EJC READY FOR USE FROM THE TRIDENT GROUP TAMROCK EJC WILLIAMS OPERATING SPECIFICATION UNDERGROUND HAUL TRUCK POWERED WITH A DETROIT SERIES ENGINE MILITARY SPECIFICATION WIRING WILLIAMS OPERATING SPECIFICATION WIRE AND HIGH HEAT HOSE PACKAGE WILLIAMS OPERATING SPECIFICATION CHASIS WEAR/STIFFENING PACKAGE TRUCK IS FULLY SERVICED AND READY FOR OPERATION EJC TECHNICAL SPECIFICATION A RUGGED PERFORMER FOR THE TOUGHEST HAULAGE APPLICATIONS CAPACITY: SHORT TONS (7.3 TONNES) 1
Main Dimensions 5o. m (.5 ft.) Note: all dimensions in millimeters. Dimensions in brackets are in inches. All vertical dimensions are for an empty unit and are based on a tire radius of 13 mm (3")
EJC Specification Sheet SANDVIK TAMROCK EJC Loaders Division EJC /1/99 STANDARD UNIT Detroit Diesel Series, hp ( kw) Donaldson dry type air cleaner ECS catalytic exhaust purifier with silencer Clark transmission Clark torque converter Clark axles with "Posi-Stop" brakes 1: R5 Michelin XKA** tires. yd3 (.3 m3) SAE rated dump box Pilot operated stick steering control Pilot operated dump box control Electric transmission controls Central hydraulic pressure test points Electric gauges -volt DC electrical system Central manual lube Back-up alarm, audible SAE type hose fittings Four () parts manuals operator and service manuals BASE UNIT PRICE = no impact on delivery time; = delivery time on request OPTIONAL EQUIPMENT * Caterpillar 3 PCTA, 35 hp ( kw) (altitude application) * Caterpillar 3 PCTA, 7 hp (1 kw) * Deutz F1L-13FW diesel engine, 77 hp (7 kw) * Deutz BF1L-13FWC, 35 hp ( kw)for ft/metres, Temperature * Deutz BFM-ECP, hp ( kw) * Automatic lubrication system (Lincoln Modular) * Torque converter lockup with tach. * 1 yd3 (.7m3) SAE box 11 " (9 mm) wide * 17 yd3 (13.m3) SAE box 11 " (9 mm) wide Split dump box rework SAE ROPS canopy Fire suppression system, Ansul nozzle Ansul fire suppression system, Ansul nozzle (Checkfire II) Hand held fire extinguisher lb Hand held fire extinguisher lb Enclosed operator's cab with A/C (solid mounts) Abrasion resistant box liners (1/"- BHN plate) Emergency steering system (SAE J-11), electric Spare rim & tire, standard (1: R5) Spare rim Additional spare parts manuals Additional workshop manuals (*) Replaces the standard equipment 3
Standard Unit Main dimensions Standard tires Total length 9 55 mm (37") Total width 91 mm (11") Height with safety canopy 7 mm (5") Height of dump box mm (9") Dump Height 5 3 mm (") Tire size Type Air pressure, front Air pressure, rear Weights Full hydraulic power steering, centre articulated with double acting steering cylinder. Open centre system with a gear pump and pilot operated stick steer. Turning radius: Right inner 39 mm (173 ") outer 33 mm (33 ") Turning angle. Main components in steering system: Hydraulic pump Gear pump Control valve Pilot operated Steering cylinder 17 mm bore X mm rod (5." X.5") Pressure settings: Main relief 17. MPa (17 bar) (5 psi) Port relief valves 1. MPa (1 bar) (7 psi) Operating weight 91 kg (53 lb.) Total loaded weight 51 3 kg (113 lb.) Shipping weight 3 kg (5 lb.) Axle weights without load front axle 75 kg (3 5 lb.) rear axle 31 kg (1 35 lb.) Axle weights with load front axle 3 11 kg (5 5 lb.) rear axle 5 kg ( lb.) Capacities Payload 7 73 kg ( lb.) Dump box volume (SAE).7 -.3 m³ (1 -.7 yd³) Dump box motion times Discharging time Dumping angle 17 sec. 5 Driving speeds forward and reverse (Loaded) 1st gear nd gear 3rd gear th gear 5.5 km/h (3. m.p.h.). km/h (. m.p.h.) 17.7 km/h (11. m.p.h.) 3. km/h ( m.p.h.) Frame Rear and front frame Material Central hinge Welded steel box construction G.1-5wt Cat.#3 full plate, clevis type with spherical bearings Standard Engine Diesel engine Output Torque Number of cylinders Displacement Cooling system Combustion principle Air filtration Electric system Exhaust system Detroit Diesel Series kw ( HP) @ RPM 1 Nm (5 ft.lb.) @135 RPM In line 11.1 litres (7 in3) Liquid Cooled Direct injected, turbo charged, after cooled Donaldson, dry type V Catalytic purifier with silencer Torque Converter Clark C1 Single stage, 3.5 torque multiplication ratio,.95:1 offset ratio Transmission Clark 51 -speed forward and reverse Standard axles Front axle Rear axle Clark 19D35, standard differential, oscillating 1 total. Clark 19D35, standard differential, fixed. 1: R5 Michelin XKA** 55 kpa (5.5 bar) ( psi) 55 kpa (5.5 bar) ( psi) Steering hydraulics Dump box hydraulics Full hydraulic open-centre system with two gear pumps. Oil flows to the dump box hydraulic system from the dump box pump and the steering pump when the steering system is not in use. Pilot operated lever dump box control. Main components: Dump cylinders () Commercial -stage telescopic 1/ mm bores (7.5/.") Hydraulic pump Gear pump Control valve Pilot operated Pressure Settings: Main relief 17. MPa (17 bar) (5 psi) Port relief (dump) 17.9 MPa (179 bar) ( psi) Hydraulic oil tank capacityappro. 3 litre (75 gal) Standard brakes Service brakes are spring applied, hydraulically released, liquid cooled (LCB) multi-disc brakes on all wheels. Service brakes also function as an emergency brake, when the emergency brake hand valve is on. Main components in the brake system: Pressure accumulators Piston type with charging valve Brake pedal valve Modulated Electrical equipment Alternator V 7A, min Batteries x 1 V, 95 CCA Starter V, Heavy Duty Driving and working lightspcs front, pcs rear Standard manuals (customer) 3 pcs Spare parts manuals 3 Operators manual 3 Service manual Standard manuals (region) 1 pcs Spare parts manuals 1 Operators manual 1 Service manual
Tractive Effort (Klbf) 5 7 EJC D (Imperial Units) 1 'th 3'rd 'nd 1'st 3 5 7 9 11 13 1 1 17 1 With torque converter lock-up Without torque converter lock-up Speed (mph) 1 TIRES: 1: R5 Payload: lbs AXLES: 19D35 19 1 3 5 FULL LOAD Rolling resistance (% ) EMPTY Grade (%) DET. DIESEL DDEC ENGINE: CONVERTER: CL1 51 TRANS: EJC Speeds On Grade 5
F (kn) 5 5 35 'th 3'rd 'nd 1'st 1 ENGINE: DET. DIESEL DDEC CONVERTER: CL1 51 TRANS: EJC D (Metric Units) 1 1 Speed (km/h) 1 With torque converter lock-up Without torque converter lock-up AXLES:19D35 TIRES: 1: R5 Payload: 7 kg Grade (%) 3 Em pty 3 3 3 Loaded Rolling resistance (% )