POWERHEAD ASSEMBLY BLOWER / VAC. 69 \. 25 L./ / a./, 7 <..\ %>, Y + 6 5 4 8 36- i 4 43 > 23
BLOWER / VAC FGURE POWERHEAD ASSEMBLY TEM PART UNTS PEF TEM NO. PART UNTS PE NUM8ER DESCRPTON ASY. 27669 Screw - M4 X 25 torx 2 (6-9 in lb. toraue) 25988 Cover - Air Cleaner ; 27376 Filter Assembly - Air 27275 Nut - Flange M-5 2 ; 25993 Spacer - Shutter 6 2599 Shutter - Choke 7 2608 Air Box/GromnetAsy 8 25992.Grormnet- Choke Fig. 3 Carburetor Asy.?0 2899 Gasket-Carburetor 297 nsulator-carburetor :L 2898 Gasket/Shield-nsulator 3 2863 Stud-M-5 X 79 2 4 26025 Screw M-4 x 8 Torx-Outlet 2 (3-7 in. lb. Torque) 5 28553 Outlet-Muffler 2556 Screen-SparkArrestor ;; 27275 Nut-FlangeM-5 2 (32-5in. lb. Torque) 8 2865 Muffler Assembly 9 28632 Spacer-Muffler 20 28920 Gasket-Muffler 2 28652 Shield-Muffler ;; 2863 Stud-M-5 x 79-Muffler 2 (40-5 in. lb. Torque) 23 2377 Screw M-4.2 x 8.5 Torx 3 (2-6 in. lb. Torque) 24 27672 liasher-m-4flat-starter 25 27388 Starter Assembly? 26 27389 Housing-StarterAssembly 27 25874 ; Screw-M-4 x 9.5 Torx- Drum (7-22 in. lb. Torque) 28 26590 Washer M-4-Flat 26092 ; Drum/Rope Assembly % 25770.. Drum-Starter 3 26093.. Rope-Starter 32 27482. Spring-Starter 33 2894. Washer-Nylon 26792. Handle-Starter ;: 27382 Cushion-Fuel Tank/Starter 36 28650 Fuel Tank/Hose Assembly 37 28576. Tank-Fuel 38 2895. Hose-Fuel 39 26985. Pickup-Fuel 40,25495. Grommet-Hose ; 4 42 43 44 45 46 47 48 49 5 52 53 E 56 57 58 59 60 6 62 :: % X 69 70 7 72 27383 26346 27390 2378 28649 28586 235593 27320 2908 25542 29082 27475 28273 026 28275 0984 26583 25525 83859 2379 2885 23282 2806 0264 25545 239 2554 28654 27378 2377 27439 Decal 40: Cap-Fuel Cushion-FuelTank/C case.screw-m-5x 8.5 Torx (5-25in. lb. torque) TerminalAssembly-Ground Cover-Cylinder Spark Plug-AC-CS45T (09-35in. lb. Hand Torque)l Screw-M6x 8 Torx 2 (72-83in. lb. Hand Torque) Cylinder/GasketKit Gasket-Cylinder/C case ;iston Kit. Ririg-Piston. Piston Snap Ring-WristPin 2 Pin-iJrist Bearing-Needle Nut-HexM-8 Ratchet Assy (56-7in. lb. Torque) RatchetAssembyly (HandTighten Only) Oil Seal-C Shaft/C ca~e Screw-M-5x 28.5 Torx : (35-42in. lb. Hand Torque) CrankcaseAssembly Bearing-C Shaft/C case ; Crankshaft/ConRod Assy Key-Flywheel ; Gasket-CrankcaseHalves Pin Gromnet ; Extension-Shaft [50-68in. lb. Torque) Flywheel Screw-M-4.2x 8.5 Torx- 2 gnition(3-6in. lb. Torque) gnition SPECFCATONS ENGNETYPE...TWOCYCLESNGLE CYLNDER DSPLACEMENT...2.2CC CYLNDER TYPE...ALUMNUM GNTON...ELECTR~NC MUFFLER...LARGE VOLLME SPARKARRESTORSCREEN...U.S.FORESTSERVCE APPROVED CARBURETOṘ...ALLPOSTONDAPHRAGM AR FLTER...FELT FUEL TANK CAPACTY...6.9 FL. OZ. RUNNNG TME...35-40 MNUTES AR VOLLME...400CFM ARVELOCTY...40MPH MPELLERTYPE...CENTRFUGAL FAN MPELLER BLADE NUMBER...6 MPELLER SPEED...7000 RPM ORY WEGHT...2 LBS. MEMBEROF VACUUMTUBES...2SECTONS LENGTH OF VACUUM TUBES...34 3/4 TOTAL - NSTALLED VACULMTUBEDA....4/2 NUMBER OF BLOHER TUBES...2 SECTONS LENGTH OF BLOWER TUBES...23 /2 TOTAL - NSTALLED BLOUER TUBE/NOZZLE OUTLET DA...2 3/4 / 7/8 RESPECTVELY 3
- 0 GENERAL ASSEMBLY 9 7 + 4 6 BLOWER /VA cm 4. 24 / 25 */ [[, P, ; /#AJ @ ziiz. \. 22 5 j -.
TEM PART UNTS PER 299 ; 26022 28655 : 2858 5 28656 6 2369 7 28644 8 2978 9 26389 0 2B643 28538 2 28539 3 28939 4 28852 5 28797 FGURE2 GENERAL ASSEMBLY Housing nner Screw-M-4 x 23.4 Torx : (40-50 in. lb. Torque) Disc-Drive mpeller Washer-mpeler i Nut-Hx Flange M-8 (90-00 in. lb. Torque) Screw-0-4x.75 Torx 5 (35-45 in. lb. Torque) Housing-Outer mpeller Screw 6-32 x.5 ~25-35 in. lb. Torque) Screw 8-6 x.50 Torx- ;in (25-35 in. lb. Torque). Pin-Cover Spring-Cover : Cover-nlet. Decal-Warning nlet Decal-Warning BLOWER / VAC TEM PART UNTS PER 6 28648 2989 : 28646 9 28667 20 27935 2 28676 22 28644 23 2990 2974 ;: 2972 26 SEE 27ACCESSORES 28 2987 :: 2988 Switch Trigger Spring-Trfgger Link-Harness Screw-0-24x.50 Torx (45-55in. lb. Torque) Eyelet-Threaded Screw-0-4x.75 Torx (35-45in. lb. Torque) Shroud-Engine Adapter-Tube Clamp-Adapter @Screw-0-Z4x.2 Torx- 4 Frame [35-45in. lb. Torque) @Plate-Nut 2 @ Frame Spring-Activator Activator-ThrottleLock ; 5 # @Used On Units With Suffix Letter DAnd F Only. ACCESSORES 8 6 * % z *4{.--- --- -.. ----~ ACCESSORES TEM PART UNTS PER TEM PART UNTS PER,,., 2877 Kt - Vacuum 28947.Screw0-24x.2 Torx - 4 287 ~~~&(~5fl~ n lb. toroue) 2 : 28545.Frame 4 2976.Vacuum Tube - Upper Sectl on! 5 28684.Vacuum Tube - Lower Section 6 28660.Bag Assembly 28666.Harness ; 28938.Hook - Snap 2973 Blower Tube - Straight : 2979 Blower Nozzle - Curved : 5
BLOWER / VAC -CARBURETOR a ASSEMBLY,, /./ y &- 2.-,#\ \ /9 OTE: ternsare shown for identificationand Disassemblyseauence purposesonly. omponentsare not availiibleseparately. [itslisted are theonly service parts vailablefor this carburetor. & 22 CARBURETOR [TEH PART UNTS PER NO, NUMBER DESCRPTON ASY. 28647 Zama M-2 -- --@@.Screw 2 -- --.Cover- Diaphragm 3 -- -- @@.Diaphragm-Main 4 ---- @@.Gasket- Main 5 -- --~. Disc 6 -- --@@,Screw - Pin 7 -- --@@.Pin -Arm 8 ---- @@.Ann - Needle Valve 9 -- --@@.Valve - Needle 0 -- --@).Spring -Arm --.-@_ @.Plug-Welch 2 -- --.S.crew - Throttle Valve 3 -- --.Valve - Throttle 4 -- -- @.E-Rina @ Contained in minor repairkit P/N 2906 2 ; ASSEMBLY TEM PART UNTS PER 5 ----.Shaft Asy. - Throttle 6 -- --.Spring - Throttle Return 7 -- -- @.Needle - High Speed Adj. 8 -- -- @.Needle - Low Speed Adj. 9 -- -- @.Spring - Needle ; 20 -- -- @.Screw - Throttle Adj. -- -- @.Spring- Throttle Adj. Screw?2 -- --@@.Screw - Cover.Cover - Fuel Pump :: :: ::@@.Diaphragm - Surge 25 -- --@@.Gasket- Fuel Pump 26 -- --@) @.Retainer- Fuel Pump 27 -- --@@.Diaphragm- Fuel Pump 28 -- --@@.Strainer- Fuel @ Containedin major repair kit P/N 2907 )