Project: REMENDED PARTNER 1 by SIRS-E Comments: Prepared By: Ketra's recommended low-profile solution: Ketra has selected SIRS-E to provide a seamless experience to integrate low profile LED strips into a cohesive Ketra controlled space. Fully tunable spectrum delivers white light, pastels and saturated color Color match profiles (/- 100 K) built into Ketra's Design Studio content controlled via DMX. IP40 indoor location or IP68 outdoor location rated options. Optional extrusions support up to two parallel runs of IP40 Flexible Strip Light for increased output applications HARDWARE ORDERING GUIDE Full Roll Options Segment Options3 KS Roll KS Series IP Rating Roll Series IP Rating Segment Length Lead In/Out Config. Series Series Ketra Recommended Flexible Strip Light KS Ketra Recommended Flexible Strip Light KS IP IP 40 (Indoor) Flexible Strip Light, 16.4ft roll, (includes 12" lead in and lead out) IP 68 (Outdoor)Flexible Strip Light, 16.4ft roll, (includes 12" lead in and lead out 2 11 Required Devices Requires a Ketra N3 for DMX control, data cable supplied by others. N3 must be ordered separately. Ketra N3 Recessed Rated Plenum Rated Power Supply Options Power Supplies must be ordered separately. Power Supply 10 16.4' flexible strip light max per power supply. See p, 3 for product details. EldoLED LINEARdrive 120-277VAC, 100W, DMX, UI, CV, 4CH, 12/24V 14.57"Lx1.61"Wx1.18"T EldoLED LINEARdrive 120-277VAC, 100W, DMX, UI, CV, 4CH, 12/24V 9.06"Lx3.15"Wx1.18"T KE03 KE05 N3IND16REDBK N3IND16PLEBK IP 40 (Indoor) 10 68 (Outdoor) 2 11 Segment Length (Max = 193.52 in (16.13 ft)) Enter segment length in total inches rounded up to nearest inch. Segments are available in lengths of 3.27" increments. Lead in/ Lead Out Configuration 12" Lead In Cable (flying leads) 1 12" Lead In & Lead out Cable (flying leads) 2 Extrusions See page 4 for Extrusion options Accessories See page 5 for Accessory Options XXX 1 The SIRS-E Flexible Strip Light has been tested to match Ketra products as closely as possible. Ketra does not guarantee color point accuracy over the lifetime of any partner products and does not control for batch to batch variation. 2 IP68 Rated Flexible Strip Light must use manufacture soldered connections only. 3 When ordering pre-cut segments be sure to account for the extra length required for cable bend radius and extrusion end caps. See page 8 for actual lengths
REMENDED PARTNER SPECIFICATIONS1 OPTICAL & ELECTRICAL PERFORMANCE MECHANICAL Input Voltage Limiting Control Method Power Consumption LED Chip Type LED Density Beam Angle Luminous Flux Maintenance Dimming ENVIRONMENTAL Operating Temperature Certification Location 24V DC CV - Constant Voltage 5.75 W/ft High Quality SMD 5050 4-Diode 22 LEDs/ft 72 LEDs/m 120 75,000 hrs1 DMX PWM -20-120 F cul UL Listed, E479339 IP 40 - Indoor, Dry IP 68 - Damp, Wet Board Type/Color Mounting DIMENSIONAL Weight Cuttable Segments Reel Length Max Run Length Segment Width Warranty 4oz Density Copper, White PCB Non-Porous: 3M VHB Adhesive Mounting Tape 5.3 oz (16.4ft Reel IP40, w/out pkg) 18.4 oz (16.4ft Reel IP68, w/out pkg) 3.27 in (83mm) 16.4 ft (5m) 16.4ft, 5m, 10% luminous flux loss 0.47 in (12mm) for IP40 0.56 in (14mm) for IP68 5 Year SIRS-E Limited Warranty DMX SAMPLE CHART2, 3 CCT 2400K 2700K 3000K 3200K 3500K 4000K 8200K Luminous Flux (1ft) 157 127 127 128 131 138 404 CRI 78 96 96 96 95 91 - R9 51 98 97 94 90 73 - DMX - Red 40,000 8,000 3,500 2,000 0 0 Full, 65,535 DMX - Green 12,500 3,000 4,500 5,500 7,700 12,300 Full, 65,535 DMX - Blue 0 950 2,300 3,400 5,200 8,750 Full, 65,535 DMX - White 65,535 65,535 65,535 65,535 65,535 65,535 Full, 65,535 NOTES A good technique to minimize brightness loss and increase lumen output on CV LED Strips is to power the strip on both sides. LED electrical and photometric characteristics change with the manufacturing batch/bin date. Approximately 3-Step MacAdam Ellipses between batches. SIRS-E reserves the right to change any data without prior notice. 1 Specifications are provided by SIRS-E, and are subject to change without notice. 2 After 75,000 hrs: 30% Luminous Flux loss, 10% Chromaticity change, as per LM-80-15 3 DMX profile must be set to 16bit RGBW in Ketra's Design Studio and LED driver must be set to 16bit mode with a linear dim curve. 4 The DMX chart above reflects measurements for the full intensity of each CCT value. Color point may shift when dimming.
REMENDED PARTNER POWER SUPPLY & CONTROLLER DETAILS KE05 KE03/ KE05 POWER SUPPLY SPECIFICATIONS 1,2 INPUT CHARACTERISTICS Input Voltage Input Current Input frequency 120-277VAC, 120-275VDC 1.05A max @ 120V/60Hz 0.5A max @ 230V/50Hz 0.45A max @ 277V/60Hz 50-60Hz Power Factor @ full load >0.94 THD @ Full Load <10% Inrush current Surge protection Standby power OUTPUT CHARACTERISTICS LED output load LED output power LED output voltage LED output current 35A 240 μs @ 120V/60Hz 67A 240 μs @ 230V/50Hz 75A 240 μs @ 277V/60Hz 3kV (L to N), 4kV (L/N to ) <0.5W RGBW @ 24V: 1A per output For UL Class 2: RGBW @ 24V: 1A per output 5A max common anode 100W max LED output 4 (UL Class 2) Circuit protection 24V DC (selectable via DIP switch) 2.8A absolute max rating per output To prevent excessive output current from damaging the LED driver, it is highly recommended to use circuit protection appropriate for your application s nominal current and inrush current requirements. ENVIRONMENTAL Operating Temperature Certification WARRANTY Warranty -40 C - 50 C UL 1310, UL 8750 (Class 2 Output), FCC 47 CFR Part 15 class B, ROHS2 3 Years LED WIRE LENGTH Maximum wire length from LED driver to LED engine at full load: Notes: AWG Value 20 19 18 17 16 Distance (m) 14 18 22 28 36 Distance (ft) 45.9 59 72.2 91.9 118.1 Please observe voltage drop over long wire lengths Longer wire lengths increase EMI susceptibility KE03 DIMENSIONS, WEIGHT Weight LxWxH 31oz / 880g KE03: 14.57x1.61x1.18in / 370x41x30mm KE05: 9.06x3.15x1.18in / 230x80x30mm KE05 1 Specifications are provided by eldoled, and are subject to change without notice. 2 LED driver must be set to 16bit mode with a linear dim curve.
REMENDED PARTNER EXTRUSION DETAILS Extrusions do not include endcaps, which must be ordered separately. KKLXO1 Extrusion KKOX01 45 Extrusion KKGX01 Extrusion Linear extrusion, surface mount, with frosted linear lens, & mounting brackets 45 linear extrusion, surface mount, with frosted lens Shallow linear extrusion, surface mount, with frosted lens, & mounting brackets FIXED MOUNT SURFACE MOUNT FIXED MOUNT (3) fixed mounting brackets 1.02"W x 0.96"H x 39.4 L KKLASF Curved lens 1.78" X 1.5" X 39.4" KKOACS Square lens & (3) fixed mounting brackets 1.02"W x 1.06"H x 39.4 L KKGASF ADJUSTABLE MOUNT (3) adjustable mounting brackets 1.02"W x 0.96"H x 39.4 L KKLASA Square lens 1.78" X 1.5" X 39.4" KKOASS Round lens & (3) fixed mounting brackets 1.02"W x 1.06"H x 39.4 L KKGARF ADJUSTABLE MOUNT Fixed Mounting Bracket Adjustable Mounting Bracket Square lens & (3) adjustable mounting brackets 1.02"W x 1.06"H x 39.4 L KKGASA Round lens & (3) adjustable mounting brackets 1.02"W x 1.06"H x 39.4 L KKGARA Fixed Mounting Bracket Adjustable Mounting Bracket END CAPS KKLXO1 End Caps KKOX01 End Caps KKGX01 End Caps Linear extrusion end cap KKLE01 For curved lens KKOE01 For square lens KKGE01 For square lens KKOE02 For round lens KKGE02
REMENDED PARTNER ACCESSORY DETAILS Accessories Quick Coupler with Lead in Cables 12" KS30 Quick Coupler with Lead Out Cables 12" KS31 End-to-End Quick Coupler KS32 12" Quick Jumper Cable KS44 Heat Shrink Tubing 3/8" X 12" - Black KS34 Heat Shrink Tubing 3/8" X 12" - White KS35 Power Supply Wire, 16 AWG, 2 Conductor Cable - Wire Only, 1ft KS40 RGBW LED cable - Wire Only, 1ft KS41
L N D D 4 3 2 1 B A DC Out Activity B A Status Monitor DMX DALI TRIAC Power Analog I/O DMX Out DMX In DALI L N D D 4 3 2 1 B A DC Out Activity B A Status Monitor DMX DALI TRIAC Power Analog I/O DMX Out DMX In DALI REMENDED PARTNER DIMENSION DRAWINGS KS-10 KS-11 WIRING DIAGRAM KETRA N3, SIRS-E 3815 S. CA AU P GENERAL N D1 DMX OUT DMX OUT - D1 DMX IN DMX IN - DMX OUT DMX OUT - D1 DMX OUT DMX OUT - D1 DMX IN DMX IN - DMX OUT DMX OUT - 16-24 AWG WIRE 16-24 AWG WIRE 12V / 24V DIP SWITCH (SET TO 24V BEFORE 12V ENERGIZING) / 24V DIP SWITCH (SET TO 24V BEFORE ENERGIZING) 24V 12V 24V 12V INACTIVE INACTIVE SIRS-E RGBW FLEXIBLE STRIP SIRS-E RGBW FLEXIBLE STRIP 1. KETRAN 3815 S. CAPITAL O WIRELE SUITE AUSTIN, TX 2. A P: NODE 512.872 ENABLE GENERAL NOTES: 3. 50 KETR 1. KETRANET MESH WIRELESS PER CONT INS 2. A NODE 4. ALL IS A KET ENABLED WIREL BE INST 3. 50 KETRANET RANGE ME PER INSTALLATIO 4. ALL KETRANET M BE INSTALLED W RANGE OF THE N 120VAC, 60 Hz MAINS SUPPLY D D DMX Out DMX In DALI TRIAC Control AC Mains IN N L N3 DETAIL VIEW 1 L N S Power & Signal OUT N3 DETAIL VIEW TO NEXT DMX DEVICE (IF APPLICABLE) 120VAC, 60 Hz MAINS SUPPLY D D DMX Out DMX In DALI TRIAC Control AC Mains IN N L 1 eldoled S DRIVER L N S Power & Signal OUT TO NEXT DMX DEVICE (IF APPLICABLE) eldoled S DETAIL VIEW eldoled S DRIVER eldoled S DETAIL VIEW 120-277VAC MAINS SUPPLY 16-20 AWG WIRE 120-277VAC MAINS SUPPLY 16-20 AWG WIRE D1 KETRANET MESH WIRELESS NETWORK BELDEN-9729 OR EQUIVALENT DMX, 2 TWISTED PAIRS, ED KETRANET MESH Ketra Recommended Partner 512-347-1100 ketra.com WIRELESS NETWORK BELDEN-9729 OR D1 EQUIVALENT DMX, 2 2018 Ketra, Inc. All rights reserved TWISTED PAIRS, ED KEY KEY FOR REFERE NOT F CONSTRU FOR R DRAWING TYPE: DRAWING #: REVISION #: CO DATE: 4/12/2018 DRAWIN DRAWN BY: LEB DRAWIN CHECKED BY: C SCALE: REVISIO NTS DATE: 4 SHEET N DRAWN KETRA ELDOLE CHECKE SIRS SCALE: SHEE 1 01 OF E
REMENDED PARTNER FULL DMX CHART 1 CCT Luminous Flux (1ft) CRI R9 DMX - Red DMX - Green DMX - Blue DMX - White 1400 62.2 33 45 65535 13500 0 0 1500 65 30.9 22 65535 15500 0 0 1600 67.7 28.8 1 65535 17500 0 0 1700 70.5 27.1 0 65535 19500 0 0 1800 72.9 25.6 0 65535 21300 0 0 1900 75.2 24.1 0 65535 23000 0 0 2000 79.8 24.3 0 65535 24000 0 2000 2100 102.4 35.7 0 65535 22500 0 17000 2200 120 46.2 0 65535 22500 0 28000 2300 153.7 61 11 65535 21000 0 50000 2400 157.5 77.8 51 40000 12500 0 65535 2500 129 94.4 96 13500 2200 500 65535 2600 129.1 94.4 95 11500 3000 860 65535 2700 127 96.1 98 8000 3000 950 65535 2800 127.4 96.3 98 6500 3500 1300 65535 2900 127.5 96.4 97 5000 4000 1800 65535 3000 127.5 96.6 97 3500 4500 2300 65535 3100 127.7 96.5 96 2500 5000 2850 65535 3200 128.2 96.2 94 2000 5500 3400 65535 3300 128.2 96.5 94 1000 6000 4000 65535 3400 128.7 96.3 93 500 6500 4600 65535 3500 130.5 95.4 90 0 7700 5200 65535 3600 132.5 94.6 86 0 8900 5800 65535 3700 134.2 93.8 83 0 10000 6400 65535 3800 135.4 92.8 79 0 10500 7400 65535 3900 137 92.1 76 0 11500 8000 65535 4000 138.3 91.4 73 0 12300 8750 65535 4100 139.8 90.8 70 0 13200 9400 65535 4200 141.2 90.2 68 0 14100 10000 65535 4300 142.2 89.5 65 0 14600 10900 65535 4400 143.5 89 63 0 15400 11500 65535 4500 144.9 88.5 61 0 16200 12200 65535 5000 150.1 86.3 51 0 19200 15700 65535 5500 153.8 84.5 42 0 21200 18500 65535 6000 158.4 82.7 32 0 23800 22000 65535 6500 161.5 81.4 26 0 25500 24900 65535 7000 164.4 80.4 20 0 27000 27450 65535 8000 168.6 78.8 11 0 29000 32200 65535 9000 171.9 77.6 6 0 30500 36150 65535 10000 174.4 76.7 0 0 31500 39550 65535 1 Ketra Design Studio DMX profile: 16bit RGBW LED driver setting: 16bit mode, linear dim curve. 2 The DMX chart above reflects measurements for the full intensity of each CCT value. Color point may shift when dimming.
REMENDED PARTNER FULL DMX CHART 1 - COARSE/FINE DMX VALUES Luminous Red Red CCT CRI R9 Flux (1ft) Coarse Fine Green Coarse 1 Ketra Design Studio DMX profile: 16bit RGBW LED driver setting: 16bit mode, linear dim curve. 2 The DMX chart above reflects measurements for the full intensity of each CCT value. Color point may shift when dimming. Green Fine Blue Coarse Blue Fine White Coarse 1400 62.2 33 45 255 255 52 188 0 0 0 0 1500 65 30.9 22 255 255 60 140 0 0 0 0 1600 67.7 28.8 1 255 255 68 92 0 0 0 0 1700 70.5 27.1 0 255 255 76 44 0 0 0 0 1800 72.9 25.6 0 255 255 83 52 0 0 0 0 1900 75.2 24.1 0 255 255 89 216 0 0 0 0 2000 79.8 24.3 0 255 255 93 192 0 0 7 208 2100 102.4 35.7 0 255 255 87 228 0 0 66 104 2200 120 46.2 0 255 255 87 228 0 0 109 96 2300 153.7 61 11 255 255 82 8 0 0 195 80 2400 157.5 77.8 51 156 64 48 212 0 0 255 255 2500 129 94.4 96 52 188 8 152 1 244 255 255 2600 129.1 94.4 95 44 236 11 184 3 92 255 255 2700 127 96.1 98 31 64 11 184 3 182 255 255 2800 127.4 96.3 98 25 100 13 172 5 20 255 255 2900 127.5 96.4 97 19 136 15 160 7 8 255 255 3000 127.5 96.6 97 13 172 17 148 8 252 255 255 3100 127.7 96.5 96 9 196 19 136 11 34 255 255 3200 128.2 96.2 94 7 208 21 124 13 72 255 255 3300 128.2 96.5 94 3 232 23 112 15 160 255 255 3400 128.7 96.3 93 1 244 25 100 17 248 255 255 3500 130.5 95.4 90 0 0 30 20 20 80 255 255 3600 132.5 94.6 86 0 0 34 196 22 168 255 255 3700 134.2 93.8 83 0 0 39 16 25 0 255 255 3800 135.4 92.8 79 0 0 41 4 28 232 255 255 3900 137 92.1 76 0 0 44 236 31 64 255 255 4000 138.3 91.4 73 0 0 48 12 34 46 255 255 4100 139.8 90.8 70 0 0 51 144 36 184 255 255 4200 141.2 90.2 68 0 0 55 20 39 16 255 255 4300 142.2 89.5 65 0 0 57 8 42 148 255 255 4400 143.5 89 63 0 0 60 40 44 236 255 255 4500 144.9 88.5 61 0 0 63 72 47 168 255 255 5000 150.1 86.3 51 0 0 75 0 61 84 255 255 5500 153.8 84.5 42 0 0 82 208 72 68 255 255 6000 158.4 82.7 32 0 0 92 248 85 240 255 255 6500 161.5 81.4 26 0 0 99 156 97 68 255 255 7000 164.4 80.4 20 0 0 105 120 107 58 255 255 8000 168.6 78.8 11 0 0 113 72 125 200 255 255 9000 171.9 77.6 6 0 0 119 36 141 54 255 255 10000 174.4 76.7 0 0 0 123 12 154 126 255 255 White Fine
REMENDED PARTNER SEGMENT LENGTHS Order Length, Nominal (inches, rounded) 004 3.28 007 6.56 010 9.84 014 13.12 017 16.4 020 19.68 023 22.96 027 26.24 030 29.52 033 32.8 037 36.08 040 39.36 043 42.64 046 45.92 050 49.2 053 52.48 056 55.76 060 59.04 063 62.32 066 65.6 069 68.88 073 72.16 076 75.44 079 78.72 082 82 086 85.28 089 88.56 092 91.84 096 95.12 099 98.4 Actual Length (inches) Order Length, Nominal (inches, rounded) 102 101.68 Actual Length (inches) 105 104.96 109 108.24 112 111.52 115 114.8 119 118.08 122 121.36 125 124.64 128 127.92 132 131.2 135 134.48 138 137.76 142 141.04 145 144.32 148 147.6 151 150.88 155 154.16 158 157.44 161 160.72 164 164 168 167.28 171 170.56 174 173.84 178 177.12 181 180.4 184 183.68 187 186.96 191 190.24 194 193.52 ROLL 196.80
Testing was performed in accordance with LM-79-08 REMENDED PARTNER 0-40 165 42.1% SIRS Electronics Inc 0-60 302 77% Average Luminance cd/m2 Catalog Number 0-90 391 99.8% Horizontal ACUHUE-12CV27-4016 - ALL COLORS Vertical Angle Angle 40-90 226 57.6% 60-90 Electrical 89 Test Conditions 22.8% 0 30100 Voltage 90-180 Current 1 Power Power 0.2% Factor Frequency 45 Current THD 30600 11.99 VDC 0.6482 0-180 A 7.771 392 W 100% N/A N/A N/A55 30660 65 29360 90 75 60 45 0.46 0.44 0.46 0.42 0.44 0.42 2700 2500K 2200K 0.38 0.4 3000K 3500K 2700 2500K 2200K 0.36 0.38 4000K 3000K 4500K 3500K 0.34 0.36 5000K 4000K 5700K 4500K 0.32 0.34 5000K 5700K Outside all Quadrangles 0.32 Outside all Quadrangles 0.28 0.3 0.3 0.28 0.35 0.4 x 0.45 0.5 0.3 0.35 0.4 0.45 0.5 y y 30 25.00 20.00 25.00 15.00 20.00 10.00 15.00 5.00 MORE DATA1: ALL COLORS @ FULL Zonal Lumen Summary Zone Lumens %Luminaire 0-30 100 25.4% 105 120 135 165 165 135 180 Deg. Plane 15 25 50 75 100 125 270 Deg. Plane 0 120 0 Deg. Plane Nominal CCT Quadrangles Nominal CCT Quadrangles Flux vs Wavelength x Flux vs Wavelength 105 15 30 90 75 60 45 90 Deg. Plane Spectral Flux (mw/nm) Spectral Flux (mw/nm) Spacing Criteria 0-180 1.30 90-270 1.30 75 25750 Intensity (Candlepower) Summary 85 17800 Angle Mean CP Lumens Cone 0 of Light Tabulation 126 Mounting 5 Foot-candles 125 Diameter 12 Height (ft) 10 at 124 Nadir (ft) 4.0015 7.89 122 5.20 34 6.0020 3.51 119 7.80 8.0025 1.97 115 10.4 53 30 110 10.0 1.26 13.0 35 105 12.0 0.876 15.6 40 99 66 14.0 45 0.644 91 18.2 70 16.050 0.493 83 20.8 55 74 66 Intensity 60 (Candlepower) 64 Summary 65 53 52 Angle Mean CP Lumens 70 40 0 75 126 28 30 5 80 125 16 12 10 85 124 6 8 15 90 122 1 34 20 119 25 115 53 30Color Rendering 110 Index Details 35 Ra (CRI) 105 66 58.3 40 R1 99 43.2 45 R2 91 70 65.7 R3 85.4 50 83 R4 54.3 R5 53.9 R6 59.5 R7 73.5 R8 31.0 R9-98.6 R10 23.1 R11 41.3 R12 56.0 R13 45.9 R14 88.5 Summary of Results Total Lumen Output Luminaire Efficacy Max. Candela 403.7 lm/ft 52.9 lm/w 10.00 Chromaticity Coordinates 0.00 350 400 450 500 550 600 650 700 750 800 850 Chromaticity (x) 0.2974 5.00 Wavelength (nm) Chromaticity (y) 0.2907 1 Specifications are provided by SIRS-E, and are subject to change without Chromaticity notice. (u) 0.2019 0.00 770-0000XX-XX Chromaticity (v) r 12 0.2960 350 400 450 500 550 600 650 700 750 800 850 Specifications are Chromaticity subject to change (u') without notice 0.2019 Wavelength (nm) Chromaticity (v') 0.4439 Duv -0.0094 CCT 127 Cd 8200K CRI 58.3 Duv -0.0094 TM-30 Rf 0.0 TM-30 Rg 0.0 Electrical Test Conditions 55 74 66 60 64 65 53 52 70 40 75 28 30 80 16 85 6 8 90 1 Color Rendering Index Details Ra (CRI) 58.3 R1 43.2 R2 65.7 R3 85.4 R4 54.3 R5 53.9 R6 59.5 R7 73.5 R8 31.0 R9-98.6 R10 23.1 R11 41.3 R12 56.0 R13 45.9 R14 88.5 Chromaticity Coordinates Chromaticity (x) 0.2974 Chromaticity (y) 0.2907 Chromaticity (u) 0.2907 Chromaticity (v) 0.2960 Chromaticity (u') 0.2019 Chromaticity (v') 0.4439 Duv -0.0094