TM 5-3810-307-10 TECHNICAL MANUAL OPERATOR'S MANUAL FOR ALL-TERRAIN CRANE (ATEC) AT422T DIESEL ENGINE DRIVEN, 22 TON CAPACITY TRUCK MOUNTED WITH CAB NSN 3810-01-448-2619 DISTRIBUTION STATEMENT A - Approved for public release; distribution is unlimited. HEADQUARTERS, DEPARTMENT OF THE ARMY 1 November 1999
TM 5-3810-307-10 WARNING OPERATIONS ADJACENT TO OVERHEAD LINES ARE PROHIBITED UNLESS ONE OF THE FOLLOWING CONDITIONS ARE SATISFIED. 1 POWER HAS BEEN SHUT OFF AND POSITIVE MEANS TAKEN TO PREVENT LINES FROM BEING ENERGIZED. 2 POSITION AND BLOCK EQUIPMENT INSURING NO PARTS, INCLUDING CABLE, CAN COME WITHIN THE FOLLOWING CLEARANCES: VOLTAGE REQD CLEARANCE UNDER 50 KV - 10 FEET 69 KV - 12 FEET 115-161 KV - 15 FEET 230-285 KV - 20 FEET 345 KV - 25 FEET 500 KV - 35 FEET CHECK WITH YOUR LOCAL POWER SUPPLIER FOR CORRECT LINE VOLTAGE NOTE READ AND UNDERSTAND ALL OF THE SAFETY WARNINGS AND CAUTIONS CONTAINED IN SECTION 2 - SAFETY PRECAUTIONS BEFORE OPERATING THE CRANE, DIRECT ANY QUESTIONS THAT YOU MAY HAVE TO YOUR SUPERVISOR FOR CLARIFICATION.
TM 5-3810-307-10 CHANGE HEADQUARTERS, DEPARTMENT OF THE ARMY NO. 1 WASHINGTON, D.C., 2 JUNE 2006 TECHNICAL MANUAL OPERATOR S MANUAL FOR All-Terrain Crane (ATEC) AT422T Diesel Engine Driven, 22 Ton Capacity Truck Mounted With Cab NSN 3810-01-448-2619 DISTRIBUTION STATEMENT A Approved for public release; distribution is unlimited. TM 5-3810-307-10, 1 November 1999, is updated as follows: 1. File this sheet in front of the manual for reference. 2. This change is a result of changes documented against the configuration of the crane. Extreme weather equipment including engine coolant and hydraulic reservoir heaters have been added as an option. 3. New or updated test is indicated by a vertical bar in the outer margin of the page. 4. Added illustrations are indicated by a vertical bar adjacent to the figure number. Changed illustrations are indicated by change bars in the outside margin adjacent to the updated area and a change bar adjacent to the figure number. 5. Remove old pages and insert new pages as indicated below: Remove Pages Insert Pages List of Effective Pages List of Effective Pages i and ii i and ii iii and iv iii and iv v and vi v and vi 1-1 and 1-2 1-1 and 1-2 1-5 and 1-6 1-5 and 1-6 2-33/(2-34 blank) 2-33/(2-34 blank) 4-7/(4-8 blank) 4-7/(4-8 blank) 5-27 and 5-28 5-27 and 5-28 5-29 and 5-30 5-29 and 5-30 5-35 thru 5-38 5-35 thru 5-38 5-49 and 5-50 5-49 and 5-50 5-73 and 5-74 5-73 and 5-74 5-89 thru 5-92 5-89 thru 5-92 5-95 and 5-96 5-95 and 5-96 5-101 and 5-102 5-101 and 5-102 6-23 thru 6-30 6-23 thru 6-30 Appendix A A-1(A-2 blank) Appendix A A-1(A-2 blank) Appendix B B-3 thru B-6 Appendix B B-3 thru B-6 Appendix C C-3 and C-4 Appendix C C-3 and C-4
Remove Pages Insert Pages Appendix D D-1 and D-2 Appendix D D-1 and D-2 Appendix E E-1 thru E-10 Appendix E E-1 thru E-9/ (E-10 blank) Appendix F F-1 thru F-6 Appendix F F-1 thru F-6 Appendix F F-29/(F-30 blank) Appendix F F-29 and F-30 Appendix G (G-1 thru G-39) Appendix G (G-1 thru G-41/ G-42 blank) Appendix H (H-1 thru H-18) Appendix H (H-1 thru H-97/ H-98 blank) Index-1 thru Index-6 Index-1 thru Index-6 6. Add the following new pages: 5-42a/(5-42b blank) B-7/(B-8 blank) Appendix K (K-1 thru K-4) Appendix L (L-1 thru L-18) Appendix M (M-1 thru M-12)
By Order of the Secretary of the Army: Official: PETER J. SCHOOMAKER General, United States Army Chief of Staff JOYCE E. MORROW Administrative Assistant to the Secretary of the Army 0611601 Distribution: To be distributed in accordance with the initial distribution number (IDN) 256569, requirements for TM 5-3810-307-10.
TM 5-3810-307-10 INSERT LATEST CHANGED PAGES. DESTROY SUPERCEDED DATA. LIST OF EFFECTIVE PAGES NOTE: The portion of text affected by the changes is indicated by a vertical line in the outer margins of the pages. Added illustrations are indicated by a vertical bar adjacent to the figure number. Changed illustrations are indicated by change bars in the outside margin adjacent to the updated area and a change bar adjacent to the figure number. Dates of issue for original and changed pages are: Original..0 1 November 1999 Change..1 2 June 2006 TOTAL NUMBER OF PAGES FOR THIS MANUAL IS 454 CONSISTING OF THE FOLLOWING: Page No. *Change No. Page No. *Change No. Page No. *Change No. Cover 0 5-74 5-88 0 H-1 H-97/ 1 Blank 0 5-89 1 (H-98 blank) Warning 0 5-90 0 I-1 I-3/ 0 Blank 0 5-91 1 (I-4 blank) i iii 1 5-92 5-94 0 J-1 J-3/ 0 iv 0 5-95 1 (J-4 blank) v vi 1 5-96 5-100 0 K-1 K-4 1 1-1 0 5-101 1 L-1 L-18/ 1 1-2 1 5-102- 5-110 0 M-1 M-12 1 1-3 1-5 0 6-1 6-22 0 Index-1 1 1-6 1 6-23 1 Index -6 1-7 1-9/ 0 6-24 0 (1-10 blank) 6-25 1 2-1 2-32 0 6-26 6-27 0 2-33/(2-34 1 6-28 6-30 1 blank) 3-1 3-4 0 A-1/(A-2 blank) 1 4-1 4-6 0 B-1 B-2 0 4-7/(4-8 blank) 1 B-3 B-7/ 1 5-1 5-26 0 (B-8 blank) 5-27 5-29 1 C-1 C-3 0 5-30 5-34 0 C-4 1 5-35 5-36 1 D-1 D-2 1 5-37 0 D-3 D-4 0 5-38 1 E-1 E-9/ 1 5-39 5-42 0 (E-10 blank) 5-42a/(5-42b 1 F-1 F-6 1 blank) F-7 F-28 0 5-43 5-48 0 F-29 F-30 1 5-49 1 G-1 G-41/ 1 5-50 5-72 0 G-42 blank) 5-73 1 * Zero in this column indicates an original page. Change.1
TM 5-3810-307-10 1 NOVEMBER 1999 OPERATOR S MANUAL FOR ALL-TERRAIN CRANE (ATEC) DIESEL ENGINE DRIVEN, 22 TON CAPACITY TRUCK MOUNTED WITH CAB NSN 3810-01-448-2619 REPORTING ERRORS AND RECOMMENDING IMPROVEMENTS You can help improve this publication. If you find any mistakes or if you know of a way to improve the procedures, please let us know. Submit your DA Form 2028 (Recommended Changes to Equipment Technical Publications), through the Internet, on the Army Electronic Product Support (AEPS) website. The Internet address is http://aeps.ria.army.mil. The DA Form 2028 is located under the Public Applications section in the AEPS Public Home Page. Fill out the form and click on SUBMIT. Using this form on the AEPS will enable us to respond quicker to your comments and better manage the DA Form 2028 program. You may also mail, fax or E-mail your letter or DA Form 2028 direct to: AMSTA-LC-LPIT / TECH PUBS, TACOM-RI, 1 Rock Island Arsenal, Rock Island, IL 61299-7630. The email address is TACOM-TECH- PUBS@ria.army.mil. The fax number is DSN 793-0726 or Commercial (309) 782-0726. TABLE OF CONTENTS Page HOW TO USE THIS MANUAL... WARRANTY INFORMATION... iv vi SECTION 1 GENERAL... 1-1 Introduction... 1-1 List of Specifications... 1-2 SECTION 2 SAFETY PRECAUTIONS... 2-1 General... 2-1 Operator's Information... 2-1 Operator's Qualifications... 2-2 Crane Stability/Structural Strength... 2-3 Two-Blocking... 2-8 Load Moment Indicating Systems... 2-9 Electrocution Hazard... 2-10 Crushing Hazards... 2-14 Personnel Handling... 2-16 Travel Operation... 2-17 Maintenance... 2-18 Batteries... 2-22 Engine... 2-22 Work Practices... 2-23 Shutdown... 2-28 Cold Weather Operation... 2-28 Supplemental Warnings and Cautions... 2-29 i C-1