Owner s Manual 21 Gas Powered Lawn Mower Item# PU850 Model# SP-PM137GMC WARNING! To Reduce The Risk Of Injury, User Must Read And Understand Instruction Manual. 12/2012
Introduction This rotary-blade, walk-behind lawn mower is intended to be used by residential homeowners or professional, hired operators. It is designed primarily for cutting grass on well -maintained lawns on residential or commercial properties. It is not designed for cutting brush or for agricultural uses. Read this information carefully to learn how to operate and maintain your product properly and to avoid injury and product damage. You are responsible for operating the product properly and safely. You may contact ALL-POWER directly at 888-896-6881 for product and accessory information, help finding a dealer, or to register your product.this manual indentifies potential hazards and has safety messages indentifies by the safety alert symbol (Figure 1), which signals a hazard that may cause serious injury or death if you do not follow the recommended precautions. Figure 1 1. Safety alert symbol This manual uses two words to highlight information.important calls attention to special mechanical information and Note emphasizes general information worthy of special attention. Warning CALIFORNIA Proposition 65 Warning The engine exhaust from this product contains chemicals known to the State of California to cause cancer, birth defects, or other reproductive harm. Important:This engine is not equipped with a spark arrester muffler. It is a violation of California Public Resource Code Section 4442 to use or operate the engine on any forest covered, brush-covered, or grass-covered land. Other states or federal areas may have similar laws. The enclosed Engine Owner s Manual is supplied for information regarding the US Environmental Protection Agency (EPA) and the California Emission Control Regulation of emission systems,maintenance, and warranty. Replacements may be ordered through the engine manufacturer. For models with stated engine horsepower, the gross horsepower of the engine was laboratory rated by the engine manufacturer in accordance with SAEJ1940.As Configured to meet safety, emission, and operating requirements, the actual engine horsepower on this class of lawn mower will be significantly lower. Do not tamper with the engine controls or alter the governor speed; doing so may create an unsafe condition resulting in personal injury. Safety This lawn mower meets or exceeds the CPSC blade safety requirements for walk-behind rotary lawn mowers and the B71.1 of the American National Standards Institute in effect at the time of production. Read and understand the contents of this manual before you start the engine. The safety alert symbol (Figure 1) is used to alert you to potential personal injury hazards. Obey all safety messages that follow this symbol to avoid possible injury or death. Improperly using or maintaining this mower could result in injury or death. To reduce this potential, comply with the following safety instructions. The following instructions have been adapted from the ANSI/OPEI standard B71.1-2003. This cutting machine is capable of amputating hands and feet and of throwing objects. Failure to observe the following safety instructions could result in serious injury or death. General Operation machine and in the manual(s) before starting. Keep clear of the discharge opening at all times. instructions, to operate this machine. which could be thrown by the blade. Stay behind the handle when the engine is running. Stop machine if anyone enters the area. sandals. Always wear substantial footwear. ssary. Always look down and behind before and while moving backward. discharging material against a wall or obstruction. Material may ricochet back toward the operator. Stop the blade when crossing gravel surfaces. discharge guard, rear guard, or other safety protective devices in place and working. complete stop before cleaning the machine, removing grass catcher, or unclogging the discharge guard. 1
ALL-POWER
Height adjustment: Single lever 5 position height adjustment. From.8 to 2.8. Pull lever to desired height to mow the grass. see (Figure 7): Deflector Installation: see (Figure 8) Note: The product has two functions for grass-cutting: cut the grass and discharge it through the deflector; cut and chop the grass, then mulch the ground with the chopped grass. If the mulching function is not required, the deflector should be mounted on the base component (see Figure 8). The deflector should point to the direction of the mowed lawn, in order to keep the discharging smooth during the mowing process. When mowing high and dense grass, the operator should often observe the discharging effect, and stop or slow down the moving speed if poor discharging is found, should not proceed until the high-speed air flow blows all cut grass away. If the deflector is completely blocked, the engine should be turned off right away and the discharging door needs to be cleared up. If the mulching function is required, the deflector should be removed from the base component and the discharging door should be covered to achieve the mulching purpose (see Figure 8). The engine must be off when operating.
(Not Included) Steele
PARTS LIST PART # KEY # DESCRIPTION DJXZ46H.2.2-1 1 THROTTLE CONTROL BAR DJXZ46H.2.1-1 2 UPPER HANDLE GB/T6189-86 3 HEX HEAD FLANGE NUT (M6) DJXZ46H.2.1-8 4 ADJUSTING KNOB DJXZ46H.2.1-7 5 NON-STANDARD BOLT (M8X45) DJXZ46H.2.1-2 6 LOWER HANDLE GB/T6187-86 7 HEX HEAD FLANGE NUT (M8) GB14 8 CARRIAGE BOLT (M8X15) JDXS51C.2.6-2 9 RIGHT HANDLE BRACKET JDXS51C.2.2-2 10 BRAKE CABLE GB/T5789-86 11 HEX HEAD FLANGE BOLT (M6X35) JDXZ46H.2.1-9 12 HANDLE SHEATH GB/T5789-86 13 HEX HEAD FLANGE BOLT (M8X15) JDXZ46H.2.6-1 14 LEFT HANDLE BRACKET GB/T6178-86 15 HEX HEAD FLANGE NUT (M8) GB/T14 16 PHILLIP SCREW (M5X12) JDXS51C.4.2-2 17 MUDFLAP GB/T97.2-85 18 FLAT WASHER (5X1X15) GB/T6189-86 19 NUT (M5) GB/T5789-86 20 HEX HEAD FLANGE BOLT (M6X12) JDXS51CB.4.1-3 21 SIDE DISCHARGER BRACKET GB/T6189-86 22 HEX HEAD FLANGE NUT (M6) JDXS51C.1 23 BASE COMPONENT JDXS51CB.2.5-8 24 TENSION SPRING JDXS51CB.2.5-6 25 LINKAGE JDXZ46H.3.1-2 26 REAR AXLE RETAINER GB/T5789-86 27 HEX HEAD FLANGE BOLT (M6X20) JDXS51C.2.5-5 28 HEIGHT ADJUSTING PLATE GB/T6189-86 29 HEX HEAD FLANGE NUT (M6) JDXZ46H.3.1-3 30 AXLE CLAMP GB/T97.2-85 31 FLAT WASHER (M8) GB/T94 32 LOCK WASHER (M8) GB/T5783-86 33 HEX HEAD BOLT (M8X30) JDXS46C.3.1-2 34 FRONT AXLE RETAINER JDXS51CB.3.4-1 35 REAR WHEEL (12") GB/T5789-86 36 HEX HEAD BOLT (M5X12) JDXS51CB.3.2-1 37 REAR AXLE ASSEMBLY GB/T6189-86 38 HEX HEAD FLANGE NUT (M5) JDXS51C.2.5 39 ADJUSTING LEVER JDXZ46H.2.7-1 40 HAND GRIP JDXS51CB.4.1-5 41 DEFLECTOR JDXS51CB.4.1-1 42 DISCHARGING DOOR COVER JDXS51CB.4.1-2 43 DISCHARGING DOOR COVER SHAFT JDXS51CB.4.1-4 44 TORSION SPRING JDXS46H.5.3 45 FLAT KEY JDXS51CB.3.1-1 46 FRONT AXLE ASSEMBLY GB/T91 47 COTTER PIN JDXS51CB.3.3-1 48 FRONT WHEEL (7") GB/T6189-86 49 NUT (M8) JDXZ46H.5.2 50 BLADE MOUNT JDXZ46H.5.3-2 51 GROMMET WASHER JDXS51C.5.3-1 52 HEX HEAD BOLT (3/8X24X35) JDXS51C.5.1 53 BLADE JD1P64 54 ENGINE ASSEMBLY
LIMITED WARRANTY All-Power warrants to the original purchaser who uses the product in a consumer application (personal, residential or household usage) that all products covered under this warranty are free from defects in material and workmanship for 2 years (1 Year parts and labor 2nd year parts only) from the date of purchase. All products covered by this limited warranty which are used in commercial applications (i.e. income producing) are warranted to be free of defects in material and workmanship for 90 days from the date of original purchase. Products covered under this warranty include air compressors, air tools, service parts, pressure washers and generators. All-Power will repair or replace at their sole option, products or components which have failed within the warranty period. Service will be scheduled according to the normal work flow and business hours at the service center location, and the availability of replacement parts. All decisions of All-Power with regard to this limited warranty shall be final. This warranty gives you specific legal rights, and you may also have other rights which vary from state to state. RESPONSIBILITY OF ORIGINAL PURCHASER (Initial User): To process a warranty claim on this product, DO NOT return item to the retailer. The product must be evaluated by an Authorized Warranty Service Center. For the location of the nearest Authorized Warranty Service Center contact the retailer or place of purchase. Retain original cash register sales receipt as proof of purchase for warranty work. Use reasonable care in the operation and maintenance of the product as described in the Owner s Manual(s). Deliver or ship the product to the nearest Authorized Warranty Service Center. Freight costs, if any, must be paid by the purchaser. Air compressors with 60 and 80 gallon tanks will be inspected at the site of installation. Contact the nearest Authorized Warranty Service Center that provides on-site service calls for service call arrangements. 13
LIMITED WARRANTY (cont d) THIS WARRANTY DOES NOT COVER: Merchandise sold as reconditioned, used as rental equipment, or floor or display models. Merchandise that has become damaged or inoperative because of ordinary wear, misuse, cold, heat, rain, excessive humidity, freeze damage, use of improper chemicals, negligence, accident, failure to operate the product in accordance with the instructions provided in the Owner s Manual(s) supplied with the product, improper maintenance, the use of accessories or attachments not recommended, or unauthorized repair or alterations. Repair and transportation costs of merchandise determined not to be defective. Costs associated with assembly, required oil, adjustments or other installation and start-up costs. Expendable parts or accessories supplied with the product which are expected to become inoperative or unusable after a reasonable period of use. Merchandise which has been manufactured by and identified as the product of another company, such as gasoline engines. The product manufacturer's warranty, if any, will apply. ANY INCIDENTAL, INDIRECT OR CONSEQUENTIAL LOSS, DAMAGE, OR EXPENSE THAT MAY RESULT FROM ANY DEFECTS, FAILURE OR MALFUNCTION OF THE PRODUCT IS NOT COVERED BY THIS WARRANTY. Some states do not allow the exclusion, so it may not apply to you. IMPLIED WARRANTIES, INCLUDING THOSE OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE, ARE LIMITED TO TWO YEARS FROM THE DATE OF ORIGINAL PURCHASE. Some states do not allow limitations on how long an implied warranty lasts, so the above limitations may not apply. STOP DO NOT RETURN TO STORE For Technical Assistance Please Call 888-896-6881 14