GLOBAL LIFT CORP Owner s Manual Rtatinal Series R-375 684 N Prt Crescent Rd Suite C Bad Axe, MI 48413 Tll Free: 866-712-0606 Fax: 989-269-5902 www.glballiftcrp.cm Page 1
ROTATIONAL SERIES POOL LIFTS R-375 TABLE OF CONTENTS INTRODUCTION PAGE 3 ADA GUIDELINES FOR PLACEMENT PAGE 4 24 VOLT BATTERY SYSTEM/WITH CONTROLS PAGE 5 ROTATIONAL SERIES OPERATING INSTRUCTIONS PAGE 6 UNIT MAINTENANCE AND CARE PAGE 7 TROUBLESHOOTING PAGE 8 WARRANTY INFORMATION PAGE 9/10 WARRANTY REGISTRATION PAGE - 11 NEW CONSTRUSTION/SLEEVE CUT INSTALLATION R-375 RETRO FIT INSTALLATION R-375 FIXED ANCHOR INSTALLATION R-375 OUT OF BOX INSTALLATION SEAT INSTALLATION Page 2
INTRODUCTION Yur Number One Chice fr Cmmercial Pl Access Equipment Glbal Lift Crp. is lcated in Mid-Michigan, Glbal Lift Crp. prides itself in manufacturing tp f line quality aquatic access equipment. Glbal Lift Crp's key staff has a century f cmbined industry experience and we take pride in each and every prduct that we build. Our Cmpany is ISO Certified and ur prducts are manufactured in the United States. Glbal Lift Crp uses nly the finest materials and prcesses t prvide ur custmers with the highest quality prducts while still maintaining a price cmpetitive edge. ADA GUIDELINES FOR POOL LIFT PLACEMENT Page 3
1. Pl Lift Lcatin. Pl lifts shall be lcated where the water level des nt exceed 48 inches (1220 mm). 2. Seat Lcatin. In the raised psitin, the centerline f the seat shall be lcated ver the deck and 16 inches (405 mm) minimum frm the edge f the pl. The deck surface between the centerline f the seat and the pl edge shall have a slpe nt steeper than 1:48. 3. Clear Deck Space. On the side f the seat ppsite the water, a clear deck space shall be prvided parallel with the seat. The space shall be 36 inches (915 mm) wide minimum and shall extend frward 48 inches (1220 mm) minimum frm a line lcated 12 inches (305 mm) behind the rear edge f the seat. The clear deck space shall have a slpe nt steeper than 1:48. 4. Submerged Depth. The lift shall be designed s that the seat will submerge t a water depth f 18 inches (455 mm) minimum belw the statinary water level. T make sure the lift has enugh clearance the lift shuld be installed at a lcatin with 48 f Water depth 24 VOLT BATTERY SYSTEMS WITH CONTROLS Page 4
All f Glbal Lift Crp s Rtatinal Series Lifts are equipped with a sealed 24 vlt battery that is rechargeable. Alng with a charging unit, hand held cntrller and cntrl cmpartment. The 24 vlt battery munts right abve the cntrl cmpartment and the battery simply snaps in. The battery shuld be charged fr 5-8 hurs prir t the 1 st use. The unit is perated by the 4 buttn easy t use cntrls. Staff will use the prvided key t unlck the lift. The lck feature is lcated n the hand cntrls r frnt f the cntrl bx. Insert the key prvided and turn t unlck the unit fr use. (Avid turning the key farther than 45 degrees as it will damage the key) Once unlcked, the arrw pinting dwn will lwer the lift when depressed, the arrw that pints up will raise the unit when depressed and the bttm arrws will rtate the lift frm left t right. If yu hear the lw battery indicatr tne D Nt Use the Lift remve the battery frm the unit and recharge the battery. When the unit is nt in use, remve the battery and place it n the charger. The battery shuld never be left n the lift when nt in use. RECHARGING THE BATTERY: Remve battery frm the unit by unclipping frm the cntrl cmpartment. Place the battery in the charging unit. When the battery is charging the light will be illuminated, nce fully charged the charge light will g ff and then the battery is ready fr use in yur Rtatinal Series pl lift. Page 5
ROTATIONAL SERIES POOL LIFT OPERATING INSTRUCTIONS Prir t using the Rtatinal Series Pl Lift, perfrm a test run f the lift empty. Once that is cmpleted and the lift is back t riginal psitin, make sure that the arm lifts are in the up psitin and the seatbelt is unbuckled, nce acknwledged yu are ready! Once yu are in the seat, buckle the seatbelt (make sure it is snug) and lwer the arm rails. Befre yu attempt t perate the lift, make sure the pathway is clear frm any bstacles. Once yu have the 4 buttn easy cntrls in yur hand, press the Left r Right arrw that specifies which directin yu want the lift t mve in, nce ver the water press the dwn arrw t lwer the lift int the pl, keep in mind yu dn t have t g t the bttm f the cycle, yu can stp the lift whenever yu deem cmfrtable t exit the lift. Hwever when exiting the pl while n the lift, yu shuld cmplete the cycle back t the tp t have a cmpletely safe exit frm the pl. Once submerged int the pl, unbuckle the seatbelt and raise the armrest and slide ff f the seat. Once yu are dne with yur pl activity, make sure the seat is lwered sufficiently t allw yu t easily slide back int the chair. Once yu are seated, buckle the seatbelt and make sure that it is snug, lwer the armrest. Next, t raise the lift chair ut f the pl, make sure yu press the buttn/arrw that represents up n the cntrl. Apply cntinuus pressure until the lift cmes t a cmplete stp at the end f the cmplete up cycle and then press the left r right arrw t return t the pl deck. Yu nw can unbuckle the seatbelt and raise the arm rest and exit the unit. Staff will turn the key n the hand cntrl r frnt f the cntrl panel t relck the lift when the pl is nt in peratin. Maintenance Page 6
Regular servicing will help prlng the life f yur lift. Rutine maintenance and cleaning is very imprtant. The fllwing is a rutine maintenance yu shuld fllw. Daily Check and charge battery Test fr nrmal peratins Inspect yur lift Clean the lift and seat Cver and stre lift after use Weekly Overview Daily Checklist Mnthly Inspects all cnnectins, frame, seat etc, Clean battery cnnectins Clean metallic surfaces with a wax cleaner The maintenance prvisin f the ADA states that a public accmmdatin shall maintain in perable wrking cnditin thse features f facilities and equipment that are required t be readily accessible t and usable by persns with disabilities" TROUBLESHOOTING GUIDE Befre any trubleshting cmmences make sure the battery has a full charge! Page 7
(1) Des the lift raise r lwer NO (a) Check the battery cnnectin and recnnect (b) Check hand cntrls, make sure they are cnnected prperly (c) Check fr any lse wires n the cntrl cmpartment (d) Check the cnnectin cable fr damage (e) Check t see that the lck n the hand cntrl is in the unlcked psitin. (2) The batteries will nt charge? Yes (a) Battery nt inserted adequately, re-insert battery and check psitin (b) Check the Display light Alng with the main cable fr gd cntact. (c) Check the main cable fr damage. (d) Subsequent charging can be restarted by briefly discnnecting the main supply r the battery. Glbal Lift Crp Warranty Infrmatin The Cmmercial, Prfrmance, and Rtatinal series lifts have a Lifetime Limited Warranty n the metal cmpnents f the frame, nt including the pwder cating prcess. The Superir series lift has a 5 year structural limited warranty. Glbal Lift Crp warrants t the riginal retail end user nly prducts manufactured by Glbal Lift Crp, when prperly installed in accrdance t the assembly and installatin instructins, and when the equipment is prperly used and maintained, be free frm material defects and wrkmanship as stated belw: Warranty starts frm date f riginal purchase Metal structure (nt including pwder cat) Lifetime Limited (Cmmercial/Prfrmance/Rtatinal Series) Metal structure (nt including pwder cat) 5 year limited structural warranty (Superir Series) Page 8
Actuatr and cntrls 2 years frm date f purchase then 2 years prrated Actuatr and cntrls 3 years 50% cverage (Custmer is respnsible fr 50% f replacement cst Actuatr and cntrls 4 years 30% cverage (Custmer is respnsible fr 70% f replacement cst Battery 1 year frm date f purchase This warranty des nt cver damages t ANY f ur lifts due t accident, abuse, negligence, misuse, damage by imprper use f chemicals, fading, ice damage, fire, rust beynd structural damage( des nt cver csmetic rust), exceeding the weight capacity fr mdel purchased, failure t install r t assemble the prduct in accrdance with the installatin and assembly instructins, nrmal wear and tear frm day t day use, nt maintained prperly, if unit is altered r repaired withut written apprval f Glbal Lift Crp All Warranties are Vid. T cmmence the warranty claim prcess f a Glbal Lift Crp prduct, in writing prvide place f purchase alng with the prduct name and descriptin, date f installatin and a detailed descriptin f the defect, alng with a pht f the entire prduct and claimed defect. Prir t a 30 day perid after receiving the written warranty claim by Glbal Lift Crp and barring any unfreseen delays the claimant will be ntified f Glbal Lift Crp s decisin regarding the claim. If the request made by Glbal Lift Crp fr the prduct t be returned t its factry r distributr f chice fr inspectin and/r repair, purchaser will be liable fr Freight Prepaid. Glbal Lift Crp at its ptin will replace r repair the defective item and deliver the repaired prduct r replacement t the buyer f the prduct, freight prepaid by the purchaser t the destinatin n file in regards t the riginal rder. Parts and Prducts returned fr replacement t Glbal Lift Crp shall remain the prperty f Glbal Lift Crp under this limited warranty. A new warranty perid shall nt be established fr any repaired r replaced prducts. Replaced r repaired prducts will remain under warranty nly fr the remainder f the riginal warranty perid fr the riginal prduct purchased. N persn r rganizatin is authrized t make any ther specific r implied warranties n behalf f Glbal Lift Crp. Page 9
THE WARRANTIES ARE IN LIEU OF ALL OTHER WARRANTIES, EXPRESSED OR IMPLIED, WHICH ARE HEREBY DISCLAIMED AND EXCLUDED, INCLUDING WITHOUT LIMITATION ANY WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE OR USE. IN NO EVENT SHALL GLOBAL LIFT CORP BE LIABLE FOR ANY INCIDENTAL, CONSEQUENCIAL, INDIRECT, SPECIAL EXEMPLARY OR PUNITIVE DAMAGES OR LOST PROFITS FROM ANY BREACH OF THIS LIMITED WARRANTY.THE SOLE AND EXCLUSIVE REMEDY OF THIS WARRANTY IN REGARDS TO GLOBAL LIFT CORP S PRODUCT SHALL BE LIMITED TO REPLACEMENT OR REPAIR AT A GLOBAL LIFT CORP S FACILITY OR A DULY APPOINTED DISTRIBUTOR S LOCATION OR AT A GLOBAL LIFT CORP S DESIGNATED LOCATION. IN NO EVENT SHALL GLOBAL LIFT CORP LIABILITY EXCEED THE ENTIRE AMOUNT PAID TO GLOBAL LIFT CORP BY THE ORIGINAL PURCHASER IN REGARDS TO THE DEFECTIVE OR FAILED PRODUCT. NO REPRESENTATIVE OF GLOBAL LIFT CORP SUCH AS AGENTS, DISTRIBUTORS AND DEALERS HAS THE AUTHORITY TO ALTER IN ANY FASHION THE TERMS OF THIS WARRANTY AND GLOBAL LIFT CORP IS NOT RESPONSIBLE FOR REPRESENTATION, UNDERTAKING OR WARRANTY MADE BY ANY OTHER PERSON BEYOND THE WARRANTIES EXPRESSED SET FORTH IN THIS WARRANTY. Warranty Prcedure Warranty Claims shall be submitted t Glbal Lift Crpratin by the distributr which riginated the sale with Glbal Lift Crpratin. All RGA (Return Gds Authrizatin) dcuments shall be requested by and issued nly t the distributr which riginated the sale. Glbal Lift Crpratin shall determine warranty cverage validatin and replacement parts r repair shall be directed t the distributr which riginated the sale. Warranty claims received frm end users by Glbal Lift Crpratin shall be re-directed t the distributr which riginated the sale with Glbal Lift Crpratin. Page 10
GLOBAL LIFT CORP WARRANTY REGISTRATION PURCHASED BY: Cmpany Name: Cntact: City: State: Zip: Phne: ( ) DEALER: Name: Phne Number City: State: Zip: Phne: ( ) Mdel: Serial Number: Clr: Purchase Price: $ Date Purchased: I have read and I accept the warranty terms. Signature: Date: This card must be cmpleted and returned t Glbal Lift Crp within 30 days f purchase date t assure cverage. Please mail t: Glbal Lift Crp, 684 N Prt Crescent Suite C, Bad Axe, MI 48413 Page 11