5 FM BHP FM BHP FM BHP FM BHP FM BHP FM BHP 0.6 --- --- --- --- --- --- --- --- --- --- --- --- 0.7 --- --- --- --- --- --- --- --- --- --- --- --- 0.8 --- --- --- --- --- --- --- --- --- --- 459 0.5 0.9 --- --- --- --- --- --- --- --- --- --- 3 0.50.0 --- --- --- --- --- --- --- --- 39 0.55 36 0.46. --- --- --- --- --- --- 455 0.63 08 0.5 947 0.43. --- --- --- --- --- --- 99 0.60 985 0.46 738 0.40.3 --- --- --- --- 409 0.65 094 0.54 740 0.4 --- ---.4 --- --- 480 0.76 5 0.6 870 0.49 --- --- --- ---.5 --- --- 33 0.7 095 0.57 --- --- --- --- --- ---.6 48 0.80 6 0.65 95 0.53 --- --- --- --- --- ---.7 66 0.75 90 0.60 --- --- --- --- --- --- --- ---.8 68 0.73 --- --- --- --- --- --- --- --- --- --- SS-DS3 www.daikinac.com 5
Airflow Data 4 Tons Standard Direct Drive Horizontal Standard Direct Drive Down Shot FM Static Amps Watts PM Speed Tap FM Static Amps Watts PM Speed Tap 570 0..09 490 905 548 0..03 480 930 50 0..06 480 90 500 0. 470 945 445 0.3.95 460 945 Low 45 0.3.89 450 970 Low 375 0.4.89 440 970 353 0.4.83 430 995 95 0.5.8 45 995 73 0.5 75 45 00 75 0..39 560 975 660 0..3 540 00 655 0..3 545 985 65 0..5 530 035 580 0.3.4 55 005 565 0.3.9 55 040 500 0.4.6 505 00 Med 485 0.4. 505 050 Med 405 0.5.09 490 035 405 0.5. 500 055 305 0.6.00 465 050 85 0.6.98 465 060 00 0.7.9 440 065 00 0.7.93 440 070 839 0..77 650 030 85 0..65 60 045 770 0..70 630 040 745 0..55 600 060 696 0.3.6 60 050 670 0.3.53 590 065 High 6 0.4.53 590 060 585 0.4.46 575 070 High 50 0.5.44 560 070 480 0.5.37 550 080 48 0.6.36 540 085 405 0.6.3 535 090 Notes: Assumes dry coil with filter in place SFM correction for wet coil = 4% 6 www.daikinac.com SS-DS3
Airflow Data 4 Tons (cont.) Standard Belt Drive Down Shot ESP (" W..) 0 Turns Turn Turns 3 Turns 4 Turns 5 Turns FM BHP FM BHP FM BHP FM BHP FM BHP FM BHP 0. --- --- --- --- --- --- --- --- 7 0.4 588 0.34 0. --- --- --- --- --- --- 756 0.47 58 0.39 449 0.33 0.3 --- --- --- --- 736 0.5 604 0.44 437 0.37 8 0.3 0.4 --- --- 765 0.54 60 0.49 45 0.4 86 0.34 09 0.8 0.5 80 0.53 653 0.5 458 0.46 306 0.38 4 0.3 --- --- 0.6 70 0.56 55 0.48 34 0.43 5 0.36 --- --- --- --- 0.7 593 0.54 406 0.46 60 0.40 956 0.33 --- --- --- --- 0.8 446 0.5 47 0.43 98 0.36 --- --- --- --- --- --- 0.9 37 0.48 07 0.39 --- --- --- --- --- --- --- ---.0 45 0.44 987 0.39 --- --- --- --- --- --- --- ---. 059 0.44 --- --- --- --- --- --- --- --- --- --- High-Static Belt Drive Down Shot ESP (" W..) 0 Turns Turn Turns 3 Turns 4 Turns 5 Turns FM BHP FM BHP FM BHP FM BHP FM BHP FM BHP 0.6 --- --- --- --- --- --- --- --- --- --- 634 0.5 0.7 --- --- --- --- --- --- --- --- 705 0.59 50 0.49 0.8 --- --- --- --- --- --- 753 0.64 576 0.56 378 0.47 0.9 --- --- --- --- --- --- 644 0.6 447 0.5 37 0.43.0 --- --- --- --- 77 0.69 535 0.58 94 0.49 070 0.40. --- --- --- --- 605 0.66 39 0.54 44 0.45 --- ---. --- --- 745 0.76 483 0.6 3 0.50 974 0.4 --- ---.3 783 0.87 586 0.7 33 0.58 068 0.46 --- --- --- ---.4 658 0.83 47 0.66 77 0.53 --- --- --- --- --- ---.5 533 0.78 96 0.6 09 0.50 --- --- --- --- --- ---.6 387 0.73 3 0.57 --- --- --- --- --- --- --- ---.7 36 0.68 --- --- --- --- --- --- --- --- --- ---.8 096 0.65 --- --- --- --- --- --- --- --- --- --- SS-DS3 www.daikinac.com 7
Airflow Data 4 Tons (cont.) Standard Belt Drive Horizontal ESP (" W..) 0 Turns Turn Turns 3 Turns 4 Turns 5 Turns FM BHP FM BHP FM BHP FM BHP FM BHP FM BHP 0. --- --- --- --- --- --- --- --- --- --- 76 0.37 0. --- --- --- --- --- --- --- --- 70 0.43 575 0.36 0.3 --- --- --- --- 888 0.57 744 0.48 56 0.4 398 0.34 0.4 --- --- --- --- 740 0.54 579 0.45 398 0.38 7 0.3 0.5 --- --- 797 0.56 586 0.5 40 0.4 6 0.36 004 0.8 0.6 849 0.6 658 0.53 49 0.48 5 0.40 997 0.3 --- --- 0.7 73 0.59 58 0.5 66 0.45 039 0.36 --- --- --- --- 0.8 57 0.55 355 0.47 068 0.4 --- --- --- --- --- --- 0.9 43 0.5 7 0.43 --- --- --- --- --- --- --- ---.0 45 0.48 987 0.39 --- --- --- --- --- --- --- ---. 059 0.44 --- --- --- --- --- --- --- --- --- --- High-Static Belt Drive Horizontal ESP (" W..) 0 Turns Turn Turns 3 Turns 4 Turns 5 Turns FM BHP FM BHP FM BHP FM BHP FM BHP FM BHP 0.6 --- --- --- --- --- --- --- --- --- --- 776 0.57 0.7 --- --- --- --- --- --- --- --- --- --- 65 0.54 0.8 --- --- --- --- --- --- --- --- --- --- 498 0.5 0.9 --- --- --- --- --- --- --- --- 73 0.6 345 0.47.0 --- --- --- --- --- --- 787 0.67 573 0.57 63 0.44. --- --- --- --- 745 0.7 668 0.63 407 0.53 960 0.40. --- --- --- --- 6 0.68 53 0.59 43 0.49 --- ---.3 --- --- 74 0.78 447 0.63 339 0.54 059 0.46 --- ---.4 80 0.90 55 0.7 79 0.58 6 0.50 --- --- --- ---.5 667 0.85 409 0.67 08 0.54 --- --- --- --- --- ---.6 508 0.80 0.6 --- --- --- --- --- --- --- ---.7 343 0.74 005 0.56 --- --- --- --- --- --- --- ---.8 9 0.70 --- --- --- --- --- --- --- --- --- --- 8 www.daikinac.com SS-DS3
Airflow Data 5 Tons Standard Direct Drive Motor Horizontal Standard Direct Drive Motor Down Shot FM Static Amps Watts PM Speed Tap FM Static Amps Watts PM 5 0..4 65 60 05 0..47 80 635 50 0..46 75 645 50 0..54 85 675 085 0.3.54 80 690 065 0.3.59 85 730 T 00 0.4.64 95 75 980 0.4.68 95 760 900 0.5.74 05 780 860 0.5.79 00 80 840 0.6.77 5 80 800 0.6.8 0 840 395 0..86 30 670 375 0..94 35 690 35 0..95 40 705 300 0..0 45 70 60 0.3.0 50 735 30 0.3.05 55 750 0 0.4.0 60 770 80 0.4.5 65 790 35 0.5.6 65 80 T 00 0.5. 75 830 040 0.6.8 80 860 005 0.6.33 85 890 970 0.7.38 90 885 970 0.7.43 95 900 90 0.8.46 300 95 95 0.8.5 30 940 840 0.9.5 30 955 845 0.9.57 35 980 790 0. 3.4 45 80 755 0. 3.34 385 850 735 0. 3.37 435 830 700 0. 3.47 395 865 670 0.3 3.45 450 865 665 0.3 3.56 40 895 60 0.4 3.55 465 890 580 0.4 3.68 45 930 560 0.5 3.60 475 90 T3 545 0.5 3.7 435 955 50 0.6 3.70 490 945 505 0.6 3.80 50 990 470 0.7 3.80 500 970 430 0.7 3.93 530 00 40 0.8 3.94 50 995 370 0.8 4.08 535 040 345 0.9 3.98 530 035 300 0.9 4. 570 070 005 0. 4.30 575 880 945 0. 4.46 600 90 965 0. 4.4 590 900 90 0. 4.57 60 940 895 0.3 4.5 60 930 850 0.3 4.66 635 965 835 0.4 4.63 60 955 795 0.4 4.78 655 990 790 0.5 4.75 635 980 T4 760 0.5 4.84 670 00 745 0.6 4.84 650 005 70 0.6 4.96 685 045 695 0.7 4.9 660 030 640 0.7 5.06 675 065 650 0.8 5.03 675 055 60 0.8 5.9 690 090 600 0.9 5.0 675 080 560 0.9 5. 700 5 0 0. 5.0 690 930 090 0. 5.35 70 970 075 0. 5.5 70 950 040 0. 5.38 740 990 05 0.3 5.3 70 975 985 0.3 5.70 755 05 975 0.4 5.35 735 995 935 0.4 5.44 760 035 930 0.5 5.46 750 00 T5 900 0.5 5.8 780 050 875 0.6 5.59 770 040 855 0.6 5.73 800 075 835 0.7 5.64 780 065 80 0.7 5.69 80 090 795 0.8 5.73 790 090 750 0.8 5.8 85 0 735 0.9 5.8 805 0 680 0.9 5.94 840 45 Speed Tap T T T3 T4 T5 Notes Assumes dry coil with filter in place; SFM correction for wet coil = 4% Five-ton models are shipped from the factory with speed tap set on T4. SS-DS3 www.daikinac.com 9
Airflow Data 5 Tons (cont.) Standard Belt Drive Down Shot ESP (" W..) 0 Turns Turn Turns 3 Turns 4 Turns 5 Turns FM BHP FM BHP FM BHP FM BHP FM BHP FM BHP 0. --- --- --- --- --- --- 040 0.53 873.00 0.43 730 0.35 0. --- --- --- --- 046 0.58 90 0.50 758.00 0.4 586 0.34 0.3 --- --- 30 0.65 938 0.55 78 0.46 67.00 0.38 435 0.3 0.4 090 0.74 08 0.6 830 0.5 65 0.43 493.00 0.35 90 0.8 0.5 005 0.7 897 0.59 698 0.49 505 0.40 348.00 0.3 --- --- 0.6 95 0.68 776 0.55 576 0.45 376 0.37 74.00 0.9 --- --- 0.7 85 0.64 657 0.5 44 0.4 7 0.33 --- --- --- --- 0.8 7 0.60 59 0.48 300 0.39 --- --- --- --- --- --- 0.9 587 0.56 397 0.44 --- --- --- --- --- --- --- ---.0 460 0.53 0 0.40 --- --- --- --- --- --- --- ---. 34 0.50 --- --- --- --- --- --- --- --- --- --- High-Static Belt Drive Down Shot ESP (" W..) 0 Turns Turn Turns 3 Turns 4 Turns 5 Turns FM BHP FM BHP FM BHP FM BHP FM BHP FM BHP 0.6 --- --- --- --- --- --- --- --- --- --- 73 0.77 0.7 --- --- --- --- --- --- --- --- 8 0.87 048 0.74 0.8 --- --- --- --- --- --- --- --- 9 0.84 99 0.7 0.9 --- --- --- --- --- --- 58 0.93 97 0.80 78 0.66.0 --- --- --- --- 9.04 3 0.9 796 0.76 576 0.63. --- --- --- --- 49.00 99 0.84 636 0.7 343 0.58. --- --- 38.8 06 0.96 84 0.8 4 0.66 --- ---.3 38.30 86. 874 0.9 650 0.76 --- --- --- ---.4 80.6 048.07 674 0.87 456 0.70 --- --- --- ---.5 4. 874.0 49 0.79 --- --- --- --- --- ---.6 009.7 735 0.96 --- --- --- --- --- --- --- ---.7 83.0 4 0.85 --- --- --- --- --- --- --- ---.8 474 0.98 --- --- --- --- --- --- --- --- --- --- 0 www.daikinac.com SS-DS3
Airflow Data 5 Tons (cont.) ESP (" W..) Standard Belt Drive Horizontal 0 Turns Turn Turns 3 Turns 4 Turns 5 Turns FM BHP FM BHP FM BHP FM BHP FM BHP FM BHP 0. --- --- --- --- --- --- --- --- 05 0.49 940 0.40 0. --- --- --- --- --- --- 47 0.57 975 0.47 78 0.39 0.3 --- --- --- --- 78 0.63 00 0.53 88 0.43 63 0.36 0.4 --- --- --- --- 057 0.60 855 0.50 678 0.4 450 0.33 0.5 --- --- 3 0.68 90 0.57 69 0.47 55 0.38 5 0.9 0.6 5 0.78 995 0.64 77 0.53 546 0.44 30 0.34 --- --- 0.7 05 0.74 86 0.6 60 0.49 379 0.40 --- --- --- --- 0.8 9 0.70 78 0.57 46 0.46 0 0.37 --- --- --- --- 0.9 784 0.66 570 0.53 96 0.43 --- --- --- --- --- ---.0 64 0.6 37 0.48 --- --- --- --- --- --- --- ---. 477 0.58 00 0.44 --- --- --- --- --- --- --- ---. 9 0.53 --- --- ESP (" W..) High-Static Belt Drive Horizontal 0 Turns Turn Turns 3 Turns 4 Turns 5 Turns FM BHP FM BHP FM BHP FM BHP FM BHP FM BHP 0.6 --- --- --- --- --- --- --- --- 94 0.94 04 0.8 0.7 --- --- --- --- --- --- 366.05 70 0.90 969 0.77 0.8 --- --- --- --- --- --- 30.0 060 0.87 839 0.74 0.9 --- --- --- --- 33.6 5 0.97 98 0.84 699 0.7.0 --- --- --- ---. 04 0.95 788 0.80 495 0.66. --- --- 336.6 5.09 880 0.9 636 0.75 --- ---. --- --- 7. 988.05 7 0.86 433 0.70 --- ---.3 306.36 075.7 844.00 57 0.8 --- --- --- ---.4 96.3 946. 68 0.94 386 0.76 --- --- --- ---.5 06.7 786.06 486 0.88 --- --- --- --- --- ---.6 95. 60.00 --- --- --- --- --- --- --- ---.7 785.6 434 0.94 --- --- --- --- --- --- --- ---.8 633.09 --- --- --- --- --- --- --- --- --- --- SS-DS3 www.daikinac.com
rankcase Heater, High Efficiency MEV 3 Air Filter Option High Efficiency MEV 3 Air Filter Option 0.50 Flanders Pre Pleat M3 Air Velocity vs esistance (Test Size: 4" x 4" x " High apacity) 0.45 0.40 " Deep esistance (in. w.g.) 0.35 0.30 0.5 0.0 0.5 0.0 0.05 0.00 0 00 00 300 400 500 600 700 Air Velocity (FPM) Tonnage: Filter Nominal Size: Part Number: Order QTY: 3 4 x 4 x 060L0003 4 4 x 0 x 060L0004 4 5 6 x 0 x 060L0005 4 rankcase Heater Selection Table ompressor Voltage rankcase ZP/ZPS ompressor Diameter 30V 460V 575V Heater Watts 6-3 5.5" 0630000S 0630003S 0630003S 40 39-83 6.58/7.3" 030L0007S 030L0008S 030L0009S 70 03-37 9.4 030L0000S 030L000S 030L000S 90 D*,DT* & DS* Tonnage ompressor Voltage 30V 460V 575V rankcase Heater Watts 3 Ton 0630000S 0630003S 0630003S 40 4 Ton-5 Ton 030L0007S 030L0008S 030L0009S 70 *Includes,G&H models. www.daikinac.com SS-DS3
Electrical Data 3 Tons Model Number Electrical ating ompressor ircuit ompressor ircuit Outdoor Fan Motor Indoor Fan Motor Optional Electric Heat Optional Powered onvienience Outlet Power Supply LA LA LA LA QTY HP FLA Type HP FLA Part # KW* FLA FLA MA MOP - - - - 4.7 / 4.7 40 / 40 EHK-0 7.5 / 0.0 36. / 4.7-48. / 55. 50 / 60 DS036XXXD 08/30--60 6.7 79.0 0.5.40 Standard - Direct Drive 0.33.46 EHK-5.3 / 5.0 54. / 6.5-70.8 / 8. 80 / 90 - - - 7. / 6.5 3.9 / 3. 45 / 45 EHK-0 7.5 / 0.0 36. / 4.7 7. / 6.5 57. / 63.3 60 / 70 EHK-5.3 / 5.0 54. / 6.5 7. / 6.5 79.8 / 89.3 80 / 90 - - - - 6.9 / 6.9 5 / 5 EHK3-0 7.5 / 0.0 0.8 / 4.0-9. / 33. 30 / 35 DS036XXX3D 08/30-3-60 0.4 73.0 0.5.40 Standard - Direct Drive 0.33.46 EHK3-5.3 / 5.0 3.3 / 36. - 4. / 48. 45 / 50 - - - 7. / 6.5 4. / 3.4 30 / 30 EHK3-0 7.5 / 0.0 0.8 / 4.0 7. / 6.5 38. / 4. 40 / 45 EHK3-5.3 / 5.0 3.3 / 36. 7. / 6.5 5. / 56.3 60 / 60 - - - - 7.9 / 7.9 5 / 5 EHK3-0 7.5 / 0.0 0.8 / 4.0-30.3 / 34.3 35 / 35 DS036XXX3B 08/30-3-60 0.4 73.0 0.5.40 Standard - Belt Drive.00 3.40 EHK3-5.3 / 5.0 3.3 / 36. - 43.4 / 49.4 45 / 50 - - - 7. / 6.5 5. / 4.4 35 / 30 EHK3-0 7.5 / 0.0 0.8 / 4.0 7. / 6.5 39.3 / 4.4 40 / 45 EHK3-5.3 / 5.0 3.3 / 36. 7. / 6.5 5.4 / 57.5 60 / 60 - - - - 9. / 9. 5 / 5 EHK3-0 7.5 / 0.0 0.8 / 4.0-3.8 / 35.8 35 / 40 DS036XXX3H 08/30-3-60 0.4 73.0 0.5.40 High Static - Belt Drive.50 4.60 EHK3-5.3 / 5.0 3.3 / 36. - 44.9 / 50.9 45 / 60 - - - 7. / 6.5 6.3 / 5.6 35 / 35 EHK3-0 7.5 / 0.0 0.8 / 4.0 7. / 6.5 40.8 / 43.9 45 / 45 EHK3-5.3 / 5.0 3.3 / 36. 7. / 6.5 53.9 / 59.0 60 / 60 - - - - 9.6 5 EHK4-0 0.0.0-7. 0 DS036XXX4B 460-3-60 5.8 38.0 0.5 0.70 Standard - Belt Drive.00.70 EHK4-5 5.0 8.0-4.6 5 - - - 3.3.9 5 EHK4-0 0.0.0 3.3.3 5 EHK4-5 5.0 8.0 3.3 8.8 30 - - - - 0.0 5 EHK4-0 0.0.0-7.6 0 DS036XXX4H 460-3-60 5.8 38.0 0.5 0.70 High Static - Belt Drive.50.0 EHK4-5 5.0 8.0-5. 30 - - - 3.3 3.3 5 EHK4-0 0.0.0 3.3.8 5 EHK4-5 5.0 8.0 3.3 9.3 30 - - - - 7.6 5 EHK7-0 0.0 0.0-5.4 0 DS036XXX7B 575-3-60 3.8 36.5 0.5 0.55 Standard & High Static - Belt Drive.50.30 EHK7-5 5.0 5. -.8 5 - - -.6 0. 5 EHK7-0 0.0 0.0.6 8.6 0 EHK7-5 5.0 5..6 5.0 5 * Electric Heater kw rating: ated at 40v for 08-30v units; 480v for 460v units SS-DS3 www.daikinac.com 3
Heat Kit Electrical Data (Blower Only, Heat Mode) 3 Tons Model and Heat Kit Usage ecommended Airflow ange DS036***D*** --- EHK30-0 50-350 FM EHK30-5 400-440 FM DS036***3D*** --- EHK3-0 50-350 FM EHK3-5 400-440 FM DS036***3B*** --- EHK3-0 50-350 FM EHK3-5 400-440 FM Model and Heat Kit Usage ecommended Airflow ange DS036***4B*** --- EHK4-0 50-350 FM EHK4-5 400-440 FM Model and Heat Kit Usage ecommended Airflow ange DS036***7B*** --- EHK7-0 50-350 FM EHK7-5 400-440 FM kw orrection Factor kw orrection Factor for - & 3-Phase Units Supply Voltage 40 30 0 0 08 orrection Factor 0.9 0.84 0.77 0.75 For other voltage use votlage / 40 Multiply rated kw by correction factor to get actual kw kw orrection Factor for 480V Units Actual Voltage 460 440 430 orrection Factor 0.9 0.84 0.8 For other voltage use voltage / 480 kw orrection Factor for 575V Units Supply Voltage 560 550 540 orrection Factor 0.95 0.9 0.88 For other voltage use votlage / 40 Multiply rated kw by correction factor to get actual kw 4 www.daikinac.com SS-DS3
Electrical Data 4 Tons Model Number Electrical ating ompressor ircuit ompressor ircuit Outdoor Fan Motor Indoor Fan Motor Optional Electric Heat Optional Powered onvienience Outlet Power Supply LA LA LA LA QTY HP FLA Type HP FLA Part # KW* FLA FLA MA MOP DS048XXXD 08/30--60 9.9 09.0 0.5.40 DS048XXX3D 08/30-3-60 3. 83. 0.5.40 DS048XXX3B 08/30-3-60 3. 83. 0.5.40 DS048XXX3H 08/30-3-60 3. 83. 0.5.40 DS048XXX4B 460-3-60 6. 4.0 0.5 0.70 DS048XXX4H 460-3-60 6. 4.0 0.5 0.70 DS048XXX7B 575-3-60 4.4 33.0 0.5 0.55 * Electric Heater kw rating: ated at 40v for 08-30v units; 480v for 460v units Standard - Direct Drive Standard - Direct Drive Standard - Belt Drive High Static - Belt Drive Standard - Belt Drive High Static - Belt Drive Standard & High Static - Belt Drive 0.75.80 0.75.80.00 3.40.50 4.60.00.70.50.0.50.30 - - - - 9.0 / 9.0 45 / 45 EHK-0 7.5 / 0.0 36. / 4.7-48.6 / 55.6 50 / 60 EHK-5.3 / 5.0 54. / 6.5-7.3 / 8.6 80 / 90 EHK-8 3.5 / 8.0 65.0 / 75.0-84.8 / 97.3 90 / 00 - - - 7. / 6.5 36. / 35.5 50 / 50 EHK-0 7.5 / 0.0 36. / 4.7 7. / 6.5 57.6 / 63.8 60 / 70 EHK-5.3 / 5.0 54. / 6.5 7. / 6.5 80.3 / 89.8 90 / 90 EHK-8 3.5 / 8.0 65.0 / 75.0 7. / 6.5 93.8 / 05.0 00 / 0 - - - - 0.6 / 0.6 30 / 30 EHK3-0 7.5 / 0.0 0.8 / 4.0-9.5 / 33.5 30 / 35 EHK3-5.3 / 5.0 3.3 / 36. - 4.6 / 48.6 45 / 50 EHK3-8 3.5 / 8.0 37.5 / 43.3-50.4 / 57.6 60 / 60 - - - 7. / 6.5 7.8 / 7. 40 / 40 EHK3-0 7.5 / 0.0 0.8 / 4.0 7. / 6.5 38.5 / 4.6 40 / 45 EHK3-5.3 / 5.0 3.3 / 36. 7. / 6.5 5.6 / 56.8 60 / 60 EHK3-8 3.5 / 8.0 37.5 / 43.3 7. / 6.5 59.4 / 65.8 60 / 70 - - - -. /. 30 / 30 EHK3-0 7.5 / 0.0 0.8 / 4.0-30.3 / 34.3 35 / 35 EHK3-5.3 / 5.0 3.3 / 36. - 43.4 / 49.4 45 / 50 EHK3-8 3.5 / 8.0 37.5 / 43.3-5. / 58.4 60 / 60 - - - 7. / 6.5 8.4 / 7.7 40 / 40 EHK3-0 7.5 / 0.0 0.8 / 4.0 7. / 6.5 39.3 / 4.4 40 / 45 EHK3-5.3 / 5.0 3.3 / 36. 7. / 6.5 5.4 / 57.5 60 / 60 EHK3-8 3.5 / 8.0 37.5 / 43.3 7. / 6.5 60. / 66.5 70 / 70 - - - -.4 /.4 35 / 35 EHK3-0 7.5 / 0.0 0.8 / 4.0-3.8 / 35.8 35 / 40 EHK3-5.3 / 5.0 3.3 / 36. - 44.9 / 50.9 45 / 60 EHK3-8 3.5 / 8.0 37.5 / 43.3-5.6 / 59.9 60 / 60 - - - 7. / 6.5 9.6 / 8.9 40 / 40 EHK3-0 7.5 / 0.0 0.8 / 4.0 7. / 6.5 40.8 / 43.9 45 / 45 EHK3-5.3 / 5.0 3.3 / 36. 7. / 6.5 53.9 / 59.0 60 / 60 EHK3-8 3.5 / 8.0 37.5 / 43.3 7. / 6.5 6.6 / 68.0 70 / 70 - - - - 0.0 5 EHK4-0 0.0.0-7. 0 EHK4-5 5.0 8.0-4.6 5 EHK4-8 8.0.7-9.3 30 - - - 3.3 3.3 5 EHK4-0 0.0.0 3.3.3 5 EHK4-5 5.0 8.0 3.3 8.8 30 EHK4-8 8.0.7 3.3 33.4 35 - - - - 0.4 5 EHK4-0 0.0.0-7.6 0 EHK4-5 5.0 8.0-5. 30 EHK4-8 8.0.7-9.8 30 - - - 3.3 3.7 5 EHK4-0 0.0.0 3.3.8 5 EHK4-5 5.0 8.0 3.3 9.3 30 EHK4-8 8.0.7 3.3 33.9 35 - - - - 8.3 5 EHK7-0 0.0 0.0-5.4 0 EHK7-5 5.0 5. -.8 5 EHK7-8 8.0 8. - 5.5 30 - - -.6 0.9 5 EHK7-0 0.0 0.0.6 8.6 0 EHK7-5 5.0 5..6 5.0 5 EHK7-8 8.0 8..6 8.8 30 SS-DS3 www.daikinac.com 5
Heat Kit Electrical Data (Blower Only, Heat Mode) 4 Tons Model and Heat Kit Usage ecommended Airflow ange DS048***D*** --- EHK-0 400-800 FM EHK-5 575-800 FM EHK-8 575-800 FM DS048***3D*** --- EHK3-0 400-800 FM EHK3-5 575-800 FM EHK3-8 575-800 FM DS048***3B*** --- EHK3-0 400-800 FM EHK3-5 575-800 FM EHK3-8 575-800 FM Model and Heat Kit Usage ecommended Airflow ange DS048***4B*** --- EHK4-0 400-800 FM EHK4-5 575-800 FM EHK4-8 575-800 FM kw orrection Factor kw orrection Factor for - & 3-Phase Units Supply Voltage 40 30 0 0 08 orrection Factor 0.9 0.84 0.77 0.75 For other voltage use votlage / 40 Multiply rated kw by correction factor to get actual kw kw orrection Factor for 480V Units Actual Voltage 460 440 430 orrection Factor 0.9 0.84 0.8 For other voltage use voltage² / 480² kw orrection Factor for 575V Units Supply Voltage 560 550 540 orrection Factor 0.95 0.9 0.88 For other voltage use votlage / 40 Multiply rated kw by correction factor to get actual kw Model and Heat Kit Usage ecommended Airflow ange DS048***7B*** --- EHK7-0 400-800 FM EHK7-5 575-800 FM EHK7-8 575-800 FM 6 www.daikinac.com SS-DS3
Electrical Data 5 Tons Model Number Electrical ating ompressor ircuit ompressor ircuit Outdoor Fan Motor Indoor Fan Motor Optional Electric Heat Optional Powered onvienience Outlet Power Supply LA LA LA LA QTY HP FLA Type HP FLA Part # KW* FLA FLA MA MOP DS060XXXD 08/30--60 6.4 34.0 0.5.40 DS060XXX3D 08/30-3-60 6.4 0.0 0.5.40 DS060XXX3B 08/30-3-60 6.0 0.0 0.5.40 DS060XXX3H 08/30-3-60 6.0 0.0 0.5.40 DS060XXX4B 460-3-60 7.8 5.0 0.5 0.70 DS060XXX4H 460-3-60 5.7 5.0 0.5 0.70 DS060XXX7B 575-3-60 5.7 38.9 0.5 0.55 DS060XXX7H 575-3-60 5.7 38.9 0.5 0.55 * Electric Heater kw rating: ated at 40v for 08-30v units; 480v for 460v units Standard - Direct Drive Standard - Direct Drive Standard - Belt Drive High Static - Belt Drive Standard - Belt Drive High Static - Belt Drive Standard - Belt Drive High Static - Belt Drive.00 6.90.00 6.90.00 3.0.50 4.80.00.50.50.40.00.0.50.30 - - - - 4.3 / 4.3 60 / 60 EHK-0 7.5 / 0.0 36. / 4.7-53.8 / 60.8 60 / 70 EHK-5.3 / 5.0 54. / 6.5-76.4 / 86.8 80 / 90 EHK-0 5.0 / 0.0 7. / 83.3-98.9 / 3 00 / 5 - - - 7. / 6.5 48.5 / 47.8 70 / 70 EHK-0 7.5 / 0.0 36. / 4.7 7. / 6.5 6.8 / 68.9 70 / 70 EHK-5.3 / 5.0 54. / 6.5 7. / 6.5 85.4 / 94.9 90 / 00 EHK-0 5.0 / 0.0 7. / 83.3 7. / 6.5 08 / 0 / 5 - - - - 4.3 / 4.3 60 / 60 EHK3-0 7.5 / 0.0 0.8 / 4.0-53.8 / 60.8 60 / 70 EHK3-5.3 / 5.0 3.3 / 36. - 76.4 / 86.8 80 / 90 EHK3-0 5.0 / 0.0 4.6 / 48.0-98.9 / 3 00 / 5 - - - 7. / 6.5 48.5 / 47.8 70 / 70 EHK3-0 7.5 / 0.0 0.8 / 4.0 7. / 6.5 6.8 / 68.9 70 / 70 EHK3-5.3 / 5.0 3.3 / 36. 7. / 6.5 85.4 / 94.9 90 / 00 EHK3-0 5.0 / 0.0 4.6 / 48.0 7. / 6.5 08 / 0 / 5 - - - - 5.5 / 5.5 40 / 40 EHK3-0 7.5 / 0.0 0.8 / 4.0-5.5 / 55.5 60 / 60 EHK3-5.3 / 5.0 3.3 / 36. - 64.6 / 70.6 70 / 80 EHK3-0 5.0 / 0.0 4.6 / 48.0-77.5 / 85.5 80 / 90 - - - 7. / 6.5 3.7 / 3.0 45 / 45 EHK3-0 7.5 / 0.0 0.8 / 4.0 7. / 6.5 58.7 / 6.0 60 / 70.3 / 5.0 3.3 / 36. 7. / 6.5 7.8 / 77. 80 / 80 EHK3-0 5.0 / 0.0 4.6 / 48.0 7. / 6.5 84.7 / 9.0 90 / 00 - - - - 7. / 7. 40 / 40 EHK3-0 7.5 / 0.0 0.8 / 4.0-53. / 57. 60 / 60 EHK3-5.3 / 5.0 3.3 / 36. - 66. / 7. 70 / 80 EHK3-0 5.0 / 0.0 4.6 / 48.0-79. / 87. 80 / 90 - - - 7. / 6.5 34.3 / 33.6 50 / 45 EHK3-0 7.5 / 0.0 0.8 / 4.0 7. / 6.5 60.3 / 63.6 70 / 70 EHK3-5.3 / 5.0 3.3 / 36. 7. / 6.5 73.4 / 78.7 80 / 80 EHK3-0 5.0 / 0.0 4.6 / 48.0 7. / 6.5 86.3 / 93.6 90 / 00 - - - -.9 5 EHK4-0 0.0.0-6.9 0 EHK4-5 5.0 8.0-4.4 5 EHK4-0 0.0 4.0-3.9 35 - - - 3.3 5. 0 EHK4-0 0.0.0 3.3.0 5 5.0 8.0 3.3 8.5 30 EHK4-0 0.0 4.0 3.3 36.0 40 - - - -.8 0 EHK4-0 0.0.0-8.0 0 EHK4-5 5.0 8.0-5.5 30 EHK4-0 0.0 4.0-33.0 35 - - - 3.3 6. 0 EHK4-0 0.0.0 3.3. 5 EHK4-5 5.0 8.0 3.3 9.6 30 EHK4-0 0.0 4.0 3.3 37. 40 - - - - 8.9 5 EHK7-0 0.0 0.0-4.0 5 EHK7-5 5.0 5. - 0.4 5 EHK7-0 0.0 0.0-6.5 30 - - -.6.5 5 EHK7-0 0.0 0.0.6 7.3 0 EHK7-5 5.0 5..6 3.6 5 EHK7-0 0.0 0.0.6 9.8 30 - - - - 0.0 5 EHK7-0 0.0 0.0-5.4 0 EHK7-5 5.0 5. -.8 5 EHK7-0 0.0 0.0-7.9 30 - - -.6.6 5 EHK7-0 0.0 0.0.6 8.6 0 5.0 5..6 5.0 5 EHK7-0 0.0 0.0.6 3. 35 SS-DS3 www.daikinac.com 7
Heat Kit Electrical Data (Blower Only, Heat Mode) 5 Tons Model and Heat Kit Usage ecommended Airflow ange DS060***D*** --- EHK-0 EHK-5 EHK-0 750-50 FM 750-50 FM 850-50 FM DS060***3D*** --- EHK3-0 EHK3-5 EHK3-0 750-50 FM 750-50 FM 850-50 FM DS060***3B*** --- EHK3-0 EHK3-5 EHK3-0 Model and Heat Kit Usage 750-50 FM 750-50 FM 850-50 FM ecommended Airflow ange DS060***4B*** --- EHK4-0 EHK4-5 EHK4-0 750-50 FM 750-50 FM 850-50 FM kw orrection Factor kw orrection Factor for - & 3-Phase Units Supply Voltage 40 30 0 0 08 orrection Factor 0.9 0.84 0.77 0.75 For other voltage use votlage / 40 Multiply rated kw by correction factor to get actual kw kw orrection Factor for 480V Units Actual Voltage 460 440 430 orrection Factor 0.9 0.84 0.8 For other voltage use voltage / 480 kw orrection Factor for 575V Units Supply Voltage 560 550 540 orrection Factor 0.95 0.9 0.88 For other voltage use votlage / 40 Model and Heat Kit Usage ecommended Airflow ange DS060***7B*** --- EHK7-0 EHK7-5 EHK7-0 750-50 FM 750-50 FM 850-50 FM EHK7-5 --- 8 www.daikinac.com SS-DS3
Dimensions TOP VIEW.65 33.805 FLUE/VENT OUTLET OMBUSTION AI INLET (GAS UNITS) GAS LINE ENTANE 73.945 FONT VIEW ALL DIMENSIONS GIVEN AE IN INHES ALL DIMENSIONS AND SPEIFIATIONS AE SUBJET TO HANGE WITHOUT NOTIE SUPPLY AI DUT.000 4.475 0.060 6.96 DS036-060 3 THU 5 TON OMMEIAL 3.540.000 7.65 7.000 ONDENSATE DAIN OUTLET LIFTING SHAKLE HOLES BOTH SIDES AND ENDS 48.96 FOK HOLES BOTH SIDES AND BOTH ENDS 0.853 IGHT END VIEW ETUN AI DUT SS-DS3 www.daikinac.com 9
Dimensions (cont.) 9.470 5.04.000 ONDENSATE DAIN BOTTOM EXIT SUPPLY AI DUT 7.000 48.3 3.44.000 0.905 6.9 5.558 5.000 ETUN AI DUT 74.06 BASE PAN VIEW (VIEWED FOM TOP) ONDENSATE MODEL TONNAGES "A" "B" "" 3 TON OMMEIAL GAS, HT MP, AI ONDITIONE 38.840 6.555 6.055 4 TON OMMEIAL GAS, HT MP, AI ONDITIONE 38.840 6.555 6.055 5 TON OMMEIAL GAS, AI ONDITIONE 38.840 6.555 6.055 BOTTOM EXIT 7.984 LINE WIE ENTANE "A" "" "B" 8.555 TSTAT WIE ENTANE 5.87 0.37 LEFT END VIEW 30 www.daikinac.com SS-DS3
Unit learances Maintain an adequate clearance around the unit for safety, service, maintenance, and proper unit operation. Leave a clearance of 48" on all sides of the unit for possible compressor removal or service access, and to ensure proper ventilation and condenser airflow. Do not install the unit Beneath any obstruction. Install the unit away from all building exhausts to inhibit ingestion of exhaust air into the unit s fresh-air intake. 48" 48" 48" 48" Electrical Entrance Locations High-Voltage Entrance (emove Plug) ⅜ 30¼ Low-Voltage Entrance Low-Voltage Entrance 3½ Dia. Power Thru the urb 47½ 7½ SS-DS3 www.daikinac.com 3
oof urb Installation igging Provisions for forks have been included in the unit base frame. No other fork locations are approved. Unit must be lifted by the four lifting holes located at the base frame corners. Lifting cables should be attached to the unit with shackles. The distance between the crane hook and the top of the unit must not be less than 60. Two spreader bars must span over the unit to prevent damage to the cabinet by the lift cables. Spreader bars must be of sufficient length so that cables do not come in contact with the unit during transport. emove wood struts mounted beneath unit base frame before setting unit on roof curb. These struts are intended to protect unit base frame from fork lift damage. To remove the struts, extract the sheet metal retainers and pull the struts through the base of the unit. efer to rigging label on the unit. Important: If using bottom discharge with roof curb, duct-work should be attached to the curb prior to installing the unit. Duct-work dimensions are shown in oof urb Installation Instructions Manual. efer to the oof urb Installation Instructions for proper curb installation. urbing must be installed in compliance with the National oofing ontractors Association Manual. Lower unit carefully onto roof mounting curb. While rigging the unit, the center of gravity will cause the condenser end to be lower than the supply air end. Bring condenser end of unit into alignment with the curb. With condenser end of the unit resting on curb member and using curb as a fulcrum, lower opposite end of the unit until entire unit is seated on the curb. When a rectangular cantilever curb is used, take care to center the unit. heck for proper alignment and orientation of supply and return openings with duct. To assist in determining rigging requirements, unit weights are shown below. orner & enter-of-gravity Locations Unit Weights 3-Ton Weights 4-Ton Weights 5-Ton Weights 30 ondenser oil eturn Evaporator oil orner Weight (A) 3 3 3 orner Weight (B) 67 68 68 orner Weight () 7 8 8 orner Weight (D) 50 5 5 Unit Shipping Weight 565 570 570 Unit Operating Weight 590 595 595 Supply ompressor Note: Weights are calculated without accessories installed. 37 urb installations must comply with local codes and should follow the established guidelines of the National oofing ontractors Association. Proper unit installation requires that the roof curb be firmly and permanently attached to the roof structure. heck for adequate fastening method prior to setting the unit on the curb. Full perimeter roof curbs are available from the factory and are shipped unassembled. The installing contractor is responsible for field assembly, squaring, leveling, and mounting on the roof structure. All required hardware necessary for the assembly of the sheet metal curb is included in the curb accessory package. Determine sufficient structural support before locating and mounting the curb and package unit. Duct-work must be constructed using industry guidelines. The duct-work must be placed into the roof curb before mounting the package unit. Our full perimeter curbs include duct connection frames to be assembled with the curb. antilevered-type curbs are not available from the factory. ontractor furnishes curb insulation, cant strips, flashing, and general roofing material. Support curbs on parallel sides with roof members. To prevent damage to the unit, the roof members cannot penetrate supply and return duct openings. Note: The unit and curb accessories are designed to allow Down Shot duct installation before unit placement. Duct installation after unit placement is not recommended. See the manual shipped with the roof curb for assembly and installation instructions. 3 www.daikinac.com SS-DS3