Parts Manual Generator Set with Detector Control GGHG (Spec A D) GGHH (Spec A D) English Original Instructions -0 98 0 (Issue )
To avoid errors or delay in filling your parts order, always give the MODEL, SPEC NO. and SERIAL NO. from the Cummins Power Generation nameplate. For handy reference, insert your nameplate information in the spaces below. MODEL AND SPEC NO. SERIAL NO. DIGITAL CONTROL SOFTWARE VERSION AND DATE (IF APPLICABLE) The following symbols are used in Cummins Power Generation manuals to alert users to the potentially dangerous conditions relating to maintenance of equipment and replacement of parts. Please read and observe. This symbol warns of immediate hazards which will result in severe personal injury or death. This symbol refers to a hazard or unsafe practice which can result in severe personal injury or death. This symbol refers to a hazard or unsafe practice which can result in severe personal injury or product or property damage. Service and repair of Cummins Power Generation equipment must be performed by trained, experienced personnel only. Improper service or repair may result in property damage, severe personal injury or death. Do not use this catalog as a guide to servicing your equipment. Read and follow the IMPORTANT SAFETY INSTRUCTIONS in the Service Manual appropriate for the equipment you are working on. Contact with USED ENGINE OILS has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When checking or changing engine oils take all necessary precautions not to ingest, breathe the fumes or contact the used oil. Contact with ASBESTOS has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When handling engine gaskets take all necessary precautions not to ingest, breathe or contact the dust from the gaskets! Use adequate ventilation and wear protective gloves, masks and clothing! Contact with BENZINE and LEAD, found in gasoline, fuel additives and solvents has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When checking, draining or adding gasoline and fuel additives or using solvents take all necessary precautions not to ingest, breathe the fumes or contact the liquids. Use adequate ventilation and wear protective gloves, masks and protective clothing! PSP-
Introduction This catalog applies to Cummins Power Generation Generator Models GGHG and GGHH as listed in the Generator Set Data Table. Parts are arranged in groups of related items and each illustrated part is identified by a reference number corresponding to the same reference number in the parts list. Parts illustrations are typical. Unless otherwise mentioned in the description or page heading, parts are interchangeable between models. Throughout this catalog left and right sides are determined by facing the engine end (front) of the set unless noted in the description column. Engine parts that have been modified or added by Cummins Power Generation are identified in this catalog. All other engine replacement parts must be ordered from the engine manufacturer by referring to the engine manufacturer s nameplate and supplying all available information. Contact your nearest engine parts distributor for assistance in ordering replacement parts. Replacement Engine Cummins Power Generation Generator Model GGHG, GGHH Ford Engine Model WSG08 00 A Generator Set Data Table Model and Electrical Data Battery Specification Watts Volts Hertz Wire Phase Voltage 8GGHG 8,000 # 0,, or VDC 7GGHH 00GGHH 7,000 00,000 # # 0 0,,,, or or VDC VDC # Broad range reconnectible
Index A Adapter, Duct, Adapter, Generator, 9, 8 Adapter, Generator Stator, 8 Adapter, Oil Drain Begin Spec C, 0 Adapter, Oil Drain Spec A B, 9 Adapter, Oil Filter, Alarm, Common, 9 Alarm, Fuel, 0 Alternator, 9 Ammeter, AC Detector Control, 8 Armature, Starter, 9 B Bearing, Ball Generator, 8 Bearing, Starter (Commutator End), 9 Bearing, Starter (Pinion End), 9 Bell, End, 8 Belt, Serpentine, 9 Block, Terminal Detector Control, 8 Block, Terminal Generator Heater, 79 Board, Printed Circuit Alarm Relay, 9 Board, Printed Circuit Common Alarm, 9 Board, Printed Circuit Engine Monitor Detector Control, 8 Board, Printed Circuit Isolation Transformer, 9 Board, Printed Circuit Sensor Board Detector Control, 8 Board, Printed Circuit Time Delay Start/Stop, 00 Board, Printed Circuit Voltage Regulator, 9 Box, Control, 8 Box, Entrance, 7 Box, Terminal Generator Heater, 79 Bracket, Alternator, 9 Bracket, Ignition Module Begin Spec D, 7 Bracket, Ignition Module Spec A C, 9 Bracket, Mounting Generator Foot, 8 Bracket, Mounting Main Circuit Breaker, 0 Bracket, Transformer, 0 Breaker, Circuit Main, 07 Bulb, Replacement Emergency Stop Switch, 99 C Cable, Battery, 9 Cable, Heater Control, 8 Cap, Radiator, Cartridge, Generator Heater, 79 Cleaner, Air Standard Begin Spec C, 7 Clutch, Starter, 9 Control, Detector, 8 Cooler, Oil Remote Radiator Spec A B, Cover Main Circuit Breaker, 0 Cover, Battery Tray For UL 00 Approved Generator Sets, Cover, End Bell PMG, 8 Cover, Housing Control, 77 Cover, Rocker, 9 Cover, Shroud Radiator, Cover, Stator Generator, 8 Cover, Terminal Box Generator Heater, 79 D Disc, Drive Generator, 8 Door, Control Detector Control, 8 Drain, Oil Begin Spec C, 0 Drain, Oil Spec A B, 9 E Enclosure, Generator Set F7, 9 Enclosure, Generator Set F7, Enclosure, Generator Set F8, Exhaust System Critical With L0 Low Emissions and F7/F7 Housing Begin Spec C, 9 Exhaust System F7/F7 Housing, Exhaust System Industrial, Exhaust System Residential, 9 Exhaust System With F8 Housing, Exhaust System With L0 Low Emissions and F8 Housing Begin Spec C, Exhaust System With L0 Low Emissions and Mounted Muffler Begin Spec C, 7
Index Exhaust System With L0 Low Emissions and Threaded Exhaust Pipe Begin Spec C, Exhaust System With Threaded Exhaust Pipe, Extension, Radiator Drain, 7 External Engine Parts, 9 F Fan, Alternator, 9 Fan, Radiator, Filter, Oil, Frame, Starter (Commutator End), 9 Fuel System LP Liquid Begin Spec C, Fuel System Natural Gas, 0 Fuel System Natural Gas / Propane Liquid Withdrawl With Automatic Changeover Begin Spec C, Fuel System Natural Gas / Propane Vapor Begin Spec C, Fuel System Natural Gas / Propane Vapor Withdrawl With Automatic Changeover Begin Spec C, 9 Fuel System Natural Gas / Propane Vapor Withdrawl With Automatic Changeover Spec A B,, 7 Fuel System Propane Liquid Withdrawl Spec A B, Fuel System Propane Vapor Withdrawl Spec A B, Fuse Engine Monitor Board Detector Control, 8 G Gasket, Oil Drain Begin Spec C, 0 Gasket, Oil Drain Spec A B, 9 Gasket, Oil Filter Adapter, Gauge, Oil Pressure Control Mounted Detector Control, 8 Gauge, Water Temperature Control Mounted Detector Control, 8 Generator, 8 Generator, Permanent Magnet, 8 Governor Begin Spec D, 7 Governor Spec A B, 7 Governor Spec C, 7 Grille, Guard, Fan Generator, 8 Guard, Fan Radiator, Guard, Fan Remote Radiator Begin Spec C, Guard, Fan Remote Radiator Spec A B, H Harness, Wiring AC Auxiliary, 87 Harness, Wiring AC Control Door Detector Control, 8 Harness, Wiring Alarm Relay Board, 9 Harness, Wiring Common Alarm, 9 Harness, Wiring DC Control Door Detector Control, 8 Harness, Wiring Engine to Control Begin Spec D, 9 Harness, Wiring Engine to Control Spec A B, 88 Harness, Wiring Engine to Control Spec C, 89 Harness, Wiring Fuel Alarm, 0 Harness, Wiring Low Battery Voltage, 97 Harness, Wiring Low Coolant Level Sender With Continuously Monitored Low Coolant Level, 7 Harness, Wiring Low Coolant Level Sender Without Continuously Monitored Low Coolant Level, Harness, Wiring PMG, 8 Harness, Wiring Terminal Block Detector Control, 8 Harness, Wiring Time Delay Start/Stop, 00 Harness, Wiring Transformer, 0 Heater, Control, 8 Heater, Coolant, 8 Heater, Generator, 79 Hose, Breather, 9 Hose, Drain Radiator Drain Extension, 7 Hose, Inlet Remote Radiator Begin Spec C, Hose, Inlet Remote Radiator Spec A B, Hose, Oil Drain Spec A B, 9 Hose, Radiator, Hose, Vacuum, 9 Housing, Control, 7, 77 Housing, Starter, 9
Index Hub, Drive Generator, 8 I Isolator, Vibration Detector Control, 8 K Kit, Starter Brush, 9 L Lead Main Circuit Breaker, 07 Lens, Indicator Low Battery Voltage, 97 Lens, Replacement Low Coolant Level With Continuously Monitored Low Coolant Level, 7 Light Assembly, Indicator Detector Control, 8 Light, Indicator Upper and Lower Scale Detector Control, 8 Light, Panel Detector Control, 8 Lug, Solderless Entrance Box, 7 Lug, Solderless Main Circuit Breaker, 0 M Meter, Frequency Detector Control, 8 Meter, Hour Detector Control, 8 Module, Ignition, 9 P Package, Mounting Hardware Main Circuit Breaker, 07 Paint, Pan, Skid, Panel, Radiator Housing Remote Radiator, Panel, Radiator Housing Remote Radiator Begin Spec C, Pick Up, Magnetic Governor Begin Spec D, 7 Pick Up, Magnetic Governor Spec A B, 7 Pick Up, Magnetic Governor Spec C, 7 Pin, Parallel PMG, 8 Plate, Audible Signal, 98 Plug, Spark, 9 Potentiometer Voltage Regulator, 9 Pulley, Alternator, 9 R Radiator, Radiator, Remote Begin Spec C, Radiator, Remote Spec A B, Rectifier, Power Control Heater, 8 Rectifier, Silicon Low Coolant Level With Continuously Monitored Low Coolant Level, 7 Regulator, Voltage, 9 Resistor Voltage Regulator, 9 Rotor, Exciter, 8 Rotor, Generator, 8 Rotor, PMG, 8 S Sealant, Thread, Sender, Low Coolant Level With Continuously Monitored Low Coolant Level, 7 Sender, Low Coolant Level Without Continuously Monitored Low Coolant Level, Sender, Oil Pressure, Sensor, Low Battery Voltage, 97 Sensor, Map Begin Spec C, Separater, Oil, 9 Signal, Audible, 98 Skid Begin Spec D, 7 Skid Spec A C, 9 Standoff, Insulator Main Circuit Breaker, 0 Starter Components, 9 Stator, Exciter Generator, 8 Stator, Generator, 8 Stator, PMG, 8 Strap, Ground Detector Control, 8 Switch, Emergency Stop, 99 Switch, Rocker Lamp Test/Reset Panel Lamp Detector Control, 8 Switch, Rocker Run/Stop/Remote Detector Control, 8
Index Switch, Rotary Voltmeter/Ammeter Detector Control, 8 Switch, Starter, 9 Switch, Trip Alarm Main Circuit Breaker, 07 T Thermostat, 9 Transformer, Current, 0 Transformer, Meter, 0 Tray, Battery For Non UL 00 Approved Generator Sets, Tray, Battery For UL 00 Approved Generator Sets, Trip, Shunt Main Circuit Breaker, 07 V Valve, Oil Drain Begin Spec C, 0 Valve, Shutoff Oil Drain, 9 Valve, Shutoff Radiator Drain Extension, 7 Voltmeter, AC Detector Control, 8 Voltmeter, DC Detector Control, 8
Abbreviations Some of the following abbreviations may be used throughout this Parts Catalog: AC Amp A/R AVR AWG Deg DC EFC ET EIT GFI ID IT IEC kw LPG LT M(meter Number) Alternating Current Ampere As Required Automatic Voltage Regulator American Wire Gauge Degree Direct Current Electronic Fuel Control External Tooth External/Internal Tooth Ground Fault Interrupter Inside Diameter Internal Tooth International Electrotechnical Commission Kilowatt Liquid Petroleum Gas Left Meter mm MOH NFS NPT OD oz. PMG Ph PC RFI RT Spec Thk UL UNC UNF VAC VDC W/(ET, IT, EIT) Millimeter Mobile Off Highway Not For Sale National Pipe Thread Outside Diameter Ounce Permanent Magnet Generator Phase Printed Circuit Radio Frequency Interference Right Specification Thick Underwriters Laboratories Inc. Union National Coarse Union National Fine Volts Alternating Current Volts Direct Current With Paint and Thread Sealant Onan Green Enamel (Non-Metallic) 00 oz. Pressurized Spray Can 00 Quart Can 00 Gallon Can 8 00 Sealant, Thread ( ml Tube)
This Page Intentionally Left Blank. 7
8 External Engine Parts 7 8 9 9 9 0 0 0 9 7 8 9 0 0 7 8 9 7 7 0 7 8 7 8
External Engine Parts 09 0 Adapter, Generator 0 97 Flywheel (Includes Ring Gear) 0 99 Gear, Ring 9 0 Bracket, Alternator Rear 9 80 0 Bracket, Alternator Front Belt, Serpentine 0 8 8 Groove Spec A 0 Groove Begin Spec B 7 9 8 0 Bracket, Alternator 8 9 98 Fan, Alternator 9 00 Washer, Flat (M8) 0 0 Washer, Flat (M0) 800 08 Screw, Cap Hex Head (M8 x. x ) 800 097 Screw, Cap Hex Head (M0 x. x 80) 800 08 Screw, Cap Hex Head (M0 x. x ) 80 008 Nut, Hex (M8 x.) 07 0 Strap, Guard Manifold 00 0 Guard, Manifold 7 8 00 0 Screw, Hex Head (M x.0 x ) 8 80 008 Washer, Lock Split (M8) 9 9 08 Sender, Water Temperature 0 80 00 7 Washer, Lock Split (M0) 800 088 7 Screw, Cap Hex Head (M0 x. x ) 09 Cable, Battery 09 Boot, Battery Red 0 Hose, Breather 0 Hose, Crank Case Vent Clamp, J 7 0 08 Clamp, Hose 8 08 Grommet 9 0 Insulation, Hose 0 Module, Ignition 087 0 Spec A C 0890 0 Begin Spec D (V0 Turbo) 0 98 Cover, Rocker 0 Cap, Heater Tube (/ ) 0 Cap, Heater Tube (/8 ) 77 0 Separater, Oil 08 Grommet 0 0 0 Fitting, Hose 7 09 Tie, Cable 8 0 9 Adapter, Hose 9 0 8 Thermostat 8 F (Ford Part Number YC 87 BA) (Not Illustrated) 0 Thermostat 9 F (Ford Part Number YC 87 AA) (Optional) (Not Illustrated) 7 9 A/R Plug, Spark (Ford Part Number AGSF FM) (.0 Gap) (Not Illustrated) 8 070 Clamp, J 08 Boot, Starter Red 8 0 Harness, Jumper 8 000 Washer, Lock W/EIT (/) Harness, Ignition 087 Spec A C 8 Begin Spec D 7 8 000 Washer, Lock W/EIT (#0) 8 0008 Washer, Flat (#0) 9
Fuel System Natural Gas 8 0 8 7 9 7 9 9 8 0 7 0 8 0 Bracket, Fuel System Mounting 800 08 Screw, Cap Hex Head (M0 x. x ) 00 Washer, Flat (M8) 800 07 0 Screw, Cap Hex Head (M8 x. x ) 8 0 Regulator, Natural Gas Nipple, Pipe (-/ x.) 0 077 Fuel Systems Without Pressure Switch 0 077 Fuel Systems With Pressure Switch 7 0 00 Elbow, Pipe 8 0 07 Nipple, Pipe (-/ x.00) 9 07 88 Valve, Solenoid 0 0 097 Bushing, Reducer (. x.7) 0 08 Nipple, Pipe (/ x 9.00) 8 7 Mixer (Includes Parts Marked *) 8 7 0 * Adapter, Hose 0 * G 7 Gasket 00 * G Gasket 0 09 # Tee, Pipe 7 0 00 # Bushing, Reducer (-/ x.00) 8 0 080 # Bushing, Reducer (.00 x /) 9 8 70 0 # Harness, Fuel Alarm 0 0 0007 # Bushing, Reducer (/ x /8) 09 09 # Switch, Low Pressure 0 8 Connector, Hose 8 089 Clamp, Fuel System (.) 8 00 0 Screw, Hex Head (M8 x. x 0) 0 Cleaner, Air (Includes Stud and Wing Nut) 0 Element, Replacement Air Cleaner 7 8 8 Hose, Mixer Adapter 8 0 870 0 Clamp, Hose 9 Clamp, Muffler (.0 ) 0 8 0 Bracket, Fuel System Support 07 Washer, Flat 800 089 Screw, Cap Hex Head (M0 x. x 0) 0 00 Stud Air Cleaner * Parts Included with 8 7 Mixer # Parts Included with Fuel Systems With Pressure Switch 0
Fuel System Propane Vapor Withdrawl Spec A B 0 9 7 0 9 8 7 8 9 0 7 8 0 8 0 Bracket, Fuel System Mounting 800 08 Screw, Cap Hex Head (M0 x. x ) 00 Washer, Flat (M8) 800 07 0 Screw, Cap Hex Head (M8 x. x ) 8 0 Regulator, Propane Vapor Nipple, Pipe (.00 x.00) 0 007 Fuel Systems Without Pressure Switch 0 007 Fuel Systems With Pressure Switch 7 0 00 Elbow, Pipe 8 0 09 Bushing, Reducer (.00 x.7) 9 0 0090 Nipple, Pipe (.00 x.00) 0 07 88 Valve, Solenoid 0 08 Nipple, Pipe (/ x 9.00) 8 7 Mixer (Includes Parts Marked *) 8 7 0 * Adapter, Hose 0 * G 7 Gasket 00 * G Gasket 0 00 # Tee, Pipe 7 0 080 # Bushing, Reducer (.00 x /) 8 8 70 0 # Harness, Fuel Alarm 9 0 0007 # Bushing, Reducer (/ x /8) 0 09 09 # Switch, Low Pressure 0 8 Connector, Hose 8 089 Clamp, Fuel System (.) 8 00 0 Screw, Hex Head (M8 x. x 0) 0 Cleaner, Air (Includes Stud and Wing Nut) 0 Element, Replacement Air Cleaner 8 8 Hose, Mixer Adapter 7 0 870 0 Clamp, Hose 8 Clamp, Muffler (.0 ) 9 8 0 Bracket, Fuel System Support 0 07 Washer, Flat 800 089 Screw, Cap Hex Head (M0 x. x 0) 0 00 Stud Air Cleaner * Parts Included with 8 7 Mixer # Parts Included with Fuel Systems With Pressure Switch
Fuel System Propane Liquid Withdrawl Spec A B 0 7 8 9 0 0 0 7 9 7 9 7 8 7 8 9 8 0 9 7 8
Fuel System Propane Liquid Withdrawl Spec A B 8 0 Bracket, Fuel System Mounting 0 097 Reducer, Bushing Pipe (. x.7) 0 079 Cap, Pipe (.00) 8 8 0 Harness, Wiring Dual Fuel (Includes Relay) 07 87 0 Relay ( Volt) 0 08 Nipple, Pipe (/ x 9.00) 7 8 7 Mixer (Includes Parts Marked *) 8 8 7 0 * Adapter, Hose 9 0 * G 7 Gasket 0 00 * G Gasket 0 8 Connector, Hose 0 09 Tee, Pipe 0 08 Nipple, Pipe (-/ x.00) 0 07 Elbow, Reducer 90 ( x.) 0 000 Nipple, Pipe ( x.0) 8 0 Valve, Load Adjusting 7 0 08 Nipple, Pipe ( x 0.00) 8 8 00 0 Screw, Hex Head (M x x ) 9 8 0 Bracket, Fuel System Support 0 0 Cleaner, Air (Includes Stud and Wing Nut) 0 Element, Replacement Air Cleaner 8 8 Hose, Mixer Adapter 0 870 0 Clamp, Hose 00 Washer, Flat (M8) 800 07 0 Screw, Cap Hex Head (M8 x. x ) Clamp, Muffler (.0 ) 7 07 Washer, Flat 8 800 089 Screw, Cap Hex Head (M0 x. x 0) 9 800 08 Screw, Cap Hex Head (M0 x. x ) 0 8 090 Clamp, Fuel System (.00) 8 00 0 Screw, Hex Head (M8 x. x 0) 8 8 0 Bracket, Converter 800 Screw, Cap Hex Head (M x.7 x ) (Genset Mounted Converter Only) 8 0 Converter, Gas 8 Solenoid, Primer 0 000 Nipple, Pipe ( x.0) 7 0 00 Tee, Pipe 8 0 008 Nipple, Pipe ( x.0) 9 0 00 Elbow, Pipe 0 0 00 Hose 0 00 Elbow, Pipe Street 0 0099 Nipple, Pipe (/ x.88) 07 08 0 Valve, Solenoid 0 09 Elbow, Hose 90 0 988 Hose Bulk (Order by the Foot 8 Feet Required) 0 00 Connector, Hose (/ x /8) 7 0 000 Elbow, Pipe 8 0 087 Hose, Barb 9 0 09 Hose Bulk (Order by the Foot Foot Required) 0 8 09 Screw, Hex Washer Head (M x x 0) Clamp, J 0 08 Clamp, Hose 0 87 0 Clamp, Hose 8 0 Harness, LPG 0 00 Stud Air Cleaner * Parts Included with 8 7 Mixer
Fuel System Natural Gas / Propane Vapor Withdrawl With Automatic Changeover Spec A B 7 7 8 0 7 9 8 0 8 0 9 8 7 7 8 0 9 9 9
Fuel System Natural Gas / Propane Vapor Withdrawl With Automatic Changeover Spec A B 8 0 Bracket, Fuel System Mounting 800 08 Screw, Cap Hex Head (M0 x. x ) 00 Washer, Flat (M8) 800 07 0 Screw, Cap Hex Head (M8 x. x ) 8 0 Regulator, Natural Gas 0 077 Nipple, Pipe (-/ x.) 7 0 09 Tee, Pipe 8 0 097 Bushing, Reducer (. x.7) 9 0 08 Nipple, Pipe (/ x 9.00) 0 8 7 Mixer (Includes Parts Marked *) 8 7 0 * Adapter, Hose 0 * G 7 Gasket 00 * G Gasket 0 07 Nipple, Pipe (-/ x.00) 07 88 Valve, Solenoid 0 08 Nipple, Pipe (-/ x.00) 7 0 07 Elbow, Reducer 90 ( x.) 8 0 000 Nipple, Pipe ( x.0) 9 8 0 Valve, Load Adjusting 0 0 0090 Nipple, Pipe ( x.00) 8 0 Regulator, Propane Vapor 07 88 Valve, Solenoid 0 00 Bushing, Reducer (-/ x.00) 0 080 Bushing, Reducer (.00 x /) 8 8 0 Harness, Dual Fuel 0 0007 Bushing, Reducer (/ x /8) 7 09 09 Switch, Low Pressure 8 0 8 Connector, Hose 9 8 07 Harness, Fuel Alarm 0 8 090 Clamp, Fuel System (.00) 8 089 Clamp, Fuel System (.) 8 00 0 Screw, Hex Head (M8 x. x 0) 0 Cleaner, Air (Includes Stud and Wing Nut) 0 Element, Replacement Air Cleaner 8 8 Hose, Mixer Adapter 0 870 0 Clamp, Hose 7 Clamp, Muffler (.0 ) 8 8 0 Bracket, Fuel System Support 9 07 Washer, Flat 0 800 089 Screw, Cap Hex Head (M0 x. x 0) 0 00 Stud Air Cleaner * Parts Included with 8 7 Mixer
Fuel System Natural Gas / Propane Liquid Withdrawl With Automatic Changeover Spec A B
Fuel System Natural Gas / Propane Liquid Withdrawl With Automatic Changeover Spec A B 7
Fuel System Natural Gas / Propane Vapor Withdrawl With Automatic Changeover Begin Spec C 8 0 9 8 7 9 8 0 0 7 9 9 8 7 0 7 7 0 8
Fuel System Natural Gas / Propane Vapor Withdrawl With Automatic Changeover Begin Spec C 8 0 Bracket, Fuel System Mounting 8 00 0 Mixer ITB 08 Gasket, Throttle Body 8 7 Adapter, Mixer 0 00 Valve, Fuel Manual 00 0 0 Valve, Fuel Automatic 7 8 Gasket, Mixer With Automatic Fuel Valve 8 80 9 Screw, Cap Socket Head (M x 0.8 x 7) With Automatic Fuel Valve 9 80 8 Screw, Cap Socket Head 0 0 08 Nipple, Pipe (/ x 8.00) 0 09 Bushing, Reducer ( x /) 0 00 Tee, Pipe 0 07 Nipple, Pipe ( x.0) Nipple, Pipe ( x.0) 0 000 Automatic Fuel Valve 0 000 Manual Fuel Valve 0 00 Elbow, Pipe 8 0 Regulator, Fuel 7 8 0 Valve, Load Adjusting With Manual Fuel Valve 8 0 07 Nipple, Pipe ( x.0) 9 Nipple, Pipe 0 08 With Automatic Fuel Valve 0 0090 With Manual Fuel Valve ( x.00) 0 07 88 Valve, Solenoid 0 007 Nipple, Pipe ( x.00) 0 080 Bushing, Reducer (.00 x /) 0 0007 Bushing, Reducer (/ x /8) 09 09 0 Switch, Low Pressure 0 9 Connector, Hose 8 090 Clamp, Fuel System (.00) 7 8 00 0 Screw, Hex Head (M8 x. x ) 8 00 Washer, Flat (M8) 9 800 07 0 Screw, Cap Hex Head (M8 x. x ) 0 07 Washer, Flat 800 08 Screw, Cap Hex Head (M0 x. x ) Clamp, Muffler (.0 ) 8 7 0 Bracket, Fuel System Support 800 090 Screw, Cap Hex Head (M0 x. x ) 0077 Washer, Flat (/8) 8 8 0 Harness, Dual Fuel (Includes Relay) 7 07 87 0 Relay (V) 8 8 8 Hose, Mixer Adapter 9 0 870 0 Clamp, Hose 9
Fuel System Natural Gas / Propane Vapor Begin Spec C 9 8 0 7 8 9 7 9 0 0 7 7 8 0
Fuel System Natural Gas / Propane Vapor Begin Spec C 8 0 Bracket, Fuel System Mounting 8 00 0 Mixer ITB 08 Gasket, Throttle Body 8 7 Adapter, Mixer 0 00 Valve, Fuel Manual 00 0 0 Valve, Fuel Automatic 7 80 8 Screw, Cap Socket Head (M x.0 x 0) 8 8 Gasket, Mixer With Automatic Fuel Valve 9 80 9 Screw, Cap Socket Head (M x 0.8 x 7) With Automatic Fuel Valve 0 0 08 Nipple, Pipe (/ x 8.00) 0 09 Bushing, Reducer ( x /) 0 00 Elbow, Pipe 0 000 Nipple, Pipe ( x.0) 8 0 Regulator, Fuel 0 07 Nipple, Pipe ( x.0) 07 88 Valve, Solenoid 7 0 007 Nipple, Pipe ( x.00) With Low Pressure Switch 8 0 00 Tee, Pipe With Low Pressure Switch 9 0 080 Bushing, Reducer (.00 x /) With Low Pressure Switch 0 0 0007 Bushing, Reducer (/ x /8) With Low Pressure Switch 09 09 0 Switch, Low Pressure 0 9 Connector, Hose 8 090 Clamp, Fuel System (.00) 8 00 0 Screw, Hex Head (M8 x. x ) 00 Washer, Flat (M8) 800 07 0 Screw, Cap Hex Head (M8 x. x ) 7 07 Washer, Flat 8 800 08 Screw, Cap Hex Head (M0 x. x ) 9 Clamp, Muffler (.0 ) 0 8 7 0 Bracket, Fuel System Support 800 090 Screw, Cap Hex Head (M0 x. x ) 0077 Washer, Flat (/8) 8 8 Hose, Mixer Adapter 0 870 0 Clamp, Hose
Fuel System LP Liquid Begin Spec C 9 9 0 7 0 8 9 7 8 0 0 9 8 7 0 8 9 0 0 9 9 9 7 8 7 8 9 7
Fuel System LP Liquid Begin Spec C 8 0 Bracket, Fuel System Mounting 8 00 0 Mixer ITB 08 Gasket, Throttle Body 8 7 Adapter, Mixer 0 00 Valve, Fuel Manual 00 0 0 Valve, Fuel Automatic 7 80 8 Screw, Cap Socket Head (M x.0 x 0) 8 8 Gasket, Mixer With Automatic Fuel Valve 9 80 9 Screw, Cap Socket Head (M x 0.8 x 7) With Automatic Fuel Valve 0 0 08 Nipple, Pipe (/ x 8.00) 0 09 Bushing, Reducer ( x /) 0 00 Elbow, Pipe 0 000 Nipple, Pipe ( x.0) 8 0 Regulator, Fuel 0 07 Nipple, Pipe ( x.0) 07 88 Valve, Solenoid 7 0 007 Nipple, Pipe ( x.00) 8 0 9 Connector, Hose 9 8 090 Clamp, Fuel System (.00) 0 8 00 0 Screw, Hex Head (M8 x. x ) 00 Washer, Flat (M8) 800 07 0 Screw, Cap Hex Head (M8 x. x ) 07 Washer, Flat 800 08 Screw, Cap Hex Head (M0 x. x ) Clamp, Muffler (.0 ) 8 7 0 Bracket, Fuel System Support 7 800 090 Screw, Cap Hex Head (M0 x. x ) 8 0077 Washer, Flat (/8) 9 8 8 Hose, Mixer Adapter 0 0 870 0 Clamp, Hose 8 8 0 Bracket, Converter 8 0 Converter 0 00 Elbow, Street Pipe 0 0099 Nipple, Pipe (/ x.88) 07 08 0 Valve, Solenoid 0 09 Elbow, 90 Hose 7 0 9 0 Hose, Coolant 8 0 9 0 Hose, Coolant 9 0 08 Clamp, Hose 0 0 00 Connector, Hose (/ x /8) 0 000 Elbow, Pipe 0 087 Hose, Barb 0 09 Hose, Water Bulk (Order by the Foot Foot Required) 0 870 0 Clamp, Hose 0 007 Nipple, Pipe ( x.00) 0 00 Tee, Pipe 7 0 079 Cap, Pipe 8 0 0087 Nipple, Pipe ( x.00) 9 0 00 Elbow, Pipe 0 0 0 0 Connector, Hose 8 09 Screw, Hex Washer Head (M x x 0) 0 0 0 Spacer, Shock Absorber UCD Generator 800 099 Screw, Cap Hex Head (M0 x. x 90) UCD Generator 800 Screw, Cap Hex Head (M x. x ) UC7 Generator 0 0 Hose, Fuel 9 Clamp, J 7 800 0 Screw, Cap Hex Head (M x x 0) 8 008 Washer, Flat (/) 9 80 007 Nut, Hex (M x ) 0 8 Harness, Jumper 0 7 0 Clamp, Hose
Fuel System Natural Gas / Propane Liquid Withdrawl With Automatic Changeover Begin Spec C 8 0 8 9 7 8 9 7 9 8 0 0 9 9 8 7 0 0 7 7 7 0 8 9 9 70 70 8 8 8 7 0 9 0 8 7
Fuel System Natural Gas / Propane Liquid Withdrawl With Automatic Changeover Begin Spec C 8 0 Bracket, Fuel System Mounting 8 00 0 Mixer ITB 08 Gasket, Throttle Body 8 7 Adapter, Mixer 0 00 Valve, Fuel Manual 00 0 0 Valve, Fuel Automatic 7 8 Gasket, Mixer With Automatic Fuel Valve 8 80 9 Screw, Cap Socket Head (M x 0.8 x 7) With Automatic Fuel Valve 9 80 8 Screw, Cap Socket Head 0 0 08 Nipple, Pipe (/ x 8.00) 0 09 Bushing, Reducer ( x /) 0 00 Tee, Pipe 0 07 Nipple, Pipe ( x.0) Nipple, Pipe ( x.0) 0 000 Automatic Fuel Valve 0 000 Manual Fuel Valve 0 00 Elbow, Pipe 8 0 Regulator, Fuel 7 8 0 Valve, Load Adjusting With Manual Fuel Valve 8 0 07 Nipple, Pipe ( x.0) 9 Nipple, Pipe 0 08 With Automatic Fuel Valve ( x 0.00) 0 0090 With Manual Fuel Valve ( x.00) 0 07 88 Valve, Solenoid 0 007 Nipple, Pipe ( x.00) 0 080 Bushing, Reducer (.00 x /) 0 0007 Bushing, Reducer (/ x /8) 09 09 0 Switch, Low Pressure 0 9 Connector, Hose 8 090 Clamp, Fuel System (.00) 7 8 00 0 Screw, Hex Head (M8 x. x ) 8 00 Washer, Flat (M8) 9 800 07 0 Screw, Cap Hex Head (M8 x. x ) 0 07 Washer, Flat 800 08 Screw, Cap Hex Head (M0 x. x ) Clamp, Muffler (.0 ) 8 7 0 Bracket, Fuel System Support 800 090 Screw, Cap Hex Head (M0 x. x ) 0077 Washer, Flat (/8) 8 8 0 Harness, Dual Fuel (Includes Relay) 7 07 87 0 Relay (V) 8 8 8 Hose, Mixer Adapter 9 0 870 0 Clamp, Hose 0 8 8 0 Bracket, Converter 8 0 Converter 0 00 Elbow, Street Pipe 0 0099 Nipple, Pipe (/ x.88) 07 08 0 Valve, Solenoid 0 09 Elbow, 90 Hose 0 9 0 Hose, Coolant 7 0 9 0 Hose, Coolant 8 0 08 Clamp, Hose 9 0 00 Connector, Hose (/ x /8) 0 0 000 Elbow, Pipe 0 087 Hose, Barb 0 09 Hose, Water Bulk (Order by the Foot Foot Required) 0 870 0 Clamp, Hose 0 007 Nipple, Pipe ( x.00) 0 00 Tee, Pipe 0 079 Cap, Pipe 7 0 0087 Nipple, Pipe ( x.00) 8 0 00 Elbow, Pipe 9 0 0 0 Connector, Hose 0 8 09 Screw, Hex Washer Head (M x x 0) 0 0 0 Spacer, Shock Absorber UCD Generator 800 099 Screw, Cap Hex Head (M0 x. x 90) UCD Generator 800 Screw, Cap Hex Head (M x. x ) UC7 Generator 0 0 Hose, Fuel 9 Clamp, J 800 0 Screw, Cap Hex Head (M x x 0) 7 008 Washer, Flat (/) 8 80 007 Nut, Hex (M x ) 9 8 9 Harness, Jumper 70 0 7 0 Clamp, Hose
Map Sensor Begin Spec C 0 8 0 Tee, Street Modified 9 09 Sensor, Map 09 Clamp, Tie Connector, Hose 0 99 (/8 x /) Spec C 0 0 (/8 x /8) Begin Spec D
Air Cleaner Standard Begin Spec C 0 Hose, Air 0 Screw, Hose Clamp 0 Cleaner, Air 0 8 Element, Replacement 7
Exhaust System Residential 9 9 0 8 7 7 9 8 0 8 7 9 0 8
Exhaust System Residential 0 Tube, Exhaust 7 0 Gasket, Turbocharger 079 Turbocharger 09 Manifold, Exhaust 9 Tube, Exhaust Clamp, V-Band 7 0 0 Silencer Critical 8 9 Gasket, Muffler 9 80 0 Shield, Rain 0 0 Clamp, Muffler ( ) 0 Cap, Rain 8 00 0 Screw, Hex Head (M8 x. x 0) 0 7 Elbow, Hose Barb 0 Hose, Turbo Drain 7 0 Gasket, Oil Drain 088 0 Tube, Oil Drain 7 80 008 Washer, Lock Split (M8) 8 800 09 Screw, Cap Hex Head (M8 x. x 0) 9 0 08 Clamp, Hose 0 0 Washer, Flat (M) 800 Screw, Cap Hex Head (M x.7 x ) 0 07 Stud (M0 x. x 0) 0 Gasket, Exhaust Manifold 0 Gasket, Exhaust Manifold 0 Washer, Flat (M0) 80 009 Nut, Hex (M0 x.) 7 09 090 0 Seal, O-Ring (/) 8 0 8 Connector, Restricted 9 0 0 Adapter, Pipe 0 7 0 Tube, Turbo Feed Clamp, J 800 08 Screw, Cap Hex Head (M0 x. x 0) 0 Clamp 0 7 0 Guard, Fan 0 0 0 Cover, Guard Fan 88 0 0 Rivet, Pop 9
Exhaust System Industrial 8 7 9 0 7 0 8 7 0 9 7 9 8 8 9 0
Exhaust System Industrial 0 Tube, Exhaust 7 0 Gasket, Turbocharger 079 Turbocharger 09 Manifold, Exhaust Clamp, V-Band 9 Silencer 7 0 0 Shield, Rain 8 0 0 Cap, Rain 9 0 7 Elbow, Hose Barb 0 0 Hose, Turbo Drain 7 0 Gasket, Oil Drain 088 0 Tube, Oil Drain 80 008 Washer, Lock Split (M8) 800 09 Screw, Cap Hex Head (M8 x. x 0) 0 08 Clamp, Hose 0 Washer, Flat (M) 7 800 Screw, Cap Hex Head (M x.7 x ) 8 0 07 Stud (M0 x. x 0) 9 0 Gasket, Exhaust Manifold 0 0 Gasket, Exhaust Manifold 0 Washer, Flat (M0) 80 009 Nut, Hex (M0 x.) 09 090 0 Seal, O-Ring (/) 0 8 Connector, Restricted 0 0 Adapter, Pipe 7 0 Tube, Turbo Feed 7 Clamp, J 8 800 08 Screw, Cap Hex Head (M0 x. x 0) 9 08 Washer, Flat (M) 0 800 0 Screw, Cap Hex Head (M x x ) 0 Clamp
Exhaust System With Threaded Exhaust Pipe 0 9 0 8 7 8 9 0 7 9 8 7 8 8
Exhaust System With Threaded Exhaust Pipe 0 Tube, Exhaust 7 0 Gasket, Turbocharger 079 Turbocharger 09 Manifold, Exhaust Clamp, V-Band 0 7 Elbow, Hose Barb 7 0 Hose, Turbo Drain 8 7 0 Gasket, Oil Drain 9 088 0 Tube, Oil Drain 0 80 008 Washer, Lock Split (M8) 800 09 Screw, Cap Hex Head (M8 x. x 0) 0 08 Clamp, Hose 0 Washer, Flat (M) 800 Screw, Cap Hex Head (M x.7 x ) 0 07 Stud (M0 x. x 0) 0 Gasket, Exhaust Manifold 7 0 Gasket, Exhaust Manifold 8 0 Washer, Flat (M0) 9 80 009 Nut, Hex (M0 x.) 0 09 090 0 Seal, O-Ring (/) 0 8 Connector, Restricted 0 0 Adapter, Pipe 7 0 Tube, Turbo Feed Clamp, J 800 08 Screw, Cap Hex Head (M0 x. x 0) Adapter, Exhaust 7 0 Clamp 8 0 7 0 Guard, Fan 9 0 0 0 Cover, Guard Fan 0 88 0 0 Rivet, Pop
Exhaust System With L0 Low Emissions and Threaded Exhaust Pipe Begin Spec C 7 8 8 9 9 9 0 9 7 7 0 8 0
Exhaust System With L0 Low Emissions and Threaded Exhaust Pipe Begin Spec C 0 Tube, Exhaust 7 0 Gasket, Turbocharger 079 Turbocharger 09 Manifold, Exhaust 0 7 Elbow, Hose Barb 0 Hose, Turbo Drain 7 7 0 Gasket, Oil Drain 8 088 0 Tube, Oil Drain 9 80 008 Washer, Lock Split (M8) 0 800 09 Screw, Cap Hex Head (M8 x. x 0) 0 08 Clamp, Hose 0 Washer, Flat (M) 800 Screw, Cap Hex Head (M x.7 x ) 09 090 0 Seal, O-Ring (/) 0 8 Connector, Restricted 0 0 Adapter, Pipe 7 7 0 Tube, Turbo Feed 8 7 Converter, Catalytic 9 Clamp, V-Band 0 0 Gasket, Exhaust Manifold 0 Gasket, Exhaust Manifold 0 07 Stud (M0 x. x 0) 0 Washer, Flat (M0) 80 009 Nut, Hex (M0 x.) Clamp, J 800 08 Screw, Cap Hex Head (M0 x. x 0) 7 0 Clamp, Hose 8 7 Elbow, Exhaust 9 9 099 Sensor, Oxygen 0 008 Washer, Flat 800 0 Screw, Cap Hex Head (M x.0 x ) 0 7 0 Guard, Fan 0 0 0 Cover, Guard Fan 88 0 0 Rivet, Pop
Exhaust System With L0 Low Emissions and Mounted Muffler Begin Spec C 8 0 9 8 7 8 7 9 8 9 0 0 7 9 0 8
Exhaust System With L0 Low Emissions and Mounted Muffler Begin Spec C 0 Tube, Exhaust 7 0 Gasket, Turbocharger 079 Turbocharger 09 Manifold, Exhaust 7 Converter, Catalytic Clamp, V-Band 7 0 07 Stud (M0 x. x 0) 8 0 Washer, Flat (M0) 9 80 009 Nut, Hex (M0 x.) 0 0 Washer, Flat (M) 800 Screw, Cap Hex Head (M x.7 x ) 0 Gasket, Exhaust Manifold 0 Gasket, Exhaust Manifold 0 0 Shield, Rain 0 0 Cap, Rain 008 Washer, Flat 7 800 0 Screw, Cap Hex Head (M x.0 x ) 8 7 0 Gasket, Oil Drain 9 088 0 Tube, Oil Drain 0 80 008 Washer, Lock Split (M8) 800 09 Screw, Cap Hex Head (M8 x. x 0) 0 8 Connector, Restricted 0 0 Adapter, Pipe 7 0 Tube, Turbo Feed 0 7 Elbow, Hose Barb 0 Hose, Turbo Drain 7 0 08 Clamp, Hose 8 09 090 0 Seal, O-Ring (/) 9 Clamp, J 0 800 08 Screw, Cap Hex Head (M0 x. x 0) 0 Clamp, Hose 7 Elbow, Exhaust 9 099 Sensor, Oxygen 0 7 0 Guard, Fan 0 0 0 Cover, Guard Fan 88 0 0 Rivet, Pop 7
Exhaust System Critical With L0 Low Emissions and F7/F7 Housing Begin Spec C 7 8 7 9 8 9 9 0 9 0 7 7 8 0 9 0 8 8
Exhaust System Critical With L0 Low Emissions and F7/F7 Housing Begin Spec C 0 Tube, Exhaust 7 0 Gasket, Turbocharger 079 Turbocharger 09 Manifold, Exhaust 0 7 Elbow, Hose Barb 0 Hose, Turbo Drain 7 7 0 Gasket, Oil Drain 8 088 0 Tube, Oil Drain 9 80 008 Washer, Lock Split (M8) 0 800 09 Screw, Cap Hex Head (M8 x. x 0) 0 08 Clamp, Hose 0 Washer, Flat (M) 800 Screw, Cap Hex Head (M x.7 x ) 09 090 0 Seal, O-Ring (/) 0 8 Connector, Restricted 0 0 Adapter, Pipe 7 7 0 Tube, Turbo Feed 8 7 Converter, Catalytic 9 Clamp, V-Band 0 0 Gasket, Exhaust Manifold 0 Gasket, Exhaust Manifold 0 07 Stud (M0 x. x 0) 0 Washer, Flat (M0) 80 009 Nut, Hex (M0 x.) Clamp, J 800 08 Screw, Cap Hex Head (M0 x. x 0) 7 0 Clamp, Hose 8 9 099 Sensor, Oxygen 9 008 Washer, Flat 0 800 0 Screw, Cap Hex Head (M x.0 x ) 0 0 Silencer Critical 9 Gasket, Muffler 80 Shield, Rain 0 Clamp, Muffler 0 Cap, Rain 8 00 0 Screw, Hex Head (M8 x. x 0) 7 7 Transition, Exhaust 8 0 7 0 Guard, Fan 9 0 0 0 Cover, Guard Fan 0 88 0 0 Rivet, Pop 9
Exhaust System With F8 Housing 7 8 9 8 8 0 8 9 0 7 9 7 0 0
Exhaust System With F8 Housing 0 Tube, Exhaust 7 0 Gasket, Turbocharger 079 Turbocharger 09 Manifold, Exhaust 9 Muffler, Exhaust Clamp, V-Band 7 0 07 Stud (M0 x. x 0) 8 0 Washer, Flat (M0) 9 80 009 Nut, Hex (M0 x.) 0 0 Washer, Flat (M) 800 Screw, Cap Hex Head (M x.7 x ) 0 Gasket, Exhaust Manifold 0 Gasket, Exhaust Manifold 0 0 Shield, Rain 0 0 Cap, Rain 008 Washer, Flat 7 800 0 Screw, Cap Hex Head (M x.0 x ) 8 7 0 Gasket, Oil Drain 9 088 0 Tube, Oil Drain 0 80 008 Washer, Lock Split (M8) 800 09 Screw, Cap Hex Head (M8 x. x 0) 0 8 Connector, Restricted 0 0 Adapter, Pipe 7 0 Tube, Turbo Feed 0 7 Elbow, Hose Barb 0 Hose, Turbo Drain 7 0 08 Clamp, Hose 8 09 090 0 Seal, O-Ring (/) 9 Clamp, J 0 800 08 Screw, Cap Hex Head (M0 x. x 0) 0 Clamp, Hose
Exhaust System F7/F7 Housing 9 8 7 7 8 9 0 9 0 0 7 8
Exhaust System F7/F7 Housing 0 Tube, Exhaust 7 0 Gasket, Turbocharger 079 Turbocharger 09 Manifold, Exhaust 9 Tube, Exhaust Clamp, V-Band 7 0 0 Silencer Critical 8 9 Gasket, Muffler 9 80 0 Shield, Rain 0 0 Clamp, Muffler 0 Cap, Rain 8 00 0 Screw, Hex Head (M8 x. x 0) 0 7 Elbow, Hose Barb 0 Hose, Turbo Drain 7 0 Gasket, Oil Drain 088 0 Tube, Oil Drain 7 80 008 Washer, Lock Split (M8) 8 800 09 Screw, Cap Hex Head (M8 x. x 0) 9 0 08 Clamp, Hose 0 0 Washer, Flat (M) 800 Screw, Cap Hex Head (M x.7 x ) 0 07 Stud (M0 x. x 0) 0 Gasket, Exhaust Manifold 0 Gasket, Exhaust Manifold 0 Washer, Flat (M0) 80 009 Nut, Hex (M0 x.) 7 09 090 0 Seal, O-Ring (/) 8 0 8 Connector, Restricted 9 0 0 Adapter, Pipe 0 7 0 Tube, Turbo Feed Clamp, J 800 08 Screw, Cap Hex Head (M0 x. x 0) 0 Clamp, Hose
Exhaust System With L0 Low Emissions and F8 Housing Begin Spec C 8 7 9 8 9 9 0 9 7 7 0 8 0
Exhaust System With L0 Low Emissions and F8 Housing Begin Spec C 0 Tube, Exhaust 7 0 Gasket, Turbocharger 079 Turbocharger 09 Manifold, Exhaust 0 7 Elbow, Hose Barb 0 Hose, Turbo Drain 7 7 0 Gasket, Oil Drain 8 088 0 Tube, Oil Drain 9 80 008 Washer, Lock Split (M8) 0 800 09 Screw, Cap Hex Head (M8 x. x 0) 0 08 Clamp, Hose 0 Washer, Flat (M) 800 Screw, Cap Hex Head (M x.7 x ) 09 090 0 Seal, O-Ring (/) 0 8 Connector, Restricted 0 0 Adapter, Pipe 7 7 0 Tube, Turbo Feed 8 7 Converter, Catalytic 9 Clamp, V-Band 0 0 Gasket, Exhaust Manifold 0 Gasket, Exhaust Manifold 0 07 Stud (M0 x. x 0) 0 Washer, Flat (M0) 80 009 Nut, Hex (M0 x.) Clamp, J 800 08 Screw, Cap Hex Head (M0 x. x 0) 7 0 Clamp, Hose 8 9 099 Sensor, Oxygen 9 008 Washer, Flat 0 800 0 Screw, Cap Hex Head (M x.0 x ) 0 0 Shield, Rain 0 0 Cap, Rain 7 Elbow, Exhaust
Low Coolant Level Sender Without Continuously Monitored Low Coolant Level 8 7 Harness, Low Coolant Level (Includes Parts Marked *) 9 08 Sender, Low Coolant Level 7 *Housing, Connector ( Pin) 709 *Socket, Contact (Used in S7) 708 *Seal, Cable 7 *Plug, Cavity * Parts Included in 8 7 Wiring Harness
Low Coolant Level Sender With Continuously Monitored Low Coolant Level Light Indicator Controls 7 8 0 07 Lens, Replacement 8 0 0 Harness, Low Coolant Level 9 08 Sender, Low Coolant Level 7 000 Rectifier, Silicon 8 9 Harness, Pigtail (Includes Parts Marked *) 7 *Housing, Connector ( Pin) 7 709 *Socket, Contact (Used in S) 8 708 *Seal, Cable * Parts Included in 8 9 Pigtail Harness 7
Coolant Heater 0 Bracket, Mounting Heater, Coolant 088 0 0 Volt 088 0 0 Volt 0 09 Connector, Hose 0 08 Hose, Heater Bulk (Order by the Foot Feet Required) 0 08 Clamp, Hose 8 00 0 Screw, Hex Head Stainless Steel (M x x ) 8
Oil Drain Extension Spec A B 0 0 Adapter, Oil Drain 0 00 Valve, Shutoff 0 087 Barb, Hose (/ x /) 0 0098 Hose, Oil Drain Bulk (Order by the Foot Feet Required) 0 097 Clip, Hose 0 0 Gasket, Oil Drain 9
Oil Drain Extension Begin Spec C 0 07 Valve, Oil Drain 0 0 0 Adapter, Oil Drain 0 0 Clamp, Hose 0 0 08 Hose, Oil Drain ( ) 0 0 Gasket, Oil Drain 0
Oil Filter 087 Adapter, Oil Filter 08 Gasket, Oil Filter Adapter 088 0 Stud, Oil Filter 08 Filter, Oil 9 08 Sender, Oil Pressure 8 0970 Screw, Hex Flange Head (M8 x. x 0)
Remote Radiator Spec A B 0 7 9 0 8 0 9 8 7 7 0 0 0 Panel, Radiator Housing Front 0 09 0 Panel, Radiator Housing Side 0 97 0 Cover, Shroud Bottom 0 7 0 Guard, Fan Left Side 0 0 Guard, Fan Right Side 0 0 0 Guard, Alternator 7 0 8 0 Guard, Fan Lower 8 0 0 0 Guard, Fan 9 0 0 0 Support, Tube 0 08 00 0 Edging Bulk (Order by the Foot Foot Required) 0 0 Tube, Inlet 0 0 Hose, Inlet 0 0 0 Bracket, Oil Cooler 0 8 Cooler, Oil 0 009 Bushing, Reducer (/ x /8) 0 07 Elbow 90 (.0 x /8 8) 7 0 0 Hose, Hydraulic Bulk (Order by the Foot Feet Required) 8 0 8 Connector, Hose (/8 x /) 9 0 Hose, Radiator Flexible 0 0 0 Clamp, Hose 0 0 Clamp, Hose 8 00 0 Screw, Hex Head (M8 x. x 0) 8 00 0 Screw, Hex Head (M x x )
Remote Radiator Begin Spec C 7 7 9 0 8 8 0 0 0 Panel, Radiator Housing Front 0 09 0 Panel, Radiator Housing Side 0 97 0 Cover, Shroud Bottom 0 7 0 Guard, Fan Left Side 0 0 Guard, Fan Right Side 0 0 0 Guard, Alternator 7 0 8 0 Guard, Fan Lower 8 0 0 0 Guard, Fan 9 0 0 0 Support, Tube 0 08 00 0 Edging Bulk (Order by the Foot Foot Required) 0 0 Tube, Inlet 0 0 Hose, Inlet 0 0 0 Bracket, Oil Cooler 0 0 Clamp, Hose 8 00 0 Screw, Hex Head (M8 x. x 0) 0 0 Tube, Outlet 7 0 Hose, Outlet 8 0 9 0 Hose, Hanger
Radiator 8 0 7 7 7 0 9 7 8 7 8 9 0 7 9
Radiator Radiator (Includes Over Flow Hose) 0 9 0 Row 0 9 0 Row 0 07 Hose, Over Flow Bulk (Order by the Foot Feet Required) 0 9 Side, Housing 0 0 Cover, Shroud 0 98 0 Panel, Shroud Side 0 99 0 Cover, Shroud Latch 7 0 0 Shroud Fan 8 0 0 Spacer, Fan 9 0 87 Fan, Radiator 0 0 7 0 Guard, Fan Right Hand 0 0 Guard, Fan Left Hand 0 0 0 Guard, Alternator 0 8 0 Guard, Fan Lower 0 0 0 Guard, Fan 0 Hose, Radiator 0 0 Tube, Outlet 7 0 Hose, Outlet 8 0 Hose, Inlet 9 0 0 Tube, Inlet 0 0 0 Hose, Inlet 0 7 0 Cap, Radiator ( PSI) 0 000 Cock, Drain 0 0 8 Clamp, Hose 0 Washer, Flat (M8) 800 077 Screw, Cap Hex Head (M8 x. x 0) 8 007 0 Screw, Hex Head (Stainless Steel) (M8 x. x 0) 7 8 00 0 9 Screw, Hex Head (M8 x. x 0) 8 88 0 0 8 Rivet, Pop 9 0 9 0 Hanger, Hose (Lower) 0 0 0 0 Support, Tube 08 00 0 Edging Bulk (Order by the Foot Foot Required)
Duct Adapter 0 Adapter, Duct 0 7 Adapter, Duct Side 88 0 0 Rivet, Pop 0 7 Grille
Radiator Drain Extension 0 008 Nipple, Pipe Brass (/8 ) 0 07 Bushing, Flush (/8 X / ) 0 00 Valve, Shutoff (/ ) 0 087 Barb, Hose (/ x /) 0 9 Hose, Drain ( ) 0 097 Clamp, Hose 7
8 F7 Enclosure 7 8 9 0 0 0 7 8 9 0 7 8 9 0 7 8 9 0 7 8 9 0 0 7 7 8 9 0
F7 Enclosure 0 908 Panel, Side Radiator Housing 0 9 Extension, Side Left Hand 0 9 Post, Corner 0 7 Post, Housing Center 0 998 Support, Muffler 0 9 Box, Muffler 7 0 9 Panel, End Roof 8 0 9 Panel, End Roof 9 0 90 Extension, Side Right Hand 0 0 807 Retainer, Insulation 0 9 Support, Center 0 97 Angle 0 9 Baffle, Air 0 80 Retainer, Insulation 0 80 Retainer, Insulation 0 8 Retainer, Insulation 7 0 9 Roof 8 0 9 Tube, Fill Radiator 9 0 00 Box, Radiator Fill 0 0 909 Panel, Front Radiator Housing 0 97 Panel, End Roof 0 09 Fiberglass 0 08 Hinge, Housing Door, Housing 0 90 7 Without Window 0 90 With Window 0 90 Door, Housing With Window 8 Cover, Exhaust 7 0 88 Insulation, Exhaust Bulk (Order by the Foot 0 Feet Required) 8 0 Washer, Flat Stainless Steel 9 0 097 0 7 Latch, Door 0 0 078 7 Key, Replacement Fits 0 097 0 Latch 098 00 Label, Prototype 098 70 Label, Warning 098 9 Label, Coolant Fill 8 007 0 Screw, Hex Head Stainless Steel (M8 x. x 0) 0 99 Baffle, Recirculation 88 0 0 Rivet, Pop (/ ) 7 88 07 0 9 Rivet, Pop (/8 ) 8 89 0 Weatherstrip Bulk (Order by the foot Feet Required) Units With Window 9 9 Window, Control 0 098 790 0 Label, Logo 7 0 Plug, Hole 89 08 Seal, Weather 89 08 7 Seal, Weather 89 08 7 Seal, Weather 098 7 Label, Caution 0 8 Fiberglass 7 0 8 Retainer, Insulation 8 0 80 Retainer, Insulation 9 7 0 Plug, Hole (.7 ) 0 7 08 07 Plug, Hole (.7 ) 0 00 Air Dam 870 00 Nut, Captive Floating (M x.0) 8 00 0 Screw, Hex Head Stainless Steel (M x x ) 0 98 Cover, Exhaust Inlet 00 Washer, Flat 0 9 Baffle, Air Discharge 7 8 0 Insulation, Foam 8 0 00 0 Fiberglass 9 0 7 Insulation, Door 0 0 00 Fiberglass 0 00 0 Fiberglass 0 000 0 Fiberglass 0 000 0 Fiberglass 0 997 Fiberglass 9
0 F7 Enclosure 7 8 9 0 0 0 7 8 9 0 7 8 9 0 7 8 9 0 7 8 9 0 0 7 7 8 9 0 7 8 9 70 70 7 7 7 7 7 7 7 7 77 78 79 7 80 80
F7 Enclosure 0 908 Panel, Side Radiator Housing 0 9 Extension, Side Left Hand 0 9 Post, Corner 0 7 Post, Housing Center 0 998 Support, Muffler 0 9 Box, Muffler 7 0 9 Panel, End Roof 8 0 9 Panel, End Roof 9 0 90 Extension, Side Right Hand 0 0 9 Retainer, Insulation 0 9 Support, Center 0 97 Angle 0 9 Baffle, Air 0 80 Retainer, Insulation 0 80 Retainer, Insulation 0 8 Retainer, Insulation 7 0 9 Roof 8 0 9 Tube, Fill Radiator 9 0 00 Box, Radiator Fill 0 0 909 Panel, Front Radiator Housing 0 97 Panel, End Roof 0 09 Fiberglass 0 08 Hinge, Housing Door, Housing 0 90 7 Without Window 0 90 With Window 0 90 Door, Housing With Window 8 Cover, Exhaust 7 0 88 Insulation, Exhaust Bulk (Order by the Foot 0 Feet Required) 8 0 Washer, Flat Stainless Steel 9 0 097 0 7 Latch, Door 0 0 078 7 Key, Replacement Fits 0 097 0 Latch 098 00 Label, Prototype 098 70 Label, Warning 098 9 Label, Coolant Fill 8 007 0 9 Screw, Hex Head Stainless Steel (M8 x. x 0) 0 99 Baffle, Recirculation 88 0 0 Rivet, Pop (/ ) 7 88 07 0 0 Rivet, Pop (/8 ) 8 89 0 Weatherstrip Bulk (Order by the foot Feet Required) Units With Window 9 9 Window, Control 0 098 790 0 Label, Logo 7 0 Plug, Hole 89 08 Seal, Weather 89 08 7 Seal, Weather 89 08 7 Seal, Weather 098 7 Label, Caution 0 8 Fiberglass 7 0 8 Retainer, Insulation 8 0 80 Retainer, Insulation 9 7 0 Plug, Hole (.7 ) 0 7 08 07 Plug, Hole (.7 ) 0 00 Air Dam 870 00 Nut, Captive Floating (M x.0) 8 00 0 Screw, Hex Head Stainless Steel (M x x ) 0 98 Cover, Exhaust Inlet 00 Washer, Flat 0 9 Baffle, Air Discharge 7 8 0 Insulation, Foam 8 0 00 0 Fiberglass 9 0 7 Insulation, Door 0 0 00 Fiberglass 0 00 0 Fiberglass 0 000 0 Fiberglass 0 000 0 Fiberglass 0 997 Fiberglass 0 99 0 Panel, Side Discharge (Right Hand) 0 87 0 Panel, Enclosure 7 0 99 0 Panel, Side Discharge (Left Hand) 8 0 99 Panel, Center 9 0 99 Cover, Duct 70 0 808 Retainer, Insulation 7 0 80 Retainer, Insulation 7 0 00 Cover, Air Discharge Box (Top) 7 0 8 Retainer, Insulation 7 0 000 07 Fiberglass 7 0 8 Retainer, Insulation 7 0 000 0 Fiberglass 77 0 989 Cover, Air Discharge Box (Top) 78 0 990 Cover, Air Discharge 79 0 809 Retainer, Insulation 80 0 000 0 Fiberglass
F8 Enclosure 9 9 0 7 7 9 8 0 8
F8 Enclosure 0 908 Panel, Side Radiator Housing 0 909 Panel, Front Radiator Housing 0 9 Roof 0 7 Post, Housing Center 0 9 Angle, Roof 0 9 Post, Corner Housing 7 0 88 Insulation, Foam Bulk (Order by the Foot 0 Feet Required) 8 0 08 Hinge, Door 9 8 Cover, Exhaust 0 098 70 Label, Warning 098 9 Label, Coolant Fill 098 00 Label, Prototype Tested 88 0 0 98 Rivet, Pop (/) 8 007 0 Screw, Hex Head (M8 x. x 0) 0 8 Door, Housing 0 097 0 7 Latch, Door 0 078 7 Key, Replacement (fits Latch 0 097 0) 7 Door, Housing 0 90 Sets With Control Window 0 90 Sets W/O Control Window 8 89 0 Weatherstrip Window Bulk (Order By The Foot Feet Required) 9 9 Window, Control (If Equipped) 0 89 08 Bumper, Door 0 97 Panel, End Roof 88 07 0 Rivet, Pop (/8) 8 0 0 Insulation, Foam 870 00 Nut, Captive Floating (M x.0) 8 00 0 Screw, Hex Head (M x.0 x ) 0 88 0 Insulation, Foam Bulk (Order by the Foot Feet Required)
Battery Tray For Non-UL 00 Approved Generator Sets 0 7 Tray, Battery 8 007 0 Screw, Hex Head (M8 x. x 0) 0 Hold Down, Battery 099 0 Rod, Hold Down Battery 8 000 Nut, Wing (M)
Battery Tray For UL 00 Approved Generator Sets 00 0 Tray, Battery 8 00 0 7 Screw, Hex Head (M8 x. x 0) 0 Cover, Battery 0 0 Hold Down, Battery 099 0 Rod, Battery Hold Down 8 000 Nut, Wing
Skid Pan 0 87 Pan, Skid 0 0 Clamp 8 00 0 Screw, Self Locking Hex Washer Head (M x mm) 0 Cover, Stub Up End (7 / x 8 ) 0 Cover, Stub Up Side (7 / x /8 )
This Page Intentionally Left Blank. 7
Skid Spec A C 9 0 9 8 8 0 8 7 8 7 7 8
Skid Spec A C 0 8 0 Skid 0 0779 0 Isolator, Vibration 08 0 8 Washer, Flat (/) 0 707 0 Bracket, Mounting Engine 7 009 Plug, Hole 800 007 Screw, Cap Hex Head (/ 0 x ) 7 0 8 Washer, Hardened 8 800 0 9 Screw, Cap Hex Head (M x ) 9 07 9 Washer, Flat 0 800 0 0 9 Screw, Cap Hex Head (M0 x. x ) 8 00 Washer, Lock W/EIT (/) 7 0090 Strap, Electrical 0 0 0 Bracket, Ignition Module 8 00 0 Screw, Hex Head (M x.0 x ) 8 079 0 Screw, Hex Flange Head Thread Forming (M x 0.8 x ) 8 00 Nut, Hex (/ 0) 7 0 79 Hose, Vacuum 8 8 000 Washer, Lock W/EIT (/8) 9
Skid Begin Spec D 9 0 9 7 8 0 8 7 8 7 70
Skid Begin Spec D 0 8 0 Skid 0 0779 0 Isolator, Vibration 08 0 8 Washer, Flat (/) 0 707 0 Bracket, Mounting Engine 7 009 Plug, Hole 800 007 Screw, Cap Hex Head (/ 0 x ) 7 0 8 Washer, Hardened 8 800 0 9 Screw, Cap Hex Head (M x ) 9 07 9 Washer, Flat 0 800 0 0 9 Screw, Cap Hex Head (M0 x. x ) 8 00 Washer, Lock W/EIT (/) 7 0090 Strap, Electrical 0 0 0 Bracket, Ignition Module 8 00 0 Screw, Hex Head (M x.0 x ) 8 079 08 Screw, Hex Flange Head Thread Forming (M x 0.8 x ) 8 00 Nut, Hex (/ 0) 7 8 000 Washer, Lock W/EIT (/8) 7
Governor Spec A B 0 7 9 8 08 Plate, Throttle Body Governor 0 79 0 0 Hz GGHG, GGHH 0 79 0 0 Hz GGHH 08 Gasket, Throttle Body 08 Adapter, Throttle Body 0 0 Stud (M) 080 8 Washer, Flat (M) 7 8 00 Nut, Hex (M) 8 0 99 Connector, Hose (/8 x /) 9 0 00 Plug, Square Head 0 7 0 Hose, Turbocharger 0 870 0 Clamp, Hose 0 Pick-Up, Magnetic 800 8 Screw, Cap Hex Head (M x x 80) 078 Gasket, Throttle Body 7
Governor Spec C 9 8 7 0 Adapter, Intake 0 79 09 Governor Complete (Includes Items, and ) 0 7 0 Governor 08 Gasket, Throttle Body 08 Adapter, Throttle Body 0 0 Stud (M) 7 080 Washer, Flat (M) 8 8 00 Nut, Hex (M) 9 0 Connector, Hose (/8 x /) 0 0 00 Plug, Square Head 7 0 Hose, Turbocharger 0 870 0 Clamp, Hose 0 Pick-Up, Magnetic 80 9 Screw, Cap Hex Head (M x.0 x 80) 078 Gasket, Throttle Body 7
Governor Begin Spec D 0 8 7 9 Adapter, Intake 0 7 0 Governor 08 Gasket, Throttle Body 08 Adapter, Throttle Body 0 0 Stud (M) 080 Washer, Flat (M) 7 8 00 Nut, Hex (M) 8 0 0 Connector, Hose 9 0 00 Plug, Square Head 0 7 0 Hose, Turbocharger 0 870 0 Clamp, Hose 0 Pick-Up, Magnetic 80 9 Screw, Cap Hex Head (M x.0 x 80) 078 Gasket, Throttle Body 0 000 0 Elbow, Pipe Street (/8 ) 7
Entrance Box 9 8 7 0 9 07 Panel, Box Top and Bottom 9 978 Panel, Box Side 9 979 0 Cover, Entrance Box 8 00 0 Screw, Self Locking Hex Washer Head (M x x mm) 08 09 Edging Bulk (Order By The Foot Feet Required) 8 0008 Washer, Lock EIT (/ ) 7 8 00 0 Screw, Self Locking Hex Washer Head (M8 x. x 0mm) 8 7 Lug, Solderless 9 9 99 Cover, Control Housing 0 098 7 Label, Ground 7
Control Housing 9 8 0 7 7
Control Housing 9 97 Housing, Control 9 99 Cover, Housing Control 8 00 0 Screw, Hex Head (M x ) 80 009 8 Nut, Hex (M0 x.) 80 00 8 Washer, Lock (M0) 0 8 Washer, Flat (M0) 7 987 Link, Terminal 8 8 00 Screw, Locking Hex Head (/ 8 x.0) 9 8 0008 Washer, Lock ET (/) 0 08 00 0 Edging Bulk (Order by the Foot Foot Required) 7 0 Plug, Hole 88 0 0 Rivet, Pop 88 00 0 Screw, Self-Locking Hex Washer Head (/ x 0.0 ) 9 0 Brace, Control Housing 77
Generator Heater 7 8 0 9 7 8 78
Generator Heater Cartridge, Heater (00 Watt) 08 07 0 Volt 08 08 0 Volt 0 Clamp, Loop 8 07 Screw, Machine Pan Head (M x mm) 80 00 Nut, Hex (M) 80 00 Washer, Lock Spring (M) 00 Washer, Flat (M) 7 0 0 Box, Terminal 8 0 0 0 Cover, Terminal Box 9 0 0 0 Gasket, Terminal Box 0 0 Block, Terminal 08 08 Grommet 8 07 Screw, Machine Pan Head (M x 0mm) 80 00 Washer, Lock Spring (M) 800 0 Screw, Cap Hex Head (M x mm) 8 Mount, Cable Tie 870 0 0 Nut, Hex (M) 7 8 079 0 Screw, Pan Head (M x mm) 8 7 00 Plug, Dot Button 79
80 Generator 8 7 0 9 7 8 0 9 8 0 9 9 8 7 7 0 9 0 8 7 7 8 0 7 9
Generator Stator, Generator (See Separate Pages for Part Numbers) Rotor Assembly, Generator (Includes Parts Marked *) 0 97 0 mm Stack Length 0 97 0 90mm Stack Length 0 97 0 0mm Stack Length 0 97 0 8mm Stack Length 0 97 0 mm Stack Length *Key, Exciter Rotor 097 0 0, 90mm Stack Length 097 0 0, 8mm Stack Length 097 0 mm Stack Length *Rotor Assembly, Exciter (Includes Parts Marked #) 0 0, 90mm Stack Length 0 0 0, 8, mm Stack Length *#Rectifier Assembly (Includes Parts Marked +) 7 009 Forward ( With Positive Diode) 7 009 Reverse (With Negative Diode) *#+Diode 8 0 0 Positive 8 0 0 Negative 7 800 009 *#+Screw, Cap Hex Head (M x mm) (CR,,,,,) 8 80 00 *#+Nut, Hex (M) 9 80 00 *#+Washer, Lock Spring (M) 0 00 *#+Washer, Flat (M) 870 0 0 *#Nut, Locking Nylon (M) 00 *#Washer, Flat (M) 0 0 *Bearing, Ball 8 008 *Ring, Retaining 0 0807 *Varistor 80 00 *Nut, Hex (M) 7 9 *Hub, Drive 8 80 00 *Washer, Lock Spring (M) 9 00 *Washer, Flat (M) 0 09 0 0 O-Ring 07 Adapter, Generator Screw, Cap Hex Head 800 07 M0 x 0mm 800 07 M0 x 0mm ( O Clock Position) 80 0 Washer, Lock Spring (M0) 70 9 8 Screw, Cap Hex Head (M x 0mm) 99 Disc, Drive Generator 09 8 Washer, Flat (/8 ) Hardened 7 09 Adapter, Generator Stator 8 08 09 Seal, Edging Bulk (Order by the Foot Feet Required) 9 Cover, Stator Top 097 0, 90mm Stack Length 097 0 0, 8mm Stack Length 097 0 mm Stack Length 0 Cover, Stator Bottom 80 0, 90mm Stack Length 80 0 0, 8mm Stack Length 80 0 mm Stack Length 800 07 0 Screw, Cap Hex Head (M x 0mm) 80 0 0 Washer, Lock Spring (M) 099 0 Washer, Flat (M) 08 07 Grommet Block, Terminal 7 0 Plug, Hole 7 0 Washer, Flat (/ ID x / OD x / Thk) 8 800 07 8 Screw, Cap Hex Head (M0 x 0mm) 9 80 008 Washer, Lock Spring (M8) 0 800 00 Screw, Cap Hex Head (M8 x mm) 00 Washer, Flat (M8) 80 0 Washer, Lock Spring (M0) 087 Guard, Fan Generator 0879 Screen, Air Inlet 8 00 0 8 Screw, Self Locking Hex Washer Head (M x mm) 0 Bell, End 7 80 0 Washer, Lock Spring (M0) 8 800 07 8 Screw, Cap Hex Head (M0 x 0mm) 9 80 00 Washer, Lock Spring (M) 0 Screw, Cap Hex Head (M) 800 0, 90mm Stack Length 800 0 0, 8, mm Stack Length Stator, Exciter 0 9 0, 90mm Stack Length 0 9 0 0, 8, mm Stack Length 9 Bracket, Mounting Generator Foot 800 0 Screw, Cap Hex Head (M x 0mm) 80 07 8 Washer, Lock Spring (M) 0 8 Washer, Flat (M) 70 0 Spacer, Mounting Foot 7 8 00 0 8 Screw, Self Locking Hex Washer Head (M x 0mm) 8 80 00 8 Bolt, Place (/8 x.7 ) 9 800 088 Screw, Cap Hex Head (M0 x mm) 0 80 00 Washer, Lock Spring (M0) 07 8 Washer, Flat (/8 ) 800 0 Screw, Cap Hex Head (M x 0mm) * Parts Included in Generator Rotor Assemblies # Parts Included in Exciter Rotor Assemblies + Parts Included in Rectifier Assemblies NOTE: If the first position of the alternator serial number is M, the replacements for the rotor and stator are no longer available. Please contact the factory Technical Support for more information. 8
Permanent Magnet Generator (PMG) 0 8 7 9 77 009 Pin, Parallel 8 07 0 Bolt, Mounting PMG 0 Rotor, PMG 0 Stator, PMG 97 Clamp, Stator PMG 087 0 Cover, End Bell 7 0 Spacer, Cover 8 8 00 0 Screw, Hex Head (M x 0.8 x 0) 9 80 00 Washer, Lock (M0) 0 8 0 Harness, Wiring PMG 80 00 Washer, Lock (M) 8